YORK PHG6 Technical Guide

YORK PHG6 Technical Guide
5331896-YTG-C-1017
DESCRIPTION
These packaged duel fuel cooling/gas heating/heat pumps are
designed for outdoor installation. Only utility and duct
connections are required at the point of installation.
FEATURES
TECHNICAL GUIDE
SINGLE PACKAGE
HEAT PUMP / GAS HEAT
16 SEER – R-410A – 208/230V - 1 PHASE
2 THRU 5 NOMINAL TONS
50 THRU 125 MBH HEAT INPUT
MODELS: PHG6*24 THRU 60
• Operating Efficiency - All PHG6 models provide a minimum
AFUE of 81.0% in gas heating and 16.0 SEER, 12.5 or 12.0
EER and 8.2 HSPF ratings for heat pump cooling/heating
operation. All models meet California Low-Nox requirements
of 40 ng/joule emission level for Air Quality Management Districts.
• On Site Flexibility - All model sizes use a compact design
cabinet in one of two footprints. This provides installer flexibility for placing the proper capacity unit on curbs or pads
with the smallest footprint after the internal load has been
determined. Field convertible duct connections from side
shot to down shot allows the installer to have greater flexibility with less inventory.
• Lower Installation Cost - Installation time and costs are
reduced by easy power and control wiring connections. The
small base dimension means less space is required on the
ground or roof. All units are completely wired, charged with
R-410A refrigerant and tested prior to shipment. Test stations using a state-of-the-art computerized process system
are used to insure product quality. Refrigerant charge and
component part numbers are verified via computers during
assembly. Vital run test statistics such as system pressure,
motor currents, air velocity and temperature, unit vibration,
and gas system safeties are monitored and recorded by the
system to insure unit performance. Equal size side supply
and return duct connections allow easy connection of ducts
to match low crawl spaces without transition pieces.
• Utility Connections Made Easy - Gas and electric utility
access provided through the bottom or the side of the unit.
Utility connections can be made quickly and with a minimum
amount of field labor. A field supplied and field installed electrical disconnect switch must be installed.
Š
Due to continuous product improvement, specifications
are subject to change without notice.
Visit us on the web at
www.upgnet.com and www.york.com
Additional rating information can be found at:
www.ahridirectory.org
WARRANTY SUMMARY*
Extended 10-Years limited parts and compressor warranty
Lifetime gas heat exchanger warranty with registration.
* Extended warranty requires online registration within 90 days of purchase for
replacement or closing for new home purchase. See limited warranty certificate
in User’s Information Manual for details.
• Convertible Airflow Design - The bottom duct openings are
covered when they leave the factory, ready to be used for a
side supply/side return application. If a bottom supply/bottom
return application is desired, simply remove the two panels
from the bottom of the unit and place them in the side supply/
side return duct openings. No panel cutting is required and
no accessory panel is necessary. Convertible airflow design
allows maximum field flexibility and minimum inventory.
• Condensate Pan - A corrosion-resistant, long-lasting, watertight pan is positioned below the indoor coil to collect and
drain all condensate, preventing build-up of stagnant condensate. The condensate pan conforms to ASHRAE 62-89
standards (Ventilation for Acceptable Indoor Air Quality).
• Condensate Drain - The 3/4 inch NPT female connection is
rigidly mounted to assure proper fit and leak tight seal.
• Durable Finish - The cabinet is made of G90 galvanized
steel with a powder paint coating for appearance and protection. The pre-treated galvanized steel provides a better paintto-steel bond, which resists corrosion and rust creep. Powder paint finish insures less fading when exposed to sunlight,
and provides superior corrosion resistance (1000 hour salt
spray tested).
Continued on next page.
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
5331896-YTG-C-1017
• Full Perimeter Base Rails - The easily removable base rails
provide a solid foundation for the entire unit and protects the
unit during shipment. The rails provide fork lift access from
all sides, and rigging holes are also provided so that an overhead crane can be used to place the units on a roof. On
applications where the unit is placed on a pad, the base will
keep the unit off the pad to deter corrosion. On applications
where height is limited, the base rails may be removed by
removing 2 screws in each corner.
• Controls - Demand defrost curves are pre-loaded into the
demand defrost control for optimized performance based on
unit capabilities.
• More Attractive Appearance - A single-piece top cover
containing a top-discharge outdoor fan arrangement requires
less square footage on installation and provides a wider variety of installations. The one-piece design adds greater water
integrity. Rounded corners with water drip edges add to the
attractive appearance.
• Pressure Switches - A high pressure switch is standard in
all units. When abnormal conditions are sensed through the
pressure switch, the unit will lock out preventing any further
operation until reset or problem is corrected.
• Top Discharge - The top-discharge outdoor fan does not
disrupt neighboring areas or dry out vegetation surrounding
the unit. The warm air from the top mounted fan is blown up
and away from the structure and any landscaping. This
allows compact location on multi-unit applications.
• Outdoor Coil Grille - All models utilize a stamped slotted
design which provides superior impact protection against
small objects during transit and after installation.
• Low Operating Sound Level - The upward air flow carries
the normal operating noise up and away from the living area.
The rigid top panel effectively isolates noise. Isolator
mounted compressor and the rippled fins of the outdoor coil
muffle the normal fan motor and compressor operating
sounds. The unique formed base pan also aids in sound
attenuation with its structural design. This design strategically places embossments in the pan for optimum strength
and rigidity.
• Fan System - All models operate over a wide range of
design conditions with an enhanced ECM indoor fan motor.
These units easily match all types of applications and provide greater on-site flexibility to match comfort requirements.
The cooling speed is factory-set and can be field-adjusted to
a alternate speed. The heating speed is factory set to maintain mid point rise at the units heating input, but can be field
adjusted. This allows maximum comfort conditions.
• Simple Control Circuit - A low voltage gas heat printed circuit board contains a status/diagnostic indicator light. Field
thermostat wiring connects to color coded leads using twist
on wire connectors. Cooling controls use contactor and
relays for simple application and troubleshooting. Mate-nlock plug connectors are used. The electrical control box is
not located in the compressor compartment. The controls are
mounted to allow the separate access panel to be removed
for trouble shooting and maintenance without affecting the
normal system operating pressures. All wiring internal to the
unit is color/number coded.
2
• Protected Compressor - The compressor is internally protected against high pressure and temperature. This is
accomplished by the simultaneous operation of high pressure internal relief valve and a temperature sensor which
protect the compressor if undesirable operating conditions
occur.
• Exclusive Coil Design - Grooved copper tubes and
enhanced aluminum fin construction improves heat transfer
for maximum efficiency and durability for long-lasting durability and efficient operation. Indoor coils use tin-coated copper
tubing with aluminum fins for effective heat transfer.
• Heat Exchangers - Gas heat exchangers use corrosionresistant, stainless-steel tubular construction to provide longlife, trouble-free operation. Gas heat exchangers are offered
with lifetime warranties as standard with registration.
• Post Purge Induced Draft Combustion - Exhausts combustion products from the heat exchanger upon completion
of the heating cycle to prolong the heat exchanger life.
• Spark To Burner Ignition - No pilot assembly required,
which provides more consistent ignition in gas heating mode.
This ignition system is highly reliable, durable and eliminates
nuisance lockouts.
• Multi Port In-shot Burners - No field adjustment is required
to mix the air and gas for natural gas or propane use. These
burners are constructed of high-grade corrosion-resistant,
aluminumized steel.
• Low Maintenance - Long life, permanently lubricated outdoor and indoor fan motor bearings need no annual maintenance, adding greater reliability to the unit. Slide-out blower
assembly can be easily removed for cleaning.
• Easy Service Access - Individual access panels covering
the electrical and gas controls, compressor, and blower section makes servicing easy. Removing this panel will allow
easy removal of the blower assembly for maintenance and
ease of troubleshooting.
• Replacement Parts - The installer requires no special training to replace any of the components of these units and the
number of new components have been reduced to minimize
the inventory of unique parts.
• Loss of Charge Switch - All models include a loss of charge
switch to provide safe shutdown of compressor.
Johnson Controls Unitary Products
5331896-YTG-C-1017
NOMENCLATURE
PHG
4
A
24
050
2
X
1
A
1
2
3
4
5
6
7
8
9
1. Model Family
5. Gas Heating Input BTU/Hr x 1000
PHG - packaged heat pump with gas heat,
050 = 50,000 BTU/Hr. input, blank = electric heat
PCG - packaged A/C with gas heat,
6. Voltage-Phase-Frequency
PCE - packaged A/C with electric heat,
2 = 208/230-1-60, 3=208/230-3-60, 4 = 460-3-60
PHE - packaged heat pump with electric heat
2. Nominal Cooling Efficiency
7. NOx Approval
4 = 14 SEER, 6 = 16 SEER, etc.
X = low-NOx, blank = not low-NOx
3. Cabinet Size
8. Generation Level
A = small 35 x 51, B = large 45 x 51
1 = first generation
4. Nominal Air Conditioning Cooling Capacity
9. Revision Level
24 = Nominal Capacity, etc.
A = original release, B = second release
Examples:
PHG4B421002X1 is a dual fuel, 14 SEER, 3-1/2 ton, large cabinet, single-stage heat, 100,000 BTU gas heat, 230 volt, single phase, low-NOx
model (first generation, first release)
COMPONENT LOCATION
FAN MOTOR
OUTDOOR FAN
COIL GUARD PANEL
OUTDOOR COIL
(Behind Panel)
CONTROL BOARD
BLOWER MOTOR
TXV
TRANSFORMER
HIGH VOLTAGE
CONTACTOR
PRESSURE SWITCH
INDOOR COIL
DRAFT INDUCER BLOWER
GAS HEAT
EXCHANGER
INDOOR BLOWER
COMPRESSOR
GAS VALVE
BURNER
ASSEMBLY
REMOVABLE
BASE RAILS
A0444-001
UNIT LIMITATIONS
Model
PHG6A24
PHG6A30
PHG6B36
PHG6B42
PHG6B48
PHG6B60
Unit Voltage
208/230-1-60
208/230-1-60
208/230-1-60
208/230-1-60
208/230-1-60
208/230-1-60
Johnson Controls Unitary Products
Min
187
187
187
187
187
187
Unit Limitations
Applied Voltage
Max
252
252
252
252
252
252
Outdoor DB Temp
Max (°F)
125
125
125
125
125
125
3
5331896-YTG-C-1017
ACCESSORIES
• Propane Conversion Kit (S1-1NP0703, S1-1NP0704) - Kit
includes burner orifices, gas valve conversion and installation instructions necessary to field convert unit from natural
gas to propane.
• Economizer for Downflow Applications
(S1-2EE04710024, S1-2EE04710124) - Modulating integrated economizer provides simultaneous operation
between the mechanical cooling and economizer operation.
Independent blade design insures proper control and less
than 1% leak rate. Includes hood and mesh bird screen filter
integrated into the hood, dry bulb sensor and relief damper.
Separate field accessories of single enthalpy and dual
enthalpy are also available.
• Economizer for Horizontal Applications
(S1-2EE04710224, S1-2EE04710324) - Modulating integrated economizer provides simultaneous operation
between the mechanical cooling and economizer operation.
Independent blade design insures proper control and less
than 1% leak rate. Includes hood and mesh bird screen filter
integrated into the hood, dry bulb sensor and relief damper.
Separate field accessories of single enthalpy and dual
enthalpy are also available.
• Single/Dual Enthalpy Sensor (S1-HE-6863-0N00WS) Sensor replaces supply air temperature dry bulb sensor
standard in economizer kit. Provides improved economizer
operation by sensing the dry bulb temperature of indoor supply air plus the enthalpy content of the outdoor air.
• Duct/Unit Mount CO2 Kit (S1-2AQ04700924) - Sensor kit
detects CO2 levels automatically and overrides the economizer when CO2 levels rise above the preset limits.
• Wall Mount CO2 Kit (S1-2AQ04701024) - Sensor kit
detects CO2 levels automatically and overrides the economizer when CO2 levels rise above the preset limits.
• Supply Air Temperature Sensor Kit (S1-TE-63616E-2D) Outdoor supply air temperature sensor kit used with economizers.
• Filter/Frame Kit (S1-1FF0602, S1-1FF0601) - Kit contains
the necessary hardware to field install return air filters into
the base unit. The filter rack is suitable for either 1" or 2" filters.
• Filter (S1-02647812000) - Washable 1" filter. Two filters are
required for A base units. Three filters are required for B
base units.
• Motorized Fresh Air Damper
(S1-2MD04705224, S1-2MD04705124) - Designed for duct
mounted side supply/return and unit mounted down supply/
return applications. Damper capable of providing 0% through
50% of outdoor air (field supplied). Closes on power loss,
includes hood and screen assembly.
• Rectangle to Round (Downflow) Adapter
(S1-1AK0108, S1-1AK0109) - Kit includes one supply and
one return air rectangle to round duct adapter. Adapters are
preformed and designed to fit into current downflow duct
openings on the roof curb. Transition is from rectangle to 16"
round for the 1AK0108 kit and from rectangle to 18" round for
the 1AK0109 kit.
• Roof Curbs (S1-1RC0503, S1-1RC0501) - NRCA approved
curbs provide proper fit to base unit for rooftop installations.
Curbs are designed to be assembled through hinge pins in
each corner. Kit also provides seal strip to assure an air tight
seal. These are 8 inch high roof curbs.
• Roof Curbs (S1-1RC0504, S1-1RC0502) - NRCA approved
curbs provide proper fit to base unit for rooftop installations.
Curbs are designed to be assembled through hinge pins in
each corner. Kit also provides seal strip to assure an air tight
seal. These are 14 inch high roof curbs.
• Transition Curb Kits (S1-1TC01*) - Adapter kits to allow
field use of pre-existing installed roof curbs to match PHG6
footprint to Affinity roof curbs, Carrier, Trane, or Goodman
curb footprints. Curb adapters are optional for current generation Carrier replacements but are recommended for previous generation applications. Refer to the PHG6 price pages
for more details.
• Manual Outdoor Damper (S1-1FA0502, S1-1FA0501) Provides 0% through 50% outdoor air capability (field adjustable). Designed for duct mounted side supply/return applications. Includes hood and screen assembly.
• Thermostat (S1-THXU280*) - Compatible thermostat controls are available through accessory sourcing. For optimum
performance, these outdoor units are fully compatible with
the York Hx™ Touchscreen Thermostat (S1-THXU280*)
available through Source1. For more information, see the
thermostat section of the Product Equipment Catalog.
• Wall Thermostat - The units are designed to operate with
standard, 24-volt electronic and electro-mechanical thermostats. All units must operate with a two-stage heat/two-stage
cool heat pump thermostat able to control fossil fuel operation - with or without the economizer.
• Loss of Charge Switch (S1-2LC00024) - Kit provides loss
of charge switch and wiring to provide safe shutdown of compressor.
• Low Ambient Kit (S1-2LA04701024) - Kit provides necessary hardware to convert unit to operate in cooling cycle
down to 0º F. Standard unit operation 45º F.
• Base Rail Hole Cover Kit (S1-1HC0101) - Kit provides necessary hardware to close off openings in base rails to block
off openings, i.e. prevent animal entrance.
* For additional kit numbers refer to the price pages.
• Rectangle to Round (Horizontal) Adapter
(S1-1AK0110, S1-1AK0111) - Kit includes one supply and
one return air rectangle to round duct adapter. Adapters are
preformed and designed to fit over current horizontal duct
openings on the base unit. Transition is from rectangle to 12"
round for the 1AK0110 kit and from rectangle to 14" round for
the 1AK0111 kit.
4
Johnson Controls Unitary Products
5331896-YTG-C-1017
GUIDE SPECIFICATIONS
GENERAL
Units shall be manufactured by Unitary Products in an ISO
9001 certified facility. Package units give you the flexibility and
choices you need in today’s market. These packaged cooling/
heating units are designed for outdoor installation. Only utility
and duct connections are required at the point of installation.
The two-stage gas fired heaters have stainless steel tubular
heat exchangers and spark to burner ignition. They are
available in natural gas with field conversion to propane.
DESCRIPTION
Units shall be factory-assembled, single packaged, Heat
Pumps with Electric Cooling/Gas Heating units, designed for
outdoor installation. They shall have built in, equal size, field
convertible duct connections for supply/return or horizontal
supply/return. The units shall be factory wired, piped, charged
with R-410A Refrigerant and factory tested prior to shipment. All
unit wiring shall be both numbered and color coded. All models
shall be rated in accordance with DOE and AHRI test
procedures for both heating and cooling operation. Units shall
be CSA listed and classified to ANSI Z21.47/CAN/ CSA 2.3
standards and UL 1995/CAN/CSA No. 236-M90 standards.
• Operating Efficiency - All Heat Pump models shall be rated
at 14.0 SEER, 11.0 EER, and 8.0 HSPF for heat pump cooling and heating operation. All models shall be rated at 81.0%
AFUE for gas heating operation.
• Low Operating Sound Level - The upward air flow carries
the normal operating noise up and away from the living area.
The rigid top panel effectively isolates noise. Isolator
mounted compressor and the rippled fins of the outdoor coil
muffle the normal fan motor and compressor operating
sounds. The unique formed base pan also aids in sound
attenuation with its structural design. Sound ratings as tested
under AHRI test procedures shall be less than 77 dbA for all
models.
UNIT CABINET
Unit cabinet shall be a single piece design, with drip edges and
no-seam corners to provide optimum water integrity. Unit shall
have a rigidly mounted outdoor coil guard to provide protection
from objects and personnel after installation. Indoor blower
section shall be insulated with foil-faced or foam insulation,
fastened to prevent insulation from entering the air stream.
Cabinet panels shall be separate, easily removable for
servicing and maintenance. Unit shall be built on a formed,
design base pan, with embossments at critical points to add
strength and rigidity and to aid in minimizing sound. Full
perimeter base rails shall be provided to assure reliable transit
of equipment, overhead rigging, for truck access and proper
sealing on roof curb applications. Base rails shall be easily
removable, when required to lower unit height. Filters shall be
field installed and field provided and be accessible through a
removable access door, sealed airtight. Units vertical discharge
and return duct configuration shall be designed to fit between
standard 24” O.C. beams without modification to building
structure, duct work and base unit. Condensate pan shall be
internally sloped and conform to ASHRAE 62-89 self-draining
standards, with 3/4” NPT female ridged mount connection.
Johnson Controls Unitary Products
• Durable Finish - The cabinet shall be is made of G90 galvanized steel with a powder paint coating for appearance and
protection. The pre-treated galvanized steel shall provide a
better paint-to-steel bond, which resists corrosion and rust
creep. Powder paint finish shall provide superior corrosion
resistance (1000 hour salt spray tested).
• On Site Flexibility - All model sizes shall use a compact
design cabinet in one of two footprints. This provides installer
flexibility for placing the proper capacity unit on curbs or pads
with the smallest footprint after the internal load has been
determined. Field convertible duct connections from side
shot to down shot allows the installer to have greater flexibility with less inventory.
• Attractive Appearance - A single-piece top cover containing
a top-discharge outdoor fan arrangement shall be used
which requires less square footage on installation and provides a wider variety of installations. The one-piece design
adds greater water integrity. Rounded corners with water drip
edges add to the attractive appearance and prevent water
penetration.
• Convertible Airflow Design - The bottom duct openings are
covered when they leave the factory, ready to be used for a
side supply/side return application. If a bottom supply/bottom
return application is desired, simply remove the two panels
from the bottom of the unit and place them in the side supply/
side return duct openings. No panel cutting is required and
no accessory panel is necessary. Convertible airflow design
allows maximum field flexibility and minimum inventory.
• Utility Connections Made Easy - Electric utility access shall
be provided through the bottom or the side of the unit. Utility
connections should be made quickly and with a minimum
amount of field labor. A field supplied and field installed electrical disconnect switch must be installed.
• Easy Service Access - Individual access panels are provided in access to all major components - compressors,
indoor coils, blower, controls/gas heating section, filters, etc.
that makes servicing easy. Removing these panels allow
easy removal of the components such as the blower assembly for maintenance and ease of troubleshooting.
• Top Discharge - The top-discharge outdoor fan does not
disrupt neighboring areas or dry out vegetation surrounding
the unit. The warm air from the top mounted fan is blown up
and away from the structure and any landscaping.
• Outdoor Coil Grille - All models utilize a stamped slotted
design which provides superior impact protection against
small objects during transit and after installation.
Indoor Blower Assembly - Fan shall be direct drive design.
Blower wheel shall be double-inlet type with forward-curved
blades, dynamically balanced to operate smoothly throughout
the entire range of operation. Airflow design shall be constant
air volume. Bearings shall be sealed and permanently
lubricated for longer life and no maintenance. Fan assembly
shall be a slide-out design for easy removal and cleaning.
Indoor blower motors shall be equipped with a high efficiency
brushless DC motor (constant torque) also known as an
enhanced ECM motor.
5
5331896-YTG-C-1017
Outdoor Fan Assembly - The outdoor fan shall be of the
direct-driven propeller type, discharge air vertically, have
aluminum blades riveted to corrosion resistant steel spider
bracket and shall be statically balanced for smooth operation.
The outdoor fan motor shall be totally enclosed with
permanently lubricated bearings and internally protected
against overload conditions.
REFRIGERANT COMPONENTS
• Protected Compressor - The compressor shall be a fully
hermetic type, direct drive compressor, that is internally protected against high pressure and temperature. This is
accomplished by the simultaneous operation of high pressure internal relief valve and a temperature sensor which
protect the compressor if undesirable operating conditions
occur. The hermetic motor shall be suction gas cooled and
have a voltage range of +/- 10% of the unit nameplate voltage. Compressors shall have internal isolation and sound
muffling to minimize vibration and noise, and be externally
isolated on a dedicated, independent mounting.
• Indoor Coils - Indoor coils shall be of the direct expansion,
draw through design and have aluminum plate fins mechanically bonded to seamless internally enhanced tin-coated
copper tubes with all joints brazed.
• Condensate Pan - A corrosion-resistant, long-lasting, watertight pan is positioned below the indoor coil to collect and
drain all condensate, preventing build-up of stagnant condensate. The condensate pan conforms to ASHRAE 62-89
standards (Ventilation for Acceptable Indoor Air Quality).
• Condensate Drain - The 3/4 inch NPT female connection is
rigidly mounted to assure proper fit and leak tight seal.
• Outdoor Coils - Outdoor coils shall have aluminum plate
fins mechanically bonded to seamless internally enhanced
copper tubes with all joints brazed, and be a draw through
design.
Refrigerant Circuit and Refrigerant Safety Components
shall include: Thermal expansion devices (TXVs) shall be
factory mounted and provided, Filter/strainer to eliminate any
foreign matter, reversing valves to control refrigerant flow.
GAS HEATING SECTION
Heat exchanger and exhaust system shall be constructed of
corrosion-resistant materials and shall be designed with
induced draft combustion with post purge logic and redundant
main gas valve. The heat exchanger shall be of the tubular
type, constructed of stainless steel for corrosion resistance and
allowing minimum mixed air entering temperature of 40 °F.
Burners shall be of the in-shot type, constructed of
aluminumized steel. All gas piping shall enter the unit cabinet at
a single location through either the side or bottom, without any
field modifications. An integrated control board shall provide
timed control of indoor fan functioning and burner ignition.
Heating section shall be provided with the following minimum
protection:
a. Primary high-temperature limit switch.
b. Induced draft pressure switch.
c. Flame roll out switch(s) (manual reset).
d. Flame proving controls.
All gas heat models will meet California requirement for
emissions of less than 40 nanograms per Joule (California
requirement on single phase models only).
CONTROLS
• Simple Control Circuit - Field thermostat wiring connects to
color coded leads using twist on wire connections. Cooling
controls use contactor and relays for simple application and
troubleshooting. Mate-n-lock plug connectors are used.
Heating controls consist of direct spark ignition control and
demand defrost heat pump control. The electrical control box
is not located in the compressor compartment. The controls
are mounted to allow the separate access panel to be
removed for trouble shooting and maintenance without
affecting the normal system operating pressures. All wiring
internal to the unit is color/number coded.
• Pressure Switches - A high pressure switch is standard in
all units. When abnormal conditions are sensed through the
pressure switch, the unit will lock out preventing any further
operation until reset or problem is corrected.
• Factory Testing - Installation time and costs are reduced by
easy power and control wiring connections. All units are
completely wired, charged with R-410A and tested prior to
shipment. Test stations using a state-of-the-art computerized
process system shall be used to insure product quality.
Refrigerant charge and component part numbers are verified
via computer bar code scans during assembly. Vital run test
statistics such as system pressure, motor currents, air velocity and temperature, unit vibration, and gas system safeties
are monitored and recorded by the system to insure unit performance. This data could be provided by serial number
tracking if requested.
Spark To Burner Ignition - No pilot assembly required, which
provides more consistent ignition in gas heating mode. This
ignition is highly reliable, durable and eliminates nuisance
lockouts.
6
Johnson Controls Unitary Products
5331896-YTG-C-1017
PHYSICAL DATA
MODELS: PHG6A24
NOMINAL TONNAGE:
2.0
COMPONENT
AHRI Cooling Performance
Gross Capacity @ AHRI A point (MBH)
AHRI net capacity (MBH)
EER
SEER
Nominal CFM
System power (kW)
Refrigerant type
Refrigerant charge (lb-oz)
AHRI Heat Pump Heating Performance
47 Capacity Rating (MBH)
System Power (kW/COP)
17 F Capacity Rating (MBH)
HSPF (BTU/Watts-hr.)
AHRI Gas Heat Performance
Heating model
Heat input - High Fire (kBTU)
Heat output - High Fire (kBTU)
Heat input - Low Fire (kBTU)
Heat output - Low Fire (kBTU)
AFUE%
No. burners
No. stages
Temperature Rise Range - High Fire (°
F)
Temperature Rise Range - Low Fire (°
F)
Max. Static Pressure w.c.
Max. Outlet Air Temp. (°
F)
Gas piping connection (inch)
Dimensions (inches)
Length
Width
Height
Operating WT. (lbs.)
Compressors
Type
Stage
Outdoor Coil Data
Face area (Sq. Ft.)
Rows
Fins per inch
Tube diameter
Circuitry Type
Refrigerant Control
Indoor Coil Data
Face area (Sq. Ft.)
Rows
Fins per inch
Tube diameter
Circuitry Type
Refrigerant control
Outdoor Fan Data
Fan diameter (inch)
Type
Drive type
No. speeds
Motor HP each
RPM
Nominal total CFM
Table continued on next page.
Johnson Controls Unitary Products
PHG6A30
2.5
PHG6B36
3.0
PHG6B42
3.5
PHG6B48
4.0
PHG6B60
5.0
23.7
23.4
12.5
16.0
800
1.8
R410A
9-0
29.5
29.0
12.5
16.0
1000
2.3
R410A
10-0
37.0
36.4
12.5
16.0
1200
2.8
R410A
12-12
43.2
42.5
12.5
16.0
1400
3.3
R410A
11-8
49.2
47.5
12.5
16.0
1600
3.7
R410A
15-0
59.2
57.5
12.5
16.0
1800
4.5
R410A
15-8
22.2
3.7
12.0
8.2
27.2
3.6
16.8
8.2
33.8
3.6
19.0
8.2
38.0
3.6
22.0
8.2
45.5
3.6
28.0
8.2
56.0
3.6
31.7
8.2
50
75
50.0
75.0
40
60
33.0
49.0
26
39
81.0
81.0
2
3
2
2
40-70
20-50
0.5
180
1/2
50
75
50.0
75.0
40
60
33.0
49.0
26
39
81.0
81.0
2
3
2
2
40-70
20-50
0.5
180
1/2
65
100
65.0 100.0
52
80
43.0
65.0
34
53
81.0
81.0
2
3
2
2
40-70
25-55
0.5
180
1/2
65
100
65.0 100.0
52
80
43.0
65.0
34
53
81.0
81.0
2
3
2
2
40-70
25-55
0.5
180
1/2
65
100 125
65
100 125
65.0 100.0 125.0 65.0 100.0 125.0
52
80
101
52
80
101
43.0 65.0 82.0 43.0 65.0 82.0
34
53
66
34
53
66
81.0 81.0 81.0 81.0 81.0 81.0
2
3
4
2
3
4
2
2
2
2
2
2
40-70
40-70
25-55
25-55
0.5
0.5
180
180
1/2
1/2
51-1/4
35-3/4
47
394
404
51-1/4
35-3/4
47
449
453
51-1/4
45-3/4
49
498
505
51-1/4
45-3/4
49
532
534
51-1/4
45-3/4
53
551 559 564
51-1/4
45-3/4
55
577 581 588
Scroll
2
Scroll
2
Scroll
2
Scroll
2
Scroll
2
Scroll
2
15.1
2
22
3/8
Interlaced
TXV
16.9
2
22
3/8
Interlaced
TXV
19.5
2
22
3/8
Interlaced
TXV
19.5
2
22
3/8
Interlaced
TXV
23.8
2
22
3/8
Interlaced
TXV
25.9
2
22
3/8
Interlaced
TXV
4.6
3
16
3/8
Interlaced
TXV
4.6
3
16
3/8
Interlaced
TXV
6.3
3
16
3/8
Interlaced
TXV
6.3
3
16
3/8
Interlaced
TXV
6.3
3
16
3/8
Interlaced
TXV
6.3
4
16
3/8
Interlaced
TXV
24
Prop
Direct
1
1/8
790
2300
24
Prop
Direct
1
1/8
790
2300
26
Prop
Direct
1
1/3
850
4000
26
Prop
Direct
1
1/3
850
4000
26
Prop
Direct
1
1/3
850
4200
26
Prop
Direct
1
1/3
850
4200
7
5331896-YTG-C-1017
PHYSICAL DATA (Continued)
MODELS:
NOMINAL TONNAGE:
COMPONENT
Direct Drive Indoor Fan Data
Fan Size (Inch)
Type
Motor HP each
RPM
Frame size
Filters
Filter Size
Quantity - Size
8
PHG6A24
2.0
PHG6A30
2.5
PHG6B36
3.0
PHG6B42
3.5
PHG6B48
4.0
PHG6B60
5.0
11 x 8
Centrifugal
1/3
1/2
1200 Max
48
11 x 8
Centrifugal
1/3
1/2
1200 Max
48
11 x 10
Centrifugal
1/2
3/4
1200 Max
48
11 x 10
Centrifugal
3/4
1200 Max
48
11 x 10
Centrifugal
3/4
1200 Max
48
11 x 10
Centrifugal
1
1200 Max
48
A
A
B
B
B
B
Field-supplied external filters must be sized so as not to exceed 300 fpm air velocity through disposable
filters. For internal filter use, a filter rack kit is available. Consult the instructions supplied with that kit for
replacement filter sizes. Filter sizes: A=20x10 (2 each), B=20x10 (3 each).
Johnson Controls Unitary Products
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 2 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6A24
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
16.2 19.4
55 / 45
S.C.
16.1 15.0
K.W.
0.72 0.71
T.C.
15.3 17.9
65 / 55
S.C.
15.3 14.1
K.W.
0.82 0.81
T.C.
14.5 16.5
75 / 63
S.C.
14.4 13.3
K.W.
0.92 0.91
T.C.
13.1 14.9
85 / 69
S.C.
13.1 12.6
K.W.
1.04 1.04
T.C.
11.8 13.3
95 / 75
S.C.
11.8 11.9
K.W.
1.17 1.17
T.C.
10.3 11.1
105 / 83
S.C.
10.3 10.2
K.W.
1.36 1.36
T.C.
8.9
9.1
115 / 89
S.C.
8.9
8.6
K.W.
1.53 1.53
T.C.
7.5
7.0
125 / 95
S.C.
7.5
7.0
K.W.
1.71 1.71
375
75
62
19.6
12.9
0.71
17.8
12.1
0.80
16.1
11.3
0.90
14.6
10.5
1.03
13.1
9.7
1.17
11.0
8.6
1.35
9.1
7.5
1.53
7.1
6.3
1.70
80
67
22.2
13.3
0.69
20.6
12.5
0.79
19.1
11.7
0.89
17.2
10.9
1.02
15.4
10.2
1.15
13.1
9.0
1.34
10.8
8.0
1.51
8.6
6.9
1.69
80
72
23.2
10.7
0.68
22.3
10.2
0.77
21.3
9.7
0.87
19.6
8.9
1.00
18.0
8.1
1.13
15.6
7.2
1.32
13.3
6.3
1.50
10.9
5.4
1.68
80
57
18.9
18.8
0.65
17.6
17.5
0.75
16.2
16.2
0.84
15.0
15.0
0.97
13.8
13.8
1.10
11.9
11.9
1.28
10.1
10.1
1.46
8.3
8.3
1.64
80
62
22.2
18.7
0.64
20.5
17.9
0.74
18.8
17.1
0.84
16.8
15.6
0.97
14.9
14.2
1.11
12.2
11.8
1.29
9.6
9.4
1.46
7.0
7.0
1.64
575
75
62
22.2
16.0
0.64
20.3
15.2
0.74
18.4
14.3
0.83
16.5
13.3
0.97
14.5
12.4
1.11
12.1
10.6
1.29
9.8
8.8
1.47
7.5
7.1
1.64
80
67
24.4
16.0
0.63
22.8
15.2
0.73
21.2
14.5
0.82
19.0
13.6
0.96
16.9
12.8
1.09
14.1
11.0
1.27
11.3
9.4
1.45
8.5
7.7
1.63
80
72
26.5
12.9
0.62
25.1
12.2
0.71
23.6
11.6
0.81
21.7
10.8
0.94
19.8
10.0
1.07
16.9
8.8
1.26
14.1
7.7
1.44
11.3
6.6
1.62
80
57
21.5
21.5
0.58
19.8
19.8
0.68
18.0
18.0
0.77
16.9
16.9
0.90
15.8
15.8
1.03
13.5
13.5
1.21
11.3
11.2
1.39
9.0
9.0
1.57
80
62
25.0
22.4
0.58
23.0
21.6
0.68
21.0
20.9
0.77
18.8
18.7
0.90
16.5
16.5
1.04
13.3
13.3
1.22
10.2
10.2
1.39
7.1
7.1
1.56
775
75
62
24.8
19.1
0.58
22.8
18.2
0.68
20.8
17.2
0.77
18.4
16.1
0.91
16.0
15.0
1.05
13.2
12.6
1.23
10.5
10.2
1.41
7.9
7.9
1.58
80
67
26.6
18.6
0.57
24.9
18.0
0.67
23.3
17.4
0.76
20.9
16.3
0.89
18.4
15.3
1.03
15.1
13.0
1.21
11.8
10.8
1.39
8.5
8.5
1.57
80
72
29.8
15.0
0.56
27.9
14.2
0.66
25.9
13.4
0.75
23.8
12.6
0.88
21.7
11.8
1.01
18.3
10.5
1.19
15.0
9.2
1.37
11.7
7.9
1.55
80
62
30.2
24.4
1.00
27.6
23.5
1.12
25.1
22.6
1.24
23.1
21.1
1.39
21.0
19.6
1.54
18.0
17.0
1.76
15.1
14.5
1.97
12.1
12.0
2.18
750
75
62
28.9
20.8
1.00
26.9
19.8
1.12
25.0
18.9
1.23
22.7
17.7
1.38
20.5
16.6
1.53
17.6
14.7
1.75
14.7
12.8
1.97
11.8
10.9
2.18
80
67
31.5
20.9
1.02
30.0
20.2
1.14
28.6
19.5
1.25
26.1
18.3
1.41
23.6
17.1
1.56
20.5
15.6
1.78
17.4
14.1
1.99
14.4
12.7
2.20
80
72
34.8
16.6
1.02
33.6
15.9
1.14
32.3
15.2
1.26
30.0
14.2
1.42
27.8
13.2
1.58
24.3
11.9
1.79
21.0
10.8
2.00
17.7
9.6
2.21
80
57
26.5
26.3
0.98
25.9
25.8
1.10
25.3
25.2
1.22
23.3
23.2
1.37
21.3
21.2
1.52
18.9
18.8
1.74
16.6
16.5
1.96
14.3
14.2
2.17
80
62
32.1
27.7
0.98
29.3
27.0
1.10
26.6
26.2
1.22
24.5
24.2
1.37
22.3
22.2
1.52
18.9
18.8
1.74
15.5
15.5
1.95
12.2
12.1
2.16
950
75
62
31.4
23.5
0.98
29.2
22.7
1.10
27.0
21.8
1.21
24.4
20.4
1.36
21.7
19.0
1.51
18.1
16.3
1.73
14.6
13.6
1.94
11.0
11.0
2.15
80
67
34.4
23.8
0.99
32.6
23.0
1.11
30.8
22.1
1.23
28.1
20.9
1.38
25.4
19.7
1.53
21.6
17.8
1.75
18.0
16.0
1.96
14.3
14.2
2.17
80
72
37.4
18.2
0.99
36.3
17.7
1.12
35.2
17.1
1.24
32.6
15.8
1.40
30.0
14.5
1.55
25.9
13.3
1.77
22.0
12.0
1.98
18.0
10.8
2.18
COOLING PERFORMANCE DATA - 2 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6A24
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
23.7 28.2
55 / 45
S.C.
23.5 21.0
K.W.
1.02 1.03
T.C.
22.1 25.9
65 / 55
S.C.
22.0 20.0
K.W.
1.13 1.15
T.C.
20.5 23.6
75 / 63
S.C.
20.4 18.9
K.W.
1.25 1.27
T.C.
19.1 21.7
85 / 69
S.C.
19.0 18.0
K.W.
1.40 1.42
T.C.
17.6 19.8
95 / 75
S.C.
17.5 17.0
K.W.
1.56 1.57
T.C.
16.1 17.1
105 / 83
S.C.
16.0 15.3
K.W.
1.78 1.78
T.C.
14.6 14.6
115 / 89
S.C.
14.5 13.6
K.W.
1.99 1.99
T.C.
13.1 12.0
125 / 95
S.C.
13.0 12.0
K.W.
2.21 2.20
Johnson Controls Unitary Products
550
75
62
26.4
18.1
1.03
24.7
17.0
1.14
22.9
16.0
1.26
21.1
15.1
1.41
19.3
14.2
1.56
17.0
13.1
1.78
14.8
12.0
1.99
12.6
10.9
2.21
80
67
28.6
18.1
1.05
27.5
17.4
1.16
26.3
16.8
1.28
24.1
15.6
1.43
21.9
14.5
1.59
19.3
13.3
1.80
16.9
12.2
2.01
14.5
11.1
2.22
80
72
32.2
15.0
1.05
30.9
14.2
1.17
29.5
13.3
1.29
27.5
12.5
1.44
25.6
11.8
1.60
22.8
10.6
1.81
20.0
9.5
2.02
17.3
8.4
2.23
80
57
25.1
24.9
1.00
24.0
23.9
1.12
22.9
22.8
1.23
21.2
21.1
1.39
19.5
19.4
1.54
17.5
17.4
1.76
15.6
15.5
1.98
13.7
13.6
2.19
9
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 2.5 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6A30
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
22.7 25.9
55 / 45
S.C.
21.8 19.8
K.W.
1.05 1.03
T.C.
21.2 23.8
65 / 55
S.C.
20.4 19.1
K.W.
1.20 1.18
T.C.
19.8 21.7
75 / 63
S.C.
19.0 18.4
K.W.
1.35 1.34
T.C.
18.0 19.6
85 / 69
S.C.
17.4 17.4
K.W.
1.55 1.54
T.C.
16.3 17.6
95 / 75
S.C.
15.7 16.4
K.W.
1.75 1.75
T.C.
14.6 15.0
105 / 83
S.C.
14.0 14.1
K.W.
2.02 2.02
T.C.
13.0 12.5
115 / 89
S.C.
12.5 11.8
K.W.
2.29 2.28
T.C.
11.3
9.9
125 / 95
S.C.
10.9
9.6
K.W.
2.55 2.54
550
75
62
25.8
17.2
1.04
24.0
16.3
1.19
22.2
15.4
1.34
19.9
14.2
1.54
17.7
13.1
1.75
15.1
12.0
2.02
12.6
10.9
2.28
10.1
9.8
2.54
80
67
29.0
17.4
1.02
26.9
16.5
1.17
24.9
15.6
1.32
22.8
14.5
1.53
20.7
13.5
1.73
18.0
12.3
2.00
15.3
11.1
2.27
12.6
10.0
2.53
80
72
32.4
14.2
1.02
30.3
13.5
1.17
28.3
12.8
1.31
26.1
11.7
1.51
24.0
10.6
1.70
21.1
9.4
1.97
18.3
8.3
2.24
15.4
7.2
2.51
80
57
25.4
24.4
1.04
23.7
22.8
1.19
22.0
21.1
1.33
20.0
19.3
1.53
18.1
17.4
1.73
15.9
15.3
2.01
13.8
13.3
2.27
11.7
11.3
2.54
80
62
27.8
23.5
1.03
25.4
22.2
1.18
23.0
20.9
1.33
20.7
19.2
1.53
18.4
17.5
1.73
15.4
14.7
2.00
12.5
11.9
2.26
9.5
9.2
2.53
750
75
62
28.6
20.0
1.04
26.2
19.0
1.18
23.8
18.0
1.33
21.2
16.8
1.53
18.5
15.6
1.74
15.4
13.3
2.01
12.3
11.1
2.27
9.3
8.9
2.53
80
67
32.0
20.3
1.02
29.4
19.2
1.17
26.9
18.1
1.32
24.5
17.0
1.52
22.2
16.0
1.72
18.6
14.0
1.99
15.1
12.1
2.26
11.7
10.1
2.53
80
72
35.3
16.1
1.01
32.9
15.3
1.16
30.4
14.5
1.30
28.0
13.3
1.50
25.6
12.0
1.70
21.9
10.7
1.97
18.4
9.4
2.24
14.8
8.2
2.50
80
57
28.1
27.0
1.03
26.1
25.1
1.17
24.2
23.3
1.32
22.0
21.2
1.52
19.8
19.1
1.72
17.2
16.6
1.99
14.7
14.1
2.26
12.1
11.6
2.53
80
62
29.7
27.1
1.03
27.0
25.2
1.17
24.3
23.4
1.32
21.8
21.0
1.52
19.3
18.6
1.72
15.9
15.2
1.99
12.5
12.0
2.25
9.1
8.8
2.51
950
75
62
31.3
22.8
1.03
28.4
21.7
1.17
25.5
20.7
1.32
22.4
19.4
1.53
19.4
18.1
1.73
15.7
14.7
2.00
12.0
11.4
2.26
8.4
8.1
2.53
80
67
35.0
23.2
1.02
31.9
21.9
1.16
28.8
20.6
1.31
26.3
19.5
1.51
23.7
18.5
1.71
19.3
15.7
1.99
15.0
13.0
2.26
10.7
10.3
2.53
80
72
38.2
17.9
1.00
35.4
17.0
1.15
32.6
16.2
1.30
29.9
14.9
1.50
27.2
13.5
1.69
22.8
12.0
1.97
18.5
10.5
2.24
14.2
9.1
2.50
80
62
35.2
28.9
1.67
33.2
28.1
1.85
31.1
27.2
2.03
28.4
25.7
2.26
25.7
24.1
2.48
22.9
21.9
2.81
20.3
19.8
3.12
17.7
17.6
3.44
950
75
62
35.1
24.7
1.67
33.1
23.7
1.85
31.0
22.7
2.02
28.5
21.4
2.25
26.0
20.0
2.48
23.1
18.3
2.80
20.4
16.7
3.12
17.6
15.1
3.43
80
67
37.6
24.3
1.69
36.3
23.5
1.87
35.1
22.7
2.06
32.4
21.4
2.28
29.7
20.0
2.51
26.4
18.4
2.83
23.1
16.9
3.14
19.9
15.4
3.45
80
72
39.5
19.1
1.69
38.5
18.4
1.88
37.5
17.8
2.07
34.6
16.5
2.30
31.6
15.3
2.53
28.8
13.8
2.85
26.0
12.4
3.17
23.3
10.9
3.48
80
57
32.9
32.8
1.76
30.8
30.7
1.93
28.7
28.7
2.11
26.4
26.3
2.34
24.0
23.9
2.57
21.0
20.9
2.90
18.0
18.0
3.21
15.1
15.1
3.53
80
62
37.5
32.0
1.76
35.1
31.1
1.94
32.6
30.3
2.12
29.7
28.5
2.34
26.8
26.7
2.56
23.9
23.8
2.89
21.0
20.9
3.21
18.1
18.1
3.53
1150
75
62
37.0
26.9
1.76
34.8
26.0
1.93
32.6
25.1
2.11
29.8
23.7
2.34
26.9
22.3
2.56
23.8
20.3
2.89
20.8
18.5
3.20
17.8
16.6
3.51
80
67
39.4
26.3
1.77
37.9
25.7
1.96
36.4
25.1
2.15
33.5
23.6
2.37
30.6
22.1
2.60
27.0
20.4
2.92
23.5
18.7
3.23
20.0
17.1
3.54
80
72
41.1
20.2
1.77
39.9
19.5
1.96
38.8
18.9
2.16
35.5
17.6
2.38
32.2
16.3
2.61
29.2
14.7
2.93
26.3
13.1
3.25
23.4
11.5
3.56
COOLING PERFORMANCE DATA - 2.5 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6A30
ID CFM
CONDENSER
IDDB
80
80
ENTERING AIR
TEMPERATURE
IDWB
57
62
T.C.
28.5 32.9
55 / 45
S.C.
28.4 25.9
K.W.
1.57 1.59
T.C.
27.0 31.2
65 / 55
S.C.
26.9 25.0
K.W.
1.74 1.77
T.C.
25.5 29.6
75 / 63
S.C.
25.4 24.2
K.W.
1.92 1.95
T.C.
23.8 27.1
85 / 69
S.C.
23.7 22.8
K.W.
2.15 2.17
T.C.
22.1 24.5
95 / 75
S.C.
22.0 21.5
K.W.
2.39 2.40
T.C.
19.8 22.0
105 / 83
S.C.
19.8 20.0
K.W.
2.71 2.72
T.C.
17.7 19.6
115 / 89
S.C.
17.6 18.6
K.W.
3.03 3.03
T.C.
15.5 17.2
125 / 95
S.C.
15.4 17.2
K.W.
3.35 3.35
10
750
75
62
33.2
22.4
1.59
31.3
21.4
1.76
29.4
20.4
1.93
27.2
19.1
2.17
25.1
17.7
2.40
22.5
16.4
2.72
19.9
15.0
3.03
17.3
13.7
3.35
80
67
35.9
22.3
1.61
34.8
21.3
1.79
33.7
20.4
1.97
31.2
19.2
2.20
28.8
17.9
2.42
25.7
16.5
2.74
22.7
15.1
3.06
19.8
13.7
3.37
80
72
38.0
17.9
1.61
37.1
17.3
1.80
36.3
16.7
1.98
33.7
15.5
2.21
31.1
14.3
2.45
28.4
12.9
2.77
25.8
11.7
3.09
23.2
10.4
3.41
80
57
30.7
30.6
1.66
28.9
28.8
1.84
27.1
27.0
2.02
25.1
25.0
2.25
23.0
23.0
2.48
20.4
20.3
2.81
17.8
17.8
3.12
15.3
15.2
3.44
Johnson Controls Unitary Products
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 3 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B36
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
25.7 28.0
55 / 45
S.C.
24.3 21.9
K.W.
1.12 1.10
T.C.
24.2 26.2
65 / 55
S.C.
23.3 21.0
K.W.
1.28 1.26
T.C.
22.6 24.5
75 / 63
S.C.
22.3 20.2
K.W.
1.44 1.41
T.C.
21.2 22.9
85 / 69
S.C.
21.0 19.3
K.W.
1.64 1.63
T.C.
19.7 21.3
95 / 75
S.C.
19.7 18.5
K.W.
1.85 1.84
T.C.
17.5 19.3
105 / 83
S.C.
17.5 17.1
K.W.
2.13 2.12
T.C.
15.5 17.3
115 / 89
S.C.
15.5 15.9
K.W.
2.40 2.39
T.C.
13.4 15.3
125 / 95
S.C.
13.4 14.6
K.W.
2.68 2.67
600
75
62
28.1
19.0
1.11
26.7
18.1
1.26
25.3
17.3
1.41
23.4
16.4
1.62
21.6
15.5
1.83
19.2
14.3
2.12
16.9
13.1
2.40
14.6
12.0
2.68
80
67
31.4
19.0
1.08
29.4
18.1
1.24
27.5
17.3
1.39
26.0
16.5
1.60
24.6
15.7
1.80
22.1
14.6
2.09
19.8
13.5
2.38
17.4
12.4
2.66
80
72
33.6
15.6
1.06
32.6
14.8
1.21
31.7
14.1
1.36
30.1
13.4
1.57
28.5
12.8
1.77
25.7
11.7
2.07
23.0
10.7
2.35
20.3
9.6
2.64
80
57
29.0
27.6
1.05
27.0
26.2
1.21
25.0
24.8
1.37
23.5
23.4
1.58
22.0
22.0
1.78
19.5
19.5
2.07
17.0
17.0
2.34
14.5
14.5
2.62
80
62
30.2
25.8
1.04
28.5
25.1
1.20
26.8
24.4
1.36
25.0
23.0
1.57
23.1
21.6
1.78
20.8
19.7
2.06
18.6
17.9
2.34
16.4
16.1
2.61
800
75
62
30.5
21.8
1.05
28.9
21.1
1.20
27.3
20.3
1.36
25.3
19.4
1.56
23.3
18.4
1.77
20.7
17.0
2.06
18.2
15.6
2.35
15.7
14.3
2.63
80
67
33.9
21.8
1.02
32.0
21.1
1.18
30.2
20.4
1.34
28.4
19.5
1.54
26.5
18.7
1.75
23.7
17.4
2.04
21.0
16.1
2.33
18.3
14.9
2.61
80
72
36.3
17.4
1.01
35.1
16.7
1.16
33.9
16.1
1.31
31.9
15.3
1.52
30.0
14.5
1.72
27.2
13.4
2.01
24.5
12.3
2.30
21.7
11.2
2.58
80
57
32.3
30.9
0.99
29.8
29.1
1.15
27.3
27.3
1.31
25.8
25.8
1.51
24.3
24.3
1.72
21.4
21.4
2.00
18.6
18.5
2.28
15.7
15.7
2.56
80
62
32.4
29.7
0.99
30.8
29.2
1.14
29.2
28.7
1.30
27.0
26.8
1.51
24.9
24.8
1.72
22.4
22.4
2.00
19.9
19.9
2.28
17.5
17.5
2.56
1000
75
62
33.0
24.7
1.00
31.2
24.0
1.15
29.3
23.3
1.30
27.2
22.3
1.51
25.1
21.3
1.72
22.3
19.7
2.01
19.5
18.2
2.30
16.8
16.6
2.58
80
67
36.3
24.6
0.97
34.7
24.0
1.13
33.0
23.4
1.28
30.7
22.6
1.49
28.5
21.7
1.70
25.3
20.2
1.99
22.2
18.8
2.27
19.1
17.4
2.56
80
72
39.0
19.1
0.96
37.5
18.6
1.11
36.0
18.1
1.26
33.8
17.2
1.46
31.6
16.3
1.66
28.7
15.1
1.96
25.9
13.9
2.24
23.1
12.8
2.53
80
62
42.7
35.1
1.93
40.3
34.3
2.11
38.0
33.5
2.29
35.5
32.1
2.53
33.0
30.8
2.76
30.0
28.4
3.12
27.0
26.0
3.47
24.1
23.7
3.82
1200
75
62
41.6
29.6
1.92
36.5
28.3
2.49
31.4
27.0
3.05
32.0
26.2
2.91
32.6
25.4
2.76
29.4
23.7
3.11
26.3
22.2
3.46
23.2
20.6
3.81
80
67
45.5
29.5
1.96
43.4
28.7
2.14
41.4
27.9
2.32
38.7
26.7
2.56
35.9
25.5
2.79
32.4
24.0
3.14
29.0
22.6
3.49
25.7
21.1
3.83
80
72
48.3
12.7
1.97
46.5
17.6
2.16
44.6
22.6
2.34
42.5
21.1
2.57
40.3
19.6
2.81
36.9
18.1
3.16
33.6
16.7
3.51
30.3
15.3
3.85
80
57
43.7
40.1
2.00
42.0
38.5
2.19
40.3
36.9
2.37
38.2
34.9
2.60
36.1
32.9
2.84
32.6
30.3
3.20
29.2
27.8
3.55
25.8
25.4
3.90
80
62
44.4
38.3
2.00
42.1
37.5
2.19
39.7
36.8
2.37
37.0
35.3
2.60
34.2
33.7
2.84
31.1
30.6
3.20
28.0
27.6
3.55
24.9
24.5
3.90
1400
75
62
43.4
32.1
2.00
41.1
31.3
2.18
38.8
30.6
2.36
36.2
29.2
2.59
33.6
27.7
2.83
30.1
26.0
3.19
26.7
24.3
3.53
23.4
22.5
3.87
80
67
47.9
31.6
2.03
45.4
31.0
2.22
42.9
30.4
2.40
40.0
29.1
2.63
37.1
27.8
2.86
33.4
26.3
3.21
29.7
24.9
3.56
26.1
23.4
3.90
80
72
50.1
24.7
2.05
48.8
23.9
2.23
47.4
23.0
2.42
44.7
21.9
2.65
42.0
20.8
2.88
38.2
19.3
3.24
34.5
17.9
3.58
30.8
16.4
3.92
COOLING PERFORMANCE DATA - 3 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B36
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
38.4 40.9
55 / 45
S.C.
35.6 32.0
K.W.
1.83 1.86
T.C.
37.0 38.6
65 / 55
S.C.
34.2 31.1
K.W.
2.01 2.03
T.C.
35.5 36.2
75 / 63
S.C.
32.9 30.2
K.W.
2.19 2.21
T.C.
33.8 34.0
85 / 69
S.C.
31.2 29.0
K.W.
2.43 2.45
T.C.
32.1 31.8
95 / 75
S.C.
29.5 27.9
K.W.
2.67 2.68
T.C.
29.3 28.9
105 / 83
S.C.
27.4 26.2
K.W.
3.04 3.04
T.C.
26.7 26.1
115 / 89
S.C.
25.4 24.5
K.W.
3.39 3.39
T.C.
24.0 23.2
125 / 95
S.C.
23.4 22.9
K.W.
3.75 3.74
Johnson Controls Unitary Products
1000
75
62
39.9
27.1
1.85
31.9
25.3
2.80
24.0
23.4
3.75
27.8
23.2
3.22
31.6
23.0
2.68
28.7
21.5
3.04
25.9
20.1
3.39
23.0
18.7
3.74
80
67
43.0
27.4
1.88
41.5
26.4
2.06
40.0
25.4
2.24
37.3
24.3
2.48
34.7
23.2
2.72
31.5
21.7
3.07
28.4
20.3
3.42
25.3
18.9
3.76
80
72
46.5
0.6
1.90
44.1
11.4
2.08
41.8
22.2
2.25
40.2
20.3
2.49
38.6
18.3
2.73
35.6
16.9
3.09
32.7
15.6
3.43
29.8
14.3
3.78
80
57
41.0
37.9
1.92
39.5
36.4
2.10
37.9
34.9
2.28
36.0
33.0
2.52
34.1
31.2
2.76
31.0
28.9
3.12
27.9
26.6
3.47
24.9
24.4
3.82
11
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 3.5 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B42
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
35.2 37.9
55 / 45
S.C.
34.3 29.2
K.W.
1.26 1.23
T.C.
33.8 35.6
65 / 55
S.C.
32.6 28.0
K.W.
1.44 1.41
T.C.
32.5 33.4
75 / 63
S.C.
31.0 26.9
K.W.
1.62 1.60
T.C.
30.9 31.3
85 / 69
S.C.
29.4 25.9
K.W.
1.86 1.84
T.C.
29.4 29.1
95 / 75
S.C.
27.8 25.0
K.W.
2.10 2.08
T.C.
26.9 25.6
105 / 83
S.C.
25.0 22.8
K.W.
2.42 2.40
T.C.
24.6 22.1
115 / 89
S.C.
22.4 20.6
K.W.
2.73 2.71
T.C.
22.2 18.6
125 / 95
S.C.
19.8 18.4
K.W.
3.04 3.03
760
75
62
38.9
25.9
1.24
36.7
24.5
1.42
34.5
23.2
1.60
31.8
21.7
1.85
29.0
20.2
2.10
25.3
18.4
2.41
21.6
16.6
2.71
17.9
14.9
3.02
80
67
41.9
25.1
1.22
40.2
24.6
1.40
38.4
24.1
1.59
35.9
22.6
1.83
33.3
21.1
2.07
29.3
19.1
2.39
25.5
17.2
2.70
21.6
15.3
3.02
80
72
45.5
21.0
1.22
43.9
20.1
1.40
42.2
19.2
1.58
39.2
17.9
1.81
36.1
16.7
2.03
32.2
14.9
2.35
28.4
13.2
2.66
24.7
11.6
2.97
80
57
37.7
37.1
1.26
36.2
35.4
1.44
34.7
33.7
1.62
32.9
31.7
1.86
31.0
29.8
2.11
28.4
26.9
2.42
25.9
24.1
2.73
23.4
21.3
3.03
80
62
39.8
32.7
1.24
37.6
31.7
1.42
35.5
30.8
1.61
33.1
29.6
1.85
30.7
28.5
2.09
26.8
25.3
2.41
23.1
22.2
2.72
19.3
19.1
3.02
960
75
62
41.7
29.0
1.25
39.4
27.9
1.43
37.1
26.7
1.61
34.1
25.2
1.86
31.0
23.8
2.11
26.8
21.4
2.42
22.6
19.1
2.72
18.5
16.9
3.03
80
67
43.7
27.5
1.23
42.2
27.3
1.41
40.7
27.0
1.60
38.1
25.6
1.84
35.4
24.2
2.08
30.7
22.0
2.40
26.1
20.0
2.71
21.6
17.9
3.02
80
72
46.5
22.3
1.23
45.5
21.6
1.41
44.4
20.9
1.59
40.8
19.5
1.82
37.2
18.1
2.05
32.9
16.3
2.37
28.7
14.6
2.68
24.5
12.8
2.98
80
57
40.2
39.8
1.25
38.6
38.2
1.44
37.0
36.5
1.62
34.8
34.1
1.86
32.6
31.7
2.11
29.9
28.7
2.42
27.3
25.7
2.73
24.6
22.7
3.03
80
62
41.7
36.2
1.24
39.6
35.4
1.43
37.6
34.6
1.62
34.9
33.3
1.86
32.3
32.0
2.10
28.1
27.8
2.41
24.1
23.9
2.72
20.0
19.9
3.02
1160
75
62
44.5
32.2
1.25
42.1
31.2
1.44
39.6
30.2
1.63
36.3
28.7
1.87
33.0
27.3
2.11
28.3
24.4
2.43
23.7
21.6
2.73
19.0
18.9
3.04
80
67
45.6
29.9
1.24
44.3
29.9
1.43
43.0
30.0
1.61
40.3
28.6
1.85
37.5
27.3
2.09
32.1
25.0
2.41
26.8
22.7
2.72
21.5
20.4
3.03
80
72
47.6
23.5
1.24
47.0
23.0
1.42
46.5
22.5
1.60
42.4
21.0
1.83
38.3
19.5
2.07
33.5
17.7
2.39
28.9
15.9
2.69
24.3
14.1
3.00
80
62
45.2
37.4
2.38
43.7
37.2
2.63
42.3
36.9
2.87
39.5
35.6
3.19
36.6
34.4
3.50
32.7
31.2
3.96
29.0
28.2
4.40
25.2
25.2
4.84
1290
75
62
46.1
33.0
2.38
44.3
32.1
2.62
42.4
31.1
2.87
39.1
29.6
3.18
35.9
28.1
3.50
31.9
26.0
3.95
28.0
23.9
4.39
24.1
21.8
4.82
80
67
48.5
31.0
2.38
48.1
30.9
2.64
47.6
30.9
2.91
44.8
29.8
3.22
41.9
28.8
3.54
37.7
26.9
3.99
33.6
25.0
4.42
29.5
23.2
4.85
80
72
49.7
23.7
2.38
49.9
23.7
2.65
50.2
23.7
2.93
47.5
22.6
3.25
44.8
21.4
3.58
40.2
19.4
4.02
35.8
17.5
4.45
31.4
15.5
4.89
80
57
45.5
45.5
2.47
44.8
44.3
2.72
44.0
43.1
2.97
41.4
40.7
3.29
38.7
38.3
3.61
35.2
34.9
4.06
31.8
31.7
4.50
28.4
28.4
4.94
80
62
45.4
39.9
2.47
44.4
39.9
2.72
43.3
39.9
2.97
40.4
38.6
3.29
37.4
37.4
3.61
33.3
33.3
4.06
29.3
29.3
4.49
25.3
25.3
4.93
1490
75
62
46.7
34.8
2.47
45.1
34.2
2.72
43.5
33.6
2.97
40.2
32.1
3.28
36.8
30.5
3.59
32.5
28.1
4.04
28.3
25.8
4.48
24.2
23.5
4.92
80
67
48.5
32.1
2.47
48.4
32.4
2.74
48.3
32.7
3.00
45.5
32.0
3.32
42.8
31.3
3.63
38.3
29.3
4.07
34.0
27.2
4.51
29.7
25.2
4.94
80
72
50.7
24.3
2.46
51.1
24.6
2.74
51.5
24.8
3.03
48.9
23.8
3.35
46.4
22.7
3.68
41.5
20.9
4.12
36.8
19.2
4.55
32.0
17.4
4.98
COOLING PERFORMANCE DATA - 3.5 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B42
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
42.7 44.9
55 / 45
S.C.
42.3 35.0
K.W.
2.25 2.29
T.C.
41.7 43.1
65 / 55
S.C.
40.8 34.5
K.W.
2.49 2.54
T.C.
40.7 41.3
75 / 63
S.C.
39.4 33.9
K.W.
2.74 2.78
T.C.
38.4 38.5
85 / 69
S.C.
37.2 32.6
K.W.
3.07 3.09
T.C.
36.1 35.8
95 / 75
S.C.
35.1 31.3
K.W.
3.39 3.40
T.C.
33.3 32.1
105 / 83
S.C.
32.5 29.2
K.W.
3.85 3.86
T.C.
30.7 28.6
115 / 89
S.C.
30.0 27.2
K.W.
4.29 4.31
T.C.
28.0 25.1
125 / 95
S.C.
27.5 25.1
K.W.
4.73 4.75
12
1090
75
62
45.5
31.2
2.28
43.4
29.9
2.52
41.3
28.7
2.77
38.1
27.2
3.08
34.9
25.8
3.40
31.2
23.8
3.85
27.6
21.9
4.29
24.1
20.0
4.73
80
67
48.5
29.8
2.29
47.7
29.4
2.55
46.9
29.0
2.81
44.0
27.7
3.13
41.0
26.3
3.45
37.0
24.5
3.90
33.1
22.9
4.33
29.2
21.2
4.76
80
72
48.6
23.0
2.29
48.8
22.8
2.56
48.9
22.6
2.84
46.0
21.3
3.16
43.1
20.0
3.47
38.9
17.9
3.93
34.8
15.7
4.36
30.7
13.6
4.80
80
57
44.1
43.9
2.36
43.2
42.6
2.61
42.4
41.3
2.85
39.9
39.0
3.18
37.4
36.7
3.50
34.3
33.7
3.95
31.2
30.8
4.39
28.2
27.9
4.83
Johnson Controls Unitary Products
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 4 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B48
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
38.0 38.6
55 / 45
S.C.
38.0 34.4
K.W.
1.63 1.61
T.C.
35.9 36.9
65 / 55
S.C.
35.9 33.2
K.W.
1.90 1.88
T.C.
33.9 35.2
75 / 63
S.C.
33.9 32.0
K.W.
2.17 2.14
T.C.
31.9 31.9
85 / 69
S.C.
31.9 30.2
K.W.
2.50 2.49
T.C.
30.0 28.7
95 / 75
S.C.
30.0 28.5
K.W.
2.84 2.83
T.C.
27.8 25.0
105 / 83
S.C.
27.3 24.9
K.W.
3.29 3.28
T.C.
25.7 21.4
115 / 89
S.C.
24.7 21.4
K.W.
3.73 3.72
T.C.
23.6 17.9
125 / 95
S.C.
22.0 17.9
K.W.
4.16 4.16
1050
75
62
42.2
29.9
1.62
39.4
28.4
1.88
36.6
26.8
2.14
33.5
25.3
2.49
30.4
23.7
2.84
26.6
21.1
3.28
23.0
18.6
3.72
19.3
16.0
4.15
80
67
45.8
29.6
1.60
43.5
28.4
1.86
41.2
27.2
2.12
37.8
25.8
2.46
34.5
24.4
2.80
30.1
22.3
3.26
25.9
20.4
3.71
21.7
18.4
4.15
80
72
48.4
23.7
1.57
47.1
22.7
1.82
45.8
21.6
2.07
41.2
20.4
2.42
36.6
19.1
2.77
32.9
16.9
3.22
29.3
14.8
3.65
25.7
12.7
4.09
80
57
39.5
39.5
1.59
37.3
37.3
1.85
35.0
35.0
2.12
33.0
33.0
2.46
31.0
31.0
2.79
28.6
28.3
3.24
26.3
25.8
3.68
24.0
23.2
4.11
80
62
40.2
37.8
1.57
37.9
35.9
1.84
35.6
34.0
2.11
32.5
31.7
2.45
29.4
29.3
2.79
26.2
26.2
3.24
23.1
23.1
3.68
20.0
20.0
4.12
1250
75
62
43.4
32.4
1.59
40.8
31.0
1.85
38.2
29.5
2.11
34.7
27.7
2.45
31.2
26.0
2.80
27.1
23.1
3.26
23.1
20.3
3.70
19.1
17.4
4.14
80
67
47.0
31.9
1.56
44.6
30.9
1.82
42.2
29.9
2.08
38.7
28.4
2.43
35.2
26.8
2.77
30.9
24.8
3.22
26.7
22.8
3.67
22.5
20.8
4.11
80
72
49.8
25.2
1.54
48.2
24.3
1.79
46.6
23.3
2.04
42.2
21.8
2.38
37.7
20.3
2.73
33.6
18.3
3.18
29.6
16.3
3.62
25.6
14.3
4.07
80
57
40.9
40.9
1.55
38.6
38.6
1.81
36.2
36.2
2.07
34.1
34.1
2.41
32.0
32.0
2.75
29.4
29.4
3.20
26.9
26.9
3.63
24.4
24.4
4.06
80
62
41.7
41.2
1.53
38.9
38.6
1.80
36.0
36.0
2.07
33.1
33.1
2.41
30.2
30.2
2.75
27.5
27.5
3.20
24.8
24.8
3.64
22.1
22.1
4.08
1450
75
62
44.6
34.9
1.56
42.1
33.5
1.81
39.7
32.2
2.07
35.8
30.2
2.42
32.0
28.3
2.76
27.5
25.1
3.23
23.2
22.0
3.68
18.8
18.8
4.12
80
67
48.2
34.3
1.52
45.7
33.4
1.78
43.3
32.6
2.05
39.6
30.9
2.39
35.9
29.2
2.74
31.6
27.2
3.19
27.5
25.3
3.63
23.3
23.3
4.06
80
72
51.2
26.7
1.51
49.3
25.9
1.76
47.4
25.0
2.01
43.1
23.3
2.35
38.8
21.6
2.69
34.3
19.7
3.15
29.8
17.8
3.59
25.4
16.0
4.04
80
62
52.5
46.8
2.78
49.2
45.4
3.06
45.9
43.9
3.34
41.8
40.7
3.70
37.7
37.5
4.05
34.2
34.1
4.59
30.8
30.7
5.11
27.4
27.4
5.62
1550
75
62
55.1
39.8
2.78
50.2
38.2
3.05
45.4
36.6
3.32
41.9
34.7
3.69
38.4
32.8
4.05
33.7
29.6
4.58
29.0
26.6
5.10
24.4
23.5
5.61
80
67
60.0
39.1
2.81
57.3
38.0
3.10
54.5
36.9
3.38
50.2
35.0
3.74
46.0
33.1
4.09
41.5
31.2
4.62
37.1
29.4
5.14
32.8
27.5
5.66
80
72
63.5
30.4
2.84
61.2
29.2
3.13
59.0
28.0
3.42
54.2
25.9
3.79
49.4
23.8
4.15
44.5
22.0
4.67
39.8
20.3
5.17
35.1
18.5
5.68
80
57
55.0
53.8
2.83
48.6
48.0
3.11
42.2
42.2
3.39
39.7
39.7
3.76
37.2
37.2
4.13
34.4
34.4
4.66
31.6
31.6
5.18
28.9
28.9
5.70
80
62
53.9
49.4
2.86
50.6
48.1
3.14
47.3
46.7
3.41
42.6
42.4
3.77
38.0
38.0
4.12
34.8
34.8
4.65
31.6
31.6
5.17
28.5
28.5
5.69
1750
75
62
56.7
42.5
2.84
51.6
40.6
3.12
46.4
38.7
3.39
42.6
36.9
3.75
38.8
35.1
4.12
33.7
31.3
4.65
28.7
27.5
5.16
23.8
23.8
5.67
80
67
61.3
41.2
2.88
58.7
40.0
3.16
56.2
38.8
3.45
51.5
36.9
3.81
46.7
35.1
4.16
42.1
33.2
4.69
37.6
31.4
5.20
33.1
29.5
5.71
80
72
65.3
31.5
2.90
63.4
30.5
3.20
61.5
29.5
3.50
56.3
27.0
3.86
51.2
24.6
4.22
45.7
22.7
4.74
40.3
20.9
5.24
35.0
19.2
5.75
COOLING PERFORMANCE DATA - 4 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B48
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
50.4 51.0
55 / 45
S.C.
50.3 44.3
K.W.
2.68 2.71
T.C.
45.9 47.7
65 / 55
S.C.
45.9 42.7
K.W.
2.96 2.99
T.C.
41.4 44.4
75 / 63
S.C.
41.4 41.0
K.W.
3.24 3.27
T.C.
39.4 40.9
85 / 69
S.C.
39.4 39.0
K.W.
3.61 3.63
T.C.
37.3 37.5
95 / 75
S.C.
37.3 37.0
K.W.
3.98 3.99
T.C.
34.4 33.7
105 / 83
S.C.
34.4 33.3
K.W.
4.52 4.53
T.C.
31.6 30.0
115 / 89
S.C.
31.6 29.8
K.W.
5.05 5.04
T.C.
28.8 26.3
125 / 95
S.C.
28.8 26.3
K.W.
5.57 5.56
Johnson Controls Unitary Products
1350
75
62
53.4
37.2
2.71
48.9
35.9
2.98
44.3
34.5
3.26
41.2
32.5
3.62
38.1
30.4
3.98
33.7
28.0
4.51
29.4
25.6
5.03
25.1
23.2
5.55
80
67
58.8
36.9
2.74
55.8
36.0
3.03
52.8
35.1
3.31
49.0
33.1
3.67
45.3
31.1
4.02
40.9
29.2
4.56
36.6
27.4
5.08
32.4
25.6
5.61
80
72
61.8
29.3
2.78
59.1
27.9
3.06
56.4
26.5
3.35
52.0
24.7
3.71
47.6
23.0
4.08
43.4
21.3
4.60
39.2
19.6
5.10
35.1
17.9
5.61
80
57
52.7
52.1
2.76
47.3
46.9
3.04
41.8
41.8
3.32
39.5
39.5
3.69
37.2
37.2
4.05
34.4
34.4
4.59
31.6
31.6
5.11
28.9
28.9
5.64
13
5331896-YTG-C-1017
COOLING PERFORMANCE DATA - 5 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B60
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
46.1 50.2
55 / 45
S.C.
44.9 40.0
K.W.
2.03 1.99
T.C.
43.7 46.8
65 / 55
S.C.
42.7 38.3
K.W.
2.34 2.29
T.C.
41.3 43.4
75 / 63
S.C.
40.4 36.6
K.W.
2.65 2.58
T.C.
38.8 39.7
85 / 69
S.C.
38.0 34.3
K.W.
3.02 2.95
T.C.
36.3 36.0
95 / 75
S.C.
35.5 32.0
K.W.
3.39 3.32
T.C.
33.0 32.3
105 / 83
S.C.
32.4 29.7
K.W.
3.87 3.81
T.C.
29.7 28.8
115 / 89
S.C.
29.4 27.4
K.W.
4.33 4.29
T.C.
26.4 25.2
125 / 95
S.C.
26.4 25.2
K.W.
4.79 4.77
1150
75
62
50.9
34.8
2.01
47.0
33.0
2.30
43.1
31.2
2.58
39.2
29.2
2.95
35.4
27.2
3.32
31.3
25.0
3.82
27.3
22.9
4.30
23.3
20.7
4.78
80
67
56.9
34.4
1.98
52.6
32.7
2.27
48.2
30.9
2.56
44.8
29.5
2.93
41.3
28.0
3.30
36.6
25.9
3.79
32.1
23.8
4.27
27.6
21.8
4.74
80
72
63.1
28.8
1.94
58.8
27.2
2.22
54.5
25.7
2.50
50.4
23.8
2.88
46.4
21.9
3.25
41.3
19.8
3.75
36.5
17.9
4.22
31.6
15.9
4.70
80
57
47.6
46.9
2.03
45.3
44.5
2.34
42.9
42.1
2.64
40.4
39.3
3.01
37.9
36.6
3.38
34.1
33.2
3.86
30.5
30.0
4.32
26.8
26.7
4.78
80
62
51.3
42.9
2.00
47.8
41.0
2.29
44.2
39.0
2.58
40.3
36.6
2.95
36.4
34.1
3.33
32.5
31.0
3.82
28.8
28.0
4.29
25.0
24.9
4.77
1350
75
62
51.1
36.9
2.01
47.4
35.0
2.29
43.7
33.1
2.58
39.7
30.9
2.95
35.7
28.8
3.33
31.3
26.4
3.83
27.2
24.0
4.30
23.0
21.6
4.78
80
67
58.1
36.6
1.98
53.7
34.9
2.27
49.3
33.3
2.57
45.5
31.6
2.94
41.7
29.9
3.31
36.8
27.6
3.80
32.0
25.4
4.27
27.2
23.2
4.75
80
72
63.4
29.6
1.95
58.9
28.3
2.23
54.5
27.0
2.50
50.6
25.0
2.88
46.7
23.0
3.26
41.3
20.8
3.75
36.1
18.8
4.23
30.9
16.7
4.71
80
57
49.1
49.0
2.03
46.8
46.4
2.33
44.5
43.7
2.63
42.0
40.7
3.00
39.5
37.7
3.37
35.3
34.1
3.85
31.2
30.6
4.31
27.2
27.1
4.78
80
62
52.5
45.8
2.01
48.8
43.6
2.30
45.0
41.5
2.58
40.9
38.8
2.96
36.8
36.2
3.33
32.7
32.3
3.82
28.7
28.5
4.29
24.8
24.7
4.77
1550
75
62
51.3
39.1
2.01
47.9
37.0
2.29
44.4
34.9
2.57
40.2
32.6
2.96
36.0
30.3
3.34
31.4
27.7
3.83
27.0
25.1
4.31
22.6
22.6
4.79
80
67
59.3
38.8
1.99
54.9
37.2
2.28
50.5
35.6
2.57
46.3
33.7
2.95
42.1
31.8
3.32
36.9
29.4
3.81
31.9
27.0
4.28
26.9
24.6
4.75
80
72
63.7
30.4
1.95
59.1
29.4
2.23
54.5
28.4
2.50
50.7
26.2
2.88
47.0
24.0
3.26
41.3
21.8
3.76
35.7
19.7
4.24
30.2
17.6
4.72
80
62
67.7
55.4
3.52
63.6
53.4
3.92
59.5
51.4
4.33
54.9
48.8
4.76
50.4
46.1
5.18
45.2
42.3
5.80
40.1
38.6
6.41
35.0
34.9
7.02
1800
75
62
65.8
47.5
3.67
62.2
45.4
3.92
58.5
43.4
4.16
53.5
41.0
4.67
48.5
38.6
5.17
43.5
35.8
5.74
38.6
33.1
6.29
33.8
30.4
6.84
80
67
73.8
47.7
3.61
68.7
45.8
3.93
63.5
43.8
4.25
59.2
41.4
4.68
54.9
39.1
5.10
48.7
36.5
5.70
42.6
34.0
6.29
36.6
31.4
6.87
80
72
77.1
39.3
3.78
73.4
37.6
4.13
69.7
35.9
4.47
64.7
32.9
4.90
59.6
29.9
5.34
53.3
27.3
5.88
47.2
24.9
6.41
41.1
22.4
6.94
80
57
64.5
64.4
3.72
61.0
60.9
4.05
57.5
57.4
4.38
52.7
52.7
4.82
48.0
48.0
5.25
43.9
43.9
5.88
40.0
39.9
6.48
36.0
36.0
7.09
80
62
68.7
58.3
3.77
64.6
56.2
4.10
60.5
54.1
4.42
55.6
51.1
4.85
50.7
48.1
5.27
45.3
43.6
5.89
40.1
39.2
6.50
34.8
34.8
7.11
2000
75
62
67.4
49.5
3.77
63.1
47.6
4.09
58.9
45.7
4.41
53.9
42.9
4.83
48.8
40.2
5.25
43.3
37.3
5.87
38.0
34.5
6.48
32.6
31.7
7.08
80
67
74.9
49.6
3.86
69.1
47.6
4.18
63.2
45.6
4.51
59.0
43.0
4.93
54.7
40.4
5.35
48.2
37.9
5.95
42.0
35.4
6.53
35.7
33.0
7.11
80
72
77.2
40.1
3.86
73.5
38.5
4.21
69.9
36.8
4.56
65.2
33.5
5.00
60.5
30.2
5.43
53.6
27.8
6.03
46.9
25.4
6.61
40.2
23.0
7.18
COOLING PERFORMANCE DATA - 5 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B60
CONDENSER
ID CFM
ENTERING AIR
IDDB
80
80
TEMPERATURE
IDWB
57
62
T.C.
60.7 66.7
55 / 45
S.C.
60.3 52.5
K.W.
3.19 3.26
T.C.
57.4 62.5
65 / 55
S.C.
57.2 50.6
K.W.
3.68 3.75
T.C.
54.1 58.4
75 / 63
S.C.
54.1 48.7
K.W.
4.17 4.24
T.C.
50.5 54.3
85 / 69
S.C.
50.5 46.4
K.W.
4.45 4.66
T.C.
47.0 50.2
95 / 75
S.C.
46.9 44.0
K.W.
4.72 5.09
T.C.
42.3 45.1
105 / 83
S.C.
42.3 41.0
K.W.
5.47 5.71
T.C.
37.8 40.1
115 / 89
S.C.
37.7 38.0
K.W.
6.19 6.32
T.C.
33.2 35.1
125 / 95
S.C.
33.2 35.0
K.W.
6.91 6.92
14
1600
75
62
64.3
45.5
3.58
61.2
43.3
3.75
58.2
41.1
3.92
53.1
39.0
4.50
48.1
37.0
5.09
43.6
34.3
5.60
39.3
31.7
6.10
35.0
29.1
6.59
80
67
72.7
45.9
3.36
68.2
44.0
3.68
63.8
42.0
4.00
59.5
39.9
4.43
55.1
37.8
4.85
49.1
35.1
5.46
43.3
32.5
6.04
37.5
29.9
6.63
80
72
76.9
38.6
3.71
73.2
36.8
4.04
69.6
35.0
4.37
64.2
32.3
4.81
58.8
29.6
5.25
53.1
26.9
5.74
47.5
24.3
6.22
42.0
21.7
6.70
80
57
62.6
62.4
3.46
59.2
59.1
3.87
55.8
55.8
4.28
51.6
51.6
4.63
47.5
47.4
4.99
43.1
43.1
5.67
38.9
38.8
6.34
34.6
34.6
7.00
Johnson Controls Unitary Products
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 2 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6A24
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
MBH
21.6
20.2
18.8
17.4
16.0
14.7
20.8
19.8
18.7
360
COP
5.36
4.46
3.74
4.35
3.58
2.97
3.88
3.33
2.88
KW
1.12
1.26
1.40
1.11
1.25
1.38
1.50
1.67
1.84
MBH
20.3
18.9
17.6
16.5
15.2
13.9
20.3
19.2
18.2
ID CFM
560
COP
4.34
3.64
3.06
3.66
3.02
2.51
3.27
2.81
2.44
KW
1.31
1.47
1.62
1.26
1.41
1.56
1.75
1.94
2.13
MBH
18.9
17.6
16.4
15.5
14.3
13.0
19.7
18.7
17.7
760
COP
3.57
3.00
2.54
3.11
2.57
2.13
2.81
2.42
2.09
KW
1.50
1.68
1.85
1.41
1.57
1.74
2.00
2.22
2.43
MBH
30.1
28.7
27.3
25.1
23.7
22.2
21.9
20.8
19.8
18.2
17.2
16.3
13.6
12.6
11.6
11.3
10.1
8.9
ID CFM
750
COP
4.96
4.30
3.76
4.34
3.72
3.21
3.88
3.35
2.90
3.31
2.85
2.47
2.59
2.19
1.86
2.19
1.79
1.46
KW
1.69
1.86
2.03
1.60
1.77
1.94
1.56
1.73
1.90
1.52
1.68
1.84
1.45
1.59
1.73
1.41
1.55
1.69
MBH
31.4
29.9
28.4
26.1
24.5
22.9
22.8
21.4
20.0
18.8
17.6
16.4
14.2
13.0
11.8
11.3
10.1
9.0
950
COP
5.51
4.80
4.20
4.78
4.08
3.50
4.23
3.63
3.12
3.56
3.03
2.60
2.76
2.31
1.94
2.25
1.85
1.51
KW
1.55
1.71
1.87
1.49
1.64
1.80
1.47
1.62
1.76
1.44
1.59
1.74
1.39
1.53
1.66
1.36
1.49
1.62
HEATING PERFORMANCE DATA - (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6A24
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
Johnson Controls Unitary Products
MBH
28.9
27.5
26.2
24.1
22.8
21.5
21.0
20.3
19.5
17.6
16.9
16.1
13.0
12.2
11.4
11.2
9.9
8.7
550
COP
4.46
3.87
3.37
3.95
3.40
2.95
3.56
3.09
2.71
3.07
2.68
2.35
2.43
2.08
1.79
2.13
1.74
1.40
KW
1.83
2.01
2.21
1.72
1.89
2.06
1.65
1.84
2.03
1.61
1.77
1.94
1.50
1.64
1.79
1.47
1.61
1.75
15
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 2.5 TON
PACKAGED UNIT MODEL NO. PHG6A30
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
MBH
28.9
27.1
25.3
22.4
21.0
19.6
19.3
17.7
16.1
550
COP
5.11
4.31
3.66
3.98
3.36
2.84
3.43
2.83
2.34
KW
1.51
1.70
1.88
1.50
1.69
1.87
1.50
1.69
1.87
MBH
27.7
26.1
24.5
21.5
20.3
19.1
18.8
17.3
15.9
ID CFM
750
COP
4.55
3.84
3.26
3.67
3.09
2.63
3.21
2.65
2.20
KW
1.69
1.89
2.09
1.62
1.83
2.03
1.62
1.81
2.01
MBH
26.5
25.0
23.6
20.7
19.7
18.7
18.3
17.0
15.6
950
COP
4.03
3.41
2.91
3.36
2.84
2.42
2.99
2.48
2.06
KW
1.86
2.08
2.30
1.74
1.97
2.20
1.73
1.94
2.15
MBH
37.5
35.7
33.8
30.5
29.0
27.4
25.5
24.5
23.6
21.3
19.2
17.1
15.8
13.9
11.9
12.1
10.9
9.6
ID CFM
950
COP
4.60
3.99
3.47
3.94
3.41
2.96
3.34
2.92
2.57
2.89
2.37
1.94
2.21
1.79
1.43
1.75
1.44
1.18
KW
2.22
2.44
2.67
2.09
2.31
2.53
2.06
2.29
2.51
1.98
2.19
2.40
1.91
2.09
2.26
1.86
2.03
2.20
MBH
36.6
34.8
32.9
30.0
28.6
27.3
25.7
24.8
23.9
21.8
19.8
17.8
15.9
14.4
12.8
12.9
11.6
10.3
1150
COP
4.44
3.83
3.32
3.88
3.36
2.92
3.37
2.93
2.57
2.99
2.46
2.01
2.28
1.88
1.55
1.91
1.58
1.29
KW
2.30
2.55
2.79
2.16
2.39
2.63
2.13
2.37
2.61
2.02
2.25
2.48
1.94
2.12
2.30
1.87
2.04
2.22
HEATING PERFORMANCE DATA - 2.5 TON
PACKAGED UNIT MODEL NO. PHG6A30
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
16
MBH
38.5
36.5
34.6
31.1
29.3
27.4
25.2
24.3
23.4
20.7
18.5
16.4
15.6
13.4
11.1
11.4
10.1
8.9
750
COP
4.76
4.15
3.63
4.00
3.45
2.99
3.30
2.90
2.58
2.78
2.29
1.87
2.13
1.69
1.31
1.59
1.31
1.07
KW
2.13
2.34
2.54
2.03
2.24
2.44
2.00
2.21
2.42
1.94
2.13
2.32
1.89
2.06
2.23
1.86
2.01
2.18
Johnson Controls Unitary Products
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 3 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B36
AIR TEMP.
ENTERING
OUTDOOR UNIT
60
47
40
AIR TEMP.
ENTERING
INDOOR COIL
60
70
80
60
70
80
60
70
80
MBH
600
COP
KW
30.3
29.0
27.8
25.3
23.8
22.2
22.0
20.6
19.3
5.01
4.28
3.69
4.18
3.51
2.96
3.63
3.06
2.59
1.72
1.93
2.15
1.72
1.93
2.14
1.72
1.92
2.13
MBH
ID CFM
800
COP
KW
MBH
1000
COP
KW
29.4
28.0
26.6
24.3
22.9
21.5
21.2
19.9
18.6
4.36
3.74
3.22
3.67
3.11
2.65
3.22
2.72
2.31
1.89
2.12
2.34
1.87
2.08
2.30
1.85
2.07
2.28
28.4
27.0
25.5
23.3
22.0
20.8
20.4
19.1
17.9
3.84
3.29
2.83
3.24
2.77
2.38
2.88
2.43
2.07
2.07
2.31
2.54
2.01
2.24
2.47
1.99
2.21
2.44
MBH
43.0
41.2
39.5
35.7
34.1
32.5
31.4
30.0
28.6
26.1
25.0
23.9
19.7
18.6
17.5
16.3
12.0
7.8
ID CFM
1200
COP
4.45
3.94
3.51
3.85
3.39
3.00
3.45
3.04
2.68
2.97
2.60
2.29
2.30
2.00
1.74
1.93
1.35
0.83
KW
2.58
2.82
3.05
2.47
2.70
2.93
2.42
2.65
2.89
2.33
2.57
2.81
2.26
2.48
2.70
2.22
2.36
2.50
MBH
42.0
40.3
38.7
35.3
33.7
32.0
30.9
29.6
28.3
25.6
24.6
23.6
19.4
18.5
17.5
16.6
15.6
14.5
1400
COP
4.37
3.87
3.44
3.85
3.37
2.96
3.45
3.03
2.67
3.01
2.62
2.29
2.33
2.03
1.77
2.05
1.75
1.51
KW
2.64
2.88
3.11
2.50
2.75
2.99
2.45
2.69
2.93
2.31
2.57
2.83
2.25
2.49
2.72
2.20
2.42
2.64
HEATING PERFORMANCE DATA - 3 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B36
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
Johnson Controls Unitary Products
MBH
43.9
42.1
40.2
36.0
34.5
33.1
31.9
30.5
29.0
26.6
25.4
24.2
20.0
18.8
17.6
15.9
8.5
1.1
1000
COP
4.52
4.01
3.57
3.84
3.41
3.04
3.45
3.04
2.69
2.93
2.59
2.29
2.26
1.97
1.72
1.83
0.95
0.12
KW
2.53
2.76
2.99
2.44
2.66
2.88
2.40
2.62
2.84
2.34
2.56
2.78
2.27
2.48
2.69
2.24
2.30
2.38
17
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 3.5 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B42
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
MBH
34.9
33.0
31.1
28.6
26.8
25.0
25.2
23.8
22.3
750
COP
4.68
3.99
3.42
3.83
3.24
2.76
3.36
2.84
2.42
KW
2.01
2.25
2.50
2.01
2.25
2.49
2.02
2.27
2.52
MBH
33.9
32.1
30.2
28.3
26.4
24.5
24.8
23.3
21.7
ID CFM
950
COP
4.39
3.74
3.21
3.71
3.12
2.64
3.26
2.73
2.31
KW
2.14
2.39
2.64
2.11
2.35
2.59
2.10
2.36
2.63
MBH
32.9
31.1
29.3
28.0
26.0
23.9
24.4
22.8
21.1
1150
COP
4.11
3.51
3.01
3.59
3.01
2.52
3.16
2.63
2.20
KW
2.26
2.52
2.77
2.21
2.45
2.70
2.19
2.46
2.73
MBH
46.5
44.3
42.0
35.0
34.7
34.4
27.6
22.8
18.0
28.7
26.2
23.8
16.9
14.4
11.9
17.5
15.4
13.4
ID CFM
1270
COP
4.36
3.81
3.34
4.13
3.37
2.85
2.84
2.20
1.63
2.93
2.48
2.09
1.84
1.44
1.10
1.89
1.54
1.24
KW
2.89
3.17
3.45
2.25
2.77
3.30
2.61
2.79
2.98
2.63
2.86
3.09
2.45
2.68
2.91
2.46
2.68
2.91
MBH
46.1
43.9
41.8
32.5
33.5
34.6
33.1
25.9
18.8
29.9
27.6
25.4
18.5
15.6
12.8
18.2
16.9
15.5
1470
COP
4.30
3.76
3.30
3.90
3.28
2.86
3.38
2.51
1.73
3.08
2.64
2.25
2.07
1.61
1.22
2.04
1.73
1.46
KW
2.98
3.26
3.54
2.27
2.82
3.38
2.71
2.86
3.01
2.68
2.91
3.14
2.46
2.68
2.91
2.45
2.69
2.94
HEATING PERFORMANCE DATA - 3.5 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B42
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
18
MBH
47.0
44.7
42.3
37.5
35.8
34.2
22.2
19.7
17.1
27.5
24.8
22.1
15.2
13.0
10.9
16.7
14.0
11.2
1070
COP
4.42
3.86
3.39
4.35
3.46
2.83
2.30
1.89
1.53
2.79
2.32
1.93
1.62
1.28
0.99
1.76
1.36
1.02
KW
2.80
3.07
3.34
2.22
2.72
3.23
2.51
2.73
2.95
2.57
2.81
3.04
2.44
2.67
2.91
2.47
2.68
2.89
Johnson Controls Unitary Products
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 4 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B48
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
MBH
44.4
42.2
39.9
35.9
33.6
31.3
31.4
29.3
27.3
1000
COP
4.83
4.08
3.48
3.90
3.25
2.72
3.41
2.87
2.42
KW
2.48
2.80
3.14
2.48
2.81
3.15
2.48
2.78
3.08
MBH
44.3
41.9
39.6
35.9
33.4
31.0
31.3
29.3
27.3
ID CFM
1200
COP
4.55
3.82
3.24
3.71
3.08
2.57
3.25
2.73
2.30
KW
2.68
3.05
3.42
2.67
3.01
3.36
2.65
2.98
3.30
MBH
44.1
41.7
39.3
35.9
33.3
30.6
31.2
29.3
27.3
1400
COP
4.31
3.59
3.02
3.54
2.92
2.43
3.11
2.61
2.20
KW
2.89
3.29
3.70
2.85
3.21
3.57
2.82
3.17
3.51
MBH
60.8
58.2
55.7
50.3
48.0
45.8
44.7
42.6
40.6
36.9
35.2
33.5
28.2
26.6
25.0
25.5
23.5
21.6
ID CFM
1500
COP
4.52
3.93
3.43
3.87
3.34
2.91
3.48
2.99
2.58
2.93
2.51
2.17
2.29
1.94
1.66
2.14
1.78
1.49
KW
3.56
3.97
4.38
3.43
3.83
4.24
3.39
3.81
4.23
3.31
3.73
4.15
3.23
3.64
4.05
3.11
3.49
3.86
MBH
60.1
57.7
55.3
49.6
47.7
45.7
44.6
42.7
40.7
37.0
35.3
33.6
28.4
26.9
25.4
25.6
23.9
22.1
1700
COP
4.42
3.82
3.32
3.78
3.26
2.84
3.45
2.95
2.55
2.94
2.47
2.10
2.33
1.95
1.65
2.17
1.81
1.52
KW
3.68
4.12
4.57
3.53
3.97
4.40
3.48
3.92
4.36
3.38
3.88
4.38
3.26
3.73
4.19
3.15
3.55
3.95
HEATING PERFORMANCE DATA - 4 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B48
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
Johnson Controls Unitary Products
MBH
61.4
58.7
56.0
50.9
48.3
45.8
44.7
42.6
40.5
36.8
35.1
33.4
28.0
26.3
24.6
25.3
23.3
21.2
1300
COP
4.63
4.04
3.55
3.97
3.43
2.97
3.51
3.02
2.62
2.92
2.55
2.24
2.26
1.94
1.66
2.11
1.76
1.47
KW
3.46
3.82
4.19
3.32
3.71
4.09
3.30
3.70
4.09
3.25
3.59
3.94
3.20
3.55
3.90
3.08
3.44
3.78
19
5331896-YTG-C-1017
HEATING PERFORMANCE DATA - 5 TON (LOW SPEED)
PACKAGED UNIT MODEL NO. PHG6B60
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
MBH
53.8
51.7
49.6
45.2
43.2
41.1
40.6
38.4
36.3
1030
COP
4.73
4.09
3.57
4.06
3.50
3.04
3.66
3.14
2.72
KW
2.98
3.34
3.72
2.91
3.25
3.60
2.90
3.23
3.55
MBH
54.5
52.2
49.9
46.3
44.0
41.8
41.1
39.0
37.0
ID CFM
1230
COP
4.57
3.93
3.42
4.03
3.46
2.98
3.62
3.12
2.70
KW
3.22
3.61
4.01
3.09
3.46
3.83
3.05
3.40
3.75
MBH
55.1
52.7
50.2
47.3
44.9
42.5
41.6
39.7
37.7
1430
COP
4.42
3.79
3.28
4.01
3.42
2.94
3.60
3.09
2.68
KW
3.47
3.88
4.30
3.27
3.67
4.05
3.21
3.57
3.94
MBH
73.1
70.2
67.4
61.5
59.0
56.4
54.8
52.2
49.6
44.9
43.3
41.7
33.3
31.9
30.5
30.6
28.9
27.2
ID CFM
1730
COP
4.56
4.03
3.57
4.02
3.53
3.12
3.66
3.19
2.80
3.11
2.75
2.44
2.41
2.12
1.87
2.24
1.95
1.70
KW
4.18
4.60
5.01
3.97
4.38
4.78
3.88
4.28
4.69
3.72
4.10
4.49
3.54
3.90
4.26
3.49
3.83
4.18
MBH
72.5
69.8
67.2
61.6
59.1
56.6
55.1
52.3
49.5
45.3
43.8
42.3
33.2
32.3
31.5
31.2
29.5
27.8
1930
COP
4.37
3.85
3.42
3.88
3.42
3.02
3.57
3.10
2.70
3.06
2.70
2.40
2.36
2.10
1.88
2.24
1.95
1.69
KW
4.21
4.67
5.11
4.01
4.43
4.84
3.88
4.30
4.73
3.70
4.10
4.51
3.48
3.87
4.26
3.43
3.79
4.15
HEATING PERFORMANCE DATA - 5 TON (HIGH SPEED)
PACKAGED UNIT MODEL NO. PHG6B60
AIR TEMP.
AIR TEMP.
ENTERING
ENTERING
OUTDOOR UNIT
INDOOR COIL
60
60
70
80
60
47
70
80
60
40
70
80
60
30
70
80
60
17
70
80
60
10
70
80
20
MBH
73.6
70.6
67.6
61.4
58.8
56.2
54.6
52.2
49.7
44.5
42.8
41.1
33.4
31.5
29.6
30.1
28.4
26.6
1530
COP
4.77
4.22
3.74
4.17
3.66
3.23
3.76
3.30
2.90
3.17
2.80
2.48
2.46
2.14
1.87
2.24
1.95
1.70
KW
4.15
4.53
4.92
3.94
4.33
4.73
3.88
4.26
4.65
3.74
4.11
4.48
3.60
3.94
4.26
3.55
3.88
4.21
Johnson Controls Unitary Products
5331896-YTG-C-1017
81,77233$1(/
&251(53267
,1'225&2,/
&2,/*8$5'
+,*+92/7$*(
23(1,1*´
&
+,*+92/7$*(
23(1,1*´
&20%867,21$,5,17$.(
+($7(;&+$1*(5$&&(663$1(/
&2035(6625
$&&(663$1(/
)/8((;+$867+22'
&21'(16$7(
'5$,1
%/2:(5
$&&(66
3$1(/
$
&21752/+($7
$&&(663$1(/
%
/2:92/7$*(23(1,1*´
*$66833/<+2/(´:,7+
*5200(723(1,1*2)´
$
UNIT DIMENSIONS AND ACCESS LOCATIONS
Model
PHG6A24
PHG6A30
PHG6B36
PHG6B42
PHG6B48
PHG6B60
A
51-1/4
51-1/4
51-1/4
51-1/4
51-1/4
51-1/4
Dimensions (in inches)
B
35-3/4
35-3/4
45-3/4
45-3/4
45-3/4
45-3/4
C
47
49
49
49
53
55
Distance (in.)
36
36
0
Direction
Power Entry (Right Side)
Left Side
Bottom4
Distance (in.)
36
24
1
UNIT CLEARANCES1 2
Direction
Top3
Side Opposite Ducts
Duct Panel
1. A 1" clearance must be provided between any combustible material and the supply air duct work.
2. The products of combustion must not be allowed to accumulate within a confined space and recirculate.
3. Units must be installed outdoors. Over hanging structure or shrubs should not obstruct condenser air discharge outlet.
4. Units may be installed on combustible materials made from wood or class A, B or C roof covering materials only if factory base rails are left in place as shipped.
Johnson Controls Unitary Products
21
5331896-YTG-C-1017
INDOOR BLOWER SPECIFICATIONS
Model
HP
1/2
1/2
1/2
3/4
3/4
1
PHG6A24
PHG6A30
PHG6B36
PHG6B42
PHG6B48
PHG6B60
Motor
EFF.
0.8
0.8
0.8
0.8
0.8
0.8
RPM
Variable
Variable
Variable
Variable
Variable
Variable
SF
1.0
1.0
1.0
1.0
1.0
1.0
Frame
48
48
48
48
48
48
SOUND PERFORMANCE - COOLING
Model
(Tons)
Sound Rating1
dB (A)
PHG6A24
PHG6A30
PHG6B36
PHG6B42
PHG6B48
PHG6B60
72.4
68.7
73.2
73.6
74.0
125
61.8
58.3
61.8
62.4
62.0
250
60.5
58.8
63.2
59.0
62.0
74.1
65.9
61.8
Octave Band Centerline Frequency (Hz)
500
1000
2000
63.1
62.5
57.1
56.6
57.3
54.0
60.5
64.4
58.9
61.5
64.9
60.3
60.9
64.7
60.1
60.8
63.5
4000
51.8
48.4
53.4
55.8
56.6
8000
44.0
43.0
45.9
50.6
49.2
55.5
48.3
4000
49.2
47.6
53.0
54.4
56.4
55.1
8000
43.2
49.7
46.0
47.9
48.9
51.4
58.7
1. Rated in accordance with AHRI Standard 270.
SOUND PERFORMANCE - HEATING
Model
(Tons)
Sound Rating1
dB (A)
PHG6A24
PHG6A30
PHG6B36
PHG6B42
PHG6B48
PHG6B60
70.3
69.0
72.8
73.6
74.6
73.7
125
64.7
57.5
60.1
62.4
66.0
61.6
250
59.2
58.0
62.5
58.3
63.3
59.4
Octave Band Centerline Frequency (Hz)
500
1000
2000
59.8
58.1
54.3
58.0
63.8
53.2
60.4
64.5
58.8
61.5
65.7
59.7
61.1
64.6
60.2
60.5
63.6
58.7
1. Rated in accordance with AHRI Standard 270.
ELECTRICAL DATA
Model
Compressor
Voltage
OD Fan
Motor
Supply
Blower Motor
RLA
LRA
MCC
FLA
FLA
MCA1
(Amps)
Max Fuse2/
Breaker3 Size
(Amps)
24050
208/230-1-60
11.7
58.3
18.2
0.7
2.6
17.9
25
24075
208/230-1-60
11.7
58.3
18.2
0.7
3.8
19.1
30
30050
208/230-1-60
13.1
73.0
20.4
0.8
2.6
19.8
30
30075
208/230-1-60
13.1
73.0
20.4
0.8
3.8
21.0
30
36065
208/230-1-60
15.3
83.0
23.8
1.7
3.8
24.6
35
36100
208/230-1-60
15.3
83.0
23.8
1.7
5.4
26.2
40
42065, 42100
208/230-1-60
17.9
96.0
28.0
1.7
5.4
29.5
45
48065, 48100, 48125
208/230-1-60
21.2
104.0
33.0
1.7
5.4
33.6
50
60065, 60100, 60125
208/230-1-60
28.8
152.9
45.0
1.7
7.0
44.7
70
1. Minimum Circuit Ampacity.
2. Maximum Over Current Protection per standard UL 1995.
3. Fuse or HACR circuit breaker size field installed.
22
Johnson Controls Unitary Products
5331896-YTG-C-1017
"D"
CENTER OF
GRAVITY
COMPRESSOR
"C"
"A"
FRONT
OF UNIT
Y
"B"
X
A0295-001-TG
WEIGHTS & DIMENSIONS
Model
PHG6A24050
PHG6A24075
PHG6A30050
PHG6A30075
PHG6B36065
PHG6B36100
PHG6B42065
PHG6B42100
PHG6B48065
PHG6B48100
PHG6B48125
PHG6B60065
PHG6B60100
PHG6B60125
Weight (lbs.)
Shipping
399
409
454
458
503
510
537
539
556
564
569
582
586
593
Operating
394
404
449
453
498
505
532
534
551
559
564
577
581
588
Johnson Controls Unitary Products
Center of Gravity
X
28
28
28
28
29
29
29
29
28
28
29
29
28
27
Y
15
15
15
15
14
14
14
14
14
14
14
14
14
15
4 Point Load Location (lbs.)
A
131
135
155
161
176
178
190
191
199
194
193
199
201
202
B
101
103
108
102
122
123
132
133
137
141
146
151
152
151
C
86
86
96
90
104
109
112
109
106
117
126
127
123
125
D
76
80
90
100
96
95
98
101
109
107
99
100
105
110
23
5331896-YTG-C-1017
AIRFLOW PERFORMANCE - SIDE DUCT APPLICATION
Model
0.1
0.2
SCFM
SCFM
A
991
957
B
902
858
High Cool
C
826
779
D
693
642
A
808
761
B
718
668
Low Cool
C
615
556
D
562
494
24050
A
862
815
B
768
721
High Heat
C
680
628
D
655
602
A
862
815
B
756
708
Low Heat
C
628
571
D
602
540
A
982
946
B
927
867
High Cool
C
870
761
D
799
623
A
902
822
B
855
734
Low Cool
C
827
678
D
675
546
24075
A
1184
1161
B
1076
1047
High Heat
C
992
957
D
927
867
A
1205
1182
B
1076
1047
Low Heat
C
992
957
D
902
822
A
1148
1117
B
1078
1047
High Cool
C
1026
994
D
871
824
A
982
947
B
910
867
Low Cool
C
808
761
D
781
734
30050
A
862
815
B
768
721
High Heat
C
680
628
D
655
602
A
862
815
B
756
708
Low Heat
C
628
571
D
602
540
Table continued on next page. See NOTES at end of table.
24
Jumper Position
0.3
SCFM
913
809
719
571
699
599
489
436
761
654
557
530
761
640
503
476
899
813
699
552
764
669
611
466
1124
1011
912
813
1145
1011
912
764
1081
1007
951
771
904
819
699
668
761
654
557
530
761
640
503
476
External Static Pressure (Inches WC)
0.4
0.5
0.6
0.7
SCFM
SCFM
SCFM
SCFM
863
809
768
717
753
703
659
615
664
616
570
531
529
466
430
390
645
597
552
512
554
495
457
416
450
390
358
311
395
348
317
259
702
655
607
571
604
553
511
469
516
451
416
376
491
422
389
350
702
655
607
571
591
539
498
456
464
400
368
324
436
379
348
298
849
801
761
710
761
717
667
612
649
605
539
484
475
436
387
338
713
669
612
557
615
572
509
454
545
504
448
396
404
347
277
205
994
954
1084
1041
967
912
875
833
863
813
774
724
761
717
667
612
1107
1065
1019
979
967
912
875
833
863
813
774
724
713
669
612
557
945
901
1039
991
962
906
859
816
903
846
803
757
712
664
616
580
853
799
759
707
763
713
670
624
645
597
552
512
617
568
525
482
702
655
607
571
604
553
511
469
516
451
416
376
491
422
389
350
702
655
607
571
591
539
498
456
464
400
368
324
436
379
348
298
0.8
SCFM
662
570
478
357
455
375
281
217
524
411
348
330
524
402
298
265
656
561
449
294
513
418
356
160
913
790
672
561
938
790
672
513
862
769
696
536
654
578
455
420
524
411
348
330
524
402
298
265
0.9
SCFM
630
513
434
309
420
334
221
155
463
386
296
271
463
373
238
204
609
524
422
237
480
385
311
126
872
734
622
524
896
734
622
480
821
722
673
470
620
524
420
398
463
386
296
271
463
373
238
204
1.0
SCFM
598
496
417
275
401
304
181
113
450
362
261
232
450
347
198
164
581
487
370
192
437
334
263
80
822
707
596
487
845
707
596
437
764
693
635
458
589
505
401
376
450
362
261
232
450
347
198
164
Johnson Controls Unitary Products
5331896-YTG-C-1017
AIRFLOW PERFORMANCE - SIDE DUCT APPLICATION (Continued)
Model
Jumper Position
0.1
0.2
SCFM
SCFM
A
1152
1128
B
1076
1047
High Cool
C
1023
991
D
910
837
A
982
946
B
927
867
Low Cool
C
870
761
D
813
650
30075
A
1184
1161
B
1076
1047
High Heat
C
992
957
D
927
867
A
1205
1182
B
1076
1047
Low Heat
C
992
957
D
902
822
A
1371
1354
B
1293
1246
High Cool
C
1232
1178
D
1058
999
A
1153
1095
B
1015
952
Low Cool
C
882
805
D
805
718
36065
A
1126
1067
B
1015
952
High Heat
C
955
886
D
910
836
A
970
902
B
818
732
Low Heat
C
766
674
D
721
625
A
1374
1333
B
1304
1260
High Cool
C
1233
1186
D
1063
1006
A
1120
1067
B
1025
966
Low Cool
C
882
812
D
821
746
36100
A
1704
1667
B
1506
1468
High Heat
C
1322
1278
D
1251
1205
A
1392
1352
B
1251
1205
Low Heat
C
1139
1087
D
984
922
Table continued on next page. See NOTES at end of table.
Johnson Controls Unitary Products
0.3
SCFM
1090
1011
950
780
899
813
699
582
1124
1011
912
813
1145
1011
912
764
1303
1206
1131
931
1036
884
741
642
1006
884
821
774
837
659
593
540
1298
1218
1137
937
1004
892
716
641
1645
1441
1238
1157
1318
1157
1027
841
External Static Pressure (Inches WC)
0.4
0.5
0.6
0.7
SCFM
SCFM
SCFM
SCFM
958
917
1049
1005
967
912
875
833
903
850
813
767
729
685
631
576
849
801
761
710
761
717
667
612
649
605
539
484
510
470
417
367
1084
1041
994
954
967
912
875
833
863
813
774
724
761
717
667
612
1107
1065
1019
979
967
912
875
833
863
813
774
724
713
669
612
557
1257
1209
1148
1084
1152
1098
1028
938
1077
1012
929
853
859
762
694
635
979
899
810
751
802
709
646
582
625
556
501
415
523
436
376
294
945
860
777
718
802
709
646
582
721
642
584
508
661
592
537
453
599
527
742
659
540
456
397
314
473
377
314
234
413
314
251
172
1255
1204
1145
1100
1170
1116
1055
1007
1085
1029
965
915
871
806
735
678
944
882
813
758
823
756
684
625
633
559
480
412
552
475
392
321
1612
1572
1520
1477
1404
1358
1302
1259
1191
1138
1077
1030
1107
1051
987
938
1276
1226
1168
1123
1107
1051
987
938
968
907
839
785
769
700
625
564
0.8
SCFM
876
790
719
529
656
561
449
325
913
790
672
561
938
790
672
513
1008
865
790
582
697
528
359
247
664
528
453
396
472
265
190
131
1044
953
861
628
707
575
366
276
1419
1203
975
884
1067
884
733
515
0.9
SCFM
834
734
664
495
609
524
422
274
872
734
622
524
896
734
622
480
934
813
738
523
643
467
297
193
608
467
391
333
410
211
142
102
993
896
799
550
635
494
270
174
1384
1159
920
824
1017
824
663
430
1.0
SCFM
788
707
640
453
581
487
370
227
822
707
596
487
845
707
596
437
878
767
690
459
588
402
228
118
551
402
324
265
343
136
63
53
933
834
736
484
569
427
199
101
1327
1101
859
761
957
761
598
361
25
5331896-YTG-C-1017
AIRFLOW PERFORMANCE - SIDE DUCT APPLICATION (Continued)
Model
0.1
0.2
SCFM
SCFM
A
1555
1518
B
1473
1435
High Cool
C
1374
1333
D
1216
1168
A
1233
1186
B
1139
1087
Low Cool
C
1025
966
D
964
900
42065
A
1120
1067
B
1063
1006
High Heat
C
964
900
D
882
812
A
1101
1047
B
923
856
Low Heat
C
821
746
D
735
655
A
1555
1518
B
1473
1435
High Cool
C
1374
1333
D
1216
1168
A
1233
1186
B
1139
1087
Low Cool
C
1025
966
D
964
900
42100
A
1704
1667
B
1506
1468
High Heat
C
1322
1278
D
1251
1205
A
1392
1352
B
1251
1205
Low Heat
C
1139
1087
D
984
922
A
1851
1809
B
1689
1652
High Cool
C
1614
1578
D
1374
1333
A
1473
1435
B
1374
1333
Low Cool
C
1322
1278
D
1286
1241
48065
A
1120
1067
B
1063
1006
High Heat
C
964
900
D
882
812
A
1101
1047
B
923
856
Low Heat
C
821
746
D
735
655
Table continued on next page. See NOTES at end of table.
26
Jumper Position
0.3
SCFM
1494
1406
1298
1117
1137
1027
892
816
1004
937
816
716
982
766
641
533
1494
1406
1298
1117
1137
1027
892
816
1645
1441
1238
1157
1318
1157
1027
841
1781
1630
1554
1298
1406
1298
1238
1197
1004
937
816
716
982
766
641
533
External Static Pressure (Inches WC)
0.4
0.5
0.6
0.7
SCFM
SCFM
SCFM
SCFM
1360
1318
1459
1414
1368
1320
1264
1220
1255
1204
1145
1100
1064
1007
942
892
1085
1029
965
915
968
907
839
785
823
756
684
625
742
672
596
534
944
882
813
758
871
806
735
678
742
672
596
534
633
559
480
412
919
857
787
732
688
616
538
473
552
475
392
321
435
353
266
189
1459
1414
1360
1318
1368
1320
1264
1220
1255
1204
1145
1100
1064
1007
942
892
1085
1029
965
915
968
907
839
785
823
756
684
625
742
672
596
534
1612
1572
1520
1477
1404
1358
1302
1259
1191
1138
1077
1030
1107
1051
987
938
1276
1226
1168
1123
1107
1051
987
938
968
907
839
785
769
700
625
564
1746
1707
1656
1609
1597
1556
1504
1461
1520
1477
1424
1382
1255
1204
1145
1100
1368
1320
1264
1220
1255
1204
1145
1100
1191
1138
1077
1030
1149
1095
1032
984
944
882
813
758
871
806
735
678
742
672
596
534
633
559
480
412
787
732
919
857
688
616
538
473
552
475
392
321
435
353
266
189
0.8
SCFM
1261
1164
1044
838
861
733
575
485
707
628
485
366
680
426
276
147
1261
1164
1044
838
861
733
575
485
1419
1203
975
884
1067
884
733
515
1552
1404
1324
1044
1164
1044
975
930
707
628
485
366
680
426
276
147
0.9
SCFM
1220
1119
993
775
799
663
494
398
635
550
398
270
606
334
174
100
1220
1119
993
775
799
663
494
398
1384
1159
920
824
1017
824
663
430
1518
1368
1286
993
1119
993
920
872
635
550
398
270
606
334
174
100
1.0
SCFM
1162
1060
933
712
736
598
427
329
569
484
329
199
541
264
101
85
1162
1060
933
712
736
598
427
329
1327
1101
859
761
957
761
598
361
1460
1310
1228
933
1060
933
859
810
569
484
329
199
541
264
101
85
Johnson Controls Unitary Products
5331896-YTG-C-1017
AIRFLOW PERFORMANCE - SIDE DUCT APPLICATION (Continued)
Model
Jumper Position
0.1
0.2
SCFM
SCFM
A
1851
1809
B
1689
1652
High Cool
C
1614
1578
D
1374
1333
A
1473
1435
B
1374
1333
Low Cool
C
1322
1278
D
1286
1241
48100
A
1704
1667
B
1506
1468
High Heat
C
1322
1278
D
1251
1205
A
1392
1352
B
1251
1205
Low Heat
C
1139
1087
D
984
922
A
1851
1809
B
1689
1652
High Cool
C
1614
1578
D
1374
1333
A
1473
1435
B
1374
1333
Low Cool
C
1322
1278
D
1286
1241
48125
A
2114
2046
B
1982
1930
High Heat
C
1785
1746
D
1614
1578
A
2114
2046
B
1982
1930
Low Heat
C
1490
1452
D
1357
1315
A
2149
2114
B
2013
1977
High Cool
C
1936
1900
D
1719
1685
A
1629
1591
B
1558
1516
Low Cool
C
1453
1406
D
1410
1361
60065
A
1276
1219
B
1133
1068
High Heat
C
1025
950
D
844
748
A
1228
1169
B
1086
1017
Low Heat
C
844
748
D
786
666
Table continued on next page. See NOTES at end of table.
Johnson Controls Unitary Products
0.3
SCFM
1781
1630
1554
1298
1406
1298
1238
1197
1645
1441
1238
1157
1318
1157
1027
841
1781
1630
1554
1298
1406
1298
1238
1197
1974
1887
1720
1554
1974
1887
1423
1278
2077
1941
1864
1642
1546
1469
1355
1307
1158
995
868
651
1104
940
651
593
External Static Pressure (Inches WC)
0.4
0.5
0.6
0.7
SCFM
SCFM
SCFM
SCFM
1746
1707
1656
1609
1597
1556
1504
1461
1520
1477
1424
1382
1255
1204
1145
1100
1264
1220
1368
1320
1255
1204
1145
1100
1191
1138
1077
1030
1149
1095
1032
984
1612
1572
1520
1477
1404
1358
1302
1259
1191
1138
1077
1030
1107
1051
987
938
1276
1226
1168
1123
1107
1051
987
938
968
907
839
785
769
700
625
564
1746
1707
1656
1609
1597
1556
1504
1461
1520
1477
1424
1382
1255
1204
1145
1100
1264
1220
1368
1320
1255
1204
1145
1100
1191
1138
1077
1030
1149
1095
1032
984
1914
1874
1815
1745
1844
1806
1752
1697
1687
1647
1596
1551
1520
1477
1424
1382
1815
1745
1914
1874
1844
1806
1752
1697
1386
1339
1283
1240
1234
1182
1123
1077
1948
1905
2030
1989
1898
1860
1816
1772
1822
1783
1739
1695
1600
1555
1508
1465
1409
1362
1502
1455
1423
1375
1329
1280
1305
1255
1207
1153
1255
1204
1155
1100
987
927
1098
1040
922
849
793
730
788
713
654
591
563
494
433
372
922
861
1039
976
863
786
728
664
563
494
433
372
514
453
370
314
0.8
SCFM
1552
1404
1324
1044
1164
1044
975
930
1419
1203
975
884
1067
884
733
515
1552
1404
1324
1044
1164
1044
975
930
1696
1643
1494
1324
1696
1643
1183
1021
1859
1726
1649
1418
1315
1232
1100
1044
869
680
505
168
806
617
168
263
0.9
SCFM
1518
1368
1286
993
1119
993
920
872
1384
1159
920
824
1017
824
663
430
1518
1368
1286
993
1119
993
920
872
1645
1604
1459
1286
1645
1604
1139
969
1816
1677
1597
1372
1266
1181
1047
992
818
634
458
115
757
573
115
180
1.0
SCFM
1460
1310
1228
933
1060
933
859
810
1327
1101
859
761
957
761
598
361
1460
1310
1228
933
1060
933
859
810
1582
1545
1402
1228
1582
1545
1080
908
1768
1630
1551
1327
1220
1135
997
938
761
579
415
105
700
519
105
38
27
5331896-YTG-C-1017
AIRFLOW PERFORMANCE - SIDE DUCT APPLICATION (Continued)
Model
Jumper Position
High Cool
Low Cool
60100
High Heat
Low Heat
High Cool
Low Cool
60125
High Heat
Low Heat
A
B
C
D
A
B
C
D
A
B
C
D
A
B
C
D
A
B
C
D
A
B
C
D
A
B
C
D
A
B
C
D
0.1
SCFM
2149
2013
1936
1719
1629
1558
1453
1410
1739
1558
1410
1323
1594
1323
1181
1025
2149
2013
1936
1719
1629
1558
1453
1410
2259
2093
1908
1760
2259
1965
1701
1683
0.2
SCFM
2114
1977
1900
1685
1591
1516
1406
1361
1705
1516
1361
1270
1553
1270
1118
950
2114
1977
1900
1685
1591
1516
1406
1361
2221
2059
1872
1726
2221
1929
1666
1648
0.3
SCFM
2077
1941
1864
1642
1546
1469
1355
1307
1664
1469
1307
1213
1507
1213
1049
868
2077
1941
1864
1642
1546
1469
1355
1307
2183
2023
1835
1685
2183
1893
1623
1604
External Static Pressure (Inches WC)
0.4
0.5
0.6
0.7
SCFM
SCFM
SCFM
SCFM
2030
1989
1948
1905
1898
1860
1816
1772
1822
1783
1739
1695
1600
1555
1508
1465
1502
1455
1409
1362
1423
1375
1329
1280
1305
1255
1207
1153
1255
1204
1155
1100
1620
1577
1530
1487
1423
1375
1329
1280
1255
1204
1155
1100
1156
1104
1052
993
1462
1415
1369
1321
1156
1104
1052
993
980
913
857
795
788
713
654
591
2030
1989
1948
1905
1898
1860
1816
1772
1822
1783
1739
1695
1600
1555
1508
1465
1409
1362
1502
1455
1423
1375
1329
1280
1305
1255
1207
1153
1255
1204
1155
1100
2142
2099
2060
2015
1977
1938
1896
1852
1792
1753
1709
1665
1641
1598
1552
1510
2060
2015
2142
2099
1851
1813
1769
1724
1580
1535
1488
1445
1560
1515
1468
1424
0.8
SCFM
1859
1726
1649
1418
1315
1232
1100
1044
1441
1232
1044
933
1274
933
743
505
1859
1726
1649
1418
1315
1232
1100
1044
1975
1805
1619
1463
1975
1678
1397
1377
0.9
SCFM
1816
1677
1597
1372
1266
1181
1047
992
1393
1181
992
880
1223
880
696
458
1816
1677
1597
1372
1266
1181
1047
992
1931
1760
1566
1413
1931
1628
1351
1330
1.0
SCFM
1768
1630
1551
1327
1220
1135
997
938
1348
1135
938
821
1178
821
640
415
1768
1630
1551
1327
1220
1135
997
938
1882
1712
1522
1370
1882
1580
1305
1284
NOTES:
1. Airflow tested with dry coil conditions, without air filters, at 230 volts
2. Applications above 0.8" w.c. external static pressure are not recommended.
3. Brushless DC high efficiency enhanced ECM blower motor used for all indoor blower assemblies.
4. Minimal variations in airflow performance data results from operating at 208 volts. Data above may be used in those cases.
5. Minimal variations in airflow performance data results from using downflow duct applications. Data above may be used in those cases.
6. Heating applications tested at 0.50" w.c. esp, and cooling applications tested at 0.30" w.c.esp per standards.
28
Johnson Controls Unitary Products
5331896-YTG-C-1017
ADDITIONAL STATIC RESISTANCE
Size (Tons)
24 (2.0)
30 (2.5)
36 (3.0)
42 (3.5)
48 (4.0)
60 (5.0)
CFM
500
600
700
800
900
1000
1100
1200
700
800
900
1000
1100
1200
1300
700
800
900
1000
1100
1200
1300
1400
1100
1200
1300
1400
1500
1600
1700
1800
1900
2000
1100
1200
1300
1400
1500
1600
1700
1800
1900
2000
1100
1200
1300
1400
1500
1600
1700
1800
1900
2000
BOTTOM DUCT DIMENSIONS (Inches)
1
Wet Indoor Coil Economizer
0.01
0.01
0.01
0.02
0.03
0.04
0.05
0.06
0.01
0.02
0.03
0.04
0.05
0.06
0.07
0.01
0.02
0.03
0.04
0.05
0.06
0.07
0.08
0.02
0.03
0.04
0.05
0.06
0.07
0.07
0.08
0.09
0.09
0.02
0.03
0.04
0.05
0.06
0.07
0.07
0.08
0.09
0.09
0.02
0.03
0.04
0.05
0.06
0.07
0.07
0.08
0.09
0.09
0.00
0.00
0.00
0.01
0.01
0.01
0.01
0.02
0.00
0.01
0.01
0.01
0.01
0.02
0.03
0.00
0.01
0.01
0.01
0.01
0.02
0.03
0.04
0.02
0.02
0.02
0.03
0.04
0.04
0.04
0.04
0.05
0.05
0.02
0.02
0.02
0.03
0.04
0.04
0.04
0.04
0.05
0.05
0.02
0.02
0.02
0.03
0.04
0.04
0.04
0.04
0.05
0.05
Filter/Frame Kit
0.01
0.02
0.04
0.06
0.08
0.10
0.13
0.16
0.04
0.06
0.08
0.10
0.13
0.16
0.17
0.04
0.06
0.08
0.10
0.13
0.16
0.17
0.18
0.04
0.04
0.05
0.05
0.06
0.07
0.08
0.09
0.10
0.11
0.04
0.04
0.05
0.05
0.06
0.07
0.08
0.09
0.10
0.11
0.04
0.04
0.05
0.05
0.06
0.07
0.08
0.09
0.10
0.11
1. The pressure drop through the economizer is greater for 100% outdoor air
than for 100% return air. If the resistance of the return air duct is less than
0.25 IWG, the unit will deliver less CFM during full economizer operation.
Filter pressure drop based on standard filter media tested at velocities not to
exceed 300 ft/min.
Johnson Controls Unitary Products
'
9,(:/22.,1*83
$7%277202)81,7
´
´
&
$
5(7851
$,5'8&7
+2/(´
(
ZLWK´JURPPHW
RSHQLQJIRUJDVSLSH
%
+2/(´
$
IRUKLJK
YROWDJH
6833/<
$,5'8&7
+2/(´ IRU
ORZYROWDJH
)
Model
24, 30
36, 42, 48, 60
A
10
14
B
21.5
13.5
$
C
5
5
D
4.5
3.5
E
47.5
47.5
F
32
42
REAR DUCT DIMENSIONS (Inches)
127(6HH)LJXUHWLWOHG³8QLW'LPHQVLRQV´IRUVLGHKROHVL]HVRI
HOHFWULFDODQGJDVOLQHV
6833/<
$,5'8&7
5(7851
$,5'8&7
$
Model
24, 30
36, 42, 48, 60
$
%
A
9.6
13.6
$
B
22
14
29
5331896-YTG-C-1017
UNIT TYPICAL DUCT APPLICATIONS
ROOF CURB
INSTALLATION
REAR DUCT
ROOF CURB
INSTALLATION
BOTTOM DUCT
SLAB ON
GROUND
INSTALLATION
A032
UNIT TYPICAL SLAB ON GROUND INSTALLATION
TO POWER SUPPLY
RETURN
AIR DUCT
SUPPLY
AIR DUCT
FIELD-SUPPLIED
DISCONNECT
SWITCH
CONDENSATE
DRAIN
MANUAL GAS
SHUTOFF VAVLE
TO GAS
SUPPLY LINE
30
CONTROL WIRING TO
INDOOR THERMOSTAT
A0325-001
Johnson Controls Unitary Products
5331896-YTG-C-1017
UNIT TYPICAL ROOF CURB INSTALLATION
ROOF
CONDENSATE
DRAIN
MANUAL GAS
SHUTOFF VAVLE
ROOF CURB
FIELD-SUPPLIED
DISCONNECT
SWITCH
TO GAS
SUPPLY LINE
TO POWER SUPPLY
CONTROL WIRING TO
INDOOR THERMOSTAT
RETURN
AIR DUCT
Johnson Controls Unitary Products
SUPPLY
AIR DUCT
A0326-
31
NOTES
Subject to change without notice. Published in U.S.A.
Copyright © 2017 by Johnson Controls, Inc. All rights reserved.
York International Corp.
5005 York Drive
Norman, OK 73069
5331896-YTG-C-1017
Supersedes: 5331896-YTG-B-0817
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement