Zenith RF02RA plasma TV Adjustment instructions

ADJUSTMENT INSTRUCTIONS

1. Application Object

These instructions are applied to all of the PDP monitor, RF-

02RA.

3-3. Adjustment Method(POWERWELL)

2. Notes

(1) Because this is not a hot chassis, it is not necessary to use an isolation transformer. However, the use of isolation transformer will help protect test instrument.

(2) Adjustment must be done in the correct order.

(3) The adjustment must be performed in the circumstance of

25±5°C of temperature and 65±10% of relative humidity if there is no specific designation.

(4) The input voltage of the receiver must keep 110~240V,

50/60Hz in adjusting.

(5) The receiver must be operated for about 15 minutes prior to the adjustment.

1) After receiving 100% white pattern, the receiver must be operate prior to adjustment.(Or white condition in HEAT-

RUN mode)

2) Enter into HEAT-RUN mode

- Select the HEAT-RUN OFF by pressing ADJ Key on

Remote Control for adjustment.

- Press the VOL + Key in HEAT-RUN OFF.

(OSD display HEAT-RUN WHITE and screen display

100% FULL WHITE PATTERN)

[

Set is activated HEAT-RUN without signal generator in this mode.

[

Single color pattern of HEAT-RUN mode uses to check

PANEL.(RED/BLUE/GREEN)

[Caution] If you turn on a still screen more than 20 minutes, a afterimage may be occur in the black level part of the screen.

Each PCB Assy must be checked by the Check JIG Set before whole assembly. (Be careful the POWER PCB Assy not to damage to PDP Module)

3. POWER PCB Assy Voltage Adjustment

(Va, Vs, -Vy, Vsetup Voltage Adjustment)

3-1. Test Equipment

D.M.M 1EA

3-2. Connection Diagram for Measuring

Refer to Fig 1.

- 18 -

<Fig 1> Connection Diagram of POWERWEL Power Adj. for

Measuring

(1) Va Adjusment

1) Connect pin 1 of CN205 to (+) jack of D.M.M.

2) After turning the VR3(Va ADJ), voltage of D.M.M

adjustment as same as Va voltage which on label of panel right/top.(Deviation : ±0.5V)

(2) Vs Adjustment


2) After turning the VR6(Vs ADJ), voltage of D.M.M adjust as same as Vs voltage which indicated on label of panel right/top.(Deviation : ±0.5V)

(3) -Vy Adjustment


2) After turning the VR5(-Vy ADJ), voltage of D.M.M adjust as same as -Vy voltage which indicated on label of panel right/top.(Deviation : ±0.5V)

(4) Vsetup Adjustment


2) After turning the VR4(Vsetup ADJ), voltage of D.M.M

adjust as same as Vsetup voltage which indicated on label of panel right/top.(Deviation : ±0.5V)


[

Refer to Typical Voltage

1. Va : 35 ~ 45V

2. Vs : 170 ~ 185V

3. -Vy : -60 ~ -90V

4. Vsetup : 210 ~ 240V

[

Replace PDP Module or Power Board, adjust certainly Power

PCB Assy Voltage.

3-4. Adjustment Method(SONY)

(3) -Vy Adjustment


2) After turning the VR403(-Vy ADJ), voltage of D.M.M

adjust as same as -Vy voltage which indicated on label of panel right/top.(Deviation : ±0.5V)

(4) Vsetup Adjustment


2) After turning the VR404(Vsetup ADJ), voltage of D.M.M

adjust as same as Vsetup voltage which indicated on label of panel right/top.(Deviation : ±0.5V)

[

Refer to Typical Voltage

1. Va : 30 ~ 50V

2. Vs : 170 ~ 185V

3. -Vy : -60 ~ -90V

4. Vsetup : 210 ~ 240V

[

Replace PDP Module or Power Board, adjust certainly Power

PCB Assy Voltage.

<Fig 1> Connection Diagram of SONY Power Adj. for

Measuring

(1) Va Adjusment


2) After turning the VR402(Va ADJ), voltage of D.M.M

adjustment as same as Va voltage which on label of panel right/top.(Deviation : ±0.5V)

(2) Vs Adjustment


2) After turning the VR401(Vs ADJ), voltage of D.M.M

adjust as same as Vs voltage which indicated on label of panel right/top.(Deviation : ±0.5V)

4. Adjustment of AUTO RGB

4-1. Outline

AUTO RGB adjustment is the function to set the optimum black-level and Gain automatically in Analog --> Digital converter and to correct RGB deviation.

