Pass-Thru
Holding Cabinet
Rev. 7 (7/07)
FL-2254LC
Page 1 of 4
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
ELECTRICAL SPECIFICATIONS:
Model No.
H138NPS-CLC Series
Volts
120
H138NPS-CLC 240 Series 240
Watts
1920
2000
Amps
16
8.3
Hertz
60
60
Phase
1
1
NEMA
5-20P
6-15P
H138NPS-CLC Series
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Pass-Thru
Holding Cabinet
Rev. 7 (7/07)
FL-2254LC
Page 2 of 4
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
HOW TO INSTALL UNIT:
1.
2.
Place cabinet on level fl oor.
Plug cord into proper wall outlet.
Yellow Light
Power Switch
Thermostat Thermometer
HOW TO START UNIT:
1.
Push POWER switch to ON . The yellow light will turn on.
2.
Turn thermostat knob to desired setting.
3.
4.
Preheat cabinet for 30-45 minutes.
Put food into cabinet and close door.
Typical temperature settings:
No. 5-1/2 setting = approx. 160°F/71°C
No. 8 setting = approx. 185°F/85°C
TO TURN OFF UNIT:
Push the POWER switch to OFF .
The yellow light will go out.
WARNING
RISK OF FIRE OR ELECTRIC SHOCK
DO NOT OPEN
WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK,
NOTE: Proper food holding temperature is
140°F/60°C or higher.
DO NOT REMOVE COVER (OR BACK)
NO USER-SERVICEABLE PARTS INSIDE
REPAIR SHOULD BE DONE BY AUTHORIZED SERVICE
PERSONNEL ONLY
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Pass-Thru
Holding Cabinet
Rev. 7 (7/07)
FL-2254LC
Page 3 of 4
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
2.
1.
WARNING
BEFORE Cleaning the Cabinet:
Allow cabinet to cool.
Do NOT use abrasives or harsh chemicals.
Cleaning Notes:
1.
2.
Wipe up spills as soon as possible.
Clean cabinet regularly to avoid heavy dirt build-up.
3.
Make a test spot with cleaner.
4.
5.
Follow manufacturer’s directions on cleaner.
Do not mix cleaners.
6.
Avoid drips and splashes.
SOIL
DIRT
FINGERPRINTS,
GREASE and OIL
WATER SPOTS
HOW TO CLEAN UNIT:
CLEANER
Mild detergent* and hot water, or mild abrasive cleaner.
METHOD
1. Use soft, damp cloth.
2. Rinse with hot water
3. Wipe dry.
Steam (no strong alkaline additive).
Chemical oven cleaner.
1. Rinse after steam cleaning.
2. Wipe dry.
Follow oven cleaner manufacturer’s directions
Mild abrasive cleaner; oily or waxy cleaner.
Apply with a soft, clean cloth.
Mild abrasive cleaner.
1. Apply with damp cloth.
2. Rinse and dry.
*Mild detergents include soaps and non-abrasive cleaners.
TROUBLE-SHOOTING CHART:
FAILURE:
1. Yellow light on switch does NOT light.
2. Unit does not heat.
3. Unit gets too hot or won’t shut off.
POSSIBLE CAUSE:
1a. Circuit breaker/fuse to wall outlet is blown
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF.”
2a. Thermostat set too low or is “OFF.”
2b. Switch is “OFF.”
3a. Defective electrical parts. UNPLUG UNIT
FROM WALL OUTLET:
4. Blower does not work or makes noise.
4a. Defective blower
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Pass-Thru
Holding Cabinet
Rev. 7 (7/07)
FL-2254LC
Page 4 of 4
5925 Heisley Road • Mentor, OH 44060-1833
LITTLE CAESARS HOT-N-READY
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H138NPS-CLC Pass-Thru Hot Cabinet Series
HOT UNIT REPLACEMENT PARTS:
DESCRIPTION
Power Unit
Heater, Air
High Limit
120 VOLT
0675-048LC
0811-074
0848-060
Thermometer 5238-030
Thermostat, Air 0848-008-ACK
Power Cord
Power Switch
0810-065-12-K
0808-116
Power Light
Vent Fan
0766-094
0769-165
Blower 0769-180-K
240 VOLT
0675-057LC
0811-074-1
0848-060
5238-030
0848-008-ACK
0810-039-07 -K
0808-116
0766-095
0769-174
0769-182-K
CABINET REPLACEMENT PARTS:
DESCRIPTION
Door, Full
Door, Full, Window
Door, Half, Window
Door, Half
Door Gasket, Full
Door Gasket, Half
Door Hinge (Full Door)
Door Hinge (Half Door)
Door Latch
Caster
Caster with Brake
Angle Slide Set
Post, Angle Slide
Blower Guard
CMP NO.
1221-540
1221-550
1221-535-01
1221-534
0861-246
0861-245
0519-089
0519-087-K
1006-120-01
0569-306
0569-306-B
0621-281-K
0696-228
1170-211
6-15P PLUG
240V, 15A
NOTES:
120V. UNITS - ATTACH WIRE #15 TO
TERMINAL #9 OF TEMP. CONT. BOARD.
208/240V. UNITS - ATTACH WIRE #15 TO
TERMINAL #10 OF TEMP. CONT. BOARD.
WIRE NUT UNUSED LEAD.
= PROTECTIVE SLEEVE
WIRING DIAGRAM
Full-Height Pass-Thru Units
TEMPERATURE CONTROL BOARD
10 9 8
5 4 6 7
16 20 4 5
15 t°
SENSOR
G
4 5
HIGH LIMIT
21
HIGH LIMIT
BM = BLOWER MOTOR
FAN = VENT FAN
A = AMBER (YELLOW) LIGHT
TERMINAL BLOCK
16
4
A
POWER
SWITCH BM
FAN
2
8
BM
7
2
1
15
1 3
6
FAN
24
HEATER AIR
23
3
G
W
G
5-20P
120V; 20A
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
