Vermont Castings Stardance SDVTSCCB Installation & Operating Manual

Installation & Operating Manual
Installation and Appliance Setup - Care and Operation
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Call your dealer for questions on Installation, Operation, or Service.
NOTICE: SAVE THESE INSTRUCTIONS
SDDVT Series Stardance®
Direct Vent Gas Heater
Models:
SDDVTCBSB, SDDVTBSSB, SDDVTBDSB,
SDDVTBMSB, SDVTSCCB, SDVTSCBS,
SDVTSCBD, SDVTSCBM
!
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result
in serious injury, death or property damage.
‡ 'RQRWVWRUHRUXVHJDVROLQHRURWKHUÀDPPDEOH
vapors and liquids in the vicinity of this or any
other appliance.
• WHAT TO DO IF YOU SMELL GAS
– Do not try to light any appliance.
– Do not touch any electrical switch; do not use
any phone in your building.
– Leave the building immediately.
– Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
– If you cannot reach your gas supplier, call the
¿UHGHSDUWPHQW
• Installation and service must be performed
E\ D TXDOL¿HG LQVWDOOHU VHUYLFH DJHQF\ RU WKH
gas supplier.
DANGER
HOT GLASS WILL
CAUSE BURNS.
CERTIFIED
SAFETY BARRIER
DO NOT TOUCH GLASS
UNTIL COOLED.
Installation and service of this appliance should be performed by
TXDOL¿HGSHUVRQQHO+HDUWK +RPH7HFKQRORJLHVUHFRPPHQGV
++7)DFWRU\7UDLQHGRU1),FHUWL¿HGSURIHVVLRQDOV
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this
appliance and shall be installed.
1
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE.
7KDQN\RXDQGFRQJUDWXODWLRQVRQ\RXUSXUFKDVHRID9HUPRQW&DVWLQJVVWRYH
IMPORTANT:5HDGDOOLQVWUXFWLRQVDQGZDUQLQJVFDUHIXOO\EHIRUHVWDUWLQJLQVWDOODWLRQ)DLOXUHWRIROORZWKHVHLQVWUXFWLRQVPD\UHVXOWLQD
SRVVLEOH¿UHKD]DUGDQGZLOOYRLGWKHZDUUDQW\
Table of Contents
Important Safety Information 3
Operating Instructions 31
Massachusetts Safety Information4
California Safety Information4
<RXU)LUVW)LUH31
Pilot and Burner Inspection31
)ODPH 7HPSHUDWXUH$GMXVWPHQW31
)ODPH&KDUDFWHULVWLFV31
/LJKWLQJDQG2SHUDWLQJ,QVWUXFWLRQV32
7URXEOHVKRRWLQJ33
5HDG%HIRUH/LJKWLQJ34
Pre-Installation 5
Stove Dimensions5
Installation Requirements6
Clearance Requirements6
Parallel Installation7
Corner Installation7
:DOODQG&HLOLQJ&OHDUDQFHV7
+HDUWK5HTXLUHPHQWV7
*DV6SHFL¿FDWLRQV8
*DV,QOHWDQG0DQLIROG3UHVVXUHV8
+LJK(OHYDWLRQV8
+RUL]RQWDO7HUPLQDWLRQ8
Vertical Termination9
5HVWULFWRU3ODWH$GMXVWPHQWIRU([WHQGHG3LSH5XQV 9
Vent Termination Clearances10
*HQHUDO9HQWLQJ,QIRUPDWLRQ±7HUPLQDWLRQ/RFDWLRQ 11
7HUPLQDWLRQ&OHDUDQFHV12
Assembly & Installation 13
9HQWLQJ5HTXLUHPHQWVDQG2SWLRQV13
$VVHPEOLQJWKH6WRYH14
,QVWDOOWKH2SWLRQDO)DQ±6''970RGHOV(Millivolt Only) ............ 14
9HQWLQJ6\VWHP$VVHPEO\16
Important Safety Information16
Before You Start16
,QVWDOOWKH9HQW$GDSWHU3LSH17
$VVHPEOH6OLS6HFWLRQV18
Secure the Vent Sections18
Disassemble Vent Sections19
+RUL]RQWDO7HUPLQDWLRQ&DS19
Divert Roof Run-off20
Vertical Side Wall Installation20
9HQW7HUPLQDWLRQ%HORZ*UDGH21
9HUWLFDO7KURXJK7KH5RRI$SSOLFDWLRQLQVWDOODWLRQ 22
9HQWLQJ6\VWHP$VVHPEO\1DWXUDO9HQW23
,QVWDOO/RJ6HW24
,QVWDOO212))6ZLWFK±6''970RGHOV(Millivolt Only) 26
Thermostat Connection (optional)26
6LJQDWXUH&RPPDQGŠ6\VWHP 6& 26
-XQFWLRQ%R[:LULQJ27
Command Center Wall Installation27
Wall Switch Installation 27
&RQQHFWWKH*DV6XSSO\/LQH28
Burner Information28
6LJQDWXUH&RPPDQG:LULQJ'LDJUDP29
Install the Safety Barrier30
,QVWDOOWKH0HVKDQG*ULOO30
2
Signature Command Operating Instructions 36
)HDWXUHV36
Battery Installation36
6\VWHP&RQ¿JXUDWLRQ6HWXS36
Operating instructions 38
7XUQLQJRQWKHVWRYH38
&RPPDQG&HQWHU2SHUDWLRQV38
,QLWLDOL]DWLRQDQG6HWWLQJXS39
)XQFWLRQVDQG2SHUDWLRQV40
6DIHW\)HDWXUHV43
Troubleshooting 44
7URXEOHVKRRWLQJ±6,*1$785(&200$1'6<67(0 44
Fuel Conversion 46
Cleaning & Maintenance 51
$QQXDO6\VWHP,QVSHFWLRQ51
/RJVHWDQG%XUQHU&OHDQLQJDQG,QVSHFWLRQ51
Care of Cast Iron51
&OHDQLQJWKH*ODVV51
*DVNHW5HSODFHPHQW52
,QVSHFWWKH9HQW6\VWHP$QQXDOO\52
&KHFNWKH*DV)ODPH5HJXODUO\52
*ODVV5HSODFHPHQW52
Wiring Diagrams 53
Service Parts List 55
Optional Accessories 59
Limited Lifetime Warranty 60
Î = Contains updated information
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Massachusetts safety information
7KH6WDUGDQFH'LUHFW9HQW5RRPKHDWHU0RGHO1RV6''97&%6%
SDDV TBSSB, SDDV TBDSB, SDDV TBMSB, SDV TSCCB,
6'976&%66'976&%'6'976&%0LVDYHQWHGJDVDSSOLDQFH
OLVWHGWRWKH$16,6WDQGDUG=DQG&6$IRU
9HQWHG5RRPKHDWHUVDQG&6$0*DV)LUHG$SSOLDQFHV
)RU8VHDW+LJK$OWLWXGHV
The installation of the Stardance Direct Vent Room heater must
conform with local codes, or in the absence of local codes, with
1DWLRQDO)XHO*DV&RGH$16,=1)3$²ODWHVWHGLWLRQDQG
&6$%,QVWDOODWLRQ&RGH (;&(37,21'RQRWGHUDWHWKLV
DSSOLDQFHIRUDOWLWXGH0DLQWDLQWKHPDQLIROGSUHVVXUHDWLQFKHV
ZFIRU1DWXUDO*DVDQGLQFKHVZFIRU/3JDVDWPD[LPXP
LQSXW
7KLVDSSOLDQFHLVRQO\IRUXVHZLWKWKHW\SHRIJDVLQGLFDWHGRQWKH
UDWLQJ SODWH 7KLV DSSOLDQFH LV QRW FRQYHUWLEOH IRU XVH ZLWK RWKHU
JDVHVXQOHVVDFHUWL¿HGNLWLVXVHG
Installation and replacement of gas piping, gas utilization
equipment or accessories, and repair and servicing of equipment
VKDOOEHSHUIRUPHGRQO\E\DTXDOL¿HGDJHQF\SUHIHUDEO\1),RU
:(77 &DQDGD FHUWL¿HG7KHWHUP³TXDOL¿HGDJHQF\PHDQVDQ\
LQGLYLGXDO¿UPFRUSRUDWLRQRUFRPSDQ\WKDWHLWKHULQSHUVRQ
or through a representative is engaged in and is responsible
for (a) installation or replacement of gas piping, or (b), the
connection, installation, repair, or servicing of equipment,
who is experienced in such work, familiar with all precautions
required, and has complied with all the requirements of the
authority having jurisdiction.
The Stardance Direct Vent Room heater should be inspected
EHIRUHXVHDQGDWOHDVWDQQXDOO\E\DTXDOL¿HGVHUYLFHDJHQF\,WLV
imperative that control compartments, burners, and circulating
air passageways of the appliance be kept clean.
The Stardance Direct Vent Room heater and its individual shut-off
YDOYHPXVWEHGLVFRQQHFWHGIURPWKHJDVVXSSO\SLSLQJGXULQJDQ\
SUHVVXUHWHVWLQJRIWKDWV\VWHPDWWHVWSUHVVXUHVLQH[FHVVRI
SVLJ N3D The Stardance Direct Vent Room heater must be isolated from the
JDVVXSSO\SLSLQJV\VWHPE\FORVLQJLWVLQGLYLGXDOPDQXDOVKXWRII
YDOYHGXULQJDQ\SUHVVXUHWHVWLQJRIWKHJDVVXSSO\SLSLQJV\VWHP
DWWHVWSUHVVXUHVHTXDOWRRUOHVVWKDQSVLJ
$QDFFHVVLEOHWDSLVORFDWHGDERYHWKHSLORW2Q2IINQREIRUFKHFNLQJ
WKHLQOHWSUHVVXUH
‘Direct Vent’ describes a sealed combustion system in which
LQFRPLQJ RXWVLGH DLU IRU FRPEXVWLRQ DQG RXWJRLQJ H[KDXVW HQWHU
DQGH[LWWKURXJKWZRVHSDUDWHFRQFHQWULFSDVVDJHVZLWKLQWKHVDPH
VHDOHGYHQWV\VWHP7KHV\VWHPGRHVQRWXVHURRPDLUWRVXSSRUW
FRPEXVWLRQ7KH'LUHFW9HQWV\VWHPSHUPLWVWKHJDVDSSOLDQFHWR
EHYHQWHGGLUHFWO\WRWKHRXWVLGHDWPRVSKHUHWKURXJKWKHVLGHRIWKH
KRXVHRUYHUWLFDOO\WKURXJKWKHURRI&RQYHQWLRQDOYHQWLQJV\VWHPV
1DWXUDO9HQW WDNHDLUIURPWKHURRPIRUFRPEXVWLRQDQGYHQWWKH
H[KDXVWYHUWLFDOO\WKURXJKWKHURRIWRWKHDWPRVSKHUH
The Stardance Direct Vent Room heater, when installed, must
EHHOHFWULFDOO\JURXQGHGLQDFFRUGDQFHZLWKORFDOFRGHVRULQWKH
DEVHQFHRIORFDOFRGHVZLWKWKH1DWLRQDO(OHFWULFDO&RGH$16,1)3$
ODWHVWHGLWLRQ RURIWKHFXUUHQW&DQDGLDQ(OHFWULFDO&RGH&
Due to high temperatures this appliance should be located out
RIWUDI¿FDQGDZD\IURPIXUQLWXUHDQGGUDSHULHV
WARNING: This appliance is hot while in operation. Keep
children, clothing, and furniture away. Contact may cause
burns or ignition of combustible materials.
Children and adults should be alerted to the hazards of high
surface temperatures and should stay away to avoid burns or
clothing ignition.
Young children should be carefully supervised when they are
in the same room as the appliance. Toddlers, young children
and others may be susceptible to accidental contact burns. A
physical barrier is recommended if there are at risk individuals
in the house. To restrict access to a stove or stove, install an
adjustable safety gate to keep toddlers, young children and other
at risk individuals out of the room and away from hot surfaces.
&ORWKLQJRURWKHUÀDPPDEOHPDWHULDOVVKRXOGQRWEHSODFHG
on or near the appliance.
Any safety screen, glass or guard removed for servicing an
appliance must be replaced prior to operating the appliance.
The appliance area must be kept clear and free from combustible
PDWHULDOVJDVROLQHDQGRWKHUÀDPPDEOHYDSRUVDQGOLTXLGV
7KH ÀRZ RI FRPEXVWLRQ DQG YHQWLODWLRQ DLU PXVW QRW EH
obstructed. The installation must include adequate accessibility
and clearance for servicing and proper operation.
WARNING: Do not operate the Room heater with the glass panel
removed, cracked or broken. Replacement of the panel should
EHGRQHE\DOLFHQVHGRUTXDOL¿HGVHUYLFHSHUVRQ
Do not use this appliance if any part has been under water.
,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQWRLQVSHFWWKH
appliance and to replace any part of the control system and
any gas control which has been under water.
Do not burn wood, trash or any other material for which this
appliance was not designed. This appliance is designed to
burn either natural gas or propane only.
7KLVJDVDSSOLDQFHPXVWQRWEHFRQQHFWHGWRDFKLPQH\ÀXH
serving a separate solid-fuel burning appliance.
CAUTION: Label all wires prior to disconnection when servicing
controls. Wiring errors can cause improper and dangerous
operation.
Verify proper operation after servicing.
* Aftermarket: Completion of sale, nor for purpose of resale, from
the manufacturer.
7KLV DSSOLDQFH LV DSSURYHG IRU EHGURRP LQVWDOODWLRQV LQ WKH 86
DQG&DQDGD
This appliance may be installed in an aftermarket* manufactured
PRELOH KRPHZKHUHQRWSURKLELWHGE\VWDWHRUORFDOFRGHV
WARNING: Operation of this heater when not connected to a
properly installed and maintained venting system can result in
carbon monoxide (CO) poisoning and possible death.
3
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Requirements for the Commonwealth of
Massachusetts
$OOJDV¿WWLQJDQGLQVWDOODWLRQRIWKLVKHDWHUVKDOORQO\EHGRQH
E\DOLFHQVHGJDV¿WWHURUOLFHQVHGSOXPEHU
)RUDOOVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQW
LQVWDOOHGLQHYHU\GZHOOLQJEXLOGLQJRUVWUXFWXUHXVHGLQZKROH
RULQSDUWIRUUHVLGHQWLDOSXUSRVHVLQFOXGLQJWKRVHRZQHGRU
operated by the Commonwealth and where the side wall
H[KDXVWYHQWWHUPLQDWLRQLVOHVVWKDQVHYHQ IHHWDERYH
¿QLVKHGJUDGHLQWKHDUHDRIWKHYHQWLQJLQFOXGLQJEXWQRW
OLPLWHG WR GHFNV DQG SRUFKHV WKH IROORZLQJ UHTXLUHPHQWV
VKDOOEHVDWLV¿HG
Installation of Carbon Monoxide Detectors
$WWKHWLPHRILQVWDOODWLRQRIWKHVLGHZDOOKRUL]RQWDOYHQWHG
JDVIXHOHGHTXLSPHQWWKHLQVWDOOLQJSOXPEHURUJDV¿WWHUVKDOO
REVHUYHWKDWDKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUZLWKDQ
DODUPLVLQVWDOOHGRQHDFKDGGLWLRQDOOHYHORIWKHGZHOOLQJ
EXLOGLQJ RU VWUXFWXUH VHUYHG E\ WKH VLGH ZDOO KRUL]RQWDO
YHQWHGJDVIXHOHGHTXLSPHQW,WVKDOOEHWKHUHVSRQVLELOLW\
RI WKH SURSHUW\ RZQHU WR VHFXUH WKH VHUYLFHV RI TXDOL¿HG
licensed professionals for the installation of hard wired carbon
PRQR[LGHGHWHFWRUV
,QWKHHYHQWWKDWWKHVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHG
equipment is installed in a crawl space or an attic, the hard
ZLUHG FDUERQ PRQR[LGH GHWHFWRU ZLWK DODUP DQG EDWWHU\
EDFNXSPD\EHLQVWDOOHGRQWKHQH[WDGMDFHQWÀRRUOHYHO
In the event that the requirements of this subdivision can not
be met at the time of completion of installation, the owner shall
have a period of thirty (30) days to comply with the above
UHTXLUHPHQWVSURYLGHGKRZHYHUWKDWGXULQJVDLGWKLUW\ GD\SHULRGDEDWWHU\RSHUDWHGFDUERQPRQR[LGHGHWHFWRUZLWK
DQDODUPVKDOOEHLQVWDOOHG
Approved Carbon Monoxide Detectors
(DFKFDUERQPRQR[LGHGHWHFWRUDVUHTXLUHGLQDFFRUGDQFH
ZLWKWKHDERYHSURYLVLRQVVKDOOFRPSO\ZLWK1)3$DQG
$16,8/OLVWHGDQG,$6FHUWL¿HG
Signage
$PHWDORUSODVWLFLGHQWL¿FDWLRQSODWHVKDOOEHSHUPDQHQWO\
mounted to the exterior of the building at a minimum
height of eight (8) feet above grade directly in line with
the exhaust vent terminal for the horizontally vented gas
fueled heating appliance or equipment. The sign shall
read, in print size no less than one-half (1/2) inch in size,
³*$69(17',5(&7/<%(/2:.((3&/($52)$//
2%6758&7,216
Stardance Direct Vent
&HUWL¿HGWR$16,=&6$9HQWHG
Gas Heaters
Exemptions
7KHIROORZLQJHTXLSPHQWLVH[HPSWIURP&05 D WKURXJK
• 7KH HTXLSPHQW OLVWHG LQ &KDSWHU HQWLWOHG ³(TXLSPHQW
1RW5HTXLUHG7R%H9HQWHGLQWKHPRVWFXUUHQWHGLWLRQRI
1)3$DVDGRSWHGE\WKH%RDUGDQG
• 3URGXFW$SSURYHGVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHG
equipment installed in a room or structure separate from
WKHGZHOOLQJEXLOGLQJRUVWUXFWXUHXVHGLQZKROHRULQSDUW
IRUUHVLGHQWLDOSXUSRVHV
Manufacturer Requirements
Gas Equipment Venting System Provided
:KHQ WKH PDQXIDFWXUHU RI 3URGXFW $SSURYHG VLGH ZDOO
KRUL]RQWDOO\YHQWHGJDVHTXLSPHQWSURYLGHVDYHQWLQJV\VWHP
GHVLJQRUYHQWLQJV\VWHPFRPSRQHQWVZLWKWKHHTXLSPHQW
the instructions provided by the manufacturer for installation
RIWKHHTXLSPHQWDQGWKHYHQWLQJV\VWHPVKDOOLQFOXGH
• 'HWDLOHG LQVWUXFWLRQV IRU WKH LQVWDOODWLRQ RI WKH YHQWLQJ
V\VWHPGHVLJQRUWKHYHQWLQJV\VWHPFRPSRQHQWVDQG
• $ FRPSOHWH SDUWV OLVW IRU WKH YHQWLQJ V\VWHP GHVLJQ RU
YHQWLQJV\VWHP
Gas Equipment Venting System NOT Provided
:KHQ WKH PDQXIDFWXUHU RI D 3URGXFW$SSURYHG VLGH ZDOO
KRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQWGRHVQRWSURYLGH
WKHSDUWVIRUYHQWLQJWKHÀXHJDVHVEXWLGHQWL¿HV³VSHFLDO
YHQWLQJ V\VWHPV WKH IROORZLQJ UHTXLUHPHQWV VKDOO EH
VDWLV¿HGE\WKHPDQXIDFWXUHU
• 7KHUHIHUHQFHG³VSHFLDOYHQWLQJV\VWHPLQVWUXFWLRQVVKDOO
be included with the appliance or equipment installation
instructions; and
• 7KH³VSHFLDOYHQWLQJV\VWHPVVKDOOEH3URGXFW$SSURYHG
by the Board, and the instructions for that system shall
LQFOXGHDSDUWVOLVWDQGGHWDLOHGLQVWDOODWLRQLQVWUXFWLRQV
$FRS\RIDOOLQVWDOODWLRQLQVWUXFWLRQVIRUDOO3URGXFW$SSURYHG
VLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQWDOOYHQWLQJ
LQVWUXFWLRQVDOOSDUWVOLVWVIRUYHQWLQJLQVWUXFWLRQVDQGRUDOO
YHQWLQJGHVLJQLQVWUXFWLRQVVKDOOUHPDLQZLWKWKHDSSOLDQFH
RUHTXLSPHQWDWWKHFRPSOHWLRQRIWKHLQVWDOODWLRQ
California safety information
!
WARNING
This product and the fuels used to operate this product
OLTXLG SURSDQH RU QDWXUDO JDV DQG WKH SURGXFWV RI
FRPEXVWLRQ RI VXFK IXHOV FDQ H[SRVH \RX WR FKHPLFDOV
LQFOXGLQJ EHQ]HQH ZKLFK LV NQRZQ WR WKH 6WDWH RI
&DOLIRUQLD WR FDXVH FDQFHU DQG UHSURGXFWLYH KDUP )RU
PRUHLQIRUPDWLRQJRWRZZZ3:DUQLQJVFDJRY
Inspection
7KHVWDWHRUORFDOJDVLQVSHFWRURIWKHVLGHZDOOKRUL]RQWDOO\
YHQWHGJDVIXHOHGHTXLSPHQWVKDOOQRWDSSURYHWKHLQVWDOODWLRQ
unless, upon inspection, the inspector observes carbon
PRQR[LGHGHWHFWRUVDQGVLJQDJHLQVWDOOHGLQDFFRUGDQFHZLWK
WKHSURYLVLRQVRI&05 D WKURXJK
4
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Stardance Direct Vent Stove Dimensions
:HLJKW)XOO\DVVHPEOHGOEV
6HH)LJXUH IRU)OXH&ROODU&HQWHUOLQH'LPHQVLRQV
7" Outer Dia.
(178 mm)
12-5/8”
(321 mm)
Flue Collar C
L
2-7/8”
(73 mm)
26-3/4"
(680 mm)
Supply Inlet
CL
25-1/2"
(648 mm)
3"
(76 mm)
14-1/2"
(355 mm)
Figure 1 - Stardance dimensions.
5
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Installation Requirements
Direct Vent System Only
The installation must conform with local codes or, in the
DEVHQFHRIORFDOFRGHVZLWKWKH1DWLRQDO)XHO*DV&RGH
$16,=1)3$±ODWHVWHGLWLRQ (;&(37,21'R
QRWGHUDWHWKLVDSSOLDQFHIRUDOWLWXGH0DLQWDLQWKHPDQLIROG
SUHVVXUH DW ZF IRU 1DWXUDO *DV DQG ZF IRU
3URSDQH A
D
B
C
In Canada, installation must be in accordance with the current
&6$%,QVWDOODWLRQ&RGHVDQGRUORFDOFRGHV
7KHLQVWDOODWLRQVKRXOGEHGRQHE\DTXDOL¿HGVHUYLFHSHUVRQ
ZKR LV IDPLOLDU ZLWK WKH EXLOGLQJ FRGHV DQG LQVWDOODWLRQ
techniques appropriate for your area to accomplish a safe
DQGHIIHFWLYHLQVWDOODWLRQ
<RXUGHDOHURU\RXUORFDOJDVVXSSOLHUZLOOEHDEOHWRUHIHUD
TXDOL¿HGVHUYLFHSHUVRQ
!
WARNING
'XHWRKLJKWHPSHUDWXUHVWKHKHDWHUVKRXOGEHORFDWHG
RXWRIWUDI¿FDQGDZD\IURPIXUQLWXUHDQGGUDSHULHV
7KHVXUIDFHRIWKH+HDWHU,VKRWZKHQLWLVLQXVH<RXQJ
children should be watched carefully when they are in the
VDPHURRPZKHQWKH+HDWHULVLQXVHDQGWKH\VKRXOG
EHWDXJKWWRDYRLGWKHKRWVXUIDFH.HHSDQ\REMHFWVWKDW
FDQ EXUQ ZHOO DZD\ IURP WKH +HDWHU DQG REVHUYH WKH
UHFRPPHQGHGFOHDUDQFHVWKDWIROORZ
DANGER
HOT GLASS WILL
CAUSE BURNS.
E
$)ODWRQFRUQHUZDOO
'&URVV&RUQHU
%5RRP'LYLGHU
()ODWRQZDOO
&,VODQG
Figure 2 - Possible stove locations.
Clearance Requirements
Minimum Clearances to Combustible Materials
0HDVXUH VLGH FOHDUDQFHV DV VKRZQ LQ )LJXUHV DQG IURPWKHRXWHUHGJHRIWKHFDVWLURQVWRYHWRS0HDVXUHUHDU
FOHDUDQFHVIURPWKHRXWHUPRVWVXUIDFHRIWKHVWHHOUHDUVNLUW
The Stardance heater is approved for installation into
an alcove constructed of combustible materials to the
GLPHQVLRQVDQGFOHDUDQFHVVKRZQRQWKHQH[WSDJH
7KHVDPHFOHDUDQFHVDSSO\LQDVWDQGDUGSDUDOOHOLQVWDOODWLRQ
!
•
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this
appliance and shall be installed.
•
WARNING
$OZD\VPDLQWDLQUHTXLUHGFOHDUDQFHV DLUVSDFHV WR
QHDUE\ FRPEXVWLEOHV WR SUHYHQW ¿UH KD]DUG 'R QRW
¿OODLUVSDFHVZLWKLQVXODWLRQ$OOYHQWLQJFRPSRQHQWV
PXVWPDLQWDLQD PP FOHDUDQFHWRFRPEXVWLEOH
PDWHULDOV7KH JDV DSSOLDQFH DQG YHQW V\VWHP PXVW
EH YHQWHG GLUHFWO\ WR WKH RXWVLGH RI WKH EXLOGLQJ DQG
QHYHU EH DWWDFKHG WR D FKLPQH\ VHUYLQJ D VHSDUDWH
VROLGIXHORUJDVEXUQLQJDSSOLDQFH
Refer to the manufacturer’s instructions included
ZLWK WKH YHQWLQJ V\VWHP IRU FRPSOHWH LQVWDOODWLRQ
SURFHGXUHV
In choosing a location for the stove, consider:
• The location of outside walls;
•
:KHUHDGGLWLRQDOKHDWLVQHHGHG
•
:KHUHIDPLO\PHPEHUVJDWKHUPRVWRIWHQ
•
7KHYHQWV\VWHPUHTXLUHPHQWV
NOTE::HGRQRWUHFRPPHQGWKHXVHRIZDOOSDSHUQH[WWR
WKLVVWRYH2YHUWLPHUDGLDQWKHDWPD\FDXVHWKHZDOOSDSHU
to shrink, or may adversely affect the binders in the wallpaper
DGKHVLYH
6
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Parallel Installation
Wall Centerline from Floor
Minimum Clearance and Flue Centerline
Direct Vent Only
C
L
C
A
D
A
C
L
B
(IIHFWLYH0LQLPXP
Stove Clearances
$ PP
Wall Thimble
PP ++73LSH
B PP
Centerline
PP 'XUD9HQW3LSH
C PP
Pipe Centerlines
D PP
Figure 5 - Minimum wall centerline.
Wall & Ceiling Clearances
)LJXUH 3DUDOOHO LQVWDOODWLRQ PLQLPXP EDFN DQG VLGH
FOHDUDQFHVDQGÀXHFHQWHUOLQHV
Direct Vent Only
D
Corner Installation
B
Minimum Clearance and Flue Centerline
B
C
A
A
B
A
Stove Clearances
$ PP
Pipe Centerlines
B
PP
)LJXUH &RUQHU LQVWDOODWLRQ PLQLPXP FRUQHU FOHDUDQFHV
DQGÀXHFHQWHUOLQH
7
$ Rear Wall
PP
B Minimum Clearance
PP
C 0LQLPXP$OFRYH+HLJKW
PP
D 0D[LPXP$OFRYH'HSWK
PP
Sidewall Clearance
PP
*QHHGHGIRULQVWDOOLQJ'XUD9HQW0LQLPXP9HQW.LWRU++70LQLPXP9HQW.LW6/3)66.
Figure 6 - Dimensions and clearances to ceiling or alcove.
Hearth Requirements
7KH 6WDUGDQFH KHDWHU PXVW EH LQVWDOOHG RQ ULJLG ÀRRULQJ
When the heater is installed directly on any combustible
VXUIDFH RWKHU WKDQ ZRRG ÀRRULQJ D PHWDO RU ZRRG SDQHO
H[WHQGLQJWKHIXOOZLGWKDQGGHSWKRIWKHXQLWPXVWEHXVHG
DVWKHKHDUWK7KHUHDUHQRRWKHUKHDUWKUHTXLUHPHQWV
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Horizontal Termination
*DV6SHFL¿FDWLRQV
Model
Fuel
Control
SDDVT
1DW
Millivolt
Manual
28,000
20,000
7KHYHQWPXVWULVHYHUWLFDOO\DPLQLPXPRI PP RII
WKHWRSRIWKHXQLWEHIRUHWKH¿UVWHOERZ7KHKRUL]RQWDOUXQ
PD\H[WHQGXSWR¶ P DQGLQFOXGHDYHUWLFDOULVHRIXSWR
¶ P )LJXUH +RUL]RQWDOWHUPLQDWLRQPXVWDOVRPHHW
WKHFULWHULDVKRZQLQ)LJXUHVWKURXJK
SDDVT
LP
Millivolt
Manual
25,000
21,000
•
$SSURYHG YHQW V\VWHPV PXVW WHUPLQDWH DERYH DQG
LQFOXGLQJWKHKHDY\OLQHLQ)LJXUH
SDVTSC
1DW
6LJQDWXUH
Command
28,000
20,000
•
SDVTSC
LP
6LJQDWXUH
Command
7ZRƒHOERZVPD\EHVXEVWLWXWHGIRUHDFKVLQJOHƒ
HOERZ
25,000
21,000
•
:LWKDULVHEHWZHHQ¶±¶RQHƒRUWZRƒHOERZV
PD\EHXVHG
Max.
Input
BTU/h
Min. Input
BTU/h
Gas Inlet and Manifold Pressures
Inlet Minimum
ZF
ZF
,QOHW0D[LPXP
ZF
ZF
Manifold Pressure
ZF
ZF
$LU6KXWWHU6HWWLQJ
RSHQ
´RSHQ
The installation of your Vermont Castings stove must
conform with local codes, or in the absence of local
FRGHVZLWKWKH1DWLRQDO)XHO*DV&RGH$16,=
1)3$ ODWHVW HGLWLRQ RU &6$ % ,QVWDOODWLRQ
code. (EXCEPTION: Do not derate this appliance
IRU DOWLWXGH XS WR P IRU QDWXUDO JDV DQG
IHHW P IRU/3*DV0DLQWDLQWKHPDQLIROG
SUHVVXUHDWZFIRU1DWXUDO*DVDQGZF
for LP Gas.
HIGH ELEVATIONS
Input ratings are shown in BTU per hour and are
FHUWL¿HGZLWKRXWGHUDWLRQIRUHOHYDWLRQVXSWR
IHHW P IRUQDWXUDOJDVDQGIHHW P for LP gas above sea level.
,QWKH86$LQVWDOODWLRQVZLWKHOHYDWLRQVDERYH
IHHW P IRUQDWXUDOJDVDQGIHHW P IRU
LP gas must be in accordance with the current ANSI
=1)3$DQGRUORFDOFRGHVKDYLQJMXULVGLFWLRQ
40
39
38
37
36
Vertical Run (in feet)
Liquid Propane
(Measured from the appliance flue collar to the top of the vent pipe.)
Natural
35
34
33
32
31
30
29
28
27
May use up to
WKUHHƒ(OERZV
26
25
24
23
1R5HVWULFWRU3ODWH
Required
22
21
20
19
18
16
15
14
13
12
11
10
9
8
7
6
5
In Canada, please consult provincial and/or local
authorities having jurisdiction for installations at
HOHYDWLRQV DERYH IHHW P IRU QDWXUDO JDV
DQGIHHW P IRU/3JDV
4
3
2QHƒ
(OERZ
1
0
1 2
!
WARNING
8QDFFHSWDEOH
9HQWLQJ&RQ¿JXUDWLRQ
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16 17 18 19 20
Horizontal Run (in feet)
)LJXUH+RUL]RQWDOYHQWWHUPLQDWLRQZLQGRZ
,PSURSHU LQVWDOODWLRQ DGMXVWPHQW DOWHUDWLRQ VHUYLFH RU
PDLQWHQDQFHFDQFDXVHLQMXU\RUSURSHUW\GDPDJH5HIHU
to this manual for correct installation and operational proFHGXUHV)RUDVVLVWDQFHRUDGGLWLRQDOLQIRUPDWLRQFRQVXOW
DTXDOL¿HGLQVWDOOHUVHUYLFHDJHQF\RUWKHJDVVXSSOLHU
8
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Vertical Termination
$YHUWLFDOYHQWV\VWHPPXVWWHUPLQDWHQROHVVWKDQ¶ P DQGQRPRUHWKDQ¶ P DERYHWKHDSSOLDQFHÀXHFROODU$
UHVWULFWRUSODWH VXSSOLHG PXVWEHXVHGZKHUHVSHFL¿HGLQDOO
YHUWLFDOO\WHUPLQDWHGYHQWV\VWHPV 5HIHUWR)LJXUH 127(
The restrictor plate supplied with the vertical termination
VKRXOGEHGLVFDUGHG$GMXVWWKHUHVWULFWRUSODWHDFFRUGLQJWR
UHFRPPHQGDWLRQVLQ)LJXUH$YHUWLFDOO\WHUPLQDWHGYHQW
V\VWHPPXVWDOVRFRQIRUPWRWKHIROORZLQJFULWHULD
Restrictor Plate Adjustment for Extended Pipe Runs
The Stardance stove is shipped with a restrictor plate in
WKH3DUWV%DJ$GMXVWPHQWVFDQEHPDGHE\ORRVHQLQJWKH
DGMXVWPHQWVFUHZWRDOORZWKHUHVWULFWRUSODWHWRVOLGHXSRU
GRZQ )LJXUH $JXLGHIRUXVDJHLVVKRZQLQ)LJXUH
•
1RPRUHWKDQWKUHHƒHOERZVPD\EHXVHG
127(6RPHLQVWDOODWLRQVPD\UHTXLUHVRPHDGMXVWPHQW
E\WKHLQVWDOOHUIRURSWLPXPÀDPHDSSHDUDQFH2SWLPXP
ÀDPHDSSHDUDQFHLVDÀDPHWKDWLVQRWVXEMHFWWRWDOOGLUW\
\HOORZ ÀDPHV SURGXFLQJ VRRW RU ÀDPHV OLIWLQJ RII RI WKH
HPEHUEHGSRUWV
•
7ZRƒHOERZVPD\EHVXEVWLWXWHGIRURQHƒHOERZ
1RPRUHWKDQVL[ƒHOERZVPD\EHXVHG
Restrictor Plate Adjustment
• 5HPRYHWKHVFUHZLQWKHEDFNZDOORIWKH¿UHER[
•
Vent must rise a minimum of 2 feet (305 mm) before
RIIVHWLVXVHG
•
,QVWDOOUHVWULFWRUSODWHDVVKRZQLQ)LJXUHZLWKFXWRXW
RQOHIWVLGH6HFXUHZLWKDGMXVWPHQWVFUHZ
•
7HUPLQDWLRQ KHLJKW PXVW FRQIRUP WR URRI FOHDUDQFH DV
VSHFL¿HGLQ)LJXUH
•
0HDVXUHIURPFHQWHURIVFUHZWRWRSHGJHRIGLYHUWHU
)LJXUH WR DGMXVW SODWH DFFRUGLQJ WR JXLGHOLQHV LQ
)LJXUH
•
7LJKWHQDWWDFKPHQWVFUHZ
•
,QVWDOOORJVIROORZLQJORJLQVWDOODWLRQLQVWUXFWLRQV
{ä
Ι
În
ÎÇ
Vertical Run (in feet)
(Measure from the appliance flue collar to the top of the vent pipe.)
ÎÈ
Îx
Î{
ÎÎ
ÎÓ
Σ
$OO9HUWLFDO
Terminations in this
area Require use
of the Restrictor
Plate*
Restrictor Plate
Îä
ә
Ón
ÓÇ
ÓÈ
Óx
Ó{
ÓÎ
Vertical terminations
must be within this
area
ÓÓ
Ó£
Óä
£™
£n
£È
8QDFFHSWDEOH
9HQWLQJ&RQ¿JXUDWLRQ
£x
£{
)LJXUH/RRVHQVFUHZWRDGMXVWUHVWULFWRUSODWH
£Î
£Ó
££
Examples for Extended Run/Restrictor Plate Settings
£ä
™
Vertical 20’
(6 m), 90°
elbow, out 8’
P
n
Ç
È
x
Vertical 11’
P ƒ
elbow, out 2’
(610 mm)
Vertical 40’
(12 m)
Vertical 5’
P ƒ
elbow, out 5’
P
ÊÊ{
**
ÊÊÎ
Ó
Restrictor plate measurement from top of plate to
center of screw:
£
ä
£
Ó
1R5HVWULFWRU3ODWH
Î
{
x
È
Ç
n
™
£ä ££ £Ó £Î £{ £x £È £Ç £n £™
Horizontal Run (in feet)
Figure 8 - Vertical vent termination window.
Óä
23»4´ PP Plate down
from center to top of slot
of screw to
WRSHGJHRI
plate
Plate down
to top of slot
23»8´ PP from center
of screw to
WRSHGJHRI
plate
)LJXUH
9
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Vent Termination Clearances
:KHQSODQQLQJWKHLQVWDOODWLRQFRQVLGHUWKHORFDWLRQRIWKH
YHQW WHUPLQDO DQG FOHDUDQFHV 6RPH RI WKH PRVW FRPPRQ
FOHDUDQFHVWRNHHSLQPLQGDUHVKRZQLQ)LJXUH
<RXUVWRYHLVDSSURYHGWREHYHQWHGHLWKHUWKURXJKWKHVLGH
ZDOORUYHUWLFDOWKURXJKWKHURRI
•
++7GRHVQRWUHTXLUHDQ\RSHQLQJIRULQVSHFWLRQRIYHQW
SLSH
Important: All vent clearances must be maintained.
Check your vent termination clearances against Figures
11 and 12.
•
QO\ ++7 6/3 FRPSRQHQWV RU 'XUD9HQW YHQWLQJ
2
FRPSRQHQWV VSHFL¿FDOO\ DSSURYHG DQG ODEHOHG IRU WKLV
VWRYHPD\EHXVHG
The vent should be placed so that people cannot be burned
E\DFFLGHQWDOO\WRXFKLQJWKHYHQWVXUIDFHVZKHQWKHVWRYH
LVRSHUDWLQJ
•
Minimum clearances between vent pipes and
FRPEXVWLEOHPDWHULDOVLVRQH LQFK PP H[FHSW
ZKHUHVWDWHGRWKHUZLVH
The vent termination should be located where it cannot be
GDPDJHGE\VXFKWKLQJVDVDXWRPRELOHGRRUVODZQPRZHUV
or snowblowers and it should be located away from areas
ZKHUHLWFRXOGEHFRPHEORFNHGE\VQRZHWF
•
9HQWLQJ WHUPLQDOV VKDOO QRW EH UHFHVVHG LQWR D ZDOO RU
VLGLQJ
•
+RUL]RQWDO YHQWLQJ PXVW EH LQVWDOOHG RQ D OHYHO SODQH
ZLWKRXWDQLQFOLQLQJRUGHFOLQLQJVORSH
6RPHFRQVLGHUDWLRQVDUH
•
2EVWUXFWLRQVRULPSHGLPHQWVWRYHQWLQJ
•
1HDUE\ FRPEXVWLEOH PDWHULDOV WKDW FRXOG FRPH LQWR
FRQWDFWZLWKFRPEXVWLRQH[KDXVWJDVHV
•
2WKHU QHDUE\ RSHQLQJV ^ZLWKLQ PP ` WKURXJK
ZKLFKH[KDXVWJDVFRXOGUHHQWHUWKHEXLOGLQJ
•
$OOYHJHWDWLRQZLWKLQ¶ PP WKDWPD\LQWHUIHUHZLWK
WKHGUDIW
2WKHU IDFWRUV WKDW LQÀXHQFH ZKHUH WKH LQVWDOODWLRQ ZLOO EH
sited include the location of outside walls, where additional
heat may be desired in the home, where the family members
JDWKHU PRVW UHJXODUO\ DQG SHUKDSV PRVW LPSRUWDQWO\ WKH
GLVWDQFHOLPLWDWLRQVRIWKHYHQWLQJV\VWHP
There must not be anyREVWUXFWLRQVXFKDVEXVKHVJDUGHQ
VKHGVIHQFHVGHFNVRUXWLOLW\EXLOGLQJVZLWKLQIURPWKH
IURQWRIWKHWHUPLQDWLRQKRRG
'RQRWORFDWHWHUPLQDWLRQKRRGZKHUHH[FHVVLYHVQRZRULFH
EXLOGXSPD\RFFXU%HVXUHWRFKHFNYHQWWHUPLQDWLRQDUHD
DIWHUVQRZIDOOVDQGFOHDUWRSUHYHQWDFFLGHQWDOEORFNDJHRI
YHQWLQJV\VWHP:KHQXVLQJVQRZEORZHUVPDNHVXUHVQRZ
LVQRWGLUHFWHGWRZDUGVYHQWWHUPLQDWLRQDUHD
Location of Vent Termination
,WLVLPSHUDWLYHWKHYHQWWHUPLQDWLRQEHORFDWHGREVHUYLQJWKH
PLQLPXPFOHDUDQFHVDVVKRZQLQWKLVPDQXDO
IMPORTANT
The horizontal termination must not be recessed into
the exterior wall or siding.
Horizontal vent runs must be level toward the vent
termination.
Clearances around the vent termination must be
maintained.
For installations using DuraVent pipe, parallel installations
with minimum wall clearance have restricted access for
connecting the Horizontal Vent Cap straps to the vent
pipe. See the maker’s instructions for recommended
installation procedures.
10
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
General Venting Information - Termination Location
INSIDE
CORNER DETAIL
G
V
N
H
A
D
V
E
L
C
B
V
F
B
Fixed
Closed
V
B
V
Ope
rable
Operable
V
Fixed
Closed
B
B
B
V
J
I
A
CFM145a
V VENT TERMINATION
X AIR SUPPLY INLET
M
X
X
K
V
AREA WHERE TERMINAL IS NOT PERMITTED
CANADIAN INSTALLATIONS1
US INSTALLATIONS2
$ &OHDUDQFHDERYHJUDGHYHUDQGDSRUFKGHFN FP
or balcony
FP
% &OHDUDQFHWRZLQGRZRUGRRUWKDWPD\EH
opened
FP IRUDSSOLDQFHV%78K N:
FP IRUDSSOLDQFHV%78K N:
FP IRUDSSOLDQFHV!%78K N: DQG%78K N:
FP IRUDSSOLDQFHV!%78K N: DQG
%78K N:
FP IRUDSSOLDQFHV!%78K N:
FP IRUDSSOLDQFHV!%78K N:
& &OHDUDQFHWRSHUPDQHQWO\FORVHGZLQGRZ
PP UHFRPPHQGHGWRSUHYHQWZLQGRZ
condensation
PP UHFRPPHQGHGWRSUHYHQWZLQGRZ
condensation
' 9HUWLFDOFOHDUDQFHWRYHQWLODWHGVRI¿WORFDWHG
PP
DERYHWKHWHUPLQDOZLWKLQDKRUL]RQWDOGLVWDQFH
of 2' (610 mm) from the center line of the
terminal
PP
( &OHDUDQFHWRXQYHQWLODWHGVRI¿W
PP PP ) &OHDUDQFHWRRXWVLGHFRUQHU
VHHQH[WSDJH
VHHQH[WSDJH
* &OHDUDQFHWRLQVLGHFRUQHU
VHHQH[WSDJH
VHHQH[WSDJH
+ &OHDUDQFHWRHDFKLQVLGHRIFHQWHUOLQH
H[WHQGHGDERYHPHWHUUHJXODWRUDVVHPEO\
FP ZLWKLQDKHLJKWRI P DERYHWKH
PHWHUUHJXODWRUDVVHPEO\
FP ZLWKLQDKHLJKWRI P DERYHWKH
PHWHUUHJXODWRUDVVHPEO\
, &OHDUDQFHWRVHUYLFHUHJXODWRUYHQWRXWOHW
3' (91cm)
3' (91cm)
- &OHDUDQFHWRQRQPHFKDQLFDODLUVXSSO\LQOHW
WREXLOGLQJRUWKHFRPEXVWLRQDLULQOHWWRDQ\
other appliance
FP IRUDSSOLDQFHV%78K N:
FP IRUDSSOLDQFHV%78K N:
FP IRUDSSOLDQFHV!%78K N: DQG%78K N:
FP IRUDSSOLDQFHV!%78K N: DQG
%78K N:
FP IRUDSSOLDQFHV!%78K N:
FP IRUDSSOLDQFHV!%78K N:
. &OHDUDQFHWRPHFKDQLFDODLUVXSSO\LQOHW
P
FP DERYHLIZLWKLQ P KRUL]RQWDOO\
/ &OHDUDQFHDERYHSDYHGVLGHZDONRUSDYHG
driveway located on public property
P
0 &OHDUDQFHXQGHUYHUDQGDSRUFKGHFNRU
balcony
FP
P
†
‡
†
FP
‡
1 &OHDUDQFHDERYHDURRIVKDOOH[WHQGDPLQLPXPRI´ PP DERYHWKHKLJKHVWSRLQWZKHQLWSDVVHVWKURXJKWKHURRIVXUIDFHDQGDQ\RWKHUREVWUXFWLRQ
ZLWKLQDKRUL]RQWDOGLVWDQFHRI´ PP Figure 11 - Vent termination clearances.
,QDFFRUGDQFHZLWKWKHFXUUHQW&6$%,QVWDOODWLRQ
Codes
,QDFFRUGDQFHZLWKWKHFXUUHQW$16,=1)3$
1DWLRQDO)XHO*DV&RGHV
‚$YHQWVKDOOQRWWHUPLQDWHGLUHFWO\DERYHDVLGHZDONRU
SDYHGGULYHZD\ZKLFKLVORFDWHGEHWZHHQWZRVLQJOH
IDPLO\GZHOOLQJVDQGVHUYHVERWKGZHOOLQJV
‡2QO\SHUPLWWHGLIYHUDQGDSRUFKGHFNRUEDOFRQ\LVIXOO\
RSHQRQDPLQLPXPVLGHVEHQHDWKWKHÀRRU
11
NOTE:
/RFDO FRGHV RU UHJXODWLRQV PD\ UHTXLUH GLIIHUHQW
FOHDUDQFHV
7KHVSHFLDOYHQWLQJV\VWHPXVHGRQ'LUHFW9HQW)LUHSODFHV
DUH FHUWL¿HG DV SDUW RI WKH DSSOLDQFH ZLWK FOHDUDQFHV
WHVWHGDQGDSSURYHGE\WKHOLVWLQJDJHQF\
++7 DVVXPHV QR UHVSRQVLELOLW\ IRU WKH LPSURSHU
SHUIRUPDQFHRIWKHDSSOLDQFHZKHQWKHYHQWLQJV\VWHP
GRHVQRWPHHWWKHVHUHTXLUHPHQWV
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Termination Clearances
Termination clearances for buildings with combustible and noncombustible exteriors.
Alcove Applications*
Inside Corner
Outside Corner
D
C
G=
Combustible
6" (152 mm)
G
V
Noncombustible
2" (51 mm)
V
V
O
F
Balcony with perpendicular side wall
Balcony with no side wall
C
F=
Combustible
6" (152 mm)
Noncombustible
2" (51 mm)
E
E = Min. 2” (51 mm) for
non-vinyl sidewalls
Min. 12” (305 mm) for
vinyl sidewalls
O = 8’ (2.4 m) Min.
M
M
V
V
P
M=
Combustible &
Noncombustible
12" (305 mm)
Combustible &
Noncombustible
M = 12" (305 mm)
P = 6” (152 mm)
RI
Caps
D0LQ
C0D[
1
3’ (914 mm)
;'$FWXDO
2
¶ P
;'$FWXDO
3
¶ P
;'$FWXDO
4
¶ P
;'$FWXDO
D0LQ RI7HUPLQDWLRQFDSV[
C0D[ WHUPLQDWLRQFDSV ['$FWXDO
*NOTE:7HUPLQDWLRQLQDQDOFRYHVSDFH VSDFHVRSHQRQO\RQRQHVLGHDQGZLWKDQRYHUKDQJ LVSHUPLWWHGZLWKWKHGLPHQVLRQVVSHFL¿HGIRUYLQ\ORU
QRQYLQ\OVLGLQJDQGVRI¿WV7KHUHPXVWEHD¶ PP PLQLPXPEHWZHHQWHUPLQDWLRQFDSV$OOPHFKDQLFDODLULQWDNHVZLWKLQ¶ P RID
WHUPLQDWLRQFDSPXVWEHDPLQLPXPRI¶ PP EHORZWKHWHUPLQDWLRQFDS$OOJUDYLW\DLULQWDNHVZLWKLQ¶ PP RIDWHUPLQDWLRQFDSPXVW
EHDPLQLPXPRI¶ PP EHORZWKHWHUPLQDWLRQFDS
Figure 12 - Termination clearances.
12
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Approved Vent System Components
7KH6WDUGDQFHKHDWHUPXVWEHYHQWHGWRWKHRXWGRRUVWKURXJK
DQ DGMDFHQW H[WHULRU ZDOO RU WKURXJK WKH URRI7KH YHQWLQJ
V\VWHPPXVWEHFRPSULVHGRIWKHDSSURSULDWHOLVWHGYHQWLQJ
FRPSRQHQWVVSHFL¿HGRQWKLVSDJH7KHVHSDUWVDUHDYDLODEOH
IURP'XUD9HQW&RUSRUDWLRQRU\RXU9HUPRQW&DVWLQJV'HDOHU
6HH )LJXUH IRU GLPHQVLRQV UHOHYDQW WR WKH VWDQGDUG
PLQLPXPYHQWNLWV
HHT Components*
DuraVent Components
6WDUWHU 3LSH $VVHPEO\ LQFO LQQHU RXWHU
sections)
ƒ(OERZ%ON
ƒ(OERZ*DO
6WUDLJKW%ON
6WUDLJKW%ON
± »8$GMXVWDEOH6WUDLJKW6HFWLRQ
5
6WUDLJKW
6WUDLJKW
'9$$'3
'9$(%
'9$(
'9$%
'9$%
'9$$%
'9$
'9$%
6/3+RUL]RQWDO7HUPLQDWLRQ.LW 7HUPLQDWLRQ
&DS6/3%.6/3%.6/3$%.
6/3%.6/3:7%. &&6/3
6/36.%.
6WRYH$GDSWHU.LW ,QFOXGHV RI)OH[
DGDSWHUVZDOOWKLPEOHPDVRQU\DQG=&
ÀDVKLQJ'$&DSDQG)DVWHQHUV
/,1.6729(
7UDSH]RLG7HUPLQDWLRQ.LW ´´
6/375$3
9LQ\O6LGLQJ6KLHOG
7UDSH]RLG7HUPLQDWLRQ.LW ´´
6/375$3
6QRUNHO7HUPLQDWLRQ±
'9$61.
5HDU9HQW7HUPLQDWLRQ.LW
6/3597.
6QRUNHO7HUPLQDWLRQ±
'9$61.
9HUWLFDO7HUPLQDWLRQFDS+LJK:LQG
(includes storm collar)
6/379+:
Wall Strap
'9$:6
&DWKHGUDO&HLOLQJ6XSSRUW%R[
'9$&6
Decorative Wall Thimble Cover
6/3:7%.
Storm Collar
'9$6&
'HFRUDWLYHFHLOLQJ¿UHVWRSEODFN
6/3'&)%.
)LUHVWRS6SDFHU
'9$)6
&DWKHGUDOFHLOLQJVXSSRUWEODFN
6/3&&6%.
)ODVKLQJ
'9$)
PP SLSHOHQJWKEODFN
6/3%.
)ODVKLQJ
'9$)
PP SLSHOHQJWKEODFN
6/3%.
Wall Thimble
3LSHOHQJWKEODFN
6/3%.
Wall Thimble
'9$:7
3LSHOHQJWKEODFN
6/3%.
Wall Thimble Cover (Brass)
3937.9
PP SLSHOHQJWKEODFN
6/3%.
:DOO)LUHVWRS
'9$:)6
3LSHOHQJWKEODFN
6/3%.
$WWLF,QVXODWLRQ6KLHOG
'9$,6
PP WHOHVFRSLQJSLSH
H[WHQVLRQEODFN
6/3$%.
&R/LQHDU9HQW$GDSWHU
'9$*&/
WHOHVFRSLQJSLSHH[WHQVLRQEODFN
6/3$%.
GHJUHHHOERZEODFN
6/3%.
GHJUHHHOERZEODFN
6/3%.
5DGLDQFH6WDUGDQFH2[IRUG6/3DGDSWHU
CCSLP
)UHHVWDQGLQJ'UDIW+RRG$GDSWHU
)6'+$*6/3
6/6QRUNHO&DS ,QFOXGHVSDLURI¿UHVWRSV
6/.61.'
6WUDLJKW
'9$%
6WUDLJKW
'9$
+RUL]RQWDO9HQW&DS
Wall Plate
&&6/3DGDSWHULVUHTXLUHGZKHQXVLQJ++7FRPSRQHQWV
Wall Thimble Cover (Brass)
:DOO)LUHVWRS
$WWLF,QVWDOODWLRQ6KLHOG
'9$+&
'9$'&
'9$966
'9$:7
3937.9
'9$:)6
'9$,6
&R/LQHDU9HQW$GDSWHU
'9$*&/
6WHHO&KLPQH\&RQY.LW$ '9$.&$
6WHHO&KLPQH\&RQY.LW% '9$.&%
6WHHO&KLPQH\&RQY.LW& ±
'9$.&&
0DVRQU\&KLPQH\&RQYHUVLRQ.LW
'9$.0&
9HUWLFDO7HUPLQDWLRQ&DS +LJK:LQG
'9$9&+
9HUWLFDO7HUPLQDWLRQ&DS /RZ3UR¿OH
'9$9&
$OO'XUD9HQW6WUDLJKWYHQWSLSHVHFWLRQVKDYHDQHWOHQJWK
PP OHVV WKDQ WKH QRPLQDO GLPHQVLRQ LH D PP 6WUDLJKWSLSHVHFWLRQKDVDQHIIHFWLYHOHQJWKRI PP 13
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Assembly & Installation
Tools Required
• Phillips screwdriver (stub)
• 8WLOLW\NQLIH
• 0HWDOGULOOELWVL]H PP
• )ODWEODGHVFUHZGULYHU
• Power drill
• 5HFLSURFDWLQJVDZ
• :UHQFK
• :UHQFK
Parts Bag Contents:
• /3&RQYHUVLRQ.LW
• Three (3) Vent Screws
• Two (2) Switch bracket screws
• :RRGKDQGOHZLQVHUWOLIWHU KDQGOHIRURSHUDEOHGRRU
• Restrictor Plate
• 6WDUWHUSLSH
• 2Q2IIVZLWFKKRXVLQJDQGZLULQJKDUQHVV
• 7KUHH 3KLOOLSVURXQGKHDGEROWV±[
• 2QH 7XEHRI9HQW*DVNHW&HPHQW
• +RPHRZQHU¶V,QVWDOODWLRQDQG2SHUDWLQJ0DQXDO
Unpack Stove
8VLQJ WKH ZUHQFK UHPRYH WKH ODJ EROWV LQVWDOOHG
WKURXJKWKHVKLSSLQJEUDFNHWVDQGLQWRWKHVNLG2QFHWKH
ODJEROWVDUHUHPRYHGUHPRYHWKHVKLSSLQJEUDFNHWVIURP
WKHVWRYHXVLQJZUHQFKRUVRFNHWDQGLQVWDOOOHJOHYHOOHUV
ORFDWHGLQWKHPDQXDOEDJRQWRWKHOHJV
!
WARNING
7KLVDSSOLDQFHLVHTXLSSHGZLWKDWKUHHSURQJ JURXQGHG SOXJIRU\RXUSURWHFWLRQDJDLQVWVKRFNKD]DUGDQGVKRXOG
EHSOXJJHGGLUHFWO\LQWRDSURSHUO\JURXQGHGWKUHHSURQJ
UHFHSWDFOH 'R QRW FXW RU UHPRYH WKH JURXQGLQJ SURQJ
IURPWKLVSOXJ
Install the Optional Fan – SDDVT models (Millivolt Only See page 27 for SC Models)
,I\RXDUHLQVWDOOLQJWKHRSWLRQDOFRQYHFWLRQ)DQ.LW
). FRQWLQXHKHUH,WLVHDVLHVWWRLQVWDOOIDQNLWEHIRUH
FRQQHFWLQJJDVOLQH
Snapstat
Bracket
6QDSVWDW
([WHQVLRQ
$VVHPEO\
1RW8VHG2Q
Stardance
Rheostat
$VVHPEO\
Blower
$VVHPEO\
Figure 15)DQNLWFRPSRQHQWV
5HPRYHWKHUHDUVNLUWLQVHUWSDQHODWWKHERWWRPRIWKH
5HDU6NLUW )LJXUH DQGIDVWHQWKHEORZHU DVVHPEO\
WRWKH¿UHER[EDFNZLWKWKHWZR3KLOOLSVSDQKHDGEROWV
RULJLQDOO\LQVWDOOHGLQWKH¿UHER[EDFN µ¶)LJXUH
$WWDFK WKH VQDSVWDW DVVHPEO\ WR WKH VQDSVWDW EUDFNHW
ZLWK WZR VKHHWPHWDO VFUHZV µ¶ )LJXUH $WWDFK
WKH VQDSVWDW EUDFNHW WR WKH VWRYH ZLWK D KH[KHDG EROW
SDVVLQJWKURXJKWKHEUDFNHWDQGLQWRWKHVWRYHEDVH µ¶
)LJXUH
7KHUKHRVWDWFRQWUROVZLWFKDWWDFKHVWRWKHOHIWVLGHRIWKH
YDOYHEUDFNHWDWWKHIURQWRIWKHVWRYH )LJXUH
Rear Skirt
Sheet Metal Screws
Rear Skirt Insert
Figure 16 - Remove rear shroud.
7KHIDQNLWLQFOXGHVD%ORZHU$VVHPEO\DQGD5KHRVWDW
$VVHPEO\FRQQHFWHGE\DFDEOH )LJXUH 7KH%ORZHU
$VVHPEO\PRXQWVWRWKHERWWRPUHDURIWKHVWRYHDQGWKH
5KHRVWDWPRXQWVWRWKHYDOYHFRYHUSODWH7KHDVVHPEO\
includes a ‘snapstat’ which automatically turns the fan
2Q RU 2II DERYH RU EHORZ DSSUR[LPDWHO\ ƒ 7KH
5KHRVWDW DOVR SURYLGHV D UDQJH RI IDQ VSHHG VHWWLQJV
IURP2II ZKLFKRYHUULGHVWKHVQDSVWDWIXQFWLRQ WR+LJK
8QSDFNDQGLQVSHFWWKH%ORZHUDVVHPEO\&RQ¿UPWKDW
WKHIDQVSLQVIUHHO\
14
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Star Washer
Sheet Metal Screws
2
1
Phillips
3DQ+HDG
Bolts
Snapstat
´±
+H[%ROW
Star
Washer
3
Snapstat
Bracket
NOTE:6KRZQZLWKRXWVKHOOIRUFODUL¿FDWLRQ
)LJXUH$WWDFKEORZHUDVVHPEO\DQGVQDSVWDW
Rheostat
Rheostat
5HWDLQLQJ&ROODU
5KHRVWDW.QRE
Figure 18$WWDFKWKHIDQUKHRVWDW
‡ 5HPRYH UHWDLQLQJ QXW IURP VKDIW RI UKHRVWDW LI
preinstalled)
‡ ,QVHUWWKHUKHRVWDWWKURXJKWKHKROHLQWKHEDFNRIWKHOHIW
VLGHRIWKHYDOYHEUDFNHWDOLJQLQJWKHORFDWRUSLQZLWKWKH
VPDOOHUKROHLQWKDWEUDFNHW
‡ 7KUHDGWKHUHWDLQLQJQXWRQWRWKHVKDIWRIWKHUKHRVWDW
WLJKWHQLQJZLWKDZUHQFK'RQRWRYHUWLJKWHQ
‡ $WWDFKWKHFRQWURONQREWRWKHUKHRVWDWVKDIW
‡ 8VH WKH ZLUH WLH WR VHFXUH WKH IDQ DQG UKHRVWDW ZLUH
KDUQHVVHVWRJHWKHU
15
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Venting System Assembly
!
WARNING
$OZD\V PDLQWDLQ PLQLPXP FOHDUDQFHV DURXQG YHQW
V\VWHPV 5HDU7RS 9HQW 9HUWLFDO 6LGH ZDOO +RUL]RQWDO
VHFWLRQVRIWKLVYHQWV\VWHPUHTXLUHDPLQLPXPRI´ PP FOHDUDQFHVWRFRPEXVWLEOHVDWWKHWRSRIWKHÀXHDQG
´ PP FOHDUDQFHDWWKHVLGHVDQGERWWRPXQWLOWKHÀXH
SHQHWUDWHVWKHRXWVLGHZDOO$PLQLPXP´FOHDUDQFHDOO
DURXQGWKHÀXHLVDFFHSWDEOHDWWKLVSRLQWRISHQHWUDWLRQ,I
YHUWLFDOULVHLV»IHHW P RUKLJKHUZKHQWRSYHQWLQJ
WKH FOHDUDQFH WR FRPEXVWLEOHV LV ´ RQ DOO VLGHV RI WKH
KRUL]RQWDOUXQ)259(57,&$/581621/<PDLQWDLQD
´ PP PLQLPXPFOHDUDQFHWRDOOVLGHV'RQRWSDFN
WKHRSHQDLUVSDFHVDURXQGWKHVWRYHRUÀXHZLWKLQVXODWLRQ
RURWKHUPDWHULDOV$Q\KRUL]RQWDOUXQPXVWKDYHD´ULVH
IRUHYHU\RQH IRRWRIUXQWRZDUGVWKHYHQWWHUPLQDWLRQ
1HYHUUXQWKHYHQWOHYHORUGRZQ
!
WARNING
)DLOXUHWRIROORZWKHVHLQVWUXFWLRQVPD\FUHDWHDSRVVLEOH
¿UHKD]DUGDQGZLOOYRLGWKHZDUUDQW\
!
7KHVHPRGHOVDUHDSSURYHGWRXVH++7GLUHFWYHQWSLSH
FRPSRQHQWV DQG ++7 WHUPLQDWLRQ NLWV DQG 'XUD9HQW
FRPSRQHQWV1RRWKHUYHQWLQJV\VWHPFRPSRQHQWVPD\
EHXVHG
•
+RUL]RQWDOUXQVPXVWEHVXSSRUWHGHYHU\IHHW PP XVLQJZDOOVWUDSV9HUWLFDOUXQVPXVWEHVXSSRUWHGHYHU\
IHHW P XVLQJZDOOVWUDSV6OLSZDOOVWUDSVORRVHO\
RQWRSLSH$WWDFKVWUDSVWRIUDPLQJPHPEHUVXVLQJQDLOV
RUVFUHZV7LJKWHQQXWEROWWRVHFXUHSLSH
•
7KH VWRYH DQG YHQWLQJ V\VWHP VKRXOG EH LQVSHFWHG
EHIRUH LQLWLDO XVH DQG DW OHDVW DQQXDOO\ E\ D TXDOL¿HG
¿HOGVHUYLFHSHUVRQ,QVSHFWWKHH[WHUQDOYHQWFDSRQD
UHJXODU EDVLV WR PDNH VXUH WKDW QR GHEULV LV LQWHUIHULQJ
ZLWKWKHDLUÀRZ,QVSHFWHQWLUHYHQWLQJV\VWHPWRHQVXUH
SURSHUIXQFWLRQ
CAUTION
$OO ++7 'LUHFW 9HQW 6WRYHV KDYH EHHQ WHVWHG DQG
DSSURYHGWR$16,&6$6WDQGDUGVDQGZLOORSHUDWHVDIHO\
ZKHQLQVWDOOHGLQDFFRUGDQFHZLWKWKLVLQVWUXFWLRQPDQXDO
5HDGDOOLQVWUXFWLRQVEHIRUHVWDUWLQJLQVWDOODWLRQWKHQIROORZ
WKHVHLQVWUXFWLRQVFDUHIXOO\WRPD[LPL]HVWRYHSHUIRUPDQFH
DQGVDIHW\5HSRUWGDPDJHGSDUWVWR\RXUGHDOHU
!
•
WARNING
$Q\FRPPRQYHQWLQJRIWKLVJDVDSSOLDQFHZLWKRWKHUJDV
DSSOLDQFHVLVQRWDOORZHG
Outside Wall
Finishing Material
(Vinyl Siding, etc.)
)LJXUH7HUPLQDWLRQFDSRQZDOO
Before You Start
3ODQ\RXULQVWDOODWLRQ6HWWKHVWRYHLQSODFHDQGVXUYH\KRZ
WREHVWYHQWWKHXQLW6HOHFWWKHDSSURSULDWHWHUPLQDWLRQNLW
DQGYHQWSLSHIRUWKHLQVWDOODWLRQ5HDGWKHVHLQVWUXFWLRQVDQG
WKHVWRYH+RPHRZQHU¶V0DQXDOEHIRUHEHJLQQLQJLQVWDOODWLRQ
$IWHUYHQWFRQ¿JXUDWLRQKDVEHHQGHFLGHGEHJLQDWWDFKLQJ
SLSHWRXQLW
,WHPVUHTXLUHGIRULQVWDOODWLRQ
Important Safety Information
7KHWHUPLQDWLRQFDS0867EHYHQWHGGLUHFWO\WRWKHRXWVLGH
7KHWHUPLQDWLRQNLW08671(9(5EHFRQQHFWHGWRDFKLPQH\
ÀXH V VHUYLFLQJDVHSDUDWHVROLGIXHOEXUQLQJDSSOLDQFHRU
DQ\RWKHUDSSOLDQFHV
•
•
16
7HUPLQDWLRQFDS0867127EHUHFHVVHGLQWRDZDOO VHH
)LJXUH The installation must conform with local codes or in the
DEVHQFHRIORFDOFRGHVZLWKWKH1DWLRQDO)XHO*DV&RGH
$16, = LQ WKH 8QLWHG 6WDWHV RU ZLWK WKH FXUUHQW
LQVWDOODWLRQFRGH&6$% LQ&DQDGD Tools:
3KLOOLSVVFUHZGULYHU
6DZDQGRUVDEHUVDZ
0HDVXULQJ7DSH
Pliers
+DPPHU
/HYHO
(OHFWULFGULOODQGELWV
Square
Building Supplies:
)UDPLQJPDWHULDOV
:DOO¿QLVKLQJPDWHULDOV
&DXONLQJ0DWHULDO QRQFRPEXVWLEOH
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
!
WARNING
5HIHUWRSDJHVDQGRIWKLVPDQXDOIRUWKHPLQLPXP
DQG PD[LPXP YHQWLQJ UHTXLUHPHQWV RI \RXU VWRYH DQG
IRU DSSURYHG KRUL]RQWDO YHQW WHUPLQDWLRQ ORFDWLRQV SULRU
WRLQVWDOODWLRQ)DLOXUHWRGRVRPD\FDXVH¿UHKD]DUG
ENT
CEM
!
WARNING
$Q\KRUL]RQWDOUXQPXVWKDYHD´ULVHIRUHYHU\RQH IRRWRIUXQWRZDUGVWKHYHQWWHUPLQDWLRQ1HYHUDOORZWKH
YHQWSLSHWRUXQGRZQ7KLVFRXOGFDXVHKLJKWHPSHUDWXUHV
DQGPD\SUHVHQWD¿UHKD]DUG
!
WARNING
Termination cap must be positioned so the embossed
DUURZLVSRLQWHGXS
General Information
The Stardance is approved for installation only with the
YHQW FRPSRQHQWV OLVWHG LQ WKH Approved Vent System
&RPSRQHQWV VHFWLRQ LQ WKLV PDQXDO )ROORZ WKH YHQW
FRPSRQHQWLQVWUXFWLRQVH[DFWO\
)LJXUH&RQQHFWWKHLQQHUVWDUWHUZLWKWKHQH[WVHFWLRQRI
inner vent pipe.
$WWDFKWKH,QQHU9HQW$VVHPEO\WRWKHVWRYH
3ODFHDEHDGRIPLOOSDFNFDXONDURXQGWKHLQVLGHRI
WKHFDVWVWDUWHUFROODU,QVHUWWKHRXWHUDGDSWHULQWR
WKHFDVWRXWHUVWDUWLQJFROODUDQGSUHVVGRZQ¿UPO\
,QVWDOOWKH&&6/32XWHU$GDSWHU3LSH
3ODFH D EHDG RI PLOOSDFN FDXON DURXQG WKH FULPSHGHQGRIWKHVWDUWHUFROODURQWKHVWRYH$WWDFKWKH
6/3SLSHWRWKHDGDSWHUDQGVHFXUHE\DOLJQLQJDGDSWHU
DQGSLSHVHDPVSUHVVLQJGRZQ¿UPO\XQWLOSLSHVWRSV
DQGWZLVWLQJWRORFNLQWRSODFH )LJXUH
)RU86LQVWDOODWLRQV7KHYHQWLQJV\VWHPPXVWFRQIRUPZLWK
ORFDOFRGHVDQGRUWKHFXUUHQW1DWLRQDO)XHO*DV&RGH$16,
=1)3$
)RU&DQDGLDQLQVWDOODWLRQV7KHYHQWLQJV\VWHPPXVWFRQIRUP
WRWKHFXUUHQW&6$%LQVWDOODWLRQFRGH
Install the Vent Adapter Pipe (HHT SLP Vent
Components)
$WWDFK,QQHU6WDUWHU3LSH IRXQGLQWKH3DUWV%DJ WRWKH
QH[WVHFWLRQRILQQHUSLSH
5XQDEHDGRIVHDODQWDERXWIURPWKHXSSHUHQGRI
WKH,QQHUVWDUWHUSLSHDQGMRLQWKHWZRVHFWLRQVWRJHWKHU
Drill three pilot holes into the Inner Starter and secure
WKHDVVHPEO\ZLWKWKUHHVKHHWPHWDOVFUHZV )LJXUH
'U\ ¿W WKH ,QQHU 3LSH DVVHPEO\ WR WKH VWRYH IRU WKH
SXUSRVHRIGHWHUPLQLQJWKHFHQWHUOLQHRIWKHSLSHRQWKH
ZDOO
)LJXUH$WWDFKLQQHUDVVHPEO\WRÀXHFROODU
6LGH:DOO7HUPLQDWLRQV'U\¿WWKHRXWHUHOERZZLWKWKH
YHUWLFDORXWHUYHQWDQGFRQ¿UPWKHFHQWHUOLQHDOLJQPHQW
ZLWKWKHZDOOWKLPEOHRSHQLQJ
17
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Assemble Slip Sections
7KHRXWHUÀXHRIWKHVOLSVHFWLRQVKRXOGVOLGHRYHUWKHRXWHU
ÀXH RI WKH SLSH VHFWLRQ DQG LQWR LQQHU ÀXH WKH ODVW SLSH
VHFWLRQ )LJXUH
6OLGHWRJHWKHUWRWKHGHVLUHGOHQJWKPDNLQJVXUHWKDWD
RXWHU ÀXH RYHUODS LV PDLQWDLQHG EHWZHHQ WKH SLSH VHFWLRQ
DQGVOLSVHFWLRQ
7KHSLSHDQGVOLSVHFWLRQQHHGWREHVHFXUHGE\GULYLQJWZR
LQVFUHZVWKURXJKWKHRYHUODSSLQJSRUWLRQVRIWKHRXWHU
ÀXHVXVLQJWKHSLORWKROHV )LJXUH
7KLV ZLOO VHFXUH WKH VOLS VHFWLRQ WR WKH GHVLUHG OHQJWK DQG
SUHYHQW LW IURP VHSDUDWLQJ 7KH VOLS VHFWLRQ FDQ WKHQ EH
DWWDFKHGWRWKHQH[WSLSHVHFWLRQ
,IWKHVOLSVHFWLRQLVWRRORQJWKHLQQHUDQGRXWHUÀXHVRIWKH
VOLSVHFWLRQFDQEHFXWWRWKHGHVLUHGOHQJWK
!
WARNING
5LVNRI)LUH([SORVLRQDO NOT break seals on slip secWLRQV8VHFDUHZKHQUHPRYLQJWHUPLQDWLRQFDSIURPVOLS
SLSH,IVOLSVHFWLRQVHDOVDUHEURNHQGXULQJUHPRYDORIWKH
WHUPLQDWLRQFDSYHQWPD\OHDN
)LJXUH6FUHZVLQWR6OLS6HFWLRQ
Secure the Vent Sections
9HUWLFDOVHFWLRQVRI6/3SLSHPXVWEHVXSSRUWHGHYHU\IW
7KH6/3¿UHVWRSLQFOXGHVWDEVWKDWPD\EHXVHGWRVHFXUH
YHUWLFDOVHFWLRQV
The vent support or plumber’s strap (spaced 120° apart)
may be used to secure the vertical sections of pipe (see
)LJXUH +RUL]RQWDOVHFWLRQVRIYHQWPXVWEHVXSSRUWHGHYHU\IWZLWK
DYHQWVXSSRUWRUSOXPEHU¶VVWUDS VHH)LJXUH !
CORRECT
INCORRECT
WARNING
5LVN RI )LUH([SORVLRQ$VSK\[LDWLRQ ,PSURSHU VXSSRUW
PD\DOORZYHQWWRVDJDQGVHSDUDWH8VHYHQWUXQVXSSRUWV
DQGFRQQHFWYHQWVHFWLRQVSHULQVWDOODWLRQLQVWUXFWLRQV'2
127DOORZYHQWWRVDJEHORZFRQQHFWLRQSRLQWWRDSSOLDQFH
Figure 22 - Make sure the seams are not aligned to prevent
unintentional disconnection.
)LJXUH6OLS6HFWLRQ3LORW+ROHV
18
Figure 25 - Securing Vertical Pipe Sections
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Horizontal Termination Cap
!
WARNING
5LVNRI)LUH7KHWHOHVFRSLQJÀXHVHFWLRQRIWKHWHUPLQDWLRQ
FDS0867EHXVHGZKHQFRQQHFWLQJYHQW
•
´ PP PLQLPXP RYHUODS RI YHQW DQG
WHOHVFRSLQJÀXHVHFWLRQLVUHTXLUHG
)DLOXUHWRPDLQWDLQRYHUODSPD\FDXVHRYHUKHDWLQJDQG
¿UH
Figure 26 - Securing Horizontal Pipe Sections
Disassemble Vent Sections
To disassemble any two pieces of pipe, rotate either section
)LJXUH VR WKDW WKH VHDPV RQ ERWK SLSH VHFWLRQV DUH
DOLJQHG )LJXUH 7KH\FDQWKHQEHFDUHIXOO\SXOOHGDSDUW
Note: For horizontal vent runs through a combustible
wall and framing dimensions, refer to appliance
installation manual.
Install the Horizontal Termination Cap
$WWDFKVOLSVHFWLRQRIFDSWRODVWYHQWVHFWLRQ0DLQWDLQ1»2
RYHUODSEHWZHHQVOLSDQGYHQWVHFWLRQV
Note: For installations using black pipe, slide the
decorative wall thimble over the last vent pipe before
connecting the termination to the pipe. When this
connection has been made, slide the wall thimble up to
the interior wall surface and attach with screws provided.
6HFXUHWHUPLQDWLRQFDSWRH[WHULRUZDOOXVLQJSURYLGHGKROHV
DQGIDVWHQHUV
9HQW WHUPLQDWLRQ PXVW QRW EH UHFHVVHG LQ WKH ZDOO 6LGLQJ
PD\EHEURXJKWWRWKHHGJHRIWKHFDSEDVH
)LJXUH5RWDWH6HDPVIRU'LVDVVHPEO\
!
CAUTION
Risk of Burns! Local codes may require installation of a
WHUPLQDWLRQ JXDUG WR SUHYHQW DQ\WKLQJ RU DQ\RQH IURP
WRXFKLQJWKHKRWFDS
)ODVKDQGVHDODVDSSURSULDWHIRUVLGLQJPDWHULDODWRXWVLGH
HGJHVRIFDS
:KHQLQVWDOOLQJDKRUL]RQWDOWHUPLQDWLRQFDSIROORZWKHFDS
ORFDWLRQ JXLGHOLQHV DV SUHVFULEHG E\ FXUUHQW$16,=
DQG&$1&*$%LQVWDOODWLRQFRGHV
Figure 28 - Align and Disassemble Vent Sections
19
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Divert Roof Run-off
++7UHFRPPHQGVZKHUHH[FHVVLYHZDWHUUXQRIILVSRVVLEOH
XVHRIRQHRIWKHWZRRSWLRQVVKRZQLQ)LJXUHWRSUHYHQW
ZDWHU UXQQLQJ RII WKH URRI DQG RQWRLQWR WKH KRUL]RQWDO
WHUPLQDWLRQFDS
Vent Opening for Combustible Walls
(244 mm)
(244 mm)
6WRYH+HDUWK
)UDPLQJ'HWDLO
Opening for Noncombustible Wall
Install gutter
(190 mm)
6WRYH+HDUWK
)LJXUH/RFDWH9HQW2SHQLQJRQ:DOO
6HFXUH¿UHVWRSWRWKHLQVLGHIUDPHFHQWHULQWKH[
YHQWRSHQLQJ
3ODFHVWRYHLQWRSRVLWLRQ0HDVXUHWKHYHUWLFDOKHLJKW ; UHTXLUHGIURPWKHEDVHRIWKHÀXHFROODUVWRWKHFHQWHURI
WKHZDOORSHQLQJ)LJXUH
Install L-shaped
diverter
)LJXUH/RFDWH9HQW2SHQLQJRQ:DOO
X
Vertical Side Wall Installation:
127( 5HIHU WR )LJXUHV WKUX IRU UHVWULFWRU SODWH
adjustments for vertical vent runs.
/RFDWH YHQW RSHQLQJ RQ WKH ZDOO ,W PD\ EH QHFHVVDU\
WR ¿UVW SRVLWLRQ WKH VWRYH DQG PHDVXUH WR REWDLQ KROH
ORFDWLRQ'HSHQGLQJRQZKHWKHUWKHZDOOLVFRPEXVWLEOH
RU QRQFRPEXVWLEOH FXW RSHQLQJ WR VL]H )LJXUH
)RU FRPEXVWLEOH ZDOOV ¿UVW IUDPH LQ RSHQLQJ &RPEXVWLEOH:DOOV&XWD+[: [PP KROH
WKURXJKWKHH[WHULRUZDOODQGIUDPHDVVKRZQ)LJXUH
1RQFRPEXVWLEOH :DOOV +ROH RSHQLQJ PXVW EH PP LQGLDPHWHU
127(:KHQXVLQJÀH[YHQWWKHRSHQLQJZLOOKDYHWR
EHPHDVXUHGDFFRUGLQJWRWKH´ PP ULVHLQ´
PP YHQWUXQ
)LJXUH9HUWLFDO+HLJKW5HTXLUHPHQWV
8VLQJ DSSURSULDWH OHQJWK RI SLSH VHFWLRQ V DWWDFK WR
VWRYHE\WZLVWLQJFROODU
0HDVXUHWKHKRUL]RQWDOOHQJWKUHTXLUHPHQWLQFOXGLQJD´
PP RYHUODSLHIURPWKHHOERZWRWKHRXWVLGHZDOO
IDFHSOXV´ PP RUWKHGLVWDQFHUHTXLUHGLILQVWDOOLQJ
DVHFRQGƒHOERZ )LJXUH
NOTE: Always install vertical side wall horizontal venting
ZLWKD´ULVHIRUHYHU\´RIUXQ
20
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
8VHDSSURSULDWHOHQJWKRISLSHVHFWLRQV±WHOHVFRSLFRU
¿[HG ± DQG LQVWDOO 7KH VHFWLRQV ZKLFK JR WKURXJK WKH
ZDOODUHSDFNDJHGZLWKWKHVWDUWHUNLWDQGFDQEHFXWWR
VXLWLIQHFHVVDU\
*XLGH WKH YHQW WHUPLQDWLRQV DQG FROODUV LQWR
WKHLUUHVSHFWLYHYHQWSLSHV'RXEOHFKHFNWKDWWKHYHQW
SLSHV RYHUODS WKH FROODUV E\ PP 6HFXUH WKH
termination to the wall with screws provided and caulk
DURXQGWKHZDOOSODWHWRZHDWKHUSURRI$VDQDOWHUQDWLYH
WR VFUHZLQJ WKH WHUPLQDWLRQ GLUHFWO\ WR WKH ZDOO \RX
PD\DOVRXVHH[SDQGLQJSOXJVRUDQDSSURYHGH[WHULRU
FRQVWUXFWLRQDGKHVLYH
X
Vent Termination Below Grade
,QVWDOO6QRUNHO.LW6/36125.ZKHQLWLVQRWSRVVLEOHWR
PHHWWKHUHTXLUHGYHQWWHUPLQDWLRQFOHDUDQFHVRI PP DERYHJUDGHOHYHO7KHVQRUNHONLWZLOODOORZLQVWDOODWLRQ
GHSWKRIGRZQWR PP EHORZJUDGHOHYHO7KHVHYHQ
LQFKHV LV PHDVXUHG IURP WKH FHQWHU RI WKH KRUL]RQWDO YHQW
SLSH DV LW SHQHWUDWHV WKH ZDOO If the venting system is
installed below grade, a window well must be installed
with adequate and proper drainage. )LJXUH
NOTE: Be sure to maintain side wall clearances and vent
UXQUHVWULFWLRQV)LJXUHV
(VWDEOLVKWKHYHQWKROHWKURXJKWKHZDOO
5HPRYHVRLOWRDGHSWKRIDSSUR[LPDWHO\ PP EHORZWKHEDVHRIWKHVQRUNHO,QVWDOODZLQGRZZHOO QRW
VXSSOLHG 5H¿OO WKH KROH ZLWK PP RI FRDUVH
JUDYHODQGPDLQWDLQDFOHDUDQFHRIDWOHDVW PP EHORZWKHVQRUNHO )LJXUH
,QVWDOOWKHYHQWV\VWHPDVGHVFULEHGRQ3DJHV
%HVXUHWRPDNHDZDWHUWLJKWMRLQWDURXQGWKHYHQWSLSH
MRLQWDWWKHLQVLGHDQGRXWVLGHZDOOMRLQWV
$SSO\ KLJK WHPSHUDWXUH VHDODQW DURXQG WKH LQQHU DQG
RXWHU VQRUNHO FROODUV -RLQ WKH SLSHV DQG IDVWHQ WKH
VQRUNHOWHUPLQDWLRQWRWKHZDOOZLWKWKHVFUHZVSURYLGHG
/HYHO WKH VRLO WR PDLQWDLQ D FOHDUDQFH EHORZ WKH
VQRUNHO
)LJXUH+RUL]RQWDO/HQJWK5HTXLUHPHQW
NOTE: Support horizontal pipes every 5' (152 cm) with
metal pipe straps.
,I WKH IRXQGDWLRQ LV UHFHVVHG XVH H[WHQVLRQ EUDFNHWV
QRWVXSSOLHG WRIDVWHQWKHORZHUSRUWLRQRIWKHVQRUNHO
)DVWHQWKHEUDFNHWVWRWKHZDOO¿UVWDQGWKHQIDVWHQWRWKH
VQRUNHOZLWKVHOIWDSSLQJ[VKHHWPHWDOVFUHZV
([WHQGWKHYHQWSLSHVRXWDVIDUDVWKHSURWUXGLQJZDOO
IDFH )LJXUH
Recessed Wall
&XWRXW2Q9LQ\O
)LUHVWRS
Sheet Metal
Screws and
Bracket
)LQLVKLQJ
Collar
Wall Screws
DQG$QFKRUV
Waterproof Seal
$URXQG3LSH
3LSH
9LQ\O6LGLQJ:DOO
Wall Plate
)LJXUH8VHH[WHQVLRQEUDFNHWVWRPRXQWVQRUNHODJDLQVW
recessed wall.
Termination Cap
)LJXUH+RUL]RQWDO7HUPLQDWLRQ&DSRQD9LQ\O6LGLQJ:DOO
21
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Wall Screws
DQG$QFKRUV
Waterproof Seal
$URXQG3LSH
)LUHVWRS
Snorkel
Termination Cap
‡ 6/3+96 VXSSRUWV RIIVHWV7KLV DSSOLFDWLRQ ZLOO UHTXLUH
WKDW \RX ¿UVW GHWHUPLQH WKH URRI SLWFK DQG XVH WKH
DSSURSULDWH VWDUWHU NLW 5HIHU WR 9HQWLQJ &RPSRQHQWV
OLVW
‡ 7KHPD[LPXPDQJXODUYDULDWLRQDOORZHGLQWKHV\VWHPLV
ƒ)LJXUH
‡ )RU WKH PLQLPXP KHLJKW RI WKH YHQW DERYH WKH KLJKHVW
SRLQWRISHQHWUDWLRQWKURXJKWKHURRIUHIHUWR)LJXUH
&OHDUDQFH
*UDYHO
Drain
Window Well
RADIANCE
)LJXUH6QRUNHONLWLQVWDOODWLRQ
Vertical Through-The-Roof Application/installation
Note:5HIHUWR¿JXUHVWKUXIRUUHVWULFWRUSODWHDGMXVWPHQWV
IRUYHUWLFDOYHQWUXQV
7KLVJDVVWRYHKDVEHHQDSSURYHGIRU
‡ 9HUWLFDOLQVWDOODWLRQVXSWR P LQKHLJKW8SWRD
P KRUL]RQWDOYHQWUXQFDQEHLQVWDOOHGZLWKLQWKH
YHQWV\VWHPXVLQJDPD[LPXPRIWZRƒHOERZVFigure
38
‡ 8SWRWZRƒHOERZVPD\EHXVHGZLWKLQWKHKRUL]RQWDO
UXQ )RU HDFK ƒ HOERZ XVHG RQ WKH KRUL]RQWDO SODQH
WKHPD[LPXPKRUL]RQWDOOHQJWKPXVWEHUHGXFHGE\
PP Example:0D[LPXPKRUL]RQWDOOHQJWK
1RHOERZV
P
[ƒHOERZ
P
[ƒHOERZV P
‡ $ PLQLPXP RI DQ P YHUWLFDO ULVH LV UHTXLUHG
)LJXUH
•
22
Two sets of 45° elbow offsets may be used within the
YHUWLFDOVHFWLRQV)URPWRDPD[LPXPRI P RI
YHQWSLSHFDQEHXVHGEHWZHHQHOERZV)LJXUH
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Vertical
Termination
Horizontal
overhang
20 in.
(508 mm)
24 in. min.
(610 mm)
Vertical
wall
Lowest
Discharge
Opening
Storm Collar
Termination
Cap
)ODVKLQJ
X
Storm Collar
12
Roof
Flashing
Roof Pitch
is X / 12
H (min.) - Minimum height
from roof to lowest
discharge opening.
2IIVHW
Support Collar
Roof Pitch
)LUHVWRS
Spacer
H (Min.) Ft.
Roof Pitch
H (Min.) Ft.
)ODWWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
2YHUWR
)W0LQLPXPLQ6QRZ5HJLRQV
)LJXUH0LQLPXP+HLJKWIURP5RRIWR/RZHVW'LVFKDUJH
Opening
Venting System Assembly - Natural Vent
The heater is shipped from the factory as a Direct Vent
+HDWHU ,W PD\ EH FRQYHUWHG WR D 1DWXUDO 9HQW KHDWHU E\
LQVWDOOLQJWKH0RGHO)6'+$*6/3'UDIW+RRG$GDSWHU
&HLOLQJ
Support
Plate
&HLOLQJ6XSSRUW&ROODU
7KH KHDWHU LV DSSURYHG IRU LQVWDOODWLRQ DV D 1DWXUDO 9HQW
+HDUWKDQG+RPH7HFKQRORJLHV'LUHFW9HQWSLSHFRXOGEH
XVHGGLUHFWO\DIWHUWKH'UDIW+RRG$GDSWHUXSWRWKHFHLOLQJ
WKHQ%YHQWSLSHPXVWEHXVHG'RQRWPL[W\SHVRI%YHQW
SLSHXVHFRPSRQHQWVIURPRQHPDNHURUWKHRWKHU)ROORZ
WKH YHQW FRPSRQHQW PDNHU¶V LQVWUXFWLRQV H[DFWO\ 7KH
KHDWHUZLOODOVRDFFHSWVWDQGDUGRUHQDPHOHG´ PP GLDPHWHU SLSH DURXQG WKH 7\SH % YHQWLQJ IRU GHFRUDWLYH
SXUSRVHVRQO\ )LJXUH
NOTE: The restrictor plate supplied with the stove is
not used for Natural Vent applications.
Trim Plate
)LJXUH7\SLFDO9HUWLFDO9HQWLQJ&RQ¿JXUDWLRQ
23
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Decorative
´3LSH
´%YHQW
Pipe
++7'LUHFW9HQW
System may be used
IURP'UDIW+RRGXS
WRWKHFHLOLQJ
'UDIW+RRG
$GDSWHU
ENT
CEM
)LJXUH 'HFRUDWLYH ´ SLSH PD\ EH ¿WWHG DURXQG WKH %YHQW
SLSH
7KHVWRYHZKHQLQVWDOOHGDVD1DWXUDOYHQWKHDWHULQFOXGHV
D YHQW VDIHW\ VZLWFK 2SHUDWLQJ WKH VWRYH ZKHQ LW LV QRW
FRQQHFWHG WR D SURSHUO\ LQVWDOOHG DQG PDLQWDLQHG YHQWLQJ
V\VWHPRUWDPSHULQJZLWKRUGLVFRQQHFWLQJWKHYHQWVDIHW\
VZLWFKFDQUHVXOWLQFDUERQPRQR[LGH &2 SRLVRQLQJDQG
SRVVLEOHGHDWK
For U.S. installations:7KHYHQWLQJV\VWHPPXVWFRQIRUP
ZLWKORFDOFRGHVDQGRUWKHFXUUHQW1DWLRQDO)XHO*DV&RGH
$16,=
)LJXUH,QVWDOOGUDIWKRRGDGDSWHU
Install Log Set:
%HIRUH EHJLQQLQJ ORJ LQVWDOODWLRQ UHPRYH VWRYH IURQW DQG
JODVVIUDPH5HIHUWR)LJXUHVDQG
Note: Remove the safety barrier before you remove the
glass frame. To remove the barrier, simply lift up and pull
out until the tabs are clear of their corresponding slots
RQWKH¿UHER[7KHQSURFHHGWRUHPRYHWKHJODVVIUDPH
by following the steps below.
For Canadian installations: 7KH YHQWLQJ V\VWHP PXVW
FRQIRUPWRWKHFXUUHQW&6$%LQVWDOODWLRQFRGH
$SSO\DEHDGRIVHDODQWDURXQGERWWRPHQGRILQQHUVWDUWHU
SLSH IRXQGLQEDJZLWKORJVHW DQGDWWDFKWRVWRYH$SSO\D
bead of sealant around top of inner starter pipe and install
WKH )6'+$*6/3 'UDIW +RRG DFFRUGLQJ WR 'UDIW +RRG
LQVWUXFWLRQV )LJXUH
$WWDFK WKH ¿UVW VHFWLRQ RI YHQWLQJ WR WKH GUDIW KRRG
'HSHQGLQJRQWKHOHQJWKRIWKHLQGLYLGXDOYHQWLQJVHFWLRQV
DQGWKHOHQJWKVRIWKHGHFRUDWLYHSLSH LILQVWDOOHG \RXPD\
QHHG WR VOLS WKH GHFRUDWLYH SLSH RYHU WKH YHQWLQJ VHFWLRQV
EHIRUHDWWDFKLQJXSSHUVHFWLRQVWRORZHURQHV7KHVHFWLRQV
of decorative pipe should be oriented with their seams (if
any) toward the wall; sections usually do not need to be
IDVWHQHGDWHDFKMRLQWRWKHUWKDQVOLSVHFWLRQV,IWKHOD\RXW
includes a slip section, this should be the last section of
SLSHYLVLEOHLQWKHURRPDWWKHFHLOLQJ&RPSOHWHWKHYHQWLQJ
DFFRUGLQJWRWKHYHQWPDNHU¶VLQVWUXFWLRQV
)LJXUH5HPRYHWKHVDIHW\EDUULHUDQGVWRYHIURQW
)LJXUH5HOHDVHWKHODWFKHVWRUHPRYHWKHJODVVIUDPH
24
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
DANGER
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this
appliance and shall be installed.
,QVWDOOWKHOHIWORJE\PDWLQJWKHKROHRQWKHERWWRPRIWKH
ORJ ZLWK WKH SLQ LQ WKH HPEHU EHG )LJXUH 3RVLWLRQ
WKHORJRYHUDLUKROHLQHPEHUEHG
,QVWDOOWKHULJKWORJE\PDWLQJWKHQRWFKRQWKHERWWRPRI
WKHORJZLWKWKHUDLVHGQRWFKRQWKHHPEHUEHG )LJXUH
3RVLWLRQWKHORJRYHUDLUKROHLQHPEHUEHG
,QVWDOO WRS ORJ E\ PDWLQJ KROH RQ ERWWRP RI ORJ ZLWK
ORFDWLQJ SLQ RQ WRS ULJKW VLGH RI UHDU ORJ )LJXUH 3RVLWLRQORJVRLWLVDQJOHGGRZQWRZDUGWKHDUHDZKHUH
WKHIURQWWZRORJVPHHW
/HIW/RJ
5LJKW/RJ
Install Log Set
%HIRUH EHJLQQLQJ ORJ LQVWDOODWLRQ UHPRYH VWRYH IURQW DQG
JODVVIUDPH5HIHUWR)LJXUHVDQG
%HIRUHLQVWDOODWLRQLQVSHFWHPEHUEHGEXUQHUIRUGDPDJH
'RQRWXVHHPEHUEHGLIGDPDJHGRUFUDFNHG6PDOOVKDOORZ
VXUIDFHFUDFNVDUHDFFHSWDEOH
5HPRYHWKHORJVIURPWKHLUSDFNDJLQJDQGLQVSHFWHDFK
SLHFHIRUGDPDJH'2127,167$//'$0$*('/2*6
,QVWDOOWKHUHDUORJE\PDWLQJWKHQRWFKRQWKHERWWRPRI
WKHORJZLWKWKHUDLVHGQRWFKRQWKHEDFNOHIWVLGHRIWKH
HPEHU EHG )LJXUH (QVXUH WKH FXWRXW LQ WKH ULJKW
VLGH RI WKH ORJ LV VLWWLQJ DURXQG WKH SLORW DVVHPEO\ DQG
SLORWLVQRWREVWUXFWHG )LJXUH
5DLVHG1RWFK
)LJXUH)URQW/RJV
5HDU/RJ
7RS/RJ
/HIW/RJ
5LJKW/RJ
3LORW$VVHPEO\
Raised
1RWFK
Pin
(PEHU%HG
)LJXUH - Completed Installation
)LJXUH5HDU/RJ
5HDU/RJ
Pilot
$VVHPEO\
)LJXUH5LEVIRU/RJV
25
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Install ON/OFF Switch – SDDVT models
7KHVZLWFKDVVHPEO\SDUWVDUHIRXQGLQWKHSDUWVEDJ
$WWDFKVZLWFKDVVHPEO\WROHIWUHDUVLGHRIVWRYHVKURXG
ZKHQ IDFLQJ VKURXG XVLQJ WZR VFUHZV DQG H[LVWLQJ
KROHVLQVKURXG )LJXUH
Run wires down back of stove, under bottom of rear
VKURXGWRYDOYH
$WWDFKZLUHVWRYDOYHWHUPLQDOV )LJXUH
Signature Command® System - General:
6'976&PRGHOVDUHHTXLSSHGZLWKWKH6LJQDWXUH&RPPDQG
FRQWUROYDOYH )LJXUH ZKLFKRSHUDWHVRQYROWV7KH$&
PRGXOHSOXJVLQWRWKHVWRYHMXQFWLRQER[$&SRZHUVXSSO\
)RXU ³$$´EDWWHULHVDUHXVHGIRUEDFNXSGXULQJSRZHU
RXWDJHV
7KH 6LJQDWXUH &RPPDQG 6\VWHP FDQ DOVR EH RSHUDWHG
ZLWKRXW$& SRZHU 7KH V\VWHP FDQ UXQ RQ IRXU ³$$´
EDWWHULHVIRUDSSUR[LPDWHO\VL[ PRQWKVXQGHUQRUPDOXVH
$& SRZHU PXVW EH XVHG WR SRZHU WKH$& PRGXOH DQG
EORZHUV
Switch
$VVHPEO\
([LVWLQJ
+ROHV
Pressure Inlet
Screws
)LJXUH$WWDFKVZLWFKDVVHPEO\WRUHDUVKURXG
SIT VALVE
3LORW$GMXVWPHQW
Screw
3UHVVXUH2XWOHW
Valve
TPTH
)LJXUH6LJQDWXUH&RPPDQG9DOYH
Thermopile
TP
!
TH
PI
LO T
ON/OFF Switch or
Millivolt Thermostat
)LJXUH,QVWDOOZLULQJWRVZLWFKEHIRUHFRQQHFWLQJWRYDOYH
Thermostat or wall switch Connection (optional):
8VHRQO\DWKHUPRVWDWUDWHGIRUPLOOLYROWV
&KHFNWKHWDEOHEHORZIRUWKHDSSURSULDWHJDXJHWKHUPRVWDW
ZLUHWRXVHIRUWKHOHQJWKRIOHDGUHTXLUHGLQ\RXULQVWDOODWLRQ
Thermostat
Wire / Gauge
Maximum Run
18
)HHW
16
)HHW
14
XSWR)HHW
WARNING
(OHFWULFDO FRQQHFWLRQV VKRXOG RQO\ EH SHUIRUPHG E\ D
TXDOL¿HG OLFHQVHG HOHFWULFLDQ 0DLQ SRZHU PXVW EH RII
ZKHQ FRQQHFWLQJ WR PDLQ HOHFWULFDO SRZHU VXSSO\ RU
SHUIRUPLQJ VHUYLFH $OO ZLULQJ VKDOO EH LQ FRPSOLDQFH
ZLWKDOOORFDOFLW\DQGVWDWHFRGHV7KHDSSOLDQFHZKHQ
LQVWDOOHG PXVW EH HOHFWULFDOO\ JURXQGHG LQ DFFRUGDQFH
with local codes or in the absence of local codes, with the
1DWLRQDO(OHFWULFDO&RGH$16,1)3$ ODWHVWHGLWLRQ DQG
&DQDGLDQ(OHFWULFDO&RGH&6$&
!
CAUTION
/DEHO DOO ZLUHV EHIRUH GLVFRQQHFWLQJ ZKHQ VHUYLFLQJ
FRQWUROV:LULQJHUURUVFDQFDXVHLPSURSHUDQGGDQJHURXV
RSHUDWLRQ
,QVWDOOWKHZDOOWKHUPRVWDWRUVZLWFKLQWKHGHVLUHGORFDWLRQ
DQGUXQWKHZLUHVWRWKHVWRYHORFDWLRQ7HUPLQDWHWKHVH
OHDGVZLWKIHPDOHFRQQHFWRUV
&RQQHFWWKHWKHUPRVWDWZLUHVWRWKHYDOYH )LJXUH
26
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Junction Box Wiring
7KLV VKRXOG EH GRQH EHIRUH IUDPLQJ WKH VWRYH :LUH WKH
UHFHSWDFOHLQWRDQHOHFWULFDOFLUFXLW:LUHZLWKPLQLPXPƒ
&ZLUHLQDFFRUGDQFHZLWKSUHYDLOLQJFRGHV
!
(OHFWULFDO FRQQHFWLRQV VKRXOG RQO\ EH SHUIRUPHG E\ D
TXDOL¿HG OLFHQVHG HOHFWULFLDQ 0DLQ SRZHU VXSSO\ PXVW
EHWXUQHGRIIEHIRUHFRQQHFWLQJIDQVWRWKHPDLQHOHFWULFDO
SRZHUVXSSO\RUSHUIRUPLQJVHUYLFH
5HPRYH WKH H[WHUQDO MXQFWLRQ ER[ FRYHU E\ UHPRYLQJ WKH
VFUHZIURPWKHVLGHRIWKHRXWVLGH¿UHER[ZDOO-XQFWLRQER[
ZDVLQVWDOOHGDWWKHIDFWRU\
7KHMXQFWLRQER[FRYHUKDVDIDFWRU\LQVWDOOHG³URPH[´VW\OH
VWUDLQUHOLHIFRQQHFWRU$IWHUFRQQHFWLQJWKHZLUHVURXWHWKH
ZLUHOHDGVWKURXJKWKLVFRQQHFWRU5HIHUWRWKHZLULQJGLDJUDP
LQ)LJXUH
9$&
+]
)DFWRU\6XSSOLHG
1RW6XSSOLHG
!
Command Center Wall Installation
The command center may be mounted on the wall with the
XVHRIWKH6&6:(..LW IWFDEOHMXQFWLRQER[ZDOOFRYHU WARNING
(OHFWULFDO *URXQGLQJ ,QVWUXFWLRQV 7KLV DSSOLDQFH LV
HTXLSSHG ZLWK D WKUHHSURQJ JURXQGLQJ SOXJ IRU \RXU
SURWHFWLRQDJDLQVWVKRFNKD]DUGDQGVKRXOGEHSOXJJHG
GLUHFWO\LQWRDSURSHUO\JURXQGHGWKUHHSURQJUHFHSWDFOH
Install the Fan – SDVTSC Models
,WLVHDVLHVWWRLQVWDOOWKHIDQNLWEHIRUHFRQQHFWLQJDJDVOLQH
•
8QSDFNDQGLQVSHFWWKHEORZHUDVVHPEO\&RQ¿UPWKDW
WKHIDQVSLQVIUHHO\
•
8QIDVWHQ WKH WZR PDFKLQH EROWV DWWDFKHG WR WKH ORZHU
EDFNRIWKHVWRYH )LJXUH •
8VLQJWKHWZREROWVVHFXUHWKHEORZHUDVVHPEO\WRWKH
UHDURIWKHVWRYH )LJXUH •
&RQQHFWWKHEORZHUZLUHVWRWKHZLUHFRQWUROERDUG6HH
)LJXUHRQSDJH
-XQFWLRQ%R[
)LJXUH-XQFWLRQ%R[:LULQJ'LDJUDP
CAUTION
0RXQW WKH MXQFWLRQ ER[ SURYLGHG DW WKH GHVLUHG
ORFDWLRQ RQ WKH ZDOO 'R QRW H[WHQG EH\RQG WKH IW
ZLUH FDEOH SURYLGHG ,I D ORQJHU GLVWDQFH LV UHTXLUHG
WKH IW PD\ EH H[WHQGHG XS WR IW PD[LPXP E\
XVLQJ WZR 6&6:(. FDEOHV SOXJJHG WRJHWKHU
5RXWH WKH ZLUH IURP MXQFWLRQ ER[ WR ORZHU FRQWURO DUHD DW
ERWWRPRIVWRYH8QSOXJWKHFDEOHIURPWKHFRPPDQG
FHQWHU$WWDFKWKHFRQQHFWRUWRWKHSLQVIURPZLUHE\SXVKLQJ
LQ WR FRQQHFWRU PDNLQJ VXUH WR IROORZ WKH FRORU FRGH RQ
FRQQHFWRU3OXJWKHIWH[WHQVLRQFDEOHLQWRWKHIWFDEOH
5HPRYHFRPPDQGFHQWHUIURPWKHVWRYHDQGSOXJWKHRWKHU
HQGRIWKHH[WHQVLRQFDEOHLQWRWKHFRPPDQGFHQWHU6QDS
RQZDOOFRYHUSURYLGHGDQGVFUHZWRMXQFWLRQER[
%ORZHU$VVHPEO\
)LJXUH5$'976&%ORZHUDVVHPEO\
Wall Switch Installation
7KHZDOOVZLWFKZLUHFRQQHFWLRQLVORFDWHGRIIWKHIWZLUH
KDUQHVVIURPWKHFRQWUROER[WRWKHFRPPDQGFHQWHU)LJXUH
7KHFRQQHFWLRQLVODEHOHG³:DOO6ZLWFK´8QSOXJWKHPDOH
DQGIHPDOHFRQQHFWRUVDQGFRQQHFWWKHWZR ORZYROWDJH
ZLUHVSURYLGHG5XQZLUHWRGHVLUHGORFDWLRQRQZDOO8SWR
IWRIJDZLUHPD\EHXVHGLIQHFHVVDU\$WWDFKZLUHV
WRZDOOVZLWFK0RXQWWKHZDOOVZLWFKLQWRMXQFWLRQER[DQG
VFUHZRQFRYHU
!
WARNING
'RQRWFRQQHFWZDOOVZLWFKWR9FLUFXLW
Figure 51 - 6HFXUH%ORZHUDVVHPEO\WRORZHUEDFNRIWKHVWRYH
27
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Connect the Gas Supply Line
&KHFN WKH 5DWLQJ 3ODWH DWWDFKHG E\ D VWHHO FDEOH WR WKH
¿UHER[ WR FRQ¿UP WKDW \RX KDYH WKH DSSURSULDWH ¿UHER[
IRU WKH W\SH RI IXHO WR EH XVHG 7KH 6WDUGDQFH PD\ EH
FRQYHUWHGIURPRQHJDVWRDQRWKHUXVLQJWKHDSSURSULDWH)XHO
&RQYHUVLRQ.LWOLVWHGLQWKLVPDQXDOXQGHU5HSODFHPHQW3DUWV
In the U.S.;*DVFRQQHFWLRQVKRXOGEHPDGHLQDFFRUGDQFH
ZLWKFXUUHQW1DWLRQDO)XHO*DV&RGH$16,=1)3$
Since some municipalities have additional local codes, be
VXUHWRFRQVXOW\RXUORFDODXWKRULW\
In Canada; FRQVXOW WKH ORFDO DXWKRULW\ DQG &6$%
LQVWDOODWLRQFRGH
NOTE: Always check for gas leaks with a mild soap and
ZDWHUVROXWLRQ'RQRWXVHDQRSHQÀDPHIRUOHDNWHVWLQJ
/LJKWWKHSLORWDFFRUGLQJWRWKHGLUHFWLRQVLQWKH2SHUDWLRQ
VHFWLRQRIWKLVPDQXDO
Burner Information
7KHDSSOLDQFHPXVWRQO\XVHWKHJDVVSHFL¿HGRQWKHUDWLQJ
SODWH XQOHVV FRQYHUWHG XVLQJ D 9HUPRQW &DVWLQJV )XHO
&RQYHUVLRQ.LW7RFRQYHUWIURP1DWXUDO*DVWR/3XVH.LW
RU7RFRQYHUWIURP/3WR1DWXUDO*DV
XVH.LWRU
Conversion instructions are provided with each kit and in
WKLVPDQXDO
!
CAUTION
7KLVDSSOLDQFHVKRXOGRQO\EHFRQQHFWHGE\DTXDOL¿HG
JDV WHFKQLFLDQ 7HVW WR FRQ¿UP PDQLIROG SUHVVXUHV DV
VSHFL¿HGEHORZ
7KH6WDUGDQFH+HDWHUDQGLWVLQGLYLGXDOVKXWRIIYDOYHPXVW
EHGLVFRQQHFWHGIURPWKHJDVVXSSO\SLSLQJGXULQJDQ\
SUHVVXUHWHVWLQJRIWKDWV\VWHPDWWHVWSUHVVXUHVLQH[FHVV
RISVLJ N3D 7KH 6WDUGDQFH +HDWHU PXVW EH LVRODWHG IURP WKH JDV
VXSSO\ SLSLQJ V\VWHP E\ FORVLQJ LWV LQGLYLGXDO PDQXDO
VKXWRIIYDOYHGXULQJDQ\SUHVVXUHWHVWLQJRIWKHJDVVXSSO\
SLSLQJV\VWHPDWWHVWSUHVVXUHHTXDOWRRUOHVVWKDQ
SVLJ
7KHUHPXVWEHDJDVVKXWRIIEHWZHHQWKHVWRYHDQGWKH
VXSSO\
,QRUGHUWRFRQQHFW1DWXUDO*DVXVHD¿WWLQJZLWK137
RQ WKH YDOYH VLGH DQG QDWXUDO JDV VXSSO\ OLQH ZLWK
DQLQSXWRI%78VDWDPDQLIROGSUHVVXUHRI
EHWZHHQPLQLPXPLQOHWVXSSO\RIZFDQGPD[LPXP
RIZF
,QRUGHUWRFRQQHFW3URSDQHXVHD¿WWLQJZLWK137
RQWKHYDOYHVLGHDQGSURSDQHJDVVXSSO\OLQHZLWK
DQLQSXWRI%78VDWDPDQLIROGSUHVVXUHRI
EHWZHHQDPLQLPXPLQOHWVXSSO\RIZFDQGPD[LPXPRIZF
THIS APPLIANCE SHOULD BE CONNECTED TO THE GAS SUPPLY ONLY BY A QUALIFIED GAS SERVICE
TECHNICIAN. FOLLOW ALL LOCAL CODES.
THERE MUST BE A GAS SHUT-OFF BETWEEN THE STOVE AND THE SUPPLY.
28
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Signature Command Wiring Diagram
Pilot
A/C MODULE
Opt. Blower
Opt. Aux.
WHITE
BLACK
BLACK
WHITE
PLUG-IN
CONNECTOR
TO JUNCTION BOX
IN FIREPLACE
RF Receiver
ON/OFF Button
GREEN
300 Watt
Max.
Control Board
Black / Thermopile
Red / Thermopile
Sensor
Conversion
NG/LP
Ignitor / Sparker
Plug-in Connector
Control Board to Command Center
NOTE: Wall switch wires
must be connected together
if a wall switch is not being used.
OFF/LO
Ground
Plug-in Connector
Stepper Motor to
Control Board
LED
ON/HI
Master Switch
Command Center
Optional
Wall Switch
DC Power/Green
Plug-in Connector
Control Board to
Solenoid
Gas Out
Gas In
Pilot Gas Tubing
Valve
Figure 526LJQDWXUH&RPPDQG:LULQJ'LDJUDP
To Junction Box
In Fireplace
Light
{
WHITE
BLACK
Optional
AUX
{
WHITE
BLACK
BLACK
WHITE
GREEN
Connector
Pin To Control Box
)LJXUH%ORZHU:LULQJ'LDJUDP
29
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Install the Safety Barrier
CERTIFIED
SAFETY BARRIER
NOTE: A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance and
shall be installed for the protection of children and other
at risk individuals. If the barrier becomes damaged, the
barrier shall be replaced with the manufacturer's barrier
for this appliance.* Any safety screen, guard, or barrier
removed for servicing the appliance must be replaced
prior to operating the appliance.
%RWWRP+RRNV
)LJXUH,QVWDOOVDIHW\EDUULHUVFUHHQ
* See parts list for model number.
7KHVDIHW\EDUULHUKDVEHHQGHVLJQHGWRZRUNZLWKWKH
GRRUVRSHQRUFORVHG
5HPRYHVFUHHQIURPSDFNDJLQJ
3ODFHWKHWZRERWWRPKRRNVRYHUWKHERWWRPHGJHRIWKH
VWRYHRSHQLQJ)LJXUH
3UHVV WKH VFUHHQ DJDLQVW WKH VWRYH VQDSSLQJ WKH WZR
VSULQJ¿QJHUVXQWLOWKHVFUHHQ¿WVVHFXUHO\LQSODFH
NOTE: It is the responsibility of the installer to ensure the
EDUULHULVDI¿[HGWRWKHVWRYHDWWKHWLPHRILQVWDOODWLRQ
!
WARNING
7KHVDIHW\VFUHHQEDUULHUPXVWEHLQVWDOOHGDIWHUWKHJODVV
IURQWLVLQSODFH,WLVQRWDUHSODFHPHQWIRUWKHJODVVDQG
WKHXQLWPXVWQRWEHRSHUDWHGZLWKRXWWKHJODVVLQSODFH
Install the Mesh and Grille
3ODFHWKHPHVKDQGJULOOHRQWKHWRSRIWKH5DGLDQFHVWRYH
WRFRPSOHWHDVVHPEO\
DANGER
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this
appliance and shall be installed.
30
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Operating instructions
Operation
The Stardance is operated with the front plate in place with
WKHGRRUVRSHQRUFORVHGDQGWKHVDIHW\EDUULHULQSODFH7R
RSHQWKHIURQWGRRUVSXOOIRUZDUGWRVHSDUDWHWKHPDJQHWLF
FDWFK
Flame Characteristics
It is important to periodically perform a visual check of the
SLORWDQGWKHEXUQHUÀDPHV&RPSDUHWKHPWR)LJXUH,I
DQ\RIWKHÀDPHVDSSHDUDEQRUPDOFDOODVHUYLFHSHUVRQ
Your First Fire
5HDGWKHVHLQVWUXFWLRQVFDUHIXOO\DQGIDPLOLDUL]H\RXUVHOIZLWK
WKHEXUQHUFRQWUROVVKRZQRQ3DJH 6''97PRGHOV RU
SDJH 6'976&PRGHOV /RFDWHWKHSLORWDVVHPEO\)LJXUH
)ROORZWKHOLJKWLQJLQVWUXFWLRQVLQWKLVPDQXDOH[DFWO\
'XULQJ WKH ¿UVW ¿UH LW LV QRW XQXVXDO WR VPHOO VRPH RGRU
DVVRFLDWHG ZLWK QHZ ORJV SDLQW DQG PHWDO EHLQJ KHDWHG
2GRUV VKRXOG GLVVLSDWH ZLWKLQ WKH ¿UVW HLJKW WR WHQ KRXUV
however, you can open a window to provide fresh air to
DOOHYLDWHWKHFRQGLWLRQ
Pilot and Burner Inspection
(DFKWLPH\RXOLJKW\RXUKHDWHUFKHFNWKDWWKHSLORWÀDPHDQG
EXUQHUÀDPHSDWWHUQVDUHDVVKRZQLQ)LJXUH,IÀDPH
SDWWHUQVDUHLQFRUUHFWWXUQWKHKHDWHURII&RQWDFW\RXUGHDOHU
RUDTXDOL¿HGJDVWHFKQLFLDQIRUDVVLVWDQFH'RQRWRSHUDWH
WKHKHDWHUXQWLOWKHSLORWÀDPHLVFRUUHFW
SDDVT MODELS
)ROORZUHJXODUPDLQWHQDQFHSURFHGXUHVDVGHVFULEHGLQWKH
&OHDQLQJDQG0DLQWHQDQFHVHFWLRQRIWKLVPDQXDO
Sensor
SDVTSC MODELS
Thermopile
3LORW$VVHPEO\
Figure 553LORW$VVHPEO\ORFDWLRQ
Figure 56&RUUHFWSLORWDQGEXUQHUÀDPHDSSHDUDQFH
Turn
counterclockwise
to increase
flame height
HI
Flame & Temperature Adjustment
)RU6''97PRGHOVZKLFKDUHHTXLSSHGZLWK+,/2YDOYHV
ÀDPH DGMXVWPHQW LV DFFRPSOLVKHG E\ URWDWLQJ WKH +,/2
DGMXVWPHQWNQREORFDWHGQHDUWKHFHQWHURIWKHJDVFRQWURO
YDOYH )LJXUH
LO
Turn clockwise
to decrease
flame height
)LJXUH)ODPHDGMXVWPHQWNQREIRU6,7YDOYH
31
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
LIGHTING AND OPERATING INSTRUCTIONS FOR RADVT MODELS (MILLIVOLT ONLY)
FOR YOUR SAFETY READ BEFORE LIGHTING
:$51,1*,I\RXGRQRWIROORZWKHVHLQVWUXFWLRQVH[DFWO\D¿UHRUH[SORVLRQ
may result causing property damage, personal injury or loss of life.
$ 7KLVKHDWHUKDVDSLORWZKLFKPXVWEHOLWPDQXDOO\:KHQ
OLJKWLQJWKHSLORWIROORZWKHVHLQVWUXFWLRQVH[DFWO\
% %()25(/,*+7,1*VPHOODOODURXQGWKHKHDWHUDUHD
IRUJDV%HVXUHWRVPHOOQH[WWRWKHÀRRUEHFDXVHVRPH
JDVLVKHDYLHUWKDQDLUDQGZLOOVHWWOHRQWKHÀRRU
WHAT TO DO IF YOU SMELL GAS
‡ 'RQRWWU\WROLJKWDQ\VWRYH
• Do not touch any electric switch
‡ 'RQRWXVHDQ\SKRQHLQ\RXUEXLOGLQJ
‡ ,PPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURPDQHLJKERU¶V
SKRQH)ROORZWKHJDVVXSSOLHU¶VLQVWUXFWLRQV
‡ ,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH)LUH
Department
&8VHRQO\\RXUKDQGWRSXVKLQRUWXUQWKHJDVFRQWURO
NQRE1HYHUXVHWRROV,IWKHNQREZLOOQRWSXVKLQRUWXUQ
E\KDQGGRQRWWU\WRUHSDLULWFDOODTXDOL¿HGVHUYLFH
WHFKQLFLDQ$SSO\LQJIRUFHRUDQ\DWWHPSWHGUHSDLUPD\
UHVXOWLQD¿UHRUH[SORVLRQ
''RQRWXVHWKLVVWRYHLIDQ\SDUWKDVEHHQXQGHUZDWHU
,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQWRLQVSHFW
the heater and to replace any part of the control system
DQGDQ\JDVFRQWUROZKLFKKDVEHHQXQGHUZDWHU
Lighting Instructions
STOP!5HDGWKHVDIHW\LQIRUPDWLRQDERYH
7XUQRIIDOOHOHFWULFDOSRZHUWRWKHVWRYH
7XUQWKH2Q2IIVZLWFKWR³2))SRVLWLRQVHWWKHUHPRWH
WR2))RUVHWWKHUPRVWDWWRORZHVWOHYHO
2SHQFRQWURODFFHVVSDQHO
3XVKWKHFRQWURONQREDOOWKHZD\LQDQGKROG,PPHGLDWHO\
OLJKWWKHSLORWE\UHSHDWHGO\GHSUHVVLQJWKHSLH]RVSDUN
LJQLWRU XQWLO D ÀDPH DSSHDUV &RQWLQXH WR KROG WKH
control knob in for about one (1) minute after the pilot
LVOLW5HOHDVHNQREDQGLWZLOOSRSEDFNXS3LORWVKRXOG
UHPDLQOLW,ILWJRHVRXWUHSHDWVWHSVWKURXJK
3XVK LQ JDV FRQWURO NQRE VOLJKWO\ DQG WXUQ FORFNZLVH
WR³2))
ON
OFF
PILOT
OFF
•
SIT NOVA
:DLW¿YH PLQXWHVWRFOHDURXWDQ\JDV7KHQVPHOO
IRUJDVLQFOXGLQJQHDUWKHÀRRU,I\RXVPHOOJDV6723
)ROORZ³%LQWKHVDIHW\LQIRUPDWLRQDERYH,I\RXGRQRW
VPHOOJDVJRWRWKHQH[WVWHS
If knob does not pop up when released, stop and
LPPHGLDWHO\FDOO\RXUVHUYLFHWHFKQLFLDQRUJDVVXSSOLHU
‡ ,IDIWHUVHYHUDOWULHVWKHSLORWZLOOQRWVWD\OLWWXUQWKHJDV
FRQWURONQREWR³2))DQGFDOO\RXUVHUYLFHWHFKQLFLDQ
RUJDVVXSSOLHU
5HPRYH JODVV GRRU EHIRUH OLJKWLQJ SLORW 6HH *ODVV
)UDPH5HPRYDOVHFWLRQ 5HSODFHJODVVGRRU
9LVLEO\ORFDWHSLORWE\WKHPDLQEXUQHU
7XUQ WKH 2Q2II VZLWFK WR ³21 SRVLWLRQ RU VHW
WKHUPRVWDWWRGHVLUHGVHWWLQJ
7XUQ NQRE RQ JDV FRQWURO FRXQWHUFORFNZLVH
³3,/27
to
7XUQJDVFRQWURONQREWR³21SRVLWLRQ
7XUQRQDOOHOHFWULFDOSRZHUWRWKHVWRYH
To Turn Off Gas To Heater
7XUQWKH2Q2IIVZLWFKWR2IISRVLWLRQRUVHWWKHWKHUPRVWDW
WRORZHVWVHWWLQJ
7XUQRIIDOOHOHFWULFSRZHUWRWKHVWRYHLIVHUYLFHLVWREH
SHUIRUPHG
32
2SHQFRQWURODFFHVVSDQHO
3XVK LQ JDV FRQWURO NQRE VOLJKWO\ DQG WXUQ FORFNZLVH
WR³2))'RQRWIRUFH
&ORVHFRQWURODFFHVVSDQHO
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
TROUBLESHOOTING THE GAS CONTROL SYSTEM (SDDVT SERIES)
6,7129$0,//,92/79$/9(
127(%HIRUHWURXEOHVKRRWLQJWKHJDVFRQWUROV\VWHPEHVXUHH[WHUQDOJDVVKXWRIILVLQWKH³2QSRVLWLRQ
Symptom
Possible Causes
6SDUN,JQLWRUZLOOQRW 'HIHFWLYHRUPLVDOLJQHG
OLJKW
electrode at pilot
Pilot will not stay
lit after carefully
IROORZLQJOLJKWLQJ
instructions
3LORWEXUQLQJQR
JDVWRPDLQEXUQHU
)UHTXHQWSLORW
RXWDJHSUREOHP
8VLQJDPDWFKOLJKWSLORW,ISLORWOLJKWVWXUQRIISLORWDQGSXVKWKHUHGEXWWRQ
DJDLQ,ISLORWZLOOQRWOLJKFKHFNJDSDWHOHFWURGHDQGSLORWVKRXOGEH´WR
KDYHDVWURQJVSDUN
'HIHFWLYHLJQLWRU SXVK
button)
:LWKWKHFRQWURONQRELQWKHSLORWSRVLWLRQSXVKWKHFRQWURONQREDOOWKHZD\DQG
KROG&KHFNIRUVSDUNDWHOHFWURGHDQGSLORW,IQRVSDUNWRSLORWDQGHOHFWURGH
ZLUHLVSURSHUO\FRQQHFWHGUHSODFHWKHEDWWHU\LQWKHLJQLWRUPRGXOHDQGWU\
DJDLQ5HIHUWR0DLQWHQDQFH6HFWLRQ,IWKHSUREOHPVWLOOH[LVWVUHSODFHWKH
LJQLWRUPRGXOHER[
'HIHFWLYHSLORWJHQHUDWRU
(thermocouple), remote
wall switch
&KHFN SLORW ÀDPH 0XVW LPSLQJH RQ WKHUPRFRXSOHWKHUPRSLOH 127( 7KLV
SLORW EXUQHU DVVHPEO\ XWLOL]HV ERWK D WKHUPRFRXSOH DQG D WKHUPRSLOH 7KH
WKHUPRFRXSOHRSHUDWHVWKHPDLQYDOYHRSHUDWLRQ 2QDQG2II &OHDQDQGRU
DGMXVWSLORWIRUPD[LPXPÀDPHLPSLQJHPHQWRQWKHUPRSLOHDQGWKHUPRFRXSOH
'HIHFWLYHDXWRPDWLFYDOYH
7XUQYDOYHNQREWR³3LORW´0DLQWDLQÀRZWRSLORWPLOOLYROWPHWHUVKRXOGUHDG
JUHDWHUWKDQP9,IWKHUHDGLQJLVRND\DQGWKHSLORWGRHVQRWVWD\RQUHSODFH
WKH JDV YDOYH 127($Q LQWHUUXSWHU EORFN QRW VXSSOLHG PXVW EH XVHG WR
FRQGXFWWKLVWHVW
:DOOVZLWFKRUZLUHV
defective
&KHFN ZDOO VZLWFK DQG ZLUHV IRU SURSHU FRQQHFWLRQV -XPSHU ZLUH DFURVV
WHUPLQDOVDWZDOOVZLWFKLIEXUQHUFRPHVRQUHSODFHGHIHFWLYHZDOOVZLWFK,I
RND\MXPSHUZLUHVDFURVVZDOOVZLWFKZLUHVDWYDOYHLIEXUQHUFRPHVRQZLUHV
DUHIDXOW\RUFRQQHFWLRQVDUHEDG
7KHUPRSLOHPD\QRWEH
JHQHUDWLQJVXI¿FLHQW
PLOOLYROWDJH
•
%HVXUHZLUHFRQQHFWLRQVIRUPWKHUPRSLOHDWJDVYDOYHWHUPLQDOVDUHWLJKW
DQGWKHUPRSLOHLVIXOO\LQVHUWHGLQWRSLORWEUDFNHW
•
2QHRIWKHZDOOVZLWFKZLUHVPD\EHJURXQGHG5HPRYHZDOOVZLWFKZLUHV
IRUPYDOYHWHUPLQDOVLISLORWQRZVWD\VOLWWUDFHZDOOVZLWFKZLULQJIRUJURXQG
0D\EHJURXQGHGWRVWRYHRUJDVVXSSO\
•
&KHFNWKHUPRSLOHZLWKPLOOLYROWPHWHU7DNHUHDGLQJDWWKHUPRSLOHWHUPLQDOV
RIJDVYDOYH6KRXOGUHDGPLOOLYROWV PLQLPXP ZKLOHKROGLQJ
YDOYHNQREGHSUHVVHGLQSLORWSRVLWLRQDQGZDOOVZLWFK³2II´5HSODFHIDXOW\
WKHUPRSLOHLIUHDGLQJLVEHORZVSHFL¿HGPLQLPXP
3OXJJHGEXUQHURUL¿FH
&KHFNEXUQHURUL¿FHVIRUGHEULVDQGUHPRYH
'HIHFWLYHDXWRPDWLFYDOYH
operator
7XUQYDOYHNQREWR³2Q´SODFHZDOOVZLWFKWR³2Q´PLOOLYROWPHWHUVKRXOGUHDG
JUHDWHUWKDQP9,IWKHUHDGLQJLVRND\DQGWKHEXUQHUGRHVQRWFRPHRQ
UHSODFHWKHJDVYDOYH
3LORWÀDPHPD\EHWRRORZ &OHDQDQGRUDGMXVWSLORWÀDPHIRUPD[LPXPÀDPHLPSLQJHPHQWRQWKHUPRSLOH
RUEORZLQJ KLJK FDXVLQJ
DQGWKHUPRFRXSOH
the pilot safety
to drop out
3RVVLEOHEORFNDJHRIWKH
vent terminal
33
Corrective Action
&KHFNWKHYHQWWHUPLQDOIRUEORFNDJH UHF\FOLQJWKHÀXHJDVHV
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
FOR YOUR SAFETY READ BEFORE LIGHTING
!
WARNING
,I \RX GR QRW IROORZ WKHVH LQVWUXFWLRQ H[DFWO\ D ¿UH RU H[SORVLRQ PD\ UHVXOW FDXVLQJ SURSHUW\ GDPDJH
personal injury or loss of life.
A. 7KLVDSSOLDQFHLVHTXLSSHGZLWKDQLJQLWLRQGHYLFHZKLFKDXWRPDWLFDOO\OLJKWVWKHSLORW5HIHUWRWKHLQVWUXFWLRQV
B. %()25(23(5$7,1*VPHOODOODURXQGWKHDSSOLDQFHDUHDIRUJDV%HVXUHWRVPHOOQH[WWRWKHÀRRUEHFDXVHVRPH
JDVLVKHDYLHUWKDQDLUDQGZLOOVHWWOHRQWKHÀRRU
WHAT TO DO IF YOU SMELL GAS:
‡
'RQRWDWWHPSWWROLJKWDQ\DSSOLDQFH
‡
'RQRWWRXFKDQ\HOHFWULFVZLWFKGRQRWXVHDQ\SKRQHLQ\RXUEXLOGLQJ
‡
,PPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURPDQHLJKERU VSKRQH)ROORZWKHJDVVXSSOLHU VLQVWUXFWLRQV
‡
,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH¿UHGHSDUWPHQW
C. 8VHRQO\\RXU¿QJHUWRSXVKLQWKHPDVWHUVZLWFK1HYHUXVHWRROV,IWKHVZLWFKZLOOQRWIXQFWLRQE\KDQGGRQRWWU\
WRUHSDLULW&DOODTXDOL¿HGVHUYLFHWHFKQLFLDQ)RUFHRUDWWHPSWHGUHSDLUPD\UHVXOWLQD¿UHRUH[SORVLRQ
D. 'RQRWXVHWKLVDSSOLDQFHLIDQ\SDUWRILWKDVEHHQXQGHUZDWHU,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQWR
LQVSHFWWKHDSSOLDQFHDQGWRUHSODFHDQ\SDUWRIWKHFRQWUROV\VWHPDQGDQ\JDVFRQWUROWKDWKDVEHHQXQGHUZDWHU
34
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
LIGHTING AND OPERATING INSTRUCTIONS
FOR RADVTSC MODELS
67235HDGWKHVDIHW\LQIRUPDWLRQDERYH
7KLVDSSOLDQFHLVHTXLSSHGZLWKDQLJQLWLRQGHYLFHZKLFKDXWRPDWLFDOO\OLJKWVWKHEXUQHU'RQRWWU\WROLJKWWKH
EXUQHUE\KDQG
:LWK¿YH PLQXWHVWRFOHDURXWDQ\JDV7KHQVPHOOIRUJDVLQFOXGLQJQHDUWKHÀRRU,I\RXVPHOOJDV6723
)ROORZ%LQWKHVDIHW\LQIRUPDWLRQRQ3DJH,I\RXGRQRWVPHOOJDVJRWRQH[WVWHS
3UHVVWKHPDVWHUVZLWFKWRWKH21 SRVLWLRQ:LWKLQHLJKW VHFRQGVLWZLOOEHHSRQFH7KLVLQGLFDWHVWKH
V\VWHPLVUHDG\
3UHVV21EXWWRQ6SDUNHUZLOOVSDUNDQGSLORWÀDPHZLOOOLJKW
2QFHSLORWÀDPHLVHVWDEOLVKHGWKHPDLQEXUQHUÀDPHZLOOOLJKWDXWRPDWLFDOO\
,IWKHSLORWZLOOQRWVWD\OLWDIWHUVHYHUDOWULHVWXUQWKHPDVWHUVZLWFKWR2))DQGFDOO\RXUVHUYLFHWHFKQLFLDQRUJDV
VXSSOLHU
2))
OFF
ON
Master
Switch
21
Command Center
TO TURN OFF GAS TO APPLIANCE
7XUQPDVWHUVZLWFKWR2))
7XUQRIIDOOHOHFWULFDOSRZHUWRWKHDSSOLDQFHLIVHUYLFHLVWREHSHUIRUPHG
35
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Signature command operating instructions
Features - Command Center (Figure 58)
‡ (DV\$FFHVV)XQFWLRQ2SHUDWLRQDQG6\VWHP&RQ¿JXUDWLRQ
‡ 2SHUDWLRQ&RQ¿UPDWLRQ)DXOW'LDJQRVWLF,QGLFDWLRQV /('
%X]]HU
‡ 212))+,0HG/RZ2SHUDWLRQ
‡ 2SWLRQDO:DOO0RXQWLQJ
Control Board
‡ (OHFWURQLF,JQLWLRQ
• Pilot Lockout safety feature
‡ (OHFWULF 3RZHU 5HJHQHUDWLRQ IURP 7KHUPRSLOH WR VDYH
battery
‡ KRXU$XWRPDWLF6KXW'RZQ2SWLRQ
‡ &RQYHQLHQW1*/3*DV7\SH&RQYHUVLRQ
‡ 6WDQGLQJ3LORW,QWHUPLWWHQWSLORW&RQYHUVLRQ
‡ 3UHYLRXVVHWWLQJV5HVWRUDWLRQ$ELOLW\ 0HPRU\2II
‡ 8QLQWHUUXSWHG2SHUDWLRQ'XULQJ3RZHU2XWDJH $XWRPDWLF
Battery Backup)
‡ 212))5)5HPRWH5HFHLYHU
‡ 2SWLRQDO7UDQVPLWWHU/HDUQ&DSDELOLW\
AC Module (Requires TSFSC Remote)
‡ (DV\6QDSRQ'HVLJQ
‡ (PEHGGHG &RPSDFW 9$&$GDSWHU ZLWK$XWR %DWWHU\
%DFNXS)HDWXUH
‡ 5HPRWH &RQWUROOHG VWHS %ORZHU /LJKWLQJ DQG 2Q2II
$X[LOLDU\$&2XWSXWV
Transmitter (TSFSC)
‡ 7KUHH)ODPH+HLJKW6HWWLQJV
• Low battery Indication for Transmitter
• Child Proof Lock-out
‡ /&'%DFNOLJKW
• Security Codes (16)
• Countdown 6 hr Timer
• Standard Thermostatic Control Mode
‡ 6PDUW 0RGHŠ 7KHUPRVWDW $XWR )ODPH
Modulation)
‡ 7KUHH%ULJKWQHVV6HWWLQJVIRU/LJKWV
• Three Speed Control for Blower
‡ 2Q2II$X[LOLDU\
‡ 3URJUDPPDEOH7LPHUWRWXUQEORZHURQDQGRII
36
5)5HFHLYHU
212))
To Thermopile
To Sensor
To Sparker
1*/3
Conversion
To Command
Center
Control Board
21
/('
To Stepper Motor
To Valve
Master Switch
2))
$&0RGXOH
Battery Door
Command Center
Figure 58 - Signature Command System Components
Battery Installation
7KH&RPPDQG&HQWHUXVHVIRXU $$EDWWHULHVDVEDFNXS
IRUSRZHURXWDJHV7KHV\VWHPFDQRSHUDWHIRUDSSUR[LPDWHO\
VL[ PRQWKVRQEDWWHU\SRZHU
7R,QVWDOO%DWWHULHV QRWLQFOXGHG 3UHVVGRZQWKHEDWWHU\GRRUWDEVDQGSXOORXWWRUHPRYH
EDWWHU\GRRU
,QVWDOOWKHEDWWHULHVDVLQGLFDWHGRQ&RPPDQG&HQWHU
&ORVHEDWWHU\GRRUE\VQDSSLQJLQSODFH
%ORZHU
:KHQWKHIRXU EDWWHULHVDUHLQVWDOOHGWKHV\VWHPZLOO
RSHUDWHZLWKRXWSRZHU
7KHEDWWHULHVVKRXOGEHUHSODFHGZKHQWKH/('LQGLFDWHV
ORZEDWWHU\RUDWOHDVWRQFHD\HDU
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
6\VWHP&RQ¿JXUDWLRQ6HWXS
$OO 6\VWHP FRQ¿JXUDWLRQVHWXS LV GRQH RQ WKH &RPPDQG
&HQWHU&KRRVHWKHPRGHWKDWEHVWVXLWV\RXUQHHGV
NOTE: When using On/Off wall switch, the switch must
EH LQ WKH 21 SRVLWLRQ WR SHUIRUP DOO FRQ¿JXUDWLRQ VHW
ups at the command center.
Cold Climate Option
7KH6LJQDWXUH&RPPDQG6\VWHPLVGHVLJQHGWRRSHUDWHLQ
HLWKHU6WDQGLQJ3LORWRU,QWHUPLWWHQW3LORWPRGH
‡ 7KH 6WDQGLQJ 3LORW 0RGH LV EHVW IRU FROGHU FOLPDWHV
when the pilot must remain on continuously to prevent
FRQGHQVDWLRQDQGHQVXUHUHOLDEOHRSHUDWLRQ
‡ 7KH ,QWHUPLWWHQW 3LORW 0RGH LV LGHDO IRU PD[LPXP
HI¿FLHQF\ LJQLWLQJ WKH SLORW RQO\ ZKHQ QHHGHG WR VWDUW
\RXUVWRYHORZHULQJIXHOFRQVXPSWLRQDQGUHGXFLQJ\RXU
FDUERQIRRWSULQW
(LWKHUPRGHEHQH¿WVIURPWKHLQVWDQWDQHRXVEDWWHU\EDFNXS
VR\RXQHYHUKDYHWRZRUU\DERXWDSRZHURXWDJH
NOTE: The Signature Command System comes standard
in the Intermittent Pilot mode, so you must follow the
instructions below to switch to Standing Pilot Mode if
needed.
:KHQWKHPDVWHUVZLWFKLVLQWKH21SRVLWLRQ ³´ SUHVVLQJ
WKH21EXWWRQDQGWKH2))EXWWRQRQWKH&RPPDQG&HQWHU
VLPXOWDQHRXVO\ZLOOWRJJOHEHWZHHQHQDEOLQJDQGGLVDEOLQJ
WKHVL[KRXUVKXWGRZQRSWLRQ
$IWHUWKHDERYHRSHUDWLRQRQHEHHS IRUHQDEOLQJWKHVL[KRXU
VKXWGRZQ RSWLRQ RU WZR EHHSV IRU GLVDEOLQJ WKH VL[KRXU
VKXWGRZQRSWLRQ ZLOOEHJLYHQDVFRQ¿UPDWLRQ
Remote Transmitter Learn Function (Default OFF)
7KH5)UHFHLYHUEXWWRQORFDWHGRQWKH&RQWURO%RDUGPXVW
EHLQWKHRQSRVLWLRQEHIRUHWKHOHDUQIXQFWLRQFDQEHJLQ8VH
SDSHUFOLSWRGHSUHVVEXWWRQ2QHEHHSIRU5)UHFHLYHU21RU
WZREHHSVIRU5)UHFHLYHU2))ZLOOEHJLYHQDVFRQ¿UPDWLRQ
5HIHUWR)LJXUHIRUORFDWLRQ
$IWHUWKH5)UHFHLYHULVRQKROGLQJWKH2))EXWWRQRQWKH
&RPPDQG &HQWHU ZKLOH WXUQLQJ RQ WKH PDVWHU VZLWFK ZLOO
DFWLYDWHWKHOHDUQIXQFWLRQIRUWKHWUDQVPLWWHU
$IWHUWKHDERYHRSHUDWLRQWZREHHSVZLOOEHJLYHQDQGWKH
JUHHQ/('RQWKH&RPPDQG&HQWHUZLOOÀDVKIRUVHFRQGV
'XULQJWKHVHFRQGVSUHVVWKH2))EXWWRQRQDWUDQVPLWWHU
WR OHDUQ $QRWKHU WZR EHHSV ZLOO EH JLYHQ WR FRQILUP D
VXFFHVVIXO OHDUQLQJ 5HIHU WR WUDQVPLWWHU LQVWUXFWLRQV IRU
UHPRWHRSHUDWLRQV
Intermittent/Standing Pilot Setup (Default intermittent)
+ROGLQJWKH21EXWWRQRQWKH&RPPDQG&HQWHUZKLOHWXUQLQJ
RQWKHPDVWHUVZLWFKZLOOWRJJOHEHWZHHQVWDQGLQJSLORWDQG
LQWHUPLWWHQWSLORW
Shutting Off the Standing Pilot (Temporary Shut Off)
7RVKXWRIIWKHVWDQGLQJSLORWIRUVHUYLFHRUVXPPHUVKXWGRZQ
SUHVVDQGKROGWKH21EXWWRQRQWKH&RPPDQG&HQWHUIRU
VHFRQGVZKHQWKHPDVWHUVZLWFKLVLQWKH21SRVLWLRQ ³´ DQGWKHPDLQEXUQHULVRII
$IWHUWKHDERYHRSHUDWLRQRQHEHHS IRUVWDQGLQJSLORW RU
WZREHHSV IRULQWHUPLWWHQWSLORW ZLOOEHJLYHQDVFRQ¿UPDWLRQ
1RWH3LORWZLOOUHVXPHWKHQH[WWLPHV\VWHPLVWXUQHGRQ
Six-hour Safety Shutdown Option (Default ON)
7KHV\VWHPFRPHVSUHVHWIURPWKHIDFWRU\ZLWKDVL[ KRXU
VKXWGRZQIURPLWVODVWFRPPDQGRIRSHUDWLRQ7KLVLVGRQHWR
SUHYHQWWKHVWRYHIURPFRQWLQXLQJWRRSHUDWHLIXQDWWHQGHG
<RXPD\GLVDEOHWKLVIHDWXUHLI\RXZLVK
.H\&RPELQDWLRQVIRU6\VWHP6HWWLQJV
NOTE: When On/Off wall switch is used, it must be in the
On position to perform all system setups.
NOTE: By disabling this feature, your stove may continue
to operate unattended.
Function
Operation
Default Setting
,QWHUPLWWHQW6WDQGLQJ3LORW6HWXS
+ROG WKH 21 S EXWWRQ ZKLOH WXUQLQJ RQ WKH PDVWHU VZLWFK
%HHSRQFHIRUVWDQGLQJSLORWWZLFHIRULQWHUPLWWHQWSLORW
Intermittent Pilot
6WDQGLQJ3LORW7HPSHUDWXUH6KXWRII
+ROGWKH21SEXWWRQVHFRQGV ZKHQWKHPDVWHUVZLWFKRQ
the main burner is off)
5)5HPRWH5HFLHYHU2Q2II
3XVK WKH 5) UHFHLYHU 2Q2II EXWWRQ RQ WKH FRQWURO ERDUG
%HHSRQFHIRU21DQGEHHSWZLFHIRU2))
Learn Remote Transmitter
+ROG WKH 2)) T EXWWRQ ZKLOH WXUQLQJ RQ WKH PDVWHU VZLWFK
(Beep twice then press any handheld remote button)
+RXU6DIHW\6KXWGRZQ6HWXS
3UHVV WKH 21 S EXWWRQ DQG 2)) T EXWWRQ VLPXOWDQHRXVO\
%HHSRQFHIRU21WZLFHIRU2))
37
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
5)2))
21
3-90-20306760
Operating instructions
Turning on the stove
7XUQRQWKHPDVWHUVZLWFKDQGZDLWIRUDEHHS3UHVVWKH21
EXWWRQRQWKH&RPPDQG&HQWHURUWXUQRQZDOOVZLWFK3LORW
ZLOOOLJKWDQGEXUQHUZLOOFRPHRQ+LJKVHWWLQJRUODVWPHPRU\
VHWWLQJ 6HH7XUQLQJ2II6WRYHEHORZ )RUPHPRU\IHDWXUH
Pilot Safety Lockout Function
,IWKHSLORWGRHVQ¶WOLJKWDIWHUVSDUNLQJIRUVHFRQGVSLORWWULDO
ORFNRXWKDSSHQV7KH/('RQWKH&RPPDQG&HQWHUÀDVKHV
*UHHQRQFHHYHU\VHFRQGVXQWLOUHVHW
Command Center Operations
7KH IROORZLQJ IXQFWLRQV DUH DYDLODEOH RQ WKH &RPPDQG
&HQWHU
Self Diagnostics Chart
7KH&RPPDQG&HQWHUKDVDVHOIGLDJQRVWLF/('HQDEOLQJ
you to troubleshoot problems and potentially avoid a service
FDOO3OHDVHUHIHUWRWKHFKDUWVEHORZIRULQGLFDWRUUHIHUHQFH
,IWKHSLORWÀDPHLVORVWGXULQJQRUPDORSHUDWLRQWKHV\VWHP
ZLOOWU\WKUHH WLPHVWRUHOLJKWDIWHUWKUHH IDLOXUHVÀDPH
ORVV ORFNRXW KDSSHQV 7KH /(' RQ WKH &RPPDQG &HQWHU
ÀDVKHV5HG*UHHQRQFHHYHU\VHFRQGVXQWLOUHVHW
Fault
LED Indication
&RQYHUVLRQ&RYHU0LVVLQJ
2QH5('HYHU\VHFRQGV
6SDUN)DLO
7ZR5('HYHU\VHFRQGV
)ODPH(UURU6HQVRU6LJQDO
7KUHH5('HYHU\VHFRQGV
Pilot Lockout - Trial
)RXU5('HYHU\VHFRQGV
3LORW/RFNRXW)ODPH/RVV
)LYH5('HYHU\VHFRQGV
7XUQLQJWKHPDVWHUVZLWFKRQWKH&RPPDQG&HQWHUWRWKHRII
SRVLWLRQWKHQ21DJDLQZLOOUHVHWWKHV\VWHP
Low Battery
2QH5('HYHU\VHFRQGV
1RRU/RZ7KHUPRSLOH3RZHU
7ZR5('HYHU\VHFRQGV
Flame Height Control
3UHVVWKH21EXWWRQ RQWKH&RPPDQG&HQWHU RQFHWRWXUQ
RQWKHPDLQEXUQHUZLWKPD[LPXPÀDPHKHLJKW
9DFFXP6ZLWFK)DLOHG 3RZHU 2QH5('HYHU\VHFRQGVXQWLO
9HQW2QO\
reset
3UHVV WKH 2)) EXWWRQ WR GHFUHDVH ÀDPH KHLJKW 7KH ¿UVW
WZRSUHVVHVZLOOGHFUHDVHWKHÀDPHKHLJKWWRPHGLXPDQG
ORZ7KHWKLUGSUHVVRQ2))ZLOOWXUQRIIWKHPDLQEXUQHU,Q
VWDQGLQJSLORWFRQ¿JXUDWLRQWKHSLORWZLOOVWD\LQLQWHUPLWWHQW
SLORWFRQ¿JXUDWLRQWKHSLORWZLOOEHVKXWRII
Function
Operation
3RZHU8S
)OLS WKH PDVWHU VZLWFK WR WKH 21 ± position to power up the system
6WRYH21
3UHVVWKH21VEXWWRQRQWKH&RPPDQG
Center or turn on wall switch to turn the
stove on
6WRYH2))
/HDUQLQJ
*5((1ÀDVKHVHYHU\VHFRQG
(for 10 seconds)
$&3RZHU2Q
*5((1VROLG
NOTE: Due to the sensitive temperature monitoring
components in the transmitter, it is necessary to allow
the transmitter to stabilize to room temperature before
accurate room temperatures are displayed. If the
transmitter is activated from a severe cold condition,
allow 15 minutes for accurate temperature readings to
appear on the LCD display.
!
)OLS WKH PDVWHU VZLWFK WR WKH 2)) R SRVLWLRQ25SUHVVWKH2))WEXWWRQWLPHV
25IRU0HPRU\2IIKROGWKH2))WEXWWRQ
3 seconds, or turn off wall switch
WARNING
7XUQDSSOLDQFH2)) DWWKH0DVWHU6ZLWFK LI\RXDUHDZD\
IURP\RXUKRXVHIRUDQH[WHQGHGSHULRGRIWLPH1HYHUOHDYH
DQ\WKLQJRQWRSRIWKHVXUIDFHRIWKHWUDQVPLWWHU
)ODPH +HLJKW 3UHVVWKH21VEXWWRQRQFHWRWXUQRQWKH
8S
VWRYHZLWKPD[LPXPÀDPHKHLJKW
Function Areas of the LCD Display
)LJXUHVKRZVWKHGLVSOD\RIWKH76)6&/&'
)ODPH+HLJKW 3UHVVWKH2))WEXWWRQWRORZHUWKHÀDPH
Down
KHLJKWWR0HGLXPDQG/RZ
Information Bar
The information bar shows the room temperature, the
³VHQGLQJVLJQDO´UDGLRLFRQWKHORZEDWWHU\LQGLFDWLRQLFRQ
WKHFKLOGSURRILFRQDQGWKHÀDPHLFRQ7KLVDUHDGRHVQ¶W
KDYHWRXFKEXWWRQV
Turning the Stove Off
7KHUHDUHWKUHHZD\VWRWXUQWKHVWRYHRII
)OLSWKHPDVWHUVZLWFKWRWKHRII ³2´ SRVLWLRQ 7KLVZLOO
WXUQWKHHQWLUHV\VWHP2))
3UHVVWKH2))EXWWRQWR0HGLXP/RZWKHQ2II
+ROG WKH 2)) EXWWRQ DQ\WLPH IRU WKUHH VHFRQGV RU E\
WXUQLQJ RII WKH ZDOO VZLWFK 7KHVH WZR FRPPDQGV RI
2))DUH 0HPRU\2II WKHV\VWHPZLOOUHPHPEHUDOOODVW
VHWWLQJV EHIRUH WXUQLQJ RII 7KH QH[W WLPH WKH VWRYH LV
WXUQHG RQ DOO VHWWLQJV ZLOO UHVXPH7R UHVHW FKDQJH WR
WKH GHVLUHG VHWWLQJV DQG VKXW RII E\ XVLQJ WKH 0HPRU\
2IIFRPPDQGVDQGWKHV\VWHPZLOOEHUHVHWWRWKRVHQHZ
VHWWLQJV
38
•
The room temperature will always be shown after
SRZHUXS,WGLVSOD\VWKHURRPWHPSHUDWXUHIURPƒ)
WRƒ)³/R´DQG³+,´ZLOOEHGLVSOD\HGZKHQWKHURRP
WHPSHUDWXUH LV ORZHU WKDQ ƒ) RU KLJKHU WKDQ ƒ)
UHVSHFWLYHO\
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
•
The radio icon will be shown when the transmitter is
VHQGLQJDVLJQDO
Initialization and Setting up / Installing Batteries )LJXUH
60)
•
The low battery indication icon will be shown when the
EDWWHU\YROWDJHLVORZ
•
The child-proof icon will be shown when the child-proof
PRGHLVDFWLYDWHG
The remote transmitter has two battery compartments, one
RQHDFKHQGRIWKHWUDQVPLWWHU$OZD\VFKDQJHDOOIRXU batteries at the same time.
To install batteries,
‡ 7KHÀDPHLFRQLQGLFDWHVWKHFXUUHQWÀDPHKHLJKW±2II
/RZ0HGLXPDQG+LJK
3UHVVGRZQWKHEDWWHU\GRRUWDEDQGSXOORXWWRUHPRYH
WKHEDWWHU\GRRU
Touch Area
The touch area contains all touch buttons to control the
WUDQVPLWWHU ,W FRQVLVWV RI WZR FDWHJRULHV PHQXV DQG
DGMXVWPHQWDUURZV7KHEOXH/('EDFNOLJKWOLJKWVXSIRU
VHFRQGVZKHQDQ\RIWKHWRXFKEXWWRQVLVSUHVVHG
,QVWDOO WKH EDWWHULHV DV LQGLFDWHG LQVLGH WKH EDWWHU\
FRPSDUWPHQWV
‡ 7KHPHQXVLQFOXGH7,0(57+(502/,*+7)$1DQG
$8;
‡ 7KH DGMXVWPHQW DUURZV LQFOXGH 21XS DQG 2))GRZQ
7KHLUGHIDXOWIXQFWLRQLVWRDGMXVWWKHÀDPHKHLJKW:KHQ
D EXWWRQ IURP WKH PHQX LV SUHVVHG WKH 21XS DQG
2))GRZQ EXWWRQV ZLOO WHPSRUDULO\ EHFRPH DGMXVWPHQW
FRQWUROV IRU WKH VHOHFWHG LWHP :KHQ WKH DGMXVWPHQW
LV GRQH WKH 21XS DQG 2))GRZQ EXWWRQV JR EDFN WR
ÀDPHKHLJKWFRQWUROOHUDJDLQ
&ORVHWKHEDWWHU\GRRUE\VQDSSLQJLQSODFH
:KHQDOOfour batteries are installed, the transmitter will
LQLWLDOL]HIRUVHFRQGVDQGWKHQLVUHDG\IRUXVH
7KH EDWWHULHV VKRXOG EH UHSODFHG HYHU\ PRQWKV RU
ZKHQWKHORZEDWWHU\LFRQLQGLFDWRULVGLVSOD\HG
Battery
Door Tabs
Logo Bar
7KH/RJR%DUFRQWDLQVWKHEUDQGORJR6LJQDWXUH&RPPDQG
6\VWHP
Information
Bar
)LJXUH5HSODFLQJWKHEDWWHU\
Menus
Changing Temperature Unit
When batteries are installed in the transmitter, all available
LFRQVRQWKH/&'ZLOOEHWXUQHGRQWKHQEHFOHDUHG
$GMXVWPHQW
Controls
7RXFK$UHD
7KH/&'ZLOOGLVSOD\WHPSHUDWXUHXQLWƒ)8VH21¨WRWRJJOH
WKHXQLWVEHWZHHQƒ)DQGƒ&ZLWKLQWKH¿UVWVHFRQGV
The transmitter enters Manual Mode
7KH/&'GLVSOD\VURRPWHPSHUDWXUHZLWKWKHFKRVHQXQLW
/RJR
Bar
)LJXUH)XQFWLRQDODUHDVRI/&''LVSOD\
39
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Setting Privacy Code on Transmitter )LJXUH
7KHUHPRWHWUDQVPLWWHUSULYDF\FRGHLVSUHVHWLQIDFWRU\,Q
the event of activation or interference from other nearby
WUDQVPLVVLRQV FKDQJH WKH FRGH XVLQJ WKH IROORZLQJ
SURFHGXUHV OHDUQIXQFWLRQPXVWEHSHUIRUPHGDIWHUFKDQJLQJ
WKHFRGH •
3UHVVWKH21DUURZEXWWRQDQGWKH
7,0(5 EXWWRQ DW WKH VDPH WLPH WR
HQWHUSULYDF\FRGHVHWXSPRGH
•
The setup display is shown in the
¿JXUH 7KH IRXU GLJLWV RQ WKH WRS
stand for the privacy code (as the
DFWXDO ',3 VZLWFKHV RQ $PELHQW¶V
SUHYLRXV UHPRWHV 7KH GHIDXOW
YDOXHV RI WKH IRXU GLJLWV ZLOO EH DOO
³´ 21 •
7KH ¿UVW GLJLW ZLOO EH ÀDVKLQJ XSRQ
HQWHULQJ WKH VHWXS PRGH 3XVK Figure 61
WKH 21 EXWWRQ WR WRJJOH LWV YDOXH
EHWZHHQ ³´ 2)) DQG ³´ 21 DQG SXVK WKH ³2))´
EXWWRQWRMXPSWRWKHQH[WGLJLW7KHQH[WGLJLWZLOOWKHQ
VWDUWÀDVKLQJDQGWKH¿UVWRQHVWRSVÀDVKLQJ6HWXSWKH
IRXUGLJLWVWR\RXUFKRLFH
•
$IWHUVHWWLQJXSDOOWKHIRXUGLJLWVSXVK³2))´WR¿QLVKWKH
SURFHVVDQGUHWXUQWRWKHSUHYLRXVPRGH
•
7KH 6LJQDWXUH &RPPDQG FRQWURO ERDUG WKHQ QHHGV WR
UHOHDUQWKHQHZVHWWLQJ
Performing Learn Function
• 7KH5)UHFHLYHUEXWWRQRQWKHFRQWUROERDUGLQWKHVWRYH
PXVWEHLQWKH21SRVLWLRQEHIRUHWKHOHDUQIXQFWLRQFDQ
EHJLQ:LWKWKH&RPPDQG&HQWHUPDVWHUVZLWFKLQWKH21
position, use paper clip to depress the recessed button on
&RQWURO%RDUGRQHEHHSIRU5)UHFHLYHU21RUWZREHHSV
IRU5)UHFHLYHU2)))LJXUH
•
+ROGLQJ WKH 2)) EXWWRQ RQ WKH &RPPDQG &HQWHU ZKLOH
WXUQLQJRQWKHPDVWHUVZLWFKZLOODFWLYDWHWKHOHDUQIXQFWLRQ
IRUWKHWUDQVPLWWHU)LJXUH
•
$IWHU WKH DERYH RSHUDWLRQ WZR EHHSV ZLOO EH JLYHQ DQG
WKHJUHHQ/('RQWKH&RPPDQG&HQWHUZLOOÀDVKIRU
VHFRQGV
•
'XULQJ WKH VHFRQGV SUHVV WKH 2)) EXWWRQ RQ WKH
WUDQVPLWWHU WR OHDUQ$QRWKHU WZR EHHSV ZLOO EH JLYHQ WR
FRQ¿UPDVXFFHVVIXOOHDUQLQJ)LJXUH
Resetting the Transmitter
,IWKHWUDQVPLWWHULVQRWZRUNLQJSURSHUO\UHLQVWDOOWKHEDWWHULHV
WRUHVHWWKHWUDQVPLWWHU
•
3XOORXWDWOHDVWRQHRIWKHEDWWHULHV
•
3UHVVDQ\NH\RQWKHVFUHHQWRGLVFKDUJH
•
:DLWIRUVHFRQGVDQGUHLQVWDOOWKHEDWWHULHV
3XVKLQJDQGKROGLQJDQ\NH\IRUPRUHWKDQVHFRQGVXQWLO
WKHGLVSOD\UHIUHVKHVZLOODOVRUHVHWWKHWUDQVPLWWHU
40
21
/('
Master Switch
2))
Battery Door
5)5HFHLYHU
212))
)URQW3DQHO
%H]HO2SWLRQDO
CONTROL
BOARD
Figure 62 - Command center and control board
!
WARNING
Do not use two (2) or more remote control systems
in the same area with the same privacy code setting,
as they will communicate with each other. This may
cause the appliances to malfunction.
Functions and Operations
General
7KH76)6&5HPRWH&RQWUROKDVIRXU RSHUDWLQJPRGHV
0DQXDO7LPHU7KHUPRVWDWLFDQG6PDUW0RGHŠWKHUPRVWDW
7KHFRQWUROV\VWHPFDQEHVHWWRWHPSHUDWXUHUDQJHEHWZHHQ
ƒ)DQGƒ)7KHEORZHUVSHHGDQGÀDPHKHLJKWFDQEH
DGMXVWHGLQWKHPDQXDOWLPHUDQGWKHUPRVWDWLFPRGH7KH
6PDUW 0RGHŠ WKHUPRVWDW ZLOO DXWRPDWLFDOO\ DGMXVW ÀDPH
KHLJKWDQGEORZHUVSHHGDFFRUGLQJWRWKHGLIIHUHQFHEHWZHHQ
6HWDQG5RRPWHPSHUDWXUHV
The transmitter will operate the remote receiver from 1 foot
WR D PD[LPXP RI IHHW 7KH GLVWDQFH LV UHGXFHG ZKHQ
EDWWHULHVDUHORZ
Manual Mode )LJXUH
,QWKLVPRGHWKH7,0(5EXWWRQDQGWKH7+(502EXWWRQZLOO
RQO\GLVSOD\³7,0(5´DQG³7+(502´UHVSHFWLYHO\ZLWKRXW
VKRZLQJ WKH WLPH DQG WKH 6(7 WHPSHUDWXUH 3UHVVLQJ WKH
21XSDQG2))GRZQEXWWRQVZLOOFKDQJHWKHÀDPHKHLJKW
LIQRQHRIWKHPHQXEXWWRQV 7,0(57+(502/,*+7)$1
$8; DUHSUHVVHGDQGÀDVKLQJ
• 3UHVVWKH21XSEXWWRQWRWXUQRQWKHVWRYH7KHÀDPH
LFRQRQWKH/&'GLVSOD\V+LJK
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
•
3UHVV WKH 2))GRZQ EXWWRQ WR
GHFUHDVH WKH ÀDPH KHLJKW DQG
WXUQRIIWKHVWRYH:KHQWKH2))
down button is pressed for three
WLPHV WKH ÀDPH LFRQ FKDQJHV
IRUP +LJK WR 0HGLXP WR /RZ
WKHQWR2II
•
,IWKH2))EXWWRQLVKHOGIRUPRUH
WKDQ VHFRQGV DW DQ\ ÀDPH
KHLJKWWKHVWRYHZLOOEHWXUQHGRII
DQGWKHÀDPHLFRQGLVDSSHDUV
•
6OLGLQJXSDQGGRZQRQWKHDUURZ
buttons can also turn on or turn
)LJXUH
RIIWKHVWRYH
•
,I WKH VWRYH LV VKXW RII XVLQJ WKH DERYH PHWKRGV LQ DQG DOO WKH VHWWLQJV ZLOO EH UHPHPEHUHG DQG ZLOO EH
UHVXPHGQH[WWLPHWKHVWRYHLVWXUQHGRQ 0HPRU\2II Timer Mode ()LJXUH
3UHVVWKH7,0(5EXWWRQWRHQWHUWLPHUPRGH7KHVWRYHZLOO
VWD\ RQ IRU D SHULRG RI WLPH DV VSHFL¿HG E\ WKH WLPHU DQG
then be shut off by the transmitter when the timer counts
GRZQWR]HUR
Thermostat Mode )LJXUH
NOTE: The Command Center buttons will disable when
thermostat is being used.
3UHVVWKH7+(502EXWWRQWRVHWWKH
WUDQVPLWWHULQWKHUPRVWDWPRGH7KH
transmitter will automatically turn on
the stove when the room temperature
is below the set temperature and
turn off the appliance when the
room temperature is above the set
WHPSHUDWXUHZLWKLQRQHGHJUHH
:KHQ WKH 7+(502 EXWWRQ LV
pressed, the Set temperature
appears in the frame of the button
DQGÀDVKHV
8VH 21XS DQG 2))GRZQ
to increase or decrease the Figure 65
6HW WHPSHUDWXUH LQ GHJUHH
LQFUHPHQWV EHWZHHQ GHJUHHV DQG GHJUHHV
Slide up and down on the arrow buttons will increase or
GHFUHDVHWKH6HW7HPSHUDWXUHLQGHJUHHVLQFUHPHQWV
3UHVV WKH 7+(502 EXWWRQ DJDLQ WR FRQ¿UP WKH 6HW
7HPSHUDWXUH7KHWUDQVPLWWHUZLOOVHQGRXWDQ2QVLJQDO
RUDQ2IIVLJQDOGHSHQGLQJRQWKHUHODWLRQVKLSEHWZHHQ
WKH6HWWHPSHUDWXUHDQGWKH5RRPWHPSHUDWXUH
•
:KHQ WKH 7,0(5 EXWWRQ LV SUHVVHG WKH 6HW 7LPH
appears in the frame of the button
DQGÀDVKHV
•
8VH 21XS DQG 2))GRZQ WR
increase or decrease the Set
7LPH LQ PLQ LQFUHPHQWV
EHWZHHQWR6OLGLQJXS
and down on the arrow buttons
will increase or decrease the Set
7LPHLQKRXULQFUHPHQWV
7KHÀDVKLQJVWRSVDQGWKH21XSDQG2))GRZQEXWWRQV
EHFRPHÀDPHKHLJKWFRQWUROOHUDJDLQ7KHÀDPHKHLJKW
ZLOO WKHQ VWD\ DV VHW XS E\ WKH 21XS DQG 2))GRZQ
EXWWRQV
3XVK WKH 7,0(5 EXWWRQ DJDLQ
WR FRQ¿UP WKH 6HW 7LPH WKH
WUDQVPLWWHUVHQGVDQ21VLJQDOWR
WXUQRQWKHVWRYH
or
•
•
•
7KHÀDVKLQJVWRSVDQGWKH21XS )LJXUH
DQG 2))GRZQ EXWWRQV EHFRPH ÀDPH KHLJKW FRQWUROOHU
DJDLQ7KHÀDPHKHLJKWZLOOWKHQVWD\DVVHWXSE\WKH
21XSDQG2))GRZQEXWWRQV
7KH7,0(5EXWWRQFDQEHXVHGZKHQWKHWUDQVPLWWHULV
LQ0DQXDO0RGHRULQ7KHUPRVWDW0RGH,QERWKPRGHV
the stove will be shut down completely when the timer
FRXQWVGRZQWR]HUR
7RH[LW7LPHU0RGH\RXFDQGRRQHRIWKHIROORZLQJ
•
3XVKDQGKROGWKH7,0(5EXWWRQIRUVHFRQGV
•
8VHWKH2))GRZQEXWWRQVWRGHFUHDVHWKH6HW7LPHWR
]HUR
•
6OLGH GRZQ RQ WKH DUURZ EXWWRQV WR H[LW 7,0(5 PRGH
DQGVKXWRIIWKHVWRYH
41
7RH[LW7KHUPRVWDW0RGH
D SXVKDQGKROGWKH7+(502EXWWRQVIRUVHFRQGV
E VOLGHGRZQRQWKHDUURZEXWWRQVWRH[LW7KHUPRVWDW
PRGHDQGVKXWRIIWKHVWRYH
Smart Mode® Thermostat Option for Thermostat Mode
)LJXUH
3UHVV DQG KROG WKH 7+(502
EXWWRQ DQG WKH 2183 EXWWRQ
at the same time for 3 seconds
WRWRJJOHEHWZHHQ6PDUW0RGHŠ
WKHUPRVWDW DQG WKH UHJXODU
7KHUPRVWDW 0RGH 7KH LFRQ
³6PDUW0RGH´ZLOODSSHDUXQGHU
WKH 6HW 7HPSHUDWXUH 7KH
transmitter will automatically
DGMXVW WKH ÀDPH KHLJKW
DFFRUGLQJ WR WKH GLIIHUHQFH
between the set temperature
DQG WKH URRP WHPSHUDWXUH
7KHUHLVQRPDQXDOÀDPHKHLJKW
Figure 66
DGMXVWPHQW7KHIDQVSHHGZLOO
DOVRDXWRPDWLFDOO\DGMXVWLIWXUQHGRQ
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
Smart
Mode
Icon
3-90-20306760
127( WKHUH ZLOO D VHFRQG GHOD\ IRU WKH IODPH
adjustment when the stove is turned on.
‡ :KHQ 6HW 7HPS LV ƒ ) RU KLJKHU WKDQ 5RRP 7HPS
ÀDPHKHLJKWZLOOEHRQ+LJK
‡ ,IWKHEORZHULVWXUQHGRQXVLQJWKH)$1EXWWRQWKHEORZHU
VSHHGZLOODGMXVWDXWRPDWLFDOO\ZKHQXVLQJ6PDUW0RGHŠ
thermostat (See Smart ModeŠWKHUPRVWDWVHFWLRQ ‡ :KHQ6HW7HPSLVƒ)KLJKHUWKDQ5RRP7HPSÀDPH
KHLJKWZLOOEHRQ0HGLXP
)LJXUH
Blower On Delay Time and Off Delay Time Setup
‡ :KHQ6HW7HPSLVƒ)KLJKHUWKDQ5RRP7HPSÀDPH
KHLJKWZLOOEHRQ/RZ
‡ +ROG WKH )$1 EXWWRQ IRU VHFRQGV XQWLO WZR QXPEHUV
DSSHDURQWKH/&'VFUHHQ7KHOHIWQXPEHULVEORZHU2Q
'HOD\DQGWKHULJKWQXPEHULVEORZHU2II'HOD\7LPH
‡ :KHQ6HW7HPSLVHTXDOWR5RRP7HPSÀDPHKHLJKW
GRHVQRWFKDQJH VWD\VRQORZ ‡ :KHQWKH¿UVWQXPEHULVÀDVKLQJXVHWKH21XSEXWWRQWR
VHWWKHGHVLUHG2Q'HOD\7LPHIURPWRPLQ
‡ :KHQ 6HW7HPS LV ORZHU WKDQ 5RRP7HPS WKH VWRYH
ZLOOEHVKXWRII
‡ 3UHVVWKH2))GRZQEXWWRQWRMXPSWRWKH2II'HOD\7LPH
VHWXS
‡ :KHQ6HW7HPSLVƒ)KLJKHUWKDQ5RRP7HPSDJDLQ
WKHÀDPHKHLJKWZLOOEHRQ/RZ
‡ :KHQ WKH VHFRQG QXPEHU LV ÀDVKLQJ XVH WKH 21XS
EXWWRQDJDLQWRVHWWKHGHVLUHG2II'HOD\7LPHIURPWR
PLQ
‡ 7KH IDQ VSHHG IROORZV WKH ÀDPH KHLJKW LI WKH IDQ LV
WXUQHGRQ
To exit Smart Mode® thermostat and shut off the stove;
‡ 3XVKDQGKROGWKH7+(502EXWWRQVIRUVHFRQGV2U
‡ 3UHVVWKH2))EXWWRQ2U
‡ 3UHVVWKH2))GRZQEXWWRQDJDLQWR¿QLVKWKHVHWXSDQG
WKHQHZVHWWLQJVZLOOEHWUDQVPLWWHGWRWKHUHFHLYHU
‡ 7KHGHIDXOWVHWWLQJVDUHPLQXWHVIRUWKH2Q'HOD\7LPH
DQGPLQXWHVIRUWKH2II'HOD\7LPHDVVKRZQ
‡ 6OLGHGRZQRQWKHDUURZEXWWRQV
To shut off the Smart ModeŠ thermostat option and return
WRUHJXODUWKHUPRVWDWPRGHSUHVVDQGKROGWKH7+(502
EXWWRQDQGWKH2183EXWWRQDWWKHVDPHWLPHIRUVHFRQGV
DJDLQ
Blower Speed Control )LJXUH
127(%ORZHUZLOORQO\ZRUNZLWKÀDPHRQ
The blower speed control function
LV XVHG WR DGMXVW WKH VSHHG RI WKH
EORZHU FRQQHFWHG WR WKH 6LJQDWXUH
&RPPDQG 6\VWHP 7KHUH DUH IRXU
VSHHG OHYHOV 2II /RZ 0HGLXP
+LJK
Figure 68
‡ 3UHVV WKH )$1 EXWWRQ WR HQWHU
WKHEORZHUVSHHGFRQWUROPRGH
7KHIDQLFRQZLOOVWDUWÀDVKLQJ
‡ 3UHVVWKH21XSDQG2))GRZQ
EXWWRQWRLQFUHDVHGHFUHDVHWKH
EORZHUVSHHG
‡ 3UHVV WKH IDQ EXWWRQ DJDLQ WR
)LJXUH
FRQ¿UPWKHVSHHGVHWWLQJ,IWKH
VWRYHLVRQWKHEORZHUVSHHGZLOOWDNHHIIHFWULJKWDZD\
LIWKHVWRYHLVRIIWKHUHFHLYHUZLOOUHPHPEHUWKLVVHWWLQJ
DQGWKHEORZHULVVWLOORII VHHEORZHU2Q'HOD\DQG2II
'HOD\LQWKHQH[WVHFWLRQ ‡ $IWHUWKHVLJQDOLVVHQWWKH21XSDQG2))GRZQEXWWRQV
EHFRPHÀDPHKHLJKWFRQWUROOHUDJDLQ
‡ :KHQ WKH IDQ EXWWRQ LV ÀDVKLQJ VOLGH XS DQG GRZQ RQ
WKH DUURZ EXWWRQV ZLOO WXUQ WKH EORZHU VSHHG WR +LJK
RU 2II GLUHFWO\ ZLWKRXW SUHVVLQJ WKH IDQ EXWWRQ DJDLQ WR
FRQ¿UP
42
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Setting up Blank Screen or Constant Display in Idle
)LJXUH
There is an option to set up how the LCD displays and
IXQFWLRQV ZKHQ WKH WUDQVPLWWHU LV LQ LGOH 7KHUH DUH WZR
FKRLFHV
‡ $ 0RGH:KHQWKHWUDQVPLWWHULVLQLGOHWKHLFRQVLQWKH
³WRXFK DUHD´ WLPHU WKHUPRVWDW EORZHU OLJKW DQG$8; ZLOOGLVDSSHDUDVVKRZQLQWKH¿JXUHRQWKHOHIW:KHQ
any of the touch buttons is pressed, those icons will
DSSHDUDQGDUHUHDG\WRRSHUDWH GHIDXOW ‡ % 0RGH 7KH WUDQVPLWWHU DOZD\V GLVSOD\V DOO DYDLODEOH
LFRQVVKRZLQJFXUUHQWVWDWXVRIWLPHUWKHUPRVWDWEORZHU
OLJKWDQG$8;DVVKRZQLQWKH¿JXUHRQWKHULJKW
3UHVV7,0(5DQG7+(502EXWWRQVDWWKHVDPHWLPHIRU
VHFRQGVWRWRJJOHEHWZHHQ$ DQG% ‡ :KHQ WKH FXUUHQW VHWWLQJ LV$ WRXFK DQ\ SODFH LQ WKH
WRXFKDUHDWREULQJXSWKHLFRQVWKHQSUHVV7,0(5EXWWRQ
DQG 7+(502 EXWWRQ DW WKH VDPH WLPH IRU VHFRQGV
7KHEDFNOLJKWZLOOÀDVKRQFHWRLQGLFDWHWKDWWKHVHWWLQJ
KDVFKDQJHGWR% ‡ :KHQ WKH FXUUHQW VHWWLQJ LV % SUHVVLQJ7,0(5 EXWWRQ
DQG7+(502EXWWRQDWWKHVDPHWLPHIRUVHFRQGVZLOO
VZLWFKWR$ 0RGH7KHWRXFKDUHDLFRQVZLOOGLVDSSHDU
Thermal Shutdown
:KHQ WKH DPELHQW WHPSHUDWXUH LV PRUH WKDQ ƒ) WKH
WUDQVPLWWHUZLOOWXUQRIIWKHVWRYH
•
7KH/&'ZLOOGLVSOD\³+,´
•
The Transmitter will not function until the room
WHPSHUDWXUHKDVGURSSHGEHORZGHJUHH)DKUHQKHLW
Low Temperature Condition
:KHQ WKH DPELHQW WHPSHUDWXUH LV OHVV WKDQ GHJUHHV
)DKUHQKHLWWKH/&'ZLOOGLVSOD\³/2´DQG126,*1$/ZLOO
EHVHQWWRWXUQRQWKHDSSOLDQFH
$OOIXQFWLRQVVWLOOUHPDLQWKHVDPHIRUERWK0DQXDO
Mode and Thermostat Mode
Child-proof Protection
The child-proof icon will be shown when the
FKLOGSURRI PRGH LV DFWLYDWHG E\ SUHVVLQJ WKH
21EXWWRQDQGWKH2))EXWWRQDWWKHVDPHWLPH
IRUWKUHHVHFRQGV
•
(QWHU FKLOGSURRI PRGH E\ SUHVVLQJ DQG
KROGLQJ ERWK WKH 21 EXWWRQ DQG WKH 2))
EXWWRQ VLPXOWDQHRXVO\ IRU VHFRQGV 7KH
Childproof indicator will be shown on the
/&'
•
'HDFWLYDWHFKLOGSURRIPRGHE\SUHVVLQJDQG
KROGLQJ WKH 21 EXWWRQ DQG WKH 2)) EXWWRQ
VLPXOWDQHRXVO\ IRU VHFRQGV DJDLQ 7KH &KLOGSURRI
LQGLFDWRUGLVDSSHDUVRQWKH/&'
•
7KHWUDQVPLWWHUFDQQRWEHRSHUDWHGLQFKLOGSURRIPRGH
Using the Mounting Base )LJXUH
7KHWUDQVPLWWHUFRPHVZLWKDPRXQWLQJEDVHZKLFKDOORZV
\RXWRKDQJWKHWUDQVPLWWHURQWKHZDOO
6HFXUHWKHPRXQWLQJEDVHRQWKHZDOOZLWKVXSSOLHGVFUHZV
)RUEHVWYLHZLQJDQJOHPDNHLWWKHVDPHKHLJKWDV\RXUH\HV
+DQJWKHWUDQVPLWWHURQWKHKRRNRIWKHPRXQWLQJEDVHWKHQ
SXVKGRZQVRWKHWUDQVPLWWHULVÀXVKWRWKHPRXQWLQJEDVH
)LJXUH
Safety Features
Low Battery Detection
When low battery condition occurs, the transmitter will
WXUQRIIWKHVWRYH
%DWWHU\YROWDJHLVFKHFNHGHYHU\RQHPLQXWH:KHQWKH
EDWWHU\YROWDJHLVORZWKH/&'GLVSOD\VDORZEDWWHU\LFRQ
ZKLFKZLOOH[LVWLQDOOPRGHV
•
7KHWUDQVPLWWHUZLOOQRWRSHUDWHZLWKORZEDWWHU\YROWDJH
&KDQJH WKH EDWWHULHV EHIRUH WKH EDWWHULHV EHFRPH WRR
ZHDNIRUQRUPDORSHUDWLRQV
)LJXUH8VLQJWKH0RXQWLQJ%DVH
Power On Initialization
$IWHUWKHSRZHURQLQLWLDOL]DWLRQWKHWUDQVPLWWHUVHQGVDVLJQDO
WRWXUQRIIWKHVWRYH
43
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Troubleshooting
Signature Command System - Troubleshooting the Transmitter
Symptom
Causes
Action
Battery icon on LCD on transmitter
Low Battery
5HSODFHEDWWHULHV&KDQJHEDWWHULHVHYHU\
PRQWKV
LCD display is blank
Low Battery
Check battery installation or replace batteries
/&'GLVSOD\VKRZV³IXQQ\´GLVSOD\
Low Battery
5HVHWWKHWUDQVPLWWHU VHH³5HVHWWLQJWKH
7UDQVPLWWHU´VHWWLQJ
$SSOLDQFHGRHVQRWFRPHRQ
The transmitter did not match with the
UHFHLYHU
Make sure the transmitter has learned to the
UHFHLYHU
Transmitter measures temperature
H[FHHGLQJƒ)DQGVKRZV³+,´RQ/&'
Move transmitter to a cooler place and wait
XQWLOWHPSHUDWXUHGURSVEHORZƒ)
Distance between the transmitter and
receiver is more than 30 feet
0DNHVXUHWKHRSHQLQJGLVWDQFHLVOHVVWKDQ
IHHW
Blower is not on after the stove is turned
on
%ORZHUVHWWLQJLVRII
3UHVV)$1NH\WRVHOHFWIDQVSHHGGHVLUHG
%ORZHUGHOD\VHWWLQJLVVHWWRRKLJK
3UHVVDQGKROG)$1NH\WRVHWGHVLUHG21
2))GHOD\V7KLVLVGRQHLQPLQXWHV
General Troubleshooting
OPERATION
Install batteries and/or
plug in the AC board
FAULT
No beep in about
8 seconds
A
Using
battery?
Make sure
Command
Center and
the control
board are
connected by
a 2 feet or 15
feet cable
After the beep
Flip the master switch
(rocker switch) to the
ON position
Press the ON button on
the Command Center
No beep
or
no sound from the
valve indicating pilot
solenoid open
C
Sparking doesn’t
continue
D
Main burner doesn’t
light
44
B
No sparking on
the pilot
Pilot doesn’t light
ACTION
DIAGNOSIS
E
F
Check NG/LP
conversion cap
and control
board
connections
Check pilot
connections
Battery polarity wrong?
Re-install batteries
Battery voltage low?
Change batteries
AC plug is plugged to
AC mains?
Plug the AC plug to
AC mains
The 5-pin connector on
the AC board broken or
bent?
Repair or replace the
AC Board
LED on the Command
Center does not show
solid green?
Replace the AC Board
Check valve
connections
Check
grounding
Check power
supply (go
through A )
Replace the Control
Board or
Command Center
Go through
B
Sparking is happening
elsewhere (under the
pilot), re-install/replace
the pilot
The Control Board is having interference from the
surrounding metal (Ground)
Check gas supply
Go through E
Go through C
The sensor on the pilot
is not in the flame
(pilot flame too small)?
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
Re-install the Control
Board, move it around
or change the
Control Board
Sparking is not in the
path of gas flow, adjust
sparker position or
replace the pilot
Adjust sensor position
or replace the pilot
3-90-20306760
Burner, Pilot and Control Compartment
!
WARNING
7XUQRIIJDVEHIRUHVHUYLFLQJVWRYH,WLVUHFRPPHQGHGWKDW
DTXDOL¿HGVHUYLFHWHFKQLFLDQSHUIRUPWKHVHFKHFNXSVDW
WKHEHJLQQLQJRIHDFKKHDWLQJVHDVRQ
.HHS WKH FRQWURO FRPSDUWPHQW VWRQHV DQG EXUQHU DUHDV
VXUURXQGLQJWKHVWRQHVFOHDQE\YDFXXPLQJRUEUXVKLQJDW
OHDVWWZLFHD\HDU0DNHVXUHWKHEXUQHUSRUWLQJSLORWDLU
RSHQLQJDQGEXUQHUDLURSHQLQJDUHIUHHRIREVWUXFWLRQVDW
DOOWLPHV
Pilot Flame
7KH ÀDPHV IURP WKH SLORW VKRXOG EH YLVXDOO\ FKHFNHG DV
VRRQDVWKHKHDWHULVLQVWDOOHGDQGSHULRGLFDOO\GXULQJQRUPDO
RSHUDWLRQ7KHSLORWÀDPHPXVWDOZD\VEHSUHVHQWZKHQWKH
VWRYHLVLQRSHUDWLRQ)LJXUH7KHSLORWÀDPHKDVWKUHH
GLVWLQFWÀDPHVRQHHQJXO¿QJWKHVHQVRURQHHQJXO¿QJWKH
WKHUPRSLOHDQGWKHRWKHUUHDFKLQJWRWKHPDLQEXUQHU
Burner
,QVSHFWDUHDDURXQGWKHLQMHFWRU5HPRYHDQ\OLQWRUIRUHLJQ
PDWHULDOZLWKDEUXVKRUYDFXXP
Burner Flame
7KHÀDPHVIURPWKHEXUQHUVKRXOGEHYLVXDOO\FKHFNHGDV
VRRQDVWKHKHDWHULVLQVWDOOHGDQGSHULRGLFDOO\GXULQJQRUPDO
RSHUDWLRQ,QQRUPDORSHUDWLRQDWIXOOUDWHDQGDIWHURSHUDWLQJ
IRUDERXWWRPLQXWHVWKHÀDPHVKRXOGEH\HOORZ
,I WKH ÀDPH LV EOXH DQG FDQGOHOLNH LQ DSSHDUDQFH DGMXVW
JODVVRUDGGPRUHJODVVRYHUSRUWV
127(7KHW\SHRILQVWDOODWLRQYHQWV\VWHPFRQ¿JXUDWLRQ
DQGZLQGHIIHFWVPD\FDXVHWKHÀDPHSDWWHUQVWRYDU\
Sensor
Thermopile
)LJXUH3LORW)ODPH
45
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Valve Conversion - SDDVT Series Models
‡ 7XUQFRQWURONQREWRWKH2))SRVLWLRQDQGVKXWRIIWKH
JDVVXSSO\WRWKHYDOYH
Fuel conversion
WARNING
‡ $OORZWKHYDOYHWRFRROWRURRPWHPSHUDWXUH
‡ 5HPRYHWKHEODFNSURWHFWLRQFDSE\KDQG )LJXUH
,/
()
7KLVFRQYHUVLRQNLWVKDOOEHLQVWDOOHGE\DTXDOL¿HGVHUYLFH
DJHQF\LQDFFRUGDQFHZLWKWKHPDQXIDFWXUHU¶VLQVWUXFWLRQV
and all applicable codes and requirements of the authority
KDYLQJMXULVGLFWLRQ,IWKHLQIRUPDWLRQLQWKHVHLQVWUXFWLRQV
LVQRWIROORZHGH[DFWO\D¿UHH[SORVLRQRUSURGXFWLRQRI
FDUERQPRQR[LGHPD\UHVXOWFDXVLQJSURSHUW\GDPDJH
SHUVRQDOLQMXU\RUORVVRIOLIH7KHTXDOL¿HGVHUYLFHDJHQF\
LV UHVSRQVLEOH IRU WKH SURSHU LQVWDOODWLRQ RI WKLV NLW7KH
installation is not proper and complete until the operation
RIWKHFRQYHUWHGDSSOLDQFHLVFKHFNHGDVVSHFL¿HGLQWKH
PDQXIDFWXUHU¶VLQVWUXFWLRQVVXSSOLHGZLWKWKHNLW
()
!
,/
!
CAUTION
7KHJDVVXSSO\VKDOOEHVKXWRIISULRUWRGLVFRQQHFWLQJWKH
HOHFWULFDOSRZHUEHIRUHSURFHHGLQJZLWKWKHFRQYHUVLRQ
)LJXUH )LJXUH
)LJXUH
‡ ,QVHUWDRUPP$OOHQZUHQFKLQWRWKHKH[DJRQDONH\
ZD\RIWKHVFUHZ )LJXUH URWDWHLWFRXQWHUFORFNZLVH
XQWLOLWLVIUHHDQGH[WUDFWLW
•
Check that the screw is clean and if necessary remove
GLUW)OLSWKHVFUHZ )LJXUH
OFF
ON P
IL
NOTE: Do not over-tighten the screw. Recommended to
grip the wrench by the short side.
O H
PILOT
ADJ
L
I
O
T
‡ 8VLQJWKH$OOHQZUHQFKDVVKRZQLQ)LJXUHURWDWHWKH
VFUHZFORFNZLVHDQGWLJKWHQXQWLOVQXJ
*DV6XSSO\,QOHW
Main
*DV
Line
Shut
off
Valve
)LJXUH$WWDFKWKHJDVOLQHWRWKHULJKWVLGHRIWKHYDOYH
()
Conversion Precautions
%HIRUHSURFHHGLQJWXUQFRQWURONQRERQYDOYHWR2))DQG
WXUQJDVVXSSO\2))7XUQ2))DQ\HOHFWULFLW\WKDWPD\EH
JRLQJWRWKHDSSOLDQFH
()
,/
Conversion Procedure
‡ 5HPRYHVWRYHIURQW/LIWVWRYHIURQWXSDQGWKHQVZLQJ
ERWWRPRXWDQGDZD\WRGLVHQJDJHIURPWKHVWRYHERG\
‡ 8QGR WKH ULJKW DQG OHIW ODWFKHV DW WKH WRS RI WKH JODVV
IUDPH
,/
)LJXUH
)LJXUH
‡ 3XOOWKHWRSHGJHRIWKHJODVVDQGIUDPHDVVHPEO\DZD\
IURPWKH¿UHER[IDFH3ODFHWKHDVVHPEO\RXWRIWKHZD\
RQDÀDWSDGGHGVXUIDFHVXFKDVDFRXQWHUSURWHFWHGE\
DWRZHO
‡ 5HPRYHWKHORJVHWIURPWKH¿UHER[
46
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
9HULI\WKDWLIWKHFRQYHUVLRQLVIURP1*WR/3WKHVFUHZ
PXVWEHUHDVVHPEOHGZLWKWKHUHGRULQJYLVLEOH )LJXUH
77)
5HSODFHWKHEODFNSURWHFWLRQFDS
$OOHQZUHQFK
()
Natural Gas
Configuration
()
LP Configuration
,QGH[WDE
,/
,/
6QDSULQJ
5HG2ULQJ9LVLEOH
5HG2ULQJ1279LVLEOH
)LJXUH
)LJXUH5HPRYHSLORWRUL¿FH
NOTE: Check that also the pilot and main burner injectors
are appropriate for the gas type.
%XUQHU2UL¿FH&RQYHUVLRQ
3LORW2UL¿FH&RQYHUVLRQ
‡ /RFDWHSLORW )LJXUH
‡ 5HPRYH WKUHH QXWV RQ ERWWRP VLGH RI EXUQHU
SDQ )LJXUH
‡ &DUHIXOO\UHPRYHHPEHUEHGE\WLOWLQJWKHULJKWVLGHXS
DQGOLIWLQJRXWWRZDUGWKHULJKWVLGHRIWKHXQLW )LJXUH
‡ 5HSODFHSLORWRUL¿FH
‡ 5HPRYH SLORW KRRG E\ OLIWLQJ XS )LJXUH 'R QRW
UHPRYHWKHVQDSULQJWRUHPRYHWKHSLORWKRRG
Bottom View
5HPRYH1XW
NOTE: It is not necessary to remove the pilot tube for
conversion.
‡ 5HPRYHSLORWRUL¿FHZLWKDDOOHQZUHQFK )LJXUH
‡ ,QVWDOOWKHFRQYHUVLRQRUL¿FH
‡ 5HLQVWDOOSLORWKRRG%HVXUHWRDOLJQKRRGZLWKLQGH[WDE
Pilot
5HPRYH1XWV
Figure 815HPRYHWKUHH QXWVVHFXULQJHPEHUEHGLQSODFH
2UL¿FH
Bracket
Venturi Bracket
)LJXUH/RFDWHSLORW
Pilot hood
Pilot bracket
Pem Studs
Figure 827LOWHPEHUEHGVOLJKWO\WRFRUUHFWO\SODFHRQYHQWXULDQG
DLUVKXWWHU
)LJXUH5HPRYHSLORWKRRG
47
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
‡ 5HPRYH LQMHFWRU RUL¿FH IURP OHIW EXUQHU EUDFNHW ZLWK D
ZUHQFK8VHDEDFNXSZUHQFKWRSUHYHQWGDPDJH
WRWKHPDQLIROG )LJXUH
‡ ,QVWDOOFRQYHUVLRQRUL¿FH 5HIHUWR7DEOH
‡ 7KH DLU VKXWWHU LV IDFWRU\ VHW DFFRUGLQJ WR 7DEOH DQG
VKRXOG QRW QHHG DGMXVWPHQW 7KH DLU VKXWWHU RSHQLQJ
PD\EHYHUL¿HGE\PHDVXULQJDVVKRZQLQ)LJXUH
)LJXUH8VHWZRZUHQFKHVWRDYRLGGDPDJHWRPDQLIROG
2UL¿FH
Bracket
2UL¿FH
$LU6KXWWHU
)LJXUH7KHDLUVKXWWHUVHWWLQJLV PP IURPWKHRUL¿FH
EUDFNHWWRWKHHGJHRIWKHDLUVKXWWHU
48
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
SDVTSC Models
‡ 8VLQJ7RU[7GULYHURUVORWWHGVFUHZGULYHUUHPRYHDQG
GLVFDUGWKHUHJXODWRUDQGUXEEHUJDVNHWLQWKHIDFHRIWKH
YDOYH )LJXUH ‡ ,QVWDOO WKH QHZ UHJXODWRU ZLWK UXEEHU JDVNHW IURP WKH
FRQYHUVLRQNLW0DNHVXUHWKHJDVNHWLVVHDWHGSURSHUO\
‡ /RRVHQ WKH SLORH ¿WWLQJ DW WKH EDVH RI WKH SLORWH XVLQJ
D ZUHQFK 5HPRYH WKH H[LVWLQJ SLORW RUL¿FH DQG
UHSODFH ZLWK WKH SLORW RUL¿FH VKLSSHG ZLWK VWRYH XVLQJ
D ÀDW KHDG VFUHZ GULYHU :KHQ UHSODFLQJ WKH SLORW IRU
VHUYLFHSXUSRVHUHSODFHWKHHQWLUHSLORW
‡ &RQYHUW WKH FRQWURO ER[ E\ XVLQJ D VPDOO ÀDW KHDG
VFUHZGULYHU/LIWWKHFRQYHUVLRQFDSIURPWKHFRQWUROER[
DQGUHSODFHZLWKQHZRQHPDUNHG/3%HVXUHWRSODFH
FRUUHFWO\)LJXUH
All Models
5HSODFH EXUQHU PDNLQJ VXUH YHQWXUL RQ ERWWRP RI HPEHU
EHGDOLJQVZLWKRUL¿FHDQGLVVHDWHGSURSHUO\RQDLUVKXWWHU
DVVHPEO\0DNHVXUHEXUQHULVVOLGLQWRSODFHDWDVOLJKWDQJOH
DQGRSSRVLWHWRKRZLWZDVUHPRYHG:KHQEXUQHULVVOLGLQWR
SODFH WKH WKUHH SHP VWXGV VKRXOG VOLGH GRZQ WKURXJK
FOHDUDQFHKROHVLQWRWKHERWWRPRIWKHFRQWUROSDQHO
7KUHDG DQG WLJKWHQ ´ QXWV EDFN RQWR SHP VWXGV RQ
XQGHUQHDWK VLGH RI FRQWURO SDQHO UHYHUVLQJ 6WHS VKRZQ
LQ)LJXUH
5HIHUWR/RJ,QVWDOODWLRQVHFWLRQRIWKLVPDQXDOWRUHLQVWDOO
ORJV
3ODFHFRQYHUVLRQODEHOVXSSOLHGZLWKNLWRQUDWLQJSODWH
5HSODFHJODVVDQGVWRYHIURQW
5HVWRUH JDV WR V\VWHP DQG UHOLJKW DSSOLDQFH DFFRUGLQJ WR
/LJKWLQJ,QVWUXFWLRQVRQSDJH 6''97PRGHOV RUSDJH
6'976&PRGHOV /HDNFKHFNWKHV\VWHPXVLQJDJDVOHDNGHWHFWRUVROXWLRQ
5HJXODWRU
5HOLJKWWKHPDLQEXUQHULQERWKWKH³+,´DQG³/2´SRVLWLRQV
WRYHULI\SURSHUEXUQHULJQLWLRQDQGRSHUDWLRQ
&RQYHUVLRQLVFRPSOHWH
5XEEHUJDVNHW
Figure 859DOYH5HJXODWRU
Figure 86&RQYHUW&RQWURO%R[
49
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
7DEOH,QMHFWRU2UL¿FH6L]H0DWUL[
Conversion to LP*
Input (BTU/h)
Model
.LW
SDDVT
.
SDVTSC
4604-011
2UL¿FH
3DUW
Minimum
0D[LPXP
PP
20308650
21,000
25,000
Conversion to Natural Gas
Input (BTU/h)
.LW
Model
SDDVT
4604-012
SDVTSC
4604-013
2UL¿FH
3DUW
Minimum
0D[LPXP
PP
4604-316
20,000
28,000
7DEOH$LU6KXWWHU$GMXVWPHQW
Model
1DWXUDO*DV
1DWXUDO*DV
+LJK$OWLWXGH
LP
6''976'976&
2SHQ
´2SHQ
´2SHQ
/3PRGHOVGRQRWQHHGUHRUL¿FHGXSWR¶ P DERYHVHDOHYHO
50
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Cleaning & Maintenance
<RXU6WDUGDQFH*DVKHDWHUZLOOSURYLGH\HDUVRIVHUYLFHZLWK
PLQLPDOXSNHHS7KHIROORZLQJSURFHGXUHVZLOOKHOSHQVXUH
WKDW\RXUVWRYHFRQWLQXHVWRIXQFWLRQSURSHUO\
Annual System Inspection
+DYHWKHHQWLUHKHDWHUDQGYHQWLQJV\VWHPLQVSHFWHGDQQXDOO\
E\DTXDOL¿HGJDVWHFKQLFLDQ5HSODFHDQ\ZRUQRUEURNHQ
SDUWV
Logset and Burner / Cleaning and Inspection
&OHDQOLQHVV LV FULWLFDO WR WKH SURSHU IXQFWLRQ RI WKH KHDWHU
7KH ORJVHW DQG EXUQHU PXVW DOO EH NHSW IUHH RI GXVW DQG
XQREVWUXFWHGE\GHEULV,QVSHFWWKHVHDUHDVEHIRUHHDFKXVH
DQGFOHDQDVQHFHVVDU\
7XUQWKHEXUQHU2))DQGOHWWKHKHDWHUFRROFRPSOHWHO\
EHIRUHFOHDQLQJ
Remove the safety barrier and lift the stove front up and
WKHQVZLQJWKHERWWRPRXWWRGLVHQJDJHLWIURPWKHKHDWHU
VKHOO )LJXUH
&DUHIXOO\ UHPRYH WKH JODVV DQG IUDPH DVVHPEO\ DQG
SODFHLWRXWRIWKHZD\RQDÀDWSDGGHGVXUIDFHVXFKDV
DFRXQWHUSURWHFWHGE\DWRZHO
Cleaning the Glass
,WZLOOEHQHFHVVDU\WRFOHDQWKHJODVVSHULRGLFDOO\'XULQJ
start-up, condensation, which is normal, forms on the inside of
WKHJODVVDQGFDXVHVOLQWGXVWDQGRWKHUDLUERUQHSDUWLFOHVWR
FOLQJWRWKHJODVVVXUIDFH$OVRLQLWLDOSDLQWFXULQJPD\GHSRVLW
DVOLJKW¿OPRQWKHJODVV,WLVWKHUHIRUHUHFRPPHQGHGWKDW
WKHJODVVEHFOHDQHGWZRRUWKUHHWLPHVZLWKDQRQDPPRQLD
KRXVHKROG FOHDQHU DQG ZDUP ZDWHU ZH UHFRPPHQG JDV
VWRYHJODVVFOHDQHU $IWHUWKDWWKHJODVVVKRXOGEHFOHDQHG
WZRRUWKUHHWLPHVGXULQJHDFKKHDWLQJVHDVRQGHSHQGLQJ
RQWKHFLUFXPVWDQFHVSUHVHQW
127(&OHDQJODVVDIWHU¿UVWWZRZHHNVRIRSHUDWLRQ
!
WARNING
$OORZWKHJODVVWRFRROFRPSOHWHO\EHIRUHDWWHPSWLQJWR
FOHDQ
DANGER
&DUHIXOO\ LQVSHFW WKH /RJV IRU GDPDJH &RQWDFW \RXU
ORFDOGHDOHULIDQ\GDPDJHLVHYLGHQW
HOT GLASS WILL
CAUSE BURNS.
8VHDVRIWEULVWOHGEUXVKWRVZHHSGXVWRUGHEULVIURPWKH
/RJV3LORWDQG%XUQHU8VHFDUHDVWKHORJVDUHIUDJLOH
DQGVXVFHSWLEOHWRGDPDJH
DO NOT TOUCH GLASS
UNTIL COOLED.
5HSODFHWKHJODVVSDQHODQGIUDPHDVVHPEO\
5HSODFHWKHVWRYHIURQWDQGVDIHW\EDUULHU
Care of Cast Iron
$QRFFDVLRQDOGXVWLQJZLWKDGU\UDJZLOOKHOSNHHSWKHSDLQWHG
VXUIDFHV ORRNLQJ QHZ 8VH KLJKWHPSHUDWXUH VWRYH SDLQWV
DYDLODEOH WKURXJK \RXU ORFDO GHDOHU WR WRXFKXS DUHDV DV
QHHGHG&OHDQDUHDVWREHSDLQWHGZLWKDZLUHEUXVKDQGEH
VXUHWRFRYHUWKHORJVEXUQHUDQGYDOYHDVVHPEO\JODVVDQG
IUDPHDVVHPEO\$SSO\WKHSDLQWVSDULQJO\WZROLJKWFRDWVRI
SDLQWZLOOJLYHEHWWHUUHVXOWVWKDQDVLQJOHKHDY\FRDW
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this
appliance and shall be installed.
&OHDQ SRUFHODLQ HQDPHO VXUIDFHV ZLWK D VRIW GDPS FORWK
'RQRWXVHDEUDVLYHFOHDQLQJDJHQWV,IQHFHVVDU\XVHRQO\
DFOHDQLQJDJHQWIRUPXODWHGHVSHFLDOO\IRUXVHRQSRUFHODLQ
HQDPHOVXUIDFHV
!
CAUTION
7XUQWKHSLORWRIIEHIRUHSDLQWLQJ$OORZWKHKHDWHUWRFRRO
FRPSOHWHO\EHIRUHSDLQWLQJ
51
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Glass Replacement
5HSODFH JODVV RQO\ ZLWK ++7 DSSURYHG SDUWV 5HIHU WR
5HSODFHPHQW3DUWVVHFWLRQIRUFRUUHFWJODVV5HIHUWR)LJXUHV
87 and 88 and previous instructions for removal of the
GDPDJHGJODVVIUDPH
6WDUWLQJRQDORQJHGJHUHPRYHDERXWRIWKHSURWHFWLYH
SDSHUVWULSDQGDSSO\WKHÀDWDGKHVLYHIDFHRIWKHJDVNHW
DURXQG WKH RXWVLGHIDFLQJ HGJH RI WKH SDQHO &RQWLQXH
DURXQGWKHSDQHODSSO\LQJDERXWDWDWLPHDQGEHLQJ
FDUHIXO WR QRW VWUHWFK WKH PDWHULDO 'R QRW RYHUODS WKH
JDVNHWHQGV )LJXUH
$SSO\ D WKLQ EHDG RI KLJK WHPSHUDWXUH VLOLFRQH UXEEHU
VHDODQW DORQJ WKH LQVLGH FRUQHU RI WKH JODVV IUDPH DOO
DURXQGWKHSHULPHWHU3ODFHWKHÀDWJDVNHWHGVLGHRIWKH
JODVVSDQHOEDFNLQWRWKHVWHHOIUDPH3LQFKWKHURXQGHG
LQVLGHIDFLQJJDVNHWPDWHULDOWREXONLWXS
5HSODFH WKH JODVV IUDPH DQG IURQW SDQHO DV SUHYLRXVO\
GHVFULEHG
)LJXUH5HPRYHWKHVWRYHIURQW
)LJXUH:UDSWKHJDVNHWPDWHULDODURXQGWKHRXWVLGHHGJHRIWKHJODVV
Inspect the Vent System Annually
+DYH WKH YHQW V\VWHP LQVSHFWHG DQQXDOO\ E\ D TXDOL¿HG
WHFKQLFLDQ6KXWRIIWKHPDLQJDVVXSSO\EHIRUHLQVSHFWLQJ
WKH V\VWHP %RWK WKH LQQHU H[KDXVW SLSH DQG WKH RXWHU
FRPEXVWLRQ VXSSO\ SLSH PXVW EH FKHFNHG WR FRQ¿UP WKDW
WKH\DUHXQEORFNHGDQGLQJRRGFRQGLWLRQ
Check the Gas Flame Regularly
7R HQVXUH WKDW WKH VWRYH LV RSHUDWLQJ SURSHUO\ FKHFN WKH
ÀDPHV SHULRGLFDOO\ WR FRQ¿UP WKH\ PDWFK )LJXUH 7KH
ÀDPHVZLOOEHEOXHGXULQJWKH¿UVWPLQXWHVRIRSHUDWLRQ
DQGZLOOJUDGXDOO\WXUQWR\HOORZDIWHUWKDW
)LJXUH5HOHDVHWKHODWFKHVWRUHPRYHWKHJODVVIUDPH
Gasket Replacement
7KH6WDUGDQFH*DVKHDWHUXVHVDµWDGSROH¶W\SHJDVNHWWR
VHDO EHWZHHQ WKH JODVV SDQHO DQG WKH IUDPH ,Q WLPH WKLV
JDVNHWFDQEHFRPHEULWWOHDQGFRPSUHVVHGDQGVKRXOGEH
UHSODFHG1HZJDVNHWLVDYDLODEOHIURP\RXUGHDOHU
'RQRWXVH\RXUVWRYHLIWKHÀDPHSDWWHUQGLIIHUVIURPWKDW
VKRZQ KHUH &RQWDFW \RXU 9HUPRQW &DVWLQJV GHDOHU RU D
TXDOL¿HGWHFKQLFLDQIRUKHOS
6KXWRIIWKHJDVVXSSO\DQGDOORZWKHVWRYHWRFRRO:HDU
VDIHW\JRJJOHVDQGDGXVWPDVN
5HPRYH WKH )URQW *ODVV )UDPH DQG *ODVV 3DQHO
)LJXUHV 5HPRYHWKHROGJDVNHW8VHDUD]RU
EODGHWRVHSDUDWHWKHJODVVDQGJDVNHWIURPWKHIUDPH
DQGWRFOHDQWKHJODVVRIDQ\UHPDLQLQJFHPHQWRUELWVRI
JDVNHW8VHDFROGFKLVHOLIQHFHVVDU\
'HWHUPLQH WKH FRUUHFW OHQJWK RI JDVNHW E\ OD\LQJ LW RXW
DURXQGWKHHGJHRIWKHJODVV$OORZDQH[WUD± PP 0DUNWKHVSRWWREHFXW8VHDXWLOLW\NQLIH
52
)LJXUH3URSHUÀDPHDSSHDUDQFH
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Wiring Diagrams – SDDVT
Optional Blower Kit Wiring Diagram
OFF
On/Off Switch Wiring
ON
FAN
TP/TH
Thermopile
Black
POWER
CORD
BLK
WHT
BL
TP
K
Black
TH
Chassis
Ground
Thermostat
(Optional)
BL
K
BLK
FAN JUNCTION BOX
Thermopile
Black
Optional Thermostat Wiring
TP/TH
GRN
Strain Relief
ON / OFF
Rheostat
TP
TH
Black
Snapstat
)LJXUH2QRIIVZLWFKDQGRSWLRQDOWKHUPRVWDWFLUFXLW
WHT
LK
NOTE: If any of the original wire, as supplied with the
appliance, must be replaced, it must be replaced with
W\SH6)ƒ&ZLUHRULWVHTXLYDOHQW
B
BLK
GRN
Chassis Ground
RHEOSTAT / SNAPSTAT
BOX
Optional Blower Kit Schematic Diagram
BLK
BLK
MOTOR
BLK
WHT
GRN
WHT
BLK
SNAPSTAT
ON/OFF
RHEOSTAT
)LJXUH)DQFLUFXLW
53
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Pilot
A/C MODULE
Opt. Blower
Opt. Aux.
WHITE
BLACK
BLACK
WHITE
PLUG-IN
CONNECTOR
TO JUNCTION BOX
IN FIREPLACE
RF Receiver
ON/OFF Button
GREEN
300 Watt
Max.
Control Board
Black / Thermopile
Red / Thermopile
Sensor
Conversion
NG/LP
Ignitor / Sparker
Plug-in Connector
Control Board to Command Center
NOTE: Wall switch wires
must be connected together
if a wall switch is not being used.
OFF/LO
Plug-in Connector
Stepper Motor to
Control Board
Ground
LED
ON/HI
Master Switch
Command Center
Optional
Wall Switch
DC Power/Green
Plug-in Connector
Control Board to
Solenoid
Gas Out
Gas In
Pilot Gas Tubing
Valve
)LJXUH6LJQDWXUH&RPPDQG:LULQJ'LDJUDP
To Junction Box
In Fireplace
Light
{
WHITE
BLACK
Optional
AUX
{
WHITE
BLACK
BLACK
WHITE
GREEN
Connector
Pin To Control Box
)LJXUH%ORZHU:LULQJ'LDJUDP
54
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Service Parts List
STARDANCE
Service Parts
Beginning Manufacturing Date: NA
Ending Manufacturing Date: Active
Direct Vent Gas Heater
Active Skus
Retired Skus
SDVTSCCB (Classic Black)
SDDVTCBSB (Classic Black)
SDDVTCSCBSB (Classic Black) - End Manufacturing Date: October 2015
SDVTSCBS (Biscuit)
SDDVTBSSB (Biscuit)
SDDVTCSBSSB (Biscuit) - End Manufacturing Date: October 2015
SDVTSCBM (Majolica Brown)
SDDVTBMSB (Majolica Brown)
SDDVTCSBMSB (Majolica Brown) - End Manufacturing Date: October 2015
SDVTSCBD (Bordeaux)
SDDVTBDSB (Bordeaux)
SDDVTCSBDSB (Bordeaux) - End Manufacturing Date: October 2015
2
1
6
5
1.1
4
1.3
1.4
3
1.2
14
11
12
10
8
7
15
16
13
9
17
18
24
25
36
31
27
26
33
35
28
30
34
32
41
37
29
20 21
19
22
40
39
38
42
23
Part number list on following page.
55
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
11/18
3-90-20306760
STARDANCE
Service Parts
Beginning Manufacturing Date: NA
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor.
Hearth and Home Technologies does not sell directly to consumers. Provide model number
and serial number when requesting service parts from your dealer or distributor.
ITEM
DESCRIPTION
COMMENTS
Stocked
at Depot
PART NUMBER
Log Set, Complete
20012551
1.1
Log, Rear
20012546
1.2
Log, Right
20012548
1.3
Log, Left
20012547
1.4
Log, Top
20012915
Ember Bed Assembly
20012492
1
2
3
4
5
6
7
8
Top
Front, Operable Door
Door, Right (Use Magnet)
(Pre 7/2007 units must order Left and Rigth together)
Door, Left (Use Magnet)
(Pre 7/2007 units must order Left and Rigth together)
End, Left
End, Right
Classic Black
30001276A
Biscuit
30003305
Bordeaux
30006752
Brown Majolica
30004897
Classic Black
30001496A
Biscuit
30003302
Bordeaux
30006753
Brown Majolica
30004899
Classic Black
30004081A
Biscuit
30004089
Bordeaux
30006754
Brown Majolica
30004901
Classic Black
30004082A
Biscuit
30004090
Bordeaux
30006755
Brown Majolica
30004900
Classic Black
30001280A
Biscuit
30003300
Bordeaux
30006750
Brown Majolica
30004895
Classic Black
30001279A
Biscuit
30003301
Bordeaux
30006751
Brown Majolica
30004896
Y
Y
9
Door, Control
1301087A
10
Glass Frame Assembly
30000127
Y
11
Glass
1601691
Y
12
Gasket, Glass (Medium Knit)
1203702K
13
Nut, Hex Jam 3/8-16 TOPLK-Z
14
Pawl Assembly, Ash Door
30002362
15
Front Steel Handle/Shaft - NI/VER
30002717
Pkg of 10
1203290-10
Y
Additional service parts on following page
56
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
STARDANCE
Service Parts
Beginning Manufacturing Date: NA
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor.
Hearth and Home Technologies does not sell directly to consumers. Provide model number
and serial number when requesting service parts from your dealer or distributor.
ITEM
DESCRIPTION
16
Restrictor Plate
17
Fan Blower
18
Valve, Nova SIT 820.852 RN
19
Pilot Assembly 3 Way (SDDVT)
COMMENTS
Stocked
at Depot
PART NUMBER
20013026
SDVTSC Series Only
20308374
SDDVT Series Only
FK26
SDDVT Series Only
20012218
Y
N/DV RN 0.199.706
SRV10002264
Y
N/DV RP 0.199.703
SRV10002265
Y
Y
20
Thermocouple, 24”
SRV24D0808
21
Electrode Ignitor w/Cable SIT24
10001297
22
Thermopile, 18” RS
SRV26D0566
Y
23
Tubing Pilot w/Fittings 1/8 x 24”
26D0665
Y
24
Pilot Ori¿ce, Top Convertible
25
Ori¿ce Hood
26
Ignitor Piezo w/Nut SIT
Bracket, Piezo Ignitor Control
27
Manifold Assembly
28
Air Shutter Assembly
29
30
SDDVT NG, #62
37D0022
SDDVT LP, #35
SRV200-2630
NG, 2.4 mm
4604-316
LP, 1.45 mm
20308650
SDDVT Series Only
SDVTSC Series Only
057958A
Y
Y
20300111K
20012553
Y
20012517
Trim On/Off Switch
SDDVT Series Only
30000874
Y
Sensor1450 CMG-8184-0032
Only for FSDHAG
10002013
Y
31
Wiring Harness
SDDVT Series Only
10002582
Y
32
Gasket, Base Pan
20002282
Y
33
Gasket HE Door
1203687A
Y
34
Tie Bracket Assembly
20012514
35
Safety Screen Barrier
30007254
36
Right Burner Support Assembly
20012512
37
Remote Transmitter (Full function)
SDVTSC Series Only
TSFSC
38
Command Center
SDVTSC Series Only
SRV80D0005
Y
39
Gas Valve Assembly, SDVTSC Series Only
NG
SRV80D0001
Y
40
Control Box, SDVTSC Series Only
Y
LP
SRV80D0002
Y
NG
SRV80D0018
Y
LP
SRV80D0019
Y
41
AC Module SCS w/8’ Power Cord
SDVTSC Series Only
3007360
42
Pilot Assembly
SDVTSC Series Only
20308981
Y
30004175K
Y
Handle Package w/Screw
Switch Bracket
Wood
53821K
Additional service parts on following page
57
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
STARDANCE
Service Parts
Beginning Manufacturing Date: NA
Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor.
Hearth and Home Technologies does not sell directly to consumers. Provide model number
and serial number when requesting service parts from your dealer or distributor.
ITEM
DESCRIPTION
COMMENTS
Starter Pipe
Stocked
at Depot
PART NUMBER
20307738K
Rear Shroud
SDVT, SC/SDDVT
Rear Shroud Assembly
SDDVTCS
Fiberglass Gasket, 1/4”
20003802
20300122
1-00-1203560
Use super glue/Silicone
to attach
Magnet, Door
Touch-Up Paint
Y
30004112
Classic Black
3-42-19905
Bordeaux
0001341
Biscuit
0001277
Majolica
0001270
Wire Valve/Control
SDVTSC Series Only
SRV80D0010
Wire AC Module
SDVTSC Series Only
SRV80D0009
Wire Command Center
SDVTSC Series Only
80D0008
Cover, Vanity Control
20308405K
Control Plate Assembly (Burner, Valve, Pilot, Comm. Center)
20308376K
Control Plate Assembly (Burner, Valve, Pilot)
20012493
Y
Y
Conversion Kits
Conversion Kit, NG to LP
Conversion Kit, LP to NG
Conversion Kit, NG to LP
Conversion Kit, LP to NG
58
SDDVT
SDVTSC
20012735K
Y
4604-012
Y
4604-011
Y
4604-013
Y
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Optional Accessories
FK26 Fan Kits – SDDVT Series
7KH).IDQKHOSVGLVWULEXWHKHDWHGDLUIURPZLWKLQWKH¿UHER[
RXWLQWRWKHURRP7KHIDQLVFRQWUROOHGE\DVQDSVWDWWKDW
WXUQVSRZHURQDQGRIIDVWKH¿UHER[WHPSHUDWXUHULVHVDERYH
DQGIDOOVEHORZDSUHVHWWHPSHUDWXUH$UKHRVWDWSURYLGHVIRU
YDULDEOHIDQVSHHGV8VHGZLWKVWDQGDUGPLOOLYROWPRGHOV
6SHFL¿FDWLRQV
9ROW+]$PSV
Maintenance
7KHIDQLWVHOIGRHVQRWUHTXLUHUHJXODUPDLQWHQDQFHKRZHYHU
SHULRGLF FOHDQLQJ RI WKH IDQ DQG WKH VXUURXQGLQJ DUHD LV
UHTXLUHG
Remote Controls – SDDVT
The remote control allows you to turn the heater on or off
IURP DQ\ZKHUH LQ WKH URRP 5HIHU WR 3DJH IRU ZLULQJ
GLDJUDPV7KHVHUHPRWHFRQWUROVDUHIRUXVHZLWKVWDQGDUG
PLOOLYROWPRGHOV
ON/OFF Remotes
RCB,RCMT
59
Warming Shelf
:DUPLQJVKHOYHVDGGYHUVDWLOLW\WR\RXUVWRYHWKH\FDQEH
XVHGWRNHHSIRRGVZDUPDWPHDOWLPH
Model
2702
2684
Color
Classic Black
%URZQ0DMROLFD
Biscuit
%RUGHDX[
Shelf Installation
$WWDFKWKHVKHOIORRVHO\WRWKHVWRYHOHDYLQJWKHVFUHZV
ORRVHHQRXJKWRDOORZ¿QDODGMXVWPHQWV
3RVLWLRQWKHVKHOIDQGDGMXVWWKHEUDFNHWVVRWKHVKHOI¿WV
FRUUHFWO\
7LJKWHQWKHVFUHZV
5HIHUWRWKHLQVWUXFWLRQVLQFOXGHGZLWKHDFKZDUPLQJVKHOI
IRUFRPSOHWHLQVWDOODWLRQSURFHGXUHV
ON/OFF Thermostat Remote
TSST, RCST
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
Hearth & Home Technologies
LIMITED LIFETIME WARRANTY
Hearth & Home Technologies, on behalf of its hearth brands (“HHT”), extends the following warranty for HHT gas, wood, pellet and
electric hearth appliances that are purchased from an HHT authorized dealer.
WARRANTY COVERAGE:
,,dǁĂƌƌĂŶƚƐƚŽƚŚĞŽƌŝŐŝŶĂůŽǁŶĞƌŽĨƚŚĞ,,dĂƉƉůŝĂŶĐĞĂƚƚŚĞƐŝƚĞŽĨŝŶƐƚĂůůĂƟŽŶ͕ĂŶĚƚŽĂŶLJƚƌĂŶƐĨĞƌĞĞƚĂŬŝŶŐŽǁŶĞƌƐŚŝƉŽĨƚŚĞ
ĂƉƉůŝĂŶĐĞĂƚƚŚĞƐŝƚĞŽĨŝŶƐƚĂůůĂƟŽŶǁŝƚŚŝŶƚǁŽLJĞĂƌƐĨŽůůŽǁŝŶŐƚŚĞĚĂƚĞŽĨŽƌŝŐŝŶĂůƉƵƌĐŚĂƐĞ͕ƚŚĂƚƚŚĞ,,dĂƉƉůŝĂŶĐĞǁŝůůďĞĨƌĞĞĨƌŽŵ
ĚĞĨĞĐƚƐŝŶŵĂƚĞƌŝĂůƐĂŶĚǁŽƌŬŵĂŶƐŚŝƉĂƚƚŚĞƟŵĞŽĨŵĂŶƵĨĂĐƚƵƌĞ͘ŌĞƌŝŶƐƚĂůůĂƟŽŶ͕ŝĨĐŽǀĞƌĞĚĐŽŵƉŽŶĞŶƚƐŵĂŶƵĨĂĐƚƵƌĞĚďLJ,,d
ĂƌĞĨŽƵŶĚƚŽďĞĚĞĨĞĐƟǀĞŝŶŵĂƚĞƌŝĂůƐŽƌǁŽƌŬŵĂŶƐŚŝƉĚƵƌŝŶŐƚŚĞĂƉƉůŝĐĂďůĞǁĂƌƌĂŶƚLJƉĞƌŝŽĚ͕,,dǁŝůů͕ĂƚŝƚƐŽƉƟŽŶ͕ƌĞƉĂŝƌŽƌƌĞƉůĂĐĞ
ƚŚĞĐŽǀĞƌĞĚĐŽŵƉŽŶĞŶƚƐ͘,,d͕ĂƚŝƚƐŽǁŶĚŝƐĐƌĞƟŽŶ͕ŵĂLJĨƵůůLJĚŝƐĐŚĂƌŐĞĂůůŽĨŝƚƐŽďůŝŐĂƟŽŶƐƵŶĚĞƌƐƵĐŚǁĂƌƌĂŶƟĞƐďLJƌĞƉůĂĐŝŶŐƚŚĞ
ƉƌŽĚƵĐƚŝƚƐĞůĨŽƌƌĞĨƵŶĚŝŶŐƚŚĞǀĞƌŝĮĞĚƉƵƌĐŚĂƐĞƉƌŝĐĞŽĨƚŚĞƉƌŽĚƵĐƚŝƚƐĞůĨ͘dŚĞŵĂdžŝŵƵŵĂŵŽƵŶƚƌĞĐŽǀĞƌĂďůĞƵŶĚĞƌƚŚŝƐǁĂƌƌĂŶƚLJ
ŝƐůŝŵŝƚĞĚƚŽƚŚĞƉƵƌĐŚĂƐĞƉƌŝĐĞŽĨƚŚĞƉƌŽĚƵĐƚ͘dŚŝƐǁĂƌƌĂŶƚLJŝƐƐƵďũĞĐƚƚŽĐŽŶĚŝƟŽŶƐ͕ĞdžĐůƵƐŝŽŶƐĂŶĚůŝŵŝƚĂƟŽŶƐĂƐĚĞƐĐƌŝďĞĚďĞůŽǁ͘
WARRANTY PERIOD:
tĂƌƌĂŶƚLJĐŽǀĞƌĂŐĞĨŽƌĐŽŶƐƵŵĞƌƐďĞŐŝŶƐĂƚƚŚĞĚĂƚĞŽĨŝŶƐƚĂůůĂƟŽŶ͘/ŶƚŚĞĐĂƐĞŽĨŶĞǁŚŽŵĞĐŽŶƐƚƌƵĐƟŽŶ͕ǁĂƌƌĂŶƚLJĐŽǀĞƌĂŐĞďĞŐŝŶƐ
ŽŶƚŚĞĚĂƚĞŽĨĮƌƐƚŽĐĐƵƉĂŶĐLJŽĨƚŚĞĚǁĞůůŝŶŐŽƌƐŝdžŵŽŶƚŚƐĂŌĞƌƚŚĞƐĂůĞŽĨƚŚĞƉƌŽĚƵĐƚďLJĂŶŝŶĚĞƉĞŶĚĞŶƚ͕ĂƵƚŚŽƌŝnjĞĚ,,dĚĞĂůĞƌͬ
ĚŝƐƚƌŝďƵƚŽƌ͕ǁŚŝĐŚĞǀĞƌŽĐĐƵƌƐĞĂƌůŝĞƌ͘,ŽǁĞǀĞƌ͕ƚŚĞǁĂƌƌĂŶƚLJƐŚĂůůĐŽŵŵĞŶĐĞŶŽůĂƚĞƌƚŚĂŶϮϰŵŽŶƚŚƐĨŽůůŽǁŝŶŐƚŚĞĚĂƚĞŽĨƉƌŽĚƵĐƚ
ƐŚŝƉŵĞŶƚĨƌŽŵ,,d͕ƌĞŐĂƌĚůĞƐƐŽĨƚŚĞŝŶƐƚĂůůĂƟŽŶŽƌŽĐĐƵƉĂŶĐLJĚĂƚĞ͘dŚĞǁĂƌƌĂŶƚLJƉĞƌŝŽĚĨŽƌƉĂƌƚƐĂŶĚůĂďŽƌĨŽƌĐŽǀĞƌĞĚĐŽŵƉŽŶĞŶƚƐ
is produced in the following table.
dŚĞƚĞƌŵ͞>ŝŵŝƚĞĚ>ŝĨĞƟŵĞ͟ŝŶƚŚĞƚĂďůĞďĞůŽǁŝƐĚĞĮŶĞĚĂƐ͗ϮϬLJĞĂƌƐĨƌŽŵƚŚĞďĞŐŝŶŶŝŶŐĚĂƚĞŽĨǁĂƌƌĂŶƚLJĐŽǀĞƌĂŐĞĨŽƌŐĂƐĂƉƉůŝĂŶĐĞƐ͕
ĂŶĚϭϬLJĞĂƌƐĨƌŽŵƚŚĞďĞŐŝŶŶŝŶŐĚĂƚĞŽĨǁĂƌƌĂŶƚLJĐŽǀĞƌĂŐĞĨŽƌǁŽŽĚĂŶĚƉĞůůĞƚĂƉƉůŝĂŶĐĞƐ͘dŚĞƐĞƟŵĞƉĞƌŝŽĚƐƌĞŇĞĐƚƚŚĞŵŝŶŝŵƵŵ
ĞdžƉĞĐƚĞĚƵƐĞĨƵůůŝǀĞƐŽĨƚŚĞĚĞƐŝŐŶĂƚĞĚĐŽŵƉŽŶĞŶƚƐƵŶĚĞƌŶŽƌŵĂůŽƉĞƌĂƟŶŐĐŽŶĚŝƟŽŶƐ͘
Warranty Period
Parts
Labor
1 Year
2 years
HHT Manufactured Appliances and Venting
Gas
Pellet
Wood
Electric
Venting
Components Covered
X
X
X
X
x
All parts and material except as covered by
Conditions, Exclusions, and Limitations listed
X
X
Igniters, auger motors, electronic components, and
glass
X
X
Factory-installed blowers
X
Molded refractory panels
X
Ignition Modules
X
3 years
Firepots, burnpots, mechanical feeders/auger
assemblies
X
Vent Free burners, Vent Free ceramic fiber logs,
Aluminized Burners
X
5 years
1 year
X
X
Castings and Baffles
X
Catalyst - limitations listed
X
Manifold tubes, HHT chimney and termination
6 years
3 years
7 years
3 years
10 years
1 year
X
Limited
Lifetime
3 years
X
X
X
X
X
X
90 Days
X
Burners, logs and refractory
Firebox and heat exchanger, Grate and Stainless
Steel Burners, FlexBurnΠ System (engine, inner
cover,access cover and fireback)
X
X
All replacement parts beyond warranty period
WARRANTY CONDITIONS:
ͻ dŚŝƐ ǁĂƌƌĂŶƚLJ ŽŶůLJ ĐŽǀĞƌƐ ,,d ĂƉƉůŝĂŶĐĞƐ ƚŚĂƚ ĂƌĞ ƉƵƌĐŚĂƐĞĚ ƚŚƌŽƵŐŚ ĂŶ ,,d ĂƵƚŚŽƌŝnjĞĚ ĚĞĂůĞƌ Žƌ ĚŝƐƚƌŝďƵƚŽƌ͘ ůŝƐƚ ŽĨ ,,d
ĂƵƚŚŽƌŝnjĞĚĚĞĂůĞƌƐŝƐĂǀĂŝůĂďůĞŽŶƚŚĞ,,dďƌĂŶĚĞĚǁĞďƐŝƚĞƐ͘
ͻ dŚŝƐǁĂƌƌĂŶƚLJŝƐŽŶůLJǀĂůŝĚǁŚŝůĞƚŚĞ,,dĂƉƉůŝĂŶĐĞƌĞŵĂŝŶƐĂƚƚŚĞƐŝƚĞŽĨŽƌŝŐŝŶĂůŝŶƐƚĂůůĂƟŽŶ͘
ͻ dŚŝƐǁĂƌƌĂŶƚLJŝƐŽŶůLJǀĂůŝĚŝŶƚŚĞĐŽƵŶƚƌLJŝŶǁŚŝĐŚƚŚĞ,,dĂƵƚŚŽƌŝnjĞĚĚĞĂůĞƌŽƌĚŝƐƚƌŝďƵƚŽƌƚŚĂƚƐŽůĚƚŚĞĂƉƉůŝĂŶĐĞƌĞƐŝĚĞƐ͘
ͻ ŽŶƚĂĐƚLJŽƵƌŝŶƐƚĂůůŝŶŐĚĞĂůĞƌĨŽƌǁĂƌƌĂŶƚLJƐĞƌǀŝĐĞ͘/ĨƚŚĞŝŶƐƚĂůůŝŶŐĚĞĂůĞƌŽƌĚŝƐƚƌŝďƵƚŽƌŝƐƵŶĂďůĞƚŽƉƌŽǀŝĚĞŶĞĐĞƐƐĂƌLJƉĂƌƚƐ͕ĐŽŶƚĂĐƚ
ƚŚĞŶĞĂƌĞƐƚ,,dĂƵƚŚŽƌŝnjĞĚĚĞĂůĞƌŽƌƐƵƉƉůŝĞƌ͘ĚĚŝƟŽŶĂůƐĞƌǀŝĐĞĨĞĞƐŵĂLJĂƉƉůLJŝĨLJŽƵĂƌĞƐĞĞŬŝŶŐǁĂƌƌĂŶƚLJƐĞƌǀŝĐĞĨƌŽŵĂĚĞĂůĞƌ
other than the dealer from whom you originally purchased the product.
ͻ ŚĞĐŬǁŝƚŚLJŽƵƌĚĞĂůĞƌŝŶĂĚǀĂŶĐĞĨŽƌĂŶLJĐŽƐƚƐƚŽLJŽƵǁŚĞŶĂƌƌĂŶŐŝŶŐĂǁĂƌƌĂŶƚLJĐĂůů͘dƌĂǀĞůĂŶĚƐŚŝƉƉŝŶŐĐŚĂƌŐĞƐĨŽƌƉĂƌƚƐĂƌĞŶŽƚ
ĐŽǀĞƌĞĚďLJƚŚŝƐǁĂƌƌĂŶƚLJ͘
• Limited Catalyst Warranty
Ž &ŽƌǁŽŽĚďƵƌŶŝŶŐƉƌŽĚƵĐƚƐĐŽŶƚĂŝŶŝŶŐĂĐĂƚĂůLJƐƚ͕ƚŚĞĐĂƚĂůLJƐƚǁŝůůďĞǁĂƌƌĂŶƚĞĚĨŽƌĂƐŝdžͲLJĞĂƌƉĞƌŝŽĚĂƐĨŽůůŽǁƐ͗ŝĨƚŚĞŽƌŝŐŝŶĂů
ĐĂƚĂůLJƐƚŽƌĂƌĞƉůĂĐĞŵĞŶƚĐĂƚĂůLJƐƚƉƌŽǀĞƐĚĞĨĞĐƟǀĞŽƌĐĞĂƐĞƐƚŽŵĂŝŶƚĂŝŶϳϬйŽĨŝƚƐƉĂƌƟĐƵůĂƚĞĞŵŝƐƐŝŽŶƌĞĚƵĐƟŽŶĂĐƟǀŝƚLJ;ĂƐ
ŵĞĂƐƵƌĞĚďLJĂŶĂƉƉƌŽǀĞĚƚĞƐƟŶŐƉƌŽĐĞĚƵƌĞͿǁŝƚŚŝŶϯϲŵŽŶƚŚƐĨƌŽŵƚŚĞƉƵƌĐŚĂƐĞĚĂƚĞ͕ƚŚĞĐĂƚĂůLJƐƚǁŝůůďĞƌĞƉůĂĐĞĚĨŽƌĨƌĞĞ͘
Ž &ƌŽŵϯϳƚŽϳϮŵŽŶƚŚƐĂƉƌŽͲƌĂƚĞĚĐƌĞĚŝƚǁŝůůďĞĂůůŽǁĞĚĂŐĂŝŶƐƚĂƌĞƉůĂĐĞŵĞŶƚĐĂƚĂůLJƐƚĂŶĚůĂďŽƌĐƌĞĚŝƚŶĞĐĞƐƐĂƌLJƚŽŝŶƐƚĂůů
ƚŚĞƌĞƉůĂĐĞŵĞŶƚĐĂƚĂůLJƐƚ͘dŚĞƉƌŽƌĂƟŽŶƌĂƚĞŝƐĂƐĨŽůůŽǁƐ͗
Amount of Time Since Purchase
ϬͲϯϲDŽŶƚŚƐ
ϯϳͲϰϴDŽŶƚŚƐ
ϰϵͲϲϬDŽŶƚŚƐ
ϲϭͲϳϮDŽŶƚŚƐ
Credit Towards Replacement Cost
ϭϬϬй
ϯϬй
ϮϬй
ϭϬй
Ž ŶLJƌĞƉůĂĐĞŵĞŶƚĐĂƚĂůLJƐƚǁŝůůďĞǁĂƌƌĂŶƚĞĚƵŶĚĞƌƚŚĞƚĞƌŵƐŽĨƚŚĞĐĂƚĂůLJƐƚǁĂƌƌĂŶƚLJĨŽƌƚŚĞƌĞŵĂŝŶŝŶŐƚĞƌŵŽĨƚŚĞŽƌŝŐŝŶĂů
ǁĂƌƌĂŶƚLJ͘ dŚĞ ƉƵƌĐŚĂƐĞƌ ŵƵƐƚ ƉƌŽǀŝĚĞ ƚŚĞ ŶĂŵĞ͕ ĂĚĚƌĞƐƐ͕ ĂŶĚ ƚĞůĞƉŚŽŶĞ ŶƵŵďĞƌ ŽĨ ƚŚĞ ůŽĐĂƟŽŶ ǁŚĞƌĞ ƚŚĞ ƉƌŽĚƵĐƚ ŝƐ
ŝŶƐƚĂůůĞĚ͕ƉƌŽŽĨŽĨŽƌŝŐŝŶĂůƉƵƌĐŚĂƐĞĚĂƚĞ͕ĚĂƚĞŽĨĨĂŝůƵƌĞ͕ĂŶĚĂŶLJƌĞůĞǀĂŶƚŝŶĨŽƌŵĂƟŽŶƌĞŐĂƌĚŝŶŐƚŚĞĨĂŝůƵƌĞŽĨƚŚĞĐĂƚĂůLJƐƚ͘
WARRANTY EXCLUSIONS:
dŚŝƐǁĂƌƌĂŶƚLJĚŽĞƐŶŽƚĐŽǀĞƌƚŚĞĨŽůůŽǁŝŶŐ͗
ͻ ŚĂŶŐĞƐŝŶƐƵƌĨĂĐĞĮŶŝƐŚĞƐĂƐĂƌĞƐƵůƚŽĨŶŽƌŵĂůƵƐĞ͘ƐĂŚĞĂƟŶŐĂƉƉůŝĂŶĐĞ͕ƐŽŵĞĐŚĂŶŐĞƐŝŶĐŽůŽƌŽĨŝŶƚĞƌŝŽƌĂŶĚĞdžƚĞƌŝŽƌƐƵƌĨĂĐĞ
ĮŶŝƐŚĞƐŵĂLJŽĐĐƵƌ͘dŚŝƐŝƐŶŽƚĂŇĂǁĂŶĚŝƐŶŽƚĐŽǀĞƌĞĚƵŶĚĞƌǁĂƌƌĂŶƚLJ͘
ͻ ĂŵĂŐĞ ƚŽ ƉƌŝŶƚĞĚ͕ ƉůĂƚĞĚ͕ Žƌ ĞŶĂŵĞůĞĚ ƐƵƌĨĂĐĞƐ ĐĂƵƐĞĚ ďLJ ĮŶŐĞƌƉƌŝŶƚƐ͕ ĂĐĐŝĚĞŶƚƐ͕ ŵŝƐƵƐĞ͕ ƐĐƌĂƚĐŚĞƐ͕ ŵĞůƚĞĚ ŝƚĞŵƐ͕ Žƌ ŽƚŚĞƌ
ĞdžƚĞƌŶĂůƐŽƵƌĐĞƐĂŶĚƌĞƐŝĚƵĞƐůĞŌŽŶƚŚĞƉůĂƚĞĚƐƵƌĨĂĐĞƐĨƌŽŵƚŚĞƵƐĞŽĨĂďƌĂƐŝǀĞĐůĞĂŶĞƌƐŽƌƉŽůŝƐŚĞƐ͘
ͻ ZĞƉĂŝƌŽƌƌĞƉůĂĐĞŵĞŶƚŽĨƉĂƌƚƐƚŚĂƚĂƌĞƐƵďũĞĐƚƚŽŶŽƌŵĂůǁĞĂƌĂŶĚƚĞĂƌĚƵƌŝŶŐƚŚĞǁĂƌƌĂŶƚLJƉĞƌŝŽĚĂƌĞŶŽƚĐŽǀĞƌĞĚ͘dŚĞƐĞƉĂƌƚƐ
ŝŶĐůƵĚĞ͗ƉĂŝŶƚ͕ǁŽŽĚĂŶĚƉĞůůĞƚŐĂƐŬĞƚƐ͕ĮƌĞďƌŝĐŬƐ͕ŐƌĂƚĞƐ͕ŇĂŵĞŐƵŝĚĞƐ͕ďĂƩĞƌŝĞƐĂŶĚƚŚĞĚŝƐĐŽůŽƌĂƟŽŶŽĨŐůĂƐƐ͘
ͻ DŝŶŽƌĞdžƉĂŶƐŝŽŶ͕ĐŽŶƚƌĂĐƟŽŶ͕ŽƌŵŽǀĞŵĞŶƚŽĨĐĞƌƚĂŝŶƉĂƌƚƐĐĂƵƐŝŶŐŶŽŝƐĞ͘dŚĞƐĞĐŽŶĚŝƟŽŶƐĂƌĞŶŽƌŵĂůĂŶĚĐŽŵƉůĂŝŶƚƐƌĞůĂƚĞĚƚŽ
ƚŚŝƐŶŽŝƐĞĂƌĞŶŽƚĐŽǀĞƌĞĚďLJƚŚŝƐǁĂƌƌĂŶƚLJ͘
ͻ ĂŵĂŐĞƐƌĞƐƵůƟŶŐĨƌŽŵ͗;ϭͿĨĂŝůƵƌĞƚŽŝŶƐƚĂůů͕ŽƉĞƌĂƚĞ͕ŽƌŵĂŝŶƚĂŝŶƚŚĞĂƉƉůŝĂŶĐĞŝŶĂĐĐŽƌĚĂŶĐĞǁŝƚŚƚŚĞŝŶƐƚĂůůĂƟŽŶŝŶƐƚƌƵĐƟŽŶƐ͕
ŽƉĞƌĂƟŶŐ ŝŶƐƚƌƵĐƟŽŶƐ͕ ĂŶĚ ůŝƐƟŶŐ ĂŐĞŶƚ ŝĚĞŶƟĮĐĂƟŽŶ ůĂďĞů ĨƵƌŶŝƐŚĞĚ ǁŝƚŚ ƚŚĞ ĂƉƉůŝĂŶĐĞ͖ ;ϮͿ ĨĂŝůƵƌĞ ƚŽ ŝŶƐƚĂůů ƚŚĞ ĂƉƉůŝĂŶĐĞ ŝŶ
ĂĐĐŽƌĚĂŶĐĞǁŝƚŚůŽĐĂůďƵŝůĚŝŶŐĐŽĚĞƐ͖;ϯͿƐŚŝƉƉŝŶŐŽƌŝŵƉƌŽƉĞƌŚĂŶĚůŝŶŐ͖;ϰͿŝŵƉƌŽƉĞƌŽƉĞƌĂƟŽŶ͕ĂďƵƐĞ͕ŵŝƐƵƐĞ͕ĐŽŶƟŶƵĞĚŽƉĞƌĂƟŽŶ
ǁŝƚŚĚĂŵĂŐĞĚ͕ĐŽƌƌŽĚĞĚŽƌĨĂŝůĞĚĐŽŵƉŽŶĞŶƚƐ͕ĂĐĐŝĚĞŶƚ͕ŽƌŝŵƉƌŽƉĞƌůLJͬŝŶĐŽƌƌĞĐƚůLJƉĞƌĨŽƌŵĞĚƌĞƉĂŝƌƐ;ϱͿĞŶǀŝƌŽŶŵĞŶƚĂůĐŽŶĚŝƟŽŶƐ͕
ŝŶĂĚĞƋƵĂƚĞǀĞŶƟůĂƟŽŶ͕ŶĞŐĂƟǀĞƉƌĞƐƐƵƌĞ͕ŽƌĚƌĂŌŝŶŐĐĂƵƐĞĚďLJƟŐŚƚůLJƐĞĂůĞĚĐŽŶƐƚƌƵĐƟŽŶƐ͕ŝŶƐƵĸĐŝĞŶƚŵĂŬĞͲƵƉĂŝƌƐƵƉƉůLJ͕Žƌ
ŚĂŶĚůŝŶŐĚĞǀŝĐĞƐƐƵĐŚĂƐĞdžŚĂƵƐƚĨĂŶƐŽƌĨŽƌĐĞĚĂŝƌĨƵƌŶĂĐĞƐŽƌŽƚŚĞƌƐƵĐŚĐĂƵƐĞƐ͖;ϲͿƵƐĞŽĨĨƵĞůƐŽƚŚĞƌƚŚĂŶƚŚŽƐĞƐƉĞĐŝĮĞĚŝŶ
ƚŚĞŽƉĞƌĂƟŽŶŝŶƐƚƌƵĐƟŽŶƐ͖;ϳͿŝŶƐƚĂůůĂƟŽŶŽƌƵƐĞŽĨĐŽŵƉŽŶĞŶƚƐŶŽƚƐƵƉƉůŝĞĚǁŝƚŚƚŚĞĂƉƉůŝĂŶĐĞŽƌĂŶLJŽƚŚĞƌĐŽŵƉŽŶĞŶƚƐŶŽƚ
ĞdžƉƌĞƐƐůLJĂƵƚŚŽƌŝnjĞĚĂŶĚĂƉƉƌŽǀĞĚďLJ,,d͖;ϴͿŵŽĚŝĮĐĂƟŽŶŽĨƚŚĞĂƉƉůŝĂŶĐĞŶŽƚĞdžƉƌĞƐƐůLJĂƵƚŚŽƌŝnjĞĚĂŶĚĂƉƉƌŽǀĞĚďLJ,,dŝŶ
ǁƌŝƟŶŐ͖ĂŶĚͬŽƌ;ϵͿŝŶƚĞƌƌƵƉƟŽŶƐŽƌŇƵĐƚƵĂƟŽŶƐŽĨĞůĞĐƚƌŝĐĂůƉŽǁĞƌƐƵƉƉůLJƚŽƚŚĞĂƉƉůŝĂŶĐĞ͘
ͻ EŽŶͲ,,dǀĞŶƟŶŐĐŽŵƉŽŶĞŶƚƐ͕ŚĞĂƌƚŚĐŽŶŶĞĐƟŽŶƐŽƌŽƚŚĞƌĂĐĐĞƐƐŽƌŝĞƐƵƐĞĚŝŶĐŽŶũƵŶĐƟŽŶǁŝƚŚƚŚĞĂƉƉůŝĂŶĐĞ͘
ͻ ŶLJƉĂƌƚŽĨĂƉƌĞͲĞdžŝƐƟŶŐĮƌĞƉůĂĐĞƐLJƐƚĞŵŝŶǁŚŝĐŚĂŶŝŶƐĞƌƚŽƌĂĚĞĐŽƌĂƟǀĞŐĂƐĂƉƉůŝĂŶĐĞŝƐŝŶƐƚĂůůĞĚ͘
ͻ ,,d͛ƐŽďůŝŐĂƟŽŶƵŶĚĞƌƚŚŝƐǁĂƌƌĂŶƚLJĚŽĞƐŶŽƚĞdžƚĞŶĚƚŽƚŚĞĂƉƉůŝĂŶĐĞ͛ƐĐĂƉĂďŝůŝƚLJƚŽŚĞĂƚƚŚĞĚĞƐŝƌĞĚƐƉĂĐĞ͘/ŶĨŽƌŵĂƟŽŶŝƐƉƌŽǀŝĚĞĚ
ƚŽĂƐƐŝƐƚƚŚĞĐŽŶƐƵŵĞƌĂŶĚƚŚĞĚĞĂůĞƌŝŶƐĞůĞĐƟŶŐƚŚĞƉƌŽƉĞƌĂƉƉůŝĂŶĐĞĨŽƌƚŚĞĂƉƉůŝĐĂƟŽŶ͘ŽŶƐŝĚĞƌĂƟŽŶŵƵƐƚďĞŐŝǀĞŶƚŽƚŚĞ
ĂƉƉůŝĂŶĐĞůŽĐĂƟŽŶĂŶĚĐŽŶĮŐƵƌĂƟŽŶ͕ĞŶǀŝƌŽŶŵĞŶƚĂůĐŽŶĚŝƟŽŶƐ͕ŝŶƐƵůĂƟŽŶĂŶĚĂŝƌƟŐŚƚŶĞƐƐŽĨƚŚĞƐƚƌƵĐƚƵƌĞ͘
This warranty is void if:
ͻ dŚĞ ĂƉƉůŝĂŶĐĞ ŚĂƐ ďĞĞŶ ŽǀĞƌͲĮƌĞĚ͕ ŽƉĞƌĂƚĞĚ ŝŶ ĂƚŵŽƐƉŚĞƌĞƐ ĐŽŶƚĂŵŝŶĂƚĞĚ ďLJ ĐŚůŽƌŝŶĞ͕ ŇƵŽƌŝŶĞ͕ Žƌ ŽƚŚĞƌ ĚĂŵĂŐŝŶŐ ĐŚĞŵŝĐĂůƐ͘
KǀĞƌͲĮƌŝŶŐĐĂŶďĞŝĚĞŶƟĮĞĚďLJ͕ďƵƚŶŽƚůŝŵŝƚĞĚƚŽ͕ǁĂƌƉĞĚƉůĂƚĞƐŽƌƚƵďĞƐ͕ĚĞĨŽƌŵĂƟŽŶͬǁĂƌƉŝŶŐŽĨŝŶƚĞƌŝŽƌĐĂƐƚŝƌŽŶƐƚƌƵĐƚƵƌĞŽƌ
ĐŽŵƉŽŶĞŶƚƐ͕ƌƵƐƚĐŽůŽƌĞĚĐĂƐƚŝƌŽŶ͕ďƵďďůŝŶŐ͕ĐƌĂĐŬŝŶŐĂŶĚĚŝƐĐŽůŽƌĂƟŽŶŽĨƐƚĞĞůŽƌĞŶĂŵĞůĮŶŝƐŚĞƐ͘
ͻ dŚĞĂƉƉůŝĂŶĐĞŝƐƐƵďũĞĐƚĞĚƚŽƉƌŽůŽŶŐĞĚƉĞƌŝŽĚƐŽĨĚĂŵƉŶĞƐƐŽƌĐŽŶĚĞŶƐĂƟŽŶ͘
• There is any damage to the appliance or other components due to water or weather damage which is the result of, but not limited
ƚŽ͕ŝŵƉƌŽƉĞƌĐŚŝŵŶĞLJŽƌǀĞŶƟŶŐŝŶƐƚĂůůĂƟŽŶ͘
LIMITATIONS OF LIABILITY
ͻ dŚĞŽǁŶĞƌ͛ƐĞdžĐůƵƐŝǀĞƌĞŵĞĚLJĂŶĚ,,d͛ƐƐŽůĞŽďůŝŐĂƟŽŶƵŶĚĞƌƚŚŝƐǁĂƌƌĂŶƚLJ͕ƵŶĚĞƌĂŶLJŽƚŚĞƌǁĂƌƌĂŶƚLJ͕ĞdžƉƌĞƐƐŽƌŝŵƉůŝĞĚ͕ŽƌŝŶ
ĐŽŶƚƌĂĐƚ͕ƚŽƌƚŽƌŽƚŚĞƌǁŝƐĞ͕ƐŚĂůůďĞůŝŵŝƚĞĚƚŽƌĞƉůĂĐĞŵĞŶƚ͕ƌĞƉĂŝƌ͕ŽƌƌĞĨƵŶĚ͕ĂƐƐƉĞĐŝĮĞĚĂďŽǀĞ͘/ŶŶŽĞǀĞŶƚǁŝůů,,dďĞůŝĂďůĞĨŽƌ
ĂŶLJŝŶĐŝĚĞŶƚĂůŽƌĐŽŶƐĞƋƵĞŶƟĂůĚĂŵĂŐĞƐĐĂƵƐĞĚďLJĚĞĨĞĐƚƐŝŶƚŚĞĂƉƉůŝĂŶĐĞ͘^ŽŵĞƐƚĂƚĞƐĚŽŶŽƚĂůůŽǁĞdžĐůƵƐŝŽŶƐŽƌůŝŵŝƚĂƟŽŶŽĨ
ŝŶĐŝĚĞŶƚĂůŽƌĐŽŶƐĞƋƵĞŶƟĂůĚĂŵĂŐĞƐ͕ƐŽƚŚĞƐĞůŝŵŝƚĂƟŽŶƐŵĂLJŶŽƚĂƉƉůLJƚŽLJŽƵ͘dŚŝƐǁĂƌƌĂŶƚLJŐŝǀĞƐLJŽƵƐƉĞĐŝĮĐƌŝŐŚƚƐ͖LJŽƵŵĂLJĂůƐŽ
ŚĂǀĞŽƚŚĞƌƌŝŐŚƚƐ͕ǁŚŝĐŚǀĂƌLJĨƌŽŵƐƚĂƚĞƚŽƐƚĂƚĞ͘yWddKd,ydEdWZKs/z>t͕,,dD<^EKyWZ^^tZZEd/^
Kd,Zd,Ed,tZZEdz^W/&/,Z/E͘d,hZd/KEK&Ez/DW>/tZZEdz/^>/D/ddKhZd/KEK&d,
yWZ^^tZZEdz^W/&/Ks͘
Based on CSA P.4.1-2015
EFFICIENCY RATINGS
MODEL
ENERGUIDE RATINGS
STOVE EFFICIENCY
PERCENTAGE
(AFUE PERCENTAGE)
SDDVT Series
SDVTSC Series
D.O.E.
0RXQWDLQ+RXVH5RDG‡+DOLID[3$
ZZZYHUPRQWFDVWLQJVFRP
64
Vermont Castings • Stardance SDDVTSB Installation Manual_R18 • 11/18
3-90-20306760
">