PAPER JOGGER
PJ-100
Important Information
- This manual is designed to help you to install, operate and maintain the PJ-100 paper
jogger. Read, understand and keep this manual in a safe and convenient place.
- Do not operate the PJ-100 until you read and understand the instructions in this manual.
- Horizon International Inc. shall not be liable for incidental consequential damages
resulting from : improper or inadequate maintenance by customer; unauthorized modification or misuse; or operation outside of the environmental specifications for the product.
- Horizon International Inc. pursues a policy of continuing improvement in design and
performance of the product. Therefore, the product design and specifications are subject to
change without prior notice and without our legal obligation.
- All rights are reserved. No part of this manual may be photocopied, reproduced or
translated to another language without the prior written consent of Horizon International
Inc.
000921/PJ100/01E/
UM206006-01
1. Specifications
Model
PJ-100
Voltage/ Frequency
100 V, 50 Hz / 60 Hz
115 V, 50 Hz / 60 Hz 5.7 A
230 V, 50 Hz / 60 Hz 2.8 A
Power Consumption
50 Hz : 580 W, 60 Hz : 580 W
Max. Sheet Size :
297 x 420 mm (11” x 17”)
Min. Sheet Size :
128 x 182 mm (5” x 7.2”)
Pile Height :
95 mm (3.7”)
Machine Weight
34 kg (75 lb)
Machine Dimensions :
489 (W) x 458 (D) x 1,135 (H) mm (19.3” x 18.0” x 44.7”)
Other :
Air-assist, Vibration Timer
The machine design and specifications are subject to change without any notice.
2. Machine Descriptions
Air Opening
Timer
Mode Select Switch
Sheet Holder
Circuit Protector (5A)
For blower
POWER
OFF
DELAY
6
4
8
10
2
Tray Lock Lever
0
12
sec
5A
Foot Switch
Circuit Protector (1A)
For vibration motor
1A
Air Adjusting Dial
3. Accessories and Tools
1
1.Ground Wire
1 pc
4. Selection of the Operation Mode
Select the PJ-100 operation mode with the
mode select switch.
[OFF]
PJ-100 machine power is OFF.
Continuous Operating Mode
[Continuous Operating Mode]
While this mode is selected, jogger vibrates continues. If the air adjusting dial is
turned ON, the air will come out with the
vibration.
OFF
[Foot Pedal Operating Mode]
When this mode is selected, jogger vibrates
only when stepping on the foot switch. If
the air adjusting dial is turned ON, the air
will come out with the vibration.
Mode Select Switch
Foot switch Operating Mode
5. Air Adjusting Dial Set Up
The amount of the air can be adjusted by
the air adjusting dial.
[OFF]
Turn the dial counterclockwise until there
is a clicking sound. Air blower turns OFF
and air will not come out.
[With the air]
Turn the dial clockwise to increase the
amount of the air.
Air Adjusting Dial
6. Timer Set Up
NOTE
- Timer can be set from 0 to 12 sec.
When [Foot Switch Operating Mode] is
selected with the air on, the air comes out
and jogger vibrates during stepping the
foot switch.
The air will stop when foot switch is
released, but jogger will vibrate during
predetermined seconds.
POWER
OFF
DELAY
6
4
8
10
2
0
12
sec
NOTE
-Jogger vibrates during predetermined seconds. when [Continuous Operating Mode] is
switched to [Foot Switch Operating Mode]
during jogging.
7. Tray Angle Adjustment
Sheets
Adjust tray angle according to the sheet
size and sheet thickness.
1. Loosen both tray lock levers (Left and
Right).
Caution
-Support the bottom part of the tray
with a hand when unlocking the lever,
in case tray moves by the weight of
itself.
2. Pull up or push down the bottom part of
the tray to adjust the angle of the tray.
3. Fasten the tray lock levers.
Tray Lock
Change the Lever
tray angle
Foot
Switch
8. Operation Procedure
1. Refer to section 5 and 7 and set up PJ100 in appropriate condition.
2. [When selecting the foot switch mode]
-1. Set the sheets on the tray.
-2. Step foot switch to start jogging.
[When selecting the continuous operating
mode]
-1.Select OFF operating mode with the
mode select switch.
-2. Set the sheets on the tray.
-3. Select continuous operating mode
with the mode select switch to start
jogging.
-4.Select OFF with the mode selecting
switch to stop jogging.
9. Consumable Parts
Air Blower
Air Blower is consumable. The lifetime of air blower is about 1500 to
2000 hours (Lifetime will differ according to the usage condition) .
Call your local dealer to change the air blower.
Sheets
">
