Ideal | Twister® Al/Cu Wire Connector, Model 65 Purple | Spec sheet | Ideal Twister® Al/Cu Wire Connector, Model 65 Purple spec sheet

Ideal Twister® Al/Cu Wire Connector, Model 65 Purple spec sheet
Safety Data Sheet
OSHA Hazard Communication Standard
29 CFR 1910.1200. Prepared to GHS Rev 3.
Revision date: Initial version
Date of issue: 04.28.2018
Page: 1/10
Trade name:
Twister® Al/Cu Wire Connector
SECTION 1: Identification
Product identifier:
Synonyms:
Product Code Number:
SDS number:
Recommended use:
Recommended restrictions:
Noalox® Anti Oxidant.
None available.
30-065, 30-165, 30-265, 30-365
ID014
Wire Connector.
Uses other than those recommended.
Manufacturer/Importer/Supplier/Distributor information:
Company Name:
IDEAL INDUSTRIES, INC.
Company Address:
Becker Place,
Sycamore, IL 60178
Company Telephone:
Office hours (Mon – Fri)
7AM - 5 PM (CDT)
(815)895-5181
Company Contact Name:
Darryl Docter.
Company Contact Email:
IDEAL@IDEALINDUSTRIES.COM
Emergency phone number:
24 HOUR EMERGENCY NUMBER:
(815)895-5181.
SECTION 2: Hazard(s) identification
Classification of the chemical in accordance with paragraph (d) of §1910.1200:
Physical hazards
Not classified as a physical hazard under GHS criteria.
Health hazards
Carcinogenicity, Category 2.
Environmental hazards
Acute aquatic toxicity, Category 2.
Chronic aquatic toxicity, Category 2.
GHS Signal word:
DANGER.
GHS Hazard statement(s):
Suspected of causing cancer.
Toxic to aquatic life with long lasting effects.
Revision Date: June 13, 2018
Page 1 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
GHS Hazard symbol(s):
GHS Precautionary statement(s):
Prevention:
P201 - Obtain special instructions before use.
P202 - Do not handle until all safety precautions have
been read and understood.
P273 - Avoid release to the environment.
P281 - Use personal protective equipment as required.
Response:
P308 + P313 - IF exposed or concerned: Get medical
advice/ attention.
Storage:
P405 - Store locked up.
Disposal:
P501 - Dispose of contents/ container to an approved
waste disposal plant.
Hazard(s) not otherwise
Classified (HNOC):
None known.
Percentage of ingredient(s) of unknown acute toxicity:
13% of the mixture consists of ingredients of unknown acute toxicity (oral/dermal/inhalation).
SECTION 3: Composition/information on ingredients
Mixture: Steel and other constituents bound in a polymer matrix
Chemical name
CAS#
Concentration
(weight %)
Zinc Dust
7440-66-6
15 - 20 %
Antimony Trioxide
1309-64-4
< 2%
Note: The balance of the ingredients are not classified as hazardous or are below the
classification threshold under the criteria of the Federal OSHA Hazard Communication
Standard 29CFR 1910.1200.
SECTION 4: First-aid Measures
Description of necessary measures:
Inhalation: No first aid measures usually required. Get medical attention if concerned.
Revision Date: June 13, 2018
Page 2 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
Skin contact: No first aid measures usually required. Get medical attention if concerned.
Eye contact: No first aid measures usually required. Get medical attention if concerned.
Ingestion: No first aid measures usually required. Get medical attention if concerned.
Most important symptoms/effects, acute and delayed: None normally expected.
Indication of immediate medical attention and special treatment needed: If any symptoms
are observed, contact a physician and give them this SDS sheet. If exposed or concerned: Get
medical advice/attention.
SECTION 5: Fire-fighting measures
Suitable extinguishing media: None normally required. Use extinguishing media for
surrounding materials.
Unsuitable extinguishing media: None known.
Specific hazards arising from the chemical: None expected, but Polypropylene material is a
UL listed 94 V-2 flame rated products.
Combustion products - Carbon monoxide, Carbon dioxide.
Special protective equipment and precautions for fire-fighters: For fire involving this
material, use self-contained breathing apparatus with full face shield to protect against the
hazardous effects of combustion products and oxygen deficiencies. Keep fire exposed
containers cool with water.
SECTION 6: Accidental release measures
Personal precautions, protective equipment and emergency procedures:
Sections 2 and 7 for information on hazards and precautionary measures.
Methods and material for containment and cleaning up:
Sweep up to prevent tripping.
SECTION 7: Handling and Storage
Precautions for safe handling: Use good personal hygiene practices.
Conditions for safe storage, including any incompatibles: Keep away from children, infants
and pets. Avoid excessive heat or open flames.
Revision Date: June 13, 2018
Page 3 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
SECTION 8: Exposure controls/personal protection
Control Parameters:
Occupational exposure limits:
US OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200):
Permissible Exposure Limits
PEL-TWA
PEL-STEL
Substance
(8 hour)
(15 min)
Zinc Dust
No data available
No data available
3
Antimony Trioxide
0.5 mg/m
No data available
US ACGIH Threshold Limit Values
TLV-TWA
Substance
(8 hour)
Zinc Dust
No data available
Antimony Trioxide
No data available
TLV-STEL
(15 min)
No data available
No data available
NIOSH Exposure Limits
Substance
TWA
STEL
Zinc Dust
Antimony Trioxide
No data available
0.5 mg/m3
No data available
No data available
Appropriate engineering controls: None normally required. General (mechanical) room
ventilation is expected to be adequate.
Individual protection measures, such as personal protective equipment:
Eye/face protection: Follow company policy with respect to eye protection.
If used, safety glasses should be OSHA compliant.
Skin and Hand protection: None normally required.
Respiratory protection: None normally required. Where protection from nuisance levels
of dusts are desired, use type N95 (US) dust masks. Use respirators and components tested
and approved under appropriate government standards such as NIOSH/OSHA.
Other: None.
Thermal hazards: No data available.
SECTION 9: Physical and chemical properties
Appearance
Physical state:
Form:
Revision Date: June 13, 2018
Solid
Purple solid article.
Page 4 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
Color:
Purple.
Odor:
No data available
Odor threshold:
No data available
pH:
Not applicable
Melting point/freezing point:
No data available
Initial boiling point and
No data available
boiling range:
Flash point:
No data available
Evaporation rate:
No data available
Flammability (solid, gas):
Not applicable
Upper/lower flammability or explosive limits
Flammability limit – lower %):
Not applicable
Flammability limit – upper (%):
Not applicable
Explosive limit – lower (%):
Not applicable
Explosive limit – upper (%):
Not applicable
Vapor pressure:
No data available
Vapor density:
No data available
Relative Density:
No data available
Solubility(ies):
Insolube.
Partition coefficient (n-octanol/water): No data available
Auto-ignition temperature:
No data available
Decomposition temperature:
No data available
Viscosity:
No data available
Other information:
% Volatile by volume:
< 10%
Percent solids by weight:
~ 100%
SECTION 10: Stability and Reactivity
Reactivity:
Chemical stability:
Possibility of hazardous reactions:
Conditions to avoid:
Incompatible materials:
Hazardous decomposition Products:
Not chemically reactive.
Stable under normal ambient and anticipated
conditions of use.
Hazardous reactions not anticipated.
Avoid direct exposure to flame or excessive heat.
Avoid strong oxidizing agents.
Excessive heat and burning may release oxides of
carbon.
SECTION 11: Toxicological information
Information on likely routes of exposure:
Inhalation:
Not an expected route of entry.
Ingestion:
Not an expected route of entry.
Skin:
Skin contact is a potental route of entry.
Eyes:
Not an expected route of entry.
Revision Date: June 13, 2018
Page 5 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
Symptoms related to the physical, chemical, and toxicological characteristics:
Constituents are either steel or are bound in a polymer matrix and potential for hazardous
exposure is minimal.
Delayed and immediate effects and chronic effects from short or long-term exposure:
None expected.
Numerical measures of toxicity:
Ingredient Information:
Substance
Zinc Dust
Test Type (species)
Value
LD50 Oral (Rat)
No data available
LD50 Dermal (Rabbit)
No data available
LC50 Inhalation
No data available
LD50 Oral (Rat)
> 34600 mg/kg
Antimony Trioxide LD50 Intravenous (Rat)
LC50 Inhalation (Rat)
No data available
No data available
Product Acute Toxicity Estimates:
Acute Oral Toxicity – no data available
Acute Dermal Toxicity - no data available
Acute Inhalation Toxicity - no data available
Skin corrosion/irritation:
No information available on the mixture, however
none of the components have been classified to cause
skin corrosion/irritation (or are below the
concentration threshold for classification).
Serious eye damage/eye irritation:
No information available on the mixture, however
none of the components have been classified to cause
eye damage/irritation (or are below the concentration
threshold for classification).
Respiratory sensitization:
No information available on the mixture, however
none of the components have been classified as a
respiratory sensitizer (or are below the concentration
threshold for classification).
Skin sensitization:
No information available on the mixture, however
none of the components have been classified as a skin
sensitizer (or are below the concentration threshold
for classification).
Revision Date: June 13, 2018
Page 6 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
Germ cell mutagenicity:
No information available on the mixture, however
none of the components have been classified for
germ cell mutagenicity (or are below the
concentration threshold for classification).
Carcinogenicity:
No information available on the mixture, however
Antimony Trioxide is listed in the International
Agency for Research on Cancer (IARC) Monographs
as a Group 2B: Possibly carcinogenic to humans and
is suspected of causing pneumoconiosis and/or lung
cancer.
Reproductive toxicity:
No information available on the mixture, however
none of the components have been classified for
reproductive toxicity (or are below the concentration
threshold for classification).
Specific target organ toxicitySingle exposure:
No information available on the mixture, however
none of the components have been classified for
STOT SE (or are below the concentration threshold
for classification).
Specific target organ toxicityRepeat exposure:
No information available on the mixture, however
none of the components have been classified for
STOT RE (or are below the concentration threshold
for classification).
Aspiration hazard:
No information available on the mixture, however
none of the components have been classified for
aspiration hazard (or are below the concentration
threshold for classification).
Further information:
No data available.
SECTION 12: Ecological information
Ecotoxicity:
Product data: No data available
Ingredient Information:
Substance
Zinc Dust
Revision Date: June 13, 2018
Test
Type
LC50
Species
Value
Fish
No data available
Page 7 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
LC50
Aquatic crustacea
No data available
EC50
Algae
No data available
LC50
Fish - Danio rerio (zebra fish)
Invertebrates - Daphnia
magna (Water flea)
Algae - Selenastrum
capricornutum (green algae)
> 1000 mg/l (96 h)
Antimony Trioxide LC50
EC50
> 1000 mg/l (48 h)
67 mg/l (72h)
Persistence and Degradability: No data available
Bioaccumulative Potential: No data available.
Mobility in Soil: No data available.
Other adverse effects: No data available.
SECTION 13: Disposal considerations
Disposal instructions:
Landfill or incinerate in accordance with Local, State and Federal guidelines.
See Sections 7 and 8 for information on handling, storage and personal protection and Section
9 for physical/chemical properties.
It is possible that the material as produced contains constituents which are not required to be
listed in the SDS but could affect the hazardous waste determination. Additionally, use which
results in chemical or physical change of this material could subject it to regulation as a
hazardous waste.
SECTION 14: Transport Information
US Department of Transportation Classification (49CFR)
Identification number
UN 3077
Proper shipping name
Environmentally hazardous substance, solid, n.o.s.
(contains Zinc dust, Antimony Trioxide)
Class / Division
9
Packing group
III
Poison Inhalation Hazard
No
IMDG
Identification number
Proper shipping name
Class / Division
Packing group
UN 3077
Environmentally hazardous substance, solid, n.o.s.
(contains Zinc dust, Antimony Trioxide)
9
III
IATA (Country variations may apply)
Identification number
UN 3077
Proper shipping name
Environmentally hazardous substance, solid, n.o.s.
(contains Zinc dust, Antimony Trioxide)
Class / Division
9
Revision Date: June 13, 2018
Page 8 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
Packing group
III
SECTION 15: Regulatory Information
Safety, health and environmental regulations specific for the product.
USA:
United States Federal Regulations: This SDS complies with the OSHA, 29 CFR
1910.1200. The product is hazardous under OSHA.
Toxic Substances Control Act (TSCA) – All hazardous substances in this product are
listed, as required, on the TSCA inventory.
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311,312 and
313:
Section 302 – No chemicals in this material are subject to the reporting requirements of
SARA Title III, Section 302.
CERCLA Hazardous Substance List, 40 CFR 302.4:
None listed.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130):
None listed.
Clean Water Act Section 311 Hazardous Substances (40 CFR 117.3): None listed.
SARA Title III
Section 302 Extremely Hazardous Substance (40 CFR 355, Appendix A): None listed.
Section 311/312 (40 CFR 370):
Acute Health Hazard: No
Chronic Health Hazard: Yes
Fire Hazard: No
Pressure Hazard: No
Reactivity Hazard: No
Section 313 Toxic Release Inventory (40 CFR 372):
This product contains the following materials that are subject to the reporting requirements
of Section 313 of EPCRA: Zinc powder (stabilized), Antimony trioxide.
STATE REGULATIONS:
This SDS contains specific health and safety data is applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your
state.
Revision Date: June 13, 2018
Page 9 of 10
Twister® Al/Cu Wire Connector
SDS#: ID014
California Proposition 65 (California Safe Drinking Water and Toxic Enforcement
Act of 1986: WARNING! This product contains a chemical known to the State of
California to cause cancer. Antimony trioxide.
Massachusetts Right to Know: Zinc powder (stabilized) and Antimony trioxide are listed
on the Massachusetts Right to Know List.
New Jersey Right to Know: Zinc powder (stabilized) and Antimony trioxide are listed on
the New Jersey Right to Know list.
Pennsylvania Right to Know: Zinc powder (stabilized) and Antimony trioxide are listed
on the Pennsylvania Right to Know List.
Canada WHMIS Hazard Class: D2B – Very Toxic Material
SECTION 16: Other information, including date of preparation or last revision.
Revision Date: April 28, 2015
To the best of our knowledge, the information contained herein is accurate. However IDEAL
INDUSTRIES INC. does not assume any liability whatsoever for the accuracy or
completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and
should be used with caution. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards which exist.
Revision Date: June 13, 2018
Page 10 of 10
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising