Turck DeviceNet - Steven Engineering

Turck DeviceNet - Steven Engineering
TURCK
Industrial I/O DeviceNet™ Products
F1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ System Description
DeviceNet is based on the Controller Area Network (CAN) broadcast-oriented communication architecture. CAN uses a
bus arbitration method, CSMA/BA, that assures the highest priority message always gets use of the bus in the event of a data
collision. The DeviceNet protocol further defines message priorities such that I/O messages are given top priority and
configuration messages have lower priority.
A DeviceNet network supports up to 64 nodes and virtually an unlimited amount of I/O. The bus uses a trunkline/dropline
topology, where bus power and communication are supplied on a single cable. Bus power is 24 VDC and supplies current
to operate the nodes and (typically) power input devices. Some TURCK stations require an additional 24 VDC auxiliary
power to supply current for outputs.
DeviceNet
DeviceNet is a low-cost communications protocol that eliminates hard wiring and connects industrial devices such as limit
switches, photoelectric sensors, valve manifolds, motor starters, process sensors, bar code readers, variable frequency drives,
panel displays and operator interfaces to a network. DeviceNet's direct connection provides improved communication
between devices, as well as important device-level diagnostics not easily accessible or available through hard-wired I/O
interfaces.
DeviceNet allows peer-to-peer data exchange (where a DeviceNet node can initiate communication with other nodes or
peers), and a master/slave configuration in which the master node initiates all communication and all other nodes, or slaves,
respond to the master node’s requests.
Typical System Configuration
Power Supply
RSMCBC5 5711-1M
B
BL20 I/O System
PLC
A
D
RKM 46-1M
RSC CBC5 572-1M
E
FDN20-4S-4XSG-E
JBBS-57-SM01
RSM 57-TR2
C
D
C
FDNQ-S0400-T
E
RSM RSM 5711-2M
RSM2RKM 57
C
D
FDNP-S0404G-TT
D
C
D
RKM RKC 5711-1M
BL67 I/O System
A typical DeviceNet system consists of the following parts:
• A - Controller
• B - Power Supply
• C - DeviceNet Cable
• D - DeviceNet I/O Modules (or Slaves)
• E - Terminating Resistors
DeviceNet stations require a network master (also called a scanner) to interface the stations to the host controller.
TURCK DeviceNet stations are designed to be fully compatible with DeviceNet equipment from other manufacturers.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F2
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Cordsets
TURCK offers a complete line of molded DeviceNet cordsets to facilitate network installation, resulting in a faster start-up
and fewer wiring errors. The bus and drop cables are specially designed foil-shielded, high-flex cables with very low
inductance and capacitance to minimize propagation delay time. DeviceNet cables consist of a shielded and twisted data
pair, as well as a shielded and twisted power pair for the 24 VDC bus power, with an additional outer shield. The 24 VDC
power pair provides bus power to the station’s communication electronics and (typically) to input circuits.
The data lines for CAN-High and CAN-Low differential signals conform to the CAN standard, and support network data
exchange at the maximum transmission speed of 500 kbps.
In most cases, bus cable connections are made using 5-pin minifast ® (7/8-16 UN) or eurofast ® (M12) connectors. A
variety of stations are also available that support terminal-block type connections. Stations with output circuits for DC
actuators normally require 24 VDC auxiliary power fed through a separate connection from the communication bus.
TURCK cordsets for the DeviceNet system are available in standard lengths. Contact your local sales representative to order
custom lengths.
Diagnostics
TURCK stations provide increased diagnostics when used with standard proximity or photoelectric sensors and discrete
actuators. TURCK stations also serve as a buffer between I/O devices and the DeviceNet bus by detecting short-circuits
without disrupting DeviceNet communication.
For deluxe style stations, each I/O point on the station provides state and status data. State data represents the real world
value of the I/O device; for example, when the sensor is on or the actuator is off. Status data indicates short-circuits in the
I/O device or in the wiring between the device and the station. Some models also use status data to indicate open circuits.
State and status data are transferred to the DeviceNet scanner where it is available for fault handling in the control program.
Additionally, each input and output has a multicolored LED to indicate its state and status and pinpoint I/O problems
quickly; for example the module status LED indicates the internal health of the station, and the network status LED indicates
the station’s communication on the DeviceNet network.
Addressing
The valid range of DeviceNet node addresses is 0 to 63. The station’s default node address is 63. Each node’s address must
be initially set, usually via rotary dials or switches on the node. The address can also be set with a DeviceNet configuration
tool.
Changes to the address settings take effect when the station power is cycled. Care must be taken to prevent the same
address from being assigned to more than one node in a system. If the same address is set on multiple nodes, one node will
take control of the address and the others will go into “Critical Link Failure” state, indicated by the network status LED (solid
red).
F3
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Communication Rate/Cycle Time
DeviceNet™ specifications define three transmission speeds: 125, 250 and 500 kbps. All nodes on a network must
communicate at the same rate.
Several factors must be considered when calculating the complete cycle time of a DeviceNet system, including:
Number of nodes being scanned
Amount of data produced and consumed by the nodes
Type of I/O messaging (change of state, strobe, poll)
Network communication rate
Device time-out and explicit messaging traffic
Cycle time of the control program
DeviceNet
•
•
•
•
•
•
Electronic Data Sheets (EDS) Files
Electronic Data Sheets, or EDS files, are files that contain detailed information about a DeviceNet device, including I/O data
size and the device’s configurable parameters. The information provided by EDS files guide a user through the steps
necessary to configure a device. EDS files are available on the TURCK web site (www.turck.com).
Maximum Ratings
The DeviceNet bus uses trunk and drop topology. The trunk is the main communication cable, and requires a 121 ohm
resistor at both ends of the trunk. The length of the trunk depends on the communication rate and the cable type. Drops
are branches off the trunk, and may be from zero to 6 m (20 ft) in length. The cumulative drop lengths are dependent on
the communication rate. The following table shows the maximum ratings for a trunk using thick, mid and thin cable. Thick
and thin DeviceNet communication cable types are defined by the DeviceNet specification; mid cable is a hybrid of the two
that is offered by TURCK.
Communication
Rate
Thick Trunk
Length
(maximum)
Mid Trunk
Length
(maximum)
Thin Trunk
Length
(maximum)
Drop Length
(maximum per
drop)
Drop Length
(cumulative)
Nodes
(maximum)
125 kbps
250 kbps
500 kbps
500 m (1640 ft.)
250 m (820 ft.)
100 m (328 ft.)
300 m (984 ft.)
250 m (820 ft.)
100 m (328 ft.)
100 m (328 ft.)
100 m (328 ft.)
100 m (328 ft.)
6 m (20 ft.)
6 m (20 ft.)
6 m (20 ft.)
156 m (512 ft.)
78 m (256 ft.)
39 m (128 ft.)
64
64
64
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F4
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet Selection Guide
Housing
I/O Type
I/O Direction
Pages
Input
F13, F15, F31, F39
Output
F29, F41
Input & Output
F17 - F27, F33 - F37, F43 - F45
Analog
Input
F47 - F49
E-connect
Input & Output
F51 - F64
AIM
Discrete
Master
F65
Repeater
F67
Spanner
F69
FDN20
Discrete
Input & Output
F75
Input
F89
Output
F93
Input & Output
F91, F95
Input
F97
Output
F101
Counter
F103
Encoder
F105
Serial
F107
Discrete
Input & Output
F111
Discrete
Input & Output
F115
Piconet
Discrete
Analog
Special Function
OEM
Operator Station
Gateways
BL67
F117
BL20
F119
AS-I
piconet
DeviceNet Media
F5
N/A
F121
F125
G1 - G82
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ AIM™ Stations
TURCK’s Advanced I/O Module (AIM) DeviceNet stations are extremely rugged stations designed for machine mounting.
These stations allow easy connection of standard I/O devices (such as sensors, limit switches, valves and pilot lights) to a
DeviceNet network, typically without a protective enclosure. This is made possible by epoxy-filled station housings,
all-metal connectors and visible rotary address switches, among other things.
Specifications
Mechanical
•
•
•
•
•
DeviceNet
TURCK DeviceNet AIM stations are designed for machine mounting with no separate enclosure or housing necessary.
Quick-disconnect capability, combined with an epoxy-filled housing, creates an extremely durable station that can be
mounted in most industrial environments. Detailed environmental specifications are as follows:
Housing material: Glass filled nylon
Connector material: Nickel-plated brass
Protection level: NEMA 1,3,4,12,13; IEC IP 67
Operating temperature: SE stations -40 to +70°C (-40 to +158°F); LX stations -25 to +70°C (-13 to +158°F)
Vibration: 50 g @ 10-500 Hz
Other housing and connector materials available upon request.
The stations components are identified in the following figure. The figure shows a station with minifast ® (7/8-16 UN)
network connectors, but other connector options (such as M12 eurofast ®) are available for some stations. Stations with all
I/O powered from the DeviceNet power supply do not have the auxiliary power connectors at the top of the housing.
Aux. Power Connectors
I/O Connectors
Address and Data Rate Switches
Network Connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F6
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Connectors
DeviceNet™ AIM™ stations generally provide connections for the bus and I/O, in addition to auxiliary power for stations
with outputs.
Bus Connectors
minifast ® (7/8-16UN) is the standard bus connector for DeviceNet AIM stations. Some stations are available with
eurofast ® (M12) or M23 bus connectors.
DeviceNet eurofast Pinouts
DeviceNet minifast Pinouts
Male
Female
Male
Female
5-Pin
5-Pin
1 - Shield/Drain
2 - V+ (24 VDC)
3 - V- (0 VDC)
4 - CAN High
5 - CAN Low
5-Pin
5-Pin
eurofast I/O Connectors
Different I/O connector pinouts are used for different station types. Stations are available with one or two inputs per
connector, one or two outputs per connector, or one input and one output per connector. The pin assignments for these
styles are provided below.
Screw Terminal I/O Connection
S
Mating cordset:
RK 4.4T-*-RS 4.4T
G
Mating cordset:
RK 4.4T-*-RS 4.4T
F7
2S
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS-4.4-2RK 4T-*/*
2G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS-4.4-2RK 4T-*/*
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VB2-RS 4.4T-1/2RK
4.4T-*/*/S651
2X
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS-4.4-2RK 4T-*/*
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
AIM™ stations with part numbers ending in “ST” support screw terminal I/O and bus connections. The screw terminals for
these stations are located on the back of the station. The back of the station is also fitted with a foam gasket to allow the
station to be mounted to the outside of a cabinet or field I/O box (i.e. motor control center).
DeviceNet
Auxiliary Power Connectors
St
at
ions where I/O draws a significant amount of current (2 Amp outputs, for example) receives this power from a second, or
auxiliary, power supply. Some stations receive input power from the network and output power from the auxiliary supply.
Generally, the connection is a male/female pair to allow cabling one power supply to multiple stations without the use of a
tee (daisy chain configuration). Auxiliary power is typically supplied by a 4-pin minifast ® (7/8-16 UN) connector, though
other auxiliary power connections are used on some stations. For further details see the individual station entries in this
catalog.
Aux. Power Pinout
Male
Female
1 = VAUX+
2 = Pass Through
3 = Pass Through
4 = VAUX-
4-Pin
4-Pin
Power
Some AIM stations (typically those with only inputs) are completely powered from the DeviceNet power supply. When
designing a network, take care to include the current draw for the station, as well as all input devices connected to the
station in your power supply sizing calculations. For example, if the internal current consumption of the station is <50 mA
and the total short-circuit limit for all inputs combined is <700 mA, then the maximum current draw for the station is
50 mA + 700 mA = 750 mA.
Stations with output points normally use a separate auxiliary power supply to provide current for the outputs. Several AIM
stations can be powered by one auxiliary supply, or a single supply for each station can be used.
Common power ratings for AIM stations include:
• Bus (DeviceNet) Voltage: 11-26 VDC
• Aux Power Voltage: 24 VDC (nominal, supported stations)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F8
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
• Input Voltage: 13-26 VDC (From DeviceNet supply)
• Input Signal Current (each input): OFF <2 mA; ON 3.0-3.4 mA (@ nominal 24 VDC)
• Input Delay: 2.5 ms
Addressing
DeviceNet™ stations must have a network address for communication.
The address for AIM stations may be set via the visible rotary switches
under the clear plastic cover on the front of the station.
The pair of switches represents the address as a decimal number; the left switch being the 10’s multiplier and the right
switch the 1’s multiplier. To program the station, rotate the switches with a small slotted screwdriver until the arrows on the
switch point to the appropriate numbers for the chosen address.
Some stations (LX style with extended diagnostics) have a third switch. This switch is used to set the communication baud
rate for the station. When set to the AUTO position, the station automatically senses the baud rate of the network. SE style
stations only use the autobaud setting.
Parameters
Many DeviceNet configuration tools support the use of EDS driver files to configure nodes and set various parameters.
Some of the user settable parameters available for AIM stations are:
Parameter Name
Description
Valid Values
Default
Baud Rate
Defines the baud rate for the station to use if
Autobaud is disabled
125kB; 250kB; 500kB
125kB
Autobaud
If enabled the station automatically senses the
baud rate
Enable; Disable
Enable
Connection Mode
Set to UCMM to use unconnected messaging
Predefined M/S Connection;
UCMM
Predefined M/S Connection
Quick Connect
Set to enable fast startup connection to
DeviceNet (QuickConnect)
Enable; Disable
Disable
Consult the documentation for the DeviceNet configuration tool you are using for details on how to access device
parameters via EDS files.
F9
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Diagnostics
AIM™ stations provide two LEDs for diagnosing communication problems.
DeviceNet
Module Status
• Green: Working properly
• Flashing green: Detecting baud rate
• Flashing red: Input short-circuit
Network Status
• Green: Connection established
• Flashing green: Waiting for connection
• Flashing red: Connection timed out
• Red: Cannot connect
There is an additional LED for each I/O point on the station. This LED indicates:
•
•
•
•
Off: Point is off
Green: Point is on
Amber: Point is in open circuit state (advanced diagnostic stations only)
Red: Point is in short-circuit state (advanced diagnostic stations only)
For SE style (group diagnostic) stations there is also a single bit communicated to the controller for diagnostic purposes. This
bit is on if any input on the station is in the short-circuit condition, and off if all inputs are operating normally.
LX style (extended diagnostic) stations indicate the diagnostic status of each I/O point on the station, with an extra bit to
indicate if the point is short or open circuited. These diagnostic bits can be disabled via the EDS parameter settings.
I/O Data Map 1
In
Out
Byte
Bit 7
Bit 6
Bit 5
Bit 4
Bit 3
Bit 2
Bit 1
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
Bit 0
I-0
1
ISS-7
ISS-6
ISS-5
ISS-4
ISS-3
ISS-2
ISS-1
ISS-0
2
IOS-7
IOS-6
IOS-5
IOS-4
IOS-3
IOS-2
IOS-1
IOS-0
3
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
OS-0
4
-
APS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
extended diagnostic
Connecting Devices to an AIM Station
AIM stations typically provide a eurofast ® (M12) connection for each I/O point. Standard TURCK I/O cordsets can be used
to connect physical devices in the field to the AIM station. Some AIM stations, specifically those with I/O counts greater
than eight total points, connect two signals to each connector. If the signals being connected are on the same physical
device (for example a sensor with two outputs), a simple four or five-wire cordset can be used for connection (Figure 1) on
the next page.
I
O
ISS
IOS
OS
APS
= Input
= Output
= Input Short Circuit Status
= Input Open Circuit Status
= Output Status
= Auxiliary Power Status
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F10
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
If the signals are on two separate devices, a splitter can be used to separate the AIM™ I/O connector into two individual
eurofast ® connectors. The recommended splitter is wired such that the second signal pin on the AIM station (pin 2) is
wired to the default signal pin (pin 4) on the second splitter arm - requiring no special wiring by the user. The splitter is
simply plugged into the AIM I/O connector and each arm is plugged into the appropriate I/O devices, as shown (Figure 2).
Figure 1
For one input per connector use standard cordsets, for example RK 4.4T-1-RS 4.4T
AIM stations provide a wide range of connection options depending on the I/O count and type being used. The user should
be aware of the I/O pinout being used.
Figure 2
For two inputs per connector use a splitter, for example VBRS 4.4-2RK 4T-1/1
F11
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Part Number Key
F DN P - L 04 04
G
- T T
F = AIM™ Designator
Top-entry, plastic
-
V
DeviceNet
Connector Material
Blank = Nickel Plated Brass
V = Stainless Steel
DN = DeviceNet
Aux Power Connector
T = Through minifast ®
Both male and female
P = 8 I/O Ports/Aux power/220 mm long
L = 8 I/O Ports/197 mm long
Q = 4 I/O Ports/148 mm long
L =
P =
S =
C=
X =
N=
NPN/PNP, Individual Open and Short-circuit Detection
PNP, Individual Open and Short-circuit Detection
PNP, Group Input Short-circuit Detection, Earth Ground Pin 5
Combined (ie: CPG = Combined PNP and 500 mA Outputs)
Universal PNP Input or 500 mA Output
NPN, Group Input Short-circuit Detection, Earth Ground Pin 5
DeviceNet Connector Configuration
T = Through minifast, both male and female
E = eurofast ® Drop, single male
M= minifast drop, male only
G = 510 mA Outputs
H = 1.4 or 2.0 Amp Outputs
Number of Outputs
Number of Inputs
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F12
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Deluxe Input Stations
• Rugged, Fully Potted Stations
• Rotary Address Switches
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
≤100 mA (8-in) or 140 mA (16-in) plus sum of input
currents (from DeviceNet)
• Sensor Current: <80 mA per input (from DeviceNet)
• Operating Current:
Power Distribution
• Inputs: DeviceNet power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67
• Vibration: 50 g @ 10-500 Hz
FDNL-L0800-T
FDNL-L0800-T-V
FDNL-L1600-T
FDNL-L0800-C
FDNL-L1600-C
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit each per I/O
point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast ® Pinouts
1=
2=
3=
4=
5=
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
FDNL-...-T
DeviceNet eurofast ® Pinouts
1=
2=
3=
4=
5=
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
FDNL-...-C
F13
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
FDNL-L0800-T
8
0-7
L
1
NPN/PNP
X
X
1
FDNL-L0800-T-V
8
0-7
L
1
NPN/PNP
X
X
1
FDNL-L1600-T
16
0-7
2L
2
NPN/PNP
X
X
2
FDNL-L0800-C
8
0-7
L
1
NPN/PNP
X
X
1
FDNL-L1600-C
16
0-7
2L
2
NPN/PNP
X
X
2
DeviceNet
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
sor
Sen
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
le
Data
Sty
Inp
ut
C o s per
nne
cto
r
Pin
out
Part Number
Co
Inp
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
L
2L
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
Sensor with dual outputs:
RK 4.4T-*-RS 4.4T
Two sensors:
RK 4.5T-*-RS 4.5T
Splitter:
VBRS 4.5-2RK 4T-*/*/S818
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
I-0
1
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
2
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
3
ISS-15 ISS-14 ISS-13 ISS-12 ISS-11 ISS-10 ISS-9 ISS-8
4
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
5
IOS-15 IOS-14 IOS-13 IOS-12 IOS-11 IOS-10 IOS-9 IOS-8
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F14
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input Stations
• Rugged, Fully Potted Stations
• Rotary Address Switches
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <50 mA plus input currents (from DeviceNet)
• Sensor Current: <700 mA sum of all inputs (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
FDNL-S0800-T
FDNL-S1600-T
FDNL-S1600-T-V
FDNL-N0800-T
FDNL-N1600-T
FDNL-S1600-E
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for all inputs
Diagnostics (Physical)
• One LED indicates a fault for the whole station
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
1=
2=
3=
4=
5=
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
FDNL...T
DeviceNet eurofast ® Pinouts
Male
1=
2=
3=
4=
5=
Shield
V+
VCAN_H
CAN_L
5-Pin
FDNL...E
F15
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
FDNL-S0800-T
8
0-7
S
1
PNP
X
1
FDNL-S1600-T
16
0-7
2S
2
PNP
X
2
FDNL-S1600-T-V
16
0-7
2S
2
PNP
X
2
FDNL-N0800-T
8
0-7
N
1
NPN
X
1
FDNL-N1600-T
16
0-7
2N
2
NPN
X
2
FDNL-S1600-E
16
0-7
2S
2
PNP
X
2
DeviceNet
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
sor
Sen
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
le
Data
Sty
Inp
ut
C o s per
nne
cto
r
Pin
out
Part Number
Co
Inp
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
S
2S
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
2N
N
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
-
-
-
-
-
-
-
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
IGS
-
-
-
-
-
-
-
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F16
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Deluxe Input/Output Station
• Rugged, Fully Potted Stations
• Input and Output on Same Connector
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA plus sum of I/O currents (from DeviceNet)
• Sensor Current: <120 mA per input (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNL-CPG88-T
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit each per I/O
point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
1=
2=
3=
4=
5=
F17
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
8
C
1
PNP
X
X
8
0-7
C
1
0.5 A
X
X
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tpu
t
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
0-7
Outputs
1
DeviceNet
FDNL-CPG88-T
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VB2-RS 4.4T-1/2RK 4.4T-*/*/S651
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
In
Out
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
2
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
3
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
4
-
APS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
OS-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F18
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input/Output
Station
• Rugged, Fully Potted Stations
• IP 67, IP 68, IP 69K Protection
• Input and Output on Same
Connector
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA plus sum of I/O currents (from DeviceNet)
• Sensor Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNL-CSG88-T
FDNL-CSG88-T-V
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for all inputs, one bit for all outputs
Diagnostics (Physical)
• One LED indicates I/O fault for entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
1=
2=
3=
4=
5=
F19
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Data
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
nt
Cu
rre
Sen
Outputs
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
le
sor
Sty
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
Co
Part Number
Inp
ut C
oun
t
Inputs
8
0-7
C
1
PNP
X
8
0-7
C
1
0.5 A
1
FDNL-CSG88-T-V
8
0-7
C
1
PNP
X
8
0-7
C
1
0.5 A
1
DeviceNet
FDNL-CSG88-T
Input/Output Connectors
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VB2-RS 4.4T-1/2RK 4.4T-*/*/S651
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
1
IGS
OGS
-
-
-
-
-
I-0
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F20
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Input/Output Station
• Rugged, Fully Potted Stations
• DeviceNet Powered I/O
• IP 67, IP 68, IP 69K Protection
• Sinking Outputs
Electrical
• Operating Current: <75 mA (from DeviceNet)
• Sensor Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70 °C (-40 to +158 °F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNL-SN0808N-C
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Physical)
• One LED indicates a fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet eurofast Pinout
1=
2=
3=
4=
5=
F21
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
8
2SN
2
PNP/NPN
8
4-7 2NO
2
0.5 A
Data
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
nt
Cu
rre
le
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
Sty
sor
Sen
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
cto
nne
0-3
Outputs
1
DeviceNet
FDNL-SN0808N-C
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
2SN
2NO
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
1
IGS
-
-
-
-
-
-
I-0
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F22
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Input/Output Station
• Rugged, Fully Potted Stations
• DeviceNet Powered I/O
• IP 67, IP 68, IP 69K Protection
• Sinking Outputs
Electrical
• Operating Current: <75 mA (from DeviceNet)
• Sensor Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70 °C (-40 to +158 °F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
FDNL-S1204H-0142*
FDNL-S1204H-0153
Diagnostics (Physical)
• One LED indicates a fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet multifast Pinout
C0
C4
C1
C5
C2
C6
C3
Male
Female
17-Pin
17-Pin
C7
1=
2=
3=
4=
5=
6=
7=
8=
9=
0 V, us1
0 V, US2
+24, US2
+24, US1
PE
*
Us COM
*
KSR2
10 =KSR1
11 =*
12 =Us CAN high
13 =Devnet high
14 =Devnet low
15 =RBST
16 =UL
17 =Us CAN low
* Rear removable terminal present on FDNL-S1204H-0142 only.
F23
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
I/O
Ma
p
nt
Cu
rre
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
le
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
Sty
sor
Sen
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
cto
nne
Co
Part Number
Inp
ut C
oun
t
Industrial
Automation
0-2
4-6
2
PNP
X
4
3+7
2
2.0 A
1
FDNL-S1204H-0153 12
0-2
4-6
2
PNP
X
4
3+7
2
2.0 A
1
DeviceNet
FDNL-S1204H-0142 12
Input/Output Connectors
2S
2H
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
-
-
-
I-11
I-10
I-9
I-8
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F24
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Deluxe Input/Output
Stations
• Rugged, Fully Potted Stations
• Auxiliary Powered Outputs
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA (all except ...L0404G… is <140 mA) plus
sensor currents (from DeviceNet power)
• Sensor Current: <80 mA per input (from DeviceNet)
• Output Current: See table on facing page
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: Auxiliary power supply
Mechanical
FDNP-L0404G-TT
FDNP-L0808G-TT
FDNP-L0808H-TT*
FDNP-P0808H-TT*
* Not FM
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit each per I/O point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
Aux. Power Pinout
1=
2=
3=
4=
Male
Female
4-Pin
4-Pin
Vaux+
Pass thru
Pass thru
Vaux-
DeviceNet minifast Pinout
1=
2=
3=
4=
5=
F25
Male
Female
5-Pin
5-Pin
Shield
V+
VCAN_H
CAN_L
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Data
FDNP-L0404G-TT
4
0-3
L
1
PNP/NPN
X
X
4
4-7
G
1
0.5 A
X
X
1
FDNP-L0808G-TT
8
0-3
2L
2
PNP/NPN
X
X
8
4-7
2G
2
0.5 A
X
X
2
FDNP-L0808H-TT
8
0-3
2L
2
PNP/NPN
X
X
8
4-7
2H
2
2A
X
X
2
FDNP-P0808H-TT
8
0-3
2P
2
PNP
X
X
8
4-7
2H
2
2A
X
X
2
DeviceNet
I/O
Ma
p
Cu
rre
nt
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Outputs
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
L
Mating cordset:
RK 4.4T-*-RS 4.4T
2L
2P
Mating cordset:
Sensor with dual outputs:
RK 4.4T-*-RS 4.4T
Two sensors:
RK 4.5T-*-RS 4.5T
Splitter:
VBRS 4.5-2RK 4T-*/*/S818
Mating cordset:
Sensor with dual outputs:
RK 4.4T-*-RS 4.4T
Two sensors:
RK 4.5T-*-RS 4.5T
Splitter:
VBRS 4.5-2RK 4T-*/*/S818
2G
2H
G
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
In
Out
-
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
-
-
-
I-3
I-2
I-1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
I-0
1
IOS-3 IOS-2 IOS-1 IOS-0 ISS-3 ISS-2 ISS-1 ISS-0
2
OOS-3 OOS-2 OOS-1 OOS-0 OSS-3 OSS-2 OSS-1 OSS-0
0
In
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
2
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
3
-
APS
-
-
-
-
-
-
3
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
0
-
-
-
-
O-3
O-2
O-1
O-0
4
-
APS
-
-
-
-
-
-
0
0-7
0-6
0-5
0-4
O-3
O-2
O-1
O-0
Out
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
OS-0
F26
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Deluxe Input/Output
Station
• Rugged, Fully Potted Stations
• Auxiliary Powered I/O
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <30 mA (from DeviceNet)
• Sensor Current: <120 mA per input (from Auxiliary power)
• Output Current: <0.5 A per output (from Auxiliary power)
Power Distribution
• Inputs: Auxiliary power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNP-CPG88-TT
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit each per I/O
point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
Aux. Power Pinout
Male
Female
4-Pin
4-Pin
1 = Vaux+
2 = Pass thru
3 = Pass thru
4 = Vaux-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F27
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
8
C
1
PNP
X
X
8
0-7
C
1
0.5 A
X
X
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
nt
Cu
rre
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
0-7
Outputs
1
DeviceNet
FDNP-CPG88-TT
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VB2-RS 4.4T-1/2RK 4.4T-*/*/S651
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
In
Out
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
2
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
3
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
4
-
APS
-
-
-
-
-
-
0
0-7
0-6
0-5
0-4
O-3
O-2
O-1
O-0
OS-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F28
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Output Stations
• Rugged, Fully Potted Stations
• Auxiliary Powered Outputs
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current:
<140 mA (FDNP...G-TT), <50 mA (FDNP...H-TT),
<75 mA (FDNP...0200) (from DeviceNet)
• Output Current: see table on facing page (from aux. power)
Power Distribution
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNP-S0008G-TT
FDNP-S0008G-TT-V
FDNP-S0008H-TT*
FDNP-S0016N-TT-0200*
*Not FM
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• short-circuit status mapped to DeviceNet I/O table, one bit per each I/O point
(except FDNP...0200 has no diagnostic data)
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel (except
FDNP...0200 has one LED indicating a short for all I/O points)
Aux. Power Pinout
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = Pass thru
3 = Pass thru
4 = VAUX-
FDNP...TT
Aux. Power Pinout
Male
Female
1 = VAUX+
2 = VIN+
3 = VIN4 = VAUX-
4-Pin
4-Pin
FDNP...0200
DeviceNet minifast Pinout
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F29
Male
Female
5-Pin
5-Pin
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Wi
re
De -Brea
tec
k
tion
I/O Map
FDNP-S0008G-TT
8
0-7
G
1
0.5 A
X
1
FDNP-S0008G-TT-V
8
0-7
G
1
0.5 A
X
1
FDNP-S0008H-TT
8
0-7
H
1
1.4 A
X
1
FDNP-S0016N-TT-0200
16
0-7
2GN
2
0.5 A
DeviceNet
rre
nt
Ind
iv
Dia idual
gno
stic
s
Data
Cu
Pin
out
Co
Part Number
nne
Ou
tp
Co ut
unt
cto
rs
Ou
tp
C o uts p
n n e er
cto
r
Outputs
2
Output Connectors
H
G
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
In
Out
2GN
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
OS-0
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Out
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
1
0-15
0-14
0-13
0-12
0-11
0-10
0-9
0-8
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F30
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input Station
• Rugged, Fully Potted Stations
• Auxiliary Powered Inputs
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <20 mA (from DeviceNet)
• Sensor Current: <700 mA total of all inputs (from VIN power)
Power Distribution
• Inputs: Auxiliary (VIN) power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
FDNP-N1600-TT-0197
• No diagnostic data
Diagnostics (Physical)
• One LED indicates a fault for the entire station
• LEDs to indicate status of DeviceNet communication
Aux. Power Pinout
Male
Female
4-Pin
4-Pin
1 =VAUX+
2 = VIN+
3 = VIN4 = VAUX-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F31
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
0-7
2S
2
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
le
Sen
sor
Sty
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
16
Data
I/O Map
NPN
1
DeviceNet
FDNP-N1600-TT-0197
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
2S
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F32
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input/Output
Stations
• Rugged, Fully Potted Stations
• Auxiliary Powered
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus applicable input currents (from
DeviceNet)
• Sensor Current: <700 mA total (from DeviceNet except FDNP-CSG…
and FDNP-XSG...) per input
• Output Current: See table on facing page
Power Distribution
• Inputs: DeviceNet power supply
(except FDNP-CSG… and FDNP-XSG… from Auxiliary supply)
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
FDNP-S0404G-TT
FDNP-S0808G-TT
FDNP-CSG88-TT
FDNP-XSG16-TT
FDNP-S1204H-TT-0149*
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates fault
for entire station (FDNP-CSG88-TT maps one bit for all inputs and one bit for each
output point)
* Not FM Approved
Diagnostics (Physical)
• One LED indicates fault for entire station
• LEDs to indicate status of DeviceNet communication
C0
Aux. Power Pinout
C4
C1
C5
C2
C6
C3
C7
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = Pass thru
3 = Pass thru
4 = VAUX-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F33
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
FDNP-S0404G-TT
4
0-3
S
1
PNP
X
4
4-7
G
1
0.5 A
1
FDNP-S0808G-TT
8
0-3
2S
2
PNP
X
8
4-7
2G
2
0.5 A
2
FDNP-CSG88-TT
8
0-7
C
1
PNP
X
8
0-7
C
1
0.5 A
FDNP-XSG16-TT
16
0-7
2X
2
PNP
X
16
0-7
2X
2
0.5 A
4
FDNP-S1204H-TT-0149
12
0-2,
4-6
2S
2
PNP
X
4
3, 7
2H
2
1.4 A
3
X
5
DeviceNet
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
sor
Sty
le
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tpu
Co t
unt
Co
nne
cto
rs
Pin
out
Outputs
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
Part Number
Co
Inp
nne
ut C
oun
t
Inputs
Input/Output Connectors
2S
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VB2-RS 4.4T-1/2RK 4.4T-*/*/S651
S
Mating cordset:
RK 4.4T-*-RS 4.4T
2X
G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
2G
2H
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter: VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
OGS
-
-
I-3
I-2
I-1
I-0
0
-
-
-
-
O-3
0-2
O-1
O-0
I/O Data Map 4
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
OGS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
0-2
O-1
O-0
Out
I-6
I-5
I-4
I-3
I-2
I-1
I-0
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
IGS
OGS
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
1
O-15
O-14
O-13
O-12
O-11
O-1O
O-9
O-8
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Out
I-7
1
I/O Data Map 5
I/O Data Map 3
In
0
0
I-7
I-6
1
IGS
OGS
0
-
-
I-5
I-4
I-3
I-2
I-1
I-0
-
-
I-11
I-10
I-9
I-8
-
-
O-3
O-2
O-1
O-0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
OS-0
2
IGS
-
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F34
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Deluxe Input/Output
Station
• Rugged, Fully Potted Stations
• Auxiliary Powered Outputs
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA plus sum of input currents (from DeviceNet)
• Sensor Current: <80 mA per input (from DeviceNet)
• Output Current: <0.5 A per output (from Auxiliary power)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNP-P1204G-TT
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit for each I/O
point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
Aux. Power Pinout
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = pass thru
3 = pass thru
4 = VAUX-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F35
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
12
2P
2
PNP
X
X
4
3, 7
2G
2
0.5 A
X
X
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tpu
t
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
0-2,
4-6
Outputs
1
DeviceNet
FDNP-P1204G-TT
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
2P
2G
Mating cordset:
Sensor with dual outputs:
RK 4.4T-*-RS 4.4T
Two sensors:
RK 4.5T-*-RS 4.5T
Splitter:
VBRS 4.5-2RK 4T-*/*/S818
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
1
In
Out
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
-
APS
-
-
I-11
I-10
I-9
I-8
2
ISS-7 ISS-6 ISS-5 ISS-4 ISS-3 ISS-2 ISS-1 ISS-0
3
OSS-3 OSS-2 OSS-1 OSS-0 ISS-11 ISS-10 ISS-9 ISS-8
4
IOS-7 IOS-6 IOS-5 IOS-4 IOS-3 IOS-2 IOS-1 IOS-0
5
OOS-3 OOS-2 OOS-1 OOS-0 IOS-11 IOS-10 IOS-9 IOS-8
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F36
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input/Output
Stations
• Rugged, Fully Potted Stations
• Screw Terminal Connections
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current:
<75 mA from DeviceNet (for ...S0808G… add input
currents)
• Sensor Current: <700 mA total of all inputs (...S0808G… From
DeviceNet, ...XSG16… from aux. Power)
• Output Current: <500 mA per output (from aux. power)
Power Distribution
• Inputs: ...S0808G… from DeviceNet power supply, ...XSG16… From
Auxiliary power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNP-S0808G-ST
FDNP-XSG16-ST
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for the entire station
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire
station
• LEDs to indicate status of DeviceNet
communication
Aux. Power Pinout
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = pass thru
3 = pass thru
4 = VAUX-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F37
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
nt
Cu
rre
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Outputs
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
Part Number
Co
Inp
ut C
oun
t
Inputs
8
0-3
2S,
ST1
2
PNP
X
8
4-7
2G,
ST1
2
0.5 A
1
FDNP-XSG16-ST
16
0-7
2X,
ST2
2
PNP
X
16
0-7
2X
ST2
2
0.5 A
2
DeviceNet
FDNP-S0808G-ST
Input/Output Connectors
2S
2X
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
2G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
ST1
ST2
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
OGS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
IGS
OGS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
1
O-15
O-14
O-13
O-12
O-11
O-10
O-9
O-8
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F38
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input Stations
• Rugged, Fully Potted Stations
• Compact Housing
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus total of input currents (from DeviceNet)
• Sensor Current: <700 mA sum of all inputs (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
FDNQ-S0200-T*
FDNQ-S0400-T
FDNQ-S0800-T
FDNQ-S0400-C
* Not FM Approved
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates
fault for entire station
Diagnostics (Physical)
• One LED indicates fault for entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
FDNQ...T
DeviceNet eurofast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
FDNQ...C
F39
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Wi
re
De -Brea
tec
k
tion
I/O Map
FDNQ-S0200-T
2
0,2
S
1
PNP
X
3
FDNQ-S0400-T
4
0-3
S
1
PNP
X
1
FDNQ-S0800-T
8
0-3
2S
2
PNP
X
2
FDNQ-S0400-C
4
0-3
S
1
PNP
X
1
DeviceNet
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
sor
Sty
le
Data
Sen
Inp
u
C o ts per
nne
cto
r
Pin
out
Part Number
Co
Inp
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
S
2S
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
In
I/O Data Map 3
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
-
-
-
I-3
I-2
I-1
I-0
In
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
-
-
-
-
-
I-1
I-0
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
-
-
-
-
-
-
-
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F40
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Output Station
• Rugged, Fully Potted Stations
• Compact Housing
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus total of all output currents (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
FDNQ-S0002G-T
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit each per I/O
point
Diagnostics (Physical)
• Individual LED to indicate open/short-circuit for each channel
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F41
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
0, 2
G
1
0.5 A
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
nt
rre
Cu
Ou
tp
C o uts p
n n e er
cto
r
Pin
out
nne
Co
2
Data
X
I/O Map
1
DeviceNet
FDNQ-S0002G-T
Ou
tp
Co ut
unt
Part Number
cto
rs
Outputs
Output Connectors
G
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
-
-
-
-
-
-
OS-1
OS-0
0
-
-
-
-
-
-
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F42
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input/Output
Stations
• Rugged, Fully Potted Stations
• DeviceNet Powered I/O
• IP 67, IP 68, IP 69K Protection
• Compact Housing
Electrical
• Operating Current: <75 mA plus total of all I/O current (from DeviceNet)
• Sensor Current: <700 mA total of all inputs (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
Mechanical
• Operating Temperature: -40 to +70 °C (-40 to +158 °F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
FDNQ-S0201G-T*
FDNQ-CSG44-T
FDNQ-S0404G-T
FDNQ-XSG08-T
FDNQ-CSG44-E
* Not CSA Approved
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates
fault for entire station (...S0201G-T has one dedicated bit to indicate a fault for
the output point as well)
Diagnostics (Physical)
• One LED indicates fault for entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
FDNQ...-E
F43
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
FDNQ-S0201G-T
2
0
2S
2
PNP
X
1
1
G
1
0.5 A
FDNQ-CSG44-T
4
0-3
C
1
PNP
X
4
0-3
C
1
0.5 A
2
FDNQ-S0404G-T
4
0-1
2S
2
PNP
X
4
2-3
2G
2
0.5 A
2
FDNQ-XSG08-T
8
0-3
2X
2
PNP
X
8
0-3
2X
2
0.5 A
3
FDNQ-CSG44-E
4
0-3
C
1
PNP
X
4
0-3
C
1
0.5 A
2
Part Number
X
1
DeviceNet
nt
Cu
rre
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
Data
Co
nne
Outputs
Inp
ut C
oun
t
Inputs
Input/Output Connectors
S
C
Mating cordset:
RK 4.4T-*-RS 4.4T
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VB2-RS 4.4T-1/2RK 4.4T-*/*/S651
2X
2G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
I/O Data Map 1
Out
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
In
2S
I/O Data Map 3
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
-
-
-
-
OS-0
I-1
I-0
0
-
-
-
-
-
-
-
O-0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
1
IGS
OGS
-
-
-
-
-
I-0
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
I/O Data Map 2
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
OGS
-
-
I-3
I-2
I-1
I-0
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F44
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Standard Input/Output
Station
• Rugged, Fully Potted Stations
• Auxiliary Powered Outputs
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus total of input currents (from DeviceNet)
• Sensor Current: <700 mA total of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from Auxiliary power)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: Auxiliary power supply
Mechanical
FDNQ-S0404G-MM
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates
fault for entire station
Diagnostics (Physical)
• One LED indicates a fault for the entire station
• LEDs to indicate status of DeviceNet communication
Aux. Power Pinout
C0
C1
C2
C3
minifast Male
1 = VAUX+
2 = NC
3 = NC
4 = VAUX4-Pin
DeviceNet Pinout
minifast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
F45
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
4
2S
2
X
4
2-3
2G
2
0.5 A
X
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Sen
PNP
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
le
sor
Sty
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
0-1
Outputs
1
DeviceNet
FDNQ-S0404G-MM
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
2S
2G
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
Mating cordset:
RK 4.4T-*-RS 4.4T
Splitter:
VBRS 4.4-2RK 4T-*/*
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
OGS
-
-
I-3
I-2
I-1
I-0
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F46
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Analog Input Station
• Rugged, Fully Potted Stations
• Compact Housing
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA plus sum of input currents (from DeviceNet)
• Sensor Current: 0-20 mA or 4-20 mA analog signal (16-bit signed integer).
The 0-20 mA or 4-20 mA range can be adjusted via rotary switch on front of
station.
Power Distribution
• Inputs: DeviceNet power supply
Mechanical
FDNQ-4AI-I-T
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F47
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
0-3
AI-I
1
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
le
Sty
sor
Sen
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
4
Data
I/O Map
0-20 mA
or
4-20 mA
1
DeviceNet
FDNQ-4AI-I-T
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
AI-I
Mating cordset:
Isolated Loop:
RK 4.5T-*M-RS 4.5T/S653
Loop Powered:
RK 4.5T-*M-RS 4.5T/LPS/S653
Note: The "LPS" in the part number indicates that the cord
jumpers pin 3 to pin 4 on the male side to the signal- to the station
common. Pin 3 is not connected at the female end.
Applications:
TURCK Sensors:
LU; RK 4.4T-*-RS 4.4T/S1118
LI; RK 4.4T-*-*RS 4.4T/S1120
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Channel 0, LSB
1
Channel 0, MSB
2
Channel 1, LSB
3
Channel 1, MSB
4
Channel 2, LSB
5
Channel 2, MSB
6
Channel 3, LSB
7
Channel 3, MSB
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F48
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Analog Input Station
• Rugged, Fully Potted Stations
• Compact Housing
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <100 mA plus sum of input currents (from DeviceNet)
• Sensor Current: 0-20 mA or 4-20 mA analog signal (16-bit signed integer)
• Sensor Voltage: 0 to 10 V or -10 to +10 V Analog signal
(16 bit signed integer)
The voltage/current ranges can be adjusted via rotary switch on front of station.
Power Distribution
• Inputs: DeviceNet power supply
Mechanical
FDNQ-4AI-V/I-T
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet communication
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F49
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
0-3
AI-I
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
le
Sty
sor
Sen
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
4
Data
I/O Map
0-20 mA,
4-20 mA
0-10 V
-10 to +10 V
1
1
DeviceNet
FDNQ-4AI-V/I-T
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
Input Connectors
AI-I
Mating cordset:
Isolated Loop:
RK 4.5T-*M-RS 4.5T/S653
Loop Powered:
RK 4.5T-*M-RS 4.5T/LPS/S653
Note: The "LPS" in the part number indicates that the cord
jumpers pin 3 to pin 4 on the male side to the signal- to the station
common. Pin 3 is not connected at the female end.
Applications:
TURCK Sensors:
LU; RK 4.4T-*-RS 4.4T/S1118
LI; RK 4.4T-*-*RS 4.4T/S1120
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Channel 0, LSB
1
Channel 0, MSB
2
Channel 1, LSB
3
Channel 1, MSB
4
Channel 2, LSB
5
Channel 2, MSB
6
Channel 3, LSB
7
Channel 3, MSB
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F50
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
The E-connect system
Safely stopping motion is becoming more critical as machinery and systems become more automated. Where once a
machine was controlled by one person, today we have many interconnect machines that are controlled by Industrial
PCs and PLCs. Motion may start automatically without warning, and some of today’s equipment is almost silent in
comparision to the background noise of the factory.
TURCK has developed three systems to quickly connectorize standard e-stop devices.
1) Series E-connect
2) Series E-connect with bus monitoring and annunciation
3) Dedicated E-connect
Series E-connect
Series connection of redundant e-stop device contacts is one of the most common ways in North America to provide
machine safety for personnel. Two isolated circuits go from the safety relay module to the redundant contacts of each
emergency stop devices.
Dedicated E-connect
Two dedicated circuits go from the safety relay module to redundant contacts of a single emergency stop, or
safeguarding device.
E-connect Station
8 Pin eurofast ® for quick connection to
E-Stop devices
• 4-wires for redundant safety circuit contacts
• 2-wires for monitoring contacts
• 2-wires for optional local annunciation
controlled via DeviceNet™
Less than 50 mA current consumption
on DeviceNet™ power bus
4 Pin eurofast ® for quick series
connection of E-connect stations to
a safety relay module
• 2-isolated wires for redundant
safety circuits
• 2-wires for auxiliary power for local
pilot light annunciation
Visible Rotary Address
Switches
5 Pin minifast ®
DeviceNet connectors
Advantages
•
Tremendous savings in startup and trouble shooting time
•
DeviceNet PLC monitors the state of the safety switch
•
Easy to integrate into any DeviceNet station
•
Provides quick connection to standard e-stop devices and safety relays
The information contained in this publication is general in nature and is for educational purposes. Each application is unique. It is the
responsibility of the user to ensure all-applicable jurisdictional codes and regulations are satisfied, and that installation and maintenance instructions are
followed.
F51
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Series E-connect
The series E-connect system provides quick, basic e-stop with a total of only seven different components and cabling.
The red cables, tees and mini connectors assemble quickly and can be maintained easily.
Its only difference from a standard pipe and wire solution is that it is connectorized.
It is still a true hard wired system; the pipe
Push Button
Push Button
and wire have simply been replaced with red
connectorized cable.
Safety Module
E-Stop
E-Stop
N.C.
Safety Circuit
N.C.
Safety Circuit
RSM RKM E40-*M
RSM 40 DJ 12/34
RSM RKM RKM 40 DESD
Series E-connect with Monitoring and Annunciation
The second system adds DeviceNet™ in order to
monitor where the e-stop occurred and provide an
output for local annunciation. The safety circuit is
still a true hard wired system; it is passing through
and uses an “E-connect” station as a connectorized
junction.
Push Button
Optional
Pilot Light
(BusActuated)
Push Button
Optional
Pilot Light
(BusActuated)
E-S top
E-S top
N.O.
(BusMonitored)
N.O.
(BusMonitored)
N.C.
Safety Circuit
N.C.
Safety Circuit
Safety Module
WSC E80-*M
RSC RKC E40-*M
PLC
RSM RKM 579-*M
FNDQ-ES22-T
Dedicated E-connect
This method offers easy connectorization for safety devices.
Each set of safety contacts in the e-stop device connects
to a single set of inputs on the safety relay. Two door safety switches
are connected by 4-wire cordsets to the VB2 “Y” junction and an 8wire cordset connects to two safety modules or a tandem module. All
circuits remain isolated.
Door Switch
N.O.
Held Closed
Saf ety Circuit
Safety Module
Safety Module
VB2 FSM E8/RKC RKC E40-*M-*M
RSC RKC E80-*M
F52
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-connect™, Cable Specifications
• Provides E-line Connection from
Safety Module to Field Device
Jacket
• Provides Drop to E-Stop Device
• Red PCV Jackets
Brown
Blue
Red
Orange
Figure A
E-line from safety module to field device
Jacket
Brown
Blue
Red
Orange
Black
White
WH/RD
WH/OR
Figure B
Drop cable to E-stop device
Power Pair
Type
E40
AWM 2517
105°C 300 Volts
E46
AWM 2517
105°C 300 Volts
E80
AWM 2517
105°C 300 Volts
Outer Jacket
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Bulk Cable Part
Number /
Weight/300 M
Figure
NEC PLTC/ITC/CL2
CEC AWM-I/II A/B FT4
4/18 AWG
BN/BU/RD/OR
6.5 Ohms
PVC
PVC Red
7.2 mm (.285 in)
RB50896-*M
58 lbs.
A
NEC PLTC/ITC/CL2
CEC AWM-I/II A/B FT4
4/16 AWG
BN/BU/RD/OR
4.3 Ohms
PVC
PVC Red
8.4 mm (.330 in)
RB50925-*M
81 lbs.
A
NEC CL2
CEC AWM-I/II A/B FT4
8/24
BN/BU/RD/OR/BK/WH/
WH, RD/WH, OR
27.7 Ohms
PVC
PVC Red
5.7 mm (.224 in)
RB50897-*M
36 lbs.
B
Approvals
* Indicates length in meters.
x Indicates cable type.
Standard cable lengths are 30, 75, 150, 225 and 300 meters. Consult factory for other lengths.
®
† See page A6 for flexlife and weldlife performance.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
F53
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
E-connect™, Cable/Cordset Selection Matrix
minifast ®
1
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
RSM Exx-*M
WSM Exx-*M
RKM Exx-*M
WKM Exx-*M
RSC Exx-*M
RSM RSM Exx-*M
RSM WSM Exx-*M
RSM RKM Exx-*M
RSM WKM Exx-*M
RSM RSC Exx-*M
WSM WSM Exx-*M
WSM RKM Exx-*M
WSM WKM Exx-*M
WSM RSC Exx-*M
RKM RKM Exx-*M
RKM WKM Exx-*M
RKM RSC Exx-*M
WKM WKM Exx-*M
WKM RSC Exx-*M
DeviceNet
Pin (Male)
eurofast ® (Thin/Mid Only)
Pin (Male)
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
Pin (Male)
RSC RSC Exx-*M
RSC
6
WSC
Socket (Female)
eurofast (Thin/Mid Only)
5
7
RKC
8
WKC
See pages F56 - F57 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
minifast
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
minifast
Male
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F54
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-connect™, Cable/Cordset Selection Matrix
Pin (Male)
eurofast ® (Thin/Mid Only)
Socket (Female)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead (Thin Only)
Pin (Male)
Socket (Female)
11
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC Exx-*M
RKC Exx-*M
WKC Exx-*M
RSFP Exx-*M
RKFP Exx-*M
FSFD Exx-*M
FKFD Exx-*M
RSM WSC Exx-*M
RSM RKC Exx-*M
RSM WKC Exx-*M
RSM RSFP Exx-*M
RSM RKFP Exx-*M
RSM FSFD Exx-*M
RSM FKFD Exx-*M
WSM WSC Exx-*M
WSM RKC Exx-*M
WSM WKC Exx-*M
WSM RSFP Exx-*M
WSM RKFP Exx-*M
WSM FSFD Exx-*M
WSM FKFD Exx-*M
RKM WSC Exx-*M
RKM RKC Exx-*M
RKM WKC Exx-*M
RKM RSFP Exx-*M
RKM RKFP Exx-*M
RKM FSFD Exx-*M
RKM FKFD Exx-*M
WKM WSC Exx-*M
WKM RKC Exx-*M
WKM WKC Exx-*M
WKM RSFP Exx-*M
WKM RKFP Exx-*M
WKM FSFD Exx-*M
WKM FKFD Exx-*M
RSC WSC Exx-*M
RSC RKC Exx-*M
RSC WKC Exx-*M
RSC RSFP Exx-*M
RSC RKFP Exx-*M
RSC FSFD Exx-*M
RSC FKFD Exx-*M
WSC WSC Exx-*M
WSC RKC Exx-*M
WSC WKC Exx-*M
WSC RSFP Exx-*M
WSC RKFP Exx-*M
WSC FSFD Exx-*M
WSC FKFD Exx-*M
RKC RKC Exx-*M
RKC WKC Exx-*M
RKC RSFP Exx-*M
RKC RKFP Exx-*M
RKC FSFD Exx-*M
RKC FKFD Exx-*M
WKC WKC Exx-*M
WKC RSFP Exx-*M
WKC RKFP Exx-*M
WKC FSFD Exx-*M
WKC FKFD Exx-*M
minifast
Female
F55
Pinouts
1. BN(+ AUX)
2. RD (E1L)
3. OR (E2L)
4. BU (- AUX)
minifast
eurofast
Male
Male
Pinouts
1. BK (IN)
2. WH (OUT)
3. BN (AUX+)
4. RD (SC1
5. WH/RD (SC1c)
6. OR (SC2)
7. WH/OR (SC2c)
8. BU (AUX-)
eurofast
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
E-connect™, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-40° to +105°C (-40° to +221°F)
DeviceNet
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
1
RSM ..
3
Pages F54 - F55
RKM ..
2
WSM ..
4
Pages F54 - F55
WKM ..
9
RSFP ..
Pages F54 - F55
Pages F54 - F55
10
Pages F54 - F55
RKFP ..
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
Pages F54 - F55
www.turck.com
F56
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-connect™, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +105°C (-40° to +221°F)
5
RSC ..
7
Pages F54 - F55
RKC ..
6
WSC ..
8
Pages F54 - F55
WKC ..
11
FSFD ..
F57
Pages F54 - F55
Pages F54 - F55
12
Pages F54 - F55
FKFD ..
Pages F54 - F55
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
E-connect™, Tee
• Provides Dual Interuptions to Auxiliary
Power
• (7/8-16 UN) minifast ® Connectors on Bus
Housing
See Figure 1
Part Number
RSM RKM RKM 40 DESD
Specs
TPU (Polyurethane)
250 V, 4 A
-30° to 75°C
Application
•
E & M Dual Stop Drop
Tee
•
Provides dual
interruption to auxiliary
power
•
Terminate with minifast
®
internal jumper
DeviceNet
& Drop Lines
Pinouts
Male
Female
Standard housing material is nickel plated brass. "RSM RKM.."; "RSV RKV.." indicates stainless steel housing.
1
Wiring Diagram
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F58
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-connect™, Terminating Resistor
• Male minifast ® Connector
• TPE (PUR) Overmold Body
Housing
Part Number
RSM 40 DJ 12/34
F59
Specs
Nickel Plated Brass
or Stainless Steel
300 V, 9 A
-40 to +75°C
IP 67
Application
•
minifast with
Dual Internal
Jumper
•
Internally
jumpered to
complete dual
•
E & M stop
circuits
Pinout
Male
Internal Jumper
#1 and #2
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
Internal Jumper
#3 and #4
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
E-connect™, eurofast ® Drop Junctions
• Creates a Drop or Branch from the Main
Bus Line
• Cable Drop Lengths Available Up to a
Housing
See Figure 1
Part Number
VB2 FSM E8/RKC RKC E40-*M-*M
Application
•
•
•
DeviceNet
Maximum of 6 Meters
Wiring Diagram
VB2 Junction with Trunk Line
Reduced power and data branch
Maximum six meter branch
* Indicates length in meters.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F60
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-Connect Stations
• Rugged, Fully Potted Stations
• IP 67, IP 68, IP 69K Protection
• Monitor E-Stop Switches with
DeviceNet
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <40 mA (from DeviceNet)
• Output Current: <500 mA per output (from Aux. Power)
Power Distribution
• Inputs: Auxiliary power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
FDNP-ES44-TC
FDNP-ES88-TC
FDNP-ES88-TT
Diagnostics (Logical)
• One bit in I/O table indicates status of Auxiliary Power Supply (APS)
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet communication
Aux. Power eurofast Pinout
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = SC1
3 = SC2
4 = VAUX-
Aux. Power minifast Pinout
Male
...-TC
Female
1 = VAUX+
2 = SC1
3 = SC2
4 = VAUX-
4-Pin
4-Pin
...-TT
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F61
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
FDNP-ES44-TC
4
0-1,
4-5
E8
1
E-Stop
4
0-1,
4-5
E8
1
0.5 A
2
FDNP-ES88-TC
8
0-7
E8
1
E-Stop
8
0-7
E8
1
0.5 A
1
FDNP-ES88-TT
8
0-7
E8
1
E-Stop
8
0-7
E8
1
0.5 A
1
DeviceNet
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Outputs
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
nne
Co
Part Number
Inp
ut C
oun
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
t
Inputs
Input/Output Connectors
E8
1 = In
2 = Out
3 = AUX+
4 = SC1
5 = SC1C
6 = SC2
7 = SC2C
8 = AUXMating cordset:
RSC RKC E80-*M
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
In
1
APS
-
-
-
-
-
-
-
Out
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
APS
-
-
-
I-3
I-2
I-1
I-0
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F62
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
E-Connect Stations
• Rugged, Fully Potted Stations
• Monitor E-Stop Switches with DeviceNet
• IP 67, IP 68, IP 69K Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <50 mA (from DeviceNet)
• Output Current: <500 mA per output (from Auxiliary power supply)
Power Distribution
• Inputs: Auxiliary power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 1,3,4,12,13 / IEC IP 67, IP 68, IP 69K
• Vibration: 50 g @ 10-500 Hz
FDNQ-ES11-T
FDNQ-ES22-T
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Logical)
• One bit in I/O table indicates status of Auxiliary Power Supply (APS)
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet communication
Aux. Power eurofast Pinout
Male
Female
4-Pin
4-Pin
1 = VAUX+
2 = SC1
3 = SC2
4 = VAUX-
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
F63
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
Data
FDNQ-ES11-T
1
0
E8
1
E-Stop
1
0
E8
1
0.5 A
1
FDNQ-ES22-T
2
0, 2
E8
1
E-Stop
2
0, 2
E8
1
0.5 A
2
Part Number
DeviceNet
Co
nne
Outputs
Inp
ut C
oun
t
Inputs
Input/Output Connectors
E8
1 = In
2 = Out
3 = AUX+
4 = SC1
5 = SC1C
6 = SC2
7 = SC2C
8 = AUX-
Mating cordset:
RSC RKC E80-*M
I/O Data Map 1
In
Out
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
APS
-
-
-
-
-
-
I-0
In
0
-
-
-
-
-
-
-
O-0
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
APS
-
-
-
-
-
I-1
I-0
0
-
-
-
-
-
-
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F64
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet Master
• Used to Manage a Sub-Network
• Manages 8-nodes on Sub-Network
Electrical
• Bus Power: 11-30 VDC
• Current Consumption:
125 mA (Slave), 30 mA (Master)
LED Indication
• Slave Network Status:
• Master Network Status:
Flashing Green: Ready for connection
Green: Established connection
Flashing Red: Connection time out
Flashing Green: Ready for connection
Green: Connected to all stations
Flashing Red: Time out with one or more stations
Red: Connection not possible
Adjustments
FDN-MSTR-1220
• Slave Side (Network address): 0-63 via rotary switches
• Master Side (Node count): 0-8 via rotary switches
• Master Baud Rage (5,6,7): 5=125 K, 6=250 K, 7=500 K
Connections
• Bus Line:
5-pin minifast ® connectors
Housing
• Material: Glass filled nylon with nickel plated brass connectors
• Enclosure: NEMA 1,3,4,12,12 and IEC IP 67, 68 and 69K
• Operating Temperature: -25° to 70° C (-13° to 158° F)
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
Note: each segment has one male and one female connector
F65
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
The FDN-MSTR is a DeviceNet™ master used to manage a subnet off of the main DeviceNet network.
Main DeviceNet Network
Slave
(Side A)
DeviceNet
The subnet to the FDN-MSTR is a DeviceNet network terminated on
both ends and is limited to 8 nodes with addresses that must be in
sequential order from 1 to 8. The baud rate for this network is
determined by the rotary switch setting on the FDN-MSTR.
Master
(Side B)
DeviceNet SubNetwork
Node 1
Node 2
Node 3
Node 4
Node 5
Node 6
Node 7
Node 8
The subnet to the FDN-MSTR is a DeviceNet network terminated on both ends and is limited
to 8 nodes with addresses that must be in sequential order from 1 to 8. The baud rate for this
network is determined by the rotary switch setting on the FDN-MSTR.
The slaves on the subnet are independent of the main DeviceNet network. Hence a node 4 on the main network will
conflict with a node 4 on the sub network.
I/O Data Map 1
The Input data size is 64 bytes (where the first two bytes are reserved for status information from the FDN-MSTR).
Byte Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10
In
Bit 9
Bit 8
Bit 7
Bit 6
Bit 5
Bit 4
Bit 3
Bit 2
Bit 1
0
-
-
-
-
-
-
-
-
-
-
-
-
-
-
IC
-
1
ESN 8
ESN 7
ESN 6
ESN 5
ESN 4
ESN 3
ESN 2
ESN 1
RSN 8
RSN 7
RSN 6
RSN 5
RSN 4
RSN 3
RSN 2
RSN 1
Bit 5
Bit 4
Bit 3
Bit 2
Bit 1
Bit 0
2
Node Address 1 Input Data
3
Node Address 2 Input Data
…
…
N
Node Address X Input Data
Bit 0
The Output data is 64 bytes.
Byte Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10
Out
Bit 9
Bit 8
Bit 7
Bit 6
0
Node Address 1 Output Data
1
Node Address 2 Output Data
2
Node Address 3 Output Data
…
…
N
Node Address X Output Data
IC = Invalid configuration of node missing: 0 means OK, 1 means error.
ESNX = Error on sub node X: 0 means OK, 1 means error communicating with node.
RSNX = Registered sub node X: 0 means no node is present, 1 means that node is present.
The data table for the Input and Output show the last Byte as "N". This "N" is variable depending on the total amount of data generated
by all the nodes on the deviceNet™ sub network. However the maximum for both the Input and the Ouptut are 64 bytes.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F66
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet Repeater
• Extend Network Length
• Isolate Power Segments
• Extend Drop Lengths
• Isolate Communication Segments
Electrical
• Operating Current: 125 mA from segment A, 30 mA from segment B
Power Distribution
• REP-DN: DeviceNet power supply for each segment (must be powered
by separate supplies)
• REP-DN-Drop: Does not require a separate power supply and does not
isolate power between segments
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 and IEC IP 67
• Vibration: 50 g @ 10-500 Hz
Material
REP-DN
REP-DN-DROP
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
Diagnostics (Physical)
• One LED for each segment to indicate communication status
DeviceNet minifast Pinout
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
Note: each segment has one male and one female connector
F67
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ Repeater
A repeater does not consume an address and is invisible to all the other devices on the network. A repeater does not have
an EDS file. The REP-DN repeater can be used to extend either the trunk or drop lines, and to isolate power supplies on
networks with multiple supplies. There is no limit to the number of repeaters that can be used on one network.
A repeater's baudrate is set via a rotary switch. The baudrate on each side of the repeater must be the same, as different
rates would cause the "slow" side to be overloaded with messages from the "fast" side. When a message is repeated, a 2 ms
delay is introduced. This is typically insignificant compared to the overall scan time of the network. If more than four
repeaters are used in series, the interscan delay may need to be increased.
DeviceNet
The REP-DN is a potted, fully connectorized rugged repeater that can be mounted directly on the machine. It is designed
for use on any Controller Area Network (CAN), including DeviceNet. Network segments connected by a repeater are
considered separate physical networks (trunk and drop lengths for each segment are determined as if the other segments are
not there), but one logical network (addresses cannot be duplicated - the scanner and configuration tools work as a single
network).
500 M (125 k)
Repeater Configurations
Network Segment B
Extended Trunk Line
RSM 57 TR2
To terminate left side of network B
Repeaters are connected in series to
extend the trunk line. The total delay is 2
ms multiplied by the number of repeaters.
* REP-DN-DROP does not require a
separate power supply on segment B. If a
separate power supply is desired, it must
be attached using a "Power T" (RSM RKM
57 WSM 40 PST recommended).
RSM 57 TR2
To terminate left side of network A
Network Segment A
500 M (125 k)
Extended Drop Line
Repeaters are connected in
parallel to extend the drop length.
The overall network delay is 2 ms,
because there is only one
repeater between the scanner on
the trunk and any other device.
500 M
(125 k)
500 M
(125 k)
RSM 57 TR2
To terminate drop C
RSM 57 TR2
To terminate drop B
Network A passes
through repeater
Do Not Create a Ring
500 M (125 k)
While a repeater can be used to create very large and complex networks, some configurations are not permitted. If a ring is
created (both sides of a repeater are connected to the same network), the repeater will continuously repeat to itself, causing
the network to overload.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F68
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet Spanner
• Rugged, Fully Potted Stations
• Communicate Between PLCs
• IP 67 Protection
• Connect Two DeviceNet Networks
Electrical
• Operating Current: 125 mA from segment A, 30 mA from segment B
Power Distribution
• Station: DeviceNet power supply for each segment (must be powered by
separate supplies)
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: NEMA 1,3,4,12,13 and IEC IP 67
• Vibration: 50 g @ 10-500 Hz
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Nylon 6 (other materials available on request)
FDN-DN1
Diagnostics (Physical)
• One LED for each segment to indicate communication status
DeviceNet minifast Pinouts
Male
Female
5-Pin
5-Pin
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
Note: Each segment has one male and one female connector.
F69
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ Spanner
Theory of operation
The spanner transfers data between PLC A and PLC B by appearing as I/O to each PLC. The spanner immediately copies
the output data from PLC A to the input data for PLC B. Similarly, PLC B’s output data is copied to PLC A’s input data. The
size of data transferred is set by the transfer size switch. If the transfer size switch is set at 4,16, 32 or 128 bytes, then the
size of the data transferred is the same in both directions. If the transfer size switch is set to software, then the transfer size is
set via software and it can be any size (0,1,2,3...128 bytes). When in software mode, the data size mapped to the PLC must
be equal in opposite directions on either side of the spanner. For example, if side A produces 2 input bytes and consumes
12 output bytes, then side B must be set to produce 12 input bytes and consume 2 output bytes.
DeviceNet
The FDN-DN1 “Spanner” module provides a means to route data between two PLC’s using DeviceNet. The spanner
eliminates the need for a high level control network pyramid, by connecting the DeviceNet networks directly. This simple
approach is extremely powerful and economical. It is simple because the spanner appears to each PLC as a standard rack of
I/O; any DeviceNet scanner can send I/O data to the spanner without additional software or complex configuration
procedures. It is powerful because it can transfer up to 128 bytes of data in one message. It is economical because it
replaces the high level control network, eliminating two control cards, wiring, conduit and programming.
Electrically
The spanner optically isolates network A from network B; the networks do not interact electrically in any way. The spanner
is powered internally by network A; a power reset on the A side will reset the entire station.
Addressing
Because the spanner is essentially two DeviceNet devices, one on network A and one on network B, it has two sets of
address switches. The address switches for network A are completely independent of network B.
Baudrate
The spanner automatically detects the Baudrate at startup. Network A and B may be at different baudrates.
Spanner Topology
The spanner is typically used to correct and coordinate multiple work cells.
Conveyor
PLC
To other stations on conveyor
To other stations on work cell A
Cell A
PLC
To other stations on work cell B
Cell B
PLC
Work Cell A Network
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
Work Cell A Network
www.turck.com
F70
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet FDN20 Stations
TURCK's FDN20 DeviceNet stations are low-cost screw-terminal connection stations designed for mounting in an enclosure.
These stations allow you to easily connect standard I/O devices such as push buttons, pilot lights, motor starters and drives to
a DeviceNet network. The FDN20 station is designed to easily upgrade existing equipment to a DeviceNet network.
Specifications
TURCK FDN20 stations are designed to be mounted in standard equipment enclosures (operator stations, motor control
centers, etc.). Most FDN20 stations use only screw terminal connections for all I/O and network wiring. FDN20-4S-4XSG-E
has a DeviceNet eurofast ® (M12) connector on the back of the housing that enables mounting the station to an enclosure
wall with the (DeviceNet) connection on the outside of the box; greatly simplifying network wiring. Detailed environmental
specifications are as follows:
• Housing material: Glass filled nylon
• Protection level: IP 20
• Operating temperature: -40 to +70°C (-40 to +158°F)
The station's components are identified in the figure below.
Rotary Address Switches
DeviceNet eurofast
M12x1 Connector
Compact, Low Profile
I/O Screw Terminals
4 Dedicated Inputs +
4 Inputs or Outputs
Connectors
Bus connectors:
FDN20 screw terminal and eurofast bus connectors pinouts:
DeviceNet Pinout
Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
I/O connectors:
5-Pin
Each FDN20 version uses a different screw terminal connector. Detailed pinout information is given in the product
information on the following pages.
F71
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Power
The short FDN20 stations provide all the power to the I/O devices from the DeviceNet™ power supply. In this case there is
no auxiliary power connection.
DeviceNet
The remaining long FDN20 stations (FDN20-16XSG, for example) provide an auxiliary power connection. I/O devices can
be powered from the DeviceNet or auxiliary power supply, depending on how the user chooses to wire the station. The
different wiring options are illustrated in the following diagram.
Power ratings for FDN20 stations:
•
•
•
•
•
•
•
•
Bus (DeviceNet) Voltage: 11-26 VDC
Aux Power Voltage: 24 VDC (nominal)
Internal Current Consumption: <75 mA (@ nominal 24 VDC) plus sum of I/O currents if auxiliary power is not used
Input Voltage: 13-26 VDC (From DeviceNet supply)
Input Short-Circuit Current: <700 mA (total for entire station)
Input Signal Current (each input): OFF <2 mA; ON 3.0-3.4 mA (@ nominal 24 VDC)
Input Delay: 2.5 ms
Output Current: 0.5 A max per output
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F72
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Addressing
DeviceNet stations must have a network address for communication. The address for FDN20 stations may be set via the
visible rotary switches on the front of the station.
Address = 6x10 + 3x1 = 63
The pair of switches represents the address as a decimal number; the left switch being the 10's multiplier and the right
switch the 1's multiplier. To program the stations, rotate the switches with a small slotted screwdriver until the arrows are
pointing at the appropriate numbers for the chosen address.
Diagnostics
FDN20 stations provide a single Network Status LED for diagnosing communication problems.
•
•
•
•
•
Green: Connection established
Flashing green: Waiting for connection
Flashing red: Connection timed out
Red: Cannot connect
Flashing Amber: Finding baud rate (autobaud setting)
The long housing stations (i.e. FDN20-16XSG) have an additional LED for each I/O point on the station indicating:
• Off: Point is off
• Green: Point is on
Additionally, most FDN20 stations provide diagnostic bits in the I/O table for diagnostics. One bit indicates a short-circuit
fault for outputs or inputs. See product pages in this catalog for detailed I/O information.
F73
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet
Notes:
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F74
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Enclosure Mounted
Input/Output Stations
• In-Cabinet I/O
• Ideal for Retrofits
• IP 20 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current:
<75 mA (from DeviceNet) plus I/O currents (from bus
power)
• Input Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
FDN20-4S-4XSG
FDN20-4S-4XSG-E*
FDN20-4S-4XSG-DIN*
* Not UL
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: IEC IP 20
Material
• Connectors: Nickel-plated brass (eurofast option only)
• Housing: Nylon
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a fault
for all inputs and one bit indicates a fault for all outputs
Diagnostics (Physical)
• LED to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
FDN20-4S-4XSG-E only
DeviceNet Connector
FDN20-4S-4XSG-E shown
Note: A DIN rail mounting bracket (FDN20-BKT-DIN) may be purchased
separately for use with the FDN20-4S-4XSG.
F75
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
FDN20-4S-4XSG
8
FS
PNP
X
4
FS
0.5 A
1
FDN20-4S-4XSG-E
8
FS
PNP
X
4
FS
0.5 A
1
FDN20-4S-4XSG-DIN
8
FS
PNP
X
4
FS
0.5 A
1
DeviceNet
Da
ta M
ap
Data
Wi
reDe Break
tec
tion
Ind
ivid
ual
nt
Cu
rre
Pin
out
Wi
reDe Break
tec
tion
Ou
tp
Co ut
unt
Gro
up
Sty
sor
Sen
Pin
out
Ind
ivid
ual
t
oun
ut C
Inp
Part Number
Outputs
le
Inputs
Input/Output Connectors
FS
*Note: I/O0 to I/O3 can be used as inputs or outputs
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
1
IGS
OGS
-
-
-
-
-
I-0
-
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F76
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Enclosure Mounted
Input/Output Station
• In-Cabinet I/O
• Ideal for Retrofits
• IP 20 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus I/O currents (from bus power)
• Input Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
FDN20-4S-4XSG-0189
FDN20-S0404G-0220*
* Not CE
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: IEC IP 20
Material
• Housing: Nylon
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for all inputs and one bit indicates a fault for all outputs
Diagnostics (Physical)
• LED to indicate status of DeviceNet communication
DeviceNet Connector
F77
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Da
ta M
ap
Wi
reDe Break
tec
tion
Data
Ind
ivid
ual
nt
rre
Cu
Pin
out
up
Gro
Wi
reDe Break
tec
tion
Ou
tp
Co ut
unt
Sty
sor
Sen
Pin
out
Ind
ivid
ual
t
oun
ut C
Inp
Part Number
Outputs
le
Inputs
8
FS
PNP
X
4
FS
0.5A
1
FDN20-S0404G-0220
4
FS-2
PNP
X
4
FS-2
0.5 A
2
DeviceNet
FDN20-4S-4XSG-0189
Input/Output Connectors
FS-2
FS
*Note: I/O0 to I/O3 can be used as inputs or outputs
I/O Data Map 2
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
OGS
-
-
-
-
-
-
0
-
-
-
-
O-3
O-2
O-1
O-0
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
OGS
-
-
I-3
I-2
I-1
I-0
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F78
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Enclosure Mounted
Input/Output Stations
• In-Cabinet I/O
• Ideal for Retrofits
• IP 20 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus applicable I/O currents (from bus power)
• Input Current: <700 mA sum of all inputs
• Output Current: <500 mA per output
Power Distribution
• Inputs: Optionally DeviceNet or Auxiliary power supply as shown in
wiring diagram
• Outputs: Optionally DeviceNet or Auxiliary power supply as shown in
wiring diagram
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: IEC IP 20
Material
FDN20-16XSG
FDN20-16S
• Housing: Nylon
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for all inputs, on bit indicates a fault for all outputs
Diagnostics (Physical)
DIV 2
• LED to indicate status of DeviceNet communication
DeviceNet Connector
F79
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
16
FLX
PNP
X
16
FDN20-16S
16
FL
PNP
X
0
FLX
0.5 A
Da
ta M
ap
Wi
reDe Break
tec
tion
Cu
rre
nt
Ind
ivid
ual
Data
1
2
DeviceNet
FDN20-16XSG
Pin
out
up
Gro
Wi
reDe Break
tec
tion
Ou
tp
Co ut
unt
Sty
sor
Sen
Pin
out
Ind
ivid
ual
t
oun
ut C
Inp
Part Number
Outputs
le
Inputs
Input/Output Connectors
FL
FLX
Indicates I/O groups which can be powered from separate Aux. Power supplies if desired.
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
IGS
OGS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
1
O-15
O-14
O-13
O-12
O-11
O-10
O-9
O-8
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
IGS
OGS
-
-
-
-
-
-
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F80
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Enclosure Mounted
Input/Output Stations
• In-Cabinet I/O
• Ideal for Retrofits
• IP 20 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus applicable I/O currents (from bus power)
• Input Current: <700 mA sum of all inputs
• Output Current: 1.8 A per output
Power Distribution
• Inputs: Optionally DeviceNet or Auxiliary power supply as shown in
wiring diagram
• Outputs: Optionally DeviceNet or Auxiliary power supply as shown in
wiring diagram
FDN20-16SN-16XSG
FDN20-32SN
DIV 2
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: IEC IP 20
Material
• Housing: Nylon
Diagnostics (Logical)
• Open/short-circuit status mapped to DeviceNet I/O table, one bit indicates a
fault for all inputs, on bit indicates a fault for all outputs
Diagnostics (Physical)
• LED to indicate status of DeviceNet communication
DeviceNet Connector
F81
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
1
NPN/PNP
X
FDN20-32SN
32
1
NPN/PNP
X
16*
2
1.8 A
Da
ta M
ap
Wi
reDe Break
tec
tion
Data
Ind
ivid
ual
nt
rre
Cu
Pin
out
up
Gro
32*
Wi
reDe Break
tec
tion
Ou
tp
Co ut
unt
Sty
sor
Sen
Pin
out
FDN20-16SN-16XSG
Ind
ivid
ual
t
oun
ut C
Inp
Part Number
Outputs
le
Inputs
1
2
DeviceNet
* 16 dedicated inputs and 16 points which can be used as inputs or outputs.
1
2
I/O Data Map 1
I/O Data Map 2
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
1
I-15
I-14
I-13
I-12
I-11
I-10
I-9
I-8
2
I-23
I-22
I-21
I-20
I-19
I-18
I-17
I-16
2
I-23
I-22
I-21
I-20
I-19
I-18
I-17
I-16
3
I-31
I-30
I-29
I-28
I-27
I-26
I-25
I-24
3
I-31
I-30
I-29
I-28
I-27
I-26
I-25
I-24
4
IGS
OGS
-
-
-
-
-
-
4
IGS
OGS
-
-
-
-
-
-
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
1
O-15
O-14
O-13
O-12
O-11
O-10
O-9
O-8
In
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
I-0
F82
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Enclosure Mounted
Input/Output Stations
• In-Cabinet I/O
• Ideal for Retrofits
• IP 20 Protection
• Automatic Baud Rate Sensing
Electrical
• Bus Power: 11-26 VDC
• Internal Current Consumption: ≤75 mA plus sum of sensor and output
currents (from bus power)
Input Circuits: (4) Negetive switched dry contacts
• Input Voltage (V+): 0-26 VDC
• Input Signal Current (Input): OFF>3 V, <0.5 mA
ON 0-1 V, 2-3 mA
• Input Delay: 1 ms
Output Circuits: (12) Solid state relays
• Output Voltage: 0-26 VDC
• Output Load Current: 120 mA (max.)
Output Circuits (Analog): (4) 0-10 V
FDN20-4DR
DIV 2
• Output Voltage 0-10 V
• Representation
16-bit signed integer
• Analog Supply Voltage
10-24 V
Network Status LED
• Status:
Green: Established connection
Flashing Green: Ready for connection
Red: Connection not possible
Flashing Amber: autobaud/125k/250k/500k
Adjustments
• Slave Side (Network address): 0-63 via rotary switches
• Master Side (Node count): 0-8 via rotary switches
• Master Baud Rage (5,6,7): 5=125 K, 6=250 K, 7=500 K
I/O Status LED
• OFF = off
• Green = On
Housing
• Material: Nylon
• Operating Temperature: -40° to 70° C (-40° to 158° F)
DeviceNet Connector
F83
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
12
1
4
Da
ta M
ap
Wi
reDe Break
tec
tion
Ind
ivid
ual
Ana
lo
Ou g
tpu
ts
Data
1
DeviceNet
X
Pin
out
up
Gro
Sinking
Dry Contacts
Wi
reDe Break
tec
tion
Dis
c
Rel rete
ay
Ou
tp
Co ut
unt
Sty
sor
1
Sen
Pin
out
4
Ind
ivid
ual
t
oun
ut C
FDN20-4DR
Inp
Part Number
Outputs
le
Inputs
Input/Output Connectors
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
-
-
-
-
-
-
I-1
I-0
1
-
-
-
-
-
-
I-3
I-2
0
-
-
O-5
O-4
O-3
O-2
O-1
O-0
1
-
-
O-11
O-10
O-9
O-8
O-7
O-6
2
A0 Low Byte
3
A0 High Byte
4
A1 Low Byte
5
A1 High Byte
6
A2 Low Byte
7
A2 High Byte
8
A3 Low Byte
9
A3 High Byte
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F84
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
DeviceNet™ piconet Stations
TURCK’s piconet DeviceNet stations are compact rugged stations designed for machine mounting. These stations allow
easy connection of standard I/O devices such as sensors, limit switches, valves and pilot lights to a DeviceNet network,
typically without a protective enclosure. This is made possible by epoxy-filled station housings, all-metal connectors and
visible rotary address switches, among other things.
piconet‘s small size sets them apart from other stations. piconet stations are the smallest rugged I/O modules available, with
a standard housing footprint of 30 x 175 mm. They are also available with picofast ® (M8) connectors for I/O, making them
ideally suited for small-space applications.
Mechanical Specifications
TURCK DeviceNet piconet stations are designed to be mounted directly on machines and work cells with no separate
enclosure or housing necessary. Epoxy-filled housing creates a durable station that allows it to be mounted in most
industrial environments. Detailed environmental specifications include:
•
•
•
•
Housing material: Glass filled nylon
Connector material: Nickel-plated brass
Protection level: NEMA 1,3,4,12,13; IEC IP 67
Operating temperature: 0 to 55°C
The station’s components are identified in the figure below.
DeviceNet Connector
Address Switches
Diagnostic LEDs
I/O Connectors
Power Connectors
F85
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Connectors
DeviceNet™ piconet ® stations provide connectors for bus and I/O power. Unlike other TURCK DeviceNet stations,
piconet stations power all I/O from auxiliary power.
Bus connector
DeviceNet
DeviceNet eurofast Pinouts
Male
1 = Shield/Drain
2 = V+ (24 VDC)
3 = V- (0 VDC)
4 = CAN High
5 = CAN Low
5-Pin
picofast ® I/O connectors
piconet stations with discrete I/O are available with picofast (M8) connectors. See the individual product pages in this
catalog for detailed pinouts.
eurofast I/O connectors
piconet stations with analog and special function I/O are available with eurofast (M12), and in some cases M23, connectors.
See the individual product pages in this catalog for detailed pinouts.
Auxiliary Power Connectors
piconet stations have two 4-pin picofast auxiliary power connectors, one male and one female, that allow the stations to be
“daisy-chained” from one power supply to another without using a T-connector. Two power supplies are connected
through the auxiliary supply; one for the station electronics and inputs and one for outputs.
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
Stations may be available with different connector options than the standards mentioned here. Consult your local sales
representative for different connector options.
Power
Common power specifications for piconet stations:
•
•
•
•
Bus (DeviceNet) Voltage: 11-26 VDC
Aux Power Voltage: 24 VDC (nominal)
Input Voltage: (From Auxiliary supply, UB)
Output Voltage: From Auxiliary supply, UL
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F86
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Addressing
DeviceNet stations must have a network address for communication. The address for piconet stations may be set via the
visible rotary switches under the clear plastic cover on the front of the station.
Address = 6x10 + 3x1 = 63
The pair of switches represents the address as a decimal number; the left switch being the 10’s multiplier and the right
switch the 1’s multiplier. To program the station, rotate the switches with a small slotted screwdriver until the arrows point
to the appropriate numbers for the chosen address.
Diagnostics
piconet DeviceNet stations provide two LEDs for diagnosing communication problems.
Module Status
• Green: Working properly
• Flashing green: Detecting baud rate
• Flashing red: Input short-circuit
Network Status
•
•
•
•
Green: Connection established
Flashing green: Waiting for connection
Flashing red: Connection timed out
Red: Cannot connect
There is an additional LED for each input on the station. This LED indicates:
• Off: Input is off
• Green: Input is on
There is also an LED to indicate the status of the two auxiliary power supplies.
• Off: Power is missing
• On: Power is present
F87
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
TURCK’s USA website is your most complete and up-to-date source for product documentation,
CAD files and more. Search results produce downloadable documentation or request for quote
(RFQ). Additional product information or CAD files are easily requested and promptly filled.
DeviceNet
Visit our site for new product releases, approvals, white papers, application support and more.
Access to all TURCK catalogs, press
releases, white papers and tutorials
Complete category listing
of TURCK products
Search for products
by part number, ID
number or key word
Access to CAD, wiring
and pinout diagrams
Download or e-mail
files, request for quote
Option to
e-mail pages
Contact a
TURCK representative
www.turck.com
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F88
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Input Station
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
• Sensor Current: <500 mA total of all sensors (from UB)
Power Distribution
• Inputs: UB Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IP 67
• Vibration: IEC 68, part 2-6
Material
SDNB-0800D-0008
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F89
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
8
PI
1
PNP
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
le
Sen
sor
Sty
Inp
u
C o ts per
nne
cto
r
Pin
out
nne
0-7
Data
Map
1
DeviceNet
SDNB-0800D-0008
Co
Part Number
Inp
ut C
cto
oun
rs
t
Inputs
Input Connectors
PI
Mating cordset:
PSG 3M-*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IS-7
IS-6
IS-5
IS-4
IS-3
IS-2
IS-1
IS-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F90
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Input/Output Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
• Sensor Current: <500 mA total of all sensors (from UB)
• Output Current: <500 mA per output (from UL)
Power Distribution
• Inputs: UB Power supply
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
SDNB-0808D-0001
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F91
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
8
PIO
1
8
0-7
PIO
1
0.5 A
I/O
Ma
p
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
sor
Sen
PNP
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
le
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tpu
t
Co
nne
cto
rs
Pin
out
Sty
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
cto
nne
0-7
Outputs
1
DeviceNet
SDNB-0808D-0001
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
PIO
Mating cordset:
PSG 4M-*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IS-7
IS-6
IS-5
IS-4
IS-3
IS-2
IS-1
IS-0
2
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
OS-0
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F92
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Output Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA (from UB)
• Output Current: See table on facing page (from UL)
Power Distribution
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
SDNB-0008D-0006
SDNB-0008D-0002
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
®
picofast Male
picofast ® Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F93
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
nt
Data
Cu
rre
Ou
tp
C o uts p
n n e er
cto
r
Co
Pin
out
nne
Ou
tp
Co ut
unt
Part Number
cto
rs
Outputs
SDNB-0008D-0006
8
0-7
PO
1
0.5 A
1
SDNB-0008D-0002
8
0-7
PO
1
2 A*
1
DeviceNet
*Note: Total output current for the station is limited to 4 A.
Output Connectors
PO
Mating cordset:
PSG 3M-*
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
OS-7
OS-6
OS-5
OS-4
OS-3
OS-2
OS-1
OS-0
0
O-7
O-6
O-5
O-4
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F94
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Input/Output Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
• Sensor Current: <500 mA total of all sensors (from UB)
• Output Current: See table on facing page (from UL)
Power Distribution
• Inputs: UB Power supply
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
SDNB-0404D-0005
SDNB-0404D-0001
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F95
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Data
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Cu
rre
nt
Sty
le
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tpu
t
Co
nne
cto
rs
Pin
out
Ou
tp
C o uts p
n n e er
cto
r
Outputs
sor
Sen
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
cto
nne
Co
Part Number
Inp
ut C
oun
t
Inputs
SDNB-0404D-0005
4
0-3
PI
1
PNP
4
4-7
PO
1
2 A*
1
SDNB-0404D-0001
4
0-3
PI
1
PNP
4
4-7
PO
1
0.5 A
1
DeviceNet
*Note: Total output current for the station is limited to 4 A.
Input/Output Connectors
PI
PO
Mating cordset:
PSG 3M-*
Mating cordset:
PSG 3M-*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
IS-3
IS-2
IS-1
IS-0
I-3
I-2
I-1
I-0
1
-
-
-
-
OS-3
OS-2
OS-1
OS-0
0
-
-
-
-
O-3
O-2
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F96
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Analog Input Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
Power Distribution
• Inputs: UB Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
SDNB-40A-0005
SDNB-40A-0007
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = GndB
4 = GndL
F97
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Data
Gro
u
Dia p
gno
stic
s
le
Sen
sor
Sty
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
4
0-3
AI
1
-10/0 to 10 V
1
SDNB-40A-0007
4
0-3
AI
1
0 to 20 mA
1
DeviceNet
SDNB-40A-0005
Input/Output Connectors
AI
Mating cordset:
Isolated Loop:
RK 4.5T-*M-RS 4.5T/S653
Loop Powered:
RK 4.5T-*M-RS 4.5T/LPS/S653
Note: The "LPS" in the part number indicates that the cord
jumpers pin 3 to pin 4 on the male side to the signal- to the station
common. Pin 3 is not connected at the female end.
Applications:
TURCK Sensors:
LU; RK 4.4T-*-RS 4.4T/S1118
LI; RK 4.4T-*-*RS 4.4T/S1120
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Channel 0, MSB
1
Channel 0, LSB
2
Channel 1, MSB
3
Channel 1, LSB
4
Channel 2, MSB
5
Channel 2, LSB
6
Channel 3, MSB
7
8
Channel 3, LSB
-
-
-
-
AIS-3 AIS-2 AIS-1 AIS-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F98
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Temperature Input Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
Power Distribution
• Inputs: UB Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
SDNB-40A-0004
SDNB-40A-0009
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = GndB
4 = GndL
F99
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Data
Gro
u
Dia p
gno
stic
s
le
Sen
sor
Sty
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
4
0-3
TC
1
TC
1
SDNB-40A-0009
4
0-3
RTD
1
RTD
1
DeviceNet
SDNB-40A-0004
Input/Output Connectors
TC
RTD
Mating connector (field wireable):
WAS5-THERMO
Mating cordset:
RK 4.5T-*-RS 4.5T
(includes cold junction compensation)
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Channel 0, MSB
1
Channel 0, LSB
2
Channel 1, MSB
3
Channel 1, LSB
4
Channel 2, MSB
5
Channel 2, LSB
6
Channel 3, MSB
7
8
Channel 3, LSB
-
-
-
-
AIS-3 AIS-2 AIS-1 AIS-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F100
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Analog Output Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA (from UB)
Power Distribution
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
SDNB-04A-0009
SDNB-04A-0007
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = GndB
4 = GndL
F101
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Pin
out
Co
Ind
iv
Dia idual
gno
stic
s
Ou
tp
C o uts p
n n e er
cto
r
rs
cto
nne
Ou
tp
Co ut
unt
Part Number
Data
Ou
tpu
t St
yle
Outputs
4
0-3
AOI
1
0 to 20 mA
1
SDNB-04A-0007
4
0-3
AOV
1
-10/0 to 10 V
1
DeviceNet
SDNB-04A-0009
Output Connectors
AOV
AOI
Mating cordset:
RK 4.5T-*-RS 4.5T
Mating cordset:
RK 4.5T-*-RS 4.5T
Applications:
TURCK Sensors:
LU; RK 4.4T-*-RS 4.4T/S1118
LI; RK 4.4T-*-*RS 4.4T/S1120
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
-
-
-
-
AOS-3 AOS-2 AOS-1 AOS-0
0
Channel 0, MSB
1
Channel 0, LSB
2
Channel 1, MSB
3
Channel 1, LSB
4
Channel 2, MSB
5
Channel 2, LSB
6
Channel 3, MSB
7
Channel 3, LSB
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F102
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Counter Station
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
•
•
•
•
Operating Current: <75 mA plus device currents (from UB)
Input Current: <500 mA total of all sensors (from UB)
Output Current: <500 mA per output (from UL)
Frequency: 100 KHz
Power Distribution
• Inputs: UB Power supply
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
SDNB-0202D-0003
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = GndB
4 = GndL
F103
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
2
2
Counter
2
0-3 PCNT
2
0.5 A
Data
I/O
Ma
p
Ind
iv
Dia idual
gno
stic
s
Wi
reB
r
De
tec eak
tion
nt
Cu
rre
Ou
tp
C o uts p
n n e er
cto
r
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reB
r
De
tec eak
tion
Ou
tp
Co ut
unt
Co
unt
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
cto
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
nne
0-3 PCNT
Outputs
1
DeviceNet
SDNB-0202D-0003
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
PCNT
Mating cordset:
RK 4.5T-*-RS 4.5T
Mating cordset:
RK 4.5T-*-RS 4.5T
Mating cordset:
RK 4.5T-*-RS 4.5T
I/O Data Map 1
Mating cordset:
RK 4.5T-*-RS 4.5T
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
Channel 0 - Status
1
Channel 0, Byte 0
2
Channel 0, Byte 1
3
Channel 0, Byte 2
4
Channel 0, Byte 3
5
Channel 1 - Status
6
Channel 1, Byte 0
7
Channel 1, Byte 1
8
Channel 1, Byte 2
9
Channel 1, Byte 3
10
Res.
0
Channel 0 - Control
1
Channel 0, Byte 0
2
Channel 0, Byte 1
3
Channel 0, Byte 2
4
Channel 0, Byte 3
5
Channel 1 - Control
6
Channel 1, Byte 0
7
Channel 1, Byte 1
8
Channel 1, Byte 2
9
Channel 1, Byte 3
C2-S
C1-S
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F104
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Incremental Encoder
Station
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus device currents (from UB)
Power Distribution
• Inputs: UB Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
SDNB-10S-0001
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F105
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
0-1
ENC
1
Encoder
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Gro
u
Dia p
gno
stic
s
le
Sen
sor
Sty
Inp
u
C o ts per
nne
cto
r
Pin
out
Co
1
Data
1
DeviceNet
SDNB-10S-0001
Inp
Part Number
nne
ut C
cto
oun
rs
t
Inputs
Input/Output Connectors
ENC
1 = V+
2 = Gate
3 = Gnd
4 = Latch
5 = Shield
1=B
2 = +5 VDC
3 = Zero
4 = Zero
5=A
6=A
7 = Status
8=B
9 = NC
10 = Gnd
11 = Gnd
12 = V+
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
Serial Interface - Status
1
Count Value - High (MSB)
2
Count Value - Low (LSB)
3
Latch
4
Period Value - High (MSB)
5
Period Value - Low (LSB)
6
Device Status
0
Serial Interface - Control
1
Set Value - High (MSB)
2
Set Value - Low (LSB)
3
Reserved
4
Reserved
5
Reserved
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F106
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
Serial Interface Stations
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA (from UB)
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
SDNB-10S-0002
SDNB-10S-0004
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F107
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Data
Da
ta
p e r bytes
tra
nsa
ctio
n
Int
er
T y p face
e
Ch
an
C o nels
n n e per
cto
r
Co
Pin
out
nne
Ch
an
Co n e l
unt
Part Number
cto
rs
I/O
1
0
232
1
RS232
3 to 5
1
SDNB-10S-0004
1
0
485
1
RS485/422
3 to 5
1
DeviceNet
SDNB-10S-0002
Input/Output Connectors
232
Mating cordset:
RK 4.5T-*-RS 4.5T
485
Mating cordset:
RK 4.5T-*-RS 4.5T
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
Serial Interface Status
1
Data 0
2
Data 1
3
Data 2
4
Data 3
5
Data 4
6
Device Status
0
Serial Interface Control
1
Data 0
2
Data 1
3
Data 2
4
Data 3
5
Data 4
*Note: Five data byte configuration shown. Can be configured for 3, 4 or 5 data bytes. Consult user manual for details.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F108
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O piconet Products
SSI Station
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
SDNB-10S-0005
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F109
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
1
1
SSI
4
I/O
Ma
p
Wi
re
De -Brea
tec
k
tion
Ind
iv
Dia idual
gno
stic
s
Da
ta
p e r bytes
tra
nsa
ctio
n
Int
er
T y p face
e
Ch
an
C o nels
n n e per
cto
r
Pin
out
cto
nne
0
Data
1
DeviceNet
SDNB-10S-0005
Co
Part Number
Ch
an
Co n e l
unt
rs
Inputs
Input/Output Connectors
1 = Clock2 = Clock+
3 = Data+
4 = Data5 = NC
6 = NC
7 = NC
8 = NC
9 = NC
10 = NC
11 = V+
12 = Ground
SSI
Mating cordset:
CKM 12-12-*/S817
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Data 0
1
Data 1
2
Data 2
3
Data 3
4
Device Status
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F110
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
OEM Stations
• PC-Board Slaves
• Ideal for Retrofits
• Small Footprint
• Bus Powered I/O
Electrical
• Operating Current: <50 mA plus sum of I/O currents (from DeviceNet)
• Input Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: DeviceNet power supply
FDN-PCB-22
FDN-PCB-22-OEM*
* Not CE
Mechanical
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: Open Frame
Diagnostics (Logical)
• One bit in I/O table indicates input fault for entire station, one bit er output for
fault indication
F111
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Ind
ivi
Dia dual
gno
stic
s
OC
D
nt
Ou
tp
Co ut
unt
Gro
up
Dia
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
ut C
Data
X
2
DN-O1
0.5A
X
1
None
2
DN-O1
PNP
X
2
DN-O1
0.5A
X
1
DeviceNet
Cu
rre
OC
Ma
p
PNP
Pin
out
DN-O1
D
2
le
Screw
Terminal
Inp
Sty
FDN-PCB-22-OEM
Outputs
Pin
out
FDN-PCB-22
Co
Part Number
nne
cto
r
oun
t
Inputs
Input/Output Connectors
DN-O1
I0
O0
V-
I1
O1
V-
V+
L
H
V-
V+
Note: L refers to CAN_L and H refers to CAN_H
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
-
-
-
OS-1
OS-0
I-1
I-0
0
-
-
-
-
-
-
O-1
O-0
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F112
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
OEM Station
• PC-Board Slaves
• Ideal for Retrofits
• Small Footprint
• Included Mounting Bracket
Electrical
• Operating Current: <50 mA plus sum of I/O currents (from DeviceNet)
• Input Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
• Inputs: DeviceNet power supply
• Outputs: Auxiliary power supply
Mechanical
FDN-PCB-22-1003-BKT
• Operating Temperature: -40 to +70°C (-40 to +158°F)
• Protection: Open Frame
Diagnostics (Logical)
• One bit in I/O table indicates input fault for entire station, one bit per output
for fault indication
F113
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
1
0.5 A
X
Ma
p
D
OC
Ind
ivi
Dia dual
gno
stic
s
nt
Cu
rre
DN-O3
Data
1
DeviceNet
X
Pin
out
Ou
tp
Co ut
unt
D
PNP
OC
DN-O3
le
Sty
2
Pin
out
oun
ut C
FDN-PCB-22-1003-BKT
Inp
Part Number
Outputs
Gro
up
Dia
gno
stic
s
Ind
ivi
Dia dual
gno
stic
s
t
Inputs
Input/Output Connectors
DN-O3
V+
V-
H
L
+
Out
+
-
S
+
Open Input
DeviceNet
-
S
Closed Input
I/O
Note: L refers to CAN_L and H refers to CAN_H
I/O Data Map 1
In
Out
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0
IGS
-
-
-
OS-1
-
I-1
I-0
0
-
-
-
-
-
-
O-1
-
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F114
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
Operator Station
• Ideal for Operator Interfaces
• Bus Powered I/O
• IP 67 Protection
• Automatic Baud Rate Sensing
Electrical
• Operating Current: <50 mA plus sum of all I/O currents (from DeviceNet)
• Input Current: <700 mA sum of all inputs (from DeviceNet)
• Output Current: <500 mA per output (from DeviceNet)
Power Distribution
ODNA-4S-4XSG-E
• Inputs: DeviceNet power supply
• Outputs: Auxiliary power supply
Mechanical
• Operating Temperature: -25 to +70°C (-13 to +158°F)
• Protection: NEMA 4 / IEC IP 67
Material
• Connectors: Nickel-plated brass (stainless steel available on request)
• Housing: Fiberglass
Diagnostics (Logical)
• One bit in I/O table indicates an I/O fault for inputs, one bit for outputs
Diagnostics (Physical)
• LED to indicate status of DeviceNet communication
DeviceNet eurofast ®
Pinouts
Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
F115
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
PNP
X
4
FS
0.5A
X
Ma
p
D
Data
OC
Ind
ivi
Dia dual
gno
stic
s
nt
Cu
rre
Pin
out
Ou
tp
Co ut
unt
D
OC
Gro
up
Dia
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
le
FS
Sty
8
Outputs
1
DeviceNet
ODNA-4S-4XSG-E
Pin
out
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
FS
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
Out
0
I-7
I-6
I-5
I-4
I-3
I-2
I-1
I-0
1
IGS
OGS
-
-
-
-
-
-
0
-
-
-
-
O-3
O-2
O-1
O-0
Covers for ODNA-4S-4XSG-E
Part Number
OCA-B
OCA-1-30
OCA-2-30
OCA-1-22
OCA-2-22
OCA-3-22
Cutouts
Blank
1 x 30 mm
2 x 30 mm
1 x 22 mm
2 x 22 mm
3 x 22 mm
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F116
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
BL67 Gateway
• Modular I/O
• IP 67 Protection
• Fieldbus Independent Configuration
• Various I/O Styles
Electrical
• Operating Current: <600 mA from VMB
• Supply Current: <8 A to I/O (from DeviceNet)
• Backplane Current: <1.5 A (from DeviceNet)
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IP 67
• Vibration: 5 g @ 10-500 Hz
BL67-GW-DN
Material
• Housing: PC-V0 (Lexan)
Diagnostics (Logical)
• Diagnostic information available through the DeviceNet I/O map
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet and Module Bus communication
DeviceNet minifast ® Pinouts
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
Male
Female
5-Pin
5-Pin
Note: Power feeding modules may be used for I/O current supply to prevent overloading the DeviceNet power supply.
F117
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ BL67 Stations
The BL67 system supports several different network protocols, including DeviceNet. A BL67 station consists of a gateway
module that interfaces to the DeviceNet system, and several I/O modules that interface with the physical I/O in the field.
Different connector options are available to allow a greater level of customization to the user.
For more details on the BL67 system please see the section G of this catalog.
DeviceNet
TURCK's BL67 is a modular, user configurable network I/O system designed to allow installation of nodes containing
different types and sizes of I/O depending on the users needs for a particular area. Featuring IP 67 protection and metal
threaded connectors, the BL67 can often be mounted in the physical process environment or directly on a machine without
the need to plan or purchase a separate enclosure for the I/O. This saves planning and installation time, as well as the cost
of the enclosure itself.
TURCK's I/O Assistant software package is used to configure the BL67 system.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F118
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
BL20 Gateway
• Modular I/O
• IP 20 Protection
• Fieldbus Independent Configuration
• Various I/O Styles
Electrical
• Operating Current: <250 mA from BR power supply
• Supply Current: <10 A to I/O (from UL)
<1.5 A to backplane (from USYS)
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IP 20
• Vibration: 1 g @ 5...100 Hz
Material
• Housing: PC-V0 (Lexan)
BL20-GWBR-DNET
Diagnostics (Logical)
• Diagnostic information available through the DeviceNet I/O map
Diagnostics (Physical)
• LEDs to indicate status of DeviceNet and Module Bus communication
DeviceNet Connector
Power Connector
1 = USYS
2 = GndSYS
3 = UL
4 = GndL
F119
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ BL20 Stations
TURCK's BL20 is a modular, user configurable network I/O system designed to allow installation of nodes containing
different types and sizes of I/O depending on the users needs for a particular area. Featuring IP 20 protection and terminal
point connections, the BL20 is intended to be mounted in the control cabinet or in a field enclosure.
The BL20 system supports several different network protocols, including DeviceNet. A BL20 station consists of a gateway
module that interfaces to the DeviceNet system, and several I/O modules that interface with the physical I/O in the field.
The terminal bases are available with tension clamp or screw terminal connector types.
DeviceNet
For more details on the BL20 system please see section H of this catalog.
TURCK's I/O Assistant software package is used to configure the BL20 system.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F120
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
DeviceNet to AS-interface ® Gateways
AS-I systems can be easily connected to a higher-level network, such as DeviceNet, through a gateway master. The gateway
acts as a master to the AS-I system(s) and a slave to the DeviceNet system, mapping all of the AS-I data for DeviceNet in a
single block.
For AS-I specifications and ratings details, see section E of this catalog.
DeviceNet System
(Gateway is the Slave)
AS-I System
(Gateway is the Master)
F121
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Addressing
DeviceNet™ stations must have a network address for communication. The address for AS-i/DeviceNet gateway stations
may be set via the display screen and push buttons. Please consult the manual for a particular gateway for instruction on the
procedure.
AS-i/DeviceNet gateways contain LEDs for diagnosing I/O and communication problems for both the DeviceNet and AS-I
interfaces. For a detailed description of the LED states, please see the Bihl+Wiedemann AS-i/DeviceNet Gateway User
Manual available to download from www.bihl-wiedemann.com.
Power
DeviceNet
Diagnostics
Most AS-i/DeviceNet gateways draw power from the AS-I power supply. The option to use a separate, non-AS-I power
supply is also available. Refer to the AS-I masters section of this catalog for more details on the power supply configurations.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F122
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
AS-I Gateways in Stainless Steel
• AS-I v3.0 Supported
• Integrated Ground-Fault Detection
• Graphical Display
• Integrated AS-I Diagnostics
Electrical
• Operating Current: 200 mA from VAS-I (Power Supply A)
200 mA from VAS-i1, 70mA from VAS-i2 (Power Supply A2)
250 mA from VAUX (Power Supply E)
Power Distribution
• From AS-I supply for each network (Power Supply A, A2)
• From external supply (Power Supply E)
Mechanical
ASI-DNG-SS BW1818*
ASI-DNG-SS BW1819*
ASI-DNG-SS BW1820*
ASI-DNG-SS-C1D2 BW1824
ASI-DNG-SS-C1D2 BW1825
ASI-DNG-SS-C1D2 BW1826
* Not ETL Listed
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IP 20
• Vibration: According to EN 61131-2
Material
• Housing: Stainless Steel
Diagnostics (Logical)
• AS-I diagnostic data is available via Network interface
Diagnostics (Physical)
• LEDs to indicate status of network and AS-I communication and power supply
DeviceNet Connector
F123
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
ASI-DNG-SS BW1818
DeviceNet
A
3.0
A
1
ASI-DNG-SS BW1819
DeviceNet
A2
3.0
A2
2
ASI-DNG-SS BW1820
DeviceNet
E
3.0
E
2
ASI-DNG-SS-C1D2 BW1824*
DeviceNet
A
3.0
A
1
ASI-DNG-SS-C1D2 BW1825*
DeviceNet
A2
3.0
A2
2
ASI-DNG-SS-C1D2 BW1826*
DeviceNet
E
3.0
E
DeviceNet
#o
f
Ma AS-I
ste
rs
Co
nn
Dia ectio
gra n
m
ion
ers
ASIV
Part Number
Pow
er S
tyle
Hig
he
Ne r Lev
two el
rk
Industrial
Automation
2
* Approved for use in Class 1, Division 2 areas.
Input/Output Connectors
A
A2
E
A - Single AS-I network is powered by and AS-I power supply
A2 - Dual AS-I networks are each powered by their own AS-I power supply
E - Dual AS-I networks are both powered by a single 30 VDC supply, decoupled through the gateway
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F124
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Industrial I/O DeviceNet™ Products
piconet Gateway
• Rugged, Fully Potted Stations
• Small Footprint
• IP 67 Protection
• Flexible I/O Subnetwork
Electrical
• Operating Current: <75 mA plus sensor currents (from UB)
• Sensor Current: <500 mA total of all sensors (from UB)
• Output Current: <500 mA per output (from UL)
Power Distribution
• Inputs: UB Power supply
• Outputs: UL Power supply
Mechanical
• Operating Temperature: 0 to +55°C (+32 to +131°F)
• Protection: IEC IP 67
• Vibration: IEC 68, part 2-6
SDNL-0404D-0003
Material
• Connectors: Nickel-plated brass
• Housing: Nylon
Diagnostics (Physical)
• One LED indicates an I/O fault for the entire station
• LEDs to indicate status of DeviceNet communication
DeviceNet Pinout
eurofast Male
1 = Shield
2 = V+
3 = V4 = CAN_H
5 = CAN_L
5-Pin
Aux. Power
picofast Male
picofast Female
4-Pin
4-Pin
1 = UB+
2 = UL+
3 = Gnd
4 = Gnd
F125
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
4
PI
1
PNP
4
4-7
PO
1
Data
Ind
iv
Dia idual
gno
stic
s
Wi
reDe Brea
tec
k
tion
I/O
Ma
p
Ou
tp
C o uts p
n n e er
cto
r
Cu
rre
nt
Gro
u
Dia p
gno
stic
s
Ind
ivid
Dia ual
gno
stic
s
Wi
reDe Brea
tec
k
tion
Ou
tpu
t
Co
nne
cto
rs
Pin
out
le
Sty
sor
Sen
rs
Pin
out
Inp
u
C o ts per
nne
cto
r
cto
nne
0-3
Outputs
0.5 A
1
DeviceNet
SDNL-0404D-0003
Co
Part Number
Inp
ut C
oun
t
Inputs
Input/Output Connectors
PI
PO
Mating cordset:
PSG 3M-*
Mating cordset:
PSG 3M-*
I/O Data Map 1
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
In
0
Data from next input
modules
1
Out
0
I-3
I-2
I-1
I-0
O-2
O-1
O-0
Status
Data for next output
modules
O-3
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708
www.turck.com
F126
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™ Media
G1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Cables
Flat Cable Connectors
Terminating Resistors
G4 - G20
G14
G21
Feed Through Connectors
Junctions
Conduit Adapters/Wall Adapters
G23
G25 - G50
G53/G55
Tees
Gender Changers
Receptacles
G56 - G59
G60
G62 - G74
Field Wireable Connectors
Power Taps
Daisy Chain Cordsets
G75
G77
G79
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
DeviceNet Media
DeviceNet™, Selection Guide
G2
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Notes:
G3
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Thin Cable Specifications
• Cable that Meets the Requirements of ODVA Thin or
Type 1 Cable
• Commonly Used as Drop Cable to a Maximum Length
DeviceNet Media
of 6 Meters (20 Feet) or Trunk Cable in Networks Up to
a Maximum Length of 100 Meters (328 Feet)
Jacket
Drain Wire
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
Braid Shield
Drop Length
Data Rate
Maximum Trunk Length
Maximum
125 Kbaud
100 meters (328 feet)
250 Kbaud
100 meters (328 feet)
500 Kbaud
100 meters (328 feet)
156 meters (512 feet)
6 meters (20 feet)
572
AWM 2464
75°C 300 Volts
577
AWM 2464
75°C 300 Volts
578
AWM 2464
75°C 300 Volts
5715
AWM 2095
80°C 300 Volts
Approvals
5732
AWM 20626
80°C 600 Volts
Data Pair
Outer Jacket
Shields
Bulk Cable
Part Number /
Weight/300 M
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
BK/RD
18.1 Ohms
PVC
2/22 AWG
BU/WH
18.1 Ohms
PE
PVC Light Grey
7.2 mm (.285 in)
Foil
22 AWG
RB50603-*M
44 lbs.
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
BK/RD
16.9 Ohms
PVC
2/22 AWG
BU/WH
16.9 Ohms
PE
PVC Light Grey
8.4 mm (.330 in)
Foil/Braid
22 AWG
RB50629-*M
65 lbs.
flexlife-10 ® †
NEC PLTC/CL2
CEC CMG
2/22 AWG
BK/RD
18.1 Ohms
PVC
2/22 AWG
BU/WH
18.1 Ohms
PE
PVC Light Grey
7.8 mm (.310 in)
Foil/Braid
22 AWG
RB50651-*M
51 lbs.
NEC AWM
CEC AWM-I/II A/B FT1
2/22 AWG
BK/RD
16.5 Ohms
PVC
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Light Grey
6.0 mm (.235 in)
Foil (Data Only)
22 AWG
RB50764-*M
26 lbs.
NEC AWM
2/22 AWG
BK/RD
16.5 Ohms
PE
2/24 AWG
BU/WH
27.7 Ohms
PE
PUR Violet
7.1 mm (.280 in)
Foil/Braid
22 AWG
RB50994-*M
50 lbs.
Halogen-Free ††
NEC AWM
CEC AWM-I/II A/B FT4
2/22 AWG
BK/RD
16.5 Ohms
PVC
2/22 AWG
BU/WH
16.5 Ohms
PE
TPE Charcoal
Grey
9.3 mm (.365 in)
Foil/Braid
22 AWG
RB51296-*M
68 lbs.
flexlife ® †
weldlife™†
5725
AWM 21080
75°C 300 Volts
78 meters (feet)
39 meters (feet)
Power Pair
Type
Cumulative
* Indicates length in meters.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
®
† See page A7 for flexlife performance.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G4
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Mid Cable Specifications
• Cable That Meets the Requirements of ODVA
Mid or Type III Cable
Jacket
Drain Wire
• Provides More Flexibility When Used as a
Trunk Cable Up to a Maximum Length of 300
Meters (984 Feet)
Blue
White
Black
Red
Figure A
Data
Power
Foil Shield
Braid Shield
Jacket
Aluminum Armor
Inner Jacket
Drain Wire
Blue
White
Black
Red
Figure B
Data
Power
Foil Shield
Data Rate
Maximum Trunk Length
125 Kbaud
300 meters (984 feet)
250 Kbaud
250 meters (820 feet)
500 Kbaud
100 meters (328 feet)
Overall Foil Shield
Power Pair
Type
5711
AWM 2464
80°C 300 Volts
5722
AWM 2464
75°C 300 Volts
5723
AWM 20233
80°C 300 Volts
5721A
75°C 300 Volts
5731
AWM 20626
80°C 300 Volts
Approvals
Data Pair
Outer Jacket
Shields
Bulk Cable
Part Number / Figure
Weight/300 M
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
NEC PLTC
CEC AWM-I/II A/B FT4
2/16 AWG
BK/RD
4.1 Ohms
PVC
2/20 AWG
BU/WH
11.2 Ohms
PE
PVC Light Grey
8.4 mm (.330 in)
Foil
20 AWG
RB50721-*M
65 lbs.
A
NEC PLTC
CEC AWM-I/II A/B FT4
2/17 AWG
BK/RD
5.2 Ohms
SR-PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PVC Light Grey
8.9 mm (.350 in)
Foil
20 AWG
RB50876-*M
71 lbs.
flexlife-10 ® †
A
NEC AWM
CEC AWM-I/II A/B FT1
2/17 AWG
BK/RD
5.2 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PUR Light Grey
8.4 mm (.330 in)
Foil
20 AWG
RB50877-*M
60 lbs.
flexlife-10 †
A
NEC PLTC/CM
CEC CMG HL ABCD
2/18 AWG
BK/RD
6.7 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PVC Light Grey
14.9 mm (.585 in)
Aluminum Armor
Foil/Armor
20 AWG
RB50859-*M
101 lbs.
armorfast ®
B
NEC AWM
CEC AWM-I/II A/B FT1
2/16 AWG
BK/RD
4.1 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
TPE Charcoal Grey
10 mm (.394 in)
Foil/Spiral
None
RB51235-*M
95 lbs.
flexlife †
weldlife™ †
A
* Indicates length in meters.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
®
† See page A7 for flexlife and weldlife performance.
G5
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Thick Cable Specifications
• Cable That Meets the Requirements of ODVA
Thick or Type II Cable
• It Provides the Most Power to a Network
Jacket
DeviceNet Media
When Used as a Trunk Cable Up to a
Maximum Standard Cable Length of 500
Meters (1640 Feet)
Drain Wire
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
Data Rate
Maximum
Trunk Length
Maximum Trunk Length
(5720)
125 Kbaud
500 meters (1640 feet)
420 meters (1378 feet)
250 Kbaud
250 meters (820 feet)
200 meters (656 feet)
500 Kbaud
100 meters (328 feet)
100 meters (328 feet)
Power Pair
Type
575
AWM 20233
80°C 300 Volts
579
AWM 2570
75°C 300 Volts
5720
75°C 600 Volts
Approvals
5727
75°C 300 Volts
5730
AWM 20626
80°C 300 Volts
Outer Jacket
Shields
Bulk Cable
Part Number /
Weight/300 M
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
NEC AWM
CEC AWM-I/II A/B FT1
2/15 AWG
BK/RD
3.3 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
PUR Light Grey
10.4 mm (.409 in)
Foil/Braid
18 AWG
RB50633-*M
94 lbs.
NEC PLTC/CL2
CEC CMG
2/15 AWG
BK/RD
3.2 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
PVC Light Grey
11.3 mm (.445 in)
Foil/Braid
18 AWG
RB50652-*M
122 lbs.
NEC TC
2/16 AWG
BK/RD
4.9 Ohms
PVC
2/18 AWG
BU/WH
6.9 Ohms
PE
PVC Light Grey
13 mm (.515 in)
Foil/Braid
16 AWG
RB50793-*M
168 lbs.
NEC AWM
2/15 AWG
BK/RD
3.2 Ohms
PE
2/18 AWG
BU/WH
6.9 Ohms
PE
PUR Violet
11.2 mm (.449 in)
Foil/Braid
18 AWG
RB51038-*M
150 lbs.
Halogen-Free ††
NEC PLTC
CEC AWM-I/II A/B FT4
2/15 AWG
BK/RD
3.44 Ohms
PVC
2/18 AWG
BU/WH
7.06 Ohms
PE
PVC Light Grey
13.7 mm (.540 in)
Foil/Spiral
None
RB51106-*M
157 lbs
flexlife-10 ® †
NEC AWM
CEC AWM-I/II A/B FT1
2/15 AWG
BK/RD
3.44 Ohms
PVC
2/18 AWG
BU/WH
7.06 Ohms
PE
TPE Grey
10.4 mm (.413 in)
Foil/Braid
18 AWG
RB51231-*M
110 lbs.
flexlife †
†
weldlife™
5726
AWM 21080
70°C 300 Volts
Data Pair
* Indicates length in meters.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.†
See page A7 for flexlife ® and weldlife performance.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G6
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Cable/Cordset Selection Matrix
minifast ®
eurofast ® (Thin/Mid Only)
Pin (Male)
1
Socket (Female)
2
3
Pin (Male)
4
5
RSM
WSM
RKM
WKM
RSC
RSM 57x-*M
WSM 57x-*M
RKM 57x-*M
WKM 57x-*M
RSC 57x-*M
RSM RSM 57x-*M
RSM WSM 57x-*M
RSM RKM 57x-*M
RSM WKM 57x-*M
RSM RSC 57x-*M
WSM WSM 57x-*M
WSM RKM 57x-*M
WSM WKM 57x-*M
WSM RSC 57x-*M
RKM RKM 57x-*M
RKM WKM 57x-*M
RKM RSC 57x-*M
WKM WKM 57x-*M
WKM RSC 57x-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
Pin (Male)
RSC RSC 57x-*M
RSC
6
WSC
Socket (Female)
eurofast (Thin/Mid Only)
5
7
RKC
8
WKC
See pages G11 - G12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
minifast
Male
G7
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Cable/Cordset Selection Matrix
Pin (Male)
Socket (Female)
7
6
minifast ® Bulkhead
Pin (Male)
8
9
eurofast Bulkhead (Thin Only)
Socket (Female)
Pin (Male)
11
10
Socket (Female)
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC 57x-*M
RKC 57x-*M
WKC 57x-*M
RSFP 57x-*M
RKFP 57x-*M
FSFD 57x-*M
FKFD 57x-*M
RSM WSC 57x-*M
RSM RKC 57x-*M
RSM WKC 57x-*M
RSM RSFP 57x-*M
RSM RKFP 57x-*M
RSM FSFD 57x-*M
RSM FKFD 57x-*M
WSM WSC 57x-*M
WSM RKC 57x-*M
WSM WKC 57x-*M
WSM RSFP 57x-*M
WSM RKFP 57x-*M
WSM FSFD 57x-*M
WSM FKFD 57x-*M
RKM WSC 57x-*M
RKM RKC 57x-*M
RKM WKC 57x-*M
RKM RSFP 57x-*M
RKM RKFP 57x-*M
RKM FSFD 57x-*M
RKM FKFD 57x-*M
WKM WSC 57x-*M
WKM RKC 57x-*M
WKM WKC 57x-*M
WKM RSFP 57x-*M
WKM RKFP 57x-*M
WKM FSFD 57x-*M
WKM FKFD 57x-*M
RSC WSC 57x-*M
RSC RKC 57x-*M
RSC WKC 57x-*M
RSC RSFP 57x-*M
RSC RKFP 57x-*M
RSC FSFD 57x-*M
RSC FKFD 57x-*M
WSC WSC 57x-*M
WSC RKC 57x-*M
WSC WKC 57x-*M
WSC RSFP 57x-*M
WSC RKFP 57x-*M
WSC FSFD 57x-*M
WSC FKFD 57x-*M
RKC RKC 57x-*M
RKC WKC 57x-*M
RKC RSFP 57x-*M
RKC RKFP 57x-*M
RKC FSFD 57x-*M
RKC FKFD 57x-*M
WKC WKC 57x-*M
WKC RSFP 57x-*M
WKC RKFP 57x-*M
WKC FSFD 57x-*M
WKC FKFD 57x-*M
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
DeviceNet Media
eurofast ® (Thin/Mid Only)
G8
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Open Connector Cordset Selection Matrix
minifast ®
eurofast ®
Pin (Male)
1
13
Socket (Female)
3
2
Pin (Male)
4
5
RSM
WSM
RKM
WKM
RSC
CBC5 57x-*M
RSM CBC5 57x-*M
WSM CBC5 57x-*M
RKM CBC5 57x-*M
WKM CBC5 57x-*M
RSC CBC5 57x-*M
BK52C 57x-*M
RSM BK52C 57x-*M
WSM BK52C 57x-*M
RKM BK52C 57x-*M
WKM BK52C 57x-*M
RSC BK52C 57x-*M
CBC5
14
BK52C
Thin, Mid and Thick Cable
Thin Cable Only
See pages G10 - G12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
For stainless steel coupling nut: Change part number (RSM ... to RSV, RSC ... to RSCV).
minifast
Male
G9
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Open Connector Cordset Selection Matrix
Pin (Male)
minifast ® Bulkhead
Socket (Female)
7
6
Pin (Male)
8
eurofast Bulkhead
Socket (Female)
9
Pin (Male)
11
10
Socket (Female)
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC CBC5 57x-*M
RKC CBC5 57x-*M
WKC CBC5 57x-*M
RSFP CBC5 57x-*M
RKFP CBC5 57x-*M
FSFD CBC5 57x-*M
FKFD CBC5 57x-*M
WSC BK52C 57x-*M
RKC BK52C 57x-*M
WKC BK52C 57x-*M
RSFP BK52C 57x-*M RKFP BK52C 57x-*M FSFD BK52C 57x-*M FKFD BK52C 57x-*M
Thin and Mid Cable Only
Thin, Mid and Thick Cable
Thin Cable Only
DeviceNet Media
eurofast ®
See pages G11 - G12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
Specifications
Housing:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PA (Nylon)
NEMA 1, and IEC IP 20
250 V
12 A
-40° to +75°C (-22° to +167°F)
13
14
CBC5 ..
BK52C ..
Page G9
CBC5
Pinouts
1 = Black (- Voltage)
2 = Blue (CAN_L)
3 = Bare (Shield Drain)
4 = White (CAN_H)
5 = Red (+ Voltage)
Page G9
BK52C
5 4 3 2 1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G10
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-40° to +75°C (-22° to +167°F)
1
3
RSM ..
Pages G7 - G10
2
RKM ..
Pages G7 - G10
WKM ..
Pages G7 - G10
RKFP ..
Pages G7 - G10
4
WSM ..
Pages G7 - G10
9
10
RSFP ..
G11
Pages G7 - G10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-22° to +167°F)
5
DeviceNet Media
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
7
RSC ..
Pages G7 - G10
6
RKC ..
Pages G7 - G10
WKC ..
Pages G7 - G10
FKFD ..
Pages G7 - G10
8
WSC ..
Pages G7 - G10
11
12
FSFD ..
Pages G7 - G10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G12
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Flat Cable Specifications
• Cable that Meets the Requirements of ODVA
Thick or Type II Cable
• Uses Insulation Displacement Connectors as
Device Taps
Jacket
Red
White
Blue
Black
Data Rate
Maximum Trunk Length
125 Kbaud
420 meters (1378 feet)
250 Kbaud
200 meters (656 feet)
500 Kbaud
100 meters (328 feet)
Power Pair
Type
Approvals
5713
NEC CL2
CEC AWM-I/II A/B FT4
75°C 300 Volts
Data Pair
Outer Jacket
Shields
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
2/16 AWG
BK/RD
4.1
PE
2/16 AWG
BU/WH
4.1
PE
PVC Light Grey
Flat Profile††
None
Bulk Cable
Part Number /
Weight/300 M
RB50787-*M
116 lbs.
* Indicates length in meters.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
†† Flat cable profile is 19.3 mm (0.760 in) x 5.3 mm (0.210 in).
Flat Cable Profile
G13
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Flat Cable Connectors
• Provides a minifast ® or eurofast ® Drop
Housing
Part Number
Application
(7/8-16UN) minifast Flat
Cable Connector
RKF 57-IDC
•
DeviceNet Media
Connector from Flat Cable
Pinouts
Female
Flat cable connector to
female (7/8-16UN)
minifast drop
Female
RKF 40-IDC
(7/8-16UN) minifast Auxiliary
Power Connector
(M12x1) eurofast Flat Cable
Connector
FK 57-IDC
•
Female
Flat cable connector to
female (M12x1)
eurofast drop
FK 57-IDC ET
RKF 57-IDC ET
Includes connector, end termination, and splice kit
RKF 40-IDC ET
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
POM (Nylon)
Nickel Plated CuZn or Stainless Steel
Nylon
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4 A (eurofast), 9 A (minifast)
-40° to +75°C (-22° to +167°F)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G14
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Notes:
G15
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Pico Cable Specifications
• Cable that Meets the Electrical Requirements
of ODVA Thin Cable (Data Pair Only)
• Pico Cable has 24 AWG Conductors Which
May be Used with picofast ® Connectors
DeviceNet Media
• Submittal to ODVA - Pending
Jacket
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
DeviceNet - Pico Cable 5724
DeviceNet - Thin Cable 5715
Data Rate
Maximum Trunk Length
Data Rate
Maximum Trunk Length
125 Kbaud
35 meters (115 feet)
125 Kbaud
100 meters (984 feet)
250 Kbaud
35 meters (115 feet)
250 Kbaud
100 meters (820 feet)
500 Kbaud
35 meters (115 feet)
500 Kbaud
100 meters (328 feet)
Power Pair
Type
5724
AWM 2464
80°C 300 Volts
5715
AWM 2464
80°C 300 Volts
Approvals
Data Pair
AWG
DCR (/1000 feet)
AWG
DCR (/1000 feet)
Color Code
Insulation
Color Code
Insulation
Outer Jacket
Shields
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
NEC AWM
CEC AWM-I/II A/B FT1
2/24 AWG
BK/RD
24.9
PVC
2/24 AWG
BU/WH
24.9
PE
PVC Light Grey
5.7 mm (.224 in)
Foil (Data Only)
24 AWG
RB51045-*M
27 lbs.
NEC AWM
CEC AWM-I/II A/B FT1
2/22 AWG
BK/RD
16.5
PVC
2/22 AWG
BU/WH
16.5
PE
PVC Light Grey
6.0 mm (.235 in)
Foil (Data Only)
22 AWG
RB50764-*M
26 lbs.
* Indicates length in meters.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G16
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Cable/Cordsets Selection Matrix - Threaded
picofast ® (5724 Cable Only)
Socket (Female)
14
Pin (Male)
13
16
eurofast ® (5724 Cable Only)
19
15
20
21
22
PKGM
PKWM
PSGM
PSWM
RST
WST
RKT
WKT
PKGM 57x-*M
PKWM 57x-*M
PSGM 57x-*M
PSWM 57x-*M
RST 57x-*
WST 57x-*
RKT 57x-*
WKT 57x-*
PKGM PKGM 57x-*M PKGM PKWM 57x-*M PKGM PSGM 57x-*M PKGM PSWM 57x-*M PKGM RST 57x-*M
PKGM WST 57x-*M
PKGM RKT 57x-*M
PKGM WKT 57x-*M
PKWM PKWM 57x-*M PKWM PSGM 57x-*M PKWM PSWM 57x-*M PKWM RST 57x-*M
PKWM WST 57x-*M
PKWM RKT 57x-*M
PKWM WKT 57x-*M
PSGM PSGM 57x-*M PSGM PSWM 57x-*M PSGM RST 57x-*M
PSGM WST 57x-*M
PSGM RKT 57x-*M
PSGM WKT 57x-*M
PSWM PSWM 57x-*M PSWM RST 57x-*M
PSWM WST 57x-*M
PSWM RKT 57x-*M
PSWM WKT 57x-*M
Socket (Female)
14
PKGM
16
PKWM
Pin (Male)
picofast (5724 Cable Only)
Bare
13
PSGM
15
PSWM
See pages G19 - G20 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type. See page B125 for available cable types.
Type 5715 cable can be used with RST, WST, RKT and WKT smaller body styles. Consult factory for part numbers.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
picofast
Male
G17
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Cable/Cordsets Selection Matrix - Snap Lock
picofast ®
Pin (Male)
17
17
18
18
19
20
PKGZ
PSG
RST
WST
RKT
WKT
PKGZ 57x-*M
PSG 57x-*M
RST 57x-*
WST 57x-*
RKT 57x-*
WKT 57x-*
PKGZ PKGZ 57x-*M
PKGZ PSG 57x-*M
PKGZ RST 57x-*M
PKGZ WST 57x-*M
PKGZ RKT 57x-*M
PKGZ WKT 57x-*M
PSG PSG 57x-*M
PSG RST 57x-*M
PSG WST 57x-*M
PSG RKT 57x-*M
PSG WKT 57x-*M
Socket (Female)
15
PKGZ
Pin (Male)
picofast ® (5724 Cable Only)
Bare
DeviceNet Media
Socket (Female)
eurofast ®
16
PSG
See pages G19 - G20 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type. See page B125 for available cable types.
Type 5715 cable can be used with RST, WST, RKT and WKT smaller body styles. Consult factory for part numbers.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1, 2, 4, 5, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
picofast
Male
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G18
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Cable/Cordsets Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-22° to +167°F)
19
RST ..
20
Pages G17 - G18
RKT ..
21
WST ..
G19
Pages G17 - G18
22
Pages G17 - G18
WKT ..
Pages G17 - G18
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, picofast ® Cable/Cordsets Connector Dimensions
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel (thread), Nylon (snap lock)
PUR (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-40° to +75°C (-22° to +167°F)
13
PSGM ..
14
Pages G17 - G18
PKGM ..
15
PSWM ..
Pages G17 - G18
16
Pages G17 - G18
PKWM ..
17
PSG ..
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Pages G17 - G18
18
Pages G17 - G18
PKGZ ..
Pages G17 - G18
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G20
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Terminating Resistors
• Terminating Resistors Stabilize and
Minimize Reflections on the Bus Line
• A Terminating Resistor is Required at the
Beginning and End of the Main Bus Line
Housing
Part Number
RSM 57-TR2
RSM 57-TR2/VM
RKM 57-TR2
RSE 57-TR2
RKE 57-TR2
G21
Specs
Nickel Plated Brass or
Stainless Steel
300 V, 9 A
-40° to +75°C
IP 67
Nickel Plated Brass or
Stainless Steel
300 V, 9 A
-40° to +75°C
IP 67
Nickel Plated Brass or
Stainless Steel
250 V, 4 A
-40° to +75°C
IP 67
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-40° to +75°C
IP 67
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-40° to +75°C
IP 67
Application
minifast ® Terminating Resistor
•
•
120 Ohms, 1/4 W
internal resistance
•
•
Male minifast connector
•
120 Ohms, 1/4 W
internal resistance
Male
Led indication:
Red - reverse polarity
Green-okay
minifast Terminating Resistor
Female
Female minifast connector
120 Ohms, 1/4 W
internal resistance
eurofast ® Terminating Resistor
•
•
Male
Male minifast connector
minifast Terminating Resistor with
Voltage Monitoring
•
•
Pinouts
Male
Male eurofast connector
120 Ohms, 1/4 W
internal resistance
Female
eurofast Terminating Resistor
•
•
Female eurofast connector
120 Ohms, 1/4 W
internal resistance
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Terminating Resistors
• Terminating Resistors Stabilize and
Minimize Reflections on the Bus Line
• A Terminating Resistor is Required at the
Housing
Part Number
Specs
Application
DeviceNet Media
Beginning and End of the Main Bus Line
Pinouts
Male
PSGM 57-TR
Nickel Plated Brass or
Stainless Steel
125 V, 2 A
-40° to +105°C
IP 67
picofast ® Terminating Resistor
•
•
Male picofast connector
120 Ohms, 1/2 W
internal resistance
Female
PKGM 57-TR
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G22
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Receptacles
• Receptacles Provide Transition from
Male to Female Connectors
• Available for Bulkhead and Feed Through
Applications
Housing
Part Number
RSF RKF 57/22
FKM FS 57/M12
Specs
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-40° to +75°C
IP 67
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-40° to +75°C
IP 67
Application
minifast ® Bulkhead
Receptacle
•
Male
Female
Male
Female
Straight
male/female
feed through
eurofast ® Bulkhead
Receptacle
•
Pinouts
Straight
male/female
feed through
Standard housing material is nickel plated brass. "RSF RKF.."; "RSFV RKFV.." indicates stainless steel housing.
Panel Cutout
RSF RKF 57/22
G23
Panel Cutout
FKM FS 57/M12
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet Media
Notes:
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G24
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Panel Mount Junction Box
• DIN Rail Junction Box
• Open Style
• Removable Terminals
Part Number
Application
Wiring Diagrams
JRBS-57-4
Open style DIN mounted junction box
JRBS-57-6
JRBS-57-8
G25
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Aluminum
PA (Nylon)
Gold Plated CuZn
NEMA 1 and IP 20
Snap-on DIN RAIL (DIN 50022)
-25° to +70°C (-13° to +158°F)
DeviceNet Media
Housing:
Contact Carrier:
Contacts:
Protection:
Connection Mode:
Ambient Temperature:
6-Port
4-Port
8-Port
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G26
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Junctions
• Multi-port Junction Boxes for Connecting
I/O in Concentrated Areas
• Available in Standard and Voltage
Monitoring
Part Number
Application
Wiring Diagram
8-port Junction with Voltage Monitoring
JBBS-57-E811
•
•
•
Bus in/bus out connections (7/8-16UN) minifast ®
Eight (M12x1) eurofast connectors for field connectors
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
8-port Junction
JBBS-57-E812
G27
•
•
Bus in/bus out connections (7/8-16UN) minifast
Eight (M12x1) eurofast connectors for field connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
POM (Nylon)
Nickel Plated CuZn or Stainless Steel
Nylon
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
8-port
Pinouts
minifast
Male
eurofast
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G28
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, picofast ® Junctions, 4-port
• Multi-Port Passive Junction Box in Small
Compact Housing
• Accepts (M8x1) Snap Lock or Threaded
Connectors
• Available in Standard and Voltage
Monitoring
Part Number
Application
Wiring Diagrams
4-port Junction Tee
JBBS-57-FS-P424Z
•
•
(M12x1) eurofast ® drop connector
Four (M8x1) picofast snap lock connectors
4-port Junction Tee
JBBS-57-FS-P424M
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast threaded connectors
4-port Junction Tee
JBBS-57-FS/VM-P424Z
•
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast snap lock connectors
Voltage monitoring provides low voltage (12.9 V) and high voltage
(25.6) indication
LED Indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
4-port Junction Tee
JBBS-57-FS/VM-P424M
•
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast threaded connectors
Voltage monitoring provides low voltage (12.9 V) and high
voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
4-port Junction Tee
JBBS-57-FS-E424
•
(M12x1) eurofast ® drop connector
Four (M12x1) eurofast threaded connectors
G29
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
POM (Nylon)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)-picofast ®, POM (Nylon)-eurofast ®
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-40° to +75°C (-22° to +167°F)
JBBS-57-FS-P424Z
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
JBBS-57-FS-P424M
JBBS-57-FS-E424
eurofast
Male
picofast
Male
Pinouts
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
picofast
eurofast
Female
Male
Pinouts
1. = (Shield Drain Wire)
2. = (+ Voltage)
3. = (- Voltage)
4. = (CAN_H)
5. = (CAN_L)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
eurofast
Female
G30
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, picofast ® Junctions, 8-port
• Multi-Port Passive Junction Box in Small
Compact Housing
• Accepts (M8x1) Snap Lock or Threaded
Connectors
• Available in Standard and Voltage
Monitoring
Part Number
Application
Wiring Diagrams
8-port Junction Tee
JBBS-57-FS-P824Z
•
•
(M12x1) eurofast ® drop connector
Eight (M8x1) picofast snap lock connectors
8-port Junction Tee
JBBS-57-FS-P824M
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast threaded connectors
8-port Junction Tee
JBBS-57-FS/VM-P824Z
•
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast snap lock connectors
Voltage monitoring provides low voltage (12.9 V)
and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
8-port Junction Tee
JBBS-57-FS/VM-P824M
•
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast threaded connectors
Voltage monitoring provides low voltage (12.9 V)
and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
G31
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
POM (Nylon)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)-picofast ®, POM (Nylon)-eurofast ®
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
JBBS-57-FS-P824Z
JBBS-57-FS-P824M
picofast
Male
Pinouts
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
picofast
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G32
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Passive Multi-Port Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagrams
4-port Junction
JBBS-57-M401
JBBS-57-M413
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Four device ports with (7/8-16UN) minifast
connectors
6-port Junction
JBBS-57-M601
JBBS-57-M613
Die-cast aluminum
enclosure.
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (7/8-16UN) minifast
connectors
8-port Junction
JBBS-57-M801
JBBS-57-M813
G33
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Eight device ports with (7/8-16UN) minifast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
9A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
6-Port
8-Port
4-Port
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G34
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Passive Multi-Port Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagrams
6-port Junction
JBBS-57-M623
G35
Fiberglass
enclosure
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (7/8-16UN) minifast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Fiberglass
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
9A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
6-Port
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G36
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multi-Port Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagram
JBBS-57-E401
JBBS-57-E403
Die-cast aluminum
enclosure.
JBBS-57-E411
JBBS-57-E421
4-port Junction
•
Bus in/bus out straight (7/8-16UN) minifast ®
through ports
•
Four device ports with (M12x1) eurofast
connectors
Fiberglass
JBBS-57-E601
Die-cast aluminum
enclosure.
6-port Junction
JBBS-57-E621
G37
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (M12x1) eurofast
connectors
Fiberglass
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum/Fiberglass
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
4-Port
6-Port
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G38
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multi-Port Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
JBBS-57-E801
Application
Wiring Diagram
Die-cast aluminum
enclosure.
JBBS-57-E803
8-port Junction
JBBS-57-E821
G39
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Eight device ports with (M12x1) eurofast
connectors
Fiberglass
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum/Fiberglass
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
8-Port
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G40
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multi-Port Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagram
10-port Junction
JBBS-57-E1001
G41
Die-cast aluminum
enclosure.
•
Bus in/bus out straight (7/8-16UN) minifast ®
through ports
•
Ten device ports with (M12x1) eurofast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
10-Port
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G42
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multi-Port Junctions
• Switchable DeviceNet Diagnostic Box
• Used fo DeviceNet Troubleshooting
Part Number
Specs
Application
Wiring Diagram
Diagnostic Box
JBBS-57-DGM
G43
Fiberglass
•
•
Taps into CAN_H, CAN_L, V+, V- and SHIELD
Used to diagnose DeviceNet (should not be
installed permanently on network)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Fiberglass
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
IEC IP20
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
DGM
Pinouts
eurofast Male
minifast Male
minifast Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G44
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multi-Port Junctions
• System Module Junction Box
Part Number
Specs
Application
Wiring Diagram
VV+ Left
V+ Right
V-
Bus In
Power
3 2 1 4
System module with two circuit groups
JBBS-57-SM01
Die-cast aluminum
enclosure.
•
•
•
•
•
•
•
•
DeviceNet circuit
Trunk
Left
Shield
V+ Left
VCAN_H
CAN_L
1
2
3
4
5
1
2
3
4
5
Shield
V+ Right
VCAN_H
CAN_L
Trunk
Right
Shield
Shield
Shield
Shield
Shield
Shield
1
2
3
4
5
1
2
3
4
5
Shield
V+ Right
VCAN_H
CAN_L
Local
Bus
E-Stop
E-stop+ R
E-stop- R
E-stop- L
E-stop+ L
2
1
4
3
1
2
3
4
5
Shield
V+ Right
VCAN_H
CAN_L
Local
Bus
E-stop+ L
E-stop- L
Aux.+ L
Aux.- L
2
3
1
4
2
3
1
4
E-stop+ R
E-stop- R
Aux.+ R
Aux.- R
Supplies DC power
Two drops
Auxiliary power
Supplies DC power
Catagory 2 E-stop
General purpose
Aux.
Left
Aux.
Right
M(machine)-stop
3 2 1 4
Aux.- R
Aux.+ R
Aux.+ L
Aux.- L
Aux. In
Power
G45
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67, IP 68, IP 69K
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
SM01
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G46
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Junction Tee
• Indoor Use Only
(for outdoor applications use JBBS family)
• Multi-Port Junction Provides a Rugged Connection to
Network Devices
• Bus-in/Bus-out Feature Eliminates Need for Splitter
Tee
Part Number
Application
Wiring Diagrams
4-port Junction Tee
JTBS 57-M433
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57-M434
4-port Junction Tee
JTBS 57VM-M433
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57VM-M434
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
CL I, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
6-port Junction Tee
JTBS 57-M633
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57-M634
6-port Junction Tee
JTBS 57VM-M633
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57VM-M634
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
G47
CL I, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
6-port
4-port
Pinouts
minifast ®
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G48
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Junction Tee
• Indoor Use Only
(for outdoor applications use JBBS family)
• Multi-Port Junction Provides a Rugged Connection to
Network Devices
• Bus-in/Bus-out Feature Eliminates Need for Splitter
Tee
Part Number
Application
Wiring Diagrams
4-port Junction Tee
JTBS 57-E433
•
•
•
(7/8-16UN) minifast ® bus in/bus out connections
Four (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57-E434
4-port Junction Tee
JTBS 57VM-E433
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57VM-E434
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
CL I, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
6-port Junction Tee
JTBS 57-E633
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57-E634
6-port Junction Tee
JTBS 57VM-E633
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57VM-E634
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9-25.6 V Green
(Hi) > 25.6 V Amber
•
G49
CL I, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
4-port
6-port
Pinouts
minifast ®
Male
eurofast ®
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G50
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Drop Junctions
• Creates a Drop or Branch from the Main
Bus Line
• Cable Drop Lengths Available Up to a
Maximum of 6 Meters
Housing
Part Number
Application
Wiring Diagrams
VB2 Junction
VB2-FKM/FKM/FSM 57
•
Ready for eurofast drop and trunk
cordsets
•
Maximum six meter drop
VB2 Junction with Trunk Line
VB2-RKC 57x-*M-FKM FSM
•
•
Ready for eurofast trunk line
Maximum six meter drop
VB2 Junction with Trunk Line
VB2-FKM/RKC RSC 57x-*M/*M
•
•
Ready for eurofast drop cordsets
Maximum six meter branch
* Indicates length in meters.
x Indicates cable type.
G51
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Mounting: Mounting hole accepts #8 screw.
VB2-FKM/FKM/FSM 57
VB2-RKC 57x-*M-FKM FSM
VB2-FKM/RKC RSC 57x-*M/*M
Pinouts
eurofast ®
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G52
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Conduit Adapters
• Gasket and Mounting Screws Provided
• Same Housing Style for Single or Double
Port
Housing
Part Number
Specs
Application
Pinout
Attaches to standard
conduit body* for transition
to 5-wire (7/8-16UN)
minifast connector
BCA 57-M123
*Crouse-Hinds 3/4" Form
8, Mark 9 or equivalent.
Female
Nylon Housing
Stainless Steel
Receptacle Housing
300 V, 9 A
-40° to +75°C
BCA 57-M223
Attaches to standard
conduit body* for transition
to 5-wire (7/8-16UN)
minifast connector
*Crouse-Hinds 3/4" Form
8, Mark 9 or equivalent.
Standard receptacle housing material is stainless steel, for nickel plated brass change part number from ... M223 to ... M224.
1-port Wiring Diagram
G53
2-port Wiring Diagram
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Conduit Adapters
• Gasket and Mounting Screws Provided
• Same Housing Style for Single or Double
Housing
Part Number
Specs
Application
DeviceNet Media
Port
Pinout
Attaches to standard conduit
body* for transition to 5-wire
(M12x1) eurofast connector
BCA 57-E123
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Female
Nylon Housing
Stainless Steel
Receptacle
Housing
250 V, 4 A
-40° to +75°C
BCA 57-E223
Attaches to standard conduit
body* for transition to 5-wire
(M12x1) eurofast connector
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Standard receptacle housing material is stainless steel, for nickel plated brass change part number from ... M223 to ... M224.
1-port Wiring Diagram
2-port Wiring Diagram
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G54
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Wall Plate Adapters
• Gasket and Mounting Screws Provided
• For Use with a Single Gang Electrical Box
Housing
Part Number
Specs
Application
Pinouts
Attaches to standard
single gang electrical
box for transition to
5-wire (7/8-16UN)
minifast connector
BPA-57-M113
Stainless Steel
250 V, 4.0 A
-40 to +70°C
(-40 to +158°F)
BPA-57-E113
G55
Attaches to standard
single gang electrical
box for transition to
5-wire (M12x1)
eurofast connector
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Bus Drop and Diagnostic Tees
• Creates a Drop or Branch from the Main
Bus Line
• (7/8-16UN) minifast ® Connectors on Bus
and Drop Lines
Housing
Part Number
Specs
Application
Wiring Diagrams
minifast Drop Off
Bus Line
•
Full power and
data drop
•
Maximum six
meter branch
•
Standard keyway
RSM 2RKM 57
DeviceNet Media
• Available in Three Keyway Options
minifast Drop Off
Bus Line
RSM 2RKM 57-KF
PUR (Polyurethane)
300 V, 9 A
-40° to +75°C
•
Full power and
data drop
•
Maximum six
meter branch
•
Keyway facing
female
minifast Drop Off
Bus Line
RSM 2RKM 57-KM
•
Full power and
data drop
•
Maximum six
meter branch
•
Keyway facing
male
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G56
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Power and Diagnostic Tees
• Provide a Drop to Insert Power or
Diagnostic Equipment
• (7/8-16UN) minifast ® Connectors on Bus
and Drop Lines
• Reverse Current Protection on Power Tap
Part Number
Housing
Specs
Application
Wiring Diagrams
Bus Power
RSM RKM 57 WSM 40 PST
•
Tee provides
segment power
•
Includes reverse
current protection
PUR
(Polyurethane)
300 V, 9 A
-40° to +75°C
Bus Diagnostic Tee
•
Provides easy
connection for
diagnostic tools
•
Tap protected
with cover when
not in use
(not shown)
RSM 2RKM 57 DGT
Pinouts
minifast
Male
G57
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Bus Tees
• Creates a Drop or Branch from the Main
Bus Line
• Cable Drop Can Be Up to a Maximum of
6 Meters
• eurofast ® Drop Connector or Extension
Part Number
Housing
Specs
Application
DeviceNet Media
Cordset
Wiring Diagrams
eurofast Drop
•
•
RSM FKM RKM 57
minifast ® to eurofast
Bus power and
data drop
PUR
(Polyurethane)
250 V, 4 A
-40° to +75°C
eurofast Drop Cordset
RSM RKC 57x-*M
RKM 57
•
minifast to eurofast
cordset
•
Bus power and
data drop
Pinouts
minifast
Male
eurofast
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G58
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Bus Tees
• Creates a Drop or Branch from the Main
Bus Line
• Cable Drop Can Be Up to a Maximum of
6 Meters
• eurofast Drop Connector
Housing
Part Number
Specs
Application
Wiring Diagram
eurofast Tee
RSC 2RKC 57
RSC 2RKC 57/KS
PUR
(Polyurethane)
250 V, 4 A
-40° to +75°C
•
eurofast trunk and drop
eurofast Tee
•
•
eurofast trunk and drop
Keyway aligns tee in-line
on (M8x1) piconet ®
boxes
Pinouts
eurofast
Male
G59
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Gender Changers and Elbow Connectors
• Allows Quick and Easy Changes from
Male to Female Connectors
• Available in Straight and Right Angle
Housing
Part Number
Specs
DeviceNet Media
Styles with minifast ® Connectors
Application
Male minifast Gender Changer
RSM RSM 57
RKM RKM 57
•
PUR (Polyurethane)
300 V, 9 A
-40° to +75°C
Changes female cordset to male cordset
Female minifast Gender Changer
•
•
Changes male cordset to female cordset
Changes straight male or female cordset
to right angle cordset
minifast Elbow
WSM RKM 57
•
Right angle male to female connector
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G60
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Gender Changers and Elbow Connectors
• Allows Quick and Easy Changes from
Male to Female and minifast ®
to eurofast ® Connectors
Housing
Specs
Part Number
RSM 57-FK 4.5
Application
Wiring Diagram
Nickel Plated CuZn or
Stainless Steel
Female eurofast to male
minifast adapter
250 V, 4 A
-40° to +75°C
Pinouts
G61
minifast
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, (7/8-16UN) minifast ® Male Receptacles
• Provides Quick Connection to Field
Devices or Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM,
Housing
Part Number
Specs
Application
DeviceNet Media
3/4-14NPT and M20 Threads
Pinouts
23
RSF 57-*M/14.5
1/2-14NPT full length
threads
RSF 57-*M/14.75
3/4-14NPT full length
threads
25
24
Male
RSF 57-*M/M20
Nickel Plated CuZn or
Stainless Steel
M20x1.5 threads
300 V, 9 A
-40° to +105°C
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
26
RSF 57-*M
1/2-14NPSM threads
RSF 57-*M/NPT
1/2-14NPT modified
length threads
27
See page G69 for dimensional drawings.
* Length in meters.
Standard cable length is 0.3 meters. Consult factory for other lengths.
Receptacles require a 13/16" (21.0 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
For locknuts to be included, add "W/LN" to the end of the part number.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G62
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, (7/8-16UN) minifast ® Female Receptacles
• Provides Quick Connection to Field
Devices or Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM,
3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinouts
28
RKF 57-*M/14.5
1/2-14NPT full length
threads
RKF 57-*M/14.75
3/4-14NPT full length
threads
30
Female
29
RKF 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-40° to +105°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
31
RKF 57-*M
1/2-14NPSM threads
RKF 57-*M/NPT
1/2-14NPT modified
length threads
32
See page G70 for dimensional drawings.
* Length in meters.
Standard cable length is 0.3 meters. Consult factory for other lengths.
Receptacles require a 13/16" (21.0 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
For locknuts to be included, add "W/LN" to the end of the part number.
G63
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, (M12x1) eurofast ® Male Receptacles
• Provides Quick Connection to Field
Devices
• Available for 1/2-14NPT, 1/2-14NPSM,
Housing
Part Number
Specs
Application
DeviceNet Media
3/4-14NPT and M20 Threads
Pinout
33
FS 57-*M/14.5
1/2-14NPT full length
threads
FS 57-*M/14.75
3/4-14NPT full length
threads
35
34
Male
FS 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-40° to +105°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
36
FS 57-*M
PG 9 threads
37
FS 57-*M/NPT
1/2-14NPT modified
length threads
See page G71 for dimensional drawings.
* Length in meters.
Standard cable length is 0.3 meters. Consult factory for other lengths.
Receptacles require a 13/16" (21.0 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G64
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, (M12x1) eurofast ® Female Receptacles
• Mounted for Quick Connection to
Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM,
3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinouts
38
FK 57-*M/14.5
1/2-14NPT full
length threads
FK 57-*M/14.75
3/4-14NPT full
length threads
40
39
Female
FK 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-40° to +105°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
41
FK 57-*M
PG 9 threads
42
FK 57-*M/NPT
1/2-14NPT
modified length
threads
See page G72 for dimensional drawings.
* Length in meters.
Standard cable length is 0.3 meters. Consult factory for other lengths.
Receptacles require a 13/16" (21.0 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
G65
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, minifast ® PCB and Solder Cup Receptacles
• Provides (7/8-16UN) minifast Connection
Housing
Part Number
Specs
Application
DeviceNet Media
to Field Devices
Pinouts
43
Male minifast PCB pins
RSF 57 PCB
Male
45
Male minifast solder cups
RSF 57
1.
2.
3.
4.
5.
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-40° to +105°C
44
RKF 57 PCB
BARE
RD
BK
WH
BU
Female minifast PCB pins
Female
46
RKF 57
Female minifast solder cups
See page G73 for dimensional drawings.
Standard housing material is nickel plated brass "RSFV .."; "RKFV .." indicates 316 stainless steel.
Panel Cutout
FK ... FS
Board Layout (reference only)
FK ... FS
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G66
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® PCB and Solder Cup Receptacles
• Provides (M12x1) eurofast Connection to
Field Devices
Housing
Part Number
Specs
Application
Pinouts
50
Male eurofast with
mounting kit
FS 57 PCB KIT
Male
51
Male eurofast
FS 57 PCB
1.
2.
3.
4.
5.
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-40° to +105°C
54
FK 57 PCB KIT
Female eurofast with
mounting kit
BARE
RD
BK
WH
BU
Female
55
FK 57 PCB
Female eurofast
See page G74 for dimensional drawings.
Standard housing material is nickel plated brass "FSV .."; "FKV .." indicates 316 stainless steel.
Board Layout (reference only)
FK ... FS
G67
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® PCB Pins and Solder Cup Receptacles
• Provides (M12x1) eurofast Connection to
Housing
Part Number
Specs
Application
DeviceNet Media
Field Devices
Pinouts
49
Male eurofast PCB
pins
FSFD 57 PCB
Male
48
Male eurofast solder
cups
FSFDL 57
47
WFS 57 PCB
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-40° to +105°C
Male eurofast right
angle PCB pins
1.
2.
3.
4.
5.
BARE
RD
BK
WH
BU
53
FKFD 57 PCB
Female eurofast PCB
pins
Female
52
FKFDL 57
Female eurofast solder
cups
See pages G73 - G74 for dimensional drawings.
Standard housing material is nickel plated brass "FKFD .."; "FKFDV .." indicates 316 stainless steel.
Panel Cutout
FKFD ... FSFD
Board Layout (reference only)
FKFD ... FSFD
Panel Cutout
WFS
Board Layout (reference only)
WFS
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G68
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
minifast ® Male Receptacles
23
RSF ..14.5
25
Page G62
RSF ..14.75
24
RSF .. M20
Page G62
26
Page G62
RSF ..
Page G62
27
RSF .. NPT
G69
Page G62
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
minifast ® Female Receptacles
RKF .. 14.5
30
Page G63
RKF .. 14.75
29
RKF .. M20
DeviceNet Media
28
Page G63
31
Page G63
RKF ..
Page G63
32
RKF .. NPT
Page G63
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G70
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
eurofast ® Male Receptacles
33
FS .. 14.5
35
Page G64
FS .. 14.75
34
FS .. M20
Page G64
36
Page G64
FS ..
Page G64
37
FS .. NPT
G71
Page G64
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
eurofast ® Female Receptacles
FK .. 14.5
40
Page G65
FK .. 14.75
39
FK .. M20
DeviceNet Media
38
Page G65
41
Page G65
FK ..
Page G65
42
FK .. NPT
Page G65
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G72
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
minifast ® PCB Mount Male and Female Receptacles
43
RSF ..PCB
45
Page G66
RSF ..
Page G66
44
RKF ..PCB
46
Page G66
RKF ..
Page G66
eurofast ® PCB Mount Male and Female Receptacles
47
WFS ..PCB
G73
Page G68
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
eurofast ® PCB Mount Male and Female Receptacles
FSFDL ..
52
Page G68
FKFDL ..
49
FSFD ..PCB
FKFD ..PCB
50
Page G68
54
Page G67
FK ..PCB KIT
51
FS ..PCB KIT
Page G68
53
Page G68
FS ..PCB KIT
DeviceNet Media
48
Page G67
55
Page G67
FK ..PCB KIT
Page G67
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G74
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Field Wireable Connectors
• Allows for Quick Connection when
Pre-Molded Cables not Available
• Available for Male and Female Connectors
• Color Coded Wire Connections for
DeviceNet
Housing
Part Number
BS 4151-0/9/DNET
BS 4151-0/13.5/DNET
B 4151-0/9/DNET
B 4151-0/13.5/DNET
G75
Housing Specs.
Application
Glass filled nylon
PG 9 cable gland
accepts 6-8 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Glass filled nylon
PG 13.5 cable gland
accepts 10-12 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Glass filled nylon
PG 9 cable gland
accepts 6-8 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Pinouts
Male
Mates with all 5-pin
cordsets and
receptacles
Female
Glass filled nylon
PG 13.5 cable gland
accepts 10-12 mm cable diameter
Screw terminals
85°C
250 V, 9 A
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Field Wireable Connectors
• Allows for Quick Connection when
Pre-Molded Cables not Available
• Available for Male and Female Connectors
in Straight or Right-Angle Configurations
• Color Coded Wire Connections for
Housing
Part Number
B 8251-0/PG9/DNET
BS 8251-0/PG9/DNET
Housing Specs.
Application
PBT, Black
PG 9 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
125 V, 4 A
DeviceNet Media
DeviceNet
Pinouts
Male
PBT, Black
PG 9 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
125 V, 4 A
Mates with 5-pin cordsets
and receptacles
B 8151-0/PG9/DNET
BS 8151-0/PG9/DNET
PBT, Black
PG 9 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
250 V, 4 A
Female
PBT, Black
PG 9 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
250 V, 4 A
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G76
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Power Taps
• Allows Connection to Bus Line for
Bringing in 12 VDC Power
• Available with minifast ® Bus Line and
Drop Connectors or Terminal
Connectors
Part Number
Application
Wiring Diagrams
Power Tap with minifast Connectors
SPTC1
•
•
(7/8-16UN) minifast male to female bus connector
(7/8-16UN) minifast female power connector
Power Tap with minifast Connectors
SPTC2
•
•
(7/8-16UN) minifast female to female bus connector
(7/8-16UN) minifast female power connector
Power Tap with Terminal Connectors
SPTT1
G77
•
•
Terminal strip bus connectors
Terminal strip power connector
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Anodized Aluminum
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-30° to +75°C (-22° to +167°F)
DeviceNet Media
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Dimensions
SPTC1
SPTC2
SPTT1
Pinouts
minifast ® - Bus Line
Female
1. Bare (Shield)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
minifast - Auxiliary Power
Female
1. + Voltage
2. - Voltage
3. + Voltage
4. - Voltage
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G78
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Daisy Chain Configurations
• Multi-drop Harnesses Designed for OEM
Applications
• Provides Cost Effective Solution vs. Single
Tees and Drops
Specs
Part Number
WSC 2VBWK WKC 5724-DCL
Application
PUR (Polyurethane)
250 V, 4 A
-40° to +75°C
(M12x1) eurofast Trunk and Drop Harness
•
Available in custom configurations including length, number of drops
and end connector styles
Consult factory for other designs.
Pinouts
eurofast
Male
G79
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Daisy Chain Configurations
• Multi-drop Harnesses Designed for OEM
Applications
• Provides Cost Effective Solution vs. Single
Specs
Part Number
RSC 8VBRK RKC 5724-DCL
DeviceNet Media
Tees and Drops
Application
PUR (Polyurethane)
250 V, 4 A
-40° to +75°C
(M12x1) eurofast Trunk and Drop Harness
•
Available in custom configurations including length, number of
drops and end connector styles
Consult factory for other designs.
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
G80
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement