Lincoln Electric KH505 Anti Spatter Non-Stick Spray Use and Care Manual

Lincoln Electric KH505 Anti Spatter Non-Stick Spray Use and Care Manual
MATERIAL SAFETY DATA SHEET
WCTA200A
This MSDS complies with OSHA'S Hazard Communication standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER'S INFORMATION
NFPA Rating: Health-2 Flammability-0 Reactivity-0 Special--HMIS Rating: Health-2 Flammability-1 Reactivity-0 Personal Protection-B
DOT Hazard Classification: Consumer Commodity ORMD 48580 Sub 3
Manufacturer's Name:
DYNAFLUX, INC.
Identity (trade name as used on label):
241 Brown Farm Rd.
Cartersville, GA 30120
LINCOLN ELECTRIC ANTISPATTER
Manufactured for: WCTA, LLC Gainesville, GA 30504
Prepared By: GS
MSDS Number: WCTA200A
Revision:
4/13/2010
Information Calls: (800)334-4420
NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
Emergency Response Number: CHEMTEL US: (800)-255-3924 / International: 813-248-0585
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
CAS
SARA
OSHA PEL
ACGIH
Carcinogen
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
NUMBER
III LIST
(PPM)
TLV (ppm) Ref. source*
Dichloromethane
>94% by wt.
75-09-2
YES
25
5
IARC NTP
Carbon Dioxide
124-38-9
NO
5000
5000
d
VOC = 0%
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 104° F
Specific Gravity (H2O=1): 1.37
Vapor Pressure:(PSIG @ 70° F (Aerosols): 80
Vapor Pressure:(Non-Aerosols)(mm Hg and Temperature): 340 @ 20°F
Vapor Density:(Air=1):
Evaporation Rate (BUAC=1): 14.5
2.93
Solubility in Water: Insoluble
Water Reactive: None
Appearance and Odor:
White tinted fluid with hydrocarbon odor
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME
Auto Ignition Temperature
Flammability Limits in Air by % in Volume:
PROJECTION TEST (aerosols) Non-Flammable
999° F
%LEL:
13
%UEL:
23
FLASH POINT AND METHOD USED (non-aerosols):
NA
EXTINGUISHER MEDIA: Water fog; Carbon dioxide
SPECIAL FIRE FIGHT PROCEDURES: Spray containers with water fog to prevent rupturing.
Unusual Fire & Explosion Hazards:
Do not expose aerosols to temperatures above 120 ° F as container may rupture.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY:
[x] STABLE
[ ] UNSTABLE
HAZARDOUS POLYMERIZATION [ ] WILL [ x ] WILL NOT OCCUR
Conditions to Avoid: None Known
Incompatibility (Mat. to Avoid):Sodium, potassium & magnesium metals
Hazardous Decompositon Products: Carbon dioxide, carbon monoxide and small amounts of hydrogen chloride and phosgene.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ X ] INHALATION [ ] INGESTION [ ] SKIN ABSORPTION [ ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS:
Inhalation: Headaches, dizziness, nausea, respiratory irritation
Eye contact: Redness and watering of the eyes; eye irritant.
Skin contact:Possible mild irritation due to defatting of skin by the chlorinated solvent.
Ingestion:
Nausea, possible aspiration pneumonitis if vomited.
CHRONIC EFFECTS: Skin and eye irritant.
Medical conditions Generally Aggravated by Exposure: Irregular heart beat
Carcinogenicity: Methylene Chloride has been shown to increase the rate on spontaneously occurring malignant tumors in laboratory mice and
benign tumors in laboratory rats. It is not believed to pose a measurable carcinogenic risk to man when handled as recommended.
It has been listed as a possible carcinogen by IARC and NTP.
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for fifteen minutes. Get medical attention.
Skin Contact: Wash with soap and water. See physician if irritation develops.
Inhalation: Primary route of exposure. Remove to fresh air. Resuscitate if necessary.
Ingestion:
Unlikely route of exposure. Do Not Induce Vomiting. Call a physician.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): In closed area use NIOSH approved positive air respirators.
Protective Gloves: Rubber gloves recommended.
Eye Protection: Safety Glasses
Ventilation Requirements: Adequate to keep vapor conc. below TLV.
Other Protective Clothing & Equipment: None
Hygienic Work Practices: Wash hands before handling food.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken if Material Is Spilled Or Released:
Small spills, mop up, wipe up or soak up immediately. Large spills, transfer to closed metal containers. Keep out of water supply.
Waste Disposal Methods: Aerosol cans, when vented to atmospheric pressure through normal use pose no disposal problem.
Precautions To Be Taken In Handling & Storage:
Avoid breathing vapors. Do not puncture or incinerate container. Do not store at temperatures above 120° F.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty
or guarantee of any kind.
*Chemical Listed as Carcinogen or Potential Carcinogen. [a] NPT [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement