GE | CGS700P3MD1 | LP Conversion Kit | GE CGB550P2MS1 LP Conversion Kit

GE CGB550P2MS1 LP Conversion Kit
PROPANE (LP) CONVERSION INSTRUCTIONS
WARNING
Explosion Hazard
Death or serious injury can result from failure to follow
these instructions.
• Service by a qualified service technician only.
• Shut off gas supply and disconnect power before servicing.
• Reconnect all grounding devices after service.
• Replace all parts and panels before operating.
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU
natural gas. To use propane (LP) gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
WARNING Do not operate the cooktop or oven
burners of this range when using propane (LP) (bottled) gas
EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV
for propane (LP) gas use. Failure to do so could cause high
ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
CONVERTING THE PRESSURE REGULATOR
Remove the warming drawer and panel behind drawer. The
pressure regulator is located in the lower, left hand rear corner
of the range as viewed from the front.
CONVERTING THE COOKTOP BURNERS
Propane (LP) Conversion Kit
Burner cap
Pressure Regulator
Propane
Orange/Light Blue
2UL¿FHORFDWHG
through this
opening
1. Use an adjustable wrench to unscrew the hex-nut cap from
the pressure regulator.
&RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRႇWKH
threaded metal cap.
Rotate cap counterclockwise to loosen
NAT
PROPANE
CR
RR
LF
CF
RF
Base
Multi-ring
Propane
None
Round burner
NOTICE:
&5HPRYHWKHSURSDQH /3 RUL¿FHVIURPWKHER[SURYLGHG
7KHSURSDQH /3 RUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS
To aid in identifying the proper location for the propane (LP)
RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH /3 Gas, color codes have been added to the side or top of the
RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD
series of engraved marks (I, II, III . . .) located on the top.
95
LF1
LF2
Propane
None
Propane
Orange/Silver
LFC
B. Using a 7 mm or 9/32” nut driver, remove the top burner
RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU
opening in the base.
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
III
TOOLS REQUIRED:
LR
Burner head
Base
Gas Valve
4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
To adjust your range for use with propane (LP) gas, follow
these instructions:
Propane
Blue/Magenta
Burner cap
Burner head
Cap assembly
• Flat bladed screwdriver
(blade approximately
3/32” across)
• Nut drivers: 1/4”, 9/32”
or 7mm
Propane
Orange/Light Blue
Burner cap
3. Turn the metal cap so the type of gas being converted to is
displayed and replace the protective plastic cover.
• Adjustable wrench
• Socket wrench with
1/2” socket and extension
• Phillips head screwdriver
Propane
Red/Yellow
A. Remove the top grates, burner caps and burner heads.
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
7KHSURSDQH /3 RUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHG
on the back of the range in the location shown.
',QVWDOOWKHSURSDQH /3 RUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
BURNER OUTPUT RATINGS: BTU/HR
Propane (LP) Gas 10” W.C.P.
BTU
ORIFICE
COLOR
MARKING
BURNER RATE SIZE (mm)
LF
18,000
LF1
N/A
0.027
None
69L
LF2
N/A
0.027
None
69L
Propane
None
LF3
Propane
None
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\
screwed into the gas supply tubes.
(,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW
along with these instructions, and replace onto the back of the
range for possible future conversion.
CHECK SURFACE BURNERS
3XVKDQGWXUQDNQREWRWKH/,7(SRVLWLRQ$FOLFNLQJVRXQG
indicates proper operation of the ignition system. When lighting
DQ\EXUQHUVSDUNVZLOODSSHDUDWDOOEXUQHUVEXWJDVÀRZV
from only the one selected. Once air is purged from the supply
line, burner should light within 4 seconds. After burner lights,
URWDWHWKHNQRERXWRIWKH/,7(SRVLWLRQ7U\HDFKEXUQHULQ
succession until all burners have been checked.
Quality of Flames
'HWHUPLQHWKHTXDOLW\RIÀDPHVYLVXDOO\1RUPDOEXUQHUÀDPHV
should look like (A) or (B).
(A) Soft blue flames—
Normal for natural gas
1. Disconnect all electrical power, at the main circuit breaker or
fuse box.
LF3
N/A
0.027
None
69L
LFC
N/A
0.016
None
40L
(B) Yellow tips on
outer cones—
6KXWRႇWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDO
VKXWRႇYDOYH
LR
5,000
0.026
Red/Yellow
66L
Normal for propane (LP) gas
CF
9,500
0.0365
Orange/Light Blue
92L
CR
9,500
0.0365
Orange/Light Blue
92L
RF
15,000
0.045
Orange/Silver
114L
RR
12,000
0.039
Blue/Magenta
99L
Broil
13,500
0.042
Grey
042L
Bake
16,000
0.047
Orange
0.047
/RQJEULJKW\HOORZÀDPHVDUHQRWQRUPDO1RUPDOÀDPHVPD\
show signs of an orange tint when well heated or signs of
ÀLFNHULQJRUDQJHGXHWRSDUWLFOHVLQWKHJDVRUDLU
PROPANE (LP) CONVERSION INSTRUCTIONS
31-11074 Rev. 2 06-19 GEA
CGS700M, CGS986, and CGS700P
CONVERTING THE OVEN BURNERS
NOTICE:
This product cannot be converted to propane (LP) by
DGMXVWLQJWKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHG
for propane (LP).
BAKE BURNER ORIFICE
Lift
Burner
%DNH%XUQHU2UL¿FH
1. Remove oven racks, door and oven bottom. Remove the
1/4” hex screws securing the bake burner.
7
KHEDNHEXUQHURUL¿FHLVRQWKHJDVYDOYHORFDWHGEHKLQG
WKHZDUPLQJGUDZHU/LIWWKHEXUQHURႇWKHRUL¿FHDQGDSSO\
D´VRFNHWRQDQH[WHQVLRQWRWKHKH[EDVHRIWKHRUL¿FH
RQWKHJDVYDOYH/RRVHQWKHRUL¿FHE\WXUQLQJFRXQWHU
clockwise and remove.
ADJUSTING AIR SHUTTER SETTINGS
FOR OVEN BURNERS
ADJUSTING LOW FLAME SETTING
ON COOKTOP BURNERS
The air shutters should be turned to the marked settings NG or
propane (LP) or set according to the following table.
Low setting adjustments must be made with other burners in
operation on a medium setting. This procedure prevents the
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5
HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
into the valve shaft and/or side adjustment screw(s) as
shown and turn clockwise to fully tighten down the bypass
screw(s). Repeat for all valves.
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ
FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU
Remember, other burners must be turned on to medium.
SPECIALTY BURNERS
Multi-Ring Burner±7KHRXWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH0('E\
Burner Cap
adjusting the set screw in the center
Flames
YDOYHVKDIW7KHÀDPHVVKRXOGEH
adjusted so that they barely curl over
the top edge of the burner cap. The
FHQWHUULQJRIÀDPHVVKRXOGEHDGMXVWHG
with the knob at the LO setting by
adjusting the set screw to the right of
the valve shaft.
( $GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ
DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV
extinguished, continue adjusting bypass screw for a larger
ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH
F. Replace the knob.
BURNER
AIR SHUTTER
SETTING FOR PROPANE (LP)
AIR SHUTTER
SETTING FOR NG
Bake
Broil
Full open
0.690”
Full open
0.690”
1. With a Phillips head screwdriver, loosen the screws
securing the air shutter on the bake burner. Adjust the air
shutter to fully open.
2. Turn on the gas.
Screw
3. Turn on the electricity.
Air shutter
4. Reinstall the oven door.
5. Turn on the bake burner.
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG
WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
$V\RXZDWFKWKHÀDPHZLWKWKHRYHQGRRUFORVHGFKHFN
the following through the oven door window.
D,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH
E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly.
7XUQEDNHEXUQHURႇDQGUHSHDWZLWKEURLOEXUQHU
WARNING If you attempt to measure the inner cone
NOTICE:
RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
6
HOHFWWKHSURSDQH /3 EDNHRUL¿FHIURPWKHNLWDQGLQVWDOO
it on the gas valve. Tighten until snug.
BROIL BURNER ORIFICE
Broil
2UL¿FH
Oven
Light
&
KHFNLQJWKHÀDPHVL]H
It should be approximately 1/2”
to 3/4” long for the bake and broil
burners.
The combustion quality of the
EXUQHUÀDPHVQHHGVWREH
determined visually.
127(,IEXUQHUÀDPHVORRNOLNH $ IXUWKHUDLUVKXWWHU
adjustment to the bake buner is required. Normal
EXUQHUÀDPHVVKRXOGORRNOLNH % RU & GHSHQGLQJRQ
the type of gas you use. With propane (LP) gas, some
yellow tipping on the outer cones is normal.
(A) Yellow flames:
Further Adjustment
Required
1. Remove the 1/4” hex screw securing the broil burner and
DOORZLWWRKDQJGRZQIUHHRIWKHEURLORUL¿FH
$
SSO\D´ZUHQFKWRWKHKH[EDVHRIWKHRUL¿FH/RRVHQ
WKHRUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
NOTICE:
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXWWKH
propane (LP) sticker and include your name, organization
and date conversion was made. Apply the sticker to the
range near the regulator to alert others in the future that
this appliance has been converted to propane (LP). If
converting back to natural gas from propane (LP), please
remove the sticker so others know the appliance is set to
use natural gas.
ADDITIONAL INFORMATION
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5” W.C.P.
BTU
ORIFICE
RATE
SIZE
(mm)
COLOR
MARKING
BURNER
LF
21,000
LF1
N/A
0.045
None
114N
LF2
N/A
0.045
None
114N
LF3
N/A
0.045
None
114N
LFC
N/A
0.025
None
63N
LR
5,000
0.040
White/Purple
101N
CF
9,500
0.0555
Yellow
141N
CR
9,500
0.0555
Yellow
141N
RF
15,000
0.070
Brown
178N
RR
12,000
0.061
Red
155N
Broil
16,500
0.071
Blue/Black
071N
Bake
16,000
0.070
None
50
198
N
Adjustment
screw for
outer ring
Denotes 1.98mm Orifice size opening
Denotes Natural Gas
III
Adjustment
screw for
center ring
Adjustment screws for multi-ring burner only
(B) Yellow tips on
outer cones:
Normal for Propane (LP) Gas
(C) Soft blue flames:
Normal for Natural Gas
6
HOHFWWKHSURSDQH /3 EURLORUL¿FHIURPWKHNLWDQGLQVWDOOLW )RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW
on the broil elbow. Tighten until snug.
¿UVWEXWWKLVZLOOVRRQGLVDSSHDU
5
HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH
9. When all adjustments are made and the results are
screw securing the burner.
satisfactory:
a. Retighten the air shutter screws.
b. Replace the oven bottom.
c. Replace the storage drawer.
Center adjustment screw only for all other burners.
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the
instructions given in making propane (LP) adjustments.
PROPANE (LP) CONVERSION INSTRUCTIONS
31-11074 Rev. 2 06-19 GEA
CGS700M, CGS986, and CGS700P
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising