Razor Electric Wagon Owner`s manual

Razor Electric Wagon Owner`s manual
Electric Wagon
Owner’s Manual
Read and understand this entire manual before
allowing child to use this product!
Item Number:
25144070
Contents
Safety Warnings............................................................. 1
Before You Begin............................................................ 2
Set-Up ........................................................................ 3-4
Operating the Wagon..................................................... 5
Electric Wagon Parts................................................... 5-6
Warranty......................................................................... 8
Safety Warnings
WARNING: Riding in the Electric Wagon can be a hazardous
activity. Certain conditions may cause the equipment to fail without
fault of the manufacturer. Like other wheeled products, the Electric
Wagon can and is intended to move, and it is therefore possible to
lose control, fall off and/or get into dangerous situations that no
amount of care, instruction or expertise can eliminate. If such things
occur, your child can be seriously injured or die, even when using
safety equipment and other precautions. USE COMMON SENSE.
Do not ride the Electric Wagon in wet weather. The Electric Wagon
is intended for use on solid, flat, clean and dry surfaces such as
pavement or level ground. Wet, slick or uneven and rough surfaces
may impair traction and contribute to possible accidents. Do not ride
the Electric Wagon in mud, ice, puddles or water. Avoid excessive
speeds that can be associated with downhill rides. Never risk
damaging surfaces such as carpet or flooring by use of a Electric
Wagon indoors. Do not ride at night or when visibility is impaired.
This manual contains many warnings and cautions concerning the
consequences of failing to maintain, inspect or properly use your
Electric Wagon. Because any incident can result in serious injury or
even death, we do not repeat the warning of potential serious injury
or death each time such a possibility is mentioned.
USING THE CHARGER
The charger supplied with the Electric Wagon should be regularly
examined for damage to the cord, plug, enclosure and other parts,
and in the event of such damage, the batteries must not be charged
until the charger has been repaired or replaced.
APPROPRIATE RIDER USE AND PARENTAL SUPERVISION
Use only with the recommended charger.
Direct adult supervision is required at all times. This manual contains
important safety information. It is your responsibility to review
this information and make sure that all children obey all warnings,
cautions, instructions and safety topics and assure that young riders
are able to safely use this product. Razor recommends that you
periodically review and reinforce the information in this manual
with young riders, and that you inspect and maintain your children’s
wagon to insure their safety.
Use caution when charging.
The charger is not a toy. Charger should be operated by an adult.
Do not operate charger near flammable materials.
Unplug charger and disconnect from scooter when not in use.
Do not exceed charging time.
Any child unable to fit comfortably on the Electric Wagon should not
attempt to ride it.
Always disconnect from the charger prior to wiping down and cleaning your
scooter with liquid.
Contains sealed lead acid batteries. Batteries must be recycled.
A parent’s decision to allow his or her child to ride in this
product should be based on the child’s maturity, skill
and ability.
DO NOT EXCEED MAX LOAD WEIGHT OF 145 pounds (66kg). Rider
weight does not necessarily mean a child’s size is appropriate to fit in
the Electric Wagon.
FAILURE TO USE COMMON SENSE AND HEED THE
ABOVE WARNINGS INCREASES RISK OF SERIOUS
INJURY. USE WITH APPROPRIATE CAUTION AND
SERIOUS ATTENTION TO SAFE OPERATION.
Refer to the section on safety for additional warnings.
ACCEPTABLE RIDING PRACTICES AND CONDITIONS
Direct parental supervision is required. The Electric Wagon is meant
to be used only in controlled environments free of potential traffic
hazards and not on public streets. Do not allow your child to ride
in the Electric Wagon in any areas where vehicle traffic is present.
Never use near steps, sloped driveways, hills, roadways, alleys or
swimming pool areas.
1
Before You Begin
Remove contents from box. Remove the foam separators that protect the components. Inspect the contents of the box
for dents or kinked cables that may have occurred during shipping.
WARNING: DO
NOT USE NON-RAZOR
PRODUCTS WITH YOUR
RAZOR ELECTRIC WAGON.
The Electric Wagon has been
built to certain Razor design
specifications. The original
equipment supplied at the time of
sale was selected on the basis of
its compatibility with the body and
all other parts. Certain aftermarket
products may or may not be
compatible.
q Estimated Assembly and Set-Up Time
Adult assembly required. Contains small parts. Do not allow children to assist with assembly.
Allow up to 20 minutes for assembly, not including initial charge time.
Allow up to 12 hours for initial charge (see page 3 for charging information).
Umbrella/cup holder
Handle
Side Board (Right)
Lap Belts
Front Board
Side Board (Left)
2 rear wheels
Power Adapter
Handle Axle
Body
Rear Axle
Fixed clips
2 front wheels
Clip tool
q Required Tools
Rubber mallet/hammer
(not included)
Need Help? Visit our web site for replacement parts, product support and a list of authorized service centers at
www.razor.com or call toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
2
Set-Up
q Charging the Battery
Your Electric Wagon may not have a fully charged battery; therefore you must charge the battery prior to use.
• Initial charge time: 12 hours
•Run time: up to 40 minutes
• Recharge time: up to 8 hours
•Average battery life: 250 charge/discharge cycles
• Fully charge once a month when not in use
•Do not store below 32 degrees - this can permanently damage the battery.
Charger
Plug
WARNING:
Rechargeable batteries are only to
be charged under adult supervision.
Always disconnect your Electric
Wagon from the charger before
cleaning with liquid.
Note: If your charger does not
look like the one illustrated,
your unit has been supplied
with an alternative charger.
The specifications and charging
procedure would not change.
Charger
Port
1 Align the groove on the charger
port with the corresponding tab
on the Electric Wagon socket and
insert into socket.
Note: When charging, the power
switch should be in the off position.
2 Plug the charger plug into a
wall outlet.
Chargers have built-in over-charge
protection to prevent battery from
being over-charged.
Be sure to properly align the
groove on the charger port with
the corresponding socket on the
body; otherwise, no charging
action will occur.
q Assembling the Wagon
1 Position the Wagon with
the body up side down on a flat
surface.
2 Insert the rear axle into the
hole in the gearbox and slide it
through to the other side.
4 Insert a fixed clip into the clip
tool.
5 Position the fixed clip and
clip tool over the end of the
axle. Using a rubber mallet/
hammer, strike the tool to
securely attach the clip onto the
rear axle.
The charger has a small window
with an LED to indicate the charge
status. Refer to the illustration
on the charger unit for the actual
“charging” and “charged” status
indications for your model charger.
3 Locate the 2 rear wheels
(Rear wheels have gears on the
inside). Slide one wheel over
the axle until it interlocks with
gearbox.
Need Help? Visit our web site for replacement parts, product support and a list of authorized service centers at
www.razor.com or call toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
3
Set-Up
6 Repeat steps 4 and 5 to
attach the other rear wheel and
the 2 front wheels.
7 Flip the body assembly over.
8 Plug the hole on the front
board with the rubber ring.
9 Align holes on the handle
with the holes on the front
board and slide the handle axle
through to the other side.
10 Attach a fixed clip to both
ends of the handle axle to secure
the handle to the front board.
11 Position the front board
assembly to the body and
connect the wires from the
handle to the wires from the
body.
12 Feed the excess wires into
the opening on the main body.
13 Align the front board with the
main body. Lean the front board
slightly forward to hook the side
pegs (See arrows), then pull back to
the upright position while pushing
down on the front board until it
attaches securely into the main
body.
14 To attach the rear board,
lean board slightly forward,
then pull back while pushing
down until rear board is
attached securely to the main
body.
15 Attach the left side board. Make
sure side board is aligned properly
with the front and rear boards before
pushing down.
Note: You may need to push against
the rear board in order to securely
attach the side boards into place.
16 Repeat step 15 for right side
board.
17 Attach umbrella/cup holder
and tighten knob.
4
Operating the wagon
1 Turn the power switch on.
Located at the back of the
wagon body.
2 Use the forward/reverse
direction switch to select a
forward or reverse motion.
3 Squeeze the button on the
handle to activate power.
q Non-powered Mode
1 To pull the wagon in the
non-powered mode, disengage
the motor by pulling both levers
upward (located behind both
back wheels).
Battery Care and Disposal
Periodically recharge battery when not in use or the battery may deplete to a level at which it will not recharge.
Do not store the battery in temperatures above 75° or below -10° F.
CONTAINS SEALED NON-SPILLABLE LEAD BATTERIES.
BATTERIES MUST BE RECYCLED.
Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an
environmentally sound manner. Do not dispose of a lead-acid battery in a fire. The battery may explode or leak. Do not
dispose of a lead-acid battery in your regular household trash. The incineration, land filling or mixing of sealed leadacid batteries with household trash is prohibited by law in most areas. Return exhausted batteries to a federal or state
approved lead-acid battery recycler or a local seller of automotive batteries. If you live in Florida or Minnesota, it is
prohibited by law to throw away lead-acid batteries in the municipal waste stream.
WARNING: If a battery
leak develops, avoid contact with
the leaking acid and place the
damaged battery in a plastic bag.
Refer to the disposal instructions at
left. If acid comes into contact with
skin or eyes, flush with cool water
for at least 15 minutes and contact
a physician.
Need Help? Visit our web site for replacement parts, product support and a list of authorized service centers at
www.razor.com or call toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
5
Electric wagon PARTS
Keep your Electric Wagon running for years with genuine Razor parts. Visit our web site to purchase replacement parts.
(Specifications subject to change without notice.)
1
Rear board w/Razor logo
15
Gear box complete
2
Side board (left)
16
Rear axle
3
Side board (right)
17
Rear wheel complete (left)
4
Front board
18
Main body complete
5
Fixed clip
18-1 On/off switch
6
Handle axle
18-2 Reset button
7
Handle
18-3 Charger post
8
Fixed clip
19
Block of foam (battery)
9
Rear wheel complete (right)
20
Control Module
10
Fixed clip
21
Battery (12V / 4.5A)
11
Front wheel complete
22
Battery Cover
12
Front axle (right)
23
Seat board
13
Front axle (left)
24
Lap belt
14
Motor
25
Umbrella / Cup holder
6
SB 1918 (CALIFORNIA) DECLARATION
YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS
INVOLVING THE USE OF THIS ELECTRIC VEHICLE. TO DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR
AGENT.
7
Warranty
Razor Limited Warranty
The manufacturer warranties this product to be free of manufacturing defects
for a period of 90 days from date of purchase. This Limited Warranty does
not cover normal wear and tear or any damage, failure or loss caused by
improper assembly, maintenance, or storage or use of the Electric Wagon.
Razor does not offer an extended warranty. If you have purchased an
extended warranty, it must be honored by the store at which it was
purchased.
For your records, save your original sales receipt with this manual and write
the serial number below.
This Limited Warranty will be void if the product is ever
• used in a manner other than for recreation;
• modified in any way;
• rented.
__________________________________________
Item Number:
25144070
The manufacturer is not liable for incidental or consequential loss or damage
due directly or indirectly to the use of this product.
DO NOT RETURN TO STORE
Do not use this wagon for the first time until you
charged the battery for at least 12 hours.
Failure to follow these instructions may damage
your vehicle and void your warranty.
Need Help? Visit our web site for replacement parts, product support and a list of authorized service centers at
www.razor.com or call toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
Patent Pending
Printed in China for:
Razor USA LLC
PO Box 3610
Cerritos, CA 90703
Copyright © 2008 Razor USA, LLC. All rights reserved. RAZOR and the Razor Logo Design
are among the registered trademarks of Razor USA LLC in the United States and/or select
foreign countries.
8
05092008
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement