manual

manual
Installation, Operating and Servicing
Instructions
Twin Deck Pizza Oven
PO89X
Please make a note of your product details for
future use:
Date Purchased:_________________________
Model Number:__________________________
Serial Number:__________________________
Dealer:_________________________________
_______________________________________
IS 110 ECN 3607
Page 1 of 8
CONTENTS
Important Information
Warnings and Precautions
Technical Data
Checklist of Enclosures
Installation and Commissioning
Operating Instructions
Cleaning
Servicing, Maintenance and Component Replacement
Fault Finding
Spare Parts List
Accessories
Service Information and Guarantee
2
3
3
3
3-5
5-6
6
6
6
6-7
7
8
IMPORTANT INFORMATION
Read these instructions carefully before using this product, paying particular
attention to all sections that carry warning symbols, caution symbols and notices.
Ensure that these are understood at all times.
WARNING!
This symbol is used whenever there is a risk of personal injury.
CAUTION!
This symbol is used whenever there is a risk of damaging your Lincat product.
NOTE:
This symbol is used to provide additional information, hints and tips.
KEEP THIS MANUAL FOR FUTURE REFERENCE
IS 110 ECN 3607
Page 2 of 8
WARNINGS AND PRECAUTIONS
This appliance must be installed, commissioned and serviced by a qualified person
in accordance with national and local regulations in force in the country of
installation.
If the supply cord is damaged, it must be replaced by the manufacturer, its service
agent or similarly qualified person.
Ensure that the plug/socket is accessible at all times.
Strip plastic coating and clean the appliance before use.
During operation parts may become hot - avoid accidental contact.
Disconnect this appliance before servicing, maintenance or cleaning.
The thermostat within this appliance contains Potassium-Sodium alloy that reacts
with water and can cause burns. Under no circumstances should the capillary/bulb
be cut open.
TECHNICAL DATA
Model
PO89X
Height (mm)
565
Width (mm)
810
Depth (mm)
740
Weight (kg)
81.0
CHECK LIST OF ENCLOSURES
Warranty card
Instructions manual
Refractory bricks x 2
INSTALLATION AND COMMISSIONING
This appliance must be earthed.
An equipotential bonding terminal is provided to allow cross bonding with other
equipment.
IS 110 ECN 3607
Page 3 of 8
If replacing the plug connect the terminals as follows:
Green and Yellow wire Earth
E
Blue wire
Neutral N
Brown wire
Live
L
Means of isolation with at least 3mm contact separation in all poles must be
incorporated into the fixed wiring of this appliance.
The fixed wiring insulation must be protected by insulated sleeving having a
temperature rating of at least 60 Deg C.
Supply cords shall be oil resistant, sheathed flexible cable not lighter than ordinary
polychloroprene or equivalent elastomer sheathed cord (code 60245 IEC 57)
Install this appliance on a level surface ensuring all vents are unobstructed. Any
partitions, walls or furniture must be of non-combustible material. Minimum
distances A 100mm B 1000mm – see Fig 1. Leave 35mm beneath the base.
Fig 1
IS 110 ECN 3607
Page 4 of 8
Power Ratings
Model
PO89X
kW
5.7
Supply 1N~+E (A)
24.8
Supply 3N~+E (A)
L1 7.6 L2 9.6 L3 7.6
OPERATING INSTRUCTIONS
Only qualified or trained personnel should use this appliance.
Fig 2
Refer to Fig 2 for control functions. The top and bottom ovens have their own set of
controls and operate independently.
With all control knobs set to ‘Off’, connect the appliance to an electrical supply and
switch on the power. The green neon (A) will illuminate.
Turn the thermostat control knob (B) clockwise to the required temperature. The
amber neon (C) will illuminate.
IS 110 ECN 3607
Page 5 of 8
Set the energy regulator knob (E) to maximum to pre-heat the oven. The amber
neon (D) will illuminate.
The thermostat neon (C) will go off when the appliance has reached temperature,
and cycle as the element maintains the set temperature. When the set temperature
is reached, turn the energy regulator down to 3 and then adjust to individual
requirements.
The energy regulator neon (D) will cycle on and off with the power supply to the
element – the energy regulator should not be left on maximum after the required
oven temperature has been reached.
The appliance is fitted with audible timers (F).
CLEANING
Do not use a water jet or steam cleaner, and do not immerse this appliance.
Clean all panels with warm water and mild detergent, do not use abrasive
materials. Dry with a soft cloth.
The refractory bricks may be removed for cleaning.
SERVICING, MAINTENANCE AND
COMPONENT REPLACEMENT
All servicing, maintenance and component replacement on this appliance should be
carried out by one of our recommended service engineers.
FAULT FINDING
Please refer to the Service Help Desk number on the final page of this manual.
SPARE PARTS LIST
Part Number
EL176
EL177
EN10
IS 110 ECN 3607
Description
Element 1.75kW
Element 1.1kW
Energy regulator
Page 6 of 8
FE10
HA05
KB21
KN139
KN270
KN92
NE37
NE38
SE30
SW58
TH58
TI38
Foot
Handle
Refractory brick
Thermostat knob
Timer knob
Energy regulator knob
Amber neon
Green neon
Door seal
Switch
Thermostat
Timer
ACCESSORIES
Part Number
POFS
IS 110 ECN 3607
Description
Floor stand
Page 7 of 8
SERVICE INFORMATION
For help with the installation, maintenance and use of your Lincat equipment,
please contact our service department:
 UK:
01522 875520
For non-UK customers, please contact your local Lincat dealer
All service work, other than routine cleaning should be carried out by one of our
authorised service agents. We cannot accept responsibility for work carried out by
other persons.
To ensure your service enquiry is handled as efficiently as possible, please tell us:




Brief details of the problem
Product code
All available on serial plate
Type number
Serial number
Lincat reserve the right to carry out any work under warranty, given reasonable
access to the appliance, during normal working hours, Monday to Friday, 08:30 to
17:00.
GUARANTEE
This unit carries a comprehensive UK mainland 2 year warranty. The guarantee is
in addition to, and does not diminish your statutory or legal rights.
The guarantee does not cover:



Accidental damage, misuse or use not in accordance with the manufacturer’s
instructions
Consumable items (such as filters, glass, bulbs, slot toaster elements and door
seals.)
Damage due to incorrect installation, modification, unauthorised service work or
damage due to scale, food debris build-up, etc.
The manufacturer disclaims any liability for incidental, or consequential damages.
Attendance is based on reasonable access to the appliance to allow the authorised
technician to carry out the warranty work.
Service calls to equipment under warranty will be carried out in accordance with the
conditions of sale. Unless otherwise specified, a maximum of 15 minutes of
administrative time, not spent directly carrying out servicing work, is provided for
within the warranty. Any requirement for staff attending the call to spend greater time
than 15 minutes due to administrative requirements, such as on health and safety risk
assessments, will be chargeable at the prevailing rate.
IS 110 ECN 3607
Page 8 of 8
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising