BP500 System Overview Manual_051812

BP500 System Overview Manual_051812
Transforming the Control of Hot Tubs
BP500
BP500
SYSTEM OVERVIEW MANUAL
1
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Intellectual Property Advisement
All Intellectual property, as defined below, owned by or which is otherwise the
property of Balboa Water Group or its respective suppliers relating to the Balboa
Water Group BP500 Spa Control, including but not limited to, accessories, parts,
or software relating there to (the “System”), is proprietary to Balboa Water Group
and protected under federal laws, state laws, and international treaty provisions.
Intellectual Property includes, but is not limited to, inventions (patentable or
unpatentable), patents, trade secrets, copyrights, software, computer programs,
and related documentation, and other works of authorship. You may not infringe
or otherwise violate the rights secured by the Intellectual Property. Moreover,
you agree that you will not (and will not attempt to) modify, prepare derivative
works of, reverse engineer, decompile, disassemble, or otherwise attempt to
create source code from the software. No title to or ownership in the Intellectual
Property is transferred to you. All applicable rights of the Intellectual Property
shall remain with Balboa Water Group and its suppliers.
End User Warning
This Installation Manual is provided solely to aid qualified spa service technicians
in installing spas with control systems manufactured by Balboa Water Group.
Balboa controls have absolutely no end user serviceable parts. Balboa Water
Group does not authorize attempts by the spa owner/user to repair or service
any Balboa products. Non-qualified users should never open or remove covers,
as this will expose dangerous voltage points and other dangerous risks. Please
contact your dealer or authorized repair center for service.
2
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Warnings: Danger! Risk of Electric Shock!
3
t
All electrical work must be performed by a qualified electrician and must
conform to all national, state, and local codes.
t
Before making any electrical connections, make certain that the Main Power
breaker from the house breaker box has been turned off.
t
Do not attempt service of this control system. Contact your dealer or service
organization for assistance.
t
Do not permit any electric appliance, such as a light, telephone, radio, or
television within 5’ (1.5m) of a pool or spa.
t
Follow all owner’s manual power connection instructions.
t
Installation must be performed by a licensed electrician and all grounding
connections must be properly installed.
t
No user serviceable parts.
t
Water temperature in excess of 38˚C may be injurious to your health.
t
Disconnect the electrical power before servicing.
t
Keep access door closed.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
CAUTION
t
t
t
t
Test the ground fault circuit interrupter before each use of the spa.
Read the instruction manual.
Adequate drainage must be provided if the equipment is to be installed in a pit.
To ensure continued protection against shock hazard, use only identical
replacement parts when servicing.
t Install a VG Compliant suction guard that is suitably rated to match the
maximum flow rate marked.
WARNING:
Water temperature in excess of 38˚C may be injurious to your health.
Disconnect the electrical power before servicing.
Keep access door closed.
ATTENTION
t
t
t
Toujours verifier l’efficacite du disjoncteur differentiel avant d’utiliser le bain.
Lire la notice technique.
Lorsque l’appareillage est installe dans une fosse, on doit assurer un
drainage adequat.
t Afin d’assurer une protection permanente contre le danger de shock
electrique, lors de l’entretien employer seulement des pieces de rechange
identiques.
t Les prises d’aspiration doivent etre equipees de grilles convenant au debit
maximal indique.
AVERTISSEMENT:
Des temperatures de l’eau superieures a 38˚C peuvent presenter un danger pour
la sante.
Deconnecter du circuit d’alimentation electrique avant l’entretien.
Garder la porte fermer.
4
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
GFCI
It is required by code to install a Ground Fault Circuit Interrupter (GFCI) in the
supply power for a spa. This device will trip the breaker if there is an unsafe
electrical condition caused by a malfunctioning component or even the slightest
short to ground.
Note: Connect the control system only to a circuit protected by a Class A GFCI
mounted at least 5’ (1.52M) from the inside walls of the spa/hot tub and in line of
sight from the equipment compartment.
Refer to NEC (National Electrical Code), 2005 Edition, Article 680 for more
information.
5
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
TABLE OF CONTENTS
BP500 OVERVIEW
7
37
Meet the BP500 . . . . . . . . . . . . . . .8
Pumps, Operation . . . . . . . . . . . . . 38
BP500 Specifications . . . . . . . . . . . . .9
Circulation Pump Modes
BP500 Components
. . . . . . . . . . . . 10
Filtration and Ozone . . . . . . . . . . . . 40
System Dimensions . . . . . . . . . . . . .11
Freeze Protection . . . . . . . . . . . . . 41
MENUS AND PANEL OPERATION
12
Menus & Panel Operation . . . . . . . . . . 13
TP Panel Series . . . . . . . . . . . . . . .13
Clean-up Cycle (optional)
. . . . . . . . . . 40
. . . . . . . . . . 41
System Default Operation Settings
. . . . . . 42
Pumps . . . . . . . . . . . . . . . . . .42
. . . . . . . . . . . . . 14
Adjusting Filtration . . . . . . . . . . . . . 43
Warm/Cool Temperature Buttons . . . . . . . .14
Adjusting Filtration Time for F1 . . . . . . . .44
Light Button . . . . . . . . . . . . . . . .14
Adjusting Filtration Time for F2 . . . . . . . .49
Main Menu -- BP500 TP Series Control Panels
. .15
Filter Cycle 2: Optional Filtration . . . . . . . .49
Temperature Adjustment . . . . . . . . . . 16
Continuous Filtration (24 Hour Filtration) . . . . 56
Panel Navigation
Dual Temperature Ranges . . . . . . . . . . 17
GENERAL MESSAGES
60
Setting a High Temperature Range . . . . . . .18
Reminder Messages
Setting a Low Temperature Range . . . . . . .19
Suppressing Reminders . . . . . . . . . . . 62
Spa Light . . . . . . . . . . . . . . . . . 21
CHEK PH . . . . . . . . . . . . . . . . .65
Mode -- Ready and Rest . . . . . . . . . . . 22
CHEK CHEM . . . . . . . . . . . . . . . .65
Choosing between Ready and Rest Mode . . . .24
CLN FLTR . . . . . . . . . . . . . . . . .65
HOLD (Standby) . . . . . . . . . . . . . . 26
TEST GFCI . . . . . . . . . . . . . . . . .66
Drain Mode (if available) . . . . . . . . . . .27
CHNG WATR . . . . . . . . . . . . . . . .66
LOCK (Restricting Panel Operation) . . . . . . 28
CLN COVR. . . . . . . . . . . . . . . . .66
UNLK (Unlock, Allowing Panel Operation) . . . .30
FLIP . . . . . . . . . . . . . . . . . . . 31
Setting the 24 Hour Clock . . . . . . . . . . 32
Temperature Display (F/C) . . . . . . . . . . 34
The Balboa Water Group Spa Control App . . . . 36
6
SPA BEHAVIOR
. . . . . . . . . . . . 61
TRT WOOD . . . . . . . . . . . . . . . .67
CHNG FLTR . . . . . . . . . . . . . . . .67
CHNG CART . . . . . . . . . . . . . . . .67
Glossary . . . . . . . . . . . . . . . . . 68
INDEX
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
71
Transforming the Control of Hot Tubs
BP500
BP500Overview
Meet the BP500
7
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Meet the BP500
t5IFGJSTUPGBOFXTFSJFTPGTZTUFNT
t#BTFEPO#BMCPBTNPTUQPQVMBSNPEFMT
t8J'J3FBEZ
t/FXGFBUVSFTJOOFXFODMPTVSF
t)JHIFSGMBNFSFUBSEBOUBOEJNQBDUSFTJTUBOUNBUFSJBMT
t1SFTT)PMECVUUPOTGPSFBTFPGVTF
Incomparable system reliability
The BP500 is the first of a new series based on Balboa’s most popular models,
utilizing advanced technology and higher flame retardent and impact resistant
materials. Wi-Fi ready with press and hold buttons for ease of use, meet the
newly designed BP500.
No Documentation Needed
Without looking at a user manual, the user friendly inteface allows you to start
using your spa right away, and the sleek new topside panel includes a large
easy to read backlit LCD. With new press and hold button technology, setting
temperature and other common tasks have been simplified. User navigation is
intuitive and easier than ever, reducing customer service calls for help.
Wi-Fi Hardware Connections / Wireless System
Control
Now you can control your system wirelessly. With some additional hardware and
a few simple connections, anywhere that you get a Wi-Fi signal you can have full
control of your spa! Download the software by going to the Apple Apps store,
download the free spa app, then run through the quick setup and you're done.
8
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
BP500 Specifications
System Model
BP500 60 Hz BP15-BP500-BJ-M
TP600 Panel
System Part Numbers, Domestic
Part Number:
56278 4kW 800 Incoloy Heater Element
56279 4kW 825 Incoloy Heater Element
56280 4kW Titanium Heater Element
TP400T Panel
Topside Panels
TP 600
55673-05
TP400T
50260
TP400W
50259
Auxiliary Panels:
TP400W Panel
AX10A2
55919
Couplings (nuts and seals included)
Part No. 55911 2” Tailpieces (2-Speed Pump 1)
9
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
BP500 Components
1
2
2
1
Electric Housing Cover
2
Bi-directional Flow Heater
3
Heater Housing
4
Electronic Enclosure
5
Nut and Tailpiece
6
Support Legs
5
3
4
6
5
6
10
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
Mounting Dimensions
BP500
System Dimensions
11
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
BP500Menus and Panel Operation
Meet the BP500
12
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
.FOVTPanel Operation
TP PANEL SERIES
READY
JETS
TP600
RANGE FLTR1
AUX
LIGHT
HEAT
All TP panels shown on this page work with both BP500 models BP1500 and
BP1600 models. They all have capabilities for navigation, setting functions
and modes (time, temperature, filter cycles, preferences), sensor related
messages, reminder messages, diagnostic messages, and utilities such as
fault logs. .
(55673-05)
TP400T
(50260)
TP400W
(50259)
13
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Panel Navigation
Navigating the entire menu can be accomplished with two buttons:
1) Either temperature button (also, if the panel has a single TEMP icon)
2) The Light button
NOTE: Hereafter, all temperature buttons (i.e., “Warm” and “Cool”) will be
referred to as a TEMP button.
Warm/Cool Temperature Buttons
An “Action” Button:
WARM
COOL
t
Allows changing the Set Temperature
t
Provides a flashing screen, which prompts the user for further action
t
Changes preferences within a menu
Light Button
A “Choose” Button, depending on control panel configuration:
LIGHT
t
Turns the LED lights on and off
t
Enters the menus when numbers are flashing
t
Scrolls through the menu
t
Makes a selection (“Enter”)
Waiting for 10 seconds will return the panel to normal operation and a display
of spa status.
14
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Main Menu -- BP500 TP Series Control Panels
Main Menu
t
TEMP
t
MODE
t
TIME
t
FLIP
FLIP
t
LOCK
LOCK
t
HOLD
HOLD
t
FILTER No. 1
FILT1
t
FILTER No. 2
t
LITE TIMR *
t
PREF
t
UTIL
TEMP
MODE
TIME
FILT2
PREF
UTIL
BP1500 main menu_only 0930090734
* LITE TIMR — This menu item may or may not appear depending on a
manufacturer’s configuration.
15
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Temperature Adjustment
t
Press TEMP buttons for desired set temperature.
t
The numbers flash during temperature adjustment.
t
Press LIGHT to return to main menu; or, main screen returns in 5 seconds.
Temperature Adjustment with One TEMP Button on Panel.
Press TEMP buttons
for desired
set temperature.
t
1st TEMP button press causes temperature to flash.
t
2nd TEMP button press causes the temperature to change.
t
Press LIGHT to return to main menu; or, main screen returns in 5 seconds.
Press and Hold: Temperature Adjustment with One TEMP Button.
16
t
If a Temperature button is pressed and held when the temperature is
flashing, the temperature will continue to change until the button is released.
t
If only one temperature button is available and the limit of the
Temperature Range is reached when the button is being held, the
progression will reverse direction.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Dual Temperature Ranges
E FLTR1
READYREADY RANGERANGE
FLTR1 FLTR
High Range Arrow
READY
RANGE FLTR1
Low Range Arrow
The water temperature display will show
whether the system is in High or Low Range.
17
The BP500 system incorporates two temperature range settings that allows an
independent set temperature within each range. The High Range is designated
in the display by an “up” arrow, and the Low Range is designated in the display
by a “down” arrow.
These ranges can be used for various reasons, with a common use being a
“ready to use” setting vs. a “vacation” setting. Each range maintains its own set
temperature as programmed by the user. This way, when a range is chosen, the
spa will heat to the set temperature associated with that range.
t
High Range can be set between 80°F and 104°F.
t
Low Range can be set between 50°F and 99°F.
t
Freeze Protection is active in either range.
t
If no key activity occurs, main menu returns in 5 seconds.
t
More specific temperature ranges may be determined by the manufacturer.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Dual Temperature Ranges (cont.)
READY
JETS
Setting a High Temperature Range
RANGE FLTR1
AUX
LIGHT
HEAT
From the Main Screen,
press TEMP to view
current set temperature
RANGE
SET
JETS
RANGE
AUX
LIGHT
SET
HEAT
is displayed for the High Range
RANGE
SET
JETS
AUX
LIGHT
Press TEMP to set
desired temperature.
SET
HEAT
Press LIGHT to exit.
RANGE
18
is displayed with the new set temperature
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Dual Temperature Ranges (cont.)
READY
JETS
Setting a Low Temperature Range
RANGE FLTR1
AUX
LIGHT
HEAT
From the Main Screen,
press TEMP to view
current set temperature
RANGE
SET
JETS
AUX
RANGE
SET
JETS
19
SET
HEAT
is displayed
RANGE
RANGE
LIGHT
AUX
LIGHT
SET
HEAT
is displayed
Press TEMP to
Toggle Range Arrow
Up or Down
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Dual Temperature Ranges (cont.)
JETS
RANGE
AUX
LIGHT
HEAT
is displayed for Low Range
ANGE FLTR1
Press LIGHT to Exit to Low Range Temperature Menu
Press LIGHT to Exit to Low
Range Temperature Menu
AUX
LIGHT
HEAT
is displayed for Low Range
Press TEMP to set
desired temperature.
Exiting reverts the display back to the main screen.
RANGE FLTR1
SET
JETS
Press TEMP to set a low temperature set point.
RANGE FLTR1
SET
JETS
RANGE
Setting a Low Temperature Range (cont.)
RANGE
SET
AUX
LIGHT
HEAT
Press LIGHT to exit.
RANGE
20
is displayed with the new set temperature
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Spa Light
READY
JETS
21
RANGE FLTR1
AUX
LIGHT
HEAT
The Light button turns the spa light on and off.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Mode -- Ready and Rest
In order for the spa to heat, a pump needs to circulate water through the
heater. The pump that performs this function is known as the “heater pump.”
READY
JETS
RANGE FLTR1
AUX
LIGHT
The heater pump can be either a 2-Speed Pump 1 or a circulation pump.
HEAT
2-Speed Pump 1
If the heater pump is a 2-Speed Pump 1, READY Mode will circulate water
every 1/2 hour, using Pump 1 Low, in order to maintain a constant water
temperature, heat as needed, and refresh the temperature display. This is
known as “polling.”
READY
RANGE FLTR1
REST RANGE FLTR1
REST Mode will only allow heating during programmed filter cycles. Since
polling does not occur, the temperature display may not show a current
temperature until the heater pump has been running for a minute or two.
24 Hour Circulation Mode
Ready Mode
Rest Mode
If the spa is configured for 24HR circulation, the heater pump generally runs
continuously. Since the heater pump is always running, the spa will maintain set
temperature and heat as needed in Ready Mode, without polling.
In Rest Mode, the spa will only heat to set temperature during programmed
filter times, even though the water is being filtered constantly when in
Circulation Mode.
22
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Menu Detail – MODE – Ready and Rest
nu Detail – MODE – Ready and Rest
Mode -- Ready and Rest (cont.)
Ready Mode
t
READY
REST RANGE FLTR1
RANGE FLTR1
READY Mode will allow the spa to Poll and determine a need for heat. The
panel will maintain a “current” temperature display.
Rest Mode
RANGE FLTR1
Screen
REST RANGE FLTR1
RANGE FLTR1
REST RANGE
After one hour...
REST RANGE
REST RANGE
REST RANGE
REST RANGE
REST RANGE
REST RANGE
REST Mode will not Poll and will only heat during filter cycles. The panel will
not display a current temperature at all times.
t
The Main Screen will display normally during Filter Cycles or when the spa is
in use.
t
If the filtration pump has been off for an hour or more, and when any function
button (except Light) is pressed on the panel, the pump used in conjunction
with the heater will run so that the temperature can be sensed and displayed.
REST RANGE
REST RANGE
Rest Mode: The Screen will display RUN PUMP FOR TEMP if the
filtration pump has not run for over 1 hour.
FLTR1
t
REST RANGE
Sub-Menu Detail – MODE – Ready-in-Rest
Main Screen
J
Main Screen
Ready-in-Rest Mode Appears in the Display
04-11-09
READY/REST appears in the display if the spa is in Rest Mode and Jet 1
is pressed. It is assumed that the spa is being used and will heat to set
temperature. While Pump 1 High can be turned on and off, Pump 1 Low will run
until set temperature is reached, or 1 hour has passed. After 1 hour, the System
will revert to Rest Mode. This mode can also be reset by entering the Mode
Menu and changing the Mode.
04-11-09
REST RANGE
23
READY/REST RANGE
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Choosing between Ready and Rest Mode
READY
JETS
Press TEMP.
RANGE FLTR1
AUX
LIGHT
HEAT
Press TEMP
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
The temperature flashes.
24
Press LIGHT
repeatedly
for MODE
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Choosing between Ready and Rest Mode (cont.)
SET READY
JETS
AUX
SET
LIGHT
HEAT
JETS
In MODE, TEMP button toggles between SET READY and SET REST.
REST
AUX
LIGHT
HEAT
Choose SET READY or SET REST, then press LIGHT to set and exit.
SET READY
JETS
25
AUX
SET
LIGHT
HEAT
JETS
REST
AUX
LIGHT
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
HOLD (Standby)
Hold Mode is used to disable the pumps during service functions like cleaning or
replacing the filter.
RANGE
SET
JETS
AUX
LIGHT
SET
HEAT
Press TEMP to
desired hold
temperature
Main Screen
RANGE
SET
JETS
AUX
LIGHT
SET
HEAT
Press LIGHT
repeatedly to
HOLD
The clock will count down from 60 minutes.
SET
JETS
AUX
LIGHT
HEAT
Press TEMP to
Count Down
26
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
HOLD (Standby, cont.)
Drain Mode (if available)
SET
JETS
AUX
LIGHT
Some spas have a special feature that allows a pump to be employed when
draining the water. When available, this feature is a component of Hold Mode.
HEAT
t
Some spas will allow PUMPING OUT (Drain Mode) with JET 1 button.
t
Press JETS Button for Pump Out/Drain, only if Drain Mode is enabled.
t
Jet 1 will toggle pump on and off.
SET
JETS
AUX
LIGHT
HEAT
To Exit HOLD,
press TEMP or LIGHT
JETS
AUX
LIGHT
HEAT
To Main Menu
27
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
LOCK (Restricting Panel Operation)
Locking the panel prevents the spa from being used; it also prevents unwanted
temperature adjustments.
RANGE
SET
JETS
AUX
LIGHT
SET
Main Menu > LOCK
HEAT
Press TEMP
NOTE:
Main Screen
RANGE
SET
JETS
AUX
LIGHT
t
All automatic functions are still active.
t
Locking the Temperature allows Jets and other features to be used, but the
Set Temperature and other programmed settings cannot be adjusted.
t
Temperature Lock allows access to a reduced selection of menu items, which
include Set Temperature, FLIP, LOCK, UTIL, INFO and FALT LOG.
SET
HEAT
The temperature flashes.
Press LIGHT
repeatedly until
LOCK appears
SET
JETS
AUX
LIGHT
HEAT
Press TEMP
28
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
LOCK (Restricting Operation, cont.)
SET
SET
JETS
AUX
LIGHT
HEAT
JETS
Locks All Temperature
4FUUJOHT
LIGHT
HEAT
Locks All
Function Buttons
Press LIGHT to
Toggle
TEMP or PANL
SET
SET
JETS
AUX
AUX
LIGHT
HEAT
JETS
AUX
LIGHT
HEAT
Press TEMP to
Toggle
ON or OFF
SET
JETS
AUX
LIGHT
HEAT
Press LIGHT to
Exit to Menu
29
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
UNLK (Unlock, Allowing Panel Operation)
This Unlock sequence may be used from any screen that may be displayed on a
restricted panel.
RANGE
SET
JETS
AUX
LIGHT
SET
Press TEMP. LOCK appears.
HEAT
Press TEMP
Press and hold TEMP while pressing LIGHT twice.
SET
JETS
JETS
30
AUX
AUX
LIGHT
LIGHT
HEAT
HEAT
UNLK screen appears, and then will exit to Main Screen in approx. 3
seconds.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
FLIP
Inverts Display.
READY
JETS
RANGE FLTR1
AUX
LIGHT
RANGE FLTR1
31
AUX
READY
JETS
HEAT
LIGHT
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Setting the 24 Hour Clock
This action changes a 12 hour clock to a 24 hour clock.
Main > PREF > 24-12
READY
JETS
AUX
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
32
AUX
Press TEMP to initiate a flashing display.
t
When the temperature flashes, press LIGHT repeatedly until PREF appears.
t
Press TEMP at PREF
RANGE FLTR1
LIGHT
HEAT
The temperature flashes.
JETS
t
LIGHT
Press LIGHT
repeatedly until
PREF appears.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Setting the 24 Hour Clock (cont.)
SET
JETS
AUX
LIGHT
HEAT
t
Press LIGHT at F/C menu.
t
Press TEMP to toggle between 24 and 12 hour.
t
Press LIGHT to 1) enter choice, 2) again to exit PREF menu, 3) again to
exit UTIL menu and return to main menu.
SET
JETS
AUX
LIGHT
HEAT
Toggle between 12 And 24 Hour
Press LIGHT
to exit.
33
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Temperature Display (F/C)
1SPWJEFTUIFPQUJPOUPDIPPTFCFUXFFO'BISFOIFJU$FMTJVT
Main Menu > PREF > F/C
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
To choose between Fahrenheit and Celsius, UPHHMFCFUXFFO'$JO13&'NFOV
Press LIGHT to exit.
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
The temperature flashes.
JETS
34
AUX
LIGHT
Press LIGHT
repeatedly until
PREF appears.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Temperature Display (F/C, cont.)
JETS
AUX
LIGHT
HEAT
Press TEMP to
toggle choice
or
SET
or
SET
JETS
SET
SET
AUX
LIGHT
HEAT
JETS
AUX
LIGHT
HEAT
Press Light two more times to exit to main menu.
or
JETS
AUX
LIGHT
HEAT
Press LIGHT
to exit to menu
35
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
The Balboa Water Group Spa Control App
The optional Wi-Fi interface connection for the iPhone®, iPod touch® or iPad®
It will take several seconds for the wireless connection to the spa to be available.
To speed up this process, a static IP address can be assigned to the iPhone®,
iPod touch® or iPad© for the point-to-point network:
Step 1
Go to the Wi-Fi Networks screen by touching the Settings icon.
Step 2
Touch the Wi-Fi on the Settings page. Note: If Wi-Fi is not currently
turned on, touch the Wi-Fi line at the top right of the list.
Step 3
The Spa Control network link will appear as BWGSpa_XXXXXX in the
‘Choose a Network’ list. Note: XXXXXX are the last 6 characters in the
MAC address of the module.
36
1.
On the Wi-Fi Networks page, touch the blue right-arrow next to the
BWGSpa_XXXXXX entry to display the address setup page
2.
Touch the Static button under IP Address
3.
Enter 169.254.1.2 for the IP Address
4.
Enter 255.255.0.0 for the Subnet Mask
5.
Enter 169.254.1.1 for the Router
6.
Touch the ‘Wi-Fi Networks’ button at the top of the page to exit the
screen This address setup only has to be done once.
The iPhone®, iPod touch® and iPad® are registered trademarks of Apple Inc.
For more information on our spa control app please visit:
www.balboawatergroup.com/iphone-application or you can contact our technical
support at 714.834.0384.
Note: The wireless WI-FI Spa Control requires optional equipment not supplied
with the BP500 System. Installation or repairs must be done by a qualified spa
technician or electrician, and in accordance with the country or local electrical
codes in effect at the time of installation.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
BP500Spa Behavior
37
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Pumps, Operation
Press the “Jets 1” button once to turn pump 1 on or off, and to shift between low
and high speeds if equipped.
If left running, the pump will turn off after a time-out period.
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
t
The pump 1 low speed will time out after 30 minutes.
t
The high speed will time out after 15 minutes.
On non-circ systems, the low speed of pump 1 runs when the blower or any other
pump is on.
TIP
38
t
If the spa is in Ready Mode, Pump 1 low may turn on for at least 1 minute
every 30 minutes to detect the spa temperature (polling) and then to heat to
the set temperature if needed.
t
When the low speed turns on automatically, it cannot be deactivated from
the panel; however, the high speed may be started by pressing the “Jets”
button.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Pumps, Operation (cont.)
Press the “Jets 1” button once to turn pump 1 on or off, and to shift between low
and high speeds if equipped.
If left running, the pump will turn off after a time-out period.
READY
JETS
39
AUX
RANGE FLTR1
LIGHT
HEAT
t
The pump 1 low speed will time out after 30 minutes.
t
The high speed will time out after 15 minutes.
On non-circ systems, the low speed of pump 1 runs when the blower or any
other pump is on. If the spa is in Ready Mode, Pump 1 low may also activate for
at least 1 minute every 30 minutes to detect the spa temperature (polling) and
then to heat to the set temperature if needed. When the low speed turns on
automatically, it cannot be deactivated from the panel; however, the high speed
may be started.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Circulation Pump Modes
If the system is equipped with a circ pump, it may be configured to work in one
of three different ways:
READY
JETS
AUX
t
The circ pump operates continuously (24 hours) with the exception of turning
off for 30 minutes at a time when the water temperature reaches 3°F (1.5°C)
above the set temperature (most likely to happen in very hot climates).
t
The circ pump stays on continuously, regardless of water temperature.
t
A programmable circ pump will come on when the system is checking
temperature (polling), during filter cycles, during freeze conditions, or when
another pump is on.
RANGE FLTR1
LIGHT
HEAT
Filtration and Ozone
On non-circ systems, Pump 1 low and the ozone generator will run during
filtration. On circ systems, the ozone will run with the circ pump.
The system is factory-programmed with one filter cycle that will run in the
evening (assuming the time-of-day is properly set) when energy rates are often
lower. The filter time and duration are programmable. A second filter cycle can
be enabled as needed.
At the start of each filter cycle, the blower (if there is one) or Pump 2 (if there is
one) will run briefly to purge its plumbing to maintain good water quality.
40
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Freeze Protection
If the temperature sensors within the heater detect a low enough temperature,
then the pump(s) and the blower automatically activate to provide freeze
protection. The pump(s) and blower will run either continuously or periodically
depending on conditions.
In colder climates, an optional additional freeze sensor may be added to protect
against freeze conditions that may not be sensed by the standard sensors.
Auxiliary freeze sensor protection acts similarly except with the temperature
thresholds determined by the switch. See your dealer for details.
Clean-up Cycle (optional)
When a pump or blower is turned on by a button press, a clean-up cycle begins
30 minutes after the pump or blower is turned off or times out. The pump and
the ozone generator will run for 30 minutes or more, depending on the system.
On some systems, you can change this setting.
41
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
System Default Operation Settings
PUMPS
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
Press the “Jets 1” button once to turn pump 1 on or off, and to shift between low
and high speeds if equipped.
If left running, the pump will turn off after a time-out period.
t
The pump 1 low speed will time out after 30 minutes.
t
The high speed will time out after 15 minutes.
On non-circ systems, the low speed of pump 1 runs when the blower or any other
pump is on.
TIP
42
t
If the spa is in Ready Mode, Pump 1 low may turn on for at least 1 minute
every 30 minutes to detect the spa temperature (polling) and then to heat to
the set temperature if needed.
t
When the low speed turns on automatically, it cannot be deactivated
from the panel; however, the high speed may be started by pressing the
“Jets” button.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration
FILT1: Main Filtration
READY
JETS
AUX
RANGE FLTR1
LIGHT
HEAT
Filter cycles are set using a start time and a duration. Start time is indicated by
an “A” or “P” in the bottom right corner of the display. Duration has no “A” or
“P” indication. Each setting can be adjusted in 15-minute increments. The panel
calculates the end time and displays it automatically.
FILT2, Filter Cycle 2: Optional Filtration
Filter Cycle 2 is OFF by default.
It is possible to overlap Filter Cycle 1 and Filter Cycle 2, which will shorten overall
filtration by the overlap amount.
Purge Cycles
t
In order to maintain sanitary conditions, secondary Pumps and/or a Blower
will purge water from their respective plumbing by running briefly at the
beginning of each filter cycle.
t
If Filter Cycle 1 is set for 24 hours, enabling Filter Cycle 2 will initiate a purge
when Filter Cycle 2 is programmed to begin.
Pump Purge default time is 60 seconds.
Blower Purge default time is 30 seconds.
The following pages describe how to set up filtration times.
43
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F1
In adjusting the filtration times, you’ll enter Filtration Screen one (F1), set
the beginning time (in hours and minutes), and then the duration. The
second filtration times (F2) are created the same way.
Main Menu > FILT1 > OFF/ON > BEGN
READY
JETS
AUX
At the main screen, begin by pressing TEMP.
RANGE FLTR1
LIGHT
HEAT
A capital F appears with a flashing number one to designate that it’s the first
filtration cycle that’s being adjusted.
READY
JETS
AUX
RANGE FLTR1
LIGHT
The temperature flashes.
44
(An extra press of LIGHT will take you to F2.)
HEAT
Press LIGHT
repeatedly until
FLTR1 appears.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F1 (cont.)
Press TEMP to advance to the beginning of the time setting
process for filtration.
1
JETS
AUX
LIGHT
HEAT
FLTR1 flashes
TEMP advances to the first screen to change time for F1. (BEGN will
appear, which stands for begin.)
FLTR1
JETS
AUX
LIGHT
JETS
AUX
LIGHT
FLTR1
SET
45
HEAT
P
The hour will flash. Press TEMP to change the hour.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F1 (cont.)
FLTR1
SET
JETS
AUX
LIGHT
FLTR1
SET
JETS
AUX
LIGHT
JETS
AUX
LIGHT
46
Press LIGHT to advance to minutes.
P
Press TEMP to change minutes.
HEAT
FLTR1
SET
P
HEAT
P
Press LIGHT to set Run Hours.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F1 (cont.)
FLTR1
JETS
AUX
LIGHT
FLTR1
HEAT
JETS
AUX
LIGHT
Press TEMP to begin hour change for F1.
HEAT
Each TEMP press increments the hours.
FLTR1
SET
JETS
AUX
HEAT
FLTR1
SET
JETS
47
LIGHT
AUX
LIGHT
HEAT
LIGHT press advances to minutes.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F1 (cont.)
Each TEMP press advances the time 15 minutes.
FLTR1
SET
JETS
AUX
LIGHT
HEAT
Press LIGHT when finished.
The read out scrolls the information that is now programmed.
A
48
Press TEMP to exit to main screen.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2
Filter Cycle 2: Optional Filtration
Filter Cycle 2 is OFF by default. It must be turned ON.
The process is the same for setting F1. Once the BEGN (begin) screen
displays, it is ready for more input. Revert back to “Adjusting Filtration
Time Filter 1” above.
Main Menu > FILT2 > OFF/ON > BEGN
At the Main Screen, begin by pressing TEMP.
READY
JETS
AUX
READY
JETS
AUX
RANGE FLTR2
LIGHT
HEAT
RANGE FLTR2
LIGHT
HEAT
The temperature flashes.
49
When the temperature is still flashing, press LIGHT repeatedly until
FLTR2 appears. (A capital F will appear with a flashing number two to
designate that it’s the second filtration cycle that’s being adjusted.)
Press LIGHT
repeatedly until
FLTR2 appears.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
Press TEMP to advance to the beginning of time setting the
process for filtration.
2
JETS
AUX
LIGHT
HEAT
JETS
If the display shows OFF, press TEMP again to witch the filtration
mode to ON.
FLTR 2
SET
AUX
LIGHT
HEAT
Press TEMP
to turn FILT2 ON
FLTR 2
SET
JETS
50
AUX
LIGHT
Press LIGHT to accept your choice to program F2.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
FLTR 2
JETS
AUX
LIGHT
JETS
AUX
LIGHT
51
HEAT
FLTR 2
SET
TEMP advances to the first screen to change time for F2. (BEGN will
appear, which stands for begin.)
The hour will flash. Press TEMP to change the hour.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
FLTR 2 P
SET
JETS
AUX
LIGHT
JETS
AUX
JETS
52
LIGHT
AUX
LIGHT
Press TEMP to change minutes.
HEAT
FLTR 2 P
SET
Press LIGHT to advance to minutes.
HEAT
FLTR 2 P
SET
SET
Press LIGHT to set Run Hours.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
FLTR 2
FLTR 2
JETS
AUX
LIGHT
HEAT
JETS
AUX
LIGHT
Press TEMP to begin hour change for F2.
HEAT
Each TEMP press increments the hours.
FLTR 2
SET
JETS
AUX
LIGHT
FLTR 2
SET
JETS
53
HEAT
AUX
LIGHT
LIGHT press advances to minutes.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
JETS
Each TEMP press advances the time 15 minutes.
FLTR 2
SET
AUX
LIGHT
HEAT
Press LIGHT when finished.
A
The read out scrolls the information that had just been programmed.
Press TEMP to exit to main screen.
54
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Adjusting Filtration Time for F2 (cont.)
TEMP will flash hours to begin filtration programming for F2.
FLTR1
JETS
AUX
LIGHT
HEAT
The hour will flash. Press TEMP to change the hour.
FLTR1
SET
JETS
55
AUX
LIGHT
HEAT
P
At this point, the time setting process is the same as for F1. Please
revert back to “Adjusting Filtration Time for F1” above.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Continuous Filtration (24 Hour Filtration)
To set continuous filtration, set Filter 1 to begin at a specified time (it could be
any time), and then to run for 24 hours.
In this case, the filter 2 start time only controls when the second purge happens.
Filter 2 end time will be unavailable.
READY
JETS
AUX
READY
JETS
AUX
At the main screen, begin by pressing TEMP.
RANGE FLTR1
LIGHT
HEAT
When the temperature is still flashing, press LIGHT repeatedly until FLTR1
appears. (An extra press of LIGHT will take you to F2.)
RANGE FLTR1
LIGHT
HEAT
Press LIGHT
repeatedly until
FILT1 appears
56
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Continuous Filtration (24 Hour Filtration, cont.)
Press TEMP to advance to the beginning of the time setting
process for filtration.
1
JETS
AUX
LIGHT
HEAT
TEMP advances to the first screen to change time for F1.
(BEGN will appear, which stands for begin.)
FLTR1
JETS
FLTR1
SET
JETS
57
AUX
LIGHT
HEAT
P
AUX
LIGHT
HEAT
FLTR1
SET
JETS
AUX
LIGHT
HEAT
P
The hour will flash. Press LIGHT to advance to minutes.
(Reminder: Since filtration will be set for 24 hours, the start/stop time is
not important.)
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Continuous Filtration (24 Hour Filtration, cont.)
FLTR1
JETS
AUX
LIGHT
FLTR1
HEAT
JETS
AUX
LIGHT
“RUN HRS” appears. Press TEMP to begin SET FLTR1 process.
HEAT
When the hours appear, advance those hours to 24 by pressing TEMP.
FLTR1
SET
JETS
AUX
LIGHT
HEAT
FLTR1
SET
JETS
58
AUX
LIGHT
When 24 appears, press LIGHT.
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Continuous Filtration (24 Hour Filtration, cont.)
JETS
If needed, adjust the minutes to zero by pressing TEMP.
FLTR1
SET
AUX
LIGHT
HEAT
Press LIGHT to exit.
F 1 ENDS appears along with the start time, which is the same as the end time,
of the filtration cycle (in this example 8:00 pm). Filtration cycle then begins again.
SET
59
FLTR1
P
To return to the main menu, press TEMP or wait approx. 30 seconds.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
BP500General Messages
60
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Main Menu
Reminder Messages
TEMP
Main Menu > PREF > Reminder
MODE
Reminder messages help in the general maintenance of the spa.
TIME
t
Reminder Messages can be suppressed by using the PREF Menu.
FLIP
t
Reminder Messages can be chosen individually by the Manufacturer.
The OEM Spa Manufacturer may disable the messages entirely, or
there may be a limited number of reminders on a specific model.
t
The frequency of each reminder (e.g., 7 days) can be specified by the
Manufacturer.
t
Press a Temperature button to reset a displayed reminder message.
t
The Reminder options are as follows:
LOCK
HOLD
FILT1
FILT2
PREF
F/C
t
Check pH every 7 days
UTIL
24-12
t
Check Chemistry every 7 days
t
Clean Filter every 30 days
t
Test GFCI every 30 days
Clean-up
t
Change Water every 90 days
Dolphin
t
Clean Cover every 180 days
t
Treat Wood every 180 days
t
Change Filter every 365 days
t
Change Cartridge as needed
Reminder
BP1500 MAIN Menu preferences_1010091000.eps
“At a Glance” of Reminder location within the Menu Tree
61
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Suppressing Reminders
This action allows you to suppress reminders.
Main > PREF > Reminder
READY
JETS
AUX
READY
JETS
AUX
LIGHT
HEAT
RANGE FLTR1
LIGHT
HEAT
The temperature flashes.
JETS
62
AUX
Press TEMP to initiate a flashing display.
RANGE FLTR1
LIGHT
Press LIGHT
repeatedly until
PREF appears
HEAT
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Suppressing Reminders (cont.)
SET
JETS
AUX
LIGHT
HEAT
JETS
AUX
LIGHT
HEAT
SET
“Reminders” scrolls across screen.
JETS
AUX
LIGHT
HEAT
Press TEMP
for options.
63
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Suppressing Reminders (cont.)
TEMP toggles between No and Yes.
SET
JETS
AUX
LIGHT
HEAT
Press TEMP
for options.
64
t
Press LIGHT to exit the PREF menu.
t
Press LIGHT 3 times to return to MAIN menu.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Reminder Messages (cont.)
CHEK PH
Check pH
Alternates with temperature or normal display.
Check pH with a test kit and adjust pH with the appropriate chemicals. Appears
on a regular schedule, i.e. every 7 days.
CHEK CHEM
Check Chemistry
Check sanitizer level and other water chemistry with a test kit and adjust with the
appropriate chemicals. Appears on a regular schedule, i.e. every 7 days.
CLN FLTR
Clean Filter
65
Clean the filter media as instructed by the manufacturer. See HOLD. Appears on
a regular schedule, i.e. every 30 days.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Reminder Messages (cont.)
TEST GFCI
The GFCI is an important safety device and must be tested on a regular basis to
verify its reliability. Appears on a regular schedule, i.e., every 30 days.
Test GFCI
Every user should know how to safely test the GFCI associated with the hot tub
installation.
A GFCI will have a TEST and RESET button on it that allows a user to verify
proper GFCI function.
CHNG WATR
Change the water in the spa on regular basis to maintain proper chemical
balance and sanitary conditions. Appears on a regular schedule, i.e. every 90
days.
Change Water
Alternates with temperature or normal display.
CLN COVR
Vinyl covers should be cleaned and conditioned for maximum life. Appears on a
regular schedule, i.e. every 180 days.
Clean Cover
.
66
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Reminder Messages (cont.)
TRT WOOD
Treat Wood
Alternates with temperature or normal display.
Alternates with temperature or normal display. Wood skirting and furniture
should be cleaned and conditioned per the manufacturers instructions for
maximum life. Appears on a regular schedule, i.e. every 180 days.
CHNG FLTR
Change Filter
Filters should be replaced occasionally to maintain proper spa function and
sanitary conditions. Appears on a regular schedule, i.e. every 365 days.
Alternates with temperature or normal display.
CHNG CART
Install new mineral cartridge as needed.
Change Cartridge
Alternates with temperature or normal display.
67
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Glossary
Circ Pump (or circulation pump)
Low horse power pump designated especially for maintenance of filtration and
heating. It often runs all day.
Clean-up (or purge) Cycle
An action designed to circulate water to maintain sanitary conditions. Pumps or
blowers purge standing water to prevent the water from becoming stagnant.
Filtration Cycle
Period of time designated to filter the system. Oftentimes there are two filter
cycles, 12 hours apart, and designated as F1 and F2.
Freeze Protection
A safety feature detecting water or air temperature approaching freezing. Once
a set low temperature is reached, an action is often initiated automatically.
Oftentimes pumps will start to keep water circulating in all plumbing and the
heater may operate.
68
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Glossary (cont.)
GFCI
A device intended to protect people in the event of an electrical malfunction.
Spa owners should know how to test the GFCI as routine maintenance.
Preferences
Programmed events according to personal preferences.
SSID
Software Self Identification
Programming
Setting an order and time for planned events, such as filter times, clean-up
cycle, etc.
69
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Transforming the Control of Hot Tubs
BP500
Glossary (cont.)
Priming Mode
Act of water flow through the plumbing to purge air from the spa system.
Normally, priming mode can be bypassed. The priming mode is necessary only
if the spa is refilled and if there’s the possibility of air being in the system.
What Priming Mode does:
Each time the spa is powered up, it will enter Priming Mode. The purpose
of Priming Mode is to allow the user to run each pump and manually verify
that the pumps are primed (air is purged) and water is flowing. This typically
requires observing the output of each pump separately, and is generally not
possible in normal operation. Priming Mode lasts 4 minutes, but you can exit
it earlier by pressing any Temp button. The heater is not allowed to run during
Priming Mode. NOTE: If your spa has a Circ Pump, it will turn on with Jets 1 in
Priming Mode. The Circ Pump will run by itself when Priming Mode is exited.
70
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Index
Symbols
2-Speed Pump 1 22
24 Hour Circulation Mode 22
24 hour clock 32
24 Hour Filtration 56
55911, Part No. 9
(F/C), Temperature Display 34
A
address, IP 36
Adequate drainage 4
Adjusting Filtration 43
Adjusting Filtration Time for F1 44
Adjusting Filtration Time for F2 49
adjusting the filtration 44
Adjustment, Temperature 16
adjust pH 65
Allowing Panel Operation 30
app, spa control 36
App, Spa Control 36
Auxiliary Panels: 9
B
BEGN 45, 49, 51
Bi-directional Flow Heater 10
Blower Purge default time 43
button, Light 14
Button, Light 14
Buttons, Temperature 14
button, temperature 14
71
C
D
CHEK CHEM 65
CHEK PH 65
CHNG FLTR 67
CHNG WATR 66
choose between Fahrenheit and Celsius 34
circ pump 40
Circ Pump 68
Circulation Mode 22
circulation pump 68
Circulation Pump Modes 40
Class A GFCI 5
clean-up cycle 41
Clean-up Cycle 41
Clean-up (or purge) Cycle 68
CLN COVR 66
CLN FLTR 65
clock, 24 hour 32
Clock, Setting the 24 Hour 32
clock will count down 26
Components 10
conditions, freeze 41
connection, wireless 36
Continuous Filtration 56
Couplings (nuts and seals included) 9
cycle, clean-up 41
Cycle, Clean-up 41
Cycle, Clean-up (or purge) 68
Cycle, Filtration 68
cycle, second filtration 49
Cycles, Purge 43
Default Operation Settings 42
Dimensions 11
Dimensions, Mounting 11
Display, Inverts 31
drainage, Adequate 4
Drain Mode 27
Dual Temperature Ranges 17
E
End User Warning 2
equipment, optional 36
F
F1, Adjusting Filtration Time for 44
F2, Adjusting Filtration Time for 49
FILT1: Main Filtration 43
FILT2 43
Filter Cycle 2: Optional Filtration 43, 49
Filtration 40
Filtration, 24 Hour 56
Filtration, Adjusting 43
filtration, adjusting the 44
Filtration, Continuous 56
Filtration Cycle 68
Filtration, FILT1: Main 43
Filtration, Filter Cycle 2: Optional 43, 49
Filtration, Optional 43
filtration programming 55
filtration pump 23
FLIP 31
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
freeze conditions 41
freeze protection 41
Freeze Protection 17, 41, 68
freeze sensor 41
G
general maintenance 61
generator, ozone 40
GFCI 69
GFCI, Class A 5
Glossary 68
guard, VG Compliant suction 4
Light, Spa 21
link, network 36
LITE TIMR 15
LOCK (Restricting Panel Operation) 28
Lock, Temperature 28
Low Range 17
low temperature set point 20
M
Identification, Software Self 69
instructions, power connection 3
Inverts Display 31
IP address 36
iPhone®, WiFi interface connection for the 36
Main Menu 15
maintenance, general 61
Menu, Main 15
Messages, Reminder 61
Mode, 24 Hour Circulation 22
Mode, Circulation 22
Mode, Drain 27
Mode, Hold 26
Model, System 9
Mode, Priming 70
Mode, Ready 23, 38, 39, 42
Mode, READY 22
Mode -- Ready and Rest 22
Mode, Ready-in-Rest 23
Mode, Rest 23
Mode, REST 22
Modes, Circulation Pump 40
Mounting Dimensions 11
K
N
kit, test 65
Navigation, Panel 14
NEC (National Electrical Code) 5
network link 36
non-circ systems 38, 39, 40, 42
Numbers, System Part 9
H
Heater, Bi-directional Flow 10
High or Low Range 17
High Range 17
Hold Mode 26
Hours, Run 52
I
L
Light button 14
Light Button 14
72
O
Operation 38
Operation, Allowing Panel 30
Operation, Panel 13
Operation, Restricting Panel 28
optional equipment 36
Optional Filtration 43
overlap Filter Cycle 1 and Filter Cycle 2 43
Ozone 40
ozone generator 40, 41
P
Panel Navigation 14
Panel Operation 13
Panels:, Auxiliary 9
Panels, Topside 9
Panel, TP400T 9
Panel, TP400W 9
Panel, TP600 9
Part No. 55911 9
period, time-out 38
pH, adjust 65
planned events 69
Poll 23
polling 22, 38, 39, 40, 42
power connection instructions 3
Preferences 69
Press and Hold 16
Priming Mode 70
programmable circ pump 40
programming, filtration 55
protection, freeze 41
Protection, Freeze 17, 41, 68
pump, circ 40
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Pump, Circ 68
pump, circulation 68
pump, filtration 23
pump, programmable circ 40
Pump Purge default time 43
Pumps 38
Purge Cycles 43
purge water 43
R
Range, High 17
Range, High or Low 17
Range, Low 17
Ranges, Dual Temperature 17
Range, Setting a High Temperature 18
Range, Setting a Low Temperature 19
Ready-in-Rest Mode 23
Ready Mode 23, 38, 39, 42
READY Mode 22
“ready to use” setting 17
Reminder Messages 61
Reminders, Suppressing 62
RESET, TEST and 66
Rest Mode 23
REST Mode 22
Restricting Panel Operation 28
Router 36
Run Hours 52
S
screen, Wi-Fi Networks 36
second filtration cycle 49
sensor, freeze 41
sensors, standard 41
sensors, temperature 41
73
sequence, Unlock 30
Series, TP Panel 13
SET READY 25
SET REST 25
set temperature 16, 22
Set Temperature 28
Setting a High Temperature Range 18
Setting a Low Temperature Range 19
setting, “ready to use” 17
Settings, Default Operation 42
Setting the 24 Hour Clock 32
setting, “vacation” 17
Software Self Identification 69
spa control app 36
Spa Control App 36
Spa Light 21
Specifications 9
SSID 69
standard sensors 41
Suppressing Reminders 62
System Model 9
System Part Numbers 9
systems, non-circ 38, 39, 40, 42
TEST GFCI 66
test kit 65
Test the ground fault circuit interrupter 4
thresholds, temperature 41
time, Blower Purge default 43
time-out period 38
time, Pump Purge default 43
UPHHMFCFUXFFO'$ 34
Topside Panels 9
TP400T 13
TP400T Panel 9
TP400W 13
TP400W Panel 9
TP600 13
TP600 Panel 9
TP Panel Series 13
TRT WOOD 67
T
“vacation” setting 17
VG Compliant suction guard 4
Temperature Adjustment 16
temperature button 14
Temperature Buttons 14
Temperature Display (F/C) 34
Temperature Lock 28
temperature sensors 41
temperature, set 16, 22
Temperature, Set 28
temperature thresholds 41
TEST and RESET 66
U
UNLK 30
Unlock sequence 30
V
W
Warning, End User 2
water, purge 43
WiFi interface connection for the iPhone® 36
Wi-Fi Networks screen 36
wireless connection 36
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
Tustin Ca. 92780 (714) 384-0384
©2012 Balboa Water Group. All rights reserved.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
74
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
42186 A May 18, 2012
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement