Monogram ZV925SLSS 36" Glass Canopy Island Hood Installation Instructions

INSTALLATION
INSTRUCTIONS
36” Island Chimney Vent Hood
ZV925
MONOGRAM.COM
Safety Information
BEFORE YOU BEGIN
Read these instructions completely and carefully.
Ŷ
IMPORTANT — Save these instructions
for local inspector’s use.
IMPORTANT
— Observe all governing
codes and ordinances.
ŶNote to Installer — Be sure to leave these
instructions with the Consumer.
ŶNote to Consumer — Keep these instructions with
your Owner’s Manual for future reference.
ŶSkill Level — Installation of this appliance requires
basic mechanical and electrical skills.
ŶCompletion Time — 1 to 3 Hours.
Ŷ3URSHULQVWDOODWLRQLVWKHUHVSRQVLELOLW\RIWKHLQVWDOOHU
3URGXFWIDLOXUHGXHWRLPSURSHULQVWDOODWLRQLVQRW
covered under the warranty.
Ŷ)RU0RQRJUDPORFDOVHUYLFHLQ\RXUDUHDYLVLW
monogram.com.
Ŷ)RU0RQRJUDPVHUYLFHLQ&DQDGDYLVLWmonogram.ca
Ŷ)RU0RQRJUDP3DUWVDQG$FFHVVRULHVYLVLW
monogram.com/use-and-care/parts.
Ŷ
CAUTION Due to the weight and size of these
vent hoods and to reduce the risk of personal injury
RUGDPDJHWRWKHSURGXFW TWO PEOPLE ARE
REQUIRED FOR PROPER INSTALLATION.
ATTENTION
À cause du poids et de la taille de
ces hottes et pour reduire le risque de blessures et
GHGRPPDJHVIL FAUT DEUX PERSONNES POUR
FAIRE L’INSTALLATION CORRECTEMENT.
WARNING To reduce the risk of fire or electrical
VKRFNGRQRWXVHWKLVUDQJHKRRGZLWKDQ\H[WHUQDO
VROLGVWDWHVSHHGFRQWUROGHYLFH$Q\VXFKDOWHUDWLRQ
from original factory wiring could result in damage to
the unit and/or create an electrical safety hazard.
AVERTISSEMENT
3RXUUpGXLUHOHULVTXH
G¶LQFHQGLHRXGHFKRFpOHFWULTXHLOQHIDXWSDV
XWLOLVHUFHWWHKRWWHDYHFXQUpJXODWHXUGHYLWHVVH
pOHFWURQLTXHH[WHUQH7RXWHPRGLILFDWLRQGHFHW\SHGX
branchement d’usine peute endommager l’appareil ou
FUpHUXQULVTXHGHFKRFpOHFWULTXH
TO REDUCE THE RISK OF FIRE, USE ONLY
METAL DUCTWORK.
WARNING 725('8&(7+(5,6.2)),5(
(/(&75,&$/6+2&.25,1-85<723(56216
2%6(59(7+()2//2:,1*
$8VHWKLVXQLWRQO\LQWKHPDQQHULQWHQGHGE\WKH
PDQXIDFWXUHU,I\RXKDYHDQ\TXHVWLRQVFRQWDFW
the manufacturer.
%%HIRUHVHUYLFLQJRUFOHDQLQJWKHXQLWVZLWFKWKH
power off at the service panel and lock the service
disconnecting means to prevent the power from
EHLQJVZLWFKHGRQDFFLGHQWDOO\:KHQWKHVHUYLFH
GLVFRQQHFWLQJPHDQVFDQQRWEHORFNHGVHFXUHO\
IDVWHQDSURPLQHQWZDUQLQJGHYLFHVXFKDVDWDJ
to the service panel.
AVERTISSEMENT
32855e'8,5(/(5,648(
'¶,1&(1',('(&+2&e/(&75,48(28'(
%/(6685(6,/)$872%6(59(5/(65(*/(6
68,9$17(6
$8WLOLVHUFHWDSSDUHLOXQLTXHPHQWGHODPDQLpUH
SUpYXHSDUOHIDEULFDQW(QFDVGHTXHVWLRQ
consulter le fabricant.
%$YDQWWRXWHLQWHUYHQWLRQRXQHWWR\DJHFRXSHU
O¶DOLPHQWDWLRQpOHFWULTXHDXGLVMRQFWHXUHWYHUURXLOOHU
OHSDQQHDXGXGLVMRQFWHXUSRXUpYLWHUODPLVHVRXV
tension accidentelle. S’il n’est pas possible de
YHUURXLOOHUOHSDQQHDXGXGLVFRQFWHXUDWWDFKHUXQ
SODFDUGRXXQHpWLTXHWWHWUpVYLVLEOHDXSDQQHDX
Ŷ)RUJHQHUDOYHQWLODWLQJXVHRQO\'RQRWXVHWRH[KDXVW
KD]DUGRXVRUH[SORVLYHPDWHULDOVRUYDSRUV
Ŷ6WUXFWXUDOIUDPLQJLQVWDOODWLRQZRUNDQGHOHFWULFDO
wiring must be done by qualified person(s) in
accordance with all applicable codes and standards
including fire-rated construction.
Ŷ6XIILFLHQWDLULVQHHGHGIRUSURSHUFRPEXVWLRQDQG
H[KDXVWLQJRIJDVHVWKURXJKWKHIOXH FKLPQH\ RIIXHO
EXUQLQJHTXLSPHQWWRSUHYHQWEDFNGUDIWLQJ)ROORZ
the heating equipment manufacturer’s guidelines
and safety standards such as those published by
WKH1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ 1)3$ DQG
WKH$PHULFDQ6RFLHW\IRU+HDWLQJ5HIULJHUDWLRQDQG
$LU&RQGLWLRQLQJ(QJLQHHUV $6+5$( DQGWKHORFDO
FRGHDXWKRULWLHV:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS
(replacement) air system in accordance with local
EXLOGLQJFRGHUHTXLUHPHQWV9LVLW*($SSOLDQFHVFRP
for available makeup air solutions.
Ŷ/RFDOFRGHVYDU\,QVWDOODWLRQRIHOHFWULFDOFRQQHFWLRQV
and grounding must comply with applicable codes.
,QWKHDEVHQFHRIORFDOFRGHVWKHYHQWVKRXOGEH
LQVWDOOHGLQDFFRUGDQFHZLWK1DWLRQDO(OHFWULFDO&RGH
$16,1)3$RUODWHVWHGLWLRQ
CAUTION To reduce risk of fire and to properly
H[KDXVWDLUEHVXUHWRGXFWDLURXWVLGH²GRQRWYHQW
H[KDXVWDLULQWRVSDFHVZLWKLQZDOOVRUFHLOLQJVRULQWR
DWWLFVFUDZOVSDFHVRUJDUDJHV
ATTENTION
Il faut prendre soin d’installer
XQFRQGXLWYHUVO¶H[WpULHXUSRXUUpGXLUHOHULVTXH
G¶LQFHQGLHHWSRXYRLUpYDFXHUO¶DLUFRUUHFWHPHQW,O
QHIDXWSDVpYDFXHUO¶DLUFRUUHFWHPHQW,OQHIDXWSDV
pYDFXHUO¶DLUGDQVO¶HVSDFHHQWUHOHVSDURLVG¶XQPXU
XQSODIRQGRXXQJUHQLHUXQHVSDFHVDQLWDLUHRXXQ
garage.
READ AND SAVE THESE INSTRUCTIONS
2
49-80329 Rev. 5
Design Information
CONTENTS
Design Information
3URGXFW'LPHQVLRQV ...................................................... 3
Advance Planning
$GYDQFH3ODQQLQJ ........................................................ 4
3RZHU6XSSO\ ............................................................... 4
'XFW)LWWLQJV ................................................................ 5
Installation Preparation
Tools and Materials Required ....................................... 6
5HPRYHWKH3DFNDJLQJ ................................................ 6
Installation Height ......................................................... 3DUWV3URYLGHG .............................................................. 8
Installation Preparation
Construct Ceiling Support ............................................. Installation Instructions—Vented to the Outside
6WHS0RXQW7HPSODWH .............................................. 12
6WHS$GMXVW)UDPH+HLJKW ....................................... 12
6WHS&XW'XFWWR/HQJWKIRU9HQWHG,QVWDOODWLRQ...... 13
6WHS,QVWDOOWKH6XSSRUW)UDPH ............................... 13
6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV..................... 13
6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 14
6WHS&RQQHFW&DEOHV .............................................. 14
6WHS&RQQHFW(OHFWULFDO ........................................... 15
6WHS3UHSDUHWKH'XFW&RYHUV ................................ 16
6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 16
6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 6WHS,QVWDOO'XFW&RYHU7ULP ................................. 6WHS,QVWDOO0HWDO)LOWHU.......................................... 6WHS)LQDOL]H,QVWDOODWLRQ ....................................... Installation Instructions—Recirculating
6WHS0RXQW7HPSODWH .............................................. 18
6WHS$GMXVW)UDPH+HLJKW ....................................... 18
6WHS,QVWDOO$LU'HIOHFWRU&XW'XFW
for Recirculating Operation ............................. 6WHS,QVWDOO8SSHU6XSSRUW)UDPH .......................... 6WHS,QVWDOO/RZHU6WUXFWXUHWR8SSHU6WUXFWXUH ..... 6WHS,QVWDOO%ORZHU0RWRU ........................................ 6WHS,QVWDOO+RRG$WWDFKPHQW6FUHZV..................... 6WHS0RXQWWKH+RRGRQWRWKH6XSSRUW .................. 6WHS&RQQHFW&DEOHV .............................................. 21
6WHS&RQQHFW(OHFWULFDO ......................................... 21
6WHS3UHSDUHWKH'XFW&RYHUV .............................. 22
6WHS,QVWDOO8SSHU'XFW&RYHU .............................. 22
6WHS,QVWDOO/RZHU'XFW&RYHU .............................. 22
6WHS,QVWDOO'XFW&RYHU7ULP ................................. 23
6WHS,QVWDOO)LOWHUV.................................................. 23
6WHS)LQDOL]H,QVWDOODWLRQ ....................................... 23
PRODUCT DIMENSIONS
*Height to
*Height
ceiling
to
Ceiling
24" min.*
PD[
3/4"
32 1/4"
9/16"
27
7/8"
35
7KHVXSSOLHGGXFWFRYHUILWV¶´WR¶FHLOLQJKHLJKWV
)RU¶´WR¶´FHLOLQJVRUGHU=;
36" min.
([DFWLQVWDOODWLRQ
height depends on
ceiling height.
These vent hoods are supplied with a support frame for
FHLOLQJKHLJKWVRI¶´WR¶´
Decorative duct covers conceal the ductwork running
from the top of the hood to the ceiling.
=;DFFHVVRU\LVDYDLODEOHIRUFHLOLQJKHLJKWVRI
¶´WR¶´
NOTE: Installation height should be measured from the
cooking surface to the bottom of the outer glass portion
of the hood.
49-80329 Rev. 5
7KLVKRRGPXVWEHLQVWDOOHG´PLQDQG´PD[
above the cooking surface. The cooking surface should
EHDWOHDVW´DERYHWKHIORRU
7KLVKRRGPD\EHYHQWHGWRWKHRXWGRRUVRULWFDQEH
installed for recirculating operation.
This hood can be installed over any Monogram electric
or gas cooktop. It cannot be installed over a Monogram
3URIHVVLRQDOFRRNWRSRUUDQJH
3
Installation Preparation
ADVANCE PLANNING
POWER SUPPLY
Ductwork Planning
Ŷ7KHVHYHQWKRRGVDUHHTXLSSHGIRU´URXQG
ductwork.
IMPORTANT - (Please read carefully)
Ŷ'HWHUPLQHWKHH[DFWORFDWLRQRIWKHYHQWKRRG
$33/,$1&(0867%(3523(5/<*5281'('
Ŷ3ODQWKHURXWHIRUYHQWLQJH[KDXVWWRWKHRXWGRRUV
Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH
)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOG
QRWH[FHHGIWHTXLYDOHQWOHQJWKIRUDQ\GXFW
configurations.
Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH
PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH
outdoors.
Ŷ8VHULJLGPHWDOGXFWZRUNRQO\
Ŷ,QVWDOODURRIFDSZLWKGDPSHUDWWKHH[WHULRU
opening. Order the cap and any transitions needed
in advance.
Ŷ:KHQDSSOLFDEOHLQVWDOODQ\PDNHXS UHSODFHPHQW air system in accordance with local building code
UHTXLUHPHQWV9LVLW*($SSOLDQFHVFRPIRUDYDLODEOH
makeup air solutions.
Ductwork Planning
Ŷ7KHVHYHQWKRRGVDUHKHDY\$GHTXDWHVWUXFWXUDO
support must be provided. The ceiling structure
must be capable of supporting the weight of the
hood and any inadvertent user contact loads
DSSUR[LPDWHO\SRXQGV 7KHKRRGVXSSRUW
IUDPHZLOOEHVXSSRUWHGE\[FURVVIUDPLQJ
Ŷ,QVWDOODWLRQZLOOEHHDVLHULIWKHYHQWKRRGLVLQVWDOOHG
before the cooktop or countertop below is installed.
Accessory Duct Cover
Ŷ$OOPRGHOVDUHVKLSSHGZLWKDGXFWFRYHUIRUFHLOLQJ
KHLJKWVRI¶´WR¶
=;DFFHVVRU\ duct cover is available
WRUHDFK 1" WR 1" ceiling heights. The
accessory should be ordered with the hood and be
on site before final framing and wall finishing.
4
WARNING )253(5621$/6$)(7<7+,6
AVERTISSEMENT
3285'(65$,6216
'(6e&85,7e&(7$33$5(,/'2,7Ç75(
&255(&7(0(170,6¬/$7(55(
Remove house fuse or open circuit breaker before
beginning installation.
'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJZLWK
WKLVDSSOLDQFH)ROORZ1DWLRQDOHOHFWULFDOFRGHVRU
prevailing local codes and ordinances.
Electrical supply
7KHVHYHQWKRRGVPXVWEHVXSSOLHGZLWK9+]
DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\JURXQGHG
EUDQFKFLUFXLWDQGSURWHFWHGE\DRUDPSFLUFXLW
breaker or time delay fuse.
Ŷ:LULQJPXVWEHZLUHZLWKJURXQG
Ŷ,IWKHHOHFWULFDOVXSSO\GRHVQRWPHHWWKHDERYH
UHTXLUHPHQWVFDOODOLFHQVHGHOHFWULFLDQEHIRUH
proceeding.
Ŷ5RXWHKRXVHZLULQJLQWKHFHLOLQJDVFORVHWRWKH
LQVWDOODWLRQORFDWLRQDVSRVVLEOH$OORZDGGLWLRQDO
OHQJWKIURPFHLOLQJMRLVWVWRUHDFKWKHMXQFWLRQER[
on the bottom of the hood support frame.
Ŷ&RQQHFWWKHZLULQJWRWKHKRXVHZLULQJLQ
accordance with local codes.
Grounding instructions
The grounding conductor must be connected to
DJURXQGPHWDOSHUPDQHQWZLULQJV\VWHPRUDQ
equipment-grounding terminal or lead on the hood.
WARNING The improper connection of the
equipment-grounding conductor can result in a risk
of electric shock. Check with a qualified electrician or
service representative if you are in doubt whether the
appliance is properly grounded.
AVERTISSEMENT
Le mauvais branchement du fil
GHPLVHjODWHUUHSHXWFDXVHUXQFKRFpOHFWULTXH(Q
FDVGHGRXWHFRQVXOWHUXQpOHFWULFLHQTXDOLILpRXXQ
WHFKQLFLHQSRXUGpWHUPLQHUVLO¶DSSDUHLOHVWjODWHUUH
49-80329 Rev. 5
Installation Preparation
DUCT FITTINGS
This Hood Must Use an 8” Round
Duct. It Can Transition to a
3-1/4” x 12” Duct.
8VHWKLVFKDUWWRFRPSXWHPD[LPXPSHUPLVVLEOHOHQJWKV
for duct runs to outdoors.
NOTE:'RQRWH[FHHGPD[LPXPSHUPLVVLEOHHTXLYDOHQW
lengths!
Maximum duct length: 100 foot for range hoods.
Duct Piece
Dimensions
Equivalent
Length*
5RXQG
straight
1 ft. (per foot
length)
´[´
straight
1 ft. (per foot
length)
ƒHOERZ
IW
ƒHOERZ
IW
´[´
ƒHOERZ
43 ft.
´[´
ƒHOERZ
26 ft.
´[´
ƒIODW
elbow
IW
´URXQGWR
´[´
transition
2 ft.
´[´
WR´URXQG
transition
5 ft.
Quantity
Used
Total
Equivalent
Length
Flexible ducting
,IIOH[LEOHPHWDOGXFWLQJLVXVHGDOOWKHHTXLYDOHQWIHHW
YDOXHVLQWKHWDEOHVKRXOGEHGRXEOHG7KHIOH[LEOHPHWDO
GXFWVKRXOGEHVWUDLJKWDQGVPRRWKDQGH[WHQGHGDV
much as possible.
DO NOTXVHIOH[LEOHSODVWLFGXFWLQJ
NOTE: $Q\KRPHYHQWLODWLRQV\VWHPVXFKDVD
YHQWLODWLRQKRRGPD\LQWHUUXSWWKHSURSHUIORZRI
FRPEXVWLRQDLUDQGH[KDXVWUHTXLUHGE\ILUHSODFHVJDV
IXUQDFHVJDVZDWHUKHDWHUVDQGRWKHUQDWXUDOO\YHQWHG
systems. To minimize the chance of interruption of such
QDWXUDOO\YHQWHGV\VWHPVIROORZWKHKHDWLQJHTXLSPHQW
manufacturer’s guidelines and safety standards such
DVWKRVHSXEOLVKHGE\1)3$DQG$6+5$(:KHQ
DSSOLFDEOHLQVWDOODQ\PDNHXS UHSODFHPHQW DLUV\VWHP
in accordance with local building code requirements. Visit
GEAppliances.com for available makeup air solutions.
´URXQGWR
6 ft.
´[´
WUDQVLWLRQƒ
elbow
´[´
13 ft.
WR´URXQG
WUDQVLWLRQƒ
elbow
Round wall
cap with
damper
32 ft.
´[´
wall cap with
damper
IW
Round roof
cap
44 ft.
Total Duct Run
$
FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFWILWWLQJ
equivalent. Equivalent length of duct pieces
DUHEDVHGRQDFWXDOWHVWVFRQGXFWHGE\*(
$SSOLDQFHV(YDOXDWLRQ(QJLQHHULQJDQGUHIOHFW
requirements for good venting performance
with any ventilation hood.
49-80329 Rev. 5
5
Installation Preparation
TOOLS AND MATERIALS REQUIRED
(NOT SUPPLIED)
3/8" swivel
socket or pivoting
KH[VRFNHWZLWK
H[WHQVLRQV
Duct tape
:LUHFXWWHUVWULSSHU
Hammer
Key hole saw
Electric or battery-operated drill
DQGELWV3KLOOLSVDQGIODW
blade screwdriver bits.
3HQFLODQGWDSHPHDVXUH
Safety glasses
Spirit level
8" round metal
GXFWOHQJWKWR
suit installation.
:LUHQXWV
)ODVKOLJKW
Saber saw
or sawsall
Step ladder
3KLOOLSVDQG
flat blade
screwdrivers
Strain relief for
junction cover.
9+]RU$PS
2-wire with ground. properly
grounded branch circuit.
Carpenter’s square
3OLHUV
Metal snips
REMOVE THE PACKAGING
CAUTION /,)77+(+22'2872)7+(%2;
%<7+(&(17(50(7$/3257,21'2127/,)7%<
7+(*/$666,'(6
ATTENTION
/(9(=/$+277(¬/¶(;7e5,(85
'(/$%2Ì7(3$5/$3257,210e7$/&(175$/
1(/(9(=3$63$5/(6&Ð7e6'(9(55(
CAUTION :HDUJORYHVWRSURWHFWDJDLQVW
sharp edges.
ATTENTION
3RUWH]GHVJDQWVSRXUpYLWHUOHV
EOHVVXUHVFDXVpHVSDUOHVWUDQFKDQWV
6
Ŷ*UDVSWKHKRRGE\WKHPHWDOLQVHUWLQWKHFHQWHUDQG
OLIWVWUDLJKWXSDQGRXWRIWKHER[
Ŷ5HPRYHDQGSURSHUO\GLVFDUGWKHSODVWLFZUDSSLQJ
Ŷ5HPRYHSDUWVER[GXFWFRYHUVDQGRWKHUSDFNDJLQJ
49-80329 Rev. 5
Installation Preparation
Ceiling
Height
Mounting Frame
Height (inches)
Trim
Needed
Ŷ'HFRUDWLYHGXFWFRYHUVDUHSURYLGHGWRFRQFHDOWKH
ductwork running to the ceiling.
Possible Hood
Installation
Height (inches)
26
$
Ŷ7KLVKRRGFDQEHLQVWDOOHGIRUUHFLUFXODWLQJ
RSHUDWLRQ1RNLWVUHTXLUHG
8’
$
24
34 1/2
B
7KHKRRGLQVWDOODWLRQKHLJKWIURPWKHFRRNLQJVXUIDFH
WRWKHERWWRPRIWKHKRRGGHSHQGVXSRQFHLOLQJ
height.
28
$
25
34 1/2
B
$
)RURSWLPXPSHUIRUPDQFHWKHKRRGPXVWEH´PLQ
DQG´PD[DERYHWKHFRRNLQJVXUIDFH
3"
26
34 1/2
B
$
Use the chart on this page to accurately determine
LQVWDOODWLRQKHLJKWDQGVXSSRUWIUDPHDGMXVWPHQWDQG
WRVHOHFWWKHFRUUHFWVL]HWRSWULPSLHFH $%&RU' 34 1/2
B
24
38 1/2
C
28
34 1/2
B
25
38 1/2
C
34 1/2
B
26
38 1/2
C
34 1/2
B
38 1/2
C
24
42 1/2
D
DETERMINE INSTALLATION HEIGHT
D
C
B
$
=;$FFHVVRU\'XFWFRYHULQFOXGHVD´
long duct cover and 3 sets of duct cover top trim
SLHFHVODEHOHG()*
28
38 1/2
C
25
42 1/2
D
38 1/2
C
26
42 1/2
D
38 1/2
C
42 1/2
D
ZX92510 Accessory Duct Cover
49-80329 Rev. 5
24
46 1/2
E
28
42 1/2
D
25
46 1/2
E
42 1/2
D
26
46 1/2
E
3"
42 1/2
D
46 1/2
E
24
)
28
46 1/2
E
25
)
46 1/2
E
26
)
46 1/2
E
)
24
54 1/2
*
28
)
25
54 1/2
*
)
26
54 1/2
*
)
54 1/2
*
28
54 1/2
*
Installation Preparation
PARTS PROVIDED
Locate the parts packed with the hood.
Stainless steel filter
$LUGHIOHFWRUIRU
recirculating installation
1 charcoal filter for
recirculating installation
HARDWARE PACKAGE
Locate and check
contents. Screws
shown actual size.
6 ceiling
mounting
screws
12 sheet
metal
screws
Telescoping support
frame
Upper duct cover trim pieces
2 each of 4 sizes
12 cage
nuts
VFUHZVWRWDO
• 24 support frame screws
‡KRRGDWWDFKPHQW
screws
• 2 upper duct cover
attachment screws
• 4 recirculating
deflector screws
• 2 duct cover bracket
2 Duct cover
attachment screws
brackets
2 thumb
screws
Lower duct cover trim pieces
Note: Some additional hardware/screws included.
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
Cut a 1≤ Dia.
Wire Access
Hole
10-1/16≤ to
Centerline
of Holes
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
7-1/16≤ to
Centerline
of Holes
24-3/4"
23-1/4"
81/2
≤
49-80406
Printed in Italy
D
ia
.
04-06 JR
36≤ Hood
Template
Cut a 1≤ Dia.
Wire Access
Hole
7-1/16≤ to
Centerline
of Holes
FRONT OF HOOD
Template
8
Decorative duct covers
(14"ZLGHGHHSZKHQDVVHPEOHG
49-80329 Rev. 5
Installation Preparation
CONSTRUCT CEILING SUPPORT
Plan the Location of the Hood and Ductwork
ŶUse a plumb bob to check the location. The
countertop/cooktop below the hood must be
centered with the hood.
Ceiling
Hood ducting
centerline
Ŷ7KHKRRGVKRXOGH[WHQGEH\RQGWKHIURQW
and rear edge of the cooking appliance.
ŶThe duct in the ceiling must be centered
over the cooktop.
)URQW
13-3/4"
Cooktop
$OLJQZLWKFHQWHU
of cooktop
Countertop
Side view
Ceiling Support Structure
Ŷ$WWKHKRRGORFDWLRQLQVWDOO[FURVVIUDPLQJ
Ŷ$UUDQJHFURVVIUDPLQJLQWKHFHLOLQJWRVXLWWKHH[LVWLQJ
EHWZHHQFHLOLQJMRLVWVDVVKRZQ [¶VDUHUHTXLUHGWR
structure.
support the weight of the hood.)
Ŷ<RXUFHLOLQJMRLVWVZLOOEHOLNHRQHRIWKHIROORZLQJ
H[DPSOHV
Install cross-framing
symmetrically over duct/
cooktop centerline
(;$03/($
16" joist
spacing
´GXFW
[FURVV
framing
)URQW
of
hood
$OLJQGXFWWR
center of cooktop
Cooktop
outline
Top view – ceiling joists parallel to front of hood
49-80329 Rev. 5
Installation Preparation
CONSTRUCT CEILING SUPPORT (Cont.)
(;$03/(%
16" joist
spacing
LQVWDOO
cross-framing
symmetrically over
duct/cooktop
centerline
[FURVV
framing
8" duct
)URQW
of
hood
Cooktop
outline
$OLJQGXFW
to center of
cooktop
Top view – ceiling joists run perpendicular to front of hood
(;$03/(&
LQVWDOOFURVV
framing symmetrically over
duct/cooktop centerline
[FURVV
framing
8" duct
16" joist
spacing
)URQW
of
hood
$OLJQGXFW
to center of
cooktop
Cooktop
outline
Top view – ceiling joists at angle to front of hood
49-80329 Rev. 5
Installation Preparation
CONSTRUCT CEILING SUPPORT (Cont.(
Ŷ6HFXUHHDFK[EORFNZLWKDWOHDVWIRXU ZRRGVFUHZV´ORQJ QRWVXSSOLHG 8VHZRRG
screws total for the two supports.
2x 4 Min.
Cross
Framing
[PLQFURVVIUDPLQJ
ŶThe cross framing must be accurately aligned to
assure correct positioning of the hood.
ŶThe cross framing must be level in all directions.
Check with a spirit level and adjust if necessary.
IMPORTANT: The ceiling structure must be capable of
VXSSRUWLQJWKHZHLJKWRIWKHKRRG DSSUR[LPDWHO\
pounds) and any inadvertent user contact loads. The
KRRGVXSSRUWIUDPHZLOOEHVXSSRUWHGE\WKH[FURVV
framing.
Ceiling
Ceiling
joist
Joist
7-1/16"
10-3/4
Height
Height
adjustment
Adjustment
screws
Screw Holes
Ductwork for Installations Vented to the Outdoors
Ŷ8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWURXWHSRVVLEOH
)RUVDWLVIDFWRU\SHUIRUPDQFHGXFWUXQVKRXOGQRW
H[FHHGIHHWHTXLYDOHQWOHQJWKIRUDQ\GXFW
configuration.
Ŷ5HIHUWR³'XFW)LWWLQJV´FKDUWWRFRPSXWHWKH
PD[LPXPSHUPLVVLEOHOHQJWKIRUGXFWUXQVWRWKH
outdoors.
Ŷ7KLVYHQWKRRGPXVWXVH´URXQGULJLGGXFW
Ŷ,QVWDOOWKHKRXVHGXFWZRUNWRUXQKRUL]RQWDOO\EHWZHHQ
ceiling joists or straight up through the roof.
CeilingJoint
joist
Ceiling
8" Duct
10"
Duct
[
2x4
Vent Vent
straight
up through
Straight
Up
the ceiling
Through
The Ceiling
Finish the Ceiling
Ŷ)LQLVKWKHFHLOLQJVXUIDFH%HVXUHWRPDUNORFDWLRQRI
the ceiling joists and cross framing. Check to be sure
the ceiling is level; use shims if necessary.
49-80329 Rev. 5
11
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
1 MOUNT TEMPLATE
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG
tape in place.
Cut a 1≤ Dia.
Wire Access
Hole
10-1/16≤ to
Centerline
of Holes
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
7-1/16≤ to
Centerline
of Holes
– Be sure the template is oriented correctly with the
front of the hood.
ia
81/2
≤
49-80406
Printed in Italy
D
Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV
will provide parallel alignment with the countertop
below.
.
04-06 JR
36≤ Hood
Template
Cut a 1≤ Dia.
Wire Access
Hole
7-1/16≤ to
Centerline
of Holes
FRONT OF HOOD
Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV
Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´
ELWDQGGULOODSSUR[LPDWHO\´GHHS
Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH
FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR
allow the screw head to engage the keyhole slots on
the support frames.
Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN
1/4" Gap
2 ADJUST FRAME HEIGHT
Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW
Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG
RQWKHFKDUWRQSDJH
Ŷ5HPRYHVFUHZVRQHDFKRIWKH
sides of the frame to loosen the upper
VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU
motor.
Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR
WKHFKDUWRQSDJH8VHDWRWDORI
32 screws (8 screws on each side)
WRVHFXUHWKHXSSHUVWUXFWXUHORZHU
structure and blower/motor together.
12
)UDPH
height
2-3/4"
24"min.
PD[
Ceiling
height
X
36"min.
49-80329 Rev. 5
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
3 CUT DUCT TO LENGTH FOR
5 INSTALL HOOD ATTACHMENT
SCREWS
VENTED
Ŷ0HDVXUHIURPKRXVH
GXFWWRH[KDXVW
opening.
House
duct
Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI
WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ
screw head and support flange.
Ŷ&XWWKH´GXFWOHQJWK
to size.
Ŷ6OLSGXFWRYHUWKH
H[KDXVWRSHQLQJ
Ŷ6HDOWKHFRQQHFWLRQ
with duct tape.
Duct
Duct
length
)UDPH
height
Install 4
attachment
screws
4 INSTALL THE SUPPORT FRAME
Ŷ5DLVHWKHVXSSRUWWRZDUG
the ceiling.
Ŷ7KUHDGWKHKRXVHZLULQJ
through one of the large
KROHVSUHIHUDEO\RQWKHOHIW
side.
Duct
Ŷ&DUHIXOO\HQJDJHWKH
ceiling mounting screws to
WKHNH\KROHVORWV$1'WKH
house duct in the top of the
frame.
Ŷ7LJKWHQWKHPRXQWLQJ
screws against the frame.
Ŷ,QVWDOOVDIHW\VFUHZV
Ŷ8VHGXFWWDSHWRVHDOWKH
duct connection at the top.
Safety screws
Keyhole
slots
House wiring
49-80329 Rev. 5
Keyhole
slots
13
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
6 MOUNT THE HOOD ONTO THE
SUPPORT
WARNING 2 people are required to lift and
7 CONNECT CABLES
Ŷ-RLQWKHWZRFDEOHFRQQHFWRUVDWWKHIURQWRIWKH
hood. Secure the cables behind the retainer clip.
position the hood onto the mounting bracket.
AVERTISSEMENT
,IIDXWGHX[SHUVRQQHVSRXU
lever et mettre en place la hotte sur le support de
montage.
Retainer clip
To lights
To control
panel
Ŷ/LIWWKHKRRGWRWKHERWWRPRIWKHVXSSRUWHQJDJLQJ
the keyhole slots to the 4 mounting screws.
Ŷ7LJKWHQWKHPRXQWLQJVFUHZV
Ŷ,QVWDOODGGLWLRQDOVFUHZVDVVKRZQ
Install
6 screws
14
49-80329 Rev. 5
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
8 CONNECT ELECTRICAL
Verify that power is turned off at the source.
WARNING If house wiring is not 2-wire with a
JURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKHLQVWDOOHU
:KHQKRXVHZLULQJLVDOXPLQXPEHVXUHWRXVH8/
DSSURYHGDQWLR[LGDQWFRPSRXQGDQGDOXPLQXPWR
copper connectors.
AVERTISSEMENT
Si le câblage de la maison n’est
SDVGXW\SHjGHX[ILOVDYHFXQILOGHWHUUHO¶LQVWDOODWHXU
GRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHVILOVGHOD
PDLVRQVRQWHQDOXPLQLXPLOSUHQGUHVRLQG¶XWLOLVHUGHOD
SkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HWGHVFRQQHFWHXUV
pour l’aluminium-cuivre.
Ŷ6HFXUHWKHKRXVHZLULQJWRWKHMXQFWLRQER[ZLWK
a strain relief.
Ŷ
House wiring
-%R[FRYHU
Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXWRQWKH
left side.
Knockout
-%R[FRYHU
Connect white leads to branch circuit white lead.
Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG
Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ
lead or bare ground lead.
Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK
electrical connector.
Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU
Be sure wires are not pinched.
Ŷ6HFXUH-%R[FRYHUZLWKRULJLQDOVFUHZ
49-80329 Rev. 5
15
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
9 PREPARE THE DUCT COVERS
Ŷ5HPRYHWKHSODVWLFSURWHFWLYHFRYHULQJRQDOOGXFW
pieces.
Ŷ,QVWDOOFDJHQXWVRQHDFKLQVLGHVHFWLRQRIWKHWRS
duct cover. The cage nuts fit into the rectangular
VORWVFOLSVIDFLQJRXWZDUG
Ŷ,QVWDOOFDJHQXWVRQHDFKVLGHRIWKHORZHUGXFW
covers.
10 INSTALL UPPER DUCT COVER
Ŷ3ODFHWKHWDOOGXFWFRYHUVRQWRWKHWRSRIWKHKRRG
This section has venting holes on one end.
NOTE: If you are installing this hood for
UHFLUFXODWLQJRSHUDWLRQSODFHWKHGXFWFRYHUVRQWR
the hood with the venting slots at the top.
,IWKHKRRGLVYHQWHGWRWKHRXWVLGHWKHKROHV
should be positioned on the bottom.
Rectangular slots
1XW
3ODQ
diagram
Top
sections
Top
sections
Ŷ6HFXUHWKHVLGHVZLWKVFUHZVLQVWDOOHGWKURXJKWKH
cage nuts.
Support
frame
16
Ŷ5DLVHWKHDVVHPEOHGGXFWFRYHUVWRWKHWRSDJDLQVW
the ceiling.
Ŷ0DWFKPRXQWLQJKROHVRQHRQHDFKVLGH,QVWDOO
screws through the duct and into the support.
49-80329 Rev. 5
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
11 INSTALL LOWER DUCT
)URQWERWWRPGXFWFRYHUVHFWLRQ
(snap into place and secure
with 6 screws – 3 per side)
12 INSTALL DUCT COVER TRIM
Upper
trim
strip
Upper
trim
strip
Side
bracket
3ODQGLDJUDPWRS
view
Lower
trim
strip
Lower
trim strip
)URQWERWWRPGXFW
cover sections
Ŷ,QVWDOOVLGHEUDFNHWVWRVHFXUHWKHORZHUGXFWWLJKWO\
against the upper duct.
Ŷ+ROGORZHUWULPVWULSV QDUURZSLHFHV ZLWKKRRNV
IDFLQJGRZQ3ODFHWKHKRRNVLQVLGHWKHVORWVDQG
slide downward.
Ŷ6HOHFWWKHFRUUHFWVL]HXSSHUWULPVWULSVDQGSUHVV
into place.
13 INSTALL METAL FILTER
IMPORTANT:&KHFNWREHVXUHWKDWWKHPDLQ21
2))VZLWFKQH[WWRWKHPRWRULVLQWKH21SRVLWLRQ
)LOWHUORFN
Ŷ3ODFHUHDUGXFWFRYHURQWRWKHKRRG
Ŷ3ODFHIURQWGXFWFRYHURQWRWKHKRRG
Ŷ6HFXUHWKHGXFWFRYHUVZLWKVFUHZV
Ŷ7LSWKHILOWHULQWRWKHOHIWRUULJKWVLGHRIWKHRSHQLQJ
Lift the filter to the opposite side and into the filter
lock.
Ŷ7RUHPRYHWKHILOWHUSXOOWKHILOWHUORFNGRZQZDUG
14 FINALIZE INSTALLATION
Ŷ5HPRYHDOOWDSHDQGSDFNLQJPDWHULDO
Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ
instructions.
49-80329 Rev. 5
Installation Instructions
INSTALLATION—VENTED TO THE OUTSIDE
1 MOUNT TEMPLATE
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
Ŷ$OLJQWKHWHPSODWHZLWKWKHPDUNVRQWKHFHLOLQJDQG
tape in place.
Cut a 1≤ Dia.
Wire Access
Hole
10-1/16≤ to
Centerline
of Holes
Drill 3/16≤
Pilot Holes
Approx. 1-1/2≤
Deep
7-1/16≤ to
Centerline
of Holes
– Be sure the template is oriented correctly with the
front of the hood.
ia
81/2
≤
49-80406
Printed in Italy
D
Ŷ8VHDSOXPEEREWREHVXUHWKHPRXQWLQJKROHV
will provide parallel alignment with the countertop
below.
.
04-06 JR
36≤ Hood
Template
Cut a 1≤ Dia.
Wire Access
Hole
7-1/16≤ to
Centerline
of Holes
FRONT OF HOOD
Ŷ&HQWHUSXQFKDOOKROHORFDWLRQV
Ŷ'ULOOSLORWKROHVLQWKHVFUHZORFDWLRQV8VHD´
ELWDQGGULOODSSUR[LPDWHO\´GHHS
Ŷ'ULYHKH[KHDGZRRGVFUHZVLQWRWKHFHQWHURIWKH
FHLOLQJMRLVWVDQGFURVVIUDPLQJ/HDYHD´JDSWR
allow the screw head to engage the keyhole slots on
the support frames.
Ŷ&XWWKH´GXFWRSHQLQJWKURXJKWKHVKHHWURFN
1/4" Gap
2 ADJUST FRAME HEIGHT
Ŷ0HDVXUHH[DFWFHLOLQJKHLJKW
Ŷ)LQGWKHH[DFWIUDPHKHLJKWUHTXLUHG
RQWKHFKDUWRQSDJH
Ŷ5HPRYHVFUHZVRQHDFKRIWKH
sides of the frame to loosen the upper
VWUXFWXUHORZHUVWUXFWXUHDQGEORZHU
motor.
Ŷ$GMXVWWKHKHLJKW³;´DFFRUGLQJWR
WKHFKDUWRQSDJH8VHDWRWDORI
32 screws (8 screws on each side)
WRVHFXUHWKHXSSHUVWUXFWXUHORZHU
structure and blower/motor together.
)UDPH
height
2-3/4"
24"min.
PD[
Ceiling
height
Mark
each
piece to
indicate
where
screw
holes
align.
X
36"min.
NOTE: Low ceilings may require that the
lower portion of the support frame be removed.
The upper support frame may be secured
directly to the blower/motor. Refer to the
FKDUWRQSDJHIRU\RXUFHLOLQJKHLJKWDQG
to be sure the duct cover trim piece will fit.
18
49-80329 Rev. 5
Installation Instructions
INSTALLATION—RECIRCULATING
3 INSTALL AIR DEFLECTOR,
CUT DUCT FOR RECIRCULATING
OPERATION
Ŷ7HPSRUDULO\VOLGHWKHDLUGHIOHFWRU
into the support frame.
4 INSTALL UPPER SUPPORT
FRAME
Ŷ5DLVHWKHXSSHUVXSSRUW
toward the ceiling.
Ŷ7KUHDGWKHKRXVHZLULQJ
through one of the large
KROHVSUHIHUDEO\RQWKHOHIW
side.
Ŷ&DUHIXOO\HQJDJHWKHFHLOLQJ
mounting screws to the
keyhole slots in the top of
the frame.
Safety
screws
)5217
Keyhole
slots
Ŷ0HDVXUHGXFWOHQJWKEHWZHHQ
the deflector and over the
H[KDXVWRSHQLQJ
Ŷ&XWGXFWSLHFHWROHQJWKDQG
set aside.
Duct
length
House wiring
Keyhole
slots
Ŷ7LJKWHQWKHPRXQWLQJVFUHZVDJDLQVWWKHIUDPH
Ŷ,QVWDOOVDIHW\VFUHZV
)5217
Ŷ6OLGHDLUGHIOHFWRU
into the support
frame.
Ŷ6HFXUHWKHGHIOHFWRU
to the support with
4 screws.
Ŷ,QVWDOOWKHGXFW
piece to the bottom
of the deflector
and seal the
connection with
duct tape.
49-80329 Rev. 5
Installation Instructions
INSTALLATION—RECIRCULATING
5 INSTALL LOWER STRUCTURE TO
UPPER STRUCTURE
Ŷ6OLGHORZHUIUDPHLQWRWKH
upper frame. Match the
marked alignment holes.
7 INSTALL HOOD ATTACHMENT
SCREWS
Ŷ,QVWDOOKRRGDWWDFKPHQWVFUHZVLQWKHERWWRPRI
WKHVXSSRUWDVVKRZQ/HDYH´JDSEHWZHHQ
screw head and support flange.
Ŷ6HFXUHWKHXSSHUDQGORZHU
IUDPHZLWKVFUHZVRQ
each side of the frame.
Install 4
attachment
screws
6 INSTALL BLOWER/MOTOR
Ŷ5DLVHWKHEORZHU
motor piece toward the
assembled frame.
Ŷ&DUHIXOO\UDLVHWKHPRWRUWR
the marked reference point
while making sure the duct
piece slips over the blower
outlet flange.
8 MOUNT THE HOOD ONTO THE
SUPPORT
WARNING 2 people are required to lift and
position the hood onto the mounting bracket.
AVERTISSEMENT
Ŷ6HFXUHWKHEORZHUPRWRUWR
WKHIUDPHXVLQJVFUHZV
4 on each side.
,IIDXWGHX[SHUVRQQHVSRXU
lever et mettre en place la hotte sur le support de
montage.
Ŷ8VHWDSHWRVHDOWKHGXFW
connection.
Ŷ/LIWWKHKRRGWRWKHERWWRP
RIWKHVXSSRUWHQJDJLQJ
the keyhole slots to the 4
mounting screws.
Ŷ7LJKWHQWKHPRXQWLQJ
screws.
Ŷ,QVWDOO
additional
screws as
shown.
Install 6 screws
49-80329 Rev. 5
Installation Instructions
INSTALLATION—RECIRCULATING
9 CONNECT CABLES
Ŷ-RLQWKHWZRFDEOHFRQQHFWRUVDWWKHIURQWRIWKHKRRG
Secure the cables behind the retainer clip.
Retainer
clip
To lights
To control
panel
10 CONNECT ELECTRICAL
Verify that power is turned off at the source.
WARNING If house wiring is not 2-wire with a
Ŷ6HFXUHWKHKRXVHZLULQJWRWKHMXQFWLRQER[ZLWKD
strain relief.
House wiring
JURXQGZLUHDJURXQGPXVWEHSURYLGHGE\WKHLQVWDOOHU
:KHQKRXVHZLULQJLVDOXPLQXPEHVXUHWRXVH8/
DSSURYHGDQWLR[LGDQWFRPSRXQGDQGDOXPLQXPWR
copper connectors.
AVERTISSEMENT
Si le câblage de la maison n’est
SDVGXW\SHjGHX[ILOVDYHFXQILOGHWHUUHO¶LQVWDOODWHXU
GRLWIRXUQLUXQFLUFXLWGHWHUUH4XDQGOHVILOVGHOD
PDLVRQVRQWHQDOXPLQLXPLOSUHQGUHVRLQG¶XWLOLVHUGHOD
SkWHDQWLR[LGDWLRQDSSURXYpHSDU8/HWGHVFRQQHFWHXUV
pour l’aluminium-cuivre.
-%R[FRYHU
Ŷ5HPRYHMXQFWLRQER[FRYHUDQGNQRFNRXWRQWKH
left side.
Knockout
-%R[FRYHU
Ŷ&RQQHFWZKLWHOHDGVWREUDQFKFLUFXLWZKLWHOHDG
Ŷ&RQQHFWEODFNOHDGVWREUDQFKFLUFXLWEODFNOHDG
Ŷ&RQQHFWJUHHQ\HOORZOHDGVWREUDQFKFLUFXLWJUHHQ
lead or bare ground lead.
Ŷ6HFXUHDOOFRQQHFWLRQVZLWKZLUHQXWVRQHDFK
electrical connector.
Ŷ3XVKZLUHVLQWRMXQFWLRQER[DQGUHSODFHFRYHU%H
sure wires are not pinched.
Ŷ6HFXUH-%R[FRYHUZLWKRULJLQDOVFUHZ
49-80329 Rev. 5
21
Installation Instructions
INSTALLATION—RECIRCULATING
11 PREPARE THE DUCT COVERS
Ŷ5HPRYH
the plastic
protective
covering
on all duct
pieces.
Ŷ,QVWDOO
cage nuts on
each inside
section of
the top duct
cover. The
cage nuts
fit into the
rectangular
VORWVFOLSV
facing
outward.
13 INSTALL LOWER DUCT COVER
)URQWERWWRPGXFWFRYHUVHFWLRQ
(snap into place and secure with
6 screws – 3 per side)
Rectangular
slots
1XW
3ODQ
diagram
top view
3ODQ
diagram
Top
sections
Ŷ,QVWDOOFDJH
nuts on each
side of the
lower duct
covers.
Top
sections
)URQWERWWRPGXFW
cover sections
Support frame
12 INSTALL UPPER DUCT COVER
Ŷ3ODFHWKHWDOOGXFW
covers onto the top
of the hood. This
section has venting
holes on one end.
NOTE: If you are
installing this hood
for recirculating
RSHUDWLRQSODFHWKH
duct covers onto
the hood with the
venting slots at the
top.
Ŷ3ODFHUHDUGXFWFRYHURQWRWKHKRRG
Ŷ3ODFHIURQWGXFWFRYHURQWRWKHKRRG
Ŷ6HFXUHWKHGXFWFRYHUVZLWKVFUHZV
,IWKHKRRGLVYHQWHGWRWKHRXWVLGHWKHKROHV
should be positioned on the bottom.
Ŷ6HFXUHWKHVLGHVZLWKVFUHZVLQVWDOOHGWKURXJKWKH
cage nuts.
Ŷ5DLVHWKHDVVHPEOHGGXFWFRYHUVWRWKHWRSDJDLQVW
the ceiling.
Ŷ0DWFKPRXQWLQJKROHVRQHRQHDFKVLGH,QVWDOO
screws through the duct and into the support.
22
49-80329 Rev. 5
Installation Instructions
INSTALLATION—RECIRCULATING
14 INSTALL DUCT COVER TRIM
Side
bracket
Upper
trim
strip
Lower
trim strip
Upper
trim
strip
15 INSTALL FILTERS
IMPORTANT: &KHFNWREHVXUHWKDWWKHPDLQ21
2))VZLWFKQH[WWRWKHPRWRULVLQWKH21SRVLWLRQ
Lower
trim
strip
Charcoal filter
Ŷ,QVWDOOWKHEODFNFKDUFRDOILOWHULQWRWKHFHQWHU
opening. Secure the filter with thumbscrews on
each side.
)LOWHUORFN
Ŷ,QVWDOOVLGHEUDFNHWVWRVHFXUHWKHORZHUGXFWWLJKWO\
against the upper duct.
Ŷ+ROGORZHUWULPVWULSV QDUURZSLHFHV ZLWKKRRNV
IDFLQJGRZQ3ODFHWKHKRRNVLQVLGHWKHVORWVDQG
slide downward.
Ŷ6HOHFWWKHFRUUHFWVL]HXSSHUWULPVWULSVDQGSUHVV
into place.
Metal filter
Ŷ7LSWKHILOWHULQWRWKHOHIWRUULJKWVLGHRIWKH
opening. Lift the filter to the opposite side and
into the filter lock.
Ŷ7RUHPRYHWKHILOWHUSXOOWKHILOWHUORFNGRZQZDUG
16 FINALIZE INSTALLATION
Ŷ5HPRYHDOOWDSHDQGSDFNLQJPDWHULDO
Ŷ5HIHUWRWKH2ZQHU¶V0DQXDOIRURSHUDWLQJ
instructions.
49-80329 Rev. 5
23
NOTE::KLOHSHUIRUPLQJLQVWDOODWLRQVGHVFULEHGLQWKLVERRN
safety glasses or goggles should be worn.
)RU0RQRJUDP®ORFDOVHUYLFHLQ\RXUDUHDYLVLW
monogram.com.
NOTE:3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRUDW
0RQRJUDP$SSOLDQFHV7KHUHIRUHPDWHULDOVDSSHDUDQFH
and specifications are subject to change without notice.
49-80329 Rev. 5
10-19 GEA
Printed in Mexico
">