4-2. Required Equipment

PC Pattern Generator

(It can be possible to output 16Gray Scale Pattern and RGB output level is corrected to 0.7±0.1Vp-p)

4-3. Adjustment Method

(1) It can be possible to RGB input 16Gray Scale Pattern signal of PC Mode and select RGB.

(2) Press the ADJ Key on R/C to enter adjustment mode and select 2.W/B and then press the VOL + Key.

(3) Turn the HEATRUN OFF and select AUTO RGB and then press the VOL + Key.

5. Adjustment of White Balance

5-1. Required Equipment

(1) Color analyzer(CA-100 or same production)

(2) Auto Regulator(Required while auto adjustment, and possible to communicate with RS-232C)

(3) AV Pattern Generator

- 19 -


5-2. Connection Diagram of Equipment for

Measuring

COLOR

ANALYZER

TYPE; CA-100

85IRE

Full White

CVBS Signal Input

PDP MONITOR

85IRE Full White

MSPG-2100 or

MSTG-5200

<Fig 2> Connection Diagram of Automatic Adjustment

[

After stop the Micom by pressing IN-START Key on Remote

Control, insert the P1002 with automatic adjustment of connector.

After remove connector, move the Micom by pressing ENTER

Key.

5-3. Adjustment of White Balance

• Operate the Zero-calibration of the CA—100, then stick sensor to PDP module surface when you adjust.

• For manual adjustment, it is also possible by the following sequence.

(1) Select WHITE PATTERN of HEAT RUN mode by pressing

ADJ button on Remote Control for adjustment then operate

HEAT RUN more than 15 minute.

(2) Supply Full White signal(signal output level : 85IRE) in AV

Pattern Generator.

(3) Select image regulation status to ‘Clear Image’.

(4) Stick sensor to the center of screen and press the ADJ

Key on R/C to select W/B and then press the VOL + Key to enter the adjustment mode.

After selecting R ADJ and B ADJ, press the VOL +/- Key and adjust it until color coordination becomes(B GAIN fixation) color coordination : X=0.280±0.003, Y=0.290±0.003

color temperature : 10,000 c K ± 500 c K

(5) Exit adjustment mode using Enter button.

- 20 -

BLOCK DIAGRAM

- 21 -

EXPLODED VIEW

300

305

301

302

200

209

208

310

207

206

205

204

520

560

540

580

530

401

570

550

551

400

203

201

202

410

210

- 22 -

301

302

305

310

400

401

410

520

No.

204

205

206

207

200

201

202

203

208

209

210

300

530

540

550

551

560

570

580

Part No.

5020V00667A

3809V00A47D

3809V00A47C

3301V00010C

3809V00A58A

6871VMMD05A

6871VMMC14A

6871VSMD84A

6871VSMD92A

6871VSMD94A

5020V00666A

6871VSMD93B

6871VSMD93A

3501V00115A

6871VSMD85A

6348Q-E034A

6871QTH025A

6871QZH023A

6871QTH026A

6871QRH021A

6871QLH021A

6871QYH022A

6871QDH061A

6871QDH060A

6871QCH024A

4980V00460A

3091V00B01G

3091V00B01E

4980V00457A

4980V00458A

3790V00281D

EXPLODED VIEW PARTS LIST

Description

PDP,42 16:9 852*480 LOW VOTAGE DRIVING

PCB ASSEMBLY,ZCNT ASSY HAND INSERT 42SD4 ZCNT TOP

PCB ASSEMBLY,ZSUS ASSY HAND INSERT 42SD4

PCB ASSEMBLY,ZCNT ASSY HAND INSERT 42SD4 ZCNT(BTM)

PCB ASSEMBLY,XRRT ASSY HAND INSERT 42SD4

PCB ASSEMBLY,XRLT ASSY HAND INSERT 42SD4

PCB ASSEMBLY,YSUS ASSY HAND INSERT 42SD4

PCB ASSEMBLY,YDRV ASSY HAND INSERT 42SD4 YDRV BTM

PCB ASSEMBLY,YDRV ASSY HAND INSERT 42SD4 YDRV TOP

PCB ASSEMBLY,CTRL ASSY HAND INSERT 42SD4 CTRL B/D (4011/4021)

SUPPORTER,VERTICAL MN-42PZ40

CABINET ASSEMBLY,MU-42PZ41S NON - SILVER ZENITH

CABINET ASSEMBLY,MU-42PZ40

SUPPORTER,FILTER NON MN-42PZ40

SUPPORTER,FILTER NON MN-42PZ40

WINDOW,1142G02D-N MN42PZ10 ETCHING MESH NBK

BUTTON,CONTROL MN-42PZ40 NON NON NON

BACK COVER ASSEMBLY,MU-42PZ41V NON PIVOT INNER

BACK COVER ASSEMBLY,MU-42PZ40

PLATE ASSEMBLY,A/V 3300V00205A MU/MP-42PZ41

BACK COVER ASSEMBLY,UTER NON MN-42PZ40

PCB ASSEMBLY,MAIN RF-02RA PIVOT MU-42PZ41V

PCB ASSEMBLY,MAIN RF-02RA PIVOT MU-42PZ40

PCB ASSEMBLY,SUB A/V RF02RA SAGE2

PCB ASSEMBLY,SUB CONT RF02RA MU-42PZ41

PCB ASSEMBLY,SUB PSW RF02RA MU-42PZ41

BUTTON,POWER MN-42PZ40 SET

PCB ASSEMBLY,SUB SPK RF02RA MU-42PZ41V

PCB ASSEMBLY,SUB SPK RF02RA MU-42PZ40

BOARD ASSEMBLY,POWER BOARD SONY 40/42 PDP ONE BOARD

PCB ASSEMBLY,SUB INTER RF02RA SAGE2 FIX BD

- 23 -

REPLACEMENT PARTS LIST

For Capacitor & Resistors, the charactors at 2nd and 3rd digit in the P/No. means as follows;

CC, CX, CK, CN : Ceramic

CQ : Polyestor

CE : Electrolytic

RD : Carbon Film

RS : Metal Oxide Film

RN : Metal Film

RF : Fusible

LOCA. NO PART NO DESCRIPTION

IC

IC204

IC205

IC206

IC301

IC302

IC303

IC304

IC401

IC1805

IC1806

IC1807

IC1809

IC1810

IC201

IC202

IC203

IC1101

IC1102

IC1700

IC1701

IC1801

IC1802

IC1803

IC1804

IC001

IC002

IC101

IC102

IC103

IC104

IC105

IC108

IC701

IC801

IC802

IC802

IC803

IC804

IC402

IC501

IC502

IC601

IC602

IC603

IC604

IC700

0IPRPML001A

0IMCRSJ001A

0IMCRSH001A

0IMCRSH001A

0IMCRRH001A

0IDS232000A

0IMCRS5003A

0IMCRTI021A

0IMCRTI021A

0IMCRTI021A

0IMCRTI021A

0ISA715100D

0IIT323000E

0IKE704200J

0IMCRTI001A

0IMMRNE002A

0ISO208900A

0IMCRFA010A

0IBB368200A

0IAL242110A

0IFA741230A

0IAL242110A

0IPH740800M

0IKE704200J

0IMCRSO008A

0IMCRAD002A

0IMCRG2004B

0ISS464323A

0IMCRRH001A

0IMCRRH001A

0IMCRRH001A

0IMCRRH001A

0IS5160000A

0IMCRGN001A

0IMMRHY033A

0IMCRMN014A

0IKE704200J

0IKE780800J

0ISH052100C

0IMCRG2004B

0ISS464323A

0IPRPML001A

0IMCRRH001A

0ISA428200A

0IMCRFA010A

0ISH122100A

CXA2089Q 48QFP BK A/V SWITCH

KA7809R, FAIRCHILD 2P DPAK

OPA3682E 16P SOP ST BUFFER AMP

AT24C2110SI2.5 8P,SOP TP 1K EEPROM

DM74LS123MX 16SOP

AT24C2110SI2.5 8P

74F08D 14P SOIC R/TP QUAD 2INPUT

KIA7042AF SOT89 TP 4.2V

CXA2151Q SONY 48P

AD9883A ANALOG DEVICE 80P

JAGASM A4 SAGE 352BALL

K4S643232E(C)TC/L60(70)

BA033FP ROHM 3PSOP

BA033FP ROHM 3PSOP

BA033FP ROHM 3PSOP

BA033FP ROHM 3PSOP

MIC39100 3P SOT223 R/TP LDO TYPE 2.5V

SC1565IST1.8 3P SOT223 TP REGULATOR

PQ05DZ1U SHARP 5, SMD

PQ05DZ1U SHARP 5, SMD

BA033FP ROHM 3PSOP

DS232AS 16P,SOP TP RS232

SIL169 CL100 SILICON IMAGE 100P

SN74LVTH541PWR TEXAS INSTRUMENT 20P




LA7151M 10SOP R/TP AUDIO SW

VPC3230D C5 80P QFP TRAY VIDEO


SN74HCT157D 16P R/TP RLJA10

UPD64083GF3BA 100 QFP ST 3D

SII160 100 TQFP ST PANELLINK DIGITAL

S2310 GENESIS 208P PQFP

HY57V643220C(L)T6 HYNIX 86P

MSP3440G QA B8 V3 80 QFP TRAY SOUND IC


KIA7808API 3 ST REGULATOR .

PQ05RD21 4SIP ST REGULATOR

JAGASM A4 SAGE 352BALL

K4S643232E(C)TC/L60(70)

MIC39100 MICREL 3P SOT223

BA033FP ROHM 3PSOP

LA4282 12S 2CHX10W AUDIO AMP


PQ12RF21 4P(TO220) 12V S/W RE

RUN DATE : 2002.12.4

Q1105

Q1106

Q1107

Q1108

Q1109

Q111

Q112

Q201

Q202

Q203

Q107

Q108

Q109

Q110

Q1101

Q1102

Q1103

Q1104

Q005

Q006

Q007

Q008

Q101

Q102

Q103

Q104

Q105

Q106

IC106

IC107

Q001

Q001

Q002

Q002

Q003

Q004


IC805

IC806

IC807

IC901

IC902

IC903

IC904

IC905

IC906

IC907

0IPRPML001A

0IMCRFA010A

0IPH743200A

0ICTMMI038A

0IMMRMR009A

0IKE704200J

0IAL241610A

0IPH740400G

0IPH743200A

0IPH743200A

MIC39100 3P SOT223 R/TP LDO TYPE 2.5V


74HC32D 14SOP TP QUAD 2INPUT OR GATE

M30620SAFP/GP MITSUBISHI 100P

COPY MX29F400BTC90 4MBIT 48P


AT24C16N10SI 8P SOIC ST EEPROM

74HC04D HEX INVERTER 14P

74HC32D 14SOP TP QUAD 2INPUT

74HC32D 14SOP TP QUAD 2INPUT

TRANSISTOR

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR150400BA

0TR150400BA

0TR387500AA

0TR387500AA

0TR150400BA

0TR150400BA

0TR150400BA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR104009AF

0TR387500AA

0TR387500AA

0TR387500AA

0TR830009BA

0TR830009BA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR150400BA

0TR150400BA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

BSS83 TP PHILIPS NON NCHANNEL S/W TR

BSS83 TP PHILIPS NON NCHANNEL S/W TR

CHIP 2SC3875S(ALY) KEC





CHIP 2SA1504S(ASY) KEC

























CHIP KRC104S SOT23 TP KEC




- 24 -

D009

D010

D011

D100

D101

D102

D103

D104

D001

D002

D003

D004

D005

D006

D007

D008

D105

D106

D107

D108

D109

D110

0TR387500AA

0TR387500AA

0TR387500AA

0TR387500AA

0TR102009AG

0TR387500AA

0TR387500AA

0TR150400BA

0TR387500AA

0TR150400BA

0TR150400BA

0TR150400BA

0TR387500AA

0TR387500AA

0TR150400BA

0TR150400BA

0TR150400BA

0TR150400BA

0TR150400BA

0TR387500AA

0TR387500AA

0TR150400BA

0TR387500AA

0TR387500AA

0TR150400BA

0TR150400BA

0TR150400BA


Q411

Q412

Q413

Q414

Q415

Q416

Q417

Q418

Q601

Q602

Q603

Q403

Q404

Q405

Q406

Q407

Q408

Q409

Q410

Q204

Q205

Q206

Q301

Q302

Q303

Q401

Q402





CHIP KRC102S KEC TP SOT23























DIODE

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD184009AA

0DD226239AA

0DD226239AA

0DD226239AA

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

KDS184S CHIP 85V 300MA

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23


C002

C013

C014

C015

C019

C020

C022

C023

C024

C025

C026

C030

C031

0DD184009AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DL200000CA

0DL233309AC

0DL233309AC

0DL233309AC

0DL233309AC

0DZRM00178A

0DR050008AA

0DR050008AA

0DR050008AA

0DZRM00178A

0DZRM00178A

0DZRM00178A

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD226239AA

0DD184009AA

0DD184009AA

0DD184009AA


LD001

LD401

LD801

LD802

LD803

ZD101

ZD103

ZD104

D604

D605

D606

D801

D802

D803

D805

D806

ZD105

ZD301

ZD302

ZD902

D1804

D1805

D1806

D1809

D1810

D601

D602

D603

D111

D112

D113

D114

D115

D1801

D1802

D1803

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23





CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

CHIP KDS226 SOT23

LED,SAM5670(DL2LRG) BK YGREEN

LED,SAM2333

LED,SAM2333

LED,SAM2333

LED,SAM2333

ZENERS,UDZS TE17 5.1B

SD05.TC R/TP SEMTECH SOD323 5V






0CE4763F618

0CE476SF6DC

0CE476SF6DC

0CE476SF6DC

0CE476SF6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

0CE105SK6DC

CAPACITOR

47UF SRE 16V M FL TP5

47UF MVG 16V M

47UF MVG 16V M

47UF MVG 16V M

47UF MVG 16V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

1UF MVG 50V M

- 25 -


C134

C135

C136

C137

C138

C139

C140

C141

C1154

C116

C1160

C1165

C117

C118

C129

C132

C1131

C1132

C1133

C1135

C1147

C1148

C1149

C115

C034

C035

C038

C042

C043

C045

C1110

C1119

C1818

C1821

C1823

C1825

C1839

C1841

C1844

C1847

C145

C147

C149

C1792

C1807

C1809

C1812

C1815

C1849

C1852

C1855


47UF MVG 16V M

1UF MVG 50V M

47UF MVG 16V M

47UF MVG 16V M

47UF MVG 16V M

47UF MVG 16V M

1UF MV 50V 20%

100UF MV 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

22UF MV 16V 20%

10UF MVG 16V 20%

47UF MVK 16V 20%

22UF MV 16V 20%

47UF MVK 16V 20%

82000PF 2012 50V 10%

22UF MV 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

1UF SHL,SD 50V M

10UF MVG 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

470UF MVK 16V 20%

470UF MVK 16V 20%

470UF MVK 16V 20%

220UF MVK 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

100UF MV 16V 20%

0CE226VF6DC

0CE476WF6DC

0CK823DK56A

0CE226VF6DC

0CE476WF6DC

0CE476WF6DC

0CE105CK636

0CE106SF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE476SF6DC

0CE105SK6DC

0CE476SF6DC

0CE476SF6DC

0CE476SF6DC

0CE476SF6DC

0CE105VK6DC

0CE107VF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE226VF6DC

0CE106SF6DC

0CE476WF6DC

0CE477WF6DC

0CE477WF6DC

0CE477WF6DC

0CE227WF6DC

0CE476WF6DC

0CE477WF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE476WF6DC

0CE477WF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE107VF6DC

C307

C322

C333

C334

C335

C338

C352

C356

C214

C223

C224

C225

C301

C302

C303

C304

C1880

C1882

C1884

C1887

C1890

C1893

C1898

C1900

C1858

C1860

C1862

C1865

C1868

C1871

C1874

C1877

C532

C601

C602

C604

C605

C606

C607

C608

C360

C408

C410

C424

C431

C437

C439

C527

C609

C610

C611


100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

220UF MVK 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

100UF MV 16V 20%

10UF MVG 16V 20%

220000PF 2012 16V 10%

220000PF 2012 16V 10%

10UF MVG 16V 20%

10UF MVG 16V 20%

220000PF 2012 16V 10%

100UF MV 16V 20%

10UF MVG 16V 20%

1UF MV 50V 20%

1UF SHL,SD 50V M FM5 BP(D) TP

10UF MVG 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

470UF STD 50V 20%

470UF STD 50V 20%

220UF MVK 16V 20%

1UF MV 50V 20%

100UF STD 25V M

10UF MVG 16V 20%

100UF STD 25V M

10UF MVG 16V 20%

100UF STD 25V M

10UF MVG 16V 20%

0CE107VF6DC

0CE476WF6DC

0CE476WF6DC

0CE476WF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE106SF6DC

0CE107VF6DC

0CE106SF6DC

0CK224DF56A

0CK224DF56A

0CE106SF6DC

0CE106SF6DC

0CK224DF56A

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE227WF6DC

0CE476WF6DC

0CE476WF6DC

0CE476WF6DC

0CE476WF6DC

0CE107VF6DC

0CE106SF6DC

0CE105VK6DC

0CE105CK636

0CE106SF6DC

0CE476WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE477DK618

0CE477DK618

0CE227WF6DC

0CE105VK6DC

0CE107DH618

0CE106SF6DC

0CE107DH618

0CE106SF6DC

0CE107DH618

0CE106SF6DC

- 26 -


C672

C673

C674

C675

C676

C792

C801

C806

C635

C637

C647

C648

C650

C652

C653

C671

C625

C627

C628

C629

C630

C631

C633

C634

C612

C613

C614

C615

C616

C618

C621

C624

C825

C827

C829

C832

C835

C837

C839

C842

C807

C809

C813

C814

C817

C820

C821

C824

C845

C847

C849


0.1U 100V K

0.0120UF 100V J

0.0120UF 100V J

0.1U 100V K

220UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

3.3UF MVG 50V 20%

0.47UF MVG 50V M

0.47UF MVG 50V M

0.47UF MVG 50V M

0.47UF MVG 50V M

10UF MVG 16V 20%

10UF MVG 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

10UF MVG 16V 20%

0.47UF MVG 50V M

0.47UF MVG 50V M

470UF STD 50V 20%

470UF STD 50V 20%

470UF STD 50V 20%

470UF STD 50V 20%

2200PF 4KV M

2200PF 4KV M

220UF MVK 16V 20%

470UF MVK 16V 20%

470UF MVK 16V 20%

1UF MV 50V 20%

220UF MVK 16V 20%

220UF MVK 16V 20%

220UF MVK 16V 20%

470UF MVK 16V 20%

220UF MVK 16V 20%

220UF MVK 16V 20%

220UF MVK 16V 20%

470UF MVK 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE476WF6DC

0CE106SF6DC

0CE474SK6DC

0CE474SK6DC

0CE477DK618

0CE477DK618

0CE477DK618

0CE477DK618

181-120K

181-120K

0CE227WF6DC

0CE477WF6DC

0CE477WF6DC

0CQ1041N509

0CQ1231N419

0CQ1231N419

0CQ1041N509

0CE227WF6DC

0CE107VF6DC

0CE107VF6DC

0CE106SF6DC

0CE106SF6DC

0CE335SK6DC

0CE474SK6DC

0CE474SK6DC

0CE474SK6DC

0CE474SK6DC

0CE106SF6DC

0CE106SF6DC

0CE105VK6DC

0CE227WF6DC

0CE227WF6DC

0CE227WF6DC

0CE477WF6DC

0CE227WF6DC

0CE227WF6DC

0CE227WF6DC

0CE477WF6DC

0CE476WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

AR1101

AR1102

AR1103

AR1104

AR1105

AR1106

AR1701

AR1702

JP1

P101

P102

P103

P103

P104

P105

P105

P107


C872

C874

C877

C880

C883

C886

C888

C890

C852

C855

C857

C859

C861

C863

C865

C867

C893

C905

C909

C910

C912

C916

C925

C935

0CE476WF6DC

0CE476WF6DC

0CE227WF6DC

0CE107VF6DC

0CE476WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE107VF6DC

0CE476WF6DC

0CE477WF6DC

0CE476WF6DC

0CE107VF6DC

0CE107VF6DC

0CE106SF6DC

0CE106SF6DC

0CE107VF6DC

0CE107VF6DC

0CE106SF6DC

47UF MVK 16V 20%

47UF MVK 16V 20%

220UF MVK 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

47UF MVK 16V 20%

470UF MVK 16V 20%

47UF MVK 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

10UF MVG 16V 20%

10UF MVG 16V 20%

100UF MV 16V 20%

100UF MV 16V 20%

10UF MVG 16V 20%

JACK

6612VLH002A

6612JH003CA

6612J00010A

380-363K

6612BBBHN6A

6612VMV002A

6612JH003CA

380-068B

380-068B

JACK,RCA SP026B 4P

JACK,RCA PPJ137A AUDIO LMONO JACK

JACK,RCA PPJ128A1 A/V 2P MONO

JACK,DIN PJ6046G H=8.0 W/O S/W,W/SHIELD

JACK,DIN 4400621 AMP DVI

JACK,DRAWING UCTEX020 UGCOM BNC MONO

JACK,RCA PPJ137A AUDIO LMONO JACK

JACK,PHONE 3.5 EARPHONE WITH SW

JACK,PHONE 3.5 EARPHONE WITH SW

COIL

L801

L802

L804

L806

6140VB0004B

6140VB0004B

6140VB0004B

150-C02F

COIL,CHOKE 26UH 1UEWPHY 22.5TURN



COIL,CHOKE 82UH

RESISTOR

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

- 27 -


AR509

AR510

AR511

AR512

AR513

AR514

AR515

AR516

AR501

AR502

AR503

AR504

AR505

AR506

AR507

AR508

AR1711

AR1712

AR1713

AR1714

AR301

AR302

AR303

AR304

AR1703

AR1704

AR1705

AR1706

AR1707

AR1708

AR1709

AR1710

AR708

AR901

AR902

AR903

AR904

AR905

AR906

AR907

AR517

AR701

AR702

AR703

AR704

AR705

AR706

AR707

R1109

R611

R614

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001D

0RRZVTA001A

0RRZVTA001A

0RRZVTA001A

0RRZVTA001A

0RRZVTA001A

0RRZVTA001A

0RRZVTA001A

0RN1002F409

0RF0221H609

0RF0221H609


22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

22 OHM 1 / 16 W 1608 5%

MNR14E0AJ101 R OHM 100 OHM 5%







10K OHM 1/6 W 1.00% TA52

2.2 OHM 1/2 W 5.00% TA52

2.2 OHM 1/2 W 5.00% TA52

L1805

L1806

L1807

L1808

L1809

L1810

L1811

L1812

L1706

L1707

L1708

L1721

L1801

L1802

L1803

L1804

L1813

L1814

L1815

L1816

L1817

L1102

L1103

L1104

L1701

L1702

L1703

L1704

L1705

F602

F603

L007

L008

L009

L100

L101

L1101


R655

R656

0RD4700H609

0RD4700H609

470 OHM 1/2 W 5.00% TA52

470 OHM 1/2 W 5.00% TA52

SWITCH

P101

P108

SW001

SW002

SW003

SW004

SW005

SW006

140-275A

140-275A

140-315A

140-315A

140-315A

140-315A

140-315A

140-315A

SWITCH,PUSH JDPB21SA 30V 0.3A

SWITCH,PUSH JDPB21SA 30V 0.3A

SWITCH,TACT SKHV17910B 12V






FILTER & CRYSTAL

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6200VJS001B

6200VJS001B

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0005A

6210VC0005A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

FILTER,EMC ZJYS51R52PL(T)

FILTER,EMC ZJYS51R52PL(T)

FILTER,EMC FBMH3216 HM501NT



FILTER,EMC BK2125 HS 750

FILTER,EMC BK2125 HS 750































- 28 -


L707

L708

L711

L721

L803

L805

L807

L808

L603

L604

L701

L702

L703

L704

L705

L706

L1829

L1830

L1831

L1832

L1833

L1834

L601

L602

L1818

L1819

L1822

L1823

L1825

L1826

L1827

L1828

LA601

LT401

LT402

LT403

LT404

R110

R111

R209

L809

L810

L811

L812

L813

L901

L902

L903

R210

R214

R215

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

6210VC0006A

150-F09A

6200C000010

6200C000010

6200C000009

6200C000009

6200JB8010L

6200JB8010L

6200JB8010L

6200JB8010L

6200JB8010L

6200JB8010L










































FILTER,EMC SQE2222 714MH 0.37PHY 48TURN

FILTER,BAND PASS H354LAIK5202




FILTER,EMC MLB2012091000LN2






A4

A5

A6

A1

A1

A2

A3


R375

T1101

T1102

T1103

X1101

X301

X401

X501

X601

X901

6200JB8010L

6200VKR002A

6200VKR002A

6200VKR002A

6212AB2015A

6202VDT002E

6212AB2015B

6202VDT002J

156-A02M

6202VDT002B


FILTER,B.P. LPF 2EA TA355LSKK5216 38MHZ



RESONATOR,CRYSTAL HC49/SM4H 4MHZ +/ 30 PPM

RESONATOR,CRYSTAL SX1SMD 20250000HZ 30PPM

RESONATOR,CRYSTAL HC49/SM5H 20MHZ +/ 30 PPM

RESONATOR,CRYSTAL SX1 13.500000MHZ +/ 50 PPM

RESONATOR,CRYSTAL HC49U 18.432MHZ 30PPM

RESONATOR,CRYSTAL SX1SMD 14.318MHZ 30PPM

MISCELLANEOUS

P102

P104

P106

PA001

PA101

X700

6630VGA004B

6630VGA001C

6630VGA001C

6726VH0001A

6726VH0001A

6204B47985E

CONNECTOR ,DSUB 9P 2.77MM

CONNECTOR ,DSUB 15PIN 2.29MM

CONNECTOR ,DSUB 15PIN 2.29MM

REMOTE CONTROLLER RECEIVER,38KHZ

REMOTE CONTROLLER RECEIVER,38KHZ

OSCILLATOR,SCO103 14.31818MHZ +/ 100 PPM

ACCESSORIES

3828VA0361E

3828VA0361D

6710V00092Z

6410VUH005A

6612VMV002B

6850J00002A

6866VA9001B

MANUAL,OWNERS MU42PZ41VS ZENITH EN

MANUAL,OWNERS MU42PZ40

REMOTE CONTROLLER,RF02RA TXT ZENITH

POWER CORD,PS204 125V/13A VOLEX

JACK,DRAWING UCTEX031 UGCOM

CABLE,DVI DVID TO DVID UL20276 3000MM

CONNECTOR ,DSUB 29909C UL 1161 AWG 26

- 29 -

MAIN(TOP)

PRINTED CIRCUIT BOARD

MAIN(BOTTOM)

SPK(TOP)

SPK(BOTTOM)

AV FIX BOARD(TOP)

AV FIX BOARD(BOTTOM)

A/V(TOP)

A/V(BOTTOM)

POWER CONTROL(TOP)

CONTROL(BOTTOM)

Zenith RF02RA plasma TV Adjustment instructions

Assistant Bot

ADJUSTMENT INSTRUCTIONS

1. Application Object

3-3. Adjustment Method(POWERWELL)

2. Notes

3. POWER PCB Assy Voltage Adjustment

3-1. Test Equipment

3-2. Connection Diagram for Measuring

ADJUSTMENT INSTRUCTIONS

3-4. Adjustment Method(SONY)

4. Adjustment of AUTO RGB

4-1. Outline

4-2. Required Equipment

4-3. Adjustment Method

5. Adjustment of White Balance

5-1. Required Equipment

ADJUSTMENT INSTRUCTIONS

5-2. Connection Diagram of Equipment for

Measuring

5-3. Adjustment of White Balance

BLOCK DIAGRAM

EXPLODED VIEW

EXPLODED VIEW PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

Key Features

Frequently Answers and Questions

What are the POWERWELL adjustments?

How do I adjust the white balance on the PDP monitor?

What is the purpose of AUTO RGB adjustment?

Related manuals

Zenith RF02RA plasma TV Adjustment instructions

Assistant Bot

ADJUSTMENT INSTRUCTIONS

1. Application Object

3-3. Adjustment Method(POWERWELL)

2. Notes

3. POWER PCB Assy Voltage Adjustment

3-1. Test Equipment

3-2. Connection Diagram for Measuring

ADJUSTMENT INSTRUCTIONS

3-4. Adjustment Method(SONY)

4. Adjustment of AUTO RGB

4-1. Outline

4-2. Required Equipment

4-3. Adjustment Method

5. Adjustment of White Balance

5-1. Required Equipment

ADJUSTMENT INSTRUCTIONS

5-2. Connection Diagram of Equipment for

Measuring

5-3. Adjustment of White Balance

BLOCK DIAGRAM

EXPLODED VIEW

EXPLODED VIEW PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

REPLACEMENT PARTS LIST

Key Features

Frequently Answers and Questions

What are the POWERWELL adjustments?

How do I adjust the white balance on the PDP monitor?

What is the purpose of AUTO RGB adjustment?

Related manuals

LG

MT-42PZ40 V/B/R/S

Zenith

P50W28A Series

Zenith

P42W34

Zenith

P42W34P

Zenith

P42W46XH

LG

NP-00LE MP-40PA10

Zenith

P60W38H Series

Zenith

P60W38H Series

LG

RP-42PX 10

LG

MW-30LZ10

LG

42PX4RV

LG

50PX5R