MULTIQUIP | DCA220SSCU | DCA220SSCU Emissions Data

EXHAUST EMISSION DATA SHEET
MQ POWER GENERATOR SET
Model: DCA220SSCU
The engine used in this generator set is certified to comply with
United States EPA Tier 4i and CARB Mobile Off-Highway emission regulations.
ENGINE DATA
Manufacturer: CUMMINS
Bore:
4.21
in.
( 107 mm)
Model:
QSB7-G6
Stroke:
4.88
in.
( 124 mm)
Type:
4-Cycle, In-Line, 6-cylinder, Diesel
Displacement: 408
cid
( 6.7
Aspiration:
Turbocharger, Charge Air Cool
ECM, EGR, DOC, PTO
Compression Ratio:
liters)
17.3:1
PERFORMANCE DATA
SAE Gross HP @ 1800 RPM (60 Hz)
314
Rated Load Fuel Consumption (gal/Hr)
12.4
Rated Load Exhaust