Summit | SCR7012DB | manual | Summit SCR7012DB Manual

BEVERAGE MERCHANDISERS
Instruction Manual
Model SCR700
(sliding doors)
Model SCR7012D
(swing-out doors)
BEFORE USE, PLEASE READ AND FOLLOW ALL SAFETY RULES AND OPERATING INSTRUCTIONS.
Write Model and Serial Numbers (on
back of unit) here:
________________________________
Felix Storch, Inc.
770 Garrison Avenue
Bronx, NY 10474
www.summitappliance.com
TABLE OF CONTENTS
Appliance Safety
3
Important Safeguards
3-4
Installation Instructions
5-6
Before Using Your Appliance
5
Installation of Your Appliance
5
Electrical Connection
5-6
Extension Cord
6
Operating Your Appliance
6-7
Turning the Unit On and Off
6
Setting the Temperature Control
6
Defrosting
6
Shelf Height Adjustment
7
Placing Items in the Unit
7
Interior Light
7
Self-Closing Doors
7
Door Lock
7
For Most Efficient Use
7
Care and Maintenance
8
Cleaning Your Beverage Merchandiser
8
Power Failure
8
Vacation Time
8
Moving Your Appliance
8
Temporary Storage
8
Troubleshooting
9
Limited Warranty
10
2
APPLIANCE SAFETY
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read
and obey all safety messages.
This is the Safety Alert Symbol. The symbol alerts you to potential hazards that
can kill or injure you and others. All safety messages will follow the Safety
Alert Symbol and either the words "DANGER" or "WARNING".
DANGER means that failure to heed this safety
statement may result in severe personal injury or
death.
WARNING means that failure to heed this safety
statement may result in extensive product
damage, serious personal injury, or death.
All safety messages will alert you about the potential hazard, tell you how to reduce the chance of injury,
and let you know what can happen if the instructions are not followed.
IMPORTANT SAFEGUARDS
Before the appliance is used, it must be properly positioned and installed as
described in this manual, so read the manual carefully. To reduce the risk of fire,
electrical shock or injury when using the appliance, follow basic precautions,
including the following:
•
•
•
•
•
•
•
Plug into a grounded 3-prong outlet, do not remove grounding prong, do not use an adapter, and do
not use an extension cord.
Replace all panels before operating.
It is recommended that a separate circuit serving only your appliance be provided. Use receptacles
that cannot be turned off by a switch or pull chain.
Never clean appliance parts with flammable fluids. These fumes can create a fire hazard or explosion.
And do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any
other appliance. The fumes can create a fire hazard or explosion.
Before proceeding with cleaning and maintenance operations, make sure the power line of the unit is
disconnected. Failure to do so can result in electrical shock or death.
Do not connect or disconnect the electric plug when your hands are wet.
Do not attempt to repair or replace any part of your appliance unless it is specifically recommended in
this manual. All other servicing should be referred to a qualified technician.
3
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
FOLLOW WARNING CALLOUTS BELOW ONLY WHEN APPLICABLE TO YOUR MODEL
This unit is intended FOR INDOOR USE ONLY.
Use two or more people to move and install appliance. Failure to do so can result in back or other
injury.
To ensure proper ventilation for your appliance, 2½ inches (100mm) of space should be kept
between the back of the unit and the wall to allow proper air circulation to cool the compressor and
condenser. Choose a well-ventilated area with temperatures above 60°F (16°C) and below 90°F
(32°C). This unit must be installed in an area protected from the elements, such as wind, rain, water
spray or drips.
The appliance should not be located next to ovens, grills or other sources of high heat.
Never place heavy objects or items containing water on top of the unit. Spilled water could deteriorate
the insulation of electrical components and result in electrical leakage.
The appliance must be installed with all electrical, water and drain connections in accordance with
state and local codes. A standard electrical supply (115 V AC only, 60 Hz), properly grounded in
accordance with the National Electrical Code and local codes and ordinances, is required.
Do not throw items onto the shelves and do not place items totaling more than 65 lbs on each shelf.
The shelf could fall, possibly causing injury.
Do not kink or pinch the power supply cord of the appliance.
The size of the fuse (or circuit breaker) should be 15 amperes.
It is important that the appliance be leveled in order to work properly. You may need to make several
adjustments to level it.
All installations must be in accordance with local plumbing code requirements.
Make certain that the pipes are not pinched, kinked or damaged during installation.
Check for leaks after connection.
Never allow children to operate, play with or crawl inside the appliance.
Do not allow anyone to hang from the door or climb onto the unit. The unit could tip over and fall,
causing material damage and injury.
Do not use solvent-based cleaning agents or abrasives on the interior. These cleaners may damage
or discolor the interior.
This appliance is intended for storage and display of beverages for sale. Use this appliance only for
its intended purpose.
Keep fingers out of the “pinch point” areas. Clearances between the doors and between the doors
and cabinet are necessarily small. Be careful closing doors when children are in the area.
Risk of child entrapment!
Child entrapment and suffocation are not problems of the past. Junked or abandoned appliances are
still dangerous, even if they will “just sit in the garage a few days”.
Before discarding your old refrigerator:
• Take off the doors
• Leave the shelves in place so that children may not easily climb inside.
- SAVE THESE INSTRUCTIONS -
4
INSTALLATION INSTRUCTIONS
BEFORE USING YOUR APPLIANCE
• Remove the exterior and interior packing and leave doors open for a while to air out the unit..
• Before connecting the appliance to the power source, let it stand upright for approximately 2 hours.
This will reduce the possibility of a malfunction in the cooling system from handling during
transportation.
• Clean the interior surface with lukewarm water using a soft cloth.
INSTALLATION OF YOUR APPLIANCE
• The appliance is designed for free-standing installation only.
• WARNING: Do not store or install the appliance outdoors.
• CAUTION: This appliance is designed for storing and cooling beverages and drinks. Do not store
perishable food, medicine or other medical products.
• Place your Beverage Merchandiser on a floor that is strong enough to support it when it is fully loaded.
To level the unit, adjust the legs at the front of cabinet.
• Leave at least 2½ inches (100mm) of space at the back of the unit to allow proper air circulation to
cool the compressor and condenser. Take care that the condenser at the rear of the appliance is
never covered or blocked in any way.
• NOTE: It is recommended that you do not install the appliance near an oven, radiator or other heating
source. Direct sunlight may affect the acrylic coating and heat sources may increase electrical
consumption. Don’t install in a location where the temperature will fall below 60°F (16°C). For best
performance, do not install the appliance behind a cabinet door or block the base grille.
• Avoid locating the unit in moist areas.
• Plug the Beverage Merchandiser into an exclusive, properly grounded wall outlet. Do not under any
circumstances cut or remove the third (ground) prong from the power cord. Any questions concerning
power and/or grounding should be directed toward a certified electrician or an authorized service
center.
ELECTRICAL CONNECTION
WARNING
Improper use of the grounded plug can result in the risk of electrical shock. If the power cord is
damaged, have it replaced by a qualified electrician or an authorized service center.
This appliance should be properly grounded for your safety. The power cord of this appliance is equipped
with a three-prong plug which mates with standard three-prong wall outlets to minimize the possibility of
electrical shock.
Do not under any circumstances cut or remove the third (ground) prong from the power cord supplied. For
personal safety, this appliance must be properly grounded.
This appliance requires a standard 115/120 Volt AC ~ 60Hz three-prong grounded electrical outlet. Have
the wall outlet and circuit checked by a qualified electrician to make sure the outlet is properly grounded.
When a standard 2-prong wall outlet is encountered, it is your responsibility and obligation to have it
replaced with a properly grounded 3-prong wall outlet.
5
To prevent accidental injury, the cord should be secured behind the appliance and not left exposed or
dangling.
The appliance should always be plugged into its own individual electrical outlet which has a voltage rating
that matches the rating label on the appliance. This provides the best performance and also prevents
overloading house wiring circuits that could cause a fire hazard from overheating. Never unplug the
appliance by pulling on the power cord. Always grip the plug firmly and pull straight out from the
receptacle. Repair or replace immediately all power cords that have become frayed or otherwise
damaged. Do not use a cord that shows cracks or abrasion damage along its length or at either end.
When moving the appliance, be careful not to damage the power cord.
EXTENSION CORD
Because of potential safety hazards under certain conditions, it is strongly recommended that you do not
use an extension cord with this appliance. However, if you must use an extension cord it is absolutely
necessary that it be a UL/CUL-Listed, 3-wire grounding type appliance extension cord having a grounding
type plug and outlet and that the electrical rating of the cord be 115 volts and at least 10 amperes.
OPERATING YOUR APPLIANCE
It is recommended you install the appliance in a place where the ambient temperature is between 72º and
78ºF (23º-26ºC). If the ambient temperature is above or below the recommended temperatures, the
performance of the unit may be affected. For example, placing your unit in extreme cold or hot conditions
may cause interior temperatures to fluctuate.
TURNING THE UNIT ON AND OFF
The red toggle switch below the door turns the unit on and off.
When the unit is first turned on, allow it to operate for about an hour to cool the interior before placing
items inside.
SETTING THE TEMPERATURE CONTROL
The interior temperature is set with the dial-type thermostat. When the unit is fully loaded, the
temperature will be kept between 32°F and 50°F (0°C – 10°C) at the factory default setting of 4 to 5 on
the thermostat. Adjust as needed.
If the ambient temperature is extremely high or the unit has been too fully loaded, the interior temperature
will tend to be somewhat higher. In these cases, you could raise the setting of the thermostat to slightly
increase the interior temperature.
If the ambient temperature is unusually low or the unit is nearly empty, the interior temperature could
reach 32°F or below, in turn causing the evaporator to ice up. Under these circumstances, you should
lower the thermostat setting in order to raise the interior temperature.
NOTE: If the unit is unplugged, or power is lost or turned off, you must wait at least 5 minutes before
restarting the unit. If you attempt to restart before this time delay, the unit will not start.
DEFROSTING
Defrosting is performed automatically and drain water is collected in the drain tray at the back of the unit.
Water in the drain tray is normally evaporated automatically. Under humid conditions, a large amount of
water may accumulate in the drain tray, which may have to be emptied manually.
6
SHELF HEIGHT ADJUSTMENT
The height of the shelves can be adjusted. Arrange the shelves to suit the dimensions of the items to be
placed in the unit.
To prevent damaging the door gaskets, make sure to have the door(s) all the way open when pulling the
shelves out of the rail compartments.
When removing a shelf from the inner rails, make sure to remove all shelf contents first.
PLACING ITEMS IN THE UNIT
The beverage merchandiser employs a system of forced circulation of cold air. If this circulation is
obstructed, items will not be adequately refrigerated. Take note of the following points:
• Do not let items obstruct the cold air inlet and suction outlet.
• Place items so that they do not protrude beyond the shelves. The gap between the shelves and
the doors is intentional, and is designed to allow free circulation of cold air.
• Arrange items evenly on all shelves.
• Do not display items on the floor of the interior cabinet. Items must be placed on the shelves.
INTERIOR LIGHT
The unit is equipped with an interior light which is controlled by the green toggle switch below the door.
SELF-CLOSING DOORS
The right-hand sliding door of model SCR700 closes automatically. On model SCR7012D, both swing-out
doors close automatically.
DOOR LOCK
Model SCR700 has two sliding glass doors which can be locked with a single key. Model SCR7012D has
two swing-out glass doors, each of which can be locked separately.
The keys are located inside the plastic bag that contains the Instruction Manual. Keep the keys in a
secure location.
FOR MOST EFFICIENT USE
• Be sure the unit is installed in a well-ventilated area. Never cover air vents.
• The appliance should be located in the coolest area of the room, away from heat-producing
appliances and out of direct sunlight.
• To minimize the escape of cold air, open and close the doors quickly, and do not keep the doors open
any longer than necessary.
7
CARE AND MAINTENANCE
• To prevent any electrical shock or injury by the rotating circulation fan,
always disconnect the power cord from the wall outlet before cleaning.
• Do not splash water directly onto the unit and do not soak the unit with
water. Short-circuiting and electrical shock could result.
CLEANING YOUR BEVERAGE MERCHANDISER
• Turn off the power, unplug the appliance, and remove all items, including shelves.
• Wash the inside surfaces with a solution of warm water and baking soda (about 2 tablespoons of
baking soda to a quart of water).
• Wash the shelves with a mild detergent solution.
• Wring excess water out of the sponge or cloth when cleaning the area where the controls are located,
or any electrical parts.
• Wash the outside cabinet with warm water and mild liquid detergent. Rinse well and wipe dry with a
clean soft cloth.
• Never use scouring powder, soap powder, benzene, oil or hot water as these will damage the paint
and plastic components.
• Do not use steel wool or a steel brush on the stainless steel.
POWER FAILURE
Most power failures are corrected within a few hours and should not affect the temperature of your
appliance if you minimize the number of times the door is opened. If the power is going to be off for a
longer period of time, you need to take the proper steps to protect the contents.
VACATION TIME
• Short vacations: Leave the appliance operating during vacations of less than three weeks.
• Long vacations: If the appliance will not be used for several months, remove all items and turn off
the appliance. Clean and dry the interior thoroughly. To prevent odor and mold growth, leave the
doors open slightly, blocking them open if necessary.
MOVING YOUR APPLIANCE
1. Disconnect the plug and remove all loose items from inside the unit.
2. Securely tape down shelves inside the appliance.
3. Turn the adjustable legs up to the base to avoid damage.
4. Tape the doors shut.
5. Be sure the appliance stays secure in the upright position during transportation. Also, protect the
outside of the appliance with a blanket or similar item.
TEMPORARY STORAGE
• Place a piece of wood or the equivalent between the doors and main unit to prevent complete closing
of the doors.
• Make sure not to store the unused cooler in a location where children play. Should a child enter the
compartment and the doors are closed, the child may not be able to open the doors from the inside.
8
TROUBLESHOOTING
You can solve many common problems easily, saving you the cost of a possible service call. Try the
suggestions below to see if you can solve the problem before calling for service.
Troubleshooting Guide
PROBLEM
The unit does not operate.
The unit is not cold enough.
Turns on and off frequently.
The light does not work.
The unit seems to make too much noise.
There is condensation on the unit exterior.
POSSIBLE CAUSE
Not plugged in.
The appliance is turned off.
Tripped circuit breaker or blown fuse.
Check the temperature control setting.
Items may be obstructing cold air inlet or suction
outlet.
External environment may require a higher setting.
The door is opened too often.
The door is not closed completely.
The door gasket does not seal properly.
Condenser may be clogged.
The room temperature is warmer than normal.
A large amount of contents has been added to the
beverage merchandiser.
The door is opened too often.
The door is not closed completely.
The temperature control is not set correctly.
The door gasket does not seal properly.
Not plugged in.
Tripped circuit breaker or blown fuse.
Are all feet in firm contact with the floor?
Is the back of the unit touching the wall or other
objects?
Are other objects in contact with the appliance?
Condensation may form on the exterior and door
during hot and humid days or depending on the
place of installation. This occurs when water
particles in the air contact cold surfaces. This is
normal. Wipe away condensation with a dry cloth.
If the problem continues after taking the proper remedial actions, disconnect the power cord from the wall
outlet and transfer stored items to a box or other container. Then call Summit’s toll-fee Customer Service
number at 1-800-932-4267. Have the following information available:
 Model number
 Serial number
 Year and date of purchase
 Nature of malfunction
 Desired date for service visit
9
LIMITED WARRANTY
ONE-YEAR LIMITED WARRANTY
Within the 48 contiguous United States, for one year from the date of purchase, when this appliance is operated and
maintained according to instructions attached to or furnished with the product, warrantor will pay for factory-specified
parts and repair labor to correct defects in materials or workmanship. Service must be provided by a designated
service company. Outside the 48 states, all parts are warranted for one year from manufacturing defects. Plastic
parts, shelves and cabinets are warranted to be manufactured to commercially acceptable standards, and are not
covered for damage during handling or breakage.
5-YEAR COMPRESSOR WARRANTY
1. The compressor is covered for 5 years.
2. Replacement does not include labor.
ITEMS WARRANTOR WILL NOT PAY FOR:
1. Service calls to correct the installation of your appliance, to instruct you how to use your appliance, to replace or
repair fuses or to correct wiring or plumbing.
2. Service calls to repair or replace appliance light bulbs or broken shelves. Consumable parts (such as filters) are
excluded from warranty coverage.
3. Damage resulting from accident, alteration, misuse, abuse, fire, flood, acts of God, improper installation,
installation not in accordance with electrical or plumbing codes, or use of products not approved by warrantor.
4. Replacement parts or repair labor costs for units operated outside the United States.
5. Repairs to parts or systems resulting from unauthorized modifications made to the appliance.
6. Expenses for travel and transportation for product service in remote locations.
7. The removal and reinstallation of your appliance if it is installed in an inaccessible location or is not installed in
accordance with published installation instructions.
DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES
CUSTOMER'S SOLE AND EXCLUSIVE REMEDY UNDER THIS LIMITED WARRANTY SHALL BE PRODUCT
REPAIR AS PROVIDED HEREIN. IMPLIED WARRANTIES, INCLUDING WARRANTIES OF MERCHANTABILITY
OR FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO ONE YEAR. WARRANTOR SHALL NOT BE
LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES. SOME STATES DO NOT ALLOW THE EXCLUSION
OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, OR LIMITATIONS ON THE DURATION OF
IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS, SO THESE EXCLUSIONS OR LIMITATIONS MAY
NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE
OTHER RIGHTS, WHICH VARY FROM STATE TO STATE.
WARNING! This product may contain chemicals known to the state of California
to cause cancer or birth defects or other reproductive harm. For more information,
visit: www.summitappliance.com/prop65
Chemicals known by the manufacturer to be present in this product in concentrations
higher than threshold limits: NONE.
FELIX STORCH, INC.
770 Garrison Avenue
Bronx, NY 10474
Phone: (718) 893-3900
Fax: (718) 842-3093
www.summitappliance.com
For parts and accessory ordering,
troubleshooting and helpful hints, visit:
www.summitappliance.com/support
Revised January 2014
Printed in China
10
Download PDF

advertising