TECH TIPS - Genie Industries

TECH TIPS - Genie Industries
TECH TIPS
Service Call:
Customer requires MSDS sheets for
Terex/Genie Equipment.
Tools Needed:
None
Model:
AWP/IWP/DPL
Tech Tips Safety Rules
Danger
Failure to obey the instructions and safety rules in
the appropriate Operator's Manual and Service
Manual for your machine will result in death or
serious injury. Many of the hazards identified in
the operator’s manual are also safety hazards
when maintenance and repair procedures are
performed.
Do Not Perform Maintenance Unless:
¾ You are trained and qualified to perform
maintenance on this machine.
¾ You read, understand and obey:
o manufacturer’s instructions and safety
rules
o employer’s safety rules and worksite
regulations
o applicable governmental regulations
¾ You have the appropriate tools, lifting
equipment and a suitable workshop.
The information contained in this tech tip is a
supplement to the service manual. Consult the
appropriate service manual of your machine for
safety rules and hazards.
TECH TIPS
Step 1
Attached is a list of MSDS sheets for the required models.
Step 2
HAZARD RATING
F
1
TROJAN BATTERY COMPANY
LEAD / ACID BATTERY
H
3
2
R
CO
MATERIAL SAFETY DATA SHEET
SECTION 1-- CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MANUFACTURER'S
NAME:
TROJAN BATTERY COMPANY
ADDRESS:
12380 CLARK ST., SANTA FE SPRINGS, CA 90670
PERSON RESPONSIBLE FOR PREPARATION:
Ismael Pedroza, Jr.
EMERGENCY
TELEPHONE NO.:
CHEMTREC 800-424-9300
OTHER
INFORMATION CALLS:
562-946-8381 800-423-6569
Revision
Date:
February 19, 2006
SECTION 2 -- COMPOSITION/INFORMATION ON INGREDIENTS
PRINCIPAL HAZARDOUS
COMPONENT(S)
(chemical & common name(s)
C.A.S.
Hazard Category
%
OSHA
PEL-TWA
ACGIH
TLV
7439-92-1
Lead/Lead Oxide/Lead Sulfate
Acute-Chronic
60 - 97%
0.05 mg/m3
0.05 mg/m3
7440-36-0
Antimony
Chronic
1.5 - 4%
0.5 mg/m3
0.5 mg/m3
7440-38-2
Arsenic
Acute-Chronic
< 1%
0.01 mg/m3
0.01mg/m3
7664-93-9
Sulfuric Acid
(Battery Electrolyte)
Reactive-Oxidizer
Acute-Chronic
10 - 38%
1.0 mg/m3
1.0 mg/m3
7440-70-2
Calcium
Reactive
< 0.15%
Not established
Not established
7440-31-5
Tin
Chronic
< 0.3%
2.0 mg/m3
Not established
NOTE: PEL's for individual states may differ from OSHA PEL's. Check with local authorities for the applicable state PEL's.
OSHA - Occupational Safety and Health Administration; ACGIH - American Conference of Governmental Industrial Hygienists; NIOSH - National Institute for Occupational
Safety and Health.
COMMON NAME: (Used on label)
(Trade Name & Synonyms)
Lead/Acid Storage Battery
Chemical Name:
Lead/Acid Storage Battery
Chemical Family: Toxic and Corrosive Material Mixture
Formula: Lead and Acid (electrolyte)
SECTION 3 -- HAZARD IDENTIFICATION
Signs and
Symptoms of
Exposure
1. Acute
Hazards
Do not open battery. Avoid contact with internal components. Internal components include lead and liquid electrolyte.
Electrolyte - Electrolyte is corrosive and contact may cause skin irritation and chemical burns. Electrolyte causes
severe irritation and burns of eyes, nose and throat. Ingestion can cause severe burns and vomiting.
Lead -Direct skin or eye contact may cause local irritation. Inhalation or ingestion of lead dust or fumes may
result
in headache, nausea, vomiting, abdominal spasms, fatigue, sleep disturbances, weight loss, anemia
and leg,
arm and joint pain.
2. Subchronic
and
Chronic Health
Effects
Electrolyte - Repeated contact with sulfuric acid battery electrolyte fluid may cause drying of the skin which may result in irritation, dermatitis, and
skin burns. Repeated exposure to sulfuric acid mist may cause erosion of teeth, chronic eye irritation and/or chronic inflammation of the nose,
throat and lungs.
Lead - Prolonged exposure may cause central nervous system damage, gastrointestinal disturbances, anemia, wrist-drop and kidney
dysfunction. Pregnant women should be protected from excessive exposure to prevent lead from crossing the placental barrier and
infant neurological disorders.
causing
California Proposition 65 Warning: Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the
State of California to cause cancer and reproductive harm, and during charging, strong inorganic acid mists containing sulfuric acid are evolved, a
chemical Known to the State of California to cause cancer. Wash hands after handling.
Medical
Conditions
Generally
Aggravated by
Exposure
If battery is broken or material is spilled, then persons with the following medical conditions must take precautions: pulmonary edema, bronchitis,
emphysema, dental erosion and tracheobronchitis.
Routes of
Entry
Inhalation - YES
Ingestion - YES
Chemical(s)
Listed as
Carcinogen or
potential
Carcinogen
Proposition
65 - YES
Eye Contact - YES
Skin Contact - YES
National Toxicology
Program - YES
I.A.R.C.
Monographs - YES
OSHA - NO
EPA
CAG - YES
NIOSH - YES
SECTION 4 -- FIRST AID MEASURES
Emergency and
First Aid
Procedures
Contact with internal components if battery is opened, broken or spilled.
1. Inhalation
Remove to fresh air and provide medical oxygen/CPR if needed. Obtain medical attention.
2. Eyes
Immediately flush with water for at least 15 minutes, hold eyelids open. Obtain medical attention.
3. Skin
Flush contacted area with large amounts of water for at least 15 minutes. Remove contaminated clothing and obtain medical attention if necessary.
4. Ingestion
Do not induce vomiting. If conscious drink large amounts of water/milk. Obtain medical attention. Never give anything by mouth to an unconscious
person.
SECTION 5 - FIREFIGHTING MEASURES
Flash
Point
Not
Applicable
Flammable Limits
in Air % by Volume
Hydrogen
(H2)
Lower
4.1%
Upper
74.2%
Extinguisher
Media
Class ABC,
CO2, Halon
Auto-Ignition
Temperature
Polypropylene
675o F
(When charging)
Special Fire
Fighting
Procedures
Lead-acid batteries do not burn or burn with difficulty. Do not use water on fires where molten metal is present. Extinguish fire with agent
suitable for surrounding combustible materials. Cool exterior of battery if exposed to fire to prevent rupture. The acid mist and vapors
generated by heat or fire are corrosive. Use NIOSH approved self-contained breathing apparatus (SCBA) and full protective equipment
operated in positive-pressure mode.
Unusual Fire and
Explosion Hazards
Hydrogen gas and sulfuric acid vapors are generated upon overcharge and polypropylene case failure. Ventilate charging areas as per
ACGIH Industrial Ventilation : A Manual of Recommended Practice and National Fire Code, 1980 Vol. 1, P. 12, B-9, 10. Hydrogen gas may
be flammable or explosive when mixed with air, oxygen, chlorine. Avoid open flames/sparks/other sources of ignition near battery. To avoid
risk of fire or explosion, keep sparks or other sources of ignition away from batteries and do not allow metallic materials to simultaneously
contact negative and positive terminals of cells and batteries. SULFURIC ACID REACTS VIOLENTLY WITH WATER/ORGANICS.
SECTION 6 -- ACCIDENTAL RELEASE MEASURES
Procedures for Cleanup: Stop release, if possible. Avoid contact with any spilled material. Contain spill, isolate hazard area, and deny entry. Limit site access to
emergency responders. Neutralize with sodium bicarbonate, soda ash, lime or other neutralizing agent. Place battery in suitable container for disposal. Dispose of
contaminated material in accordance with applicable local, state and federal regulations. Sodium bicarbonate, soda ash, sand, lime or other neutralizing agent should be
kept on-site for spill remediation.
Personal Precautions: Acid resistant aprons, boots and protective clothing. ANSI approved safety glasses with side shields/face shield recommended. Ventilate enclosed
areas.
Environmental Precautions: Lead and its compounds and sulfuric acid can pose a severe threat to the environment. Contamination of water, soil, and air should be
prevented.
SECTION 7 -- HANDLING AND STORAGE
Precautions to be Taken
in Handling and Storage
Keep away from flames during and immediately after charging. Combustion or overcharging may create or liberate toxic and
hazardous gases and liquids including hydrogen, sulfuric acid mist, sulfur dioxide, sulfur trioxide, stibine, arsine and sulfuric acid.
Store batteries in cool, dry, well ventilated area. Do not short circuit battery terminals, or remove vent caps during storage or
recharging. Protect battery from physical damage.
GOOD PERSONAL HYGIENE AND WORK PRACTICES ARE MANDATORY. Refrain from eating, drinking or smoking in work
areas. Thoroughly wash hands, face, neck, and arms before eating, drinking or smoking. Launder soiled clothing before reuse.
Emptied batteries contain hazardous sulfuric acid residue.
Other
Precautions
SECTION 8 -- EXPOSURE CONTROLS AND PERSONAL PROTECTION
Respiratory
Protection
(Specify Type)
Acid/gas NIOSH approved respirator is required when the PEL is exceeded or employee experiences respiratory irritation. When exposure levels
are unknown or when firefighting, wear a self-contained breathing apparatus with a full facepiece operated in a positive pressure mode.
Local Exhaust
Ventilation
Must be provided when
charging in an enclosed
area. Change air every 15
min.
Protective Gloves
Wear rubber or plastic acid resistant
gloves with elbow length gauntlet
when filling batteries.
Other Protective
Clothing or
Equipment
When PEL is exceeded.
Eye Protection
Mechanical (General)
Normal mechanical ventilation
recommended for stationary
applications.
ANSI approved safety glasses with side shields/face shield recommended.
Safety goggles.
Ventilation as described in the Industrial Ventilation Manual produced by the American Conference of Governmental Industrial Hygienists, shall
be provided in areas where exposures are above the PEL or TLV specified by OSHA or other local, state and federal regulations.
Acid-resistant rubber or plastic apron, boots and protective clothing. Safety shower and eyewash.
SECTION 9 -- PHYSICAL AND CHEMICAL PROPERTIES
Boiling
Point
Electrolyte
Approx. 235o F
Vapor
Pressure
Electrolyte 1 mm
Hg @ 145.8o F
Percent Volatile
by Volume (%)
Not
Applicable
Solubility
in Water
Electrolyte: 100% Soluble
Appearance
and Odor
Vapor
Density
Specific
Gravity
Hydrogen (Air = 1) : 0.069
Electrolyte (Air = 1) : 3.4
Reactivity
in Water
Electrolyte (H20 = 1)
1.250 - 1.320 pH < 2
At STP
Melting
Point
Evaporation
Rate
Electrolyte - water reactive (1)
Battery: Polypropylene or hard rubber case, solid.
Lead: Gray, metallic, solid
Electrolyte: Liquid, colorless, oily fluid; nuisance odor when hot or charging battery.
Polypropylene
< 320o F
Not
Applicable
SECTION 10 -- STABILITY AND REACTIVITY
Stability
Unstable
Stable
Incompatibility
(Materials to Avoid)
Conditions
to Avoid
High temperatures - cases decompose at <320°F.
Avoid overcharging and smoking, or sparks near battery surface and rapid overcharge.
Sparks, Open flames, Keep battery case away from strong oxidizers.
Hazardous
Decomposition Products
Hazardous
Polymerization
…
:
An explosive hydrogen/oxygen mixture within the battery may occur during charging. Combustion can produce carbon dioxide (CO2) and
carbon monoxide (CO). Molten metals produce fumes and/or vapor that may be toxic or respiratory irritants.
May Occur
Will Not Occur
…
:
Do not overcharge.
SECTION 11 -- TOXICOLOGICAL INFORMATION
GENERAL: The primary routes of exposure to lead are ingestion or inhalation of dust and fumes.
ACUTE:
INGESTION/INHALATION: Exposure to lead and its compounds may cause headache, nausea, vomiting, abdominal spasms, fatigue, sleep
disturbances, weight loss, anemia, and pain in the legs, arms and joints. Kidney damage, as well as anemia, can occur from acute exposure.
CHRONIC:
INHALATION/INGESTION: Prolonged exposure to lead and its compounds may produce many of the symptoms of short-term exposure and may also
cause central nervous system damage, gastrointestinal disturbances, anemia, and wrist drop. Symptoms of central nervous system damage include
fatigue, headaches, tremors, hypertension, hallucinations, convulsions and delirium. Kidney dysfunction and possible injury has also been associated
with chronic lead poisoning. Chronic over-exposure to lead has been implicated as a causative agent for the impairment of male and female
reproductive capacity, but there is, at present, no substantiation of the implication. Pregnant women should be protected from excessive exposure.
Lead can cross the placental barrier and unborn children may suffer neurological damage or developmental problems due to excessive lead exposure in
pregnant women.
SECTION 12 -- ECOLOGICAL INFORMATION
In most surface water and groundwater, lead forms compounds with anions such as hydroxides, carbonates, sulfates, and phosphates
and precipitates out of the water column. Lead may occur as sorbed ions or surface coatings on sediment mineral particles or may be
carried in colloidal particles in surface water. Most lead is strongly retained in soil, resulting in little mobility. Lead may be immobilized
by ion exchange with hydrous oxides or clays or by chelation with humic or fulvic acids in the soil. Lead (when in the dissolved phase) is
bio-accumulated by plants and animals, both aquatic and terrestrial.
SECTION 13 -- DISPOSAL CONSIDERATIONS
Waste Disposal
Methods
Lead-acid batteries are completely recyclable. Return whole scrap batteries to distributor, manufacturer or lead smelter for recycling.
For information on returning batteries to Trojan Battery Company for recycling call 800-423-6569. For neutralized spills, place
residue in acid-resistant containers with sorbent material, sand or earth and dispose of in accordance with local, state and federal
regulations for acid and lead compounds. Contact local and/or state environmental officials regarding disposal information.
SECTION 14 -- TRANSPORT INFORMATION
U.S. DOT PROPER SHIPPING NAME: Batteries, wet, filled with acid
U.S. DOT HAZARD CLASS: 8
U.S. DOT ID NUMBER: UN 2794
U.S. DOT PACKING GROUP: III
U.S. DOT LABEL: Corrosive
IMO PROPER SHIPPING NAME: Batteries, wet, filled with acid
IMO REGULATION PAGE NUMBER: 8120
IMO U.N. CLASS: 8
IMO U.N. NUMBER: UN 2794
IMO PACKING GROUP: III
IMO LABEL: Corrosive
IMO VESSEL STOWAGE: A
IATA PROPER SHIPPING NAME: Batteries, wet, filled with acid
IATA U.N. CLASS: 8
IATA U.N. NUMBER: UN 2794
IATA PACKING GROUP: III
IATA LABEL: Corrosive
SECTION 15 -- REGULATORY INFORMATION
U.S. Hazardous Under Hazard Communication Standard:
Lead - YES
Sulfuric Acid - YES
Antimony - YES
Arsenic - YES
Ingredients Listed on TSCA Inventory:
YES
CERCLA Section 304 Hazardous Substances:
Lead – YES
RQ: NA*
Sulfuric Acid – YES
Antimony - YES
Arsenic – YES
RQ: 1000 pounds
RQ: 5000 pounds
RQ: 1 pound
*Reporting not required when diameter of the pieces of solid metal released is equal to or exceeds 100 micrometers.
EPCRA Section 302 Extremely Hazardous Substance:
Sulfuric acid - YES
EPCRA Section 313 Toxic Release Inventory:
Lead - CAS NO: 7439-92-1
Sulfuric Acid - CAS NO: 7664-93-9
Antimony - CAS NO: 7440-36-0
Arsenic - CAS NO: 7440-38-2
SECTION 16 -- OTHER INFORMATION
THE INFORMATION ABOVE IS BELIEVED TO BE ACCURATE AND REPRESENTS THE BEST INFORMATION CURRENTLY AVAILABLE TO US. HOWEVER, TROJAN
BATTERY COMPANY MAKES NO WARRANTY OF MERCHANTABILITY OR ANY OTHER WARRANTY, EXPRESS OR IMPLIED, WITH RESPECT TO SUCH
INFORMATION, AND WE ASSUME NO LIABILITY RESULTING FROM ITS USE. USERS SHOULD MAKE THEIR OWN INVESTIGATIONS TO DETERMINE THE
SUITABILITY OF THE INFORMATION FOR THEIR PARTICULAR PURPOSES. ALTHOUGH REASONABLE PRECAUTIONS HAVE BEEN TAKEN IN THE PREPARATION
OF THE DATA CONTAINED HEREIN, IT IS OFFERED SOLELY FOR YOUR INFORMATION, CONSIDERATION AND INVESTIGATION. THIS MATERIAL SAFETY DATA
SHEET PROVIDES GUIDELINES FOR THE SAFE HANDLING AND USE OF THIS PRODUCT; IT DOES NOT AND CANNOT ADVISE ON ALL POSSIBLE SITUATIONS,
THEREFORE, YOUR SPECIFIC USE OF THIS PRODUCT SHOULD BE EVALUATED TO DETERMINE IF ADDITIONAL PRECAUTIONS ARE REQUIRED.
Form MSDS Rev. 2/19/07
MATERIAL SAFETY DATA SHEET
Emergency Phone: (631) 205-9700
Chemtrec: (800) 424-9300
Supplier: The Orelube Corporation
20 Sawgrass Drive
Bellport, NY 11713
Date Prepared: 03/30/05
1 PRODUCT IDENTIFICATION
PRODUCT NAME: BOELUBE 70200
SYNONYMS: 70206 / 16B4F
CHEMICAL FAMILY: Proprietary
PRODUCT USE: Metalworking Lubricant
NFPA
Health - 1
Flammability - 1
Reactivity - 0
2 PRECAUTIONARY INFORMATION
This product is not known or expected to be hazardous.
3 HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
COMPONENTS
OSHA
ACGIH
PEL
TLV
ACGIH
STEL
CAS #
This Material Safety Data Sheet has been prepared under guidelines in OSHA Hazard
Communication Standard 29 CFR 1910.1200.
No known hazardous ingredients present in product. Exposure limits not established.
None of the components of this product at concentrations greater than or equal to 0.1% are listed
as a carcinogen or potential carcinogen by NTP, IARC, and OSHA.
4 HEALTH HAZARD DATA
EYE: Excessive exposure may result in transient irritation.
SKIN: Excessive exposure may result in transient irritation in some individuals.
INGESTION: Not an expected route of exposure. Non-toxic by oral dosing in rats.
INHALATION: Not an expected route of exposure.
SYMPTOMS OF EXPOSURE: No persistent adverse health effects are known to be associated
with exposure to this product.
PRIMARY ROUTES OF ENTRY: Occupational exposure most likely to occur through skin
contact.
5 FIRST AID MEASURES
SKIN: Wash off with plenty of soap and water.
EYE: Flush with large amounts of water. If any irritation persists, get medical attention.
INGESTION: Remove material from mouth. Drink plenty of water. If large amount swallowed or
symptoms develop, get medical attention.
INHALATION: Remove to fresh air.
6 EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING MEASURES: Ensure ventilation or local exhaust especially for enclosed space.
HYGIENE MEASURES: Good industrial hygiene should be followed.
OCCUPATIONAL EXPOSURE LIMITS: No occupational exposure limits have been established.
PERSONAL PROTECTIVE EQUIPMENT: Normal precautions should be observed. If repeated or
prolonged skin contact is likely, impervious gloves are recommended.
7 PHYSICAL / CHEMICAL PROPERTIES
PHYSICAL STATE: Solid
COLOR: White
ODOR: None
BOILING POINT: Not determined
MELTING POINT: ~ 110 F (43 C)
VAPOR PRESSURE: < 0.1 mm Hg @ 20 C
VAPOR DENSITY: Heavier than air
SPECIFIC GRAVITY: ~ 0.84 g/ml @ 25 C
SOLUBILITY IN WATER: Insoluble
VOC CONTENT: Not volatile
8 STABILITY / REACTIVITY
STABILITY: Stable under normal conditions.
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition will evolve oxides of
carbon.
MATERIALS TO AVOID: Oxidizing agents
9 FIRE / EXPLOSION DATA
FLASH POINT: > 330 F (165 C) (COC)
AUTOIGNITION TEMPERATURE: Not Available
UNUSUAL FIRE AND EXPLOSION HAZARDS: None expected
EXTINGUISHING MEDIA: Foam, dry chemical, carbon dioxide, water spray.
SPECIAL FIRE FIGHTING PROCEDURES: Use air-supplied breathing equipment for enclosed
areas. Water or foam may cause frothing which can be violent, especially if sprayed into
containers of hot burning liquid.
10 SPILL / LEAK PROCEDURES
Recover free product. Contain any spill to prevent entry to sewers or streams. Add sand, earth or
suitable absorbent to spill area. Transfer to closed container.
11 WASTE DISPOSAL METHODS
Dispose of in accordance with local, state and federal laws.
BOELUBE 70200 MSDS
2
12 PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store in closed containers away from heat or open flames. Do not store with oxidizing agents. Not
for internal use. Empty containers may contain product residue. Do not cut, heat or weld on or
around empty containers. Avoid freezing temperatures.
13 TOXICOLOGICAL INFORMATION
ACUTE TOXICITY: Oral LD50 greater than 20 g/kg (rats)
SKIN IRRITATION: Non-irritant (rabbits)
EYE IRRITATION: Non-irritant (rabbits)
SKIN SENSITIZATION: Not a sensitizer.
MUTAGENICITY: Ames test - Negative (Non-mutagenic)
14 ECOLOGICAL INFORMATION
BIODEGRADATION: Biodegradable (expected to exhibit greater than 70% degradation within 28
days in the Modified Sturm test).
ECOTOXICITY: Not determined. However, this product is not expected to cause harm to aquatic
organisms.
15 REGULATORY INFORMATION
This product does not contain a SARA Title 3 Section 313 (40 CFR 372) reportable chemical.
This product is not considered a controlled product according to the criteria of the Canadian
Controlled Products Regulations.
CALIFORNIA PROPOSITION 65: No reportable components.
INVENTORY STATUS: This product contains only chemicals that are currently listed on:
USA - TSCA; Australia - AICS; EU - EINECS; Canada - DSL; Korea - ECL; Japan - ENCS;
Philippines - PICCS; and China - SEPA.
16 TRANSPORTATION INFORMATION
Not regulated by US DOT, IMO, or ICAO.
17 OTHER INFORMATION
This information is furnished without warranty, expressed or implied, except that it is accurate to
the best knowledge of The Orelube Corporation. The Orelube Corporation assumes no legal
responsibility for the use or reliance upon this data.
Please note that the chemical identity of some or all of the ingredients that may or may not be
listed herein is confidential business information and is being withheld as permitted by 29 CFR
1910.1200 and various State Right-to-Know Laws.
