Sea-doo | 2001 GTI 5552 | 2000-2004 SeaDoo Specifications Booklet

C
M
Y
CM
MY
CY CMY
K
www.SeaDooManuals.net
SEA-DOO
SPECIFICATION
BOOKLET
MANUEL DE
CARACTÉRISTIQUES
2000-2004
(Smt2004-001a_intro.fm SH)
(Smt2004-001a_intro.fm SH)
www.SeaDooManuals.net
SEA-DOO WATERCRAFT
SPECIFICATION BOOKLET
The purpose of this manual is to facilitate access to watercraft specifications. The Specification Booklet acts like a
summary of the technical data included in the Shop Manual.
For a more complete information, refer to Shop Manual.
2004 EDITION DIFFERENCES WITH 1988-2003
Specifications which are more commonly used for the maintenance and repair of the different Sea-Doo® watercraft for
the years specified on cover page, are grouped in sections.
Were added:
– 2004 models
– Injector and sensor resistance values were integrated in Carburetion Section.
– Distinction between 2-Stroke and 4-TEC engines in Engine Tightening
Torque Section.
This edition was primarily published to be used by watercraft
technicians who are already familiar with all service and
maintenance procedures relating to Sea-Doo watercraft.
NOTICE:Bombardier Recreational Products Inc. (BRP) is not
responsible for typesetting errors.
Were removed:
– 1988 to 1999 models
The contents of this booklet is applicable to the particular
product at its time of manufacture. However it may include
later component improvements authorized by BRP. See footnotes and read all appropriate bulletins.
Were revised:
– minor corrections were done as per latest technical information available
The use of genuine BRP parts is strongly recommended
when considering replacement of any component. Dealer
and/or distributor assistance should be sought in case of
doubt.
MODIFICATIONS DE L’ÉDITION 2004
PAR RAPPORT À CELLE DE 1988-2003
Torque tightening specifications must be strictly adhered to.
Locking devices (ex.: lock nut/tab, locking disks, self-locking
fasteners, etc.) must be installed or replaced with new ones,
where specified. If the efficiency of a locking device is
impaired, it must be renewed.
Ajouts:
– modèles 2004
– Les valeurs de résistance des injecteurs et des capteurs ont été intégrées
à la section Carburation.
– Distinction entre les moteurs 2-temps et les moteurs 4-TEC dans la section Couples de serrage du moteur.
BRP disclaims liability for all damages and/or injuries resulting from the improper use of the contents. We strongly recommend that any service be carried out and/or verified by a
highly-skilled professional technician. It is understood that
certain modifications may render the use of the watercraft
illegal under existing federal, provincial and state regulations.
Retrait:
– modèles 1988 à 1999
Révision:
BRP reserves the right at any time to discontinue or change
specifications, designs, features, models or equipment without incurring obligation.
– Des corrections mineures furent apportées conformément aux
informations techniques les plus récentes.
(Smt2004-001a_intro.fm SH)
(Smt2004-001a_intro.fm SH)
www.SeaDooManuals.net
I
MANUEL DE CARACTÉRISTIQUES
DES MOTOMARINES SEA-DOO®
MANUAL SECTIONS
SECTIONS DU MANUEL
PAGE
Ce manuel a pour but de faciliter l’accès aux caractéristiques
des motomarines. Le Manuel de caractéristiques se veut un
résumé des données techniques du Manuel de réparation.
Pour une information plus complète, se référer au Manuel de
réparation.
Les caractéristiques les plus utilisées pour l’entretien et la réparation des différents modèles Sea-Doo® selon les années précisées sur la page couverture, sont regroupées par sections.
Ce manuel est destiné avant tout aux techniciens professionnels, c’est-à-dire à des techniciens connaissant déjà toutes
les opérations d’entretien et de réparation des motomarines
Sea-Doo.
MODEL IDENTIFICATION
IDENTIFICATION
DES MODÈLES ........................
1-10
ENGINE
MOTEUR ..................................
15-38
CARBURETION & SENSORS
CARBURATION ET CAPTEURS
39-63
ELECTRICAL SYSTEM
SYSTÈME ÉLECTRIQUE..........
65-79
PROPULSION SYSTEM
SYSTÈME DE
PROPULSION...........................
81-104
AVIS: Bombardier Produits Récréatifs Inc. (BRP) n’est pas
responsable des erreurs de typographie.
Ce manuel contient les caractéristiques des motomarines
telles qu’elles étaient à leur sortie d’usine. Cependant, certaines caractéristiques peuvent avoir changé à la suite d’améliorations autorisées par BRP. Voir les renvois aux bas des
pages et lire les bulletins qui décrivent ces améliorations.
Pour tout remplacement de pièce, l’utilisation de pièces BRP
est toujours très fortement recommandée. En cas de doute,
il faut demander l’aide du concessionnaire et/ou du distributeur.
Les couples de serrage indiqués doivent être rigoureusement observés. Les pièces ou dispositifs de blocage
(ex.: écrous autobloquants, disques/plaques de verrouillage,
attaches autofreinées, etc.) doivent être installés ou remplacés par des neufs, s’il y a lieu. Remplacer toute pièce ou tout
dispositif de blocage dont l’efficacité serait diminuée.
DIMENSIONS/CAPACITIES
DIMENSIONS/
CONTENANCES ...................... 105-116
MATERIALS
MATÉRIAUX ............................ 117-132
BRP ne pourra être tenue responsable des dommages ou
blessures résultant d’une mauvaise compréhension du texte
de ce manuel. On recommande fortement de faire effectuer
et/ou vérifier les opérations mentionnées dans ce manuel par
un technicien professionnel. Il est clairement entendu que
l’utilisation d’une motomarine peut devenir illégale aux termes des règlements fédéraux, provinciaux ou d’État, si cette
motomarine a subi certaines modifications.
ENGINE TIGHTENING TORQUES
COUPLES DE SERRAGE
DU MOTEUR............................ 133-154
PROPULSION AND STEERING
TIGHTENING TORQUES
COUPLES DE SERRAGE
PROPULSION ET
DIRECTION............................... 155-170
BRP se réserve le droit de supprimer ou de modifier en tout
temps ses spécifications, designs, caractéristiques, modèles
ou pièces d’équipement, sans aucune obligation de sa part.
II
MISCELLANEOUS
DIVERS ..................................... 171-182
(Smt2004-001a_intro.fm SH)
(Smt2004-001a_intro.fm SH)
www.SeaDooManuals.net
III
GENUINE SEA-DOO PARTS
PIÈCES D’ORIGINE SEA-DOO
Genuine Sea-Doo parts are designed to careful tolerances for specific watercraft, based on extensive testing programs tailored to rigorous standards of
quality control and backed by the BRP warranty.
Les pièces d’origine Sea-Doo sont dessinées à partir de tolérances très strictes
pour des motomarines spécifiques, selon un programme d’essais répondant
à des contrôles de qualité rigoureux et protégés par la garantie BRP.
IV
(Smt2004-001a_intro.fm SH)
www.SeaDooManuals.net
(Smt2004-001a_intro.fm SH)
SECTION CONTENTS
CONTENU DE LA SECTION
MODEL IDENTIFICATION
IDENTIFICATION DES MODÈLES
PAGE
Smt2004-001b_modeles.fm
HULL IDENTIFICATION NUMBER
NUMÉRO D’IDENTIFICATION DE LA COQUE ..............
2
MODEL IDENTIFICATION (BY MODEL YEAR)
IDENTIFICATION DES MODÈLES (PAR ANNÉE) .........
3
MODEL IDENTIFICATION (BY MODEL NUMBER)
IDENTIFICATION DES MODÈLES
(PAR NUMÉROS DE MODÈLE)......................................
7
1
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
MODEL IDENTIFICATION (BY MODEL YEAR)
IDENTIFICATION DES MODÈLES (PAR ANNÉE)
MODEL IDENTIFICATION
IDENTIFICATION
DES MODÈLES
MODEL NAME
NOM DE MODÈLE
MODEL NO.
N° DE MODÈLE
2004
3D RFI (Bombay Yellow/Jaune Bombay) .....................................................6157
3D RFI International (Bombay Yellow/Jaune Bombay)...............................6158
GTI (Blue Jay/Geai bleu)................................................................................6133
GTI International (Blue Jay/Geai bleu) .........................................................6134
GTI LE (Sonoran Sand/Sable de Sonoran)...................................................6135
GTI LE International (Sonoran Sand/Sable de Sonoran) ............................6136
GTI RFI (Blue Jay/Geai bleu) .........................................................................6137
GTI RFI International (Blue Jay/Geai bleu)...................................................6138
GTI RFI LE (Sonoran Sand/Sable de Sonoran) ............................................6139
GTI RFI LE International (Sonoran Sand/Sable de Sonoran)......................6140
GTX 4-TEC (Seashore/Bord de mer) .............................................................6147
GTX 4-TEC International (Seashore/Bord de mer) ......................................6148
GTX 4-TEC Limited Supercharged (Pearl Blue/Bleu perle) .........................6141
GTX 4-TEC Limited Supercharged International (Pearl Blue/Bleu perle) ..6142
GTX 4-TEC Supercharged (Yellow/Jaune) ...................................................6143
GTX 4-TEC Supercharged International (Yellow/Jaune) ............................6144
GTX 4-TEC Wakeboard Edition (Viper Red/Rouge vipère) .........................6149
GTX 4-TEC Wakeboard Edition International (Viper Red/Rouge vipère) ...6150
RXP 4-TEC (Apple Green/Vert pomme) ........................................................6115
RXP 4-TEC International (Apple Green/Vert pomme) .................................5599
RXP 4-TEC (Yellow/Jaune) ............................................................................6162
RXP 4-TEC International (Yellow/Jaune) ......................................................6163
XP DI (Viper Red/Rouge vipère) ....................................................................6151
XP DI International (Viper Red/Rouge vipère) .............................................6152
SEA-DOO
HULL IDENTIFICATION NUMBER
NUMÉRO D’IDENTIFICATION DE LA COQUE
ZZN12345L495
Serial
number*
F00A0CB
Manufacturer
Model year
Year of production
Month of production
*A letter may also be used as a digit.
2003
GTI International (atlantic blue/bleu atlantique) ..........................................5568
GTI (ultraviolet/violet perle) ..........................................................................5598
GTI International (ultraviolet/violet perle) ....................................................5597
GTI (California/Californie) (ultraviolet/violet perle) .....................................5567
GTI LE (Earth Clay/terre glaise) ....................................................................6102
GTI LE International (Earth Clay/terre glaise) ..............................................6101
GTI LE RFI (Earth Clay/terre glaise)..............................................................6104
GTI LE RFI International (Earth Clay/terre glaise) ........................................6103
GTX 4-TEC (Early Red/rouge matinal) .........................................................6127
GTX 4-TEC International (Early Red/rouge matinal) ..................................6132
GTX 4-TEC (automn red/rouge automnal) ...................................................6112
GTX 4-TEC International (automn red/rouge automnal) ............................6111
GTX 4-TEC SUPERCHARGED (yellow/jaune)...............................................6106
GTX 4-TEC SUPERCHARGED International (yellow/jaune) ........................6105
GTX 4-TEC SUPERCHARGED (viper red/rouge vipère)..............................6129
GTX 4-TEC SUPERCHARGED International (viper red/rouge vipère) ........6128
GTX 4-TEC VANS TRIPLE CROWN EDITION ..............................................6126
GTX 4-TEC VANS TRIPLE CROWN EDITION International ........................6125
2
Smt2004-001b_modeles.fm
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
3
MODEL NAME
NOM DE MODÈLE
MODEL NAME
NOM DE MODÈLE
MODEL NO.
N° DE MODÈLE
GTX 4-TEC SUPERCHARGED LTD (blue/bleu) ............................................6108
GTX 4-TEC SUPERCHARGED LTD International (blue/bleu) .....................6107
GTX DI (autumn red/rouge automnal) ........................................................6119
GTX DI International (autumn red/rouge automnal)...................................6118
LRV DI ............................................................................................................5771
RX DI (viper red/rouge vipère) .....................................................................6123
RX DI International (viper red/rouge vipère.................................................6122
XP DI (viper red/rouge vipère.......................................................................6131
XP DI International (viper red/rouge vipère .................................................6130
2001
GS International (red/rouge) First Series, Première série...........................5548
GS International (clay/glaise) Second Series, Seconde série.....................5518
GS (clay/glaise)...............................................................................................5519
GSX RFI International First Series, Première série......................................5549
GTS International Second Series, Seconde série.......................................5520
GTS..................................................................................................................5521
GTS International First Series, Première série ...........................................5551
GTI International First Series, Première série.............................................5552
GTI International Second Series, Seconde série .........................................5522
GTI ...................................................................................................................5523
GTX RFI International ....................................................................................5524
GTX RFI ...........................................................................................................5525
GTX RFI International (green/vert)................................................................5553
GTX RFI (green/vert) ......................................................................................5555
GTX International (red/rouge) .......................................................................5526
GTX (red/rouge) .............................................................................................5527
GTX International (blue/bleu)........................................................................5538
GTX (blue/bleu) ..............................................................................................5539
GTX DI International (blue/bleu) ...................................................................5528
GTX DI (blue/bleu)..........................................................................................5529
GTX DI International (red/rouge) ..................................................................5540
GTX DI (red/rouge) .........................................................................................5541
XP Limited/Limitée International .................................................................5530
XP Limited/Limitée ........................................................................................5531
RX International (blue/bleu) ..........................................................................5532
RX (blue/bleu).................................................................................................5533
RX International (yellow/jaune) ....................................................................5542
RX (yellow/jaune) ...........................................................................................5543
RX DI International (blue/bleu)......................................................................5534
RX DI (blue/bleu) ............................................................................................5535
RX DI International (yellow/jaune)................................................................5536
RX DI (yellow/jaune) ......................................................................................5537
LRV ..................................................................................................................5697
2002
GTI (u.violet) ..................................................................................................5559
GTI California (u.violet)..................................................................................6116
GTI International (u.violet) ..........................................................................5558
GTI LE (e.clay/glaise).....................................................................................5561
GTI LE California (e.clay/glaise) ...................................................................6117
GTI LE International (e.clay/glaise) ..............................................................5560
GTX (yellow/jaune) ........................................................................................5588
GTX International (yellow/jaune)..................................................................5587
GTX 4-TEC (blue/bleu) ...................................................................................5594
GTX 4-TEC (red/rouge) ..................................................................................5574
GTX 4-TEC International (blue/bleu).............................................................5593
GTX 4-TEC International (red/rouge) ............................................................5573
GTX DI (blue/bleu)..........................................................................................5596
GTX DI (green/vert) .......................................................................................5564
GTX DI International (blue/bleu) ...................................................................5595
GTX DI International (green/vert) ................................................................5563
GTX RFI (blue/bleu).......................................................................................5566
GTX RFI International (blue/bleu) .................................................................5565
LRV DI..............................................................................................................5460
RX (blue/bleu).................................................................................................5580
RX (yellow/jaune) ...........................................................................................5582
RX International (blue/bleu) ..........................................................................5579
RX International (yellow/jaune) ....................................................................5581
RX DI (yellow/jaune) ......................................................................................5586
RX DI International (blue/bleu)......................................................................5591
RX DI LE International (yellow/jaune)...........................................................5592
RX DI LE (blue/bleu) .......................................................................................5584
RX DI LE International (blue/bleu) ................................................................5583
RX DI LE International (yellow/jaune)...........................................................5585
XP ................................................................................................................5578
XP International ...........................................................................................5577
4
MODEL NO.
N° DE MODÈLE
Smt2004-001b_modeles.fm
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
5
MODEL NAME
NOM DE MODÈLE
MODEL NO.
N° DE MODÈLE
MODEL IDENTIFICATION (BY MODEL NUMBER)
IDENTIFICATION DES MODÈLES
(PAR NUMÉRO DE MODÈLE)
2000
GS....................................................................................................................5644
GS International .............................................................................................5827
GSX RFI...........................................................................................................5645
GSX RFI International ....................................................................................5654
XP ....................................................................................................................5651
XP International..............................................................................................5655
GTI ...................................................................................................................5647
GTI International ............................................................................................5657
GTS International ...........................................................................................5639
GTX LTD..........................................................................................................5653
GTX LTD (International).................................................................................5669
GTX LTD (International (blue/bleu)...............................................................5544
GTX LTD (blue/bleu) ......................................................................................5545
GTX RFI ...........................................................................................................5648
GTX RFI International ....................................................................................5658
GTX RFI (green/vert) ......................................................................................5515
GTX RFI International (green/vert)................................................................5516
RX ................................................................................................................5513
RX International .............................................................................................5514
RX DI ...............................................................................................................5646
RX DI International.........................................................................................5656
GTX DI ............................................................................................................5649
GTX DI International .....................................................................................5659
LRV ..................................................................................................................5688
6
Smt2004-001b_modeles.fm
MODEL NUMBER
NUMÉRO DE MODÈLE
MODEL YEAR
ANNÉE MODÈLE
MODEL NAME
NOM DE MODÈLE
5460
5513
5514
5515
2002
2000
2000
2000
LRV DI
RX
RX International
GTX RFI (green/vert)
GTX RFI International (green/
vert)
GS International (clay/glaise)
GS (clay/glaise)
GTS International
GTS
GTI International
GTI
GTX RFI International
GTX RFI
GTX International (red/rouge)
GTX (red/rouge)
GTX DI International (blue/bleu)
GTX DI (blue/bleu)
XP Limited/Limitée International
XP Limited/Limitée
RX International (blue/bleu)
RX (blue/bleu)
RX DI international (blue/bleu)
RX DI (blue/bleu)
RX DI International (yellow/
jaune)
RX DI (yellow/jaune)
GTX International (blue/bleu)
GTX (blue/bleu)
GTX DI International (red/
rouge)
GTX DI (red/rouge)
RX International (yellow/jaune)
RX (yellow/jaune)
GTX International (blue/bleu)
GTX (blue/bleu)
GS International (red/rouge)
GSX RFI International
GTS International
GTI International
GTX RFI International (green/
vert)
GTX RFI (green/vert)
GTI International (u. violet)
5516
2000
5518
5519
5520
5521
5522
5523
5524
5525
5526
5527
5528
5529
5530
5531
5532
5533
5534
5535
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
2001
5536
2001
5537
5538
5539
2001
2001
2001
5540
2001
5541
5542
5543
5544
5545
5548
5549
5551
5552
2001
2001
2001
2000
2000
2001
2001
2001
2001
5553
2001
5555
5558
2001
2002
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
7
MODEL NUMBER
NUMÉRO DE MODÈLE
MODEL YEAR
ANNÉE MODÈLE
MODEL NAME
NOM DE MODÈLE
MODEL NUMBER
NUMÉRO DE MODÈLE
MODEL YEAR
ANNÉE MODÈLE
MODEL NAME
NOM DE MODÈLE
GTI (u.violet)
GTI LE International (e.clay/
glaise))
GTI LE (e.clay/glaise)
GTX International (green/vert)
GTX (green/vert)
GTX RFI International (blue/
bleu)
GTX RFI (blue/bleu)
GTI (California/Califorie) (ultraviolet/v. perle)
GTI International (atlantic blue/
bleu atlantique)
GTX 4-TEC International (red/
rouge)
GTX 4-TEC (red/rouge)
XP International
XP
RX International (blue/bleu)
RX (blue/bleu)
RX International (yellow/jaune)
RX (yellow/jaune)
RX DI International (blue/bleu)
RX DI (blue/bleu)
RX DI International (yellow/
jaune)
RX DI (yellow/jaune)
GTX International (yellow/
jaune)
GTX (yellow/jaune)
RX DI International (blue/bleu)
RX DI International (yellow/
jaune)
GTX 4-TEC International (blue/
bleu)
GTX 4-TEC (blue/bleu)
GTX International (blue/bleu)
GTX (blue/bleu)
GTI International (ultraviolet/violet perle)
GTI (ultraviolet/v. perle)
RXP 4-TEC Inter. (Apple Gr./V.
pomme)
GTS International
GS
GSX RFI
RX DI
GTI
GTX RFI
5649
5651
5653
5654
5655
5656
5657
5658
5659
5669
5688
5697
5771
6101
6102
6103
6104
2000
2000
2000
2000
2000
2000
2000
2000
2000
2000
2000
2001
2003
2003
2003
2003
2003
6105
2003
6106
2003
6107
2003
6108
2003
6111
2003
6112
2003
GTX DI
XP
GTX
GSX RFI International
XP International
RX DI International
GTI International
GTX RFI International
GTX DI International
GTX International
LRV
LRV
LRV DI
GTI LE International
GTI LE
GTI LE RFI International
GTI LE RFI
GTX 4-TEC SUPERCHARGED
International (yellow/jaune)
GTX 4-TEC SUPERCHARGED
(yellow/jaune)
GTX 4-TEC SUPERCHARGED
LTD International
GTX 4-TEC SUPERCHARGED
LIMITED
GTX 4-TEC International (aut.
red/r. automnal)
GTX 4-TEC
(automn red/rouge automnal)
RXP 4-TEC (Apple Gr./V. pomme)
GTI California (u.violet)
GTI LE California (e. clay/glaise)
GTX DI International
GTX DI
RX DI International
RX DI
GTX 4-TEC VANS TRIPLE
CROWN EDITION Intern.
GTX 4-TEC VANS TRIPLE
CROWN EDITION
GTX 4-TEC
GTX 4-TEC SUPERCHARGED International (viper red/rouge
vipère)
GTX 4-TEC SUPERCHARGED
(viper red/rouge vipère)
XP DI International
XP DI
5559
2002
5560
2002
5561
5563
5564
2002
2002
2002
5565
2002
5566
2002
5567
2003
5568
2003
5573
2002
5574
5577
5578
5579
5580
5581
5582
5583
5584
2002
2002
2002
2002
2002
2002
2002
2002
2002
5585
2002
5586
2002
5587
2002
5588
5591
2002
2002
5592
2002
5593
2002
5594
5595
5596
2002
2002
2002
5597
2003
5598
2003
5599
2004
5639
5644
5645
5646
5647
5648
2000
2000
2000
2000
2000
2000
8
Smt2004-001b_modeles.fm
6115
2004
6116
6117
6118
6119
6122
6123
2002
2002
2003
2003
2003
2003
6125
2003
6126
2003
6127
2003
6128
2003
6129
2003
6130
6131
2003
2003
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
9
MODEL NUMBER
NUMÉRO DE MODÈLE
MODEL YEAR
ANNÉE MODÈLE
6132
2003
6133
6134
2004
2004
6135
2004
6136
2004
6137
2004
6138
2004
6139
2004
6140
2004
6141
2004
6142
2004
6143
2004
6144
2004
6147
2004
6148
2004
6149
2004
6150
2004
6151
2004
6152
2004
6157
2004
6158
2004
6162
6163
2004
2004
10
MODEL NAME
NOM DE MODÈLE
NOTES/NOTES
GTX 4-TEC International (automn red/rouge automne)
GTI (Blue Jay/Geai bleu)
GTI Inter. (Blue Jay/Geai bleu)
GTI LE (Sonoran Sand/Sable de
Sonoran)
GTI LE International (Sonoran
Sand/Sable de Sonoran)
GTI RFI (Blue Jay/Geai bleu)
GTI RFI International (Blue Jay/
Geai bleu)
GTI RFI LE (Sonoran Sand/Sable
de Sonoran)
GTI RFI LE International (Sonoran Sand/Sable de Sonoran)
GTX 4-TEC Ltd Supercharged
(Pearl Blue/Bleu perle)
GTX 4-TEC Ltd Supercharged
Inter. (Pearl Blue/Bleu perle)
GTX 4-TEC Supercharged (Yellow/Jaune)
GTX 4-TEC Supercharged International (Yellow/Jaune)
GTX 4-TEC (Seashore/Bord de
mer)
GTX 4-TEC International (Seashore/Bord de mer)
GTX 4-TEC Wakeboard Edition
(Viper Red/Rouge vipère)
GTX 4-TEC Wakeboard Edition
Inter. (Viper Red/Rouge vipère)
XP DI (Viper Red/Rouge vipère)
XP DI International (Viper Red/
Rouge vipère)
3D RFI (Bombay Yellow/Jaune
Bombay)
3D RFI International (Bombay
Yellow/Jaune Bombay)
RXP 4-TEC (Yellow/Jaune)
RXP 4-TEC Inter. (Yellow/Jaune)
Smt2004-001b_modeles.fm
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
11
NOTES/NOTES
12
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
Smt2004-001b_modeles.fm
13
MODEL NUMBER
NUMÉRO DE MODÈLE
MODEL YEAR
ANNÉE MODÈLE
MODEL NAME
NOM DE MODÈLE
6132
2003
6133
6134
2004
2004
6135
2004
GTX 4-TEC International (automn red/rouge automne)
GTI (Blue Jay/Geai bleu)
GTI Inter. (Blue Jay/Geai bleu)
GTI LE (Sonoran Sand/Sable de
Sonoran)
GTI LE International (Sonoran
Sand/Sable de Sonoran)
GTI RFI (Blue Jay/Geai bleu)
GTI RFI International (Blue Jay/
Geai bleu)
GTI RFI LE (Sonoran Sand/Sable
de Sonoran)
GTI RFI LE International (Sonoran Sand/Sable de Sonoran)
GTX 4-TEC Ltd Supercharged
(Pearl Blue/Bleu perle)
GTX 4-TEC Ltd Supercharged
Inter. (Pearl Blue/Bleu perle)
GTX 4-TEC Supercharged (Yellow/Jaune)
GTX 4-TEC Supercharged International (Yellow/Jaune)
GTX 4-TEC (Seashore/Bord de
mer)
GTX 4-TEC International (Seashore/Bord de mer)
GTX 4-TEC Wakeboard Edition
(Viper Red/Rouge vipère)
GTX 4-TEC Wakeboard Edition
Inter. (Viper Red/Rouge vipère)
XP DI (Viper Red/Rouge vipère)
XP DI International (Viper Red/
Rouge vipère)
3D RFI (Bombay Yellow/Jaune
Bombay)
3D RFI International (Bombay
Yellow/Jaune Bombay)
RXP 4-TEC (Yellow/Jaune)
RXP 4-TEC Inter. (Yellow/Jaune)
6136
2004
6137
2004
6138
2004
6139
2004
6140
2004
6141
2004
6142
2004
6143
2004
6144
2004
6147
2004
6148
2004
6149
2004
6150
2004
6151
2004
6152
2004
6157
2004
6158
2004
6162
6163
2004
2004
10
Smt2004-001b_modeles.fm
NOTES/NOTES
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
13
SECTION CONTENTS
CONTENU DE LA SECTION
2-STROKE ENGINE
MOTEUR 2-TEMPS
PAGE................................... 16
– Engine
– Moteur
– Bore
– Alésage
– Stroke
– Course
– Displacement
– Cylindrée
– Compression Ratio
– Taux de compression
– Ring Type
– Segment de piston
– Ring End Gap
– Ouverture du segment
– Piston/Cylinder Wall
Clearance
– Jeu piston/cylindre
– Cylinder Taper
– Conicité du cylindre
– Cylinder Out of Round
– Ovalisation du cylindre
– Connecting Rod Big End
Axial Play
– Jeu axial de la tête de bielle
– Rotary Valve Opening
– Ouverture de la valve
rotative
– Rotary Valve Timing
– Réglage de la valve rotative
14
Smt2004-001b_modeles.fm
www.SeaDooManuals.net
Smt2004-001b_modeles.fm
SECTION CONTENTS
CONTENU DE LA SECTION
4-TEC ENGINE
MOTEUR 4-TEC
PAGE ............................ 18
– Engine
– Moteur
– Number of Cylinder
– Nombre de cylindres
– Number of Valves
– Nombre de soupapes
– Bore
– Alésage
– Stroke
– Course
– Displacement
– Cylindrée
– Compression Ratio
– Taux de compression
– Ring Type
– Type de segment
– Ring End Gap
– Ouverture du segment
– Piston/Cylinder Wall
Clearance
– Jeu piston/cylindre
– Cylinder Taper
– Conicité du cylindre
– Cylinder Out of Round
– Ovalisation du cylindre
– Intake Valve Opening
– Ouverture/fermeture
soupape d’admission
– Exhaust Valve Opening/
closing
– Ouverture/fermeture
soupape
d’échappement
PAGE ......................................... 20
– Engine
– Moteur
– Intake Valve Stem Diameter
– Diamètre de la tige de la
soupape d’admission
– Exhaust Valve Stem Diameter
– Diamètre de la tige de la
soupape d’échappement
– Valve Guide Diameter
– Diamètre du guide de soupape
– Valve Spring Free Length (Inner)
– Longueur libre du ressort de
soupape (intérieur)
– Valve Spring Free Length (Outer)
– Longueur libre du ressort de
soupape (extérieur)
– Valve Seat Contact (Intake)
– Contact de siège de soupape
(admission)
– Valve Seat Contact (Exhaust)
– Contact de siège de soupape
(échappement)
– Cam Lobe (Intake)
– Lobe de came (admission)
– Cam Lobe (Exhaust)
– Lobe de came (échappement)
– Con. Rod Big End Radial Clearance
– Jeu radial de la tête de bielle
– Crank. Axial Clearance (Min./Max.)
– Jeu axial (min./max.) du
vilebrequin
– Cylinder Head Screw (Maximum
Length)
– Vis de culasse (longueur
maximale)
ABBREVIATIONS
ABRÉVIATIONS................ 38
Smt2004-001c_moteur.fm
15
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
RING TYPE
SEGMENT DE PISTON
RING END GAP
OUVERTURE
DU SEGMENT
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
opening/
closing➃
ouverture/
fermeture➃
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.040)
0.1
(.0039)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159
147°
65.5°
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.040)
0.1
(.0039)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159
147°
65.5°
781.6
(47.70)
6.0:1
1 ST L
1R
0.4
(.016)
1.00
(.040)
0.13
(.0051)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159
147°
63.5°
74.0
(2.91)
781.6
(47.70)
6.0:1
1 ST L
1R
0.4
(.016)
1.00
(.040)
0.13
(.0051)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159
147°
63.5°
82.00
(3.23)
74.0
(2.91)
781.6
(47.70)
6.0:1
1 ST L
1R
0.4
(.016)
1.00
(.040)
0.13
(.0051)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159
147°
63.5°
88.00
(3.46)
78.2
(3.08)
951.2
(58.05)
6.0:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
mm
(in/po)
cm³
(in³/po³ )
717
82.00
(3.23)
68.0
(2.68)
718.2
(43.82)
GTI LE
(6135/6136)
717
82.00
(3.23)
68.0
(2.68)
718.2
(43.82)
3D RFI
(6157/6158)
787 RFI
82.00
(3.23)
74.0
(2.91)
GTI RFI
(6137/6138)
787 RFI
82.00
(3.23)
GTI RFI LE
(6139/6140)
787 RFI
XP DI
(6151/6152)
947 DI
GTI
(6133/6134)
16
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
ROTARY VALVE
TIMING
RÉGLAGE DE LA
VALVE ROTATIVE
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
N/U
mm
(in/po)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
STROKE
COURSE
mm
(in/po)
BORE
ALÉSAGE
N/U
mm
(in/po)
ENGINE
MOTEUR
N/U
mm
(in/po)
mm
(in/po)
2004
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
2 Stroke Engines/Moteurs 2-temps
N.A./
S.O.
17
INTAKE VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ADMISSION➃
EXHAUST VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ÉCHAPPEMENT➃
63.4
(2.5)
1493.8
(58.81)
10.6:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/5°
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
10.6:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/5°
GTX 4-TEC
Supercharged
(6143/6144)
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
8.1:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/0°
GTX 4-TEC
Limited
Supercharged
(6141/6142)
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
8.1:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/0°
RXP 4-TEC
(5599/6115/
6162/6163)
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
8.1:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/0°
18
STROKE
COURSE
COMPRESSION RATIO
TAUX DE COMPRESSION
BORE
ALÉSAGE
Smt2004-001c_moteur.fm
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
100
(3.94)
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
12
cm³
(in³/
po³ )
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/CYLINDRE
3
mm
(in/po)
RING END GAP (MAX.)
OUVERTURE
DU SEGMENT (MAX.)
NUMBER OF VALVES
NOMBRE DE SOUPAPES
1503
mm
(in/po)
RING TYPE
TYPE DE SEGMENT
NUMBER OF CYLINDER
NOMBRE DE CYLINDRES
GTX 4-TEC
(6147/6148)
2004
DISPLACEMENT
CYLINDRÉE
ENGINE
MOTEUR
4-TEC Engines/Moteurs 4-TEC
mm
(in/po)
N/U
mm
(in/po)
mm
(in/po)
mm
(in/po)
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
19
Wear limit mm (in/po)
Limite d’usure mm (in/po)
Wear limit mm (in/po)
Limite d’usure mm (in/po)
CYLINDER HEAD SCREW
(MAXIMUM LENGTH)
VIS DE CULASSE
(LONGUEUR MAXIMALE)
CON. ROD BIG END RADIAL
CLEARANCE
JEU RADIAL DE LA TÊTE
DE LA BIELLE
CRANK. AXIAL CLEARANCE
(MIN./MAX.)
JEU AXIAL (MIN./MAX.) DU
VILEBREQUIN
CAM LOBE (EXHAUST)
LOBE DE CAME
(ÉCHAPPEMENT)
CAM LOBE (INTAKE)
LOBE DE CAME (ADMISSION)
VALVE SEAT CONTACT
(EXHAUST)
CONTACT DE SIÈGE DE
SOUPAPE (ÉCHAPPEMENT)
VALVE SEAT CONTACT
(INTAKE)
CONTACT DE SIÈGE DE
SOUPAPE (ADMISSION)
VALVE SPRING FREE
LENGTH (INNER)
LONGUEUR LIBRE DU RESSORT
DE SOUPAPE (INTÉRIEUR)
VALVE SPRING FREE
LENGTH (OUTER)
LONGUEUR LIBRE DU RESSORT
DE SOUPAPE (EXTÉRIEUR)
VALVE GUIDE DIAMETER
DIAMÈTRE DU GUIDE DE
SOUPAPE
EXHAUST VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ÉCHAPPEMENT
INTAKE VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ADMISSION
ENGINE
MOTEUR
2004
mm
(in/po)
GTX 4-TEC
(6147/6148)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.430
(1.2442)
31.650
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.430
(1.2442)
31.650
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
GTX 4-TEC
Supercharged
(6143/6144)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.650
(1.2442)
31.430
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
GTX 4-TEC
Limited
Supercharged
(6141/6142)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.650
(1.2442)
31.430
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
RXP 4-TEC
(5599/6115/
6162/6163)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.650
(1.2442)
31.430
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
20
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
21
RING TYPE
SEGMENT DE PISTON
RING END GAP
OUVERTURE
DU SEGMENT
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
opening/
closing➃
ouverture/
fermeture➃
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.040)
0.1
(.0039)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159
147°
65.5°
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.040)
0.1
(.0039)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159
147°
65.5°
781.6
(47.70)
6.0:1
1 ST L
1R
0.4
(.016)
1.00
(.040)
0.13
(.0051)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159
147°
63.5°
78.2
(3.08)
951.2
(58.05)
6.0:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
88.00
(3.46)
78.2
(3.08)
951.2
(58.05)
6.0:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
947 DI
88.00
(3.46)
78.2
(3.08)
951.2
(58.05)
6.0:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
947 DI
88.00
(3.46)
78.2
(3.08)
951.2
(58.05)
6.0:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.22
(.0087)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
mm
(in/po)
cm³
(in³/po³ )
717
82.00
(3.23)
68.0
(2.68)
718.2
(43.82)
GTI LE
(6102/6101)
717
82.00
(3.23)
68.0
(2.68)
718.2
(43.82)
GTI LE RFI
(6104/6103)
787 RFI
82.00
(3.23)
74.0
(2.91)
GTX DI
(6118/6119)
947 DI
88.00
(3.46)
LRV DI
(5771)
947 DI
RX DI
(6123/6122)
XP DI
(6131/6130)
GTI
(5568/5598/
5597/5567)
22
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
ROTARY VALVE
TIMING
RÉGLAGE DE LA
VALVE ROTATIVE
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
N/U
mm
(in/po)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
STROKE
COURSE
mm
(in/po)
BORE
ALÉSAGE
N/U
mm
(in/po)
ENGINE
MOTEUR
N/U
mm
(in/po)
mm
(in/po)
2003
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
2 Stroke Engines/Moteurs 2-temps
23
INTAKE VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ADMISSION➃
EXHAUST VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ÉCHAPPEMENT➃
1493.8
(58.81)
10.6:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/5°
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
10.6:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(0.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/5°
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
8.1:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/0°
1503
3
12
100
(3.94)
63.4
(2.5)
1493.8
(58.81)
8.1:1
1R
1 T.F.
1 O.S.
1.5
(.060)
0.04
(.002)
0.1
(.004)
0.1
(.0039)
0.015
(.0006)
10°/45°
50°/0°
STROKE
COURSE
COMPRESSION RATIO
TAUX DE COMPRESSION
BORE
ALÉSAGE
GTX 4-TEC
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
24
Smt2004-001c_moteur.fm
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
63.4
(2.5)
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
100
(3.94)
cm³
(in³/
po³ )
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/CYLINDRE
12
mm
(in/po)
RING END GAP (MAX.)
OUVERTURE
DU SEGMENT (MAX.)
3
mm
(in/po)
RING TYPE
TYPE DE SEGMENT
1503
DISPLACEMENT
CYLINDRÉE
NUMBER OF VALVES
NOMBRE DE SOUPAPES
GTX 4-TEC
(6111/6112/
6127)
NUMBER OF CYLINDER
NOMBRE DE CYLINDRES
2003
ENGINE
MOTEUR
4-TEC Engines/Moteurs 4-TEC
mm
(in/po)
N/U
mm
(in/po)
mm
(in/po)
mm
(in/po)
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
25
GTX 4-TEC
(6111/6112/
6127)
Wear limit mm (in/po)
Limite d’usure mm (in/po)
Wear limit mm (in/po)
Limite d’usure mm (in/po)
mm
(in/po)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.604
(1.2442)
31.385
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.604
(1.2442)
31.385
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.604
(1.2442)
31.385
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
1503
5.930
(.2330)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
43
(1.693)
1.6
(.063)
1.8
(.071)
31.604
(1.2442)
31.385
(1.2356)
0.09
(.0035)
0.08
(.0031)
0.22
(.0087)
148.5
(5.846)
GTX 4-TEC
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
26
CYLINDER HEAD SCREW
(MAXIMUM LENGTH)
VIS DE CULASSE
(LONGUEUR MAXIMALE)
CON. ROD BIG END RADIAL
CLEARANCE
JEU RADIAL DE LA TÊTE
DE LA BIELLE
CRANK. AXIAL CLEARANCE
(MIN./MAX.)
JEU AXIAL (MIN./MAX.) DU
VILEBREQUIN
CAM LOBE (EXHAUST)
LOBE DE CAME
(ÉCHAPPEMENT)
CAM LOBE (INTAKE)
LOBE DE CAME (ADMISSION)
VALVE SEAT CONTACT
(EXHAUST)
CONTACT DE SIÈGE DE
SOUPAPE (ÉCHAPPEMENT)
VALVE SEAT CONTACT
(INTAKE)
CONTACT DE SIÈGE DE
SOUPAPE (ADMISSION)
VALVE SPRING FREE
LENGTH (INNER)
LONGUEUR LIBRE DU RESSORT
DE SOUPAPE (INTÉRIEUR)
VALVE SPRING FREE
LENGTH (OUTER)
LONGUEUR LIBRE DU RESSORT
DE SOUPAPE (EXTÉRIEUR)
VALVE GUIDE DIAMETER
DIAMÈTRE DU GUIDE DE
SOUPAPE
EXHAUST VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ÉCHAPPEMENT
INTAKE VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ADMISSION
ENGINE
MOTEUR
2003
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
27
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
ROTARY VALVE
TIMING AND
P/N 420 924 XXX
RÉGLAGE DE LA
VALVE ROTATIVE ET
N/P 420 924 XXX
RING END GAP
OUVERTURE
DU SEGMENT
N/U
mm
(in/po)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
718.2
(43.8)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.55
(.0216)1
.10
(.043)
0.120
(.0047)
0.220
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.55
(.0216)1
.10
(.043)
0.120
(.0047)
0.220
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
787
82
(3.228)
74
(2.91)
781.6
(47.7)
6.0:1
1 STL
1R
0.40
(.0156)
1.00
(.039)
0.130
(.0051)
0.220
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159°
147°
63.5°
502 ➀
XP
(5577/5578)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)1
.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
RX
(5579/5580)
(5581/5582)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)1
.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
GTX
(5587/5588)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)1
.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
947 DI
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.55
(.0216)1
.10
(.043)
0.120
(.0047)
0.220
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
mm
(in/po)
mm
(in/po)
cm³
(in³/po³ )
717
82
(3.228)
68
(2.68)
718.2
(43.8)
GTI LE
(5560/5561)
717
82
(3.228)
68
(2.68)
718.2
(43.8)
GTI California
GTI LE
California
(6116/6117)
717
82
(3.228)
68
(2.68)
GTX DI
(5563/5564)
(5595/5596)
947 DI
88
(3.46)
LRV DI
(5460)
947 DI
GTX RFI
(5565/5566)
2002
GTI
(5558/5559)
28
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
RING TYPE
SEGMENT DE PISTON
mm
(in/po)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
STROKE
COURSE
N/U
mm
(in/po)
BORE
ALÉSAGE
N/U
mm
(in/po)
ENGINE
MOTEUR
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
2 Stroke Engines/Moteurs 2-temps
opening/
closing➃
ouverture/
fermeture➃
29
NUMBER OF CYLINDER
NOMBRE DE CYLINDRES
NUMBER OF VALVES
NOMBRE DE SOUPAPES
GTX 4-TEC
(5573/5574)
(5593/5594)
1503
3
12
2002
GTX 4-TEC
(5573/5574)
(5593/5594)
1503
30
5.930
(.2330)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
cm³
(in³/
po³ )
100
(3.9)
63.4
(2.49)
1493.8
(58.81)
5.930
(.2330)
6.060
(.2386)
38.8
(1.499)
VALVE GUIDE DIAMETER
DIAMÈTRE DU GUIDE DE
SOUPAPE
VALVE SPRING FREE
LENGTH (INNER)
LONGUEUR LIBRE DU RESSORT DE SOUPAPE (INTÉ-
43
(1.693)
1.6
(.063)
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
Wear limit mm (in/po)
Limite d’usure mm (in/po)
1.8
(.071)
Smt2004-001c_moteur.fm
31.430
(1.2374)
31.650
(1.2461)
mm
(in/po)
mm
(in/po)
1.5
(0.060)
0.04
(.001)
0.100
(.004)
0.03
(.0011)
0.008
(.0003)
0.09
(.0035)
EXHAUST VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ÉCHAPPEMENT➃
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
N/U
mm
(in/po)
INTAKE VALVE OPENING/
CLOSING➃
OUVERTURE/FERMETURE
SOUPAPE D’ADMISSION➃
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
mm
(in/po)
Wear limit mm (in/po)
Limite d’usure mm (in/po)
0.08
(.0031)
0.22
(.0087)
CYLINDER HEAD SCREW
(MAXIMUM LENGTH)
VIS DE CULASSE
(LONGUEUR MAXIMALE)
CON. ROD BIG END RADIAL
CLEARANCE
JEU RADIAL DE LA TÊTE
DE LA BIELLE
CRANK. AXIAL CLEARANCE
(MIN./MAX.)
JEU AXIAL (MIN./MAX.) DU
VILEBREQUIN
CAM LOBE (EXHAUST)
LOBE DE CAME
(ÉCHAPPEMENT)
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/CYLINDRE
RING TYPE
TYPE DE SEGMENT
RING END GAP (MAX.)
OUVERTURE
DU SEGMENT (MAX.)
1R
1 T.F.
1 O.S.
CAM LOBE (INTAKE)
LOBE DE CAME (ADMISSION)
10.6:1
VALVE SEAT CONTACT
(EXHAUST)
CONTACT DE SIÈGE DE
SOUPAPE (ÉCHAPPEMENT)
VALVE SEAT CONTACT
(INTAKE)
CONTACT DE SIÈGE DE
SOUPAPE (ADMISSION)
COMPRESSION RATIO
TAUX DE COMPRESSION
STROKE
COURSE
mm
(in/
po)
VALVE SPRING FREE
LENGTH (OUTER)
LONGUEUR LIBRE DU RESSORT
DE SOUPAPE (EXTÉRIEUR)
BORE
ALÉSAGE
EXHAUST VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ÉCHAPPEMENT
ENGINE
MOTEUR
INTAKE VALVE STEM
DIAMETER
DIAMÈTRE DE LA TIGE DE LA
SOUPAPE D’ADMISSION
2002
ENGINE
MOTEUR
4-TEC Engines/Moteurs 4-TEC
10°/45°
50°/5°
mm
(in/po)
148.5
(5.846)
31
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
ROTARY VALVE
TIMING AND
P/N 420 924 XXX
RÉGLAGE DE LA
VALVE ROTATIVE ET
N/P 420 924 XXX
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
781.6
(47.7)
6.0:1
1 STL
1R
0.40
(.0156)
1.00
(.039)
0.130
(.0051)
0.220
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159°
147°
63.5°
502 ➀
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
717
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
GTI
(5522 ➁/
5523 ➂)
717
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
0.25
(.010)
1.00
(.039)
0.100
(.0039)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.311
(.012)
1.2
(.047)
159°
147°
65.5°
502 ➀
GTX RFI
(5524/5525/
5553/5555)
787
82
(3.228)
74
(2.91)
781.6
(47.7)
6.0:1
1 STL
1R
0.40
(.0156)
1.00
(.039)
0.130
(.0051)
0.220
(.0087)
0.100
(.004)
0.080
(.003)
0.230
(.009)
1.2
(.047)
159°
147°
63.5°
502 ➀
GTX
(5526/5527/
5538/5539)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
717
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
GS
(5518 ➁/
5519 ➂)
717
82
(3.228)
68
(2.68)
718.2
(43.8)
GSX RFI
Inter.
First Series/
Première
série
(5549)
787
82
(3.228)
74
(2.91)
GTS Inter.
First Series/
Première
série
(5551)
717
82
(3.228)
GTS
(5520 ➁/
5521 ➂)
717
GTI Inter.
First Series/
Première
série
(5552)
GS Inter.
First Series/
Première
série
(5548)
32
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
cm³
(in³/po³ )
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
RING END GAP
OUVERTURE
DU SEGMENT
1 ST
1R
mm
(in/po)
RING TYPE
SEGMENT DE PISTON
N/U
mm
(in/po)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
STROKE
COURSE
mm
(in/po)
BORE
ALÉSAGE
N/U
mm
(in/po)
ENGINE
MOTEUR
N/U
mm
(in/po)
mm
(in/po)
2001
opening/
closing➃
ouverture/
fermeture➃
33
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
0.45
(.0177)
1.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
6.1:1
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
951.2
(58)
6.1:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.55
(.022)
1.1
(.043)
0.12
(.0047)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.390
(.015)
1.2
(.047)
N.A./
S.O.
N.A./
S.O.
947
88
(3.46)
78.2
(3.08)
951.2
(58)
RX
(5532/5533/
5542/5543)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
RX DI
(5534/5535/
5536/5537)
947
88
(3.46)
78.2
(3.08)
GTX DI
(5528/5529/
5540/5541)
947
88
(3.46)
LRV
(5697)
947
88
(3.46)
34
ROTARY VALVE
TIMING AND
P/N 420 924 XXX
RÉGLAGE DE LA
VALVE ROTATIVE ET
N/P 420 924 XXX
RING END GAP
OUVERTURE
DU SEGMENT
1 ST
1 ST
cm³
(in³/po³ )
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
RING TYPE
SEGMENT DE PISTON
6.1:1
mm
(in/po)
XP
(5530/5531)
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
N/U
mm
(in/po)
DISPLACEMENT
CYLINDRÉE
mm
(in/po)
STROKE
COURSE
mm
(in/po)
BORE
ALÉSAGE
N/U
mm
(in/po)
ENGINE
MOTEUR
N/U
mm
(in/po)
mm
(in/po)
2001
opening/
closing➃
ouverture/
fermeture➃
35
6.2:1
1 ST
1R
GSX RFI
(5645/5654)
787
82
(3.228)
74
(2.91)
781.6
(47.7)
6.0:1
1 STL
1R
GTS Inter.
(5639)
717
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
GTI
(5647/5657)
717
82
(3.228)
68
(2.68)
718.2
(43.8)
6.2:1
1 ST
1R
GTX RFI
(5648/5658/
5515/5516)
787
82
(3.228)
74
(2.91)
781.6
(47.7)
6.0:1
1 STL
1R
GTX
(5653/5669)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
XP
(5651/5655)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
RX
(5513/5514)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
RX DI
(5646/5656)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
1 ST
1 ST
GTX DI
(5649/5659)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
LRV
(5688)
947
88
(3.46)
78.2
(3.08)
951.2
(58)
6.1:1
36
mm
(in/po)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.100
(.004)
0.080
(.003)
0.12
(.0047)
0.2
(.0079)
0.100
(.004)
0.080
(.003)
0.090
(.0035)
0.200
(.008)
0.100
(.004)
0.080
(.003)
0.25
(.010)
1.00
(.039)
0.40
(.0156)
1.00
(.039)
0.25
(.010)
1.00
(.039)
0.25
(.010)
1.00
(.039)
0.40
(.0156)
1.00
(.039)
0.45
(.0177)
1.00
(.039)
0.55
(.022)
1.1
(.043)
0.100
(.0039)
0.200
(.008)
0.130
(.0051)
0.220
(.0087)
0.100
(.0039)
0.200
(.008)
0.100
(.0039)
0.200
(.008)
0.130
(.0051)
0.220
(.0087)
0.090
(.0035)
0.200
(.008)
0.090
(.0035)
0.200
(.008)
0.090
(.0035)
0.200
(.008)
0.12
(.0047)
0.2
(.0079)
1 ST
1 ST
0.55
(.022)
1.1
(.043)
1 ST
1 ST
0.45
(.0177)
1.00
(.039)
Smt2004-001c_moteur.fm
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
N/U
mm
(in/po)
0.311
(.012)
1.2
(.047)
0.230
(.009)
1.2
(.047)
0.311
(.012)
1.2
(.047)
0.311
(.012)
1.2
(.047)
0.230
(.009)
1.2
(.047)
0.390
(.015)
1.2
(.047)
0.390
(.015)
1.2
(.047)
0.390
(.015)
1.2
(.047)
0.390
(.015)
1.2
(.047)
0.390
(.015)
1.2
(.047)
0.390
(.015)
1.2
(.047)
ROTARY VALVE
TIMING AND
P/N 420 924 XXX
RÉGLAGE DE LA
VALVE ROTATIVE ET
N/P 420 924 XXX
718.2
(43.8)
mm
(in/po)
ROTARY VALVE OPENING
OUVERTURE DE LA
VALVE ROTATIVE
68
(2.68)
N/U
mm
(in/po)
N/U
mm
(in/po)
CONNECTING ROD
BIG END AXIAL PLAY
JEU AXIAL DE
LA TÊTE DE BIELLE
RING TYPE
SEGMENT DE PISTON
82
(3.228)
CYLINDER OUT OF
ROUND (MAX.)
OVALISATION DU
CYLINDRE (MAX.)
COMPRESSION RATIO
(CORRECTED)
TAUX DE COMPRESSION
(CORRIGÉ)
717
GS
(5644/5827)
CYLINDER TAPER
(MAX.)
CONICITÉ DU
CYLINDRE (MAX.)
DISPLACEMENT
CYLINDRÉE
cm³
(in³/po³ )
PISTON /CYLINDER
WALL CLEARANCE
JEU PISTON/
CYLINDRE
STROKE
COURSE
mm
(in/po)
RING END GAP
OUVERTURE
DU SEGMENT
BORE
ALÉSAGE
ENGINE
MOTEUR
mm
(in/po)
2000
opening/
closing➃
ouverture/
fermeture➃
159°
147°
65.5°
502 ➀
159°
147°
63.5°
502 ➀
159°
147°
65.5°
502 ➀
159°
147°
65.5°
502 ➀
159°
147°
63.5°
502 ➀
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
37
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
ENGINE
MOTEUR
ABBREVIATIONS
ABRÉVIATIONS
➀ 0.25 - 0.35 mm (.010 -.011 in) for rotary valve/cover clearance.
➀ 0.25 - 0.35 mm (.010 -.011 po) pour jeu couvercle/valve rotative.
➁ International Model. (second series)
➁ Modèle international. (deuxième série)
➂ Complete North America Series
➂ Série complète Amérique du Nord
➃ Opening: Before top deand center/Closing: After top dead center
➃ Ouverture: avant le point mort haut/Fermeture: après le point mort haut
ST: Semi-Trapez
ST: Semi-trapèze
STL: Semi-Trapez L
STL: Semi-trapèze en L
R: Rectangular
R: Rectangulaire
T.F.: Tapered Face
Face conique
O.S.: Oil Scraper
Racleur
P/N: Part Number
N/P: Numéro de pièce
N.A.: Not Applicable
S.O.: Sans objet
N/U: New/Used
N/U: Neuf/Usagé
38
Smt2004-001c_moteur.fm
www.SeaDooManuals.net
Smt2004-001c_moteur.fm
SECTION CONTENTS
CONTENU DE LA SECTION
CARBURETION
CARBURATION
PAGE
PAGE
CARBURETOR
CARBURATEUR........
40
– Carburetor
– Carburateur
– Fuel
– Carburant
– Quantity
– Quantité
– Min. Fuel Octane
– Indice d’octane min.
– Fuel
– Carburant
– Fuel Pressure
– Pression d’essence
– Minimum Fuel Octane
– Indice d’octane minimum
– Idle Speed
– Vitesse de ralenti
– Main Jet
– Gicleur principal
– Pilot Jet
– Gicleur de ralenti
– Sensors (TPS, CPS, CAPS,
MATS, CTS, EGTS, MAPS, KS)
– Capteurs (CPA, CPV, CPAC,
STAC, STE, STGE, SPAC,
DD)
– Low Speed Screw
– Vis de bas régime
– TOPS Valve
– Interrupteur TOPS
– High Speed Screw
– Vis de haut régime
– Rave Solenoid
– Solénoïde Rave
– Idle Speed (in water)
– Ralenti (dans l’eau)
– Fuel Injector
– Injecteur d’essence
– Idle Speed (out of water)
– Ralenti (hors de l’eau)
– Direct Injector
– Injecteur direct
– Fuel Return Line Orifice
– Orifice de conduit de retour
de carburant
ABBREVIATIONS
ABRÉVIATIONS........
62
– Pop Off Pressure
– Pression de détente
MAIN JET
GICLEUR
PRINCIPAL................
63
PILOT JET
GICLEUR
DE RALENTI .............
63
INJECTORS AND SENSORS
INJECTEURS ET
CAPTEURS................ 42
Smt2004-001d_carburateur.fm
– Fuel Injection Type
– Type d’injecteur de
carburant
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
39
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
POP OFF PRESSURE
PRESSION
DE DÉTENTE
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
± 1/4
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
➀
2004
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
MAIN JET
GICLEUR PRINCIPAL
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
FUEL
CARBURANT
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
Carburetors/Carburateurs
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)
(lb/po²)
GTI
(6133/6134)
Mikuni ➁
BN-40i-38-48
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans
plomb
87
167.5
75
1.0 ± 0.25
0
1500
3000
0.8
36-40
GTI LE
(6135/6136)
Mikuni ➁
BN-40i-38-48
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans
plomb
87
167.5
75
1.0 ± 0.25
0
1500
3000
0.8
36-40
40
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
Smt2004-001d_carburateur.fm
41
FUEL PRESSURE
PRESSION D’ESSENCE
IDLE SPEED
VITESSE DE RALENTI
TPS
CPA
CPS
CPV
CAPS
CPAC
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
TOPS VALVE
INTERRUPTEUR TOPS
RAVE SOLENOID
SOLÉNOÏDE RAVE
FUEL INJECTOR
INJECTEUR D’ESSENCE
DIRECT INJECTOR
INJECTEUR DIRECT
2004
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
Injectors and Sensors/Injecteurs et capteurs
➀
kPa
(PSI)/
(lb/po2)
RPM
tr/mn
kΩ
Ω
kΩ
kΩ
kΩ
Ω
kΩ
MΩ
Ω
Ω
Ω
Ω
3D RFI
(6157/6158)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1550
1.6 2.4
774 946
N.A./
S.O.
2.28
2.74
2.28
2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
N.A./
S.O.
30
2.4
N.A./
S.O.
GTI RFI
(6137/6138)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1550
1.6 2.4
774 946
N.A./
S.O.
2.28
2.74
2.28
2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
N.A./
S.O.
30
2.4
N.A./
S.O.
GTI RFI LE
(6139/6140)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1550
1.6 2.4
774 946
N.A./
S.O.
2.28
2.74
2.28
2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
N.A./
S.O.
30
2.4
N.A./
S.O.
XP DI
(6151/6152)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./
S.O.
2.28
2.74
2.28
2.74
2.28 2.74
0
5
N.A./
S.O.
24
1.8
1.3
GTX 4-TEC
(6147/6148)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
0
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
0
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
GTX 4-TEC
Supercharged
(6143/6144)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
0
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
GTX 4-TEC
Limited
Supercharged
(6141/6142)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
0
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
42
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
43
44
2003
Smt2004-001d_carburateur.fm
➀
www.SeaDooManuals.net
Smt2004-001d_carburateur.fm
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
POP OFF PRESSURE
PRESSION
DE DÉTENTE
± 1/4
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
MAIN JET
GICLEUR PRINCIPAL
IDLE SPEED
VITESSE DE RALENTI
TPS
CPA
CPS
CPV
CAPS
CPAC
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
TOPS VALVE
INTERRUPTEUR TOPS
RAVE SOLENOID
SOLÉNOÏDE RAVE
FUEL INJECTOR
INJECTEUR D’ESSENCE
DIRECT INJECTOR
INJECTEUR DIRECT
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
FUEL PRESSURE
PRESSION D’ESSENCE
Premium
Unleaded/
Super
sans
plomb
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
2004
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
FUEL
CARBURANT
RXP 4-TEC
(5599/6115/
6162/6163)
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
(CONTD/SUITE)
➀
kPa
(PSI)/
(lb/po2)
RPM
tr/mn
kΩ
Ω
kΩ
kΩ
kΩ
Ω
kΩ
MΩ
Ω
Ω
Ω
Ω
91
399
(58)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
0
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
Carburetors/Carburateurs
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)
(lb/po²)
GTI
(5568/5598/
5597/5567)
Mikuni ➁
BN-40i-38-48
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1.0 ± 0.25
0
1500
3000
0.8
36-40
GTI LE
(6102/6101)
Mikuni ➁
BN-40i-38-48
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1.0 ± 0.25
0
1500
3000
0.8
36-40
45
CAPS
CPAC
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
kΩ
Ω
kΩ
kΩ
kΩ
Ω
kΩ
MΩ
DIRECT INJECTOR
INJECTEUR DIRECT
CPS
CPV
RPM
tr/mn
FUEL INJECTOR
INJECTEUR D’ESSENCE
TPS
CPA
kPa
(PSI)/
(lb/po2)
RAVE SOLENOID
SOLÉNOÏDE RAVE
IDLE SPEED
VITESSE DE RALENTI
➀
TOPS VALVE
INTERRUPTEUR TOPS
FUEL PRESSURE
PRESSION D’ESSENCE
2003
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
Injectors and Sensors/Injecteurs et capteurs
Ω
Ω
Ω
Ω
N.A./ 2.28 - 2.28 - N.A./ 5.8 (3-2) N.A./ N.A./
S.O. 2.74 2.74 S.O. 5.3 (1-2) S.O. S.O.
30
2.4
N.A./
S.O.
GTI LE RFI
(6104/6103)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1550
1.6 2.4
774 946
GTX DI
(6118/6119)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./ 2.28 - 2.28 - 2.28 S.O. 2.74 2.74 2.74
0
5
N.A./
S.O.
24
1.8
1.3
LRV DI
(5771)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./ 2.28 - 2.28 - 2.28 S.O. 2.74 2.74 2.74
0
5
N.A./
S.O.
24
1.8
1.3
RX DI
(6123/6122)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./ 2.28 - 2.28 - 2.28 S.O. 2.74 2.74 2.74
0
5
N.A./
S.O.
24
1.8
1.3
XP DI
(6131/6130)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./ 2.28 - 2.28 - 2.28 S.O. 2.74 2.74 2.74
0
5
N.A./
S.O.
24
1.8
1.3
GTX 4-TEC
(6111/6112/
6127)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28 - 2.28 - 2.28 2.74 2.74 2.74
0
5
1.27 - N.A./
2.47 S.O.
12
N.A./
S.O.
GTX 4-TEC
VANS
TRIPLE
CROWN
EDITION
(6125/6126)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28 - 2.28 - 2.28 2.74 2.74 2.74
0
5
1.27 - N.A./
2.47 S.O.
12
N.A./
S.O.
GTX 4-TEC
Supercharged
(6105/6106/
6128/6129)
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28 - 2.28 - 2.28 2.74 2.74 2.74
0
5
1.27 - N.A./
2.47 S.O.
12
N.A./
S.O.
46
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
47
48
kΩ
kΩ
91
303
(43.5)
1800
1.6 2.4
190290
1.2
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
Ω
kΩ
MΩ
Ω
0
5
2.28 - 2.28 - 2.28 2.74 2.74 2.74
Smt2004-001d_carburateur.fm
DIRECT INJECTOR
INJECTEUR DIRECT
kΩ
FUEL INJECTOR
INJECTEUR D’ESSENCE
Ω
RAVE SOLENOID
SOLÉNOÏDE RAVE
CTS
STE
kΩ
TOPS VALVE
INTERRUPTEUR TOPS
MATS
STAC
RPM
tr/mn
KS
DD
CAPS
CPAC
kPa
(PSI)/
(lb/po2)
MAPS
SPAC
CPS
CPV
➀
EGTS
STGE
TPS
CPA
Premium
Unleaded/
Super
sans
plomb
IDLE SPEED
VITESSE DE RALENTI
DELLORTO
52 mm
Throttle body/
Boîtier de
papillon
FUEL PRESSURE
PRESSION D’ESSENCE
GTX 4-TEC
Supercharged
LIMITED
(6107/6108)
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
2003
Ω
Ω
Ω
12
N.A./
S.O.
1.27 - N.A./
2.47 S.O.
49
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
POP OFF PRESSURE
PRESSION
DE DÉTENTE
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
± 1/4
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
➀
2002
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
MAIN JET
GICLEUR PRINCIPAL
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
FUEL
CARBURANT
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
Carburetors/Carburateurs
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)
(lb/po²)
GTI
(5558/5559)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTI LE
(5560/5561)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTI
California
GTI LE
California
(6116/6117)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
N.A./
S.O.
N.A./
S.O.
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
XP
(5577/5578)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1.5
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
RX
(5579/5580)
(5581/5582)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1.5
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
GTX
(5587/5588)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
50
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
51
FUEL PRESSURE
PRESSION D’ESSENCE
IDLE SPEED
VITESSE DE RALENTI
TPS
CPA
CPS
CPV
CAPS
CPAC
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
TOPS VALVE
INTERRUPTEUR TOPS
RAVE SOLENOID
SOLÉNOÏDE RAVE
FUEL INJECTOR
INJECTEUR D’ESSENCE
DIRECT INJECTOR
INJECTEUR DIRECT
2002
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
Injectors and Sensors/Injecteurs et capteurs
➀
kPa
(PSI)/
(lb/po2)
RPM
tr/mn
kΩ
Ω
kΩ
kΩ
kΩ
Ω
kΩ
MΩ
Ω
Ω
Ω
Ω
GTX RFI
(5565/5566)
SU
Automotive
56 mm
Throttle
body/Boîtier
de papillon
Regular
Unleaded/
Ordinaire
sans plomb
87
399
(58)
1500
1.6 2.4
774 946
N.A./
S.O.
2.28
2.74
2.28
2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
N.A./
S.O.
30
2.4
N.A./
S.O.
GTX DI
(5563/5564)
(5595/5596)
SU
Automotive
46 mm
46 mm
Throttle
body/Boîtier
de papillon
Regular
Unleaded/
Ordinaire
sans plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./
S.O.
2.28
2.74
2.28
2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
N.A./
S.O.
24
1.8
1.3
SU
Automotive
46 mm
46 mm
Throttle
body/Boîtier
de papillon
Regular
Unleaded/
Ordinaire
sans plomb
87
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./
S.O.
2.28
2.74
2.28
2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
N.A./
S.O.
24
1.8
1.3
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
SU
Automotive
46 mm
46 mm
Throttle
body/Boîtier
de papillon
Regular
Unleaded/
Ordinaire
sans plomb
Premium
Unleaded/
Super sans
plomb
(International)
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
N.A./
S.O.
2.28
2.74
2.28
2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
N.A./
S.O.
24
1.8
1.3
GTX 4-TEC
(5573/5574)
(5593/5594)
DELLORTO
52 mm
Throttle
body/Boîtier
de papillon
Premium
Unleaded/
Super sans
plomb
303
(43.5)
1800
1.6 2.4
190290
1.2
2.28
2.74
2.28
2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
1.27 2.47
N.A./
S.O.
12
N.A./
S.O.
LRV DI
(5460)
52
87
91
(inter)
91
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
53
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
POP OFF PRESSURE
PRESSION
DE DÉTENTE
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
± 1/4
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
➀
2001
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
MAIN JET
GICLEUR PRINCIPAL
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
FUEL
CARBURANT
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
Carburetors/Carburateurs
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)/
(lb/po2)
GS Inter.
First Series/
Première
série
(5548)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GS
(5518 ➂/
5519 ➃)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTS Inter.
First Series/
Première
série
(5551)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTS
(5520 ➂/
5521 ➃)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTI Inter.
First Series/
Première
série
(5552)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTI
(5522 ➂/
5523 ➃)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTX
(5526/5527/
5538/5539)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
XP
(5530/5531)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
RX
(5532/5533/
5542/5543)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
54
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
55
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
POP OFF PRESSURE
PRESSION
DE DÉTENTE
Regular
Unleaded/
Ordinaire
sans plomb
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
2
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
LRV
(5697)
MAIN JET
GICLEUR PRINCIPAL
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
FUEL
CARBURANT
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
➀
2001
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)/
(lb/po2)
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
± 1/4
87
162.5
75
1-1/2
0
TPS
CPA
CPS
CPV
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
RAVE SOLENOID
SOLÉNOÏDE RAVE
FUEL INJECTOR
INJECTEUR D’ESSENCE
DIRECT INJECTOR
INJECTEUR DIRECT
➀
kPa
(PSI)/
(lb/po2)
RPM
tr/mn
kΩ
Ω
kΩ
kΩ
Ω
kΩ
MΩ
Ω
Ω
Ω
IDLE SPEED
VITESSE DE RALENTI
FUEL PRESSURE
PRESSION D’ESSENCE
2001
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
Injectors and Sensors/Injecteurs et capteurs
GSX RFI
Inter.
First Series/
Première
série (5549)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded
/Ordinaire
sans
plomb
87
399
(58)
1500
1.6 2.4
774 946
2.28 2.74
2.28 2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
30
2.4
N.A./
S.O.
GTX RFI
(5524/5525/
5553/5555)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded
/Ordinaire
sans
plomb
87
399
(58)
1500
1.6 2.4
774 946
2.28 2.74
2.28 2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
30
2.4
N.A./
S.O.
GTX DI
(5528/5529/
5540/5541)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded
/Super
sans
plomb
91
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
2.28 2.74
2.28 2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
24
1.8
1.3
RX DI
(5534/5535/
5536/5537)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded
/Super
sans
plomb
91
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall)
2.28 2.74
2.28 2.74
2.28 2.74
5.8
(3-2)
5.3
(1-2)
5
24
1.8
1.3
56
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
57
IDLE SPEED
(OUT OF WATER)
RALENTI
(HORS DE L’EAU)
FUEL RETURN LINE
ORIFICE
ORIFICE DE CONDUIT
DE RETOUR DE
CARBURANT
POP OFF PRESSURE
PRESSION
DE DÉTENTE
HIGH SPEED SCREW
VIS DE HAUT RÉGIME
± 1/4
IDLE SPEED
(IN WATER)
RALENTI
(DANS L’EAU)
➀
2000
LOW SPEED SCREW
VIS DE BAS RÉGIME
PILOT JET
GICLEUR DE RALENTI
MAIN JET
GICLEUR PRINCIPAL
MINIMUM FUEL
OCTANE
INDICE D’OCTANE
MINIMUM
FUEL
CARBURANT
QUANTITY
QUANTITÉ
CARBURETOR
CARBURATEUR
Carburetors/Carburateurs
RPM
tr/mn
RPM
tr/mn
mm
(in/po)
kPa
(PSI)
(lb/po²)
GS
(5644/5827)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTS Inter.
(5639)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTI
(5647/5657)
MIKUNI ➁
BN-40i-38
(Diaphragm/
Diaphragme)
1
Regular
Unleaded/
Ordinaire
sans plomb
87
167.5
75
1
0
1500
3000
0.8
(.031)
248 - 275
(36 - 40)
GTX
(5653/5669)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
XP
(5651/5655)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
RX
(5513/5514)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
LRV
(5688)
MIKUNI ➁
BN-46i-42
(Diaphragm/
Diaphragme)
2
Regular
Unleaded/
Ordinaire
sans plomb
87
162.5
75
1-1/2
0
1400
3000
0.8
(.031)
130 - 159
(19 - 23)
58
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
59
FUEL PRESSURE
PRESSION D’ESSENCE
IDLE SPEED
VITESSE DE RALENTI
TPS
CPA
CPS
CPV
MATS
STAC
CTS
STE
EGTS
STGE
MAPS
SPAC
KS
DD
RAVE SOLENOID
SOLÉNOÏDE RAVE
FUEL INJECTOR
INJECTEUR D’ESSENCE
DIRECT INJECTOR
INJECTEUR DIRECT
2000
MIN. FUEL OCTANE
INDICE D’OCTANE MIN.
FUEL
CARBURANT
FUEL INJECTION TYPE
TYPE D’INJECTEUR DE
CARBURANT
Injectors and Sensors/Injecteurs et capteurs
➀
kPa
(PSI)/
(lb/po2)
RPM
tr/mn
kΩ
Ω
kΩ
kΩ
Ω
kΩ
MΩ
Ω
Ω
Ω
GSX RFI
(5645/
5654)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1500
1.6 2.4
774 946
2.28 2.74
2.28 2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
30
2.4
N.A./
S.O.
GTX RFI
(5648/5658/
5515/5516)
SU Automotive
56 mm
Throttle body/
Boîtier de
papillon
Regular
Unleaded/
Ordinaire
sans
plomb
87
399
(58)
1500
1.6 2.4
774 946
2.28 2.74
2.28 2.74
N.A./
S.O.
5.8
(3-2)
5.3
(1-2)
N.A./
S.O.
30
2.4
N.A./
S.O.
GTX DI
(5649/
5659)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall))
2.28 2.74
2.28 2.74
2.28 2.74
0
5
24
1.8
1.3
RX DI
(5646/
5656)
SU Automotive
46 mm 46 mm
Throttle body/
Boîtier de
papillon
Premium
Unleaded/
Super
sans
plomb
91
730
(106)
1450
1.6 2.4
5V
(Hall
effect/
effet
Hall))
2.28 2.74
2.28 2.74
2.28 2.74
0
5
24
1.8
1.3
60
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
61
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
MAIN JET
GICLEUR PRINCIPAL
CARBURETION
CARBURATION
A01C2CQ
ABBREVIATIONS
ABRÉVIATIONS
2000 - 2004
➀ Fuel Octane = (RON + MON)/2
➀ Indice d’octane = (RON + MON)/2
➁ With Fuel Acceleration Pump
➁ Avec une pompe d’accélération
SIZE
DIMENSION
P/N
N/P
162.5
270 500 371
167.5
270 500 392
➂ International Model (second series)
➂ Modèle international (deuxième série)
➃ Complete North America Series
➃ Série complète Amérique du Nord
PILOT JET
GICLEUR DE RALENTI
TPS: Throttle Position Sensor
CPA : Capteur de position d’accélérateur
CPS: Crankshaft Position Sensor
CPV : Capteur de position du vilebrequin
MATS: Manifold Air Temperature Sensor
STAC : Sonde de température du collecteur d’admission
WTS/CTS: Water Temperature Sensor/Coolant Temperature Sensor
STE/STLR : Sonde de température de l’eau/Sonde de température du
liquide de refroidissement
A01C2CQ
EGTS: Exhaust Gaz Temperature Sensor
STGE : Sonde de température des gaz d’échappement
2000 - 2004
MAPS: Manifold Air Pressure Sensor
SPAC : Sonde de pression d’air du collecteur
KS: Knock Sensor
DD : Détecteur de détonation
SIZE
DIMENSION
P/N
N/P
75
270 500 149
N.A.: Not Applicable
S.O.: Sans objet
62
Smt2004-001d_carburateur.fm
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
63
NOTES/NOTES
64
Smt2004-001d_carburateur.fm
www.SeaDooManuals.net
Smt2004-001d_carburateur.fm
SECTION CONTENTS
CONTENU DE LA SECTION
ELECTRICAL SYSTEM
SYSTÈME ÉLECTRIQUE
PAGE
PAGE
ELECTRICAL
ÉLECTRICITÉ.............
66
– Magneto Output
– Puissance de la magnéto
ABBREVIATIONS
ABRÉVIATIONS........
78
SPARK PLUGS
BOUGIES ..................
79
– Ignition
– Allumage
– Spark Plug Number
– Numéro de bougie
– Spark Plug Gap
– Écartement bougie
– Ignition Timing (BTDC)
– Avance à l’allumage
(Av.P.M.H.)
– Generating Coil
– Bobine génératrice
– Charging Coil
– Bobine de charge
– Trigger Coil
– Bobine de déclenchement
– Ignition Coil (primary)
– Bobine d’allumage
(primaire)
– Ignition Coil (secondary)
– Bobine d’allumage
(secondaire)
– Engine Rev Limiter
– Limiteur de régime
– Battery
– Batterie
– Fuse
– Fusible
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
65
BATTERY
BATTERIE
ohm
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
ohm
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
ohm
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
GTI LE
(6135/6136)
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
160 W
CHARGING COIL
BOBINE DE CHARGE
GTI
(6133/6134)
GENERATING COIL
BOBINE GÉNÉRATRICE
①
IGNITION
ALLUMAGE
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
2004
ohm
K ohm
②
RPM
tr/mn
V
(A)
N.A./
S.O.
0.34 - 0.62
9-15
7100 ± 50
12
(19)
0.05 - 0.6
N.A./
S.O.
0.34 - 0.62
9-15
7100 ± 50
12
(19)
mm
(in/po)
Degrees/
Degrés
mm (in/po)
0.4 - 0.5
(.016 - .020)
20° ➂
2.59 (.102)
40 - 76 0.05 - 0.6
0.4 - 0.5
(.016 - .020)
20° ➂
2.59 (.102)
40 - 76
②
CDI/
ADC
NGK
BR8ES
160 W
CDI/
ADC
NGK
BR8ES
3D RFI
(6157/6158)
270 W
Inductive
IN
NGK
BR8ES
0.6 - 0.7
12° ➂
(.024 - .028) 1.02 (0.040)
N.A./
S.O.
0.1 - 1.0
774946
2 x 0.3 -0.6 N.A./S.O.
7200 ± 50
12
(19)
GTI RFI
(6137/6138)
270 W
Inductive
IN
NGK
BR8ES
0.6 - 0.7
12° ➂
(.024 - .028) 1.02 (0.040)
N.A./
S.O.
0.1 - 1.0
774946
2 x 0.3 -0.6 N.A./S.O.
7200 ± 50
12
(19)
GTI RFI LE
(6139/6140)
270 W
Inductive
IN
NGK
BR8ES
0.6 - 0.7
12° ➂
(.024 - .028) 1.02 (0.040)
N.A./
S.O.
0.1 - 1.0
774946
2 x 0.3 -0.6 N.A./S.O.
7200 ± 50
12
(19)
XP DI
(6151/6152)
270 W
Inductive
IN
NGK
ZFR4F
27°
5.39 (.212)
(direct)
N.A./
S.O.
0.1 - 1.0
N.A./
S.O.
0.5 ± 10%
7300 ± 50
12
(19)
GTX 4-TEC
(6147/6148)
360 W
Inductive
IN
NGK
DCPR8E
not
0.7 - 0.8
adjustable/
(.032 - .036)
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
GTX 4-TEC
Wakeboard
Edition (6149/
6150)
360 W
Inductive
IN
NGK
DCPR8E
not
0.7 - 0.8
adjustable/
(.032 - .036)
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
GTX 4-TEC
Supercharged
(6143/6144)
360 W
Inductive
IN
NGK
DCPR8E
not
0.7 - 0.8
adjustable/
(.032 - .036)
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
GTX 4-TEC
Limited
Supercharged
(6141/6142)
360 W
Inductive
IN
NGK
DCPR8E
not
0.7 - 0.8
adjustable/
(.032 - .036)
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
RXP 4-TEC
(5599/6115/
6162/6163)
360 W
Inductive
IN
NGK
DCPR8E
not
0.7 - 0.8
adjustable/
(.032 - .036)
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
8000
12
(30)
66
1.1 (.043)
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
8.5
± 20%
67
BATTERY
BATTERIE
②
RPM
tr/mn
V
(A)
N.A./
S.O.
0.34 - 0.62
9-15
7100 ± 50
12
(19)
0.05 - 0.6
N.A./
S.O.
0.34 - 0.62
9-15
7100 ± 50
12
(19)
N.A./
S.O.
0.1 - 1.0
774946
2 x 0.3 -0.6 N.A./S.O.
27°
5.39 (.212)
(direct)
N.A./
S.O.
0.1 - 1.0
N.A./
S.O.
0.5 ± 10%
8.5
± 20%
7300 ± 50
12
(19)
1.1 (.043)
27°
5.39 (.212)➄
N.A./
S.O.
0.1 - 1.0
N.A./
S.O.
0.5 ± 10%
8.5
± 20%
7300 ± 50
12
(19)
NGK
ZFR4F
1.1 (.043)
27°
5.39 (.212)
(direct)
N.A./
S.O.
0.1 - 1.0
N.A./
S.O.
0.5 ± 10%
8.5
± 20%
7300 ± 50
12
(19)
Inductive
IN
NGK
ZFR4F
1.1 (.043)
27°
5.39 (.212)
(direct)
N.A./
S.O.
0.1 - 1.0
N.A./
S.O.
0.5 ± 10%
8.5
± 20%
7300 ± 50
12
(19)
360 W
Inductive
IN
NGK
DCPR8E
0.7 - 0.8
(.032 .036)
not
adjustable/
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
360 W
Inductive
IN
NGK
DCPR8E
0.7 - 0.8
(.032 .036)
not
adjustable/
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
GTX 4-TEC
SUPERCHARGED 360 W
(6105/6106/
6128/6129)
Inductive
IN
NGK
DCPR8E
0.7 - 0.8
(.032 .036)
not
adjustable/
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
Inductive
IN
NGK
DCPR8E
0.7 - 0.8
(.032 .036)
not
adjustable/
sans
ajustement
N.A./
S.O.
0.1 - 1.0
190290
0.85 - 1.15 9.5 -13.5
7650
12
(30)
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
K ohm
IGNITION
ALLUMAGE
ohm
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
ohm
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
CHARGING COIL
BOBINE DE CHARGE
ohm
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
GENERATING COIL
BOBINE GÉNÉRATRICE
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
ohm
mm
(in/po)
Degrees/
Degrés
mm (in/po)
NGK
BR8ES
0.4 - 0.5
(.016 .020)
20° ➂
2.59 (.102)
40 - 76 0.05 - 0.6
CDI/
ADC
NGK
BR8ES
0.4 - 0.5
(.016 .020)
20° ➂
2.59 (.102)
40 - 76
270 W
Inductive
IN
NGK
BR8ES
0.4 - 0.5
(.016 .020)
12° ➂
1.02 (0.040)
GTX DI
(6118/6119)
270 W
Inductive
IN
NGK
ZFR4F
1.1 (.043)
LRV DI
(5771)
270 W
Inductive
IN
NGK
ZFR4F
RX DI
(6123/6122)
270 W
Inductive
IN
XP DI
(6131/6130)
270 W
GTX 4-TEC
(6111/6112/
6127)
2003
①
GTI
(5568/5598/
5597/5567)
160 W
CDI/
ADC
GTI LE
(6102/6101)
160 W
GTI LE RFI
(6104/6103)
GTX 4-TEC
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
68
360 W
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
②
7200 ± 50
12
(19)
69
GENERATING COIL
BOBINE GÉNÉRATRICE
CHARGING COIL
BOBINE DE CHARGE
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
Degrees/
Degrés
mm (in/po)
ohm
ohm
ohm
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
160 W
(6000)
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
GTX DI
(5563/5564)
(5595/5596)
270 W
(6000)
Inductive
IN
NGK
ZFR4F
1.1
(.043)
LRV DI
(5460)
270 W
(6000)
Inductive
IN
NGK
ZFR4F
GTX RFI
(5565/5566)
270 W
(6000)
Inductive
IN
XP
(5577/5578)
180 W
(6000)
RX
(5579/5580)
(5581/5582)
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
BATTERY
BATTERIE
②
RPM
tr/mn
V
(A)
58
0.34-0.62
9-15
7100 ± 50
12 (19)
0.05-0.6
58
0.34-0.62
9-15
7100 ± 50
12 (19)
40-76
0.05-0.6
58
0.34-0.62
9-15
7100 ± 50
12 (19)
27°
5.39
(.212)➄
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ± 10%
8.5 K
± 20%
7300 ± 50
12 (19)
1.1
(.043)
27°
5.39
(.212)➄
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ± 10%
8.5 K
± 20%
7300 ± 50
12 (19)
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.34-0.62
N.A./
S.O.
7200 ± 50
12 (19)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
GTX
(5587/5588)
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
270 W
(6000)
Inductive
IN
NGK
ZFR4F
1.1
(.043)
27°
5.39
(.212)➄
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ± 10%
8.5 K
± 20%
7300 ± 50
12 (19)
GTX 4-TEC
(5573/5574)
(5593/5594)
360 W
(6000)
Inductive
IN
NGK
DCPR8E
0.7-0.8
(.032.036)
N.A./
S.O.
N.A./
S.O.
0.1-1.0
N.A./
S.O.
1.0 ± 15%
11.5 ±
20%
7650 ± 50
12 (30)
①
GTI
(5558/5559)
160 W
(6000)
CDI/
ADC
GTI LE
(5560/5561)
160 W
(6000)
GTI
California
GTI LE
California
(6116/6117)
70
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
K ohm
IGNITION
ALLUMAGE
ohm
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
mm
(in/po)
2002
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
②
71
GENERATING COIL
BOBINE GÉNÉRATRICE
CHARGING COIL
BOBINE DE CHARGE
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
Degrees/
Degrés
mm (in/po)
ohm
ohm
ohm
NGK
BR8ES
0.4-0.5
(.016 .020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
270 W
(6000)
DI
IN
NGK
BR8ES
0.4-0.5
(.016.020)
12°
1.02 (.040)➄
GTS Inter.
First Series/
Première
série
(5551)
160 W
(6000)
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
GTS
(5520➅/
5521➆)
160 W
(6000)
CDI/
ADC
NGK
BR8ES
GTI Inter.
First Series/
Première
série
(5552)
160 W
(6000)
CDI/
ADC
GTI
(5522➅/
5523➆)
160 W
(6000)
GTX RFI
(5524/5525/
5553/5555)
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
BATTERY
BATTERIE
②
RPM
tr/mn
V
(A)
58
0.34-0.62
9-15
7100 ± 50
12 (19)
0.05-0.6
58
0.34-0.62
9-15
7100 ± 50
12 (19)
N.A./
S.O.
0.1-1.0
774946
0.3-0.6
N.A./
S.O.
7200 ± 50
12 (19)
20° ➂
2.59 (.102)
40-76
0.05-0.6
58
0.34-0.62
9-15
7000 ± 50
12 (19)
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
58
0.34-0.62
9-15
6850 ± 50
12 (19)
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
58
0.34-0.62
9-15
7100 ± 50
12 (19)
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
58
0.34-0.62
9-15
6850 ± 50
12 (19)
270 W
(6000)
DI
IN
NGK
BR8ES
0.4-0.5
(.016.020)
12°
1.02 (.040)➄
N.A./
S.O.
0.1-1.0
774946
0.3-0.6
N.A./
S.O.
7200 ± 50
12 (19)
GTX
(5526/5527/
5538/5539)
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
XP
(5530/5531)
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016 .020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
①
GS Inter.
First Series/
Première
série
(5548)
160 W
(6000)
CDI/
ADC
GS
(5518➅/
5519➆)
160 W
(6000)
GSX RFI
Inter.
First Series/
Première
série
(5549)
72
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
K ohm
IGNITION
ALLUMAGE
ohm
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
mm
(in/po)
2001
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
②
73
0.1-1.0
DI
IN
NGK
ZFR4F
1.1
(.043)
27°
5.39 (.212)➄
N.A./
S.O.
270 W
(6000)
DI
IN
NGK
ZFR4F
1.1
(.043)
27°
5.39 (.212)➄
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
RX DI
(5534/5535/
5536/5537)
270 W
(6000)
GTX DI
(5528/5529/
5540/5541)
LRV
(5697)
Smt2004-001e_electricite.fm
BATTERY
BATTERIE
N.A./
S.O.
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
20° ➃
2.99 (.118)
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
CHARGING COIL
BOBINE DE CHARGE
0.4-0.5
(.016.020)
DC-CDI
ADC-CC
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
GENERATING COIL
BOBINE GÉNÉRATRICE
NGK
BR8ES
180 W
(6000)
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
ohm
RX
(5532/5533/
5542/5543)
74
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
ohm
①
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
ohm
IGNITION
ALLUMAGE
Degrees/
Degrés
mm (in/po)
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
mm
(in/po)
2001
ohm
K ohm
②
RPM
tr/mn
V
(A)
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
0.1-1.0
N.A./
S.O.
0.5 ± 10%
8.5 K
± 20%
7200 ± 50
12 (19)
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ± 10%
8.5 K
± 20%
7200 ± 50
12 (19)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4 - 15.6
7200 ± 50
12 (19)
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
②
75
GENERATING COIL
BOBINE GÉNÉRATRICE
CHARGING COIL
BOBINE DE CHARGE
TRIGGER COIL
BOBINE DE
DÉCLENCHEMENT
SPARK PLUG GAP
ÉCARTEMENT BOUGIE
Degrees/
Degrés
mm (in/po)
ohm
ohm
ohm
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
40-76
0.05-0.6
DI
IN
NGK
BR8ES
0.4-0.5
(.016.020)
12°
1.02 (.040)➄
N.A./
S.O.
160 W
(6000)
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➂
2.59 (.102)
GTI
(5647/5657)
160 W
(6000)
CDI/
ADC
NGK
BR8ES
0.4-0.5
(.016.020)
GTX RFI
(5648/5658/
5515/5516)
270 W
(6000)
DI
IN
NGK
BR8ES
GTX
(5653/5669)
180 W
(6000)
DC-CDI
ADC-CC
XP
(5651/5655)
180 W
(6000)
RX
(5513/5514)
IGNITION COIL
(SECONDARY)
BOBINE D’ALLUMAGE
(SECONDAIRE)
ENGINE REV LIMITER
LIMITEUR DE RÉGIME
BATTERY
BATTERIE
②
RPM
tr/mn
V
(A)
58
0.34-0.62
9-15
7100 ± 50
12 (19)
0.1-1.0
774946
0.3-0.6
N.A./
S.O.
7200 ± 50
12 (19)
40-76
0.05-0.6
58
0.34-0.62
9-15
7000 ± 50
12 (19)
20° ➂
2.59 (.102)
40-76
0.05-0.6
58
0.34-0.62
9-15
7100 ± 50
12 (19)
0.4-0.5
(.016.020)
12°
1.02 (.040)➄
N.A./
S.O.
0.1-1.0
774946
0.3-0.6
N.A./
S.O.
7200 ± 50
12 (19)
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190
300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
180 W
(6000)
DC-CDI
ADC-CC
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
RX DI
(5646/5656)
270 W
(6000)
DI
IN
NGK
ZFR4F
1.1
(.043)
27°
5.39 (.212)➄
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ±10%
8.5 K
± 20%
7200 ± 50
12 (19)
GTX DI
(5649/5659)
270 W
(6000)
DI
IN
NGK
ZFR4F
1.1
(.043)
27°
5.39 (.212)➄
N.A./
S.O.
0.1-1.0
N.A./
S.O.
0.5 ±10%
8.5 K
± 20%
7200 ± 50
12 (19)
NGK
BR8ES
0.4-0.5
(.016.020)
20° ➃
2.99 (.118)
N.A./
S.O.
0.1-1.0
190300
0.33-0.62
8.4-15.6
7200 ± 50
12 (19)
①
GS
(5644/5827)
160 W
(6000)
CDI/
ADC
GSX RFI
(5645/5654)
270 W
(6000)
GTS Inter.
(5639)
LRV
(5688)
76
180 W
(6000)
DC-CDI
ADC-CC
IGNITION TIMING
(BTDC)
AVANCE À
L’ALLUMAGE
(Av.P.M.H.)
K ohm
IGNITION
ALLUMAGE
ohm
MAGNETO OUTPUT
PUISSANCE DE
LA MAGNÉTO
IGNITION COIL
(PRIMARY)
BOBINE D’ALLUMAGE
(PRIMAIRE)
SPARK PLUG NUMBER
NUMÉRO DE BOUGIE
mm
(in/po)
2000
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
②
77
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
SPARK PLUGS
BOUGIES
ELECTRICAL SYSTEM
SYSTÈME ÉLECTRIQUE
F01H01Q
ABBREVIATIONS
ABRÉVIATIONS
At 6000 RPM
À 6000 tr/mn
All resistance measurements must be performed at room
temperature, at approximately 20°C (68°F).
Il est nécessaire de prendre toute mesure de résistance
lorsque les pièces sont à la température ambiante
(approximativement 20°C (68°F)).
NGK SPARK PLUG
BOUGIE NGK
P/N
N/P
BR8ES
278 000 609
ZFR4F
278 001 650
DCPR8E
707 000 246
Engine cold, at 6000 RPM
Moteur froid, à 6000 tr/mn
At 3500 RPM
À 3500 tr/mn
➄ Fuel Pump
➄ Pompe à carburant
➅ Fixed timing mode, at any RPM
➅ Mode calage fixe, à n’importe quel tr/mn
➆ International Model. (second series)
➆ Modèle international. (deuxième série)
➇ Complete North America Series.
➇ Série complète Amérique du Nord.
CDI: Capacitor Discharge Ignition
ADC: Allumage à décharge de condensateur
DC-CDI: Direct Current — Capacitor Discharge Ignition
ADC-CC: Allumage à décharge de condensateur — courant continu
DI: Digital Induction
IN: Induction numérique
BTDC: Before Top Dead Center
Av.P.M.H.: Avant le point mort haut
N.A.: Not Applicable
S.O.: Sans objet
78
Smt2004-001e_electricite.fm
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
79
NOTES/NOTES
80
Smt2004-001e_electricite.fm
www.SeaDooManuals.net
Smt2004-001b_modeles.fm
13
SECTION CONTENTS
CONTENU DE LA SECTION
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
PAGE
PAGE
PROPULSION
PROPULSION............
82
ABBREVIATIONS
ABRÉVIATIONS........ 104
– Propulsion System
– Système de propulsion
– Jet Pump Type
– Type de turbine
– Impeller Rotation
– Rotation de l’hélice
– Transmission
– Transmission
– Coupling
– Accouplement
– Oil Type
– Type d’huile
– Minimum Required Water
Level
– Niveau d’eau minimum
requis
– Drive Shaft Deflection
(maximum)
– Flèche d’arbre de
transmission (maximun)
– Impeller Outside Diameter
– Diamètre extérieur
de l’hélice
– Impeller/Wear Ring Clearance
– Jeu hélice/anneau
– Impeller Shaft End Play
– Jeu axial arbre hélice
– Impeller Shaft Radial Play
– Jeu radial arbre hélice
– Impeller Pitch/Material
– Pas hélice/matériau
Smt2004-001f_propulsion.fm
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
81
82
Direct Drive/
Prise directe
Direct Drive
(split front/rear)/
Prise directe
(séparé avant)/
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
11-20
stainless
steel/
acier
inoxydable
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15-21
stainless
steel/
acier
inoxydable
①
Counterclockwise/
antihoraire
Counterclockwise/
antihoraire
①
Single
Stage/
Monophase
XP DI
(6151/6152)
Single
Stage/
Monophase
GTI RFI
(6137/6138)
Smt2004-001f_propulsion.fm
11-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
11-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
3D RFI
(6157/6158)
Bombardier
Formula
10-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI LE
(6135/6136)
Splines/
Cannelures
Bombardier
Formula
10-20
stainless steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI
(6133/6134)
Rubber Cushion/
Coussinet de
caoutchouc
GTI RFI LE
(6139/6140)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2004
83
84
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.07-0.23
(.003-.009)
0.5
(.020)
0
0.75
(.029)
13-23
stainless
steel/
acier
inoxydable
90
(35)
0.5
(.020)
159.0
(6.260)
0.07-0.23
(.003-.009)
0.5
(.020)
0
0.75
(.029)
10-21
stainless
steel/
acier
inoxydable
➄
Counterclockwise/
antihoraire
Counterclockwise/
antihoraire
➄
Single
Stage/
Monophase
RXP 4-TEC
(5599/6115/
6162/6163)
Single
Stage/
Monophase
GTX 4-TEC
Supercharg
ed (6143/
6144)
Smt2004-001f_propulsion.fm
13-23
stainless
steel/
acier
inoxydable
0.75
(.029)
0
0.07-0.23
(.003-.009)
0.5
(.020)
155.3
(6.126)
0.5
(.020)
90
(35)
➄
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
13-23
stainless
steel/
acier
inoxydable
0.75
(.029)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
➄
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
Splines/
Cannelures
Bombardier
Formula
13-23
stainless
steel/
acier
inoxydable
0.75
(.029)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
➄
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTX 4-TEC
(6147/6148)
Splines/
Cannelures
GTX 4-TEC
Limited
Supercharg
ed (6141/
6142)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2004
85
86
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
11-20°
stainless
steel/
acier
inoxydable
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15-21
stainless
steel/
acier
inoxydable
①
①
90
(35)
Splines/
Cannelures
Splines/
Cannelures
Smt2004-001f_propulsion.fm
15-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
11-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Counterclockwise/
antihoraire
10-20
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
10-20
stainless steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
antihoraire
Direct Drive/ Direct Drive/ Direct Drive/ Direct Drive/ Direct Drive/
Prise directe Prise directe Prise directe Prise directe Prise directe
Counterclockwise/
antihoraire
Counterclockwise/
antihoraire
RX DI
(6123/6122)
Counterclockwise/
antihoraire
LRV DI
(5771)
Counterclockwise/
antihoraire
GTX DI
(6118/6119)
Single
Stage/
Monophase
GTI LE RFI
(6104/6103)
Single
Single
Single
Single
Single
Stage/
Stage/
Stage/
Stage/
Stage/
Monophase Monophase Monophase Monophase Monophase
GTI LE (6102/
6101)
Bombardier
Formula
GTI
(5568/5598/
5597/5567)
Bombardier Bombardier Bombardier Bombardier Bombardier
Formula
Formula
Formula
Formula
Formula
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
mm IMPELLER SHAFT RADIAL PLAY
(in/po) JEU RADIAL ARBRE HÉLICE
mm IMPELLER SHAFT END PLAY
(in/po) JEU AXIAL ARBRE HÉLICE
N /U IMPELLER/WEAR RING
mm CLEARANCE
(in/po) JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
mm
(in/po) DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
mm (MAXIMUM)
(in/po) FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
cm
(in/po) NIVEAU D’EAU MINIMUM
REQUIS
2003
87
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
GTX 4-TEC
(6107/6108)
88
Counterclockwise/
antihoraire
Counterclockwise/
antihoraire
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.75
(.029)
13-23
stainless
steel/
acier
inoxydable
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.75
(.029)
13-23
stainless
steel/
acier
inoxydable
➄
➄
90
(35)
Splines/
Cannelures
Splines/
Cannelures
Smt2004-001f_propulsion.fm
13-23
stainless
steel/
acier
inoxydable
0.75
(.029)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
➄
Splines/
Cannelures
13-23
stainless
steel/
acier
inoxydable
0.75
(.029)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
➄
Splines/
Cannelures
Direct Drive/ Direct Drive/ Direct Drive/ Direct Drive/
Prise directe Prise directe Prise directe Prise directe
Counterclockwise/
antihoraire
15-21
stainless
steel/
acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Rubber Cushion/
Coussinet de
caoutchouc
Direct Drive
(split front/rear)/
Prise directe
(séparé avant/arrière)
Counterclockwise/
antihoraire
(6125/6126)
Counterclockwise/
antihoraire
GTX 4-TEC
Single
Stage/
Monophase
VANS TRIPLE
CROWN EDITION
Single
Single
Single
Single
Stage/
Stage/
Stage/
Stage/
Monophase Monophase Monophase Monophase
GTX 4-TEC
(6111/6112/
6127)
Bombardier
Formula
XP DI
(6131/6130)
Bombardier Bombardier Bombardier Bombardier
Formula
Formula
Formula
Formula
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
mm IMPELLER SHAFT RADIAL PLAY
(in/po) JEU RADIAL ARBRE HÉLICE
mm IMPELLER SHAFT END PLAY
(in/po) JEU AXIAL ARBRE HÉLICE
N /U IMPELLER/WEAR RING
mm CLEARANCE
(in/po) JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
mm
(in/po) DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
mm (MAXIMUM)
(in/po) FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
cm
(in/po) NIVEAU D’EAU MINIMUM
REQUIS
2003
89
90
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
11-20°
Stainless
Steel/
Acier
inoxydable
90
(35)
0.5
(.020)
139.5
(5.490)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
12°-25°
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
①
Single
Stage/
Monophase
GTX RFI
(5565/5566)
Single
Stage/
Monophase
GTX DI
(5563/5564)
(5595/5596)
Smt2004-001f_propulsion.fm
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
9°-20°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI
California
GTI LE
California
(6116/6117)
Bombardier
Formula
9°-20°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI LE
(5560/5561)
Splines/
Cannelures
Bombardier
Formula
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI
(5558/5559)
Splines/
Cannelures
LRV DI
(5460)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2002
91
92
Direct Drive
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15°-21°
Stainless Steel/
Acier inoxydable
90
(35)
0.5
(.020)
155.3
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
10°-22°
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
➄
Single Stage/
Monophase
GTX 4-TEC
(5573/5574)
(5593/5594)
Single
Stage/
Monophase
GTX
(5587/5588)
Smt2004-001f_propulsion.fm
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
RX
(5579/5580)
(5581/5582)
Splines/
Cannelures
Bombardier
Formula
15-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.3
(6.126)
0.5
(.020)
90
(35)
①
Rubber Cushion/
Coussinet de
caoutchouc
Direct Drive/
(split front/rear)/
Prise directe
(séparé avant/arrière)
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
XP
(5577/5578)
Splines/
Cannelures
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2002
93
94
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
9-20°
Stainless
Steel/
Acier
inoxydable
90
(35)
0.5
(.020)
139.5
(5.490)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
17°-22°
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
①
Single
Stage/
Monophase
GTI Inter.
First Series/
Première
série
(5552)
Single
Stage/
Monophase
GTS Inter.
First Series/
Première
série
(5551)
Smt2004-001f_propulsion.fm
11°-22°
Stainless
Steel/
Acier
inoxydable
12°-25°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.12-0.54
(.005-.021)
0.05
(.002)
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GSX RFI
Inter.
First Series/
Première
série
(5549)
Bombardier
Formula
17°-22°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GS
(5518 ➂/
5519 ➃)
Splines/
Cannelures
Bombardier
Formula
17°-22°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GS Inter.
First Series/
Première
série
(5548)
Splines/
Cannelures
GTS
(5520 ➂/
5521 ➃)
Bombardier
Formula
mm
(in/po)
mm
(in/po)
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2001
95
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
96
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15°-21°
Stainless
Steel/
Acier
inoxydable
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15°-21°
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
①
Single
Stage/
Monophase
RX DI
(5534/5535/
5536/5537)
Single
Stage/
Monophase
XP
(5530/5531)
Smt2004-001f_propulsion.fm
15°-21°
Stainless Steel/
Acier inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Direct Drive
(split front/rear)/
Prise directe
(séparé avant/arrière)
Rubber Cushion/
Coussinet de
caoutchouc
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Counterclockwise/
Antihoraire
Single Stage/
Monophase
Bombardier
Formula
GTX
(5526/5527/
5538/5539)
Bombardier
Formula
12°-25°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTX RFI
(5524/5525/
5553/5555)
Splines/
Cannelures
Bombardier
Formula
9-20°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTI
(5522 ➂/
5523 ➃)
Splines/
Cannelures
RX
(5532/5533/
5542/5543)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2001
97
98
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
Smt2004-001f_propulsion.fm
mm
(in/po)
0.05
(.002)
17°-22°
Stainless
Steel/
Acier
inoxydable
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
0
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
N /U
mm
(in/po)
0.0-0.4
(.000-.016)
1.0
(.040)
11°-20°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
mm
(in/po)
139.5
(5.490)
0.5
(.020)
mm
(in/po)
0.5
(.020)
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
cm
(in/po)
90
(35)
①
Splines/
Cannelures
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
90
(35)
①
COUPLING
ACCOUPLEMENT
Direct Drive/
Prise directe
TRANSMISSION
TRANSMISSION
Direct Drive/
Prise directe
Splines/
Cannelures
Counterclockwise/
Antihoraire
IMPELLER ROTATION
ROTATION DE L’HÉLICE
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
JET PUMP TYPE
TYPE DE TURBINE
2000
Single
Stage/
Monophase
GS
(5644/5827)
Bombardier
Formula
LRV
(5697)
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTX DI
(5528/5529/
5540/5541)
Bombardier
Formula
mm
(in/po)
mm
(in/po)
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2001
99
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
100
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
139.5
(5.490)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
12°-25°
Stainless
Steel/
Acier
inoxydable
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15°-21°
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
①
Single
Stage/
Monophase
GTX
(5653/5669)
Single
Stage/
Monophase
GTI
(5647/5657)
Smt2004-001f_propulsion.fm
11°-22°
Stainless
Steel/
Acier
inoxydable
17°-22° ➁ Stainless
Steel/
Acier
inoxydable
12°-25°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.12-0.54
(.005-.021)
0.05
(.002)
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
139.5
(5.490)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
GTS Inter.
5639
Splines/
Cannelures
Bombardier
Formula
GSX RFI
(5645/5654)
Splines/
Cannelures
GTX RFI
(5648/5658/
5515/5516)
Bombardier
Formula
mm
(in/po)
mm
(in/po)
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2000
101
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
102
Direct Drive/
Prise directe
Direct Drive/
Prise directe
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
15°-21°
Stainless
Steel/
Acier
inoxydable
90
(35)
0.5
(.020)
155.6
(6.126)
0.0-0.4
(.000-.016)
1.0
(.040)
0
0.05
(.002)
11°-20° ➂
Stainless
Steel/
Acier
inoxydable
①
Counterclockwise/
Antihoraire
Counterclockwise/
Antihoraire
①
Single
Stage/
Monophase
LRV
(5688)
Single
Stage/
Monophase
RX DI
(5646/5656)
Smt2004-001f_propulsion.fm
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
15°-21°
Stainless
Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
Splines/
Cannelures
Direct Drive/
Prise directe
Counterclockwise/
Antihoraire
Single
Stage/
Monophase
Bombardier
Formula
RX
(5513/5514)
Splines/
Cannelures
Bombardier
Formula
15°-21°
Stainless Steel/
Acier
inoxydable
0.05
(.002)
0
0.0-0.4
(.000-.016)
1.0
(.040)
155.6
(6.126)
0.5
(.020)
90
(35)
①
Rubber Cushion/
Coussinet de
caoutchouc
Direct Drive
(split front/rear)/
Prise directe
(séparé avant/arrière)
Counterclockwise/
Antihoraire
Single Stage/
Monophase
Bombardier
Formula
XP
(5651/5655)
Splines/
Cannelures
GTX DI
(5649/5659)
Bombardier
Formula
IMPELLER PITCH/MATERIAL
PAS HÉLICE/MATÉRIAU
IMPELLER SHAFT RADIAL PLAY
JEU RADIAL ARBRE HÉLICE
IMPELLER SHAFT END PLAY
JEU AXIAL ARBRE HÉLICE
mm
(in/po)
mm
(in/po)
IMPELLER/WEAR RING
CLEARANCE
JEU HÉLICE/ANNEAU
IMPELLER OUTSIDE DIAMETER
DIAMÈTRE EXTÉRIEUR
DE L’HÉLICE
DRIVE SHAFT DEFLECTION
(MAXIMUM)
FLÈCHE D’ARBRE DE
TRANSMISSION (MAXIMUM)
MINIMUM REQUIRED
WATER LEVEL
NIVEAU D’EAU MINIMUM
REQUIS
OIL TYPE
TYPE D’HUILE
COUPLING
ACCOUPLEMENT
TRANSMISSION
TRANSMISSION
IMPELLER ROTATION
ROTATION DE L’HÉLICE
JET PUMP TYPE
TYPE DE TURBINE
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
N /U
mm
(in/po)
mm
(in/po)
mm
(in/po)
cm
(in/po)
2000
103
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
PROPULSION SYSTEM
SYSTÈME DE PROPULSION
ABBREVIATIONS
ABRÉVIATIONS
① SEA-DOO JET PUMP SYNTHETIC POLYOLESTER OIL
SAE 75W90 GL5. Do not mix different brands or oil types.
① HUILE SYNTHÉTIQUE POLYOLESTER 75W90 GL5 POUR
TURBINE SEA-DOO. Ne pas mélanger différents types d’huile
ou des huiles de différentes marques.
➁ As per Service Bulletin 2000-3
➁ Selon le Bulletin de service 2000-3
➂ International Model. (second series)
➂ Modèle international. (deuxième série)
➃ Complete North America Series
➃ Série complète Amérique du Nord
➄ Grease: thermalube XL-OL-C2, NLGI2.
(P/N 293 550 032)
Graisse: thermalube XL-OL-C2, NLGI2.
(N/P 293 550 032)
➄
N/U: New/Used (Service Limit)
N/U: Neuf/Usagé (limite d’usure)
104
Smt2004-001f_propulsion.fm
www.SeaDooManuals.net
Smt2004-001f_propulsion.fm
SECTION CONTENTS
CONTENU DE LA SECTION
DIMENSION/CAPACITIES
DIMENSIONS/CONTENANCES
PAGE
PAGE
Dimension
Dimensions............... 106
ABBREVIATIONS
ABRÉVIATIONS........ 116
– Number of Passengers
– Nombre de passagers
– Overall Length
– Longueur hors-tout
– Overall Width
– Largeur hors-tout
– Overall Height
– Hauteur hors-tout
– Dry Weight
– Poids à sec
– Load Limit
– Charge maximale
– Fuel Tank
– Réservoir de carburant
– Oil Injection Reservoir
– Réservoir d’huile à injection
– Impeller Shaft Reservoir
– Réservoir d’arbre d’hélice
Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
105
NUMBER OF
PASSENGERS
NOMBRE DE
PASSAGERS
OVERALL
LENGTH
LONGUEUR
HORS-TOUT
OVERALL
WIDTH
LARGEUR
HORS-TOUT
OVERALL
HEIGHT
HAUTEUR
HORS-TOUT
DRY WEIGHT
POIDS À SEC
LOAD LIMIT
CHARGE MAXIMALE
FUEL TANK
RÉSERVOIR DE
CARBURANT
OIL INJECTION
RESERVOIR
RÉSERVOIR D’HUILE
À INJECTION
IMPELLER SHAFT
RESERVOIR
RÉSERVOIR D’ARBRE
D’HÉLICE
2004
①
cm
(in/po)
cm
(in/po)
cm
(in/po)
kg
(lb)
kg
(lb)
L②
(U.S. gal/
gal É.-U.)
L
(U.S. gal/
gal É.-U.)
mL
(U.S. oz/
oz É.-U.)
GTI
(6133/6134)
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
GTI LE
(6135/6136)
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
3D RFI
(6157/6158)
1
272
(107)
112
(44)
vert: 92 (36.25)
kart: 96 (37.75)
moto: 112 (44.25)
moto: 268 (589)
kart: 274 (603)
114
(250)
32
(8.5)
4
(1.0)
100
(3.38)
GTI RFI
(6137/6138)
3
307
(121)
120
(47)
104
(41)
315
(695)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
GTI RFI LE
(6139/6140)
3
307
(121)
120
(47)
104
(41)
317
(700)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
XP DI
(6151/6152)
2
272
(107)
112
(44)
104
(41)
274
(625)
181
(400)
51
(13)
4
(1.0)
100
(3.38)
GTX 4-TEC
(6147/6148)
3
331
(130)
122
(48)
113
(44)
385
(850)
272
(600)
60
(15.9)
➅
➄
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
3
331
(130)
122
(48)
113
(44)
385
(850)
272
(600)
60
(15.9)
➅
➄
GTX 4-TEC
Supercharged
(6143/6144)
3
331
(130)
122
(48)
113
(44)
397
(875)
272
(600)
60
(15.9)
➅
➄
GTX 4-TEC
Limited
Supercharged
(6141/6142)
3
331
(130)
122
(48)
113
(44)
397
(875)
272
(600)
60
(15.9)
➅
➄
RXP 4-TEC
(5599/6115/
6162/6163)
2
307
(121)
122
(48)
109
(43)
359
(792)
181
(400)
60
(15.9)
➅
➄
106
Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
107
NUMBER OF
PASSENGERS
NOMBRE DE
PASSAGERS
OVERALL
LENGTH
LONGUEUR
HORS-TOUT
OVERALL
WIDTH
LARGEUR
HORS-TOUT
OVERALL
HEIGHT
HAUTEUR
HORS-TOUT
DRY WEIGHT
POIDS À SEC
LOAD LIMIT
CHARGE MAXIMALE
FUEL TANK
RÉSERVOIR DE
CARBURANT
OIL INJECTION
RESERVOIR
RÉSERVOIR D’HUILE
À INJECTION
IMPELLER SHAFT
RESERVOIR
RÉSERVOIR D’ARBRE
D’HÉLICE
2003
①
cm
(in/po)
cm
(in/po)
cm
(in/po)
kg
(lb)
kg
(lb)
L②
(U.S. gal/
gal É.-U.)
L
(U.S. gal/
gal É.-U.)
mL
(U.S. oz/
oz É.-U.)
GTI
(5568/5598/
5597/5567)
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
GTI LE
(6102/6101)
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
GTI LE RFI
(6104/6103)
3
307
(121)
120
(47)
104
(41)
315
(695)
243
(536)
56.5
(15)
6
(1.6)
100
(3.38)
GTX DI
(6118/6119)
3
331
(130)
122
(48)
113
(44)
351
(775)
272
(600)
56.5
(15)
6
(1.6)
100
(3.38)
LRV DI
(5771)
4
396
(156)
155
(61)
108
(42.5)
432
(952)
338
(745)
95
(25)
6
(1.6)
115
(3.88)
RX DI
(6123/6122)
2
285
(112)
120
(47)
104
(41)
285
(628)
181
(400)
56.5
(15)
6
(1.6)
100
(3.38)
XP DI
(6131/6130)
2
272
(107)
112
(44)
104
(41)
274
(625)
181
(400)
51
(13)
4
(1.0)
100
(3.38)
GTX 4-TEC
(6111/6112/
6127)
3
331
(130)
122
(48)
113
(44)
385
(850)
272
(600)
60
(15.9)
➅
➄
3
331
(130)
122
(48)
113
(44)
385
(850)
272
(600)
60
(15.9)
➅
➄
3
331
(130)
122
(48)
113
(44)
397
(875)
272
(600)
60
(15.9)
➅
➄
3
331
(130)
122
(48)
113
(44)
397
(875)
272
(600)
60
(15.9)
➅
➄
GTX 4-TEC
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
108
Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
109
NUMBER OF
PASSENGERS
NOMBRE DE
PASSAGERS
OVERALL
LENGTH
LONGUEUR
HORS-TOUT
OVERALL
WIDTH
LARGEUR
HORS-TOUT
OVERALL
HEIGHT
HAUTEUR
HORS-TOUT
DRY WEIGHT
POIDS À SEC
LOAD LIMIT
CHARGE MAXIMALE
FUEL TANK
RÉSERVOIR DE
CARBURANT
OIL INJECTION
RESERVOIR
RÉSERVOIR D’HUILE
À INJECTION
IMPELLER SHAFT
RESERVOIR
RÉSERVOIR D’ARBRE
D’HÉLICE
2002
①
cm
(in/po)
cm
(in/po)
cm
(in/po)
kg
(lb)
kg
(lb)
L②
(U.S. gal/
gal É.-U.)
L
(U.S. gal/
gal É.-U.)
mL
(U.S. oz/
oz É.-U.)
GTI
(5558/5559)
3
307
(121)
112
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
GTI LE
(5560/5561)
3
307
(121)
112
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
GTI
California
GTI LE
California
(6116/6117)
3
307
(121)
112
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
GTX DI
(5563/5564)
(5595/5596)
3
331
(130)
122
(48)
113
(44)
363
(800)
272
(600)
56.5
(15)
6
(1.6)
115
(3.88)
LRV DI
(5460)
4
396
(156)
155
(61)
108
(42.5)
432
(952)
338
(745)
95
(25)
6
(1.6)
115
(3.88)
GTX RFI
(5565/5566)
3
315
(124)
122
(48)
104
(41)
292
(644)
243
(536)
56.5
(15)
6
(1.6)
95
(3.21)
XP
(5577/5578)
2
272
(107)
112
(44)
104
(41)
255
(562)
159
(350)
54
(14)
4
(1.1)
115
(3.88)
RX
(5579/5580)
(5581/5582)
2
285
(112)
120
47
104
(41)
275
(606)
181
(400)
56.5
(15)
6
(1.6)
95
(3.21)
GTX
(5587/5588)
3
315
(124)
122
(48)
104
(41)
301
(664)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
2
285
(112)
120
(47)
104
(41)
285
(628)
181
(400)
56.5
(15)
6
(1.6)
115
(3.88)
GTX 4-TEC
(5573/5574)
(5593/5594)
3
331
(130)
122
(48)
113
(44)
393 blue
(866) bleu
397 red
(875) rouge
272
(600)
60
(15.9)
➅
➄
110
Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
111
OVERALL
LENGTH
LONGUEUR
HORS-TOUT
OVERALL
WIDTH
LARGEUR
HORS-TOUT
OVERALL
HEIGHT
HAUTEUR
HORS-TOUT
DRY WEIGHT
POIDS À SEC
LOAD LIMIT
CHARGE MAXIMALE
FUEL TANK
RÉSERVOIR DE
CARBURANT
OIL INJECTION
RESERVOIR
RÉSERVOIR D’HUILE
À INJECTION
IMPELLER SHAFT
RESERVOIR
RÉSERVOIR D’ARBRE D’HÉLICE
cm
(in/po)
cm
(in/po)
kg
(lb)
kg
(lb)
L
(U.S. gal/
gal É.-U.)
L
(U.S. gal/
gal É.-U.)
mL
(U.S. oz/
oz É.-U.)
2
270
(106)
116
(45.7)
99
(39)
219
(483)
159
(351)
56.5
(15)
6
(1.6)
95
(3.21)
2
270
(106)
116
(45.7)
99
(39)
219
(483)
159
(351)
56.5
(15)
6
(1.6)
95
(3.21)
GSX RFI Inter.
First Series/
Première série
2
270
(106)
116
(45.7)
99
(39)
234
(516)
159
(351)
56.5
(15)
6
(1.6)
95
(3.21)
GTS Inter.
First Series/
Première série (5551)
3
302
(119)
119
(47)
95
(37.4)
222
(489)
225
(496)
47
(12)
4.5
(1.2)
80
(2.7)
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
3
315
(124)
122
(48)
104
(41)
275
(606)
243
(536)
56.5
(15)
6
(1.6)
95
(3.21)
/5523 )
3
307
(121)
120
(47)
104
(41)
272
(600)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
GTX RFI
(5524/5525/5553/
5555)
3
315
(124)
122
48
107
(42)
104 (41)
292
(644)
243
(536)
56.5
(15)
6
(1.6)
95
(3.21)
GTX
(5526/5527/5538/
5539)
3
315
(124)
122
(48)
104
(41)
301
(664)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
XP
(5530/5531)
2
272
(107)
112
(44)
104
(41)
255
(562)
159
(351)
54
(14)
4
(1.1)
115
(3.88)
RX
(5532/5533/5542/
5543)
2
285
(112)
120
(47)
104
(41)
275
(606)
181
(399)
56.5
(15)
6
(1.6)
115
(3.88)
RX DI
(5534/5535/5536/
5537)
2
285
(112)
120
(47)
104
(41)
285
(628)
181
(399)
56.5
(15)
6
(1.6)
115
(3.88)
GTX DI
(5528/5529/5540/
5541)
3
315
(124)
122
48
107 (42)
104 (41)
309
(681)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
LRV
(5697)
4
396
(156)
155
(61)
108
(42.5)
435
(960)
340
(750)
95
(25)
6
(1.6)
115
(3.88)
NUMBER OF
PASSENGERS
NOMBRE DE
PASSAGERS
cm
(in/po)
2001
GS Inter.
First Series/
Première série
GS
(5518
/5519 )
GTS
(5520
/5521 )
GTI Inter.
First Series/
Première série (5552)
GTI
(5522
112

Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
113
NUMBER OF
PASSENGERS
NOMBRE DE
PASSAGERS
OVERALL
LENGTH
LONGUEUR
HORS-TOUT
OVERALL
WIDTH
LARGEUR
HORS-TOUT
OVERALL
HEIGHT
HAUTEUR
HORS-TOUT
DRY WEIGHT
POIDS À SEC
LOAD LIMIT
CHARGE MAXIMALE
FUEL TANK
RÉSERVOIR DE
CARBURANT
OIL INJECTION
RESERVOIR
RÉSERVOIR D’HUILE
À INJECTION
IMPELLER SHAFT
RESERVOIR
RÉSERVOIR D’ARBRE
D’HÉLICE
2000
①
cm
(in/po)
cm
(in/po)
cm
(in/po)
kg
(lb)
kg
(lb)
L②
(U.S. gal/
gal É.-U.)
L
(U.S. gal/
gal É.-U.)
mL
(U.S. oz/
oz É.-U.)
GS
(5644/5827)
2
270
(106)
116
(45.7)
99
(39)
219
(483)
159
(351)
56.5
(15)
6
(1.6)
95
(3.21)
GSX RFI
(5645/5654)
2
270
(106)
116
(45.7)
99
(39)
234
(516)
159
(351)
56.5
(15)
6
(1.6)
95
(3.21)
GTS Inter.
(5639)
3
302
(119)
119
(47)
95
(37.4)
222
(489)
225
(496)
47
(12)
4.5
(1.2)
80
(2.7)
GTI
(5647/5657)
3
315
(124)
122
(48)
104
(41)
275
(606)
243
(536)
56.5
(15)
6
(1.6)
95
(3.21)
GTX RFI
(5648/5658/
5515/5516)
3
315
(124)
122
48
107
(42)
292
(644)
243
(536)
56.5
(15)
6
(1.6)
95
(3.21)
GTX
(5653/5669)
3
315
(124)
122
(48)
104
(41)
301
(664)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
XP
(5651/5655)
2
272
(107)
112
(44)
104
(41)
255
(562)
159
(351)
54
(14)
4
(1.1)
115
(3.88)
RX
(5513/5514)
2
285
(112)
120
(47)
104
(41)
275
(606)
181
(399)
56.5
(15)
6
(1.6)
115
(3.88)
RX DI
(5646/5656
2
285
(112)
120
(47)
104
(41)
285
(628)
181
(399)
56.5
(15)
6
(1.6)
115
(3.88)
GTX DI
(5649/5659)
3
315
(124)
122
48
107
(42)
309
(681)
243
(536)
56.5
(15)
6
(1.6)
115
(3.88)
LRV
(5688)
4
396
(156)
155
(61)
108
(42.5)
435
(960)
340
(750)
95
(25)
6
(1.6)
115
(3.88)
114
Smt2004-001g_dimensions.fm
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
115
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
DIMENSIONS/CAPACITIES
DIMENSIONS/CONTENANCES
ABBREVIATIONS
ABRÉVIATIONS
① Driver Included
① Conducteur inclus
② Reserve Included
② Réserve incluse
➂ International Model. (second series)
➂ Modèle international. (deuxième série)
➃ Complete North America Series
➃ Série complète Amérique du Nord
➄ Sea-Doo grease (P/N 293 550 032)
4 mL in front of bearing
26 mL at rear of bearing
26 mL in pump cap
➄ Graisse Sea-Doo (N/P 293 550 032)
4 mL en avant du roulement
26 mL à l’arrière du roulement
26 mL dans le couvercle de la pompe
➅ 4.5 L (dry engine) 3.1 L (oil change w/filter)
➅ 4.5 L (moteur à sec ) 3.1 L (changement d’huile avec filtre)
116
Smt2004-001g_dimensions.fm
www.SeaDooManuals.net
Smt2004-001g_dimensions.fm
SECTION CONTENTS
CONTENU DE LA SECTION
MATERIALS
MATÉRIAUX
PAGE
PAGE
MATERIALS
MATÉRIAUX ............. 118
ABBREVIATIONS
ABRÉVIATIONS........ 132
– Hull
– Coque
– Jet Pump Housing
– Carter de turbine
– Stator
– Stator
– Venturi
– Venturi
– Nozzle
– Tuyère
– Air Intake Silencer
– Silencieux d’admission
d’air
– Flame Arrester
– Pare-flammes
– Tuned Pipe/Muffler
– Tuyau d’échappement
calibré/silencieux
– Steering Padding
– Rembourrage de guidon
– Fuel Tank
– Réservoir de carburant
– Oil Injection Reservoir
– Réservoir d’huile à injection
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
117
VENTURI
VENTURI
NOZZLE
TUYÈRE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
FLAME ARRESTER
PARE-FLAMMES
Plast.
Alum.
Alum.
Thermoplast.
Multi Layer Wire
Screen/Tamis
multicouche
GTI LE
(6135/6136)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
3D RFI
(6157/6158)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
GTI RFI
(6137/6138)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
GTI RFI LE
(6139/6140)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi Layer Wire
Screen/Tamis
multicouche
Multi Layer Wire
Screen/Tamis
multicouche
XP DI
(6151/6152)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
GTX 4-TEC
(6147/6148)
Composite
Plast.
Plast.
Alum.
Alum.
GTX 4-TEC
Wakeboard
Edition (6149/ Composite
6150)
Plast.
Plast.
Alum.
Plast.
Plast.
Plast.
Plast.
GTX 4-TEC
Supercharged Composite
(6143/6144)
GTX 4-TEC
Limited
Supercharged Composite
(6141/6142)
RXP 4-TEC
(5599/6115/
6162/6163)
118
Composite
Plast.
Plast.
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
STATOR
STATOR
Plast.
FUEL TANK
RÉSERVOIR DE CARBURANT
JET PUMP HOUSING
CARTER DE TURBINE
Composite
STEERING PADDING
REMBOURRAGE DE GUIDON
HULL
COQUE
GTI
(6133/6134)
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
2004
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Thermoplast.
Tubular Wire
Screen integrated
with Intercooler/
Tamis tubulaire
intégré au
refroidisseur
intermédiaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Alum.
Alum.
Multi Layer Wire
Screen/Tamis
multicouche
Multi Layer Wire
Screen/Tamis
multicouche
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
119
NOZZLE
TUYÈRE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
FLAME ARRESTER
PARE-FLAMMES
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
VENTURI
VENTURI
FUEL TANK
RÉSERVOIR DE CARBURANT
STATOR
STATOR
STEERING PADDING
REMBOURRAGE DE GUIDON
JET PUMP HOUSING
CARTER DE TURBINE
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
HULL
COQUE
GTI
(5568/5598/
5597/5567)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi Layer Wire
Screen/Tamis
multicouche
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
GTI LE
(6102/6101)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi Layer Wire
Screen/Tamis
multicouche
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
GTI LE RFI
(6104/6103)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi Layer Wire
Screen/Tamis
multicouche
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
GTX DI
(6118/6119)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
LRV DI
(5771)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
RX DI
(6123/6122)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
XP DI
(6131/6130)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/ Polyethylene/
Thermoplastique Polyéthylène Polyéthylène
GTX 4-TEC
(6111/6112/
6127)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tubular Wire
Screen/Tamis
tubulaire
Alum.
Thermoplastic/ Polyethylene/
Thermoplastique Polyéthylène
N.A./
S.O.
2003
GTX 4-TEC
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
120
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
121
HULL
COQUE
JET PUMP HOUSING
CARTER DE TURBINE
STATOR
STATOR
VENTURI
VENTURI
NOZZLE
TUYÈRE
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
STEERING PADDING
REMBOURRAGE DE GUIDON
FUEL TANK
RÉSERVOIR DE CARBURANT
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
GTI
(5558/5559)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTI LE
(5560/5561)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTI
California
GTI LE
California
(6116/6117)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX DI
(5563/5564)
(5595/5596)
Composite
Plast.
Plast.
Alum.
Alum
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
LRV DI
(5460)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX RFI
(5565/5566)
Composite
Plast.
Plast.
Plast
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
XP
(5577/5578)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
RX
(5579/5580)
(5581/5582)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX
(5587/5588)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX 4-TEC
(5573/5574)
(5593/5594)
Composite
Plast.
Stainless
Steel/
A. inox.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
N.A./
S.O.
122
FLAME ARRESTER
PARE-FLAMMES
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
2002
Tubular
Wire Screen/
Tamis
tubulaire
Tubular
Wire Screen/
Tamis
tubulaire
Multi-Layer
Wire Screen/
Tamis
multicouche
Tubular
Wire Screen/
Tamis
tubulaire
Tubular
Wire Screen/
Tamis
tubulaire
Tubular
Wire Screen/
Tamis
tubulaire
Tubular
Wire Screen/
Tamis
tubulaire
Tubular
Wire Screen/
Tamis
tubulaire
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
123
HULL
COQUE
JET PUMP HOUSING
CARTER DE TURBINE
STATOR
STATOR
VENTURI
VENTURI
NOZZLE
TUYÈRE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
STEERING PADDING
REMBOURRAGE DE GUIDON
FUEL TANK
RÉSERVOIR DE CARBURANT
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
GS Inter.
First Series/
Première
série
(5548)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GS
(5518 ➀/
5519 ➁)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GSX RFI
Inter.
First Series/
Première
série
(5549)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplast.
Elastomer
with Polystyrene
Foam/
Élastomère
thermoplast.
avec mousse en
polystyrène
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
FLAME ARRESTER
PARE-FLAMMES
2001
GTS Inter.
First Series/
Première
série
(5551)
Composite
Plast.
Plast.
Plast.
Plast.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
GTS
(5520 ➀/
5521 ➁)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTI Inter.
First Series/
Première
série
(5552)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTI
(5522 ➀/
5523 ➁)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX RFI
(5524/5525/
5553/5555)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX
(5526/5527/
5538/5539)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
124
Multi-Layer
Wire Screen/
Tamis
multicouche
Multi-Layer
Wire Screen/
Tamis
multicouche
Tabular
Wire Screen/
Tamis
tabulaire
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
125
HULL
COQUE
JET PUMP HOUSING
CARTER DE TURBINE
STATOR
STATOR
VENTURI
VENTURI
NOZZLE
TUYÈRE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
STEERING PADDING
REMBOURRAGE DE GUIDON
FUEL TANK
RÉSERVOIR DE CARBURANT
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
XP
(5530/5531)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
RX
(5532/5533/
5542/5543)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
RX DI
(5534/5535/
5536/5537)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
GTX DI
(5528/5529/
5540/5541)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
LRV
(5697)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
126
FLAME ARRESTER
PARE-FLAMMES
2001
Tabular
Wire Screen/
Tamis
tabulaire
Tabular
Wire Screen/
Tamis
tabulaire
Tabular
Wire Screen/
Tamis
tabulaire
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
127
Plast.
Alum.
Thermoplast.
GSX RFI
(5645/5654)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Multi-Layer
Wire Screen/
Tamis
multicouche
GTS Inter.
(5639)
Composite
Plast.
Plast
Plast.
Plast.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
GTI
(5647/5657)
Composite
Plast.
Plast
Plast.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
GTX RFI
(5648/5658/
5515/5516)
Composite
Plast.
Plast.
Plast.
Alum.
Thermoplast.
GTX
(5653/5669)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Multi-Layer
Wire Screen/
Tamis
multicouche
Tabular
Wire Screen/
Tamis
tabulaire
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
NOZZLE
TUYÈRE
Plast.
FUEL TANK
RÉSERVOIR DE CARBURANT
VENTURI
VENTURI
Plast.
STEERING PADDING
REMBOURRAGE DE GUIDON
STATOR
STATOR
Composite
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
JET PUMP HOUSING
CARTER DE TURBINE
GS
(5644/5827)
FLAME ARRESTER
PARE-FLAMMES
HULL
COQUE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
2000
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplast.
Elastomer
with Polystyrene
Foam/
Élastomère
thermoplast.
avec mousse en
polystyrène
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
Alum.
Thermoplast.
Elastomer
with Polystyrene
Foam/
Élastomère
thermoplast.
avec mousse en
polystyrène
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
XP
(5651/5655)
Composite
Plast.
Plast
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
RX
(5513/5514)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
RX DI
(5646/5656)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
128
Smt2004-001h_materiaux.fm
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
129
HULL
COQUE
JET PUMP HOUSING
CARTER DE TURBINE
STATOR
STATOR
VENTURI
VENTURI
NOZZLE
TUYÈRE
AIR INTAKE SILENCER
SILENCIEUX
D’ADMISSION D’AIR
TUNED PIPE/MUFFLER
TUYAU D’ÉCHAPPEMENT
CALIBRÉ
STEERING PADDING
REMBOURRAGE DE GUIDON
FUEL TANK
RÉSERVOIR DE CARBURANT
OIL INJECTION RESERVOIR
RÉSERVOIR D’HUILE À
INJECTION
GTX DI
(5649/5659)
Composite
Plast.
Plast.
Alum.
Alum
Thermoplast
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
LRV
(5688)
Composite
Plast.
Plast.
Alum.
Alum.
Thermoplast.
Tabular
Wire Screen/
Tamis
tabulaire
Alum.
Thermoplastic/
Thermoplastique
Polyethylene/
Polyéthylène
Polyethylene/
Polyéthylène
130
Smt2004-001h_materiaux.fm
FLAME ARRESTER
PARE-FLAMMES
2000
www.SeaDooManuals.net
Smt2004-001h_materiaux.fm
131
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
MATERIALS
MATÉRIAUX
ABBREVIATIONS
ABRÉVIATIONS
① International Model (second series)
① Modèle international (deuxième série)
② Complete North America Series
② Série complète Amérique du Nord
Alum.: Aluminum
Alum.: Aluminium
Plast.: Plastic
Plast.: Plastique
Thermoplast.: Thermoplastic
Thermoplast.: Thermoplastique
N.A.: Not Applicable
S.O. : Sans objet
132
Smt2004-001h_materiaux.fm
www.SeaDooManuals.net
Smt2004-001h_materiaux.fm
SECTION CONTENTS
CONTENU DE LA SECTION
ENGINE TIGHTENING TORQUES
COUPLES DE SERRAGE
DU MOTEUR
PAGE
2-STROKE ENGINE
MOTEUR 2-TEMPS... 134
– Magneto Flywheel Nut
– Écrou du volant
magnétique
– Flywheel (PTO Side)
– Volant moteur (côté PDM)
– Crankcase Screws (M8)
– Vis de carter (M8)
– Crankcase Screws (M10)
– Vis de carter (M10)
– Crankcase/
Engine Support Nuts
– Écrous de carter/
support moteur
– Magneto Flywheel Screws
– Vis du volant magnétique
– PTO Coupling
– Raccord PDM
– Crankcase Screws (M8)
– Vis de carter (M8)
– Cylinder Head Screws (M10)
– Vis de carter (M10)
– Engine Support Screws
– Vis de support moteur
– Connecting Rod Screws
– Vis de bielle
– Engine Support Screws
– Vis de support moteur
– Cylinder Head Screws
– Vis de culasse
– Cylinder Head Screws
– Vis de culasse
– Valve cover screw
– Vis de couvercle de
soupape
– Valve Cover Screws
– Vis de couvercle de
soupape
– Crankcase/Cylinder Screws
– Vis de carter/cylindre
– Flame Arrester Screws
– Vis de pare-flammes
– Magneto Housing Cover
Screws
– Vis de boîtier magnéto
– Starter Screws
– Vis de démarreur
– Spark Plugs
– Bougies
Smt2004-001i_couples serrage moteur.fm
PAGE
4-TEC ENGINE
MOTEUR 4-TEC........ 136
– Supercharger Impeller Nut
– Écrou d’hélice de
compresseur
– Supercharger Drive Shaft Nut
– Écrou d’arbre de
compresseur
– Magneto Housing Cover
Screws
– Vis de boîtier magnéto
– Starter Screws
– Vis de démarreur
– Spark Plugs
– Bougies
ABBREVIATIONS
ABRÉVIATIONS........ 154
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
133
40
(30)
25
(18)
N.A./
S.O.
N.A./
S.O.
25
(18)
25
(18)
➀
➀➂➄
N.A./
S.O.
25
(18)
25
(18)
➀
23
(17
➀➂➄
N.A./
S.O.
25
(18)
25
(18)
➀
23
(17)
➀➂➄
N.A./
S.O.
25
(18)
25
(18)
40
(30)
➁➂
➁➂
GTI LE
(6135/6136)
145
(107)
105
(77)
➃
23
(17)
➁➂
➁➂
3D RFI
(6157/6158)
120
(89)
105
(77)
➃
23
(17)
➁➂
40
(30)
➁➂
GTI RFI
(6137/6138)
120
(89)
105
(77)
➃
23
(17)
➁➂
40
(30)
➁➂
GTI RFI LE
(6139/6140)
120
(89)
105
(77)
➃
23
(17)
➁➂
40
(30)
➁➂
XP DI
(6151/6152)
115
(85)
115
(85)
27
(20)
40
(30)
134
①
①
①
①
①
①
23
(17)
➁
➁
①
①
①
①
①
①
①
①
N•m
(lbf•ft)/
(lbf•pi)
23
(17)
N.A./
S.O.
➀
Smt2004-001i_couples serrage moteur.fm
➀➂➄
23
(17)
➀➂➄
23
(17)
➀➂➄
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
SPARK PLUGS
BOUGIES
40
(30)
➃
N•m
(lbf•in)/
(lbf•po)
STARTER SCREWS
VIS DE DÉMARREUR
N.A./
S.O.
105
(77)
①
N•m
(lbf•ft)/
(lbf•pi)
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
25
(18)
145
(107)
N•m
(lbf•ft)/
(lbf•pi)
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
40
(30)
GTI
(6133/6134)
CRANKCASE/
CYLINDER SCREWS
VIS DE CARTER/CYLINDRE
40
(30)
N•m
(lbf•ft)/
(lbf•pi)
CYLINDER HEAD
COVER SCREWS
VIS DE COUVRE-CULASSE
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
CYLINDER HEAD SCREWS
VIS DE CULASSE
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
N•m
(lbf•ft)/
(lbf•pi)
2004
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
CRANKCASE SCREWS
VIS DE CARTER
N•m
(lbf•ft)/
(lbf•pi)
M10
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
N•m
(lbf•ft)/
(lbf•pi)
M8
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
CRANKCASE SCREWS
VIS DE CARTER
2 Stroke Engines/Moteurs 2-temps
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
23
(17)
10
(89)
9
(80)
23
(17)
23
(17)
23
(17)
10
(89)
9
(80)
23
(17)
23
(17)
40
(30)
10
(89)
9
(80)
22
(16)
23
(17)
40
(30)
10
(89)
9
(80)
22
(16)
23
(17)
40
(30)
10
(89)
9
(80)
22
(16)
23
(17)
N.A./
S.O.
9
(80)
9
(7)
23
(17)
➀➂
➀➂
➁➂
➁➂
➁➂
40
(30)
➃
➃
➃
➃
➃
①
➀
➀
➀
①
➃
➃
➃
➃
➃
➃
135
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
CONNECTING ROD SCREWS
VIS DE BIELLE
CYLINDER HEAD SCREWS
VIS DE CULASSE
VALVE COVER SCREWS
VIS DE COUVERCLE
DE SOUPAPE
SUPERCHARGER IMPELLER
NUT
ÉCROU D’HÉLICE DE
COMPRESSEUR
SUPERCHARGER DRIVE
SHAFT NUT
ÉCROU D’ARBRE DE
COMPRESSEUR
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
M8
N•m
(lbf•ft)/
(lbf•pi)
M10
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
GTX 4-TEC
(6147/6148)
23
(17)
250
(184)
23
(17)
40+55
(30+40)
25
(18)
25
(18)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
N.A./
S.O.
N.A./
S.O.
9
(80)
250
(184)
23
(17)
40+55
(30+40)
25
(18)
25
(18)
45 (33)
+90°
40 (30)
+120°
+90°
N.A./
S.O.
9
(80)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
30
(22)
29
(21)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
30
(22)
29
(21)
45 (33)
+90°
40 (30)
+120°
+90°
GTX 4-TEC
Wakeboard
Edition
(6149/6150)
GTX 4-TEC
Supercharged
(6143/6144)
GTX 4-TEC
Limited
Supercharged
(6141/6142)
RXP 4-TEC
(5599/6115/
6162/6163)
136
➀
23
(17)
➀
23
(17)
➀
23
(17)
➀
23
(17)
➀
➇
➇
250
(184)
➇
250
(184)
➇
250
(184)
➇
➀
➀
23
(17)
➀
23
(17)
➀
23
(17)
➀
➀
➀
40+55
(30+40)
➀
40+55
(30+40)
➀
40+55
(30+40)
➀
①
①
25
(18)
①
25
(18)
①
25
(18)
①
①
①
25
(18)
①
25
(18)
①
25
(18)
①
Smt2004-001i_couples serrage moteur.fm
①➂
①➂
①➂
①➂
①➂
9
(80)
9
(80)
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
N.A./
S.O.
