Yes | CGS995SELSS | LP Conversion Kit | Yes CGS995SELSS LP Conversion Kit

Yes CGS995SELSS LP Conversion Kit
PROPANE (LP) CONVERSION INSTRUCTIONS
WARNING
Explosion Hazard
Death or serious injury can result from failure to follow
these instructions.
• Service by a qualified service technician only.
• Shut off gas supply and disconnect power before servicing.
• Reconnect all grounding devices after service.
• Replace all parts and panels before operating.
CONVERTING THE PRESSURE REGULATOR
A. If this is your regulator:
&RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRႇWKH
threaded metal cap.
7KHSURSDQH /3 RUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHG
on the back of the range in the location shown.
Rear of Range
PROPANE
Cap assembly
Regulator style A
3. Turn the metal cap so the type of gas being converted to
is displayed and replace the protective plastic cover.
4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
B. If this is your regulator:
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
2. Turn the plastic cap 1/4 turn to disassemble.
Pressure
Regulator
Location
NAT
Propane
2UL¿FHORFDWHG
through this
opening
• Adjustable wrench
• Socket wrench with
1/2” socket and extension
• Phillips head screwdriver
• Flat bladed screwdriver
(blade approximately
3/32” across)
• Nut drivers: 1/4”, 9/32”
or 7mm
To adjust your range for use with propane (LP) gas, follow
these instructions:
3. Turn the plastic cap over and hook it into the slots.
Rotate cap 1/4 turn to reassemble. The type of gas to be
used should now be visible on the top of the cap.
4. Screw the hex-nut cap back onto the pressure regulator.
CR
RR
LF
CF
RF
Base
Propane
None
Round burner
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
&5HPRYHWKHSURSDQH /3 RUL¿FHVIURPWKHER[SURYLGHG
7KHSURSDQH /3 RUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS
To aid in identifying the proper location for the propane (LP)
RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH /3 Gas, color codes have been added to the side or top of the
RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD
series of engraved marks (I, II, III . . .) located on the top.
95
LF1
LF2
Propane
None
Propane
Orange/Silver
LFC
B. Using a 7 mm or 9/32” nut driver, remove the top burner
RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU
opening in the base.
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
BURNER OUTPUT RATINGS: BTU/HR
Propane (LP) Gas 10” W.C.P.
BTU
ORIFICE
RATE
SIZE
(mm)
COLOR
MARKING
BURNER
Regulator style B
LR
Burner head
III
TOOLS REQUIRED:
Propane
Blue/Magenta
Orange/Light Blue
Multi-ring
PROPANE
Propane (LP)
Conversion Kit
Propane
Orange/Light Blue
Burner cap
Base
Rotate cap counterclockwise to loosen.
Propane
Red/Yellow
Burner cap
NAT
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU
natural gas. To use propane (LP) gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
burners of this range when using propane (LP) (bottled) gas
EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV
for propane (LP) gas use. Failure to do so could cause high
ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
Burner cap
Burner head
Rotate cap counterclockwise to loosen
WARNING Do not operate the cooktop or oven
',QVWDOOWKHSURSDQH /3 RUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
A. Remove the top grates, burner caps and burner heads.
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
CONVERTING THE COOKTOP BURNERS
LF
18,000
LF1
N/A
0.027
None
69L
LF2
N/A
0.027
None
69L
Propane
None
LF3
Propane
None
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\
screwed into the gas supply tubes.
(,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW
along with these instructions, and replace onto the back of the
range for possible future conversion.
CHECK SURFACE BURNERS
3XVKDQGWXUQDNQREWRWKH/,7(SRVLWLRQ$FOLFNLQJVRXQG
indicates proper operation of the ignition system. When lighting
DQ\EXUQHUVSDUNVZLOODSSHDUDWDOOEXUQHUVEXWJDVÀRZV
from only the one selected. Once air is purged from the supply
line, burner should light within 4 seconds. After burner lights,
URWDWHWKHNQRERXWRIWKH/,7(SRVLWLRQ7U\HDFKEXUQHULQ
succession until all burners have been checked.
Quality of Flames
'HWHUPLQHWKHTXDOLW\RIÀDPHVYLVXDOO\1RUPDOEXUQHUÀDPHV
should look like (A) or (B).
(A) Soft blue flames—
Normal for natural gas
LF3
N/A
0.027
None
69L
LFC
N/A
0.016
None
40L
(B) Yellow tips on
outer cones—
LR
5,000
0.026
Red/Yellow
66L
Normal for propane (LP) gas
CF
9,500
0.0365
Orange/Light Blue
92L
1. Disconnect all electrical power, at the main circuit breaker or
fuse box.
CR
9,500
0.0365
Orange/Light Blue
92L
RF
15,000
0.045
Orange/Silver
114L
6KXWRႇWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDO
VKXWRႇYDOYH
RR
12,000
0.039
Blue/Magenta
99L
Upper Bake
7,000
0.031
Brown
031L
Broil
13,500
0.042
Grey
042L
Lower Bake
13,500
0.043
Green
043L
/RQJEULJKW\HOORZÀDPHVDUHQRWQRUPDO1RUPDOÀDPHVPD\
show signs of an orange tint when well heated or signs of
ÀLFNHULQJRUDQJHGXHWRSDUWLFOHVLQWKHJDVRUDLU
PROPANE (LP) CONVERSION INSTRUCTIONS
31-11086-1 05-18 GEA
CGS995 add CGS750P
CONVERTING THE OVEN BURNERS
ADJUSTING AIR SHUTTER SETTINGS
FOR OVEN BURNERS
NOTICE:
This product cannot be converted to propane (LP) by
DGMXVWLQJWKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHG
for propane (LP).
UPPER AND LOWER OVEN BAKE BURNER
ORIFICES
1. Remove the lower oven door from the unit
5
HPRYHRYHQUDFNVRYHQERWWRPVDQGÀDPHVSUHDGHUV
from both ovens. In the lower oven, remove the enclosure
around the rear of the bake burner held in place by three
Phillips screws.
3. Remove all 1/4” hex
screws securing the bake
burners. Gently slide
each bake burner to the
left to remove it from the
RUL¿FHDQGDOORZEXUQHUV
to rest on the bottom of
their respective ovens.
BURNER
Lower Oven
Broil Burner
Upper Oven
Bake Burner
Lower Oven
Bake Burner
AIR SHUTTER SETTING
AIR SHUTTER
FOR PROPANE (LP)
SETTING FOR NG
0.690
0.690
0.750
0.750
Full Open
Full Open
Phillips Screw
Air shutter
:
LWKD´ZUHQFKORRVHQHDFKRUL¿FHE\WXUQLQJFRXQWHU
clockwise and remove.
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
6
HOHFWWKHDSSURSULDWHEDNHRUL¿FHIRUHDFKRYHQIURPWKH
NLWDQGLQVWDOORQWKHWKUHDGHG¿WWLQJV7LJKWHQZLWKZUHQFK
until snug.
*
HQWO\UHSODFHWKHEDNHEXUQHUVRYHUWKHLUUHVSHFWLYHRUL¿FHV
and replace all 1/4” hex screws securing the burners.
BROIL BURNER ORIFICE
1. Remove the 1/4” hex
screw securing the
broil burner and allow
it to hang down free of
WKHEURLORUL¿FH
The air shutters should be turned to the marked settings NG or
propane (LP) or set according to the following table.
Broil
2UL¿FH
Air Shutter
Setting
With a Phillips head screwdriver, loosen the screws securing
the air shutters on the burners and adjust the air shutters
according to chart above.
%DNHDQGEURLOÀDPHVPXVWEHFKHFNHGZLWKWKHRYHQ
GRRUVFORVHGWRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
1. Turn on the gas.
2. Turn on the electricity.
3. Reinstall the lower oven door. Close both doors.
4. Turn on both bake burners.
5. For each burner, observe the following through the oven
door windows.
D,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH
E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly, but not by more than 1/8”.
7XUQEDNHEXUQHURႇDQGUHSHDWZLWKEURLOEXUQHU
Oven
Light
2. Apply a 1/2” wrench
to the hex base of the
RUL¿FH/RRVHQWKH
RUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
WARNING If you attempt to measure the inner cone
RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG
WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
&KHFNLQJWKHÀDPHVL]H
It should be approximately
1/2” to 3/4” long for the bake
NOTICE:
and broil burners.
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
The combustion quality of
WKHEXUQHUÀDPHVQHHGVWR
6
HOHFWWKHSURSDQH /3 EURLORUL¿FHIURPWKHNLWDQGLQVWDOOLW
be determined visually.
on the broil elbow. Tighten until snug.
5
HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH
screw securing the burner.
127(,IEXUQHUÀDPHVORRNOLNH $ IXUWKHUDLUVKXWWHU
adjustment to the bake buner is required. Normal
EXUQHUÀDPHVVKRXOGORRNOLNH % RU & GHSHQGLQJRQ
the type of gas you use. With propane (LP) gas, some
yellow tipping on the outer cones is normal.
F. Replace the knob.
Adjustment screw for outer ring
Adjustment screw
for center ring
(A) Yellow flames:
Further Adjustment
Required
(B) Yellow tips on
outer cones:
Normal for Propane (LP) Gas
(C) Soft blue flames:
Normal for Natural Gas
)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW
¿UVWEXWWKLVZLOOVRRQGLVDSSHDU
8. Retighten the air shutter screws.
9. When all adjustments are made and the results are
satisfactory:
a. Replace the enclosure around the rear of the bake
burner in the lower oven.
E5HSODFHWKHÀDPHVSUHDGHUV
c. Replace the oven bottoms and oven racks.
ADJUSTING LOW FLAME SETTING
ON COOKTOP BURNERS
Low setting adjustments must be made with other burners in
operation on a medium setting. This procedure prevents the
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
into the valve shaft and/or side adjustment screw(s) as
shown and turn clockwise to fully tighten down the bypass
screw(s). Repeat for all valves.
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ
FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU
Remember, other burners must be turned on to medium.
SPECIALTY BURNERS
Burner Cap
Multi-Ring Burner – The outer ring
Flames
RIÀDPHVVKRXOGEHDGMXVWHGZLWKWKH
NQREDWWKH0('E\DGMXVWLQJWKHVHW
screw in the center valve shaft. The
ÀDPHVVKRXOGEHDGMXVWHGVRWKDWWKH\
barely curl over the top edge of the
EXUQHUFDS7KHFHQWHUULQJRIÀDPHV
should be adjusted with the knob at the
LO setting by adjusting the set screw to
the right of the valve shaft.
( $GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ
DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV
extinguished, continue adjusting bypass screw for a larger
ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH
Center adjustment screw
only for all other burners.
Adjustment screws for
multi-ring burner only
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the
instructions given in making propane (LP) adjustments.
NOTICE:
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXWWKH
SURSDQH /3 VWLFNHUDQGLQFOXGH\RXUQDPHRUJDQL]DWLRQ
and date conversion was made. Apply the sticker to the
range near the regulator to alert others in the future that
this appliance has been converted to propane (LP). If
converting back to natural gas from propane (LP), please
remove the sticker so others know the appliance is set to
use natural gas.
ADDITIONAL INFORMATION
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5” W.C.P.
BTU
ORIFICE
COLOR
MARKING
BURNER RATE SIZE (mm)
LF
21,000
LF1
N/A
0.045
None
114N
LF2
N/A
0.045
None
114N
LF3
N/A
0.045
None
114N
LFC
N/A
0.025
None
63N
LR
5,000
0.040
White/Purple
101N
CF
9,500
0.0555
Yellow
141N
CR
9,500
0.0555
Yellow
141N
RF
15,000
0.070
Brown
178N
RR
12,000
0.061
Red
155N
Upper Bake
7,000
0.046
Yellow
046N
Broil
16,500
0.071
Black/Blue
071N
Lower Bake
14,000
0.066
Red
066N
198
N
Denotes 1.98mm Orifice size opening
Denotes Natural Gas
III
PROPANE (LP) CONVERSION INSTRUCTIONS
31-11086-1 05-18 GEA
CGS995 add CGS750P
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising