Falcon 4023 Installation instructions
Advertisement
Advertisement
*640094-00*
640094-00
Removable Mullion
4023
Installation Instructions
Note: Use lock washers on top and bottom mullion fittings except for counter sunk screws.
1 Line up bottom mullion fitting with center of door opening and flush with closed doors (Figure 1 or 2) and install.
2 Line up top mullion fitting with center of door opening and flush with closed doors as shown in Figure 3 and install. See Figures 5, 6, and
7 (reverse side) for optional frame conditions.
3 Cut mullion body to length as shown in Figure 4.
4 Insert mullion in top fitting and slide bottom of mullion into place. See Figure 8 (reverse side).
5 Nest mullion into bottom fitting and secure set screw.
6 Install top mullion clamp over mullion and fitting with mounting screws. See Figure 8 (reverse side).
7 Adjust strikes for 1/32 clearance between latch bolt and strike. See Figure 8 (reverse side).
3 15/32”
2”
F-Flat sill fitting shown
Figure 1
Threshold must be cut to fit around the flat sill fitting
3/16” R. typ.
Door opening
1/4-20 x 5/8” P.P.H.M.S.
5/8”
2”
5/8”
Figure 3
Top anchor
1”
2 7/8”
9/16”
Door opening
1/16” ref.
Door opening
Cut off top end of mullion body so length is 1/16” less than this dimension
Figure 2
Figure 4
Reinforcement
1 7/16”
15/16”
Filler block is to be supplied by the frame mfg. for conditions similar to this
Angle plate
For stops wider than 3 1/2”
1/4-20 x 1 1/2” P.P.H.M.S.
Figure 5
1/4-20 x 5/8” P.P.H.M.S.
Top clamp
Reinforcement
Note:
The application of the strike depends on the device it is to be used with
Figure 6
The use of this screw is optional depending on frame conditions
For narrow transoms
Reinforcement
1/4-20 x 5/8”
P.P.H.M.S.
Reinforcement for all sheet metal frames is to be supplied by frame mfg.
Figure 7
299 Strike
All standard rim devices
Reinforcement
264 Strike
All standard rim devices
Bottom set screw
2 1/2”
5/8”
1 1/2”
1/4” 15/16” 15/16”
1 1/2”
Symmetrical about
C L
Adj. angle plate
7/8”
Figure 8
For cutouts on inside face of door, see directions in device carton.
5/16 x 18”
Anchor
Customer Service
1-877-671-7011 www.allegion.com/us
© Allegion 2014
Printed in U.S.A.
640094-00 Rev. 06/14-a

Public link updated
The public link to your chat has been updated.
Advertisement