BOELUBE 70200 MSDS
3
LOCTITE(R*)
MATERIAL SAFETY DATA SHEET
HENKEL TECHNOLOGIES
REVISION DATE: 04/12/2006
ISSUE DATE: 04/12/2006
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: LOCTITE(R) 242(R) THREADLOCKER MEDIUM STRENGTH
ITEM NO.: 24221
PRODUCT TYPE: ANAEROBIC SEALANT
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
1001 TROUT BROOK CROSSING
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: 860.571.5100
EMERGENCY TELEPHONE: 860.571.5100
INTERNET: WWW.LOCTITE.COM
2. COMPOSITION/INFORMATION ON INGREDIENTS
HAZARDOUS COMPONENTS
%
ACGIH TLV
OSHA PEL
OTHER
POLYGLYCOL DIMETHACRYLATE
25852-47-5
60-100
NONE
NONE
NONE
POLYGLYCOL OLEATE
9004-96-0
10-30
NONE
NONE
NONE
SACCHARIN
81-07-2
1-5
NONE
NONE
NONE
SILICA, AMORPHOUS, FUMED,
TWA
CRYSTALLINE-FREE
RESPIRABLE
112945-52-5
1-5
6 MG/M3 TWA
10 MG/M3 TWA
3 MG/M3
CUMENE HYDROPEROXIDE
1-5
DUST
NONE
NONE
1 PPM
80-15-9
MG/M3)
(6
SKIN
(WEEL),
1 PPM,
SKIN
TWA,
(WEEL)
PROPYLENE GLYCOL
MG/M3
57-55-6
(WEEL)
1-5
NONE
NONE
TWA,
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW:
PHYSICAL STATE: LIQUID
COLOR: BLUE
ODOR: MILD
HMIS:
HEALTH
FLAMMABILITY
PHYSICAL HAZARD
PERSONAL PROTECTION
10
2*
1
1
SEE SECTION 8
WARNING:
CAUSES EYE IRRITATION.
MAY CAUSE SKIN IRRITATION.
MAY CAUSE ALLERGIC SKIN REACTION.
MAY CAUSE RESPIRATORY TRACT IRRITATION.
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES
POTENTIAL HEALTH EFFECTS:
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
SKIN CONTACT: MAY CAUSE ALLERGIC SKIN REACTION. MAY CAUSE SKIN
IRRITATION.
EYE CONTACT: CONTACT WITH EYES WILL CAUSE IRRITATION.
INGESTION: NOT EXPECTED TO BE HARMFUL BY INGESTION.
EXISTING CONDITIONS AGGRAVATED BY EXPOSURE:
EYE, SKIN, AND RESPIRATORY DISORDERS.
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
4. FIRST AID MEASURES
INHALATION:
REMOVE TO FRESH AIR. IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL
ATTENTION.
SKIN CONTACT:
WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES. WASH
CLOTHING BEFORE REUSE. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
EYE CONTACT:
FLUSH WITH COPIOUS AMOUNTS OF WATER, PREFERABLY, LUKEWARM WATER FOR AT
LEAST
15 MINUTES, HOLDING EYELIDS OPEN ALL THE TIME. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM. OBTAIN MEDICAL ATTENTION.
5. FIREFIGHTING MEASURES
FLASH POINT: GREATER THAN 93 DEG. C (200 DEG. F) TAGLIABUE CLOSED CUP
AUTOIGNITION TEMPERATURE: NOT AVAILABLE
FLAMMABLE/EXPLOSIVE LIMITS-LOWER %: 2.6% (PROPYLENE GLYCOL)
FLAMMABLE/EXPLOSIVE LIMITS-UPPER %: 12.5% (PROPYLENE GLYCOL)
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIRE FIGHTING PROCEDURES: NONE
UNUSUAL FIRE OR EXPLOSION HAZARDS: NONE
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SULFUR. OXIDES OF NITROGEN. IRRITATING
ORGANIC
VAPORS.
6. ACCIDENTAL RELEASE MEASURES
ENVIRONMENTAL PRECAUTIONS:
PREVENT PRODUCT FROM ENTERING DRAINS OR OPEN WATERS.
CLEAN-UP METHODS:
SOAK UP WITH INERT ABSORBENT. STORE IN A PARTLY FILLED, CLOSED
CONTAINER
UNTIL DISPOSAL.
7. HANDLING AND STORAGE
HANDLING:
AVOID CONTACT WITH EYES, SKIN AND CLOTHING. AVOID BREATHING VAPOR AND
MIST.
WASH THOROUGHLY AFTER HANDLING.
STORAGE:
FOR SAFE STORAGE, STORE AT OR BELOW 38 DEG. C (100 DEG. F). KEEP IN A
COOL,
WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME. KEEP
CONTAINER
TIGHTLY CLOSED UNTIL READY FOR USE.
INCOMPATIBLE PRODUCTS: REFER TO SECTION 10.
FOR INFORMATION ON PRODUCT SHELF LIFE CONTACT HENKEL CUSTOMER SERVICE
AT
(800) 243-4874.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS:
NO SPECIFIC VENTILATION REQUIREMENTS NOTED, BUT FORCED VENTILATION MAY
STILL
BE REQUIRED IF CONCENTRATIONS EXCEED OCCUPATIONAL EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT
SKIN
CONTACT. NEOPRENE GLOVES. BUTYL RUBBER GLOVES. NATURAL RUBBER GLOVES.
EYE/FACE PROTECTION: SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE
SHIELDS.
SEE SECTION 2 FOR EXPOSURE LIMITS.
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: LIQUID
COLOR: BLUE
ODOR: MILD
VAPOR PRESSURE: LESS THAN 5 MMHg AT 27 DEG. C (80 DEG. F)
pH: NOT APPLICABLE
BOILING POINT/RANGE: GREATER THAN 149 DEG. C (300 DEG. F)
MELTING POINT/RANGE: NOT AVAILABLE
SPECIFIC GRAVITY: 1.1 AT 23.9 DEG. C (75 DEG. F)
VAPOR DENSITY: NOT AVAILABLE
EVAPORATION RATE: NOT AVAILABLE
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT (n-OCTANOL/WATER): NOT AVAILABLE
VOC CONTENT: 4.48%; 49.3 GRAMS/LITER (EPA METHOD 24)
10. STABILITY AND REACTIVITY
STABILITY: STABLE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SULFUR. OXIDES OF NITROGEN. IRRITATING
ORGANIC
VAPORS.
INCOMPATABILITY:
STRONG OXIDIZERS. FREE RADICAL INITIATORS. STRONG REDUCING AGENTS.
ALKALIS.
OXYGEN SCAVENGERS. OTHER POLYMERIZATION INITIATORS. COPPER. IRON. ZINC.
ALUMINUM. RUST.
CONDITIONS TO AVOID:
SEE "HANDLING AND STORAGE" (SECTION 7) AND "INCOMPATABILTY" (SECTION
10).
11. TOXICOLOGICAL INFORMATION
PRODUCT TOXICITY DATA:
ACUTE ORAL LD50: GREATER THAN 10,000 MG/KG (RAT).
ACUTE DERMAL LD50: GREATER THAN 5000 MG/KG (RABBIT).
CARCINOGEN STATUS:
HAZARDOUS COMPONENTS
CARCINOGEN
NTP CARCINOGEN
IARC CARCINOGEN
OSHA
POLYGLYCOL DIMETHACRYLATE
25852-47-5
NO
NO
NO
POLYGLYCOL OLEATE
9004-96-0
NO
NO
NO
SACCHARIN
81-07-2
NO
NO
NO
SILICA, AMORPHOUS, FUMED,
CRYSTALLINE-FREE
112945-52-5
NO
NO
NO
CUMENE HYDROPEROXIDE
80-15-9
NO
NO
NO
PROPYLENE GLYCOL
57-55-6
NO
NO
NO
LITERATURE REFERENCED TARGET ORGAN & OTHER HEALTH EFFECTS:
HAZARDOUS COMPONENTS
HEALTH EFFECTS TARGET ORGANS
POLYGLYCOL DIMETHACRYLATE
25852-47-5
ALLERGEN, IRRITANT
POLYGLYCOL OLEATE
9004-96-0
IRRITANT
SACCHARIN
81-07-2
NO TARGET ORGANS
SILICA, AMORPHOUS, FUMED,
CRYSTALLINE-FREE
112945-52-5
NUISANCE DUST
CUMENE HYDROPEROXIDE
CORROSIVE,
80-15-9
ALLERGEN, CENTRAL NERVOUS SYSTEM,
PROPYLENE GLYCOL
57-55-6
IRRITANT
IRRITANT, MUTAGEN
12. ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: NOT AVAILABLE
13. DISPOSAL CONSIDERATIONS
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL GOVERNMENTAL
REGULATIONS.
EPA HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
14. TRANSPORT INFORMATION
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: UNRESTRICTED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: UNRESTRICTED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: UNRESTRICTED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
MARINE POLLUTANT: NONE
15. REGULATORY INFORMATION
UNITED STATES REGULATORY INFORMATION:
TSCA 8(B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES
CONTROL ACT INVENTORY.
TSCA 12(B) EXPORT NOTIFICATION: 4-METHOXYPHENOL (150-76-5).
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMUS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH HAZARD, DELAYED HEALTH
HAZARD
CERCLA/SARA 313:
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING
REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND COMMUNITY
RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372). CUMENE HYDROPEROXIDE (CAS# 8015-9).
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE DOMESTIC
SUBSTANCES LIST.
WHMIS HAZARD CLASS: D.2.B
16. OTHER INFORMATION
THIS MATERIAL SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS
VERSION
IN SECTIONS: 15
PREPARED BY:
KYRA KOZAK WOODS, PRODUCT SAFETY AND REGULATORY AFFAIRS SPECIALIST
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION DOES NOT ASSUME
RESPONSIBILITY FOR ANY RESULTS OBTAINED BY PERSONS OVER WHOSE METHODS
HENKEL
CORPORATION HAS NO CONTROL. IT IS THE USER'S RESPONSIBILITY TO
DETERMINE THE
SUITABILITY OF HENKEL'S PRODUCTS OR ANY PRODUCTION METHODS MENTIONED
HEREIN
FOR A PARTICULAR PURPOSE, AND TO ADOPT SUCH PRECAUTIONS AS MAY BE
ADVISABLE
FOR THE PROTECTION OF PROPERTY AND PERSONS AGAINST ANY HAZARDS THAT MAY
BE
INVOLVED IN THE HANDLING AND USE OF ANY OF HENKEL CORPORATION'S
PRODUCTS. IN
LIGHT OF THE FOREGOING, HENKEL CORPORATION SPECIFICALLY DISCLAIMS ALL
WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY
AND
FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR USE OF HENKEL
CORPORATION'S PRODUCTS. HENKEL CORPORATION FURTHER DISCLAIMS ANY
LIABILITY
FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST
PROFITS.
C704 NCP-2 BATTERY TERMINAL PROTECTOR by NOCO
Page 1 of 5
Genie Industries, Inc.
Redmond
C704 NCP-2 BATTERY TERMINAL PROTECTOR
FileName
Language
000009
English
NOCO
Internal ID
Revision Date
6/7/2005
Table Of Contents
SECTION I PRODUCT & COMPANY IDENTIFICATION
SECTION II HAZARDOUS INGREDIENTS
SECTION III PHYSICAL DATA
SECTION IV FIRE & EXPLOSION HAZARDS
SECTION V HEALTH HAZARD DATA
SECTION VI REACTIVITY DATA
SECTION VII SPILL OR LEAKAGE PROCEDURES
SECTION VIII SPECIAL PROTECTION INFORMATION
SECTION IX SPECIAL PRECAUTIONS
SECTION X HAZARDOUS MATERIAL IDENTIFICATION
Hazards
MSDS State
NFPA
HMIS
Health
1
Flammability
1
Reactivity
0
Other
B
(Active)
MSDS
MATERIAL SAFETY DATA SHEET
900701
SECTION I
PRODUCT & COMPANY IDENTIFICATION
PRODUCT NUMBER: 900701
PRODUCT NAME: C704 NOCO(R*) NCP-2 BATTERY TERMINAL PROTECTOR
HMIS CODES:
HEALTH
1
FLAMMABILITY 1
REACTIVITY
0
MANUFACTURER'S NAME:
THE NOCO(R*) COMPANY
CLEVELAND, OH 44122
EMERGENCY TELEPHONE NO.: (800) 424-9300
INFORMATION TELEPHONE NO.: (800) 456-6626
DATE OF PREPARATION: 07-JUNE-05
http://genie.complyplus.com/MSDS/print_bare.asp?S=520&ShowTOC=1&ShowHazardR... 4/20/2010
C704 NCP-2 BATTERY TERMINAL PROTECTOR by NOCO
SECTION II
Page 2 of 5
HAZARDOUS INGREDIENTS
% BY WT
CAS NO.
INGREDIENT
PEL PPM
TLV PPM
TLV MG/M3
UEL
90
PROPRIETARY
MINERAL OIL
NONE
NONE
5.0
N/A
SARA HAZARD: NONE (NOT LISTED - TITLE III, SECTION 313)
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED A SUSPECTED ANIMAL CARCINOGEN BY THE NATIONAL
TOXICITY PROGRAM, THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER, OR THE
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION.
PURSUANT TO PROPOSITION 65:
CERTAIN RAW MATERIALS USED IN MAKING THIS PRODUCT MAY CONTAIN SMALL AMOUNTS OF
MATERIALS AS IMPURITIES WHICH ARE REGULATED BY PROPOSITION 65. SEE SECTION X.
SECTION III
PHYSICAL DATA
BOILING RANGE: ABOVE 900 DEG. F
VAPOR DENSITY: HEAVIER THAN AIR
SPECIFIC GRAVITY: .970
APPEARANCE & ODOR: RED, LUBRICANT-LIKE
SOLUBILITY IN WATER: NO
EVAPORATION RATE: SLOWER THAN ETHER
VOLATILE: NEGLIGIBLE
SECTION IV
FIRE & EXPLOSION HAZARDS
FLASH POINT: 475-COCF
LEL: SEE SECTION II
UEL: SEE SECTION II
EXTINGUISHING MEDIA:
EXTINGUISH WITH DRY CHEMICAL, CO2, WATER SPRAY, FOAM, SAND OR EARTH AND FOAM
MAY CAUSE FROTHING. NOTE THAT WHILE WATER FOG EXTINGUISHERS ARE ALSO
ACCEPTABLE, DO NOT APPLY A DIRECT STREAM OF WATER ON BURNING PRODUCT BECAUSE
IT MAY CAUSE SPREADING & INCREASE FIRE INTENSITY.
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING.
http://genie.complyplus.com/MSDS/print_bare.asp?S=520&ShowTOC=1&ShowHazardR... 4/20/2010
C704 NCP-2 BATTERY TERMINAL PROTECTOR by NOCO
Page 3 of 5
UNUSUAL HAZARDS: NONE KNOWN
SECTION V
HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: (SEE SECTION II HAZARDOUS INGREDIENTS)
ROUTES OF ENTRY:
INHALATION: NO
SKIN: YES
INGESTION: YES
EFFECTS OF OVEREXPOSURE:
SKIN:
SHORT TERM SKIN CONTACT IS NOT EXPECTED TO CAUSE SKIN IRRITATION.
PROLONGED OR REPEATED CONTACT MAY CAUSE REDNESS, BURNING, AND DERMATITIS.
EYE:
THIS MATERIAL MAY CAUSE EYE IRRITATION. DIRECT CONTACT MAY CAUSE BURNING,
TEARING AND REDNESS.
INHALATION:
THIS PRODUCT HAS LOW VOLATILITY AND SO IS NOT EXPECTED TO CAUSE RESPIRATORY
TRACT IRRITATION.
INGESTION:
INGESTION OF THIS MATERIAL MAY CAUSE IRRITATION OF THE DIGESTIVE TRACT.
CHRONIC:
CANCER: NO INFORMATION FOUND IN STANDARD REFERENCES.
EMERGENCY AND FIRST AID PROCEDURES:
INGESTION:
IF SWALLOWED DO NO INDUCE VOMITING, GIVE 2 OR 3 CUPS OF MILK OR WATER TO DRINK.
SEEK MEDICAL ATTENTION.
INHALATION:
IF IRRITATION OF NOSE OR THROAT DEVELOPS, MOVE AWAY FROM SOURCE OF EXPOSURE
AND INTO FRESH AIR.
EYE CONTACT:
FOR DIRECT CONTACT, FLUSH THE AFFECTED EYE(S) WITH GENTLE STREAM OF CLEAN WATER
FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION.
SKIN CONTACT:
DO NOT USE GASOLINES, THINNERS, OR SOLVENTS TO REMOVE PRODUCTS FROM SKIN.
WIPE MATERIAL FROM SKIN AND REMOVE CONTAMINATED CLOTHING. CLEANSE AFFECTED
AREA(S) THOROUGHLY BY WASHING WITH MILD SOAP AND WATER AND, IF NECESSARY, A
WATERLESS SKIN CLEANER. IF IRRITATION OR REDNESS DEVELOPS AND PERSISTS, SEEK
MEDICAL ATTENTION.
SECTION VI
REACTIVITY DATA
http://genie.complyplus.com/MSDS/print_bare.asp?S=520&ShowTOC=1&ShowHazardR... 4/20/2010
C704 NCP-2 BATTERY TERMINAL PROTECTOR by NOCO
Page 4 of 5
STABILITY: STABLE
INCOMPATIBILITY:
AVOID CONTACT WITH STRONG OXIDIZING AGENTS. EXTENDED EXPOSURE TO HIGH
TEMPERATURES MAY CAUSE DECOMPOSITION.
HAZARDOUS DECOMPOSITION PRODUCTS:
THERMAL DECOMPOSITION IN THE PRESENCE OF AIR MAY YIELD MAJOR AMOUNTS OF
OXIDES OF CARBON AND MINOR AMOUNTS OF OXIDES OF SULFUR AND NITROGEN.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
SECTION VII
SPILL OR LEAKAGE PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
WASH DOWN ANY EXCESS LIQUID WITH WATER.
WASTE DISPOSAL METHOD:
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL
REGULATIONS.
SECTION VIII
SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: NONE
PROTECTIVE GLOVES: RECOMMENDED FOR PROLONGED OR REPEATED CONTACT.
EYE PROTECTION: SAFETY GLASSES
VENTILATION: NONE
OTHER PROTECTIVE EQUIPMENT: NONE
SECTION IX
SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
DO NOT STORE NEAR INCOMPATIBLE SUBSTANCES. (SEE SECTION VI)
OTHER PRECAUTIONS: NONE
PURSUANT TO PROPOSITION 65:
PROPOSITION 65 APPLIES TO LIST OF CHEMICALS NAMED BY THE GOVERNOR OF
CALIFORNIA AS CARCINOGENS OR REPRODUCTIVE TOXINS.
WARNING REQUIREMENTS FOR SPECIFIC CHEMICALS TAKE EFFECT ONE YEAR AFTER THEY ARE
ADDED TO THE GOVERNOR'S LIST. OTHER CHEMICALS ALREADY ADDED TO THE GOVERNOR'S
LIST WILL BE REGULATED LATER UNDER PROPOSITION 65.
http://genie.complyplus.com/MSDS/print_bare.asp?S=520&ShowTOC=1&ShowHazardR... 4/20/2010
C704 NCP-2 BATTERY TERMINAL PROTECTOR by NOCO
SECTION X
Page 5 of 5
HAZARDOUS MATERIAL IDENTIFICATION
COMMUNICATION OF PHYSICAL PROPERLY, HEALTH, AND SAFETY INFORMATION IS A KEY
FACTOR IN OUR PRODUCT SAFETY PROGRAM. WITH THIS INFORMATION YOU CAN BETTER
FULFILL YOUR OBLIGATION TO EDUCATE EXPOSED PERSONNEL IN THE PROPER HANDLING
TECHNIQUES REQUIRED TO MAINTAIN SAFETY IN THE WORKPLACE. LISTED IN THIS
SECTION IS NPCA-HMIS CLASSIFICATION FOR THIS PRODUCT.
HMIS CLASSIFICATION
HEALTH
FLAMMABILITY
REACTIVITY
PERSONAL PROTECTION
CODE:
1 - SLIGHT HAZARD
1 - SLIGHT HAZARD
0 - LEAST HAZARD
B - GLASSES AND GLOVES
THE ABOVE INFORMATION PERTAINS TO THIS PRODUCT AS CURRENTLY FORMULATED, AND IS
BASED ON THE INFORMATION AVAILABLE AT THIS TIME. ADDITION OF REDUCERS OR OTHER
ADDITIVES TO THIS PRODUCT MAY SUBSTANTIALLY AFTER THE COMPOSITION AND HAZARDS
OF THE PRODUCT. SINCE CONDITIONS OF USE ARE OUTSIDE OUR CONTROL, WE MAKE NO
WARRANTIES, EXPRESS OR IMPLIED, AND ASSUME NO LIABILITY IN CONNECTION WITH ANY
USE OF THIS INFORMATION.
Hosted as Genie Industries, Inc..
Comply Plus® Copyright © IHS Inc, 1999-2009. All Rights Reserved.
http://genie.complyplus.com/MSDS/print_bare.asp?S=520&ShowTOC=1&ShowHazardR... 4/20/2010
NYOGEL 760G
PRODUCT: 760G
REVISION DATE: 2003/02/10
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
MANUFACTURER:
NYE LUBRICANTS, INC.
12 HOWLAND ROAD
FAIRHAVEN, MA 02719
U.S.A.
MANUFACTURER EMERGENCY PHONE NUMBER:
CHEMTREC*:
800-424-9300.
508-996-6721 (8:00 AM - 5:00 PM ET WEEKDAYS).
PRODUCT NAME: NYOGEL 760G.
CHEMICAL FAMILY: LUBRICATING GREASE.
HMIS:
H
1
F
1
R
0
PPE SEC. 8
SECTION 2: INGREDIENT INFORMATION
C.A.S. CONC %
ACGIH-TLV
WGT/WGT
INGREDIENT
OSHA-PEL
OSHA-PEL
ACGIH-TLV
NAME
TWA
STEL
TWA
OIL MIST
5 MG/M3
NOT
AVAILABLE
5 MG/M3
STEL
NOT
AVAILABLE
INGREDIENT NAME
NIOSH REL TWA
NIOSH REL STEL
NIOSH IDLH
OIL MIST
5 MG/M3
10 MG/M3
2500 MG/M3
SECTION 2A: ADDITIONAL INGREDIENT INFORMATION
NOTE:
PRODUCT FORMULATION IS PROPRIETARY.
NO INGREDIENTS ARE KNOWN TO BE HAZARDOUS UNDER NORMAL USAGE.
SECTION 3: HAZARD IDENTIFICATION
EMERGENCY OVERVIEW:
MAY IRRITATE EYES. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
IRRITATION.
INHALATION OF OIL MIST OR VAPORS FROM MATERIAL AT HIGH TEMPERATURES MAY
IRRITATE RESPIRATORY PASSAGES.
ROUTE OF ENTRY: SKIN CONTACT, EYE CONTACT, INHALATION AND INGESTION.
EFFECTS OF ACUTE EXPOSURE:
EYE CONTACT: MAY CAUSE IRRITATION.
SKIN CONTACT: MAY CAUSE IRRITATION ON PROLONGED OR REPEATED CONTACT.
INHALATION:
OIL MIST AND VAPORS AT HIGH TEMPERATURES MAY IRRITATE RESPIRATORY
PASSAGES.
INGESTION: MAY CAUSE GASTRO-INTESTINAL IRRITATION.
EFFECTS OF CHRONIC EXPOSURE: SEE EFFECTS OF ACUTE EXPOSURE.
CARCINOGENIC EFFECTS:
IARC, NTP, AND OSHA DO NOT LIST THIS PRODUCT OR ITS INGREDIENTS AS
CARCINOGENS.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: NONE KNOWN.
TARGET ORGANS: RESPIRATORY PASSAGES AT HIGH TEMPERATURES, EYES, SKIN.
SECTION 4: FIRST AID MEASURES
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING.
WASH THOROUGHLY WITH SOAP AND WATER.
SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
EYE CONTACT:
FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
OBTAIN IMMEDIATE MEDICAL ATTENTION.
INHALATION:
REMOVE VICTIM TO FRESH AIR. IF NOT BREATHING, QUALIFIED PERSONNEL
SHOULD
ADMINISTER ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
INGESTION:
OBTAIN IMMEDIATE MEDICAL ATTENTION.
DO NOT INDUCE VOMITING, UNLESS DIRECTED TO DO SO BY A PHYSICIAN.
SECTION 5: FIRE FIGHTING MEASURES
FLAMMABILITY: NOT FLAMMABLE.
CONDITIONS OF FLAMMABILITY: AT TEMPERATURES AT OR ABOVE FLASH POINT.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM. WATER SPRAY.
SPECIAL PROCEDURES:
SELF-CONTAINED BREATHING APPARATUS REQUIRED.
FIREFIGHTERS SHOULD WEAR THE USUAL PROTECTIVE GEAR.
DO NOT LET FIREFIGHTING WATER RUNOFF ENTER A SEWER.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
FLASH POINT (DEG. C), METHOD:
CLOSED CUP.
ASTM D-93.
>400 DEG. F (204 DEG. C).
LOWER FLAMMABILITY LIMIT (% VOL): NOT AVAILABLE.
UPPER FLAMMABILITY LIMIT (% VOL): NOT AVAILABLE.
EXPLOSION DATA:
SENSITIVITY TO STATIC DISCHARGE: NOT AVAILABLE.
SENSITIVITY TO MECHANICAL IMPACT: NOT AVAILABLE.
HAZARDOUS COMBUSTION PRODUCTS:
CARBON MONOXIDE (CO).
TRACES OF OTHER TOXIC FUMES.
RATE OF BURNING: NOT AVAILABLE.
EXPLOSIVE POWER: NOT AVAILABLE.
SECTION 6: ACCIDENTAL RELEASE MEASURES
LEAK/SPILL:
CONTAIN THE SPILL.
PREVENT ENTRY INTO DRAINS, SEWERS, AND OTHER WATERWAYS.
AREA WILL BE SLIPPERY UNTIL CLEANED.
WEAR APPROPRIATE PROTECTIVE EQUIPMENT.
WIPE OR SCRAPE UP SPILLED MATERIAL.
WASH SPILL AREA AFTER MATERIAL PICK UP IS COMPLETE.
TRANSFER TO AN APPROVED CONTAINER FOR DISPOSAL OR RECOVERY.
OBSERVE PRECAUTIONS FROM OTHER SECTIONS.
FOLLOW APPLICABLE OSHA (29 CFR 1910.120), STATE AND LOCAL REGULATIONS.
SECTION 7: HANDLING AND STORAGE
HANDLING PROCEDURES AND EQUIPMENT:
WASH THOROUGHLY AFTER USING, PARTICULARLY BEFORE EATING OR SMOKING.
DO NOT EAT, DRINK OR SMOKE IN HANDLING AREA.
AVOID CONTAMINATION OF CIGARETTES OR OTHER TOBACCO PRODUCTS.
LAUNDER CONTAMINATED CLOTHING PRIOR TO REUSE.
USERS SHOULD BE ALERT TO THE POSSIBILITY THAT VERY SMALL PERCENTAGES OF
THE
POPULATION MAY DISPLAY UNEXPECTED ALLERGIC REACTIONS TO OTHERWISE
INNOCUOUS
INDUSTRIAL LUBRICANTS AND RAW MATERIALS.
STORAGE REQUIREMENTS:
STORE AWAY FROM INCOMPATIBLE MATERIALS.
DO NOT STORE IN OPEN OR UNLABELLED CONTAINERS.
SECTION 8: EXPOSURE CONTROLS / PERSONAL PROTECTION
PRECAUTIONARY MEASURES:
GLOVES/TYPE:
CHEMICAL RESISTANT GLOVES.
AVOID SKIN CONTACT.
RESPIRATORY/TYPE: NONE REQUIRED UNDER NORMAL USE.
IF EXPOSURE LIMIT IS EXCEEDED, WEAR A NIOSH APPROVED RESPIRATOR.
AVOID BREATHING OIL MIST.
EYE/TYPE: AVOID EYE CONTACT.
SAFETY GLASSES, GOGGLES OR FACE SHIELD.
IN ACCORDANCE WITH OSHA 29 CFR 1910.133.
FOOTWEAR/TYPE: SAFETY SHOES PER LOCAL REGULATIONS.
CLOTHING/TYPE: WEAR ADEQUATE PROTECTIVE CLOTHES.
APRON
OTHER/TYPE:
EYE WASH FACILITY SHOULD BE IN CLOSE PROXIMITY.
EMERGENCY SHOWER SHOULD BE IN CLOSE PROXIMITY.
VENTILATION REQUIREMENTS:
LOCAL VENTILATION IS GENERALLY NOT NECESSARY UNDER NORMAL CONDITIONS OF
USE
WITH ADEQUATE GENERAL VENTILATION. VENTILATION AND OTHER FORMS OF
ENGINEERING CONTROLS ARE THE PREFERRED MEANS FOR CONTROLLING CHEMICAL
EXPOSURES.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: SEMI-SOLID.
APPEARANCE & ODOR:
SLIGHT ODOR.
CLEAR TO LIGHT YELLOW.
SMOOTH GREASE.
ODOR THRESHOLD (PPM): NOT AVAILABLE.
VAPOR PRESSURE (MMHg): NEGLIGIBLE.
VAPOR DENSITY (AIR=1): NOT AVAILABLE.
VOLATILES (%): NONE
EVAPORATION RATE (BUTYL ACETATE = 1): NOT AVAILABLE.
BOILING POINT (DEG. C): NOT VOLATILE.
FREEZING POINT (DEG. C): NON-MELTING.
pH: NOT AVAILABLE.
SPECIFIC GRAVITY @ 20 DEG. C: (WATER = 1, @ 4 DEG. C). 0.91 @ 25 DEG. C
SOLUBILITY IN WATER (%): INSOLUBLE.
COEFFICIENT OF WATER\OIL DIST.: NOT AVAILABLE.
VOC: NONE
SECTION 10: STABILITY AND REACTIVITY
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS.
CONDITIONS OF INSTABILITY: PYROLYSIS.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
INCOMPATIBLE SUBSTANCES: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: SEE HAZARDOUS COMBUSTION PRODUCTS.
SECTION 11: TOXICOLOGICAL INFORMATION
SENSITIZATION TO PRODUCT: NOT AVAILABLE.
REPRODUCTIVE EFFECTS: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
SYNERGISTIC MATERIALS: NOT AVAILABLE.
SECTION 12: ECOLOGICAL INFORMATION
ENVIRONMENTAL TOXICITY: NO DATA AT THIS TIME.
ENVIRONMENTAL FATE: NO DATA AT THIS TIME.
SECTION 13: DISPOSAL CONSIDERATIONS
WASTE DISPOSAL:
CONTACT A LICENSED WASTE-DISPOSAL CONTRACTOR FOR DETAILED
RECOMMENDATIONS.
MANY STATES CLASSIFY WASTE LUBRICANTS AS "HAZARDOUS", WHICH MEANS
DISPOSAL
CAN ONLY BE A LICENSED FIRM. FOLLOW APPLICABLE FEDERAL, STATE, AND
LOCAL
REGULATIONS.
SECTION 14: TRANSPORT INFORMATION
DOT: NOT REGULATED.
SECTION 15: REGULATORY INFORMATION
USA REGULATORY INFORMATION:
SARA HAZARD CATEGORIES SECTIONS 311/312:
IMMEDIATE (ACUTE) HEALTH HAZARD: NO.
DELAYED (CHRONIC) HEALTH HAZARD: NO.
FIRE HAZARD: NO.
SUDDEN RELEASE OF PRESSURE: NO.
REACTIVE: NO.
SARA SECTION 313: NOT REGULATED.
TSCA INVENTORY:
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
SECTION 16: OTHER INFORMATION
SUPPLIER MSDS DATE: 2003/02/10
DATA PREPARED BY: GSM
DISCLAIMER:
WHILE THE INFORMATION AND RECOMMENDATIONS SET FORTH HEREIN ARE BELIEVED
TO
BE ACCURATE AS OF THE DATE HEREOF, NYE LUBRICANTS, INC. MAKES NO
WARRANTY
WITH RESPECT THERETO AND DISCLAIMS ALL LIABILITY WITH RESPECT THEREON.
Hosted as Genie Industries, Inc..
Comply Plus® Copyright © IHS Inc, 1999-2009. All Rights Reserved.
U.S. DEPARTMENT OF LABOR
OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
FORM APPROVED OMB NO.: 44-R1387
MATERIAL SAFETY DATA SHEET
REQUIRED UNDER USDL SAFETY AND HEALTH REGULATIONS FOR SHIP REPAIRING,
SHIPBUILDING, AND SHIPBREAKING (29 CFR 1915, 1916, 1917)
01/07/05
SECTION I
MANUFACTURER'S NAME: ORGANIC PRODUCTS COMPANY
ADDRESS (NUMBERS, STREET, CITY, STATE, AND ZIP CODE):
1963 E. IRVING BLVD.
IRVING, TEXAS 75060
TELEPHONE NUMBER FOR INFORMATION: (972) 438-7321
EMERGENCY TELEPHONE NUMBER:
CHEM-TEL: (800) 255-3924
OUTSIDE USA: (813) 248-0585
CHEMICAL NAME AND SYNONYMS: SENTRY SEAL
PAINT UN1263
TRADE NAME AND SYNONYMS: F-1000 SENTRY SEAL
CHEMICAL FAMILY: N/A
FORMULA: N/A
SECTION II HAZARDOUS INGREDIENTS
PAINTS, PRESERVATIVES, & SOLVENTS
%
TLV (UNITS)
PIGMENTS
CATALYST
VEHICLE
SOLVENTS
TOLUENE
CAS: 108-88-3
ADDITIVES
OTHERS
30 - 60%
100 PPM
ALLOYS AND METALLIC COATINGS
%
TLV (UNITS)
BASE METAL
ALLOYS
METALLIC COATINGS
FILLER METAL PLUS COATING OR CORE FLUX
OTHERS
HAZARDOUS MIXTURES OF OTHER LIQUIDS, SOLIDS, OR GASES
(UNITS)
%
TLV
SECTION III PHYSICAL DATA
BOILING POINT (DEG. F.): 230 DEG. F
SPECIFIC GRAVITY (H2O=1): .87
VAPOR PRESSURE (MMHg.) 65 DEG. F: 20
PERCENT, VOLATILE BY VOLUME (%):
VAPOR DENSITY (AIR=1): 3.2
EVAPORATION RATE ( = 1): 2.4
SOLUBILITY IN WATER: NIL
APPEARANCE AND ODOR: AROMATIC ODOR, HEAVY THICK PASTE.
SECTION IV FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): 45 DEG. F CLOSED
FLAMMABLE LIMITS:
LEL:
UEL:
EXTINGUISHING MEDIA: CARBON DIOXIDE OR DRY CHEMICAL, REGULAR FOAM.
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE WITH
PRESSURE
ON DEMAND.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
KEEP AWAY FROM PILOT LIGHT, LIGHTS, FLAMES, SPARKS, HEATERS, SMOKERS.
SECTION V HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: 100 PPM
EFFECTS OF OVEREXPOSURE:
FATIGUE, HEADACHE, MENTAL CONFUSION, STRONG DEGREASER OF SKIN. EYE
SEVERE
IRRITATION, UNCONSCIOUSNESS, NAUSEA IF SWALLOWED, VOMITING.
EMERGENCY AND FIRST AID PROCEDURES:
REMOVE TO FRESH AIR. WASH AND FLUSH AFFECTED AREAS WITH WATER AND SOAP,
FLUSH EYES, DO NOT INDUCE VOMITING IF SWALLOWED. KEEP WARM AND QUIET;
CALL
FOR MEDICAL HELP.
SECTION VI REACTIVITY DATA
STABILITY:
UNSTABLE ( )
STABLE
(X)
CONDITIONS TO AVOID: AVOID HEAT, SPARKS, AND FIRES
INCOMPATABILITY (MATERIALS TO AVOID): STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
HAZARDOUS POLYMERIZATION:
MAY OCCUR
( )
WILL NOT OCCUR (X)
CONDITIONS TO AVOID:
SECTION VII SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
ELIMINATE ALL IGNITION SOURCES, WEAR SUITABLE PROTECTIVE EQUIPMENT.
COLLECT IN A FLAMMABLE WASTE CONTAINER FOR DISPOSAL.
WASTE DISPOSAL METHOD:
DESTROY BY LIQUID INCINERATION. USE ABSORBENT MATERIAL AND DEPOSIT IN
TOXIC
LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGS.
SECTION VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (SPECIFY TYPE):
AIR SUPPLIED MASKS IN CONFINED AREAS, IF LARGE QUANTITIES USED.
VENTILATION:
LOCAL EXHAUST: PREFERRED
MECHANICAL (GENERAL): ACCEPTABLE
SPECIAL:
OTHER:
PROTECTIVE GLOVES: YES, IF LARGE QUANTITIES USED, NITRILE RUBBER.
EYE PROTECTION: GOGGLES, IF LARGE QUANTITIES USED.
OTHER PROTECTIVE EQUIPMENT: SAFETY SHOWER AND EYE BATH.
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
WEAR RESISTANT GLOVES SUCH AS NITRILE RUBBER, EYE PROTECTION, CHEMICAL
SPLASH GOGGLES, PROTECTIVE EQUIPMENT TO PREVENT PROLONGED SKIN CONTACT.
OTHER PRECAUTIONS:
*U.S. GOVERNMENT PRINTING OFFICE: 1981-340.979/429
ORGANIC PRODUCTS CO. BELIEVES THAT THE INFORMATION CONTAINED IN THIS
MSDS IS
CORRECT AS OF THIS DATE. HOWEVER, BECAUSE THE MATERIAL MAY BE USED
UNDER
CONDITIONS OVER WHICH ORGANIC PRODUCTS HAD NO CONTROL OR IN WAYS WE
CANNOT
ANTICIPATE, WE GIVE NO WARRANTY, EXPRESSED OR IMPLIED, AS TO THE
ACCURACY OF
THE INFORMATION AND ASSUME NO RESPONSIBILITY FOR ANY DAMAGE TO PERSON,
PROPERTY OR BUSINESS ARISING FROM SUCH USE. MOREOVER, IT IS THE
RESPONSIBILITY OF THE PURCHASER OR USER OF THIS MATERIAL TO ENSURE THAT
IT
IS PROPERLY AND SAFELY USED.
FORM: OSHA-20
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement