Manual for
Gazebo
2,9x2,9m
16-06-2017
Safety Advice
Attention
In some countries approval is needed to set up a marquee/tent larger than 75 m2. It is your responsibility to comply with local rules and regulations and to ensure that the marquee/tent is assembled correctly.
In case of bad weather conditions, it is your responsibility to ensure the marquee/tent is safely secured and that the marquee/tent does not cause damage to others.
Do not use open fire, welding equipment or other sources which can ignite, inside or close to the tent.
The marquee/tent must be safely secured. We recommend you secure your marquee/tent with straps and pegs as soon as it is assembled.
Make sure to check if the marquee/tent is covered by your home contents insurance.
Marquees/tents must be evacuated under extreme weather conditions.
In the event of snow, always remove snow from the roof of the marquee/tent regularly to prevent snow from building on the roof, as heavy snow can cause the marquee/tent to collapse.
In the event of rain, there is a risk of rain puddles building up on top of the roof of the marquee/tent. Heavy rain puddles can cause the roof to collapse.
It is your responsibility to ensure rain puddles do not build up. As a precaution, make sure the roof of the marquee/tent is stretched out properly and adequately over the side frames of the marquee/tent and remove rain water regularly.
Do not unpack or repack your marquee/tent in freezing temperatures. In case of temperatures below zero, always unpack and repack your marquee/tent indoors to avoid the risk of cracking parts.
The marquee/tent must be totally dry before you repack and store it to avoid mildew.
Note: Marquees are intended for events and other arrangements and are as such only meant for short term temporary assembly and the following disassembly. Dancover warranty applies only to the normal use of the Product, normal wear and tear excepted, in accordance with written use instructions or manual. The warranty does not apply to damage caused by accident, abuse, misuse, or modification of the Product.
Warranty Information
Please visit dancovershop.com for information on warranty.
Please always check our website for the latest safety advice and manual.
PRODUCT SIZE
Make sure a good installation location
AP1010
292cm
292cm
207cm
228cm
PARTS LIST
NO. Qty.
1 2
2 2
3 4
6 1
7 2
8 1
2200mm
2760mm
2439mm
9 1
-3-
238cm
238cm
NO. Qty.
B1 4
S1 11
S3 10
S5 4
S6 1
B2 15
NO. Qty.
B3 15
B15 16
F1 16
F2 32
F3 2
F3 3
PERGOLA
Instruction manual
size:290x290x228 cm
PA117020
IMPORTANT
You must read these instructions carefully before you start to assemble this PERGOLA .Please ensure that you find all parts in the carton box in the correct type and quantity as mentioned in the list illustrated in every page accordingly.
Please carry out the steps in the order set out in these instructions.
Keep these instructions in a safe place for future reference.
-2-
SAFETY ADVICE
We strongly recommend the use of work gloves during assembly.
Do not attempt to assemble the PERGOLA in windy or wet conditions,
Do not touch overhead power cables with the aluminum profiles.
Always wear shoes and safety goggles when working with extruded aluminum.
PERGOLA.
Dispose of all plastic bags safety-keep them out of reach of small children.
The PERGOLA must be positioned and fixed on a flat level surface.
Do not lean against or push the PERGOLA during construction.
Keep children away from the assemble area.
!
Do not attempt to assemble this PERGOLA if you are tired ,have taken drugs or alcohol or if you are prone to dizzy spells.
If using a step ladder or power tools ensure that you follow the manufacturer's safety advice.
Hot items such as recently used grills, blowtorches etc.must not be stored in the
Ensure there are no hidden pipes or cables in the ground before inserting the pegs.
GENERAL ADVICE
This is a multi-part assembly, Allow at least 45 minutes for assembly.
Selecting a site-choose a sunny level position away from overhanging trees.
If you are fixing your PERGOLA directly to a solid concrete foundation use the predrilled holes in the metal base supplied.
The component parts should be checked and laid out close to hand.
Keep all small parts(screws etc)in a bowl so they do not get lost.
Note that the door is hinged on the right hand side and therefore opens to the right.
Keep roof clear from snow and leaves.
CARE & MAINTENANCE
When your PERGOLA needs cleaning, use a mild detergent solution and risen with cool clean water.
Do NOT use acetone, abrasive cleaners or other special detergents to clean the clear panels.
OTHER CAUTIONS
1. 2 people required, one is for measuring & taking marks to ensure the installation dimension ,the second person is responsible for the installation and the last one do as assistant and assure the safety.
2. Firstly, make sure the carport is strong enough for installation.
A brick concrete structures is the best choice.
3. High-power electric tools are required, ensure the normal work
!
5. Wearing long sleeve cotton overalls,gloves and helmet during installation and wear safety glasses when using power tools .
6.Don't look up when Working in high position, or the drop screws may hurt your eyes and suffocation causing accidentally when falling into your mouth.
7. No climbing, No standing on the tent to avoid falling down.
8. If injuries immediately, using the first-aid kit to stop bleeding, bind up, In case of emergency ， taken immediately to a nearby medical institutions.
PRODUCT SIZE
Make sure a good installation location
290cm
290cm
207cm
228cm
PARTS LIST
NO. Qty.
1 2
2 2
3 4
6 1
7 2
8 1
2200mm
2760mm
2439mm
9 1
-3-
238cm
238cm
NO. Qty.
B1 4
S1 11
S3 10
S5 4
S6 1
B2 15
NO. Qty.
B3 15
B15 16
F1 16
F2 32
F3 2
F3 3
Install schematic diagram of Alu.frames
S3
S3
S5
2
S3
7
3
S3
S5
S3
3
S3
S6
9
8
6
S5
S3
1
S3
7
3
3
B1
B1
1
B1
-4-
2
B1
S3
S5
S3
1 x2
2 x2
Ⅰ x4
2
1
F1
F1
-5-
B1
F1
F1
3 x2
2
F2x4
3
3
B1 x4 F1 x16 F2 x16
Ⅱ x2
3
F2x4
1
F2x4
-6-
3 x2
3
7
S1
Ⅰ x2
3
7
S1 x5
3
F2 x4
1
3
7
Ⅱ x2
F2 x4
3
2
7 x2
2
S1 x5
7
3
F2 x16 S1 x10
1
1
S1 x5
7
3
2
-7-
6
6
8
S1
Ⅰ
S1 x1
3
F3
6
Ⅱ
8
8
6
3
F3
8
6
8
F3 x2
S1
F3
8
6
F3
-8-
S3 x10
S3
6
Ⅰ x2
Ⅲ
1
S5 x4
S6 F3
B15 x16
Ⅳ
S6
Ⅱ x4
S5
S3
3
1
3
7
S3
F3 x3
S3 S5
S3 x4
S3
S3
S5
S6
S3
S3
S5
S3
B1
B15 x4
S3
B1
B15 x4
B1
B15 x4
B1
B15 x4
S5
S3
S3
B1
B15 x4
-9-
9
Ⅰ x15
B2
9
Ⅱ x15
B3 x15 B2 x15
B3
B2
B3
9
1
S6
-10-
Maintenance:
In a timely manner the centralizer skeleton.
1.If the ground not level off, loose soil layer thickness is differ, PERGOLA may tilt to one end, once found, should be timely the centralizer, in case of deformation.
The shed may be slant when facing the un-level ground or loose soil layer, please righting the shed urgently to avoid deformation
2.Prevent increased loading-weight artificially.
Don't let any lentils, towel gourd, pumpkin and climbing fruits and vegetables to grow up on the canopy, otherwise if it is windy and rainy, skeleton is
unbearable, and easy to cause skeleton crack, broken, collapse Avoid kinds of vine plant climbing on the canopy, or it can not bearing for the wind and heavy
rain, broken,collapse may accured.
Frame maintenance:
1.The frame is aluminum alloy structure, if there is a white problem can wipe with a cloth in time, under high temperature and wet environment.
All frames are made of alloy aluminum. White spots may appeared under wet-hot environment, just wipe it.
1.If connection piece serious rust, should change in time the new screws and connectors to ensure connection parts are firm
Please replaced the serious rust screws and connection for stable.
How to do in bad weather:
1.If there is lightning may not stay in the shed, because aluminum alloy skeleton is conductive and will be caused serious consequences
Do not stay under shed when lightning.
2.Wind power reaches 70 km/h should be prepared ready to defense equipment, fixed
PERGOLA. Fixed method with a strong rope or cable connect the cornice
work four Angle of anchor block inserted into the soil or tied in a nearby tree stem >10 cm in diameter. Pay attention to the weather turns good dismantled after
the rope or cable to avoid injury and pedestrian.
Please get defensive measures when facing heavy wind (abt 70km/H). Reinforce by steel rope and anchors which insert into ground or Strapping on a big tree .
Head office:
Dancover A/S
Nordre Strandvej 119 G
3150 Hellebæk
Denmark
Denmark: 70 26 76 20 [email protected]
UK: 020 8099 7570 [email protected]
Germany: 041 0266 7040 [email protected]
France: 0975 181 800 [email protected]
Sweden: 040 233 262 [email protected]
Finland: 0 931 581 720 [email protected]
Contact information
For more information, please visit:
www.dancovershop.com
National contact
Poland: 22 300 8602 [email protected]
Luxembourg: +49 041 0266 7040 [email protected]
Portugal: 308 800 899 [email protected]
Spain: 911 436 828 [email protected]
Italy: 02 479 21 198 [email protected]
Switzerland: 0840 000125 [email protected]
Austria: 0662 626935 [email protected]
Norway: 231 00 690 [email protected]
Nederland: 0 858 880 524 [email protected]
Ireland: 0 151 33 003 [email protected]
Belgium: 0 28 08 08 09 [email protected]