①
①
30
(22)
①
29
(21)
SPARK PLUGS
BOUGIES
CRANKCASE SCREWS
VIS DE CARTER
N•m
(lbf•ft)/
(lbf•pi)
STARTER SCREWS
VIS DE DÉMARREUR
PTO COUPLING
RACCORD PDM
2004
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
MAGNETO FLYWHEEL
SCREWS
VIS DU VOLANT
MAGNÉTIQUE
4 Stroke Engines/Moteurs 4-temps
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
9
(7)
17
(13)
9
(7)
17
(13)
9
(80)
9
(7)
17
(13)
9
(80)
9
(7)
17
(13)
9
(7)
17
(13)
①
①
①
①
9
(80)
①
①
①
①
①
①
➃
➃
➃
➃
➃
137
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft) /
➁③
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁
105 (77)
23
(17)
40
(30)
40
(30)
25
(18)
145
(107)
105 (77)
23
(17)
40
(30)
40
(30)
GTI LE RFI
(6104/6103)
120
(89)
105 (77)
23
(17)
40
(30)
GTX DI
(6118/6119)
115
(85)
115
(85) ①
27
(20)
LRV DI (5771)
115
(85)
115
(85) ①
RX DI
(6123/6122)
115
(85)
XP DI
(6131/6130)
115
(85)
138
SPARK PLUGS
BOUGIES
GTI LE
(6102/6101)
STARTER SCREWS
VIS DE DÉMARREUR
145
(107)
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
GT
(5568/5598/
5597/5567)
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
N•m
(lbf•ft)/
(lbf•pi)➃
CRANKCASE/
CYLINDER SCREWS
VIS DE CARTER/CYLINDRE
N•m
(lbf•ft)/
(lbf•pi)①
CYLINDER HEAD
COVER SCREWS
VIS DE COUVRE-CULASSE
2003
CYLINDER HEAD SCREWS
VIS DE CULASSE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
N•m
(lbf•ft)/
(lbf•pi) M8
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
CRANKCASE SCREWS
VIS DE CARTER
2 Stroke Engines/Moteurs 2-temps
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N.A./
S.O.
23
(17)
➄
23
(17)
10
(7)
9
(7)
23
(17)
23
(17)
25
(18)
N.A./
S.O.
24
(17)
➄
23
(17)
10
(7)
9
(7)
23
(17)
23
(17)
N.A./
S.O.
25
(18)
25
(18)
23
(17)
➄
40
(30)
10
(7)
9
(7)
22
(16)
23
(17)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
①
(lbf•pi)①
①
Smt2004-001i_couples serrage moteur.fm
①➂
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
①➂
①
➃
①
➃
139
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
CONNECTING ROD SCREWS
VIS DE BIELLE
CYLINDER HEAD SCREWS
VIS DE CULASSE
VALVE COVER SCREWS
VIS DE COUVERCLE
DE SOUPAPE
SUPERCHARGER IMPELLER
NUT
ÉCROU D’HÉLICE DE
COMPRESSEUR
SUPERCHARGER DRIVE
SHAFT NUT
ÉCROU D’ARBRE DE
COMPRESSEUR
N•m
(lbf•ft)/
(lbf•pi)
M8
N•m
(lbf•ft)/
(lbf•pi)
M10
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
GTX 4-TEC
(6111/6112/
6127)
23
(17)
250
(184)
23
(17)
40+55
(30+40)
25
(18)
25
(18)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
N.A./
S.O.
N.A./
S.O.
9
(80)
GTX 4-TEC
23
(17)
250
(184)
23
(17)
40+55
(30+40)
25
(18)
25
(18)
45 (33)
+90°
40 (30)
+120°
+90°
N.A./
S.O.
9
(80)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
30
(22)
29
(21)
45 (33)
+90°
40 (30)
+120°
+90°
9
(80)
30
(22)
29
(21)
VANS TRIPLE
CROWN EDITION
(6125/6126)
GTX 4-TEC
SUPERCHARGED
(6105/6106/
6128/6129)
GTX 4-TEC
SUPERCHARGED
LIMITED
(6107/6108)
140
➀
➀
23
(17)
➀
23
(17)
➀
➇
➇
250
(184)
➇
250
(184)
➇
➀
➀
23
(17)
➀
23
(17)
➀
➀
➀
40+55
(30+40)
➀
40+55
(30+40)
➀
①
①
25
(18)
①
25
(18)
①
①
①
25
(18)
①
25
(18)
①
Smt2004-001i_couples serrage moteur.fm
①➂
①➂
①➂
①➂
9
(80)
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
N.A./
S.O.
①
①
SPARK PLUGS
BOUGIES
CRANKCASE SCREWS
VIS DE CARTER
N•m
(lbf•ft)/
(lbf•pi)
STARTER SCREWS
VIS DE DÉMARREUR
PTO COUPLING
RACCORD PDM
N•m
(lbf•ft)/
(lbf•pi)
2003
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
MAGNETO FLYWHEEL
SCREWS
VIS DU VOLANT
MAGNÉTIQUE
4 Stroke Engines/Moteurs 4-temps
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
9
(7)
17
(13)
9
(7)
17
(13)
9
(80)
9
(7)
17
(13)
9
(80)
9
(7)
17
(13)
①
①
①
①
①
①
①
①
➃
➃
➃
➃
141
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
CRANKCASE SCREWS
VIS DE CARTER
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
CYLINDER HEAD SCREWS
VIS DE CULASSE
CYLINDER HEAD
COVER SCREWS
VIS DE COUVRE-CULASSE
CRANKCASE/
CYLINDER SCREWS
VIS DE CARTER/CYLINDRE
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
STARTER SCREWS
VIS DE DÉMARREUR
SPARK PLUGS
BOUGIES
2 Stroke Engines/Moteurs 2-temps
2002
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
M8 ➁ ➂
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁ ➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
GTI
(5558/5559)
145
(107)
105 (77)
23
(17)
40
(30)
40
(30)
25
(18)
N.A./
S.O.
24
(17)
➄
23
(17)
10
(7)
9
(7)
23
(17)
23
(17)
GTI LE
(5560/5561)
145
(107)
105 (77)
23
(17)
40
(30)
40
(30)
25
(18)
N.A./
S.O.
24
(17)
➄
23
(17)
10
(7)
9
(7)
23
(17)
23
(17)
GTI
California
GTI LE
California
(6116/6117)
145
(107)
105 (77)
23
(17)
40
(30)
40
(30)
25
(18)
N.A./
S.O.
24
(17)
➄
23
(17)
10
(7)
9
(7)
23
(17)
23
(17)
GTX DI
(5563/5564)
(5595/5596)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
LRV DI
(5460)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
GTX RFI
(5565/5566)
120
(89)
105 (77)
23
(17)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
23
(17)
➄
40
(30)
10
(7)
9
(7)
22
(16)
23
(17)
XP
(5577/5578)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
34
(25)
N.A./
S.O.
N.A./
S.O.
5
(4)
9
(7)
10
(7)
23
(17)
RX
(5579/5580)
(5581/5582)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
34
(25)
N.A./
S.O.
N.A./
S.O.
5
(4)
9
(7)
10
(7)
23
(17)
GTX
(5587/5588)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
34
(25)
N.A./
S.O.
N.A./
S.O.
5
(4)
9
(7)
10
(7)
23
(17)
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
115
(85)
115
(85) ①
27
(20)
40
(30)
N.A./
S.O.
25
(18)
25
(18)
40
(30)
N.A./
S.O.
40
(30)
N.A./
S.O.
9
(7)
10
(7)
23
(17)
142
Smt2004-001i_couples serrage moteur.fm
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
143
144
9
(80)
N.A./
S.O.
N.A./
S.O.
N•m
(lbf•ft)/
(lbf•pi)
M10
N•m
(lbf•ft)/
(lbf•pi)
23
(17)
250
(184)
23
(17)
40+55
(30+40)
25
(18)
25
(18)
➀
➇
➀
➀
①
①
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
①➂
Smt2004-001i_couples serrage moteur.fm
SPARK PLUGS
BOUGIES
40 (30)
+120°
+90°
N•m
(lbf•ft)/
(lbf•pi)
M8
STARTER SCREWS
VIS DE DÉMARREUR
VALVE COVER SCREWS
VIS DE COUVERCLE
DE SOUPAPE
45 (33)
+90°
N•m
(lbf•ft)/
(lbf•pi)
MAGNETO HOUSING
COVER SCREWS
VIS DE BOÎTIER MAGNÉTO
CYLINDER HEAD SCREWS
VIS DE CULASSE
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
SUPERCHARGER IMPELLER
NUT
ÉCROU D’HÉLICE DE
COMPRESSEUR
SUPERCHARGER DRIVE
SHAFT NUT
ÉCROU D’ARBRE DE
COMPRESSEUR
CONNECTING ROD SCREWS
VIS DE BIELLE
N•m
(lbf•ft)/
(lbf•pi)
ENGINE SUPPORT SCREWS/
ENGINE
VIS DE SUPPORT MOTEUR/
MOTEUR
N•m
(lbf•in)/
(lbf•po)
CRANKCASE SCREWS
VIS DE CARTER
N•m
(lbf•ft)/
(lbf•pi)
CRANKCASE SCREWS
VIS DE CARTER
N•m
(lbf•ft)/
(lbf•pi)
PTO COUPLING
RACCORD PDM
GTX 4-TEC
(5573/5574)
(5593/5594)
N•m
(lbf•ft)/
(lbf•pi)
MAGNETO FLYWHEEL
SCREWS
VIS DU VOLANT
MAGNÉTIQUE
2002
ENGINE SUPPORT SCREWS/
RUBBER MOUNT
VIS DE SUPPORT MOTEUR/
TAMPON D’ANCRAGE
4 Stroke Engines/Moteurs 4-temps
N•m
(lbf•in)/
(lbf•po)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
9
(80)
9
(7)
17
(13)
➃
①
①
145
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
CRANKCASE SCREWS
VIS DE CARTER
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS
VIS DE SUPPORT MOTEUR
CYLINDER HEAD SCREWS
VIS DE CULASSE
CYLINDER HEAD COVER
SCREWS
VIS DE COUVRE-CULASSE
CRANKCASE/CYLINDER
SCREWS
VIS DE CARTER/CYLINDRE
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
MAGNETO HOUSING COVER
SCREWS
VIS DE BOÎTIER MAGNÉTO
STARTER SCREWS
VIS DE DÉMARREUR
SPARK PLUGS
BOUGIES
2001
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
M8 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
GS Inter.
First Series/
Première série
(5548)
145 (107)
110 (81)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GS
(5518 ➅/
5519 ➆)
145 (107)
105 (77)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GSX RFI
Inter.
First Series/
Première série
(5549)
105 (77)
110 (81)
24 (17)
40 (30)
35 (26)
25 (18)
24 (17)
➄
40 (30)
10 (7)
9 (7)
22 (16)
24 (17)
GTS Inter.
First Series/
Première série
(5551)
145 (107)
110 (81)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GTS
(5520 ➅/
5521 ➆)
145 (107)
105 (77)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GTI Inter.
First Series/
Première série
(5552)
145 (107)
110 (81)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GTI
(5522 ➅/
5523 ➆)
145 (107)
105 (77)
24 (17)
40 (30)
40 (30)
22 (16)
24 (17)
➄
24 (17)
10 (7)
9 (7)
22 (16)
24 (17)
GTX RFI
(5524/5525/
5553/5555)
105 (77)
120 (89)
105 (77)
24 (17)
40 (30)
N.A./
S.O.
25 (18)
24 (17)
➄
40 (30)
10 (7)
9 (7)
22 (16)
24 (17)
GTX
(5526/5527/
5538/5539)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
146
Smt2004-001i_couples serrage moteur.fm
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
147
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
CRANKCASE SCREWS
VIS DE CARTER
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS
VIS DE SUPPORT MOTEUR
CYLINDER HEAD SCREWS
VIS DE CULASSE
CYLINDER HEAD COVER
SCREWS
VIS DE COUVRE-CULASSE
CRANKCASE/CYLINDER
SCREWS
VIS DE CARTER/CYLINDRE
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
MAGNETO HOUSING COVER
SCREWS
VIS DE BOÎTIER MAGNÉTO
STARTER SCREWS
VIS DE DÉMARREUR
SPARK PLUGS
BOUGIES
2001
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
M8 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
XP
(5530/5531)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
RX
(5532/5533/
5542/5543)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
RX DI
(5534/5535/
5536/5537)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
40 (30)
N.A./
S.O.
24 (17
40 (30)
N.A./
S.O.
9 (7)
10 (7)
➇
GTX DI
(5528/5529/
5540/5541)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
40 (30)
N.A./
S.O.
24 (17)
40 (30)
N.A./
S.O
9 (7)
10 (7)
➇
LRV
(5697)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
148
Smt2004-001i_couples serrage moteur.fm
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
24 (17)
149
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
CRANKCASE SCREWS
VIS DE CARTER
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS
VIS DE SUPPORT MOTEUR
CYLINDER HEAD SCREWS
VIS DE CULASSE
CYLINDER HEAD COVER
SCREWS
VIS DE COUVRE-CULASSE
CRANKCASE/CYLINDER
SCREWS
VIS DE CARTER/CYLINDRE
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
MAGNETO HOUSING COVER
SCREWS
VIS DE BOÎTIER MAGNÉTO
STARTER SCREWS
VIS DE DÉMARREUR
SPARK PLUGS
BOUGIES
2000
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
M8 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
GS
(5644/5827)
145 (107)
110 (81)
24 (17)
40 (30)
40
(30)
22 (16)
24 (17)
➄
24 (17)
10
(7)
9 (7)
22 (16)
24 (17)
GSX RFI
(5645/5654)
105 (77)
110 (81)
24 (17)
40 (30)
N.A./
S.O.
25 (18)
24 (17)
➄
40 (30)
10
(7)
9 (7)
22 (16)
24 (17)
GTS Inter.
5639
145 (107)
110 (81)
24 (17)
40 (30)
40
(30)
22 (16)
24 (17)
➄
24 (17)
10
(7)
9 (7)
22 (16)
24 (17)
GTI
(5647/5657)
145 (107)
110 (81)
24 (17)
40 (30)
40
(30)
22 (16)
24 (17)
➄
24 (17)
10
(7)
9 (7)
22 (16)
24 (17)
GTX RFI
(5648/5658/
5515/5516)
105 (77)
110 (81)
24 (17)
40 (30)
N.A./
S.O.
25 (18)
24 (17)
➄
40 (30)
10
(7)
9 (7)
22 (16)
24 (17)
GTX
(5653/5669)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
XP
(5651/5655)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
RX
(5513/5514)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
24 (17)
RX DI
(5646/5656)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
40 (30)
N.A./
S.O.
24 (17)
N.A./
S.O.
9 (7)
10 (7)
150
Smt2004-001i_couples serrage moteur.fm
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
➇
151
MAGNETO FLYWHEEL NUT
ÉCROU DU VOLANT
MAGNÉTIQUE
FLYWHEEL (PTO SIDE)
VOLANT MOTEUR (CÔTÉ PDM)
CRANKCASE SCREWS
VIS DE CARTER
CRANKCASE SCREWS
VIS DE CARTER
ENGINE SUPPORT NUTS
ÉCROUS DE SUPPORT MOTEUR
ENGINE SUPPORT SCREWS
VIS DE SUPPORT MOTEUR
CYLINDER HEAD SCREWS
VIS DE CULASSE
CYLINDER HEAD COVER
SCREWS
VIS DE COUVRE-CULASSE
CRANKCASE/CYLINDER
SCREWS
VIS DE CARTER/CYLINDRE
FLAME ARRESTER SCREWS
VIS DE PARE-FLAMMES
MAGNETO HOUSING COVER
SCREWS
VIS DE BOÎTIER MAGNÉTO
STARTER SCREWS
VIS DE DÉMARREUR
SPARK PLUGS
BOUGIES
2000
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
④
N•m
(lbf•ft)/
(lbf•pi)
M8 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
M10 ➁ ③
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
①➂
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
N•m
(lbf•ft)/
(lbf•pi)
①
N•m
(lbf•ft)/
(lbf•pi)
➃
GTX DI
(5649/5659)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
40 (30)
N.A./
S.O.
24 (17)
N.A./
S.O
9 (7)
10 (7)
LRV
(5688)
115 (85)
115
(85) ①
27 (20)
40 (30)
N.A./
S.O.
25 (18)
34 (25)
N.A./
S.O.
N.A./
S.O.
N.A./
S.O.
9 (7)
10 (7)
152
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
Smt2004-001i_couples serrage moteur.fm
➇
24 (17)
153
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
ENGINE TIGHTENING TORQUES
COUPLES DE SERRAGE
DU MOTEUR
ABBREVIATIONS
ABRÉVIATIONS
① Loctite 243 (Blue)
① Loctite 243 (bleu)
② Loctite 518
② Loctite 518
③ Synthetic Grease
③ Graisse synthétique
④ Anti-Seize Lubricant
④ Lubrifiant antigrippage
⑤ Cylinder head screws secure also cylinder head cover.
⑤ Les vis de culasse et du couvre-culasse sont les mêmes.
⑥ International Model (second series)
⑥ Modèle international (deuxième série)
⑦ Complete North America Series
⑦ Série complète Amérique du Nord
⑧ Hand tighten +1/4 turn
⑧ Serrage à la main + 1/4 de tour
⑨ Valve Cover Screw
⑨ Vis de couvercle de soupape
N.A.: Not Applicable
S.O.: Sans objet
154
Smt2004-001i_couples serrage moteur.fm
www.SeaDooManuals.net
Smt2004-001i_couples serrage moteur.fm
SECTION CONTENTS
CONTENU DE LA SECTION
PROPULSION AND STEERING
TIGHTENING TORQUES
COUPLES DE SERRAGE
PROPULSION ET DIRECTION
PAGE
TIGHTENING TORQUES
COUPLES DE
SERRAGE ................. 156
PAGE
ABBREVIATIONS
ABRÉVIATIONS........ 170
– Impeller
– Hélice
– Jet Pump Housing Nuts
– Écrous de carter de turbine
– Venturi Screws
– Vis de venturi
– Nozzle Screws
– Vis de tuyère
– Jet Pump Housing Cover
Screws
– Vis de couvercle de carter
de turbine
– Inlet Grate Screws
– Vis de grille d’admission
– Riding Plate Screws
– Vis de plaque de promenade
– Front Steering Support
– Support avant de direction
– Rear Steering Support
– Support arrière de direction
– Handlebar Clamp Bolts
– Boulons de fixation
de guidon
– Steering Stem Arm Bolt(s)
– Boulon(s) de bras
de direction
– Ball Joint Bolt (Nozzle)
– Boulon de joint à rotule
(tuyère)
Smt2004-001j_couples serrage autres.fm
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
155
①
①
①
①
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
26 (16)
①
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
①
N•m
(lbf•ft)/
(lbf•pi)
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
N•m
(lbf•ft)/
(lbf•pi)
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
②
7 (5)
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
NOZZLE SCREWS
VIS DE TUYÈRE
N•m
(lbf•ft)/
(lbf•pi)
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
VENTURI SCREWS
VIS DE VENTURI
N•m
(lbf•ft)/
(lbf•pi)
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
N•m
(lbf•ft)/
(lbf•pi)
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2004
N•m
(lbf•ft)/
(lbf•pi)
12 (9)
N.A./
S.O.
26 (19)
①
GTI
(6133/6134)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
GTI LE
(6135/6136)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
26 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
3D RFI
(6157/6158)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
8 (6) ②
26 (19)
26 (16)
21 (15)
N.A./
S.O.
12 (9)
21 (15)
7 (5)
GTI RFI
(6137/6138)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
26 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
GTI RFI LE
(6139/6140)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
26 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
XP DI
(6151/6152)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
8 (6) ②
26 (19)
26 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
GTX 4-TEC (6147/
6148)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
GTX 4-TEC
Wakeboard
Edition (6149/
6150)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
GTX 4-TEC
Supercharged
(6143/6144)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
GTX 4-TEC
Limited
Supercharged
(6141/6142)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
6 (4.5)
②
7 (5)
RXP 4-TEC
(5599/6115/6162/
6163)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
26 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
156
Smt2004-001j_couples serrage autres.fm
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
6 (4.5)
6 (4.5)
6 (4.5)
6 (4.5)
157
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
11 (8)
N.A./
S.O.
26 (19)
5 (3.5)
②
7 (5)
22 (16)
11 (8)
N.A./
S.O.
26 (19)
②
7 (5)
11 (8) ②
26 (19)
22 (16)
11 (8)
N.A./
S.O.
26 (19)
5 (3.5)
②
7 (5)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
②
7 (5)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
5 (3.5)
②
7 (5)
26 (19)
②
5 (3.5)
7 (5)
5 (3.5)
②
7 (5)
②
7 (5)
②
7 (5)
24 (18)
7.5 (6)
21 (16)
24 (18)
21 (16)
24 (18)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
GTI
(5568/5598/5597/
5567)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
GTI LE
(6102/6101)
113 (83)
31 (23)
21 (16)
24 (18)
GTI LE RFI
(6104/6103)
113 (83)
31 (23)
21 (16)
GTX DI
(6118/6119)
113 (83)
31 (23)
LRV DI
(5771)
125 (92)
31 (23)
①
①
①
①
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
11 (8) ②
26 (19)
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
7.5 (6)
NOZZLE SCREWS
VIS DE TUYÈRE
22 (16)
VENTURI SCREWS
VIS DE VENTURI
11 (8) ②
26 (19)
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
N•m
(lbf•ft)/
(lbf•pi)
IMPELLER
HÉLICE
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
N•m
(lbf•ft)/
(lbf•pi)
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
N•m
(lbf•ft)/
(lbf•pi)
2003
N•m
(lbf•ft)/
(lbf•pi)
①
①
①
RX DI
(6123/6122)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
XP DI
(6131/6130)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
8 (6) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
GTX 4-TEC
(6111/6112/6127)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
GTX 4-TEC VANS
TRIPLE CROWN
EDITION
(6125/6126)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
GTX 4-TEC
SUPERCHARGED
(6105/6106/6128/
6129)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
GTX 4-TEC
SPERCHARGED
LIMITED
(6107/6108)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8) ②
26 (19)
22 (16)
12 (9)
N.A./
S.O.
26 (19)
158
Smt2004-001j_couples serrage autres.fm
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
5 (3.5)
5 (3.5)
6 (4)
5 (3.5)
5 (3.5)
5 (3.5)
159
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8)
26 (19)
GTI LE (5560/
5561)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8)
26 (19)
GTI
California
GTI LE
California
(6116/6117)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8)
26 (19)
GTX DI
(5563/5564)
(5595/5596)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8)
26 (19)
LRV DI
(5460)
125 (92)
31 (23)
21 (16)
24 (18)
7.5 (6)
11 (8)
26 (19)
GTX RFI
(5565/5566)
113 (83)
31 (23)
21 (16)
24 (18)
3.5 (2.5)
XP
(5577/5578)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
GTI
(5558/5559)
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
①
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
①
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
NOZZLE SCREWS
VIS DE TUYÈRE
①
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
VENTURI SCREWS
VIS DE VENTURI
①
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
①
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2002
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
②
7 (5)
N.A./
S.O.
26 (19)
②
7 (5)
N.A./
S.O.
26 (19)
②
7 (5)
①
②
22 (16)
②
②
22 (16)
22 (16)
②
②
①
11 (8)
22 (16)
22 (16)
22 (16)
②
8 (6)
①
22 (16)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
6 (4)
26 (19)
RX
(5579/5580)
(5581/5582)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
GTX
(5587/5588)
113 (83)
31 (23)
21 (16)
24 (18)
7.5 (6)
②
11 (8)
26 (19)
22 (16)
②
8 (6)
①
22 (16)
①
12 (9)
①
12 (9)
26 (19)
②
RX DI
(5583/5584)
(5585/5586)
(5591/5592)
113 (83)
GTX 4-TEC
(5573/5574)
(5593/5594)
125(92)
160
31 (23)
21 (16)
24 (18)
8 (6)
7.5 (6)
①
22 (16)
①
12 (9)
6 (4)
26 (19)
31 (23)
21 (16)
24 (18)
②
11 (8)
26 (19)
7.5 (6)
Smt2004-001j_couples serrage autres.fm
②
22 (16)
①
12 (9)
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
6 (4)
161
31 (23)
21 (16)
20 (15)
4 (3)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GSX RFI
Inter.
First Series/
Première
série
(5549)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTS Inter.
First Series/
Première
série
(5551)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTS
(5520 /
5521 )
110 (81
31 (23)
21 (16)
20 (15)
7.5 (6)
GTI Inter.
First Series/
Première
série
(5552)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTI
(5522 /
5523 )
110 (81)
31 (23)
21 (16)
20 (15)
7.5 (6)
GTX RFI
(5524/5525/
5553/5555)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTX
(5526/5527/
5538/5539)
110 (81)
31 (23)
21 (16)
20 (15)
7.5 (6)
XP
(5530/5531)
110 (81)
31 (23)
21 (16)
20 (15)
7.5 (6)
GS
(5518
5519
/
)
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
110 (81)
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
①
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
①
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
NOZZLE SCREWS
VIS DE TUYÈRE
①
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
VENTURI SCREWS
VIS DE VENTURI
①
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
①
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2001
GS Inter.
First Series/
Première
série
(5548)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
②
2 (1.5)
N.A./
S.O.
26 (19)
②
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
①
①
8 (6)
①
8 (6)
①
8 (6)
①
8 (6)
②
11 (8)
26 (19)
①
8 (6)
②
11 (8)
26 (19)
22 (16)
22 (16)
22 (16)
10 (7)
22 (16)
22 (16)
22 (16)
①
22 (16)
②
22 (16)
8 (6)
11 (8)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
②
8 (6)
①
22 (16)
①
12 (9)
40 (30)
6 (4)
26 (19)
162
Smt2004-001j_couples serrage autres.fm
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
163
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
11 (8)
26 (19)
RX DI
(5534/5535/
5536/5537)
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
11 (8)
26 (19)
GTX DI
(5528/5529/
5540/5541)
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
LRV
(5697)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
7.5 (6)
164
Smt2004-001j_couples serrage autres.fm
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
RX
(5532/5533/
5542/5543)
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
①
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
①
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
NOZZLE SCREWS
VIS DE TUYÈRE
①
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
VENTURI SCREWS
VIS DE VENTURI
①
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
①
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2001
①
②
②
②
www.SeaDooManuals.net
12 (9)
②
①
22 (16)
12 (9)
①
②
11 (8)
22 (16)
②
22 (16)
11 (8)
①
②
22 (16)
12 (9)
①
12 (9)
Smt2004-001j_couples serrage autres.fm
165
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GSX RFI
(5645/5654)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTS Inter.
(5639)
110 (81
31 (23)
21 (16)
20 (15)
4 (3)
GTI
(5647/5657)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTX RFI
(5648/5658/
5515/5516)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
GTX
(5653/5669)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
XP
(5651/5655)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
8 (6)
RX
(5513/5514)
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
11 (8)
26 (19)
RX DI
(5646/5656)
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
11 (8)
26 (19)
GTX DI
(5649/5659)
113 (83)
31 (23)
21 (16)
20 (15)
7.5 (6)
166
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
GS
(5644/5827)
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
①
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
①
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
➁
2 (1.5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
N.A./
S.O.
26 (19)
6 (4)
7 (5)
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
NOZZLE SCREWS
VIS DE TUYÈRE
①
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
VENTURI SCREWS
VIS DE VENTURI
①
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
①
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2000
①
①
8 (6)
①
8 (6)
①
8 (6)
①
8 (6)
①
8 (6)
②
11 (8)
22 (16)
22 (16)
10 (7)
22 (16)
22 (16)
22 (16)
②
①
②
②
②
11 (8)
Smt2004-001j_couples serrage autres.fm
22 (16)
②
22 (16)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
①
12 (9)
②
①
22 (16)
12 (9)
②
22 (16)
①
12 (9)
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
40 (30)
167
JET PUMP HOUSING
NUTS
ÉCROUS DE CARTER
DE TURBINE
VENTURI SCREWS
VIS DE VENTURI
NOZZLE SCREWS
VIS DE TUYÈRE
JET PUMP HOUSING
COVER SCREWS
VIS DE COUVERCLE DE
CARTER DE TURBINE
①
①
①
①
①
LRV
(5688)
110 (81)
31 (23)
21 (16)
20 (15)
4 (3)
168
Smt2004-001j_couples serrage autres.fm
11 (8)
②
www.SeaDooManuals.net
22 (16)
12 (9)
①
Smt2004-001j_couples serrage autres.fm
BALL JOINT BOLT
(NOZZLE)
BOULON DE JOINT
À ROTULE (TUYÈRE)
N.A./
S.O.
STEERING STEM ARM
BOLT(S)
BOULON(S) DE BRAS
DE DIRECTION
①
HANDLEBAR CLAMP
BOLTS
BOULONS DE FIXATION
DE GUIDON
REAR STEERING
SUPPORT
SUPPORT ARRIÈRE
DE DIRECTION
FRONT STEERING
SUPPORT
SUPPORT AVANT
DE DIRECTION
RIDING PLATE SCREWS
VIS DE PLAQUE
DE PROMENADE
INLET GRATE SCREWS
VIS DE GRILLE
D’ADMISSION
IMPELLER
HÉLICE
2000
26 (19)
6 (4)
7 (5)
169
ABBREVIATIONS AND NOTES
ABRÉVIATIONS ET NOTES
PROPULSION AND STEERING
TIGHTENING TORQUES
COUPLES DE SERRAGE
PROPULSION ET DIRECTION
ABBREVIATIONS
ABRÉVIATIONS
Loctite 243 (Blue)
Loctite 243 (bleu)
Loctite 271 (Red)
Loctite 271 (rouge)
International Model (second series)
Modèle international (deuxième série)
Complete North America Series
Série complète Amérique du Nord
N.A.: Not Applicable
S.O.: Sans objet
170
Smt2004-001j_couples serrage autres.fm
www.SeaDooManuals.net
Smt2004-001j_couples serrage autres.fm
SECTION CONTENTS
CONTENU DE LA SECTION
MISCELLANEOUS
DIVERS
PAGE
Smt2004-001k_divers.fm
SI METRIC INFORMATION CHART
TABLEAU D’INFORMATION SI ....................................
172
CONVERSION FACTORS
FACTEURS DE CONVERSION ......................................
173
TIGHTENING TORQUE CONVERSION CHART
TABLEAU DE CONVERSION DES COUPLES
DE SERRAGE .................................................................
174
TAP DRILL SIZE (IMPERIAL)
GROSSEUR DES FORETS
DE TARAUDAGE (IMPÉRIAL) .......................................
179
TAP DRILL SIZE (METRIC)
GROSSEUR DES FORETS
DE TARAUDAGE (MÉTRIQUE) .....................................
181
DRILL DIAMETER DECIMAL EQUIVALENTS — mm/in
ÉQUIVALENCE DÉCIMALE
DES DIAMÈTRES DE FORETS — mm/po ....................
182
171
Smt2004-001k_divers.fm
www.SeaDooManuals.net
SI* METRIC INFORMATION CHART
TABLEAU D’INFORMATION SI*
CONVERSION FACTORS
FACTEURS DE CONVERSION
TO CONVERT/
POUR CONVERTIR
BASE UNITS — UNITÉS DE BASE
UNIT/
UNITÉ
DESCRIPTION
SYMBOL/
SYMBOLE
length/
longueur
meter/
mètre
mass/
masse
kilogram/
kilogramme
kg
force/
force
Newton
N
liquid/
liquide
litre
L
temperature/
température
celsius
°C
pressure/
pression
kilopascal
kPa
torque/
couple
Newton meter/
Newton mètre
N•m
speed/
vitesse
kilometer per hour/
kilomètre par heure
km/h
m
PREFIXES — PRÉFIXES
TO/
EN
MULTIPLY BY ①/
MULTIPLIER PAR ①
in/(po)
in/(po)
ft/(pi)
miles/(milles)
mm
cm
m
km
25.4
2.54
0.3
1.61
MPH/(mille/h)
km/h
1.61
Knot/(noeud)
MPH
1.15
HP/(CV)
kW
0.75
in²/(po²)
cm²
6.45
in³/(po³)
oz imp./(oz imp.)
oz imp./(oz imp.)
oz U.S./(oz É.-U.)
gal imp.
gal imp.
gal U.S./(gal É.-U.)
cm³
oz U.S./(oz É.-U.)
mL
mL
gal U.S./(gal É.-U.)
L
L
16.39
0.96
28.41
29.57
1.2
4.55
3.79
oz
lb
lbf
g
kg
N
28.35
0.45
4.45
lbf•in/(lbf•po)
lbf•ft/(lbf•pi)
lbf•ft/(lbf•pi)
N•m
N•m
lbf•in/(lbf•po)
0.11
1.36
12
PSI
lb/in²/(lb/po²)
kPa
6.89
Fahrenheit
Celsius
Celsius
Fahrenheit
(°F – 32) ÷ 1.8
(°C x 1.8) + 32
PREFIX/
PRÉFIXE
SYMBOL/
SYMBOLE
MEANING/
SIGNIFICATION
VALUE/
VALEUR
* The international system of units abbreviates SI in all languages.
* Le système international d’unités a pour abréviation SI dans toutes les
kilo
k
one thousand/
un millier
1,000
① TO OBTAIN THE INVERSE SEQUENCE, DIVIDE BY THE GIVEN FACTOR.
EX.: To convert mm to in, divide by 25.4.
centi
c
one hundredth/
un centième
0.01
milli
m
one thousandth/
un millième
0.001
micro
µ
one millionth/
un millionième
0.000001
langues.
172
① POUR OBTENIR LES CONVERSIONS INVERSES, DIVISER L’UNITÉ PAR
LE FACTEUR DONNÉ.
EX.: Pour convertir des mm en po, diviser par 25.4.
CONVERSION FACTORS ARE ROUNDED OFF TO TWO DECIMALS FOR
EASIER USE.
POUR FACILITER LEUR UTILISATION, LES FACTEURS DE CONVERSION
SONT ARRONDIS À DEUX DÉCIMALES.
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
173
TIGHTENING TORQUE CONVERSION CHART
TABLEAU DE CONVERSION
DES COUPLES DE SERRAGE
N•m
Tighten fasteners to torque mentioned in appropriates sections. When they
are not specified, refer to the following table. All torques apply to 8.8 grade fasteners. The chart also gives the metric conversion.
Serrer les attaches selon les couples indiqués dans les sections appropriées. Si on ne les indique pas, se référer au tableau suivant. Tous les couples s’appliquent à des attaches de classe 8.8. Le tableau donne également
les conversions métriques.
Lbf•ft/Lbf•pi
20
15
21
15
22
23
16
M8
17
24
18
25
18
26
19
27
20
28
21
29
21
30
22
31
23
35
32
24
5
44
33
24
6
53
34
25
7
62
35
26
36
27
8
71
37
27
9
80
38
28
89
39
29
40
30
41
30
42
31
N•m
FASTENER SIZE
(8.8 GRADE)/
TAILLE DE L’ATTACHE
(CLASSE 8.8)
1
2
4
10
Lbf•in/Lbf•po
9
M4
3
174
FASTENER SIZE
(8.8 GRADE)/
TAILLE DE L’ATTACHE
(CLASSE 8.8)
18
27
M5
M6
11
97
12
106
13
115
43
32
14
124
44
32
15
133
45
33
16
142
46
34
17
150
18
159
49
36
19
168
50
37
51
38
52
38
53
39
54
40
55
41
56
41
47
48
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
35
M10
35
175
N•m
FASTENER SIZE
(8.8 GRADE)/
TAILLE DE L’ATTACHE
(CLASSE 8.8)
Lbf•ft/Lbf•pi
N•m
57
42
94
69
58
43
95
70
59
44
96
71
60
44
97
72
61
45
98
72
62
46
99
73
63
46
100
74
64
47
101
74
65
48
102
75
66
49
103
76
67
49
104
77
68
50
105
77
69
51
106
78
70
52
107
79
71
52
108
80
72
53
109
80
73
54
110
81
74
55
111
82
75
55
112
83
76
56
113
83
77
57
114
84
78
58
115
85
79
58
116
86
59
117
86
81
60
118
87
82
60
119
88
83
61
120
89
84
62
121
89
85
63
122
90
86
63
123
91
87
64
124
91
88
65
125
92
89
66
126
93
90
66
127
94
91
67
128
94
92
68
129
95
93
69
130
96
80
176
FASTENER SIZE
(8.8 GRADE)/
TAILLE DE L’ATTACHE
(CLASSE 8.8)
M12
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
Lbf•ft/Lbf•pi
177
N•m
FASTENER SIZE
(8.8 GRADE)/
TAILLE DE L’ATTACHE
(CLASSE 8.8)
131
178
97
132
97
133
98
134
99
135
TAP DRILL SIZE (IMPERIAL)
GROSSEUR DES FORETS
DE TARAUDAGE (IMPÉRIAL)
-1-
Lbf•ft/Lbf•pi
M14
TAP SIZE/
GROSSEUR DU TARAUD
NO./N°
TPI
TAP DRILL/
GROSSEUR DU FORET
80 NF
3/64
1
64 NC
72 NF
53
53
2
56 NC
64 NF
50
50
3
48 NC
56 NF
47
45
4
36 NS
40 NC
48 NF
44
43
42
5
40 NC
44 NF
38
37
6
32 NC
40 NF
36
33
8
32 NC
36 NF
29
29
10
24 NC
32 NF
25
21
12
24 NC
28 NF
16
14
1/4
20 NC
28 NF
7
3
100
136
100
137
101
138
102
139
103
140
103
141
104
142
105
143
105
144
106
145
107
146
108
147
108
148
109
149
110
150
111
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
179
TAP DRILL SIZE (IMPERIAL)
GROSSEUR DES FORETS
DE TARAUDAGE (IMPÉRIAL)
-2-
TAP DRILL SIZE (METRIC)
GROSSEUR DES FORETS
DE TARAUDAGE (MÉTRIQUE)
SIZE/
GROSSEUR
mm
PITCH/
PAS
mm
DRILL/
FORET
mm
in/po
DRILL/
FORET
in/po
M1.6
M2
M2.5
M3
M4
M5
M6
M7
0.35
0.4
0.45
0.5
0.7
0.8
1.0
1.0
1.25
1.6
2.05
2.5
3.3
4.2
5.0
6.0
.049
.063
.081
.098
.130
.165
.197
.236
3/64
1/16
46
40
30
19
9
15/64
U
25/64
M8
M8
1.25
1.0
6.75
7.0
.266
.276
17/64
J
13 NC
20 NF
27/64
29/64
M10
M10
1.5
1.25
8.5
8.75
.335
.344
Q
11/32
9/16
12 NC
18 NF
31/64
33/64
M12
M12
1.75
1.25
10.2
10.7
.402
.421
Y
27/64
5/8
11 NC
18 NF
17/32
37/64
M14
M14
2.0
1.5
12.0
12.5
.472
.492
15/32
31/64
19/32
5/8
M16
M16
2.0
1.5
14.0
14.5
.551
.571
35/64
9/16
11/16
11 NC
16 NF
M18
M18
2.5
1.5
15.5
16.5
.610
.650
39/64
41/64
M20
M20
2.5
1.5
17.5
18.5
.689
.728
11/16
23/32
M24
M24
3.0
2.0
21.0
22.0
.827
.866
53/64
55/64
TAP SIZE/
GROSSEUR DU TARAUD
NO./N°
TPI
TAP DRILL/
GROSSEUR DU FORET
5/16
18 NC
24 NF
F
I
3/8
16 NC
24 NF
5/16
Q
7/16
14 NC
20 NF
1/2
3/4
7/8
180
10 NC
16 NF
21/32
11/16
9 NC
14 NF
49/64
13/16
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
181
DRILL DIAMETER DECIMAL EQUIVALENTS — mm/in
ÉQUIVALENCE DÉCIMALE DES
DIAMÈTRES DE FORETS — mm/po
-1-
DRILL DIAMETER DECIMAL EQUIVALENTS — mm/in
ÉQUIVALENCE DÉCIMALE DES
DIAMÈTRES DE FORETS — mm/po
-2-
Based on 1 inch = 25.4 mm
Basé sur 1 pouce = 25.4 mm
Based on 1 inch= 25.4 mm
Basé sur 1 pouce= 25.4 mm
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
—
—
—
—
80
79
1/64
78
77
—
76
75
74
—
73
72
71
—
70
69
—
68
1/32
—
67
66
65
—
64
63
62
61
—
60
59
0.10
0.20
0.25
0.30
0.34
0.37
0.40
0.41
0.46
0.50
0.51
0.53
0.57
0.60
0.61
0.64
0.66
0.70
0.71
0.74
0.75
0.79
0.79
0.80
0.81
0.84
0.89
0.90
0.91
0.94
0.97
0.99
1.00
1.02
1.04
.0039
.0079
.0098
.0118
.0135
.0145
.0156
.0160
.0180
.0197
.0200
.0210
.0225
.0236
.0240
.0250
.0260
.0276
.0280
.0292
.0295
.0310
.0313
.0315
.0320
.0330
.0350
.0354
.0360
.0370
.0380
.0390
.0394
.0400
.0410
58
57
56
3/64
55
54
53
1/16
52
51
50
49
48
5/64
47
—
46
45
44
43
42
3/32
41
40
39
38
37
36
7/64
35
34
33
32
—
31
1.07
1.09
1.18
1.19
1.32
1.40
1.51
1.59
1.61
1.70
1.78
1.85
1.93
1.98
1.99
2.00
2.06
2.08
2.18
2.26
2.37
2.38
2.44
2.49
2.53
2.58
2.64
2.71
2.78
2.79
2.82
2.87
2.95
3.00
3.05
.0420
.0430
.0465
.0469
.0520
.0550
.0595
.0625
.0635
.0670
.0700
.0730
.0760
.0781
.0785
.0787
.0810
.0820
.0860
.0890
.0935
.0938
.0960
.0980
.0995
.1015
.1040
.1065
.1094
.1100
.1110
.1130
.1160
.1181
.1200
1/8
30
29
28
9/64
27
26
25
24
23
5/32
22
—
21
20
19
18
11/64
17
16
15
14
13
3/16
12
11
10
9
—
8
7
13/64
6
5
3.18
3.26
3.45
3.57
3.57
3.66
3.73
3.80
3.86
3.91
3.97
3.99
4.00
4.04
4.09
4.22
4.31
4.37
4.39
4.50
4.57
4.62
4.70
4.76
4.80
4.85
4.91
4.98
5.00
5.05
5.11
5.16
5.18
5.22
.1250
.1285
.1360
.1405
.1406
.1440
.1470
.1495
.1520
.1540
.1562
.1570
.1575
.1590
.1610
.1660
.1695
.1719
.1730
.1770
.1800
.1820
.1850
.1875
.1890
.1910
.1935
.1960
.1968
.1990
.2010
.2031
.2040
.2055
4
3
7/32
2
1
A
15/64
—
B
C
D
1/4
E
F
G
17/64
H
I
—
J
K
9/32
L
M
19/64
N
5/16
—
O
P
21/64
Q
R
11/32
5.31
5.41
5.56
5.61
5.79
5.94
5.95
6.00
6.05
6.15
6.25
6.35
6.35
6.53
6.63
6.75
6.76
6.91
7.00
7.04
7.14
7.14
7.37
7.49
7.54
7.67
7.94
8.00
8.03
8.20
8.33
8.43
8.61
8.73
.2090
.2130
.2188
.2210
.2280
.2340
.2344
.2362
.2380
.2420
.2460
.2500
.2500
.2570
.2610
.2656
.2660
.2720
.2756
.2770
.2810
.2812
.2900
.2950
.2969
.3020
.3125
.3150
.3160
.3230
.3281
.3320
.3390
.3438
182
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
183
DRILL DIAMETER DECIMAL EQUIVALENTS — mm/in
ÉQUIVALENCE DÉCIMALE DES
DIAMÈTRES DE FORETS — mm/po
-3-
NOTES/NOTES
Based on 1 inch = 25.4 mm
Basé sur 1 pouce = 25.4 mm
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
DRILL SIZE/
GROSSEUR
FORET
mm
INCHES/
POUCES
S
8.84
.3480
41/64
16.27
.6406
—
T
23/64
U
3/8
V
W
25/64
—
X
Y
13/32
Z
27/64
—
7/16
29/64
15/32
—
31/64
1/2
—
33/64
17/32
35/64
—
9/16
37/64
—
19/32
39/64
5/8
—
9.00
9.09
9.13
9.35
9.53
9.58
9.80
9.92
10.00
10.08
10.26
10.32
10.49
10.72
11.00
11.11
11.51
11.91
12.00
12.30
12.70
13.00
13.10
13.49
13.89
14.00
14.29
14.68
15.00
15.08
15.48
15.88
16.00
.3543
.3580
.3594
.3680
.3750
.3770
.3860
.3906
.3937
.3970
.4040
.4062
.4130
.4219
.4331
.4375
.4531
.4688
.4724
.4844
.5000
.5118
.5156
.5312
.5469
.5512
.5625
.5781
.5906
.5938
.6094
.6250
.6299
21/32
—
43/64
11/16
45/64
—
23/32
47/64
—
3/4
49/64
25/32
—
51/64
13/16
—
53/64
27/32
55/64
—
7/8
57/64
—
29/32
59/64
15/16
—
61/64
31/32
—
63/64
1
—
16.67
17.00
17.07
17.46
17.86
18.00
18.26
18.65
19.00
19.05
19.45
19.84
20.00
20.24
20.64
21.00
21.03
21.43
21.83
22.00
22.23
22.62
23.00
23.02
23.42
23.81
24.00
24.21
24.61
25.00
25.00
25.40
—
.6562
.6693
.6719
.6875
.7031
.7087
.7188
.7344
.7480
.7500
.7656
.7812
.7874
.7969
.8125
.8268
.8281
.8438
.8594
.8661
.8750
.8906
.9055
.9062
.9219
.9375
.9449
.9531
.9688
.9842
.9844
1.0000
—
184
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
185
NOTES/NOTES
186
NOTES/NOTES
Smt2004-001k_divers.fm
Smt2004-001k_divers.fm
www.SeaDooManuals.net
187
NOTES/NOTES
188
Smt2004-001k_divers.fm
www.SeaDooManuals.net
Smt2004-001k_divers.fm
C
www.SeaDooManuals.net
M
Y
CM
MY
CY CMY
K
Download PDF