Club Car 1990 DS Gasoline Golf Car Owner's Manual
Add to my manuals20 Pages
Club Car DS Gasoline 1990 is a golf car designed to provide safe, efficient, and long-lasting performance. It features a gasoline-powered engine, forward and reverse gears, and a top speed of 19 mph. The car also has a number of safety features, including a parking brake, seat belts, and a horn. It can be used for various purposes such as transporting people and equipment on golf courses, in warehouses, or other large properties. Its compact size allows it to navigate narrow paths and tight spaces, making it an ideal choice for personal or fleet use.
advertisement
1990
DS Gasoline
Golf
Car
Owner's Manual
Manual Number
1015439
Effective August 1, 1989
0889A00000
This instruction manual should be read completely and carefuHy before attempting t o drive or service this car. Failure t o follow the instructions in this manual could result in severe personal injury or death.
NOTE: If this vehicle is equipped as a Fairway Villager four-passenger vehicle, supplements to this manual are required. If this information does not accompany this manual, contact CLUB CAR, INC., Customer
Service and request the Fairway Villager supplement.
Safety
Details:
It is important to note that some statements throughout this manual are preceded by the words DANGER,
WARNING, CAUTION or
NOTE.
We recommend that you take special notice of these safety procedures for your protection. Safety procedures are essential and must be followed.
A danger indicates an immediate hazard which will result in severe personal injury or death.
A warning indicates an immediate hazard which could result in severe personal injury br death.
A caution indicates hazards or unsafe practices which could result in minor personal injury or product or property damage.
NOTE: A note provides key information to make procedures easier or clearer.
The safety procedures listed below must be followed whenever the car is being repaired or serviced. Other specific warnings appear throughout this manual.
Only trained people should repair or service this car. Everyone doing even simple repairs or service should follow the correct procedures and obey the warningslisted in this manual as well as the maintenance and service manual.
Always wear safety glasses or eye protection when servicing the car.
Always use insulated tools when working around batteries or electrical connections.
Improper use of this vehicle or the failure t o maintain it could result in decreased vehicle performance or severe personal injury.
Any modification or change t o the vehicle which affects the stability or increases the speed beyond the factory specifications could result in severe personal injury or death.
Gasoline/Battery Vapors
-
-
Explosive
- from the area o f the car. Only service in well-ventilated area.
Engines produce carbon monoxide which is an odorless, deadly poison.
ENCLOSED AREA WITHOUT PROPER VENTILATION.
D O NOT OPERATE I N AN
If any of the warning labels become damaged, have been removed or cannot be easily read, they should be replaced immediately. Contact your CLUB CAR Distributor/Dealer.
TABLE
OF
CONTENTS
Foreword
Page
Safety Details
..........................................................
Inside Front Cover
.........................................................................
1
Vehicle Feature Identification
Modelldentification
SafetyCommittee
......................................
.................................................................
4
Pre-Operation Checklist
Fuelinglnstructions
Controls
.
.
2-3
...................................................................
4
..............................................................
4
.................................................................
..........................................................................
6
Driving Instructions
Storage
.................................................................
TowingandTransporting
8
..............................................................
9
..........................................................................
Maintenance
10
...................................................................
1 1
...................................................................
Lubricationchart
EngineOilLevel
13
....................................................................
........................................................................
Capacities
Battery
........................................................................
Jumpstarting
Cleaning
14
14
.....................................................................
..........................................................................
15
Subsequent Owner Registration
Specifications
Warranty,
........................................................
....................................................................
.............................................................
InsideBackCover
Foreword
Congratulations for having chosen the finest golf car on the market today1 Over 25 years of the most advanced development, engineering and field experience known t o this industry has gone into the manufacture of your golf car. With your choice of the CLUB CAR Model DS Gasoline golf car as your personal or fleet vehicle, you have joined a select group of discriminating owners who look for the very best and w h o have shown their concern for safety, efficiency and long-term lasting value. This owner's manual is designed to instruct you, or anyone you may rent or loan the golf car to, i n the safe operation of the CLUB CAR
DS Gasoline golf car. In addition, this manual will acquaint you with the normal preventive maintenance required i n order to provide you safe, optimum vehicle performance.
If any repairs or service need t o be performed, there are certain basic mechanical procedures that should be known and understood. Without such basic knowledge, repairs or service to this golf car may render the golf car unsafe which could result i n severe personal injury or death. For this reason, we advise that all repairs and service be performed by an authorized CLUB CAR Distributor/Dealer or representative except as specified in the Periodic Service Schedule. Should you require further information, please contact your nearest CLUB CAR Distributor/Dealer who can provide you with technical advice, service, parts, or the
CLUB CAR DS Gasoline Golf Car Maintenance and Service Manual. For the name and address of your nearest CLUB CAR Distributor/Dealer, contact CLUB CAR, INC., P.
4658, U.S.A., Telephone: 404/863-3000.
The Club Car Limited Warranty appears on the inside back cover of this manual. No other warranties express or implied are contained herein. Your Distributor/Dealer has checked your car(s) prior t o delivery to you and will provide you with a completed warranty registration card.
CLUB CAR, INC., shall not be tiable for errors contained herein or for incidental or consequential damages which result from the use of t h e material in this manual.
This manual should be considered a permanent part of this vehicle. It should stay with t h e vehicle when sold to provide the next owner w i t h important operating, safety, and maintenance information.
b
OPERATING INSTRUCTIONS
LABEL
\
f
OPERATING INSTRUCTIONS
Study hod Und*nland Controls. Be S u n Evevone Is Saaled.
Before Ddrlng Cw. Read Safe$ Wamfngs b c r l c d AboroPcdals.
Mare Sure Whe*lc Are h m e d In Dedrr6 DlrecUon.
.Be Sua Nolhlng lr InYour PaL.
lam
Key To ON Pollllon.
F.
fonard
H .
Neutral
b
Dadred Poclthn;
R. Revetce slowly Push Accnleralor Pedal
To
Increase Speed. Park Orah* w i l l R.I~~O When Accelerator Pedalis Pushed.
.
l o
Slop C r . UaIeale A c ~ e l a n l o r
e
A111, stopping Ear, FIrmlrPurh Park B n h a UnUl I1 Locks.
a
Remora Hey And Place Shlfl Lever In The Straight Up Neutral
Posltlon
When
Car Is Not I n
U u .
w
rot
Further oelallr. Read Ownafl Manual.
Vehicle
Feature
Y R K BRAKE PEDAL
BRAKE PEDAL
I
1 I
OIL WARNING
L I G H T '
MOVING PARTS
I
ACCESS DOOR
SAFETY
WARNING
LABEL
,
.
GASOLINE TANK
DANGER LABEL (ON BODY
E R Y
DANGER
FORWARD-REVERSE
LEVER
/
/
/
CHOKE
./
.
/
*r"d
\
/:
&
+
\
:P,
*
P
j i i
NEUTRAL LOCK-OUT CAM
Model Identification:
The serial number of your CLUB CAR is stamped on a data plate mounted on the frame directly under the right dash (Example: AG9005-123456).
NOTE: Always mention this number-when ordering parts or making inquiries
(See Figure
1
).
Safety Committee:
If the golf car is going to be rented or is part of a fleet, w e strongly recommend that a safety committee be appointed. One of the main concerns of this committee should be the safe operation of the golf cars. This includes such things as where the golf cars should be driven, who should and who should not drive the golf cars, instructing all first time drivers in the controls and operation of the golf car, seeing that the golf cars are well maintained in safe driving condition and h o w the various rules are t o be enforced. The safety committee should include all these items at a minimum and such others as the committee feels necessary or appropriate.
, , ,
-,
Figure 1
Pre-Operation Checklist:
Your CLUB CAR has been thoroughly inspected and adjusted by the factory and by your CLUB CAR Distributor/
Dealer. However, when receiving your new CLUB CAR(s) you should become familiar with its controis and operation and carefully inspect each car to be satisfied w i t h its condition before accepting delivery.
Only trained people should repair or service this car. Everyone doing even simple repairs or service should follow the correct procedures and obey the warnings listed i n this manual
as
well as t h e maintenance and service manual.
Always wear safety glasses o r eye protection when servicing the car.
Use this checklist as a guide to i'nspect your car. Any problems must be corrected only by your CLUB CAR
Distributor/Dealer or a trained mechanic.
Visual
inspection
-
Look for the following on your vehicle:
General:
All the parts should be i n place and properly installed. Be sure that all nuts, bolts and screws are tight. All hose clamps should be tight. Check the starter belt for tightness.
Warning Labels:
Check that all warning and operation labels are i n place (See Pages 2 & 3).
Tires:
Check tire pressure. It should be
12-14 psi.
Engine:
Check for proper engine oil level (See Page 12). Be sure spark plug wire is in clamp on top of engine.
Fuel:
Check fuel level (See Fueling instructions
-
Page 5).
Be sure the plastic
has
been removed from the b o t t o m of the seat before operating vehicle. Failure t o do so may result in a fire or property damage.
Performance inspection
-
After you have familiarized yourself with the car's controls (See Page 5) and have read and understood the driving instructions (See Page the following:
Brakes:
Be sure that the brakes work properly. Both rear wheels should brake properly and the pedal should not go more than halfway to the floor. if it does, have brakes adjusted.
Park Brake:
The park brake should lock the wheels when latched and should release when the accelerator or brake pedal is pushed.
Steering:
The car should be easy to steer and should not have free play i n the steering wheel.
Accelerator Pedal:
As the accelerator pedal is pushed, the engine should start and the car should come smoothly up to full speed. When the pedal is released it should return to the original position and the engine should stop gradually.
Governor:
Check the speed of the car.
It should run 12-14 MPH on a level surface.
General:
Listen for any unusual noises such as squeaks or rattles. Check the car's ride and performance.
Have a trained mechanic investigate anything unusual.
A n y modification or change t o t h e vehicle which affects t h e stability o r increases the speed beyond t h e factory specifications c o u l d result i n severe personal injury o r death.
Fueling
Instructions:
GASOLINE
-
FLAMMABLE
-
EXPLOSIVE
-
N O SMOKING
Keepb sparks and flames f r o m t h e area o f the car. Only service o r repair in well-ventilated area. Never pour gasoline i n t o tank while engine is hot or running.
To avoid electric arc caused b y static electricity, t h e fuel storage/pumping device m u s t be grounded.
If pump i s n o t grounded, t h e vehicle must be grounded t o the pump before and during the fueling operation.
1.
Lift and remove seat bottom.
2.
Fuel tank is located on passenger side of car. Remove fuef cap and fill the fuel, tank with regular or unleaded gasoline. Do not use gasohol or gasolines with methyl alcohol blends.
To allow for expansion, do n o t f i l l higher than one (1 inch f r o m t o p o f tank.
Be sure t o clean up any spilled gas before operating vehicle.
3.
Replace fuel cap on tank, being sure cap is tightly sealed to tank.
4. Replace seat bottom
Controls:
If renting or loaning this car, make sure t h a t t h e driver is familiar with all controls and operating instructions before allowing the car t o be driven.
Key Switch
-
The key switch is mounted on the dash to the right of the steering column (See Figure 2).
It has two (2) positions, "on" and "off" which are clearly labeled. Remove key i n the " o f " position only.
Figure
2
Turn key switch t o "off" and remove key w h e n car is n o t i n use t o avoid unintentional starting o f the car.
Forward-Reverse Control
-
The forward-reverse shift lever is located below and to the right of the driver's right knee on the seat support panel (See
Figure 3). The lever has three (3) distinct positions: F (forward), N (neutral), and R (reverse). Rotate the lever toward the driver (F) to run the car in forward and toward the passenger
(R) to run the car in reverse. When the lever is in the straight up or neutral (N) position, the car will not run and the engine wiil stop if shifted to this position while running.
Figure
3
D o not shift forward and reverse lever while car i s i n motion. Always bring car
to a
full stop before shifting lever t o avoid injury t o a n unsuspecting passenger and damage t o the car.
Turn key switch "off" and place shift lever in neutral when leaving car
to
avoid unintentional starting o f the car,
Buzzer w i l l sound as a warning when car is in reverse.
Neutral Lock-Out -The golf car has a neutral lock-out circuit that prevents the driver from starting the car i n neutral. If the car is started in forward or reverse and shifted to neutral the engine stops running.
For the convenience of the trained and experienced mechanic, there is a neutral lock-out cam located on the back of the forward and reverse lever. If the neutral lock-out cam is pulled out approximately
?4 of an inch and rotated one half turn until it snaps. into place, the cam will be i n the SERVICE position (See Figure 4). This w i l l allow the mechanic to run the car in neutral for certain maintenance procedures. With the cam i n this position the car will not r u n if the forward and reverse lever is placed i n the forward or reverse positions. To put the car back into the
OPERATE position, pull the cam out approximately % of a n inch and rotate it one half turn until it snaps back into place (See Figure 5).
Neutral
Forward
SERVICE
Position
Figure
4
Neutral Forward
OPERATE Position
s
Figure
5
With cam. in SERVICE position, car m a y m o v e suddenly i f f o r w a r d and reverse lever is shifted o r accidentally bumped while engine is running.
Block front and rear wheels t o prevent vehicle movement,
NOTE: If car will not run, check to be sure neutral lock-out cam is i n OPERATE position.
Accelerator Pedal
-
The accelerator pedal is the pedal on the right with the word
"GO"
molded i n it
(See
Figure
6).
When the key switch is "on" and the shift lever is i n either forward or reverse and the accelerator pedal is pushed, the parking brake will be automatically released and the engine wiu start.
As
the pedal is pushed further, the engine speeds up and the car will begin to move i n the preselected direction (forward or reverse). Push the accelerator pedal further to increase vehicle speed. When the accelerator pedal is released, the engine will stop running.
NOTE: For safety, the is set for
DS Gasoline car is equipped with a governor to control the maximum speed and
12-14 MPH on a level surface.
The accelerator pedal differs from that of an automobile in the following way: Depressing the accelerator will release the parking brake if engaged. Depressing the accelerator automatically starts the vehicle moving.
Each time the accelerator pedal is released, the engine will quit running.
D o n o t tamper with the car's governor. To do so wit[ void t h e limited warranty, result
in
engine and other components and couid result in severe personal injury due
to
unsafe speeds. damage to
Brake Pedal
-
The brake pedal is the large pedal on the le-ft with the word "STOP" molded i n it
(See Figure
7). To slow or stop the car, push the brake pedal with your right foot.
Parking Brake Pedal
-
The parking or park brake pedal is the small raised portion in the upper left corner of the brake pedal with the word "PARK" molded in it
(See Figure 7). The words "Park Brake" are marked above this pedal. To set the park brake, push the brake pedal firmly and tilt the park brake portion of the pedal forward with foot (See Figure 8).
The park brake pedal will release when the accelerator or brake pedal is pushed. The parking brake has many locking teeth so that the brake can be locked i n several positions.
Figure 6 Figure 7
Always set the park brake f i r m l y before leaving the golf car t o prevent the car frorn rolling.
Figure 8
Choke
-
The choke is located below and to the left of the driver's left knee on the seat support panel (See Figure 9). If on a cool morning the car is hard to start, simply push i n the choke cover with your left hand to activate the choke. Release the choke after the engine starts and runs smoothly.
Oil tight
-
The
DS
Gasoline golf car is equipped with a dash mounted oil light above the steering column {See Figure 10). When the oil light is on, it indicates low engine oil. Oil should be added before further use. The car should never be driven if the oil light comes on and stays on. If the oil light goes on and off, you may proceed, but add oil at the first opportunity.
If the oil level is correct and light stays on, have a trained and experienced mechanic check the car.
Driving Instructions:
No one should drive the golf car without first being instructed i n the proper operation and use of the golf car controls. An experienced operator should accompany each first time driver on a short test drive before they operate the golf car alone. Only licensed drivers should be allowed to drive this vehicle.
Do not drive under the influence of alcohol, drugs or medications.
Figure
9
If renting or loaning this golf car, make sure the driver is familiar with ail controls and operating procedures before allowing the car to be driven.
This car is not specially equipped for handicapped persons. Be sure all persons can properly operate the car prior t o allowing them to drive.
Figure 10
To insure safe operation of the DS Gasoline golf car, follow all of the pro'cedures listed below exactly and i n order. Read and understand all instructions prior to driving the car.
Starting the Car:
1. Enter the car.
2.
Be sure everyone is seated.
3. Study and understand controls.
4. Read safety warnings located above pedals.
5.
Make sure wheels are turned in desired direction.
6. Be sure nothing is i n your path.
7. Turn key to "on" position.
8. Select direction by placing shift lever i n desired position F
= forward or R
= reverse.
9.
Slowly push accelerator pedai. The park brake pedal will release and the engine will start. Push accelerator further and the car will move and the speed will increase as the accelerator is depressed until governed speed is reached.
No more than two people should be on
t h e vehicle at one time.
Stop car before shifting forward and reverse lever. Failure
t o do so could result in injury to an unsuspecting
passenger and damage to the golf car.
A
buzzer will sound as a warning when the car is in reverse.
When Driving The Car:
e
Operate the car from the driver's seat only.
@
Remain seated i n moving car and hold on to prevent falis.
@
e a e e
0
Keep arms, legs, feet and entire body inside car t o prevent getting them caught between t h e golf car and the ground or other objects.
Drive slowly i n turns and drive slowly straight up and down slopes t o prevent turning the vehicle over.
Reduce speed for poor driving conditions such as w e t grass or rough terrain to avoid losing control of the car.
Do not use on public roads. This car is n o t designed or intended for street use and should not be licensed for use on public roads.
Obey all local rules concerning golf cars.
Cars should be driven only in specified areas by trained people.
Stopping the,Car:
1. To stop the car, release the accelerator pedal and push the brake pedal with your right foot.
When stopped on a hiil, use the brake pedal t o hold your position, not the accelerator pedal.
Driving through deep water may affect the brakes. Check their effectiveness by pressing the brake pedal gently. If the car does not slow down at the normal rate, continue t o apply the brakes gently until they dry out and normal performance returns.
Parking and Leaving the Car:
1.
After stopping the car, firmly push park brake pedal until it locks. This will prevent the car from roiling.
2.
Turn the key to "off" and place shift lever in the straight up "neutral" position when leaving the car.
This avoids unintentional starting of car. Remove key when car is not in use.
To avoid being struck by vehicle, do not stand in front of or behind vehicle.
Towing
and
Transporting:
Towing
-
All
CLUB CARS are equipped with tow bar attaching points both front and rear. For breakdown towing and single-car towing, a light-duty tow bar is available. For multi-car towing, a heavy-duty t o w bar is available. Observe a l l of the following warnings and precautions when towing.
Never t o w a golf car on public streets or highways.
Use only approved CLUB CAR t o w bars.
Extreme caution should be used when towing any golf car.
D o not exceed five (5) miles per hour towing speed.
D o n o t t o w more than one
( 4
) car with another CLUB CAR.
If
11 inches should be used. Only heavy-duty t o w bars should be used for multi-car towing. Never t o w more than five
(5) cars a t one time.
D o n o t allow people in cars being towed.
Avoid sudden starts, stops and tight turns,
Turn key switch "off" and place shift lever i n neutral when car is in tow.
Transporting On A Trailer
-
If your golf car must be transported over long distances or on public highways, it should be done on an approved trailer observing all the following warnings and precautions.
For use on public roads the trailer must meet all federal, state and local requirements such as taillights, brake tights, etc.
Always use an approved trailer that
has
a load rating of 1200 Ibs, per golf car. (Example: A 2-car
traiier should be rated at 2 x 1200
=
2400 lbs.).
The golf car should be securely tied down t o the trailer. The golf car's key switch should be "off", the shift lever i n "neutra1"and the park brake firmly applied and locked.
When towing a trailer, normal speeds should be reduced and care should be used when turning a corner due t o the added length of the trailer.
Never t o w a golf car behind a passenger vehicte or truck unless it is on an approved trailer.
Remove the windshield before transporting a golf car on a trailer.
Storage:
To prepare your golf car for extended off season storage:
Turn key switch "off", remove key and place forward and reverse lever i n neutral position to avoid unintentional starting of the vehicle.
1.
Store in a cool place. This w i l l prevent self discharge of the battery.
If the battery appears to be weak, have it charged by a trained mechanic.
Batteries i n l o w state of charge will freeze at l o w temperatures.
D o not attempt t o charge a battery if it
is
frozen or the case is
bulged.
Discard battery. Frozen batteries can explode.
2.
Using a siphon with a suction device (See Figure 1 I), gas out of the tank into an approved gasoline container,
Never attempt t o siphon gasoline using a hose without a built-in suction device.
Never attempt t o siphon gasoline using your mouth.
Figure 11
Gasoline
-
Flammable
-
Explosive
-
D o N o t Smoke. Keep sparks and flames away f r o m area of cars.
D o n o t anempt t o drain gasoline while engine
is
running
or
hot.
Store gasoline only i n an approved gasoline container in a weli-ventilated area. Keep o u t of reach of children. Keep sparks, fire and flames away f r o m area o f gasoline.
Engines produce carbon monoxide which i s an odorless, deadly poison. D O NOT OPERATE IN AN
ENCLOSED AREA WITHOUT PROPER VENTILATION.
3.
Be sure the tank has been drained and the stored gasoline has been removed from the area. Place the forward and reverse lever i n "neutral". Place neutral lock-out cam i n the SERVICE position. Turn key on. Run the engine until all of the gasoline has been drawn out of the fuel lines and carburetor and engine stalls. Return neutral lock-out cam to the OPERATE position. Turn the key switch to the
"off" position and remove key.
4.
To protect the engine, remove the spark plug and pour
'/2
ounce of SAE 10 weight oil into the engine through the spark plug hole. Rotate the engine several times and then reinstall the spark plug.
NOTE: When restarting engine, it may smoke excessively due to the oil added i n step 4.
5. Increase the tire pressure to 20 psi.
6. Grease front suspension and do all quarterly periodic lubrication shown in lubrication chart (See Page 12).
7.
Thoroughly clean body, seats and underside of car.
8.
Do
not latch the park brake. Block the wheels t o prevent the car from roliing.
To Return Stored Cars To Service:
1. Fill the gas tank with regular or unleaded gasoline (See Fueling Instructions
-
Page 5).
Gasoline
- -
-
Smoking. Keep sparks and flames from t h e area o f t h e car.
Only service or repair in well-ventilated area. Never pour gasoline i n t o tank while engine is h o t or running,
D o n o t overfill. Be sure t o clean u p any spilled gas before operating vehicle.
2.
Readjust tire pressure to 12-14 psi.
3. Perform the pre-operation checks (See Page 4) before returning the car to service.
Maintenance:
General information
-
To be, sure you have a trouble-free car, it is very important to follow an established preventive maintenance program. This is the least expensive maintenance requirement. Preventive mainte- nance means regularly scheduled services which include certain maintenance procedures that are performed on the cars even though the cars are functional. A good preventive maintenance program can prevent more expensive repairs from being required. Any car that is not functioning correctly should be removed from use until it is properly repaired. periodic service.
Only trained people should repair or service this car. Everyone doing even simple repairs or service should follow the correct procedures and obey t h e warnings listed i n this manual
as
well as t h e maintenance and service manual.
Turn key switch "off", remove key, and place forward and reverse lever i n neutral position prior t o servicing.
Always wear safety glasses o r eye protection w h e n servicing this car.
M o v i n g p a r t s
-
D o
n o t attempt t o service the car with engine running.
H o t
-
D o n o t attempt t o service h o t engine or exhaust system. Can cause extreme burns.
Remove spark plug w i r e t o avoid unintentional starting o f engine when servicing car.
Do n o t w e a r loose clothing and remove jewelry, such as rings, watches, chains, etc,, before servicing vehicle.
AIways use insulated tools when working around batteries or electrical connections.
Periodic
Service
Schedule:
Regular Interval
Daily Service by Owner
Weekly Service by Owner
-
Monthly Service by Owner
Quarterly Service by Owner or Trained Personnel
Semi-Annual Service by
Trained Personnel Only
(Every 100 Rounds or every 50 hours of operation)
Annual Service by Trained
Personnel Only
(Every
200 Rounds or every 100 hours of operation)
Service
Check steering and linkages
Check brake operation
Check to be sure all warning labels are i n place (see Pages 2 and
3)
Check tires for wear and damage
Check engine for proper operation
Check accelerator/governor linkage for free movement and return
Check reverse warning buzzer for proper operation
Check engine air intake screen to be sure it is not clogged
Check to be sure park brake latches and releases properly
Check speed of vehicle
Clean battery terminals and wash dirt off battery case
Wash engine and underside of car
Check all electrical wires and grounds for tightness or damage
Inspect car for loose hardware and tighten as required
Check all daily items listed above
Check exhaust system for leaks
Check brake pedal play
Check tire pressure and adjust to
12-14 psi
Check air intake expansion chamber for leaks
Check engine oil level
Check fuel tank, lines, cap, pump and carburetor for fuel leakage
Check all daily and weekly items listed above
Do quarterly lubrication as shown i n iubrication chart on Page 12
Check a l l daily, weekly and monthly items listed above
Check, clean and adjust brakes
Check front wheel alignment
Check air filter
Check spark plug wire and boot for damage and proper routing
Check head gasket and exhaust header/pipe flange connection gasket
Check starter/generator belt tension
Check condition of muffler lnspect drive belt
Do semi-annual lubrication as shown i n lubrication chart on Page 12
Check ail daily, weekly, monthly and quarterly items listed above
Replace fuel filters
Inspect starter/generator brush length
Inspect, clean and regap spark plug
Do annual lubrication as shown i n lubrication chart on page
12
Check all items listed above
If your periodic service inspection reveals any problems, do n o t operate until repairs are made. Failure
to make necessary repairs could result i n fire, severe personal injury or death.
Periodic Lubrication Schedule and Lubrication Chart:
Regular interval
Quarterly by
Owner or
Trained Personnel
Semi-Annually by
Trained Personnel
Only
Annually by Trained
Personnel Only
Service
1.
Brake shaft bearing
2.
Brake linkage and pivots
3. Accelerator push rod pivots
4. Throttle and governor pivots
5. Front suspension
(9
6 .
Check/fill drive unit to plug level
7. Check/fiil transmission to plug level
8. Inspect front wheel bearings and repack as necessary
Recommended Lubricant
Dry Graphite Lube
CLUB CAR part kt1012151
Dry Graphite Lube
CLUB CAR part
#1012151
Dry Graphite Lube
CLUB CAR part
#1012151
Dry Graphite Lube
CLUB CAR part
#I012151
Chassis Lube
80-90
API Class GL-3 or
AGMA Class
5
EP Gear Lube
VVT. API Class GL-3 or
80-90
AGMA Class 5 EP Gear Lube
Chassis Lube
SAE
10-40,
Classification SF or SE
Engine Oil:
Engine oil level should be checked at least monthly. The oil light on the dash should warn you if your oil is getting l o w (See Figure
33).
Engine must be i n level position. Remove oil level gauge b y unscrewing f r o m crankcase. Check oil
by
inserting gauge i n t o oil filler hole. D o not screw oil gauge in when checking. If oil does n o t reach the upper line (mark) o f t h e gauge, add oil until it does.
D o
not
overfill w i t h
oil.
When oil is at proper level, screw oil gauge i n and hand tighten securely.
Figure
12
Figure 13
Capacities:
Battery:
Engine Crankcase
Transmission
Drive Unit
Gasoline Tank
Tire Pressure
4 0 oz.
20 oz.
22 oz.
7.4
U.S.
Gal.
12-14 psi
Always wear safety glasses or eye protection when servicing the car.
Always use insulated tools when working around batteries or electrical connections.
Battery
-
Explosive Gases. Keep sparks, flames, cigarettes away. Ventilate when charging i n an enclosed
space.
Poison
-
Contains acid
-
Causes severe burns
-
Avoid contact w i t h skin, eyes or clothing.
Antidotes:
External
-
Flush w i t h water. Call physician immediately. internal
-
Drink large quantities o f milk o r water, follow w i t h milk o f magnesia or vegetable oil.
Call physician immediately.
Eyes
-
Flush w i t h water for 15 minutes. Call physician immediately.
The battery in the DS Gasoline is a 12 volt, maintenance free battery that does not require periodic watering of the battery (See Figure 14).
Any corrosion around the positive (+) or negative (-) terrninais should be washed off with a solution of baking soda and water. Rinse. Be sure terminals are tight. Let the terminals dry and then spray them with CLUB CAR battery protector spray, part #1014305.
Be sure battery holddowns are properly tightened. Torque to
9-14 in.-lbs.
A loose holddown may allow the battery to become damaged from vibration or jarring. A holddown that is too tight
may
buckle or crack the battery case.
If battery appears weak, have it charged by a trained mechanic.
Jump Starting
The Engine:
Figure 14
To start a car with a dead battery, use another battery of the same voltage, and proper jumper cables.
Always wear safety glasses o r eye protection when servicing the car.
Procedures other than those which follow could cause severe injury or death f r o m battery acid spray, explosion,
or
charging system overload.
Never connect t o the negative post o f the "Dead" battery, connect t o frame (See Figure 15).
Never allow the t w o cars t o touch each other.
Never allow the jumper cable clamps t o touch each other.
Never lean over the battery when making connections.
Place forward and,reverse lever i n neutral position, place neutral lock-out cam in the SERVICE position.
Figure 16):
1, Connect one end of red jumper cable to positive (+)terminal of the stalled battery.
2. Connect other end of red jumper cable to positive (+)terminal of booster battery.
3,
Connect one end of black jumper cable to negative (-)terminal of
. battery.
4. Connect other end of black jumper cabie to stalled car frame away from gasoline and battery as in Figure 15.
To remove the cables, reverse the above procedures exactly.
Figure
15
RED JUMPER CABLE
POSITIVE (+J TO POSITIVE
(+)
I
I
TO GROUND
TO GROUND
BLACK JUMPER
NEGATIVE
(-)
POST
ON
BOOSTER BATTERY TO
Figure 16
The CLUB CAR is eq&ipped with a reaction injection molded plastic cowl and a compression molded fiber reinforced piastic body.
Use only mild dishwashing liquid soap with a sponge or soft cloth for normal cleaning.
Minor scratches or blemishes i n the body can be buffed out using most commercially available polishing
Your golf car seat'will last longer with proper cleaning. Mild soap or detergent with a sponge or soft cloth for normal cleaning is recommended. For stubborn or imbedded dirt, a soft bristle brush may be used,
Do not use any harsh detergents or cleaning solvents on the body, cowl or seat.
Battery acid, fertilizers, tars, asphalt, creosote, paint or chewing gum should be removed immediately to prevent possible stains.
Subsequent owner Registration:
In the event that this vehicle has been bought as a used car from another individual or from a distributor/ dealer, re-registration is necessary. This w i l l enable us to contact you if the need arises. Please send your name, address and serial number(s) of the car(s) to CLUB CAR, INC., P.O. Box 4658, Augusta, GA
30917-
4658, ATTN: Vehicle Registration.
D S
Gaso
ine Specifications
Overall Length
Overall Width
Overall Weight
Wheelbase
...............
.91.25"
...............
.47.25"
...............
.................
.65.5'"
Ground Clearance
Front Wheel Tread
............
.4.5"
............
.34.5"
Rear Wheel Tread
Weight
Speed
............
....................
...........
.........
Curb to Curb Clearance Circle
.38.5"
.12-14 MPH, governed
....
.17'6"
.............
.14' at 12 MPH Braking Distance
Engine
.....................
Carburetor
Governor
8.5 hp single cylinder, air cooled
..................
.Float bowl with fixed jets and impulse fuel pump
....................
Internally geared in transmission
Ignition
Drive Unit
.....................
..................
Transmission
CDI electronic ignition
.Double reduction helical gear with 12.64 to 1 final ratio
..........,......
Forward, reverse, and neutral, fully synchronized
Steering
....................
Suspension
..................
Torque Converter
Frame-Chassis
Rear Body
.............
.............. absorbers
.Automatic, variable speed, dry type
.Twin I-Beam welded aluminum
..................
Front Body
Paint
...................
Reaction injection molded plastic
......................
.Two part epoxy synthetic enamel
Seating Capacity
Electrical System
..,..........
.2
.............
.12 volt, 325 cold cranking amp battery and 35 amp charging capacity starter/generator
Brakes
Tires
......................
Fuel Tank wheel. Park brake is automatically released.
,18.00 x 8.50-8.00 tubeless,
4-ply
rated
...................
.7.4 gal. U.S., regular or unleaded
Standard Equipment
..........
Compartments, Scorecard and Pencil Holder, Reverse Warning Buzzer,
Wear Resistant Floormats and Pedals, Front and Rear Bumpers, Side
Optional Equipment
Rubber Rails, Two-Way Ignition Key, Automatic Release Park Brake, Quick
Release Bag Strap Buckles, CDI Electronic Ignition System, Synchromesh
Transmission with Forward, Reverse and Neutral;
12 volt 325 Cold
Cranking Amp Battery, Neutral Lock-Out, Low Oil Level Warning Light,
Fresh Air Intake System.
...........
.Canopy Top, Snap-On Tinted Windshield, Weatherproof Enclosure, Extra
Two-Bag Attachment, Sweater Basket, Rake Holder and Rake, Bagwell
Protector, Adjustable Seat Back, Wheei Covers, Power Rib Tires, Extra
Traction Tires, White Wall Tires, Club Insignia, I.D. Numbers, Accent
Stripe, Custom Colors, Stereo Radio, Ashtray, Lighting Package (High/
Low Headlights, Taillights, Brakelights and Horn), Lighting Package with
Turn Signals, Fuei Gauge, Hour Meter, Sand Bottle Kit, Woodgrain Trim,
Ice Cooler, Info Holder, Tee Holder, Extra Beverage Holders (2 or 4), Trailer
Hitch, Rear View Mirror, Permanent Tow Bar for 'multiple car towing
(factory installation), Temporary Tow Bar for single car towing.
CLUB CAR, INC., reserves the right to change specifications and designs and without incurring any obligation or liability whatsoever. at any time without notice
1
- -
CLUB CAR LlMlTED TWO (2) YEAR WARRANTY
CLUB CAR, INC, "Manufacturer," warrants to the orrginal retail purchaser that its new DS Golf Car purchased from Manufacturer or an authorized distrrbutor or dealer
IS free from defects in materials and workmanship for a perlod of two (2) years from the date of purchase, subject to the terms and provisions contained herein
This limrted warranty covers materials and workmanshlp for a period of two (2) years from the date of purchase and repair labor costs for a period of one
(1) year from the date of purchase Such labor shall be performed only by Manufacturer, its authorized distr~butors or dealers, or a service agency approved by Manufacturer IF THE WARRANTY REGISTRATION FORM IS NOT COMPLETED AND RETURNED TO CLUB
CAR AT THE TIME OF THE ORIGINAL RETAIL SALE, PROOF OF DATE OF PURCHASE MUST BE PROVIDED
WITH ANY WARRANTY CLAIM For further rnformatron or to present a warranty claim, contact Warranty
Administrator, CLUB CAR, INC
, P
0
Box
4658,
Augusta, Georgia 30917-4658
U S A , (404) 863-3000
ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE
SHALLBEVOID AND EXCLUDED SUBSEQUENTTO TWO
(2)
YEARS FROM THE DATE OF PURCHASE
THE REPLACEMENT OR REPAIR OF THE GOLF CAR OR DEFECTIVE COMPONENT THEREOF IS
THE EXCLUSIVE REMEDY UNDER THIS WRITTEN WARRANTY OR ANY IMPLIED WARRANTY
MANUFACTURER MAKES N O OTHER REPRESENTATION OR WARRANTY OF ANY KIND, A N D N O
REPRESENTATIVE, EMPLOYEE, DISTRIBUTOR OR DEALER OF MANUFACTURER HAS THE
AUTHORITY TO MAKE OR IMPLY A N Y REPRESENTATION, PROMISE OR AGREEMENT WHICH I N
ANY WAY VARIES THE TERMS OF THlS LlMlTED WARRANTY.
LlMlTED WARRANTY EXCLUSIONS
Without limiting the generality of the foregoing in any way, and as part of its limited warranty exclus~ons,
Manufacturer does not warrant that its golf car is suitable for use on any particular golf course or terrain
As in the operation of any vehicle, a prudent driver will read and study the Owner's Manual, learn the proper operation of the controls, and exercise care and safe drlving habits
THE PROVISIONS OF THlS LIMITED WARRANTY SHALL NOT APPLY TO
(a) Normal maintenance services such as brake adjustments, steering and suspensron adjustments, linkage adjustments, recommended lubrication, oil changes, and filter replacements,
(b) All accessory options, bag straps, battery wires and connectors, body panels and trim pieces, charger plugs and receptacles, decals, drive and generator belts, filters, floormats, oils and lubricants, pedal pads, seats, spark plugs, fuses, tubes and hoses, and
(c) Tires, batterres and battery chargers (Warranted solely through their respective manufacturers)
Any warranty service whlch rncludes labor must be performed by Manufacturer, its authorized distributors or dealers, or a service agency approved by manufacturer.
THIS GOLFCAR IS INTENDED TO BE USED BY PERSONS PLAYING GOLF WITHIN THE CONFINES
OF A GOLF COURSE AND ANY OTHER USE RENDERS THE LlMlTED WARRANTIES EXPRESSED
HEREIN A N D ALL IMPLIED WARRANTiES NULL A N D VOID AND SAME ARE HEREBY EXCLUDED.
ALSO EXCLUDED FROM THlS LlMlTED WARRANTY ARE ANY AND ALL INCIDENTAL OR
CONSEQUENTIAL DAMAGES INCLUDING, BUT NOT LIMITED TO, LOSS OF USE, LOSS OF REVENUE,
LOSS OF TIME, OR INCONVENIENCE. Some states do not allow limitations on how long an ~mplred or exclusions may not apply to you
WARRANTY LIMITATIONS
a defectrve golf car or component thereof Replacement shall mean furnishing a new golf car or component thereof which
IS identrcal or reasonably equrvalent to the warranted product at no cost to purchaser during the two
(2) year lrmrted warranty period except for repair labor costs after the frrst year Repair shall mean remedyrng a defect in the golf car or component thereof at no cost to purchaser during the two except for repair labor costs after the first year
(2) year Irm~ted
If
Manufacturer elects to repair your golf car, it may use factory reconditioned parts or components.
Damage to a vehlcle or component thereof not resulting from a defect or which occurs due to unreasonable or unintended use, overload~ng, abuse or neglect (including farlure to provide reasonable or necessary maintenance as outlrned in the Owner's Manual), accident or alteration, includrng increasing the speed
IS excluded from the lrmited warranty
Thrs warranty gives you speclfic legal rights, and you may also have other rights which vary from state to state
Club Car,
Inc.
1 P.O. Box 4658
Augusta, Georgia
3091
7-4658 U.S.A.
1706-863-3000
O CLUB CAR,
INC.,
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project