DATA SHEET

SOLAR SAGM 06 315

MODEL SAGM 06 315

VOLTAGE 6

CAPACITY 315Ah @ 20Hr

MATERIAL Polypropylene

BATTERY VRLA AGM / Non-Spillable / Maintenance-Free

COLOR Maroon

WATERING No Watering Required

IEC 61427 8+ Years Life

6 VOLT

PHYSICAL SPECIFICATIONS

MODEL NAME TERMINAL TYPE D

SAGM 06 315 M8/LT

LENGTH

11.66 (296)

DIMENSIONS B INCHES (mm)

WIDTH

6.94 (176)

HEIGHT C

13.99 (355)

ELECTRICAL SPECIFICATIONS

VOLTAGE CAPACITY  A AMP-HOURS (Ah)

6

10-Hr

278

20-Hr

315

48-Hr

326

72-Hr

331

100-Hr

335

CHARGING INSTRUCTIONS

CHARGER VOLTAGE SETTINGS (AT 77°F/25°C)

SYSTEM VOLTAGE

Maximum Charge Current (A)

6V

Absorption Voltage (2.40 V/cell) 7.20

12V

14.40

24V

20% of C

20

28.80

Float Voltage (2.25 V/cell) 6.75

13.50

27.00

36V

43.20

40.50

Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under or overcharging will damage the battery and shorten its life as with any battery.

48V

57.60

54.00

WEIGHT F LBS. (kg)

95 (43)

HANDLES

Braided Rope

INSTALLATION ORIENTATION

Horizontal and Vertical

ENERGY (kWh)

20-Hr

1.89

INTERNAL RESISTANCE (mΩ) SHORT CIRCUIT CURRENT (amps)

1.7

3600

CHARGING TEMPERATURE COMPENSATION

ADD SUBTRACT

0.005 volt per cell for every 1°C below 25°C

0.0028 volt per cell for every 1°F below 77°F

0.005 volt per cell for every 1°C above 25°C

0.0028 volt per cell for every 1°F above 77°F

OPERATIONAL DATA

OPERATING TEMPERATURE

-4°F to 122°F (-20°C to +50°C). At temperatures below 32°F (0°C) maintain a state of charge greater than 60%.

SELF DISCHARGE

Less than 3% per month depending on storage temperature conditions.

RECYCLE RESPONSIBLY

6V

AGM

STATE OF CHARGE MEASURE OF OPEN-CIRCUIT VOLTAGE

PERCENTAGE CHARGE CELL 6 VOLT

100 2.14

6.42

75 2.09

6.27

50

25

2.04

1.99

6.12

5.97

0 1.94

5.82

5000

4500

4000

3500

3000

2500

2000

1500

1000

500

0

0% 20%

SOLAR CYCLE-LIFE

40% 60% 80% 100%

140

120

100

80

60

40

20

0

-20

-40

0%

PERCENT CAPACITY VS. TEMPERATURE

20% 40% 60% 80% 100%

60

50

40

30

20

10

-30

120%

-40

0

-10

-20

100

SELF DISCHARGE VS. TIME E

H

7 6

NOTES: UNLESS OTHERWISE SPECIFIED

80

75

1. ALL DIMENSIONS ARE NOMINAL.

2. HEAT SEAL MELT = 0.100".

TROJAN SAGM 06 315 PERFORMANCE

2.14

100.0

5

ZONE

7 4 6 3

1. ALL DIMENSIONS ARE NOMINAL.

2. HEAT SEAL MELT = 0.100".

5 2

10°C (50°F)

INITIAL RELEASE; ECO4501

ZONE

Recharge Threshold @ 75% SOC

H

REMOVE CROSS SECTION SIDE VIEW; MOVE DIMENSION; COR4771

REMOVING LETTERS FROM VENTS; COR4788

10.0

4

REV

1

B

DATE

12/11/14

3

DESCRIPTION

G

40

40°C (104°F)

G

30°C (86°F)

2.02

G

20 1.98

F

E

0

0 2 4 6 8 F 10

Storage Time in Months

12 14 16

1.94

BATTERY DIMENSIONS

7

(shown with M8, height is 15.15 (385) with LT)

H E

11.66 (296)

LENGTH

6

1. ALL DIMENSIONS ARE NOMINAL.

2. HEAT SEAL MELT = 0.100".

11.66 (296)

LENGTH

1.0

1 10

Current (Amps)

5

ZONE

4

INITIAL RELEASE; ECO4501

F

3

DESCRIPTION

100

2

2

D

G D

D

SCALE 0.400

SCALE 0.400

REV

1

A

B

C

DATE

7/14/14

12/11/14

12/17/14

H

G

F

REV

1

A

B

C

DATE

7/14/14

12/11/14

12/17/14

H

E

G

D

C

F

13.99 (355)

HEIGHT

13.65 (347)

C

13.99 (355)

HEIGHT

F

C

B

A

11.60 (295)

E B

TERMINAL CONFIGURATIONS D

A

6.89 (175)

11.66 (296)

LENGTH

11.60 (295)

7

15 M8

6

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED-

Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

5

M8

7 4 6 3

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED-

Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

Battery Height with Terminal in Inches (mm)

10.57 (268)

C

Torque Values in-lb (Nm)

Bolt: 85 – 90 (10 – 11)

15

B

6.94 (176)

WIDTH

12380 CLARK ST. SANTA FE SPRINGS, CA 90670

5194 MINOLA DR. LITHONIA, GA 30038

THIS DRAWING AND DATA EMBODY

PROPRIETARY INFORMATION WHICH

IS THE CONFIDENTIAL PROPERTY

OF TROJAN BATTERY COMPANY

WHICH SHALL NOT BE COPIED,

REPRODUCED DISCLOSED TO

OTHERS OR USED IN WHOLE OR

6.89 (175)

CO. THIS DRAWING IS LOANED IN

CONFIDENCE WITH THE

UNDERSTANDING THAT IT SHALL

BE RETURNED ON DEMAND

TITLE

UNLESS OTHERWISE

SPECIFICED

TOLERANCES ARE:

X.X 0.02"

X.XX 0.01"

X.XXX 0.005"

5

M8

ANGLES = 0 30'

DWN BY

J305 AGM MKTG M8

A. SAN

DATE 12-5-2014

SCALE

CSIZE=DWG SCALE

DWG NO

4

CHK

721018

APPVD

REV

C

Battery Height with Terminal in Inches (mm)

15.15 (385)

13.65 (347)

Torque Values in-lb (Nm)

Connection to M8: 85 – 90 (10 – 11)

13.99 (355)

HEIGHT

UNLESS OTHERWISE

TOLERANCES ARE:

(ADAPTER PROVIDED BUT NOT INSTALLED)

3

SCALE 0.400

X.X 0.02"

X.XX 0.01"

X.XXX 0.005"

ANGLES = 0 30'

Connection to LT: 65 – 75 (7.5 – 8.5)

Bolt Size

M8 x 1.25

E

C

B

B

12380 CLARK ST. SANTA FE SPRINGS, CA 90670

5194 MINOLA DR. LITHONIA, GA 30038

TITLE

THIS DRAWING AND DATA EMBODY

PROPRIETARY INFORMATION WHICH

IS THE CONFIDENTIAL PROPERTY

OF TROJAN BATTERY COMPANY

WHICH SHALL NOT BE COPIED,

REPRODUCED DISCLOSED TO

OTHERS OR USED IN WHOLE OR

PART FOR ANY PURPOSE WITHOUT

THE EXPRESS WRITTEN

PERMISSION OF TROJAN BATTERY

CO. THIS DRAWING IS LOANED IN

CONFIDENCE WITH THE

UNDERSTANDING THAT IT SHALL

BE RETURNED ON DEMAND

D

J305 AGM MKTG M8

DWN BY

A. SAN

DATE 12-5-2014 DWG NO

CHK

721018

APPVD

REV

C

B

A. The amount of amp-hours (Ah) a battery can deliver when discharged at a constant rate at 86°F (30°C) for all rates and maintain a voltage above 1.75 V/cell. Capacities are based on peak performance.

B. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches

(12.7 mm) spacing minimum.

TROJAN BATTERY

COMPANY WITH

QUALITY SYSTEM

CERTIFIED BY DNV

= ISO 9001:2015 =

A

6

C. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.

D. Terminal images are representative only.

11.60 (295)

Weight may vary.

6.89 (175)

Designed in compliance with applicable BCI, DIN, BS and IEC standards.

5

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED-

Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

800.423.6569 / +1.562.236.3000 / trojanbattery.com

4 3

UNLESS OTHERWISE

SPECIFICED

TOLERANCES ARE:

X.X 0.02"

X.XX 0.01"

X.XXX 0.005"

ANGLES = 0 30'

THIS DRAWING AND DATA EMBODY

PROPRIETARY INFORMATION WHICH

IS THE CONFIDENTIAL PROPERTY

OF TROJAN BATTERY COMPANY

WHICH SHALL NOT BE COPIED,

REPRODUCED DISCLOSED TO

OTHERS OR USED IN WHOLE OR

PART FOR ANY PURPOSE WITHOUT

THE EXPRESS WRITTEN

PERMISSION OF TROJAN BATTERY

CO. THIS DRAWING IS LOANED IN

CONFIDENCE WITH THE

UNDERSTANDING THAT IT SHALL

BE RETURNED ON DEMAND

12380 CLARK ST. SANTA FE SPRINGS, CA 90670

5194 MINOLA DR. LITHONIA, GA 30038

TITLE

DWN BY

J305 AGM MKTG M8

A. SAN

SCALE

CSIZE=DWG SCALE

CHK

DATE 12-5-2014 DWG NO 721018

APPVD

REV

C

SAGM_06_315_DS_021319

© 2019 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this publication at any time, without notice or obligation.