GE | PGS930SELSS | LP Conversion Kit | GE PGS930SELSS LP Conversion Kit

GE PGS930SELSS LP Conversion Kit
PROPANE CONVERSION INSTRUCTIONS
WARNING
',QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
CONVERTING THE PRESSURE REGULATOR
CONVERTING THE COOKTOP BURNERS
Propane
Red/Yellow
Explosion Hazard
Death or serious injury can result from failure to follow
these instructions.
• Service by a qualified service technician only.
• Shut off gas supply and disconnect power before servicing.
• Reconnect all grounding devices after service.
• Replace all parts and panels before operating.
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU
natural gas. To use propane gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
WARNING Do not operate the cooktop or oven
burners of this range when using propane (bottled) gas
EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV
for propane gas use. Failure to do so could cause high
ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
Remove the warming drawer and panel behind drawer. The
pressure regulator is located in the lower, left hand rear corner
of the range as viewed from the front.
A. Remove the top grates, burner caps and burner heads.
Burner cap
LR
3UHVVXUH5HJXODWRU
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
2. Completely remove the protective plastic cap off the
threaded metal cap.
Rotate cap counterclockwise to loosen
C2
RF
Base
Dual oval burner
Round burner
Propane
None
B. Using a 7 mm or 9/32” nut driver, remove the top burner
RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU
opening in the base.
LF1
LF2
Propane
None
Propane
Orange/Silver
LFC
Propane
None
LF3
Propane
None
NOTICE:
&5HPRYHWKHSURSDQHRUL¿FHVIURPWKHER[SURYLGHG7KH
SURSDQHRUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS
To aid in identifying the proper location for the propane
RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH
*DVFRORUFRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKH
RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD
series of engraved marks (I, II, III . . .) located on the top.
95
3. Turn the metal cap so the type of gas being converted to
is displayed and replace the protective plastic cover.
B. If this is your regulator:
1. Use an adjustable wrench to unscrew the hex-nut cap
from the pressure regulator.
2. Turn the plastic cap 1/4 turn to disassemble.
PROPANE
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
III
4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
NAT
LF
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
NAT
Regulator style A
Rotate cap counterclockwise to loosen.
2UL¿FHV
located
through this
opening
Multi-ring
A. If this is your regulator:
2UL¿FH
located
through this
opening
3HUPDQHQW
Oval Burner Caps
(Non-Removable)
Base
*DV9DOYH
Propane
Blue/Red
RR
C1
2UL¿FH
located
through this
opening
Cap assembly
To adjust your range for use with propane gas, follow these
instructions:
Burner cap
Burner head
PROPANE
• Flat bladed screwdriver
(blade approximately
3/32” across)
• Nut drivers: 1/4”, 9/32”
or 7mm
Round Burner Cap
(Removable)
Burner head
3URSDQH&RQYHUVLRQ.LW
• Adjustable wrench
• Socket wrench with
1/2” socket and extension
• 3KLOOLSVKHDGVFUHZGULYHU
Propane
Orange/Light Blue
Burner cap
7KHSURSDQHRUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHGRQ
the back of the range in the location shown.
TOOLS REQUIRED:
Propane
Orange/Light Blue
BURNER OUTPUT RATINGS: BTU/HR
Propane Gas 10” W.C.P.
BTU
ORIFICE
RATE
SIZE
(mm)
COLOR
MARKING
BURNER
3XVKDQGWXUQDNQREWRWKH/,7(SRVLWLRQ$FOLFNLQJVRXQG
indicates proper operation of the ignition system. When lighting
DQ\EXUQHUVSDUNVZLOODSSHDUDWDOOEXUQHUVEXWJDVÀRZV
from only the one selected. Once air is purged from the supply
line, burner should light within 4 seconds. After burner lights,
URWDWHWKHNQRERXWRIWKH/,7(SRVLWLRQ7U\HDFKEXUQHULQ
succession until all burners have been checked.
