Frigidaire | FGTR1837TE | Service Sheet Guide | Frigidaire FGTR1837TE Service Sheet Guide

SERVICE DATA SHEET
PERFORMANCE DATA NO LOAD & NO DOOR
OPENINGS AT MID-POINT CONTROL SETTING
Capacitor Run or Induction Run
A06813801
65°F (18°C) Ambient
Operating Time
STANDARD - AUTOMATIC DEFROST
TOP MOUNT FREEZER - R134a
25 to 35%
Freezer Temperature
2° to 8°F (-17° to -13°C)
Refrigerator Temperature
35° to 40°F (2° to 4°C)
Low Side Pressure (cut-in)
8 to 16 psig ( 55 to 110 kPa)
Low Side Pressure (cut-out)
High Side Pressure (last 1/3 cycle)
1 to 4 psig (7 to 28 kPa)
110 to 120 psig (758 to 827 kPa)
Wattage (last 1/3 cycle)
95 to 140
Amps (running)
0.9 to 1.3
Base Voltage
115 vac (127 vac max)
DEFROST SPECIFICATIONS
IMPORTANT
ICE MAKER INFORMATION
IMPORTANT SAFETY NOTE
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make repairs
due to the possibility of electrical shock. Disconnect power cord before
servicing this appliance.
IMPORTANT
If any green grounding wires are removed during servicing, they must
be returned to their original position and properly secured.
Thermostat
Cut-out
Ohms
18’, 20’ & 21’
9°F (-2°C)
50°F (10°C)
35
15’ & 16’
29°F (-2°C)
50°F (10°C)
41
Mechanical Timer - Defrost 24 minutes every 10 hours of compressor
run time.
Electronic Timer (ADC) - Defrost up to 24 minutes every 6-72 hours of
compressor run time.
CONDENSER FAN MOTOR
Watts
RPM
2.3
1100 CW Opposite Shaft
ICE MAKER SPECIFICATIONS
Electrical
Thermostat
115 vac (127
vac max)
60 Hertz
Ice maker with
black housing
Opens at 52°F
(11°C)
Closes at 12°F
(-11°C)
Ice maker with
white housing
Opens at 48°F
(8.9°C)
Closes at 9°F
(-12.8°C)
Heater Wattage
NOTE
Some products come equipped with an Electronic Defrost Control. To
initiate defrost, depress the fresh food light switch 5 times in 6 seconds
(light bulb must be working). To terminate defrost, depress the fresh
food light switch 5 times in 6 seconds.
CAUTION
All electrical parts and wiring must be shielded from torch flame.
DO NOT allow torch to touch insulation; it will char at 200°F
and flash ignite (burn) at 500°F. Excessive heat will distort the
plastic liner.
BLUE
165 W
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number
Wire Color
1
Green / Yellow
2
Yellow
3
Black
4
Light Blue
BLUE
BLUE
YELLOW
YELLOW
DK. BLUE
Cut-in
BLUE
Cabinet Size
PLEASE RETURN THIS SHEET TO ITS
ORIGINAL LOCATION.
Test Cycling: Remove cover by inserting screwdriver in notch at
bottom and prying cover from housing. Use screwdriver to rotate
motor gear counterclockwise until holding switch circuit is completed. All components of ice maker should function to complete
the cycle.
Water Fill Volume:
The water fill adjustment
screw will change the
fill time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 102 to
130cc (3.4 to 4.3 oz.).
When a water valve is
replaced, the fill volume
must be checked.
DEFROST
THERMOSTAT
WVC
TYCO 520935-4
CC
MOLEX 43335-2002
COMPRESSOR
LT.BLUE
LT.BLUE
RED
RED
PIN 2
BLACK
RED
BROWN
PIN 6
PIN 1
PIN 9
BROWN
PIN 2
BROWN
PIN 3
LT.BLUE
YELLOW
PIN 4
YELLOW
BLUE
PIN 5
BLUE
BLUE
YELLOW
BLACK
BROWN
LT.BLUE
RED
RED/WHITE
BROWN
GREEN/YELLOW
GREEN/YELLOW
BLUE
BLACK
RED
LT. BLUE
LT. BLUE
BLACK
PIN 5
YELLOW
PIN 6
YELLOW/RED
ORANGE
RED
PIN 9
RED
GREEN/YELLOW
LT. BLUE
RED/WHITE
RED
MC1
6 PIN CONNECTION LEFT OF COMPRESSOR
IN MACHINE COMPARTMENT
MC2
9 PIN CONNECTION RIGHT OF COMPRESSOR
IN MACHINE COMPARTMENT
FF1
9 PIN CONNECTION IN FRESH FOOD
CC
BLUE
BLUE
BROWN
YELLOW/BLACK
BROWN
YELLOW/BLACK
PIN 7
PIN 3
PIN 4
BLUE
BROWN
LT.BLUE
BLACK
BLUE
3 PIN CONNECTION TO CONDENSER FAN
WVC
2 PIN CONNECTION TO ICE MAKER WATER
VALVE (GREEN)
IMC
ICE MAKER CONNECTION IN FREEZER
FZ1
6 PIN CONNECTION IN FREEZER
EFC
EVAPORATOR FAN CONNECTION IN FREEZER
DH1
DEFROST HEATER CONNECTION IN FRZ LEFT
OF EVAP FAN
DH2
DEFROST HEATER CONNECTION IN FRZ RIGHT
OF EVAP FAN
BLUE
BLUE
PIN 2
EVAPORATOR
FAN
EFC
DEFROST HEATER
PIN 1
DH2
BROWN
PIN 1
YELLOW/BLACK
DH1
FF1
FREEZER LIGHT
YELLOW/RED
BLACK
FRESH FOOD
DOOR
SWITCH
PIN 3
BLUE
BROWN
BROWN
2 PIN CONNECTION TO COMPRESSOR
CFC
PIN 1
DEFROST THERMOSTAT
LT.BLUE
INLINE CONNECTOR ABBREVIATION KEY
ABBREVIATION
EXPLANATION
COIL COVER GROUND
GREEN/YELLOW
GREEN/YELLOW
BLUE
PIN 5
BROWN
GREEN/YELLOW
BLACK
GREEN/YELLOW
IMC
GREEN/YELLOW
GREEN/YELLOW
WVC
ICE MAKER
PIN 1
GREEN/YELLOW
COND FAN
CFC
PIN 2
PIN 3
LT. BLUE
GREEN/YELLOW
FZ1
MC2
COMP
WATER
VALVE
(ICE MAKER)
PIN 4
RED/WHITE
LT. BLUE
PIN 4
BLACK
GREEN/YELLOW
PIN 3
GREEN/YELLOW
PIN 2
LT. BLUE
LT. BLUE
LT. BLUE
DEFROST
TIMER
LT.BLUE
YELLOW/RED
CTRL(3)
COMP/EVAP FAN(2)
DEF HTR(4)
NEUTRAL (1)
PIN 1
BROWN
ORANGE
RED
BLACK
RED
CC
PIN 2
FREEZER COMPARTMENT
LT. BLUE
ORANGE
MC1
PIN 1
WVC
YELLOW
RED
LT.BLUE
LT.BLUE
LT.BLUE
LT.BLUE
GND
YELLOW/BLACK
LIVE
YELLOW
YELLOW
LT.BLUE
FRESH FOOD
LIGHT
BLACK
CTRL
BLACK
LT. BLUE
LT.BLUE
BLUE
ORANGE
CFC
MC1
BLACK
COLD
CONTROL
CONDENSER
FAN
BLACK
BLACK PIN 6
BACK VIEW
PIN 1
LT. BLUE
RED
RED/WHITE PIN 1
LT.BLUE
PIN 3
LT. BLUE
RED
LT.BLUE
PIN 2
RED
MC2
RED
PIN 6
GREEN/YELLOW
GREEN/YELLOW
LT.BLUE
LT.BLUE
RED
GREEN/YELLOW
BLUE
BLACK
LT.BLUE
GROUND TO
COMPRESSOR BASE
RED
GREEN/
YELLOW
PIN 8
BLUE
SPLICE
RED
PIN 7
PIN 1
CC
SPLICE
PIN 4 RED
GREEN/YELLOW
PIN 2
LT. BLUE
PIN 2
LT.BLUE
PIN 3
BROWN
BLACK
FRONT VIEW
BLACK
GREEN/YELLOW
BLACK
RED
LT. BLUE
GREEN/YELLOW
BLACK
FRESH FOOD
DOOR SWITCH
LT. BLUE
LT. BLUE
FRESH FOOD COMPARTMENT
FACTORY
USE
ONLY
GROUND
GROUND TO
CABINET
1
FF1
CONTROL BOX
NEUTRAL (RIBBED)
GREEN/YELLOW
1
DH1/DH2
MOLEX 19-09-2019
MOLEX 19-09-1019
DH2
EVAP FAN
LIVE (NON RIBBED)
LT. BLUE
BLACK
DH1
1
BLACK
1
1
LT. BLUE
FREEZER DOOR
SWITCH
EFC
MACHINE COMPARTMENT
MC1/FZ1
TYCO 1-480704-0
1
1
1
1
TYCO 1-480705-0
BLUE
FZ1
EFC/CFC
TYCO 1-480701-0 TYCO 1-480700-0
IMC
TYCO 1-480703-0
TYCO 1-480702-0
BROWN
I
M
C
MC2/FF1
JST VLP-09
GREEN/YELLOW
JST VLR-09
FREEZER
DOOR
SWITCH
LT. BLUE
YELLOW/RED
LT. BLUE
YELLOW/RED
YELLOW/BLACK
BLACK
OPTIONAL FREEZER DOOR
SWITCH AND FREEZER LIGHT
Wiring Diagram A06001401
Download PDF

advertising