Quality of Flames
'HWHUPLQHWKHTXDOLW\RIÀDPHVYLVXDOO\1RUPDOEXUQHUÀDPHV
should look like (A) or (B).
18,000
N/A
0.027
None
/
/)
N/A
0.027
None
/
(A) Soft blue flames—
/)
N/A
0.027
None
/
Normal for natural gas
/
N/A
0.016
None
/5
5,000
0.026
Red/Yellow
/
2. Shut off the gas supply to the range by closing the manual
shut-off valve.
RF
15,000
0.045
Orange/Silver
/
RR
9,500
0.0365
2UDQJH/LJKW%OXH
/
C
8,000
C1
9,500
0.0365
2UDQJH/LJKW%OXH
/
4. Screw the hex-nut cap back onto the pressure regulator.
CHECK SURFACE BURNERS
/)
/)&
3. Turn the plastic cap over and hook it into the slots.
Rotate cap 1/4 turn to reassemble. The type of gas to be
used should now be visible on the top of the cap.
(,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW
along with these instructions, and replace onto the back of the
range for possible future conversion.
/)
1. Disconnect all electrical power, at the main circuit breaker or
fuse box.
Regulator style B
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\
screwed into the gas supply tubes.
C2
6,800
0.030
Blue/Red
/
Broil
13,500
0.042
*UH\
/
Bake
16,000
0.047
Orange
0.047
(B) Yellow tips on
outer cones—
Normal for propane gas
/RQJEULJKW\HOORZÀDPHVDUHQRWQRUPDO1RUPDOÀDPHVPD\
show signs of an orange tint when well heated or signs of
ÀLFNHULQJRUDQJHGXHWRSDUWLFOHVLQWKHJDVRUDLU
PROPANE CONVERSION INSTRUCTIONS
31-11085 05-17 GEA
PGS930
CONVERTING THE OVEN BURNERS
NOTICE:
This product cannot be converted to propane by adjusting
WKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHGIRUSURSDQH
BAKE BURNER ORIFICE
/LIW
Burner
%DNH%XUQHU2UL¿FH
1. Remove oven racks, door and oven bottom. Remove the
1/4” hex screws securing the bake burner.
7
KHEDNHEXUQHURUL¿FHLVRQWKHJDVYDOYHORFDWHGEHKLQG
WKHZDUPLQJGUDZHU/LIWWKHEXUQHURIIWKHRUL¿FHDQGDSSO\
D´VRFNHWRQDQH[WHQVLRQWRWKHKH[EDVHRIWKHRUL¿FH
RQWKHJDVYDOYH/RRVHQWKHRUL¿FHE\WXUQLQJFRXQWHU
clockwise and remove.
ADJUSTING AIR SHUTTER SETTINGS
FOR OVEN BURNERS
ADJUSTING LOW FLAME SETTING
ON COOKTOP BURNERS
7KHDLUVKXWWHUVVKRXOGEHWXUQHGWRWKHPDUNHGVHWWLQJV1*RU
propane or set according to the following table.
/RZVHWWLQJDGMXVWPHQWVPXVWEHPDGHZLWKRWKHUEXUQHUVLQ
operation on a medium setting. This procedure prevents the
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5
HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
into the valve shaft and/or side adjustment screw(s) as
shown and turn clockwise to fully tighten down the bypass
screw(s). Repeat for all valves.
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ
FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU
Remember, other burners must be turned on to medium.
SPECIALTY BURNERS
Dual Oval Burner – This burner should be properly adjusted
with both bypass screws completely screwed in.
Multi-Ring Burner±7KHRXWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH0('
Burner Cap
by adjusting the set screw in the
Flames
FHQWHUYDOYHVKDIW7KHÀDPHVVKRXOG
be adjusted so that they barely curl
over the top edge of the burner cap.
7KHFHQWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH/2
setting by adjusting the set screw to
the right of the valve shaft.
( $GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ
DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV
extinguished, continue adjusting bypass screw for a larger
ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH
F. Replace the knob.
BURNER
AIR SHUTTER
SETTING FOR PROPANE
AIR SHUTTER
SETTING FOR NG
Bake
Broil
Full open
0.690”
Full open
0.690”
:LWKD3KLOOLSVKHDGVFUHZGULYHUORRVHQWKHVFUHZV
securing the air shutter on the bake burner. Adjust the air
shutter to fully open.
2. Turn on the gas.
Screw
3. Turn on the electricity.
Air shutter
4. Reinstall the oven door.
5. Turn on the bake burner.
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG
WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
$V\RXZDWFKWKHÀDPHZLWKWKHRYHQGRRUFORVHGFKHFN
the following through the oven door window.
D,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH
E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly.
7. Turn bake burner off and repeat with broil burner.
WARNING If you attempt to measure the inner cone
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
6
HOHFWWKHSURSDQHEDNHRUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ
the gas valve. Tighten until snug.
BROIL BURNER ORIFICE
Broil
2UL¿FH
Oven
/LJKW
1. Remove the 1/4” hex screw securing the broil burner and
DOORZLWWRKDQJGRZQIUHHRIWKHEURLORUL¿FH
$
SSO\D´ZUHQFKWRWKHKH[EDVHRIWKHRUL¿FH/RRVHQ
WKHRUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
6
HOHFWWKHSURSDQHEURLORUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ
the broil elbow. Tighten until snug.
5
HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH
screw securing the burner.
RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
&
KHFNLQJWKHÀDPHVL]H
It should be approximately 1/2”
to 3/4” long for the bake and broil
burners.
The combustion quality of the
EXUQHUÀDPHVQHHGVWREH
determined visually.
127(,IEXUQHUÀDPHVORRNOLNH $ IXUWKHUDLUVKXWWHU
adjustment to the bake buner is required. Normal
EXUQHUÀDPHVVKRXOGORRNOLNH % RU & GHSHQGLQJ
on the type of gas you use. With propane gas, some
yellow tipping on the outer cones is normal.
(A) Yellow flames:
Further Adjustment
Required
(B) Yellow tips on
outer cones:
Normal for Propane Gas
Adjustment screw
for outer ring
Adjustment screws for
multi-ring burner only
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXW
the propane sticker and include your name, organization
and date conversion was made. Apply the sticker to
the range near the regulator to alert others in the future
that this appliance has been converted to propane. If
converting back to natural gas from propane, please
remove the sticker so others know the appliance is set to
use natural gas.
ADDITIONAL INFORMATION
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5” W.C.P.
BTU
ORIFICE
RATE
SIZE
(mm)
COLOR
MARKING
BURNER
/)
21,000
/)
N/A
0.045
None
114N
/)
N/A
0.045
None
114N
/)
N/A
0.045
None
114N
/)&
N/A
0.025
None
63N
/5
5,000
0.040
:KLWH3XUSOH
101N
RF
15,000
0.070
Brown
178N
RR
9,500
0.0555
Yellow
141N
C
8,000
C1
9,500
0.0555
Yellow
141N
C2
6,800
0.047
None
119N
Broil
16,500
0.071
Black/Blue
071N
Bake
16,000
0.070
None
50
198
N
Adjustment screw
for center ring
Adjustment
screw for
center ring
NOTICE:
Denotes 1.98mm Orifice size opening
Denotes Natural Gas
III
Adjustment
screw for
2 oval rings
Adjustment screws for
dual oval burner only
(C) Soft blue flames:
Normal for Natural Gas
)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW
¿UVWEXWWKLVZLOOVRRQGLVDSSHDU
9. When all adjustments are made and the results are
satisfactory:
a. Retighten the air shutter screws.
b. Replace the oven bottom.
c. Replace the storage drawer.
Center adjustment screw only for all other burners.
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the
instructions given in making propane adjustments.
PROPANE CONVERSION INSTRUCTIONS
31-11085 05-17 GEA
PGS930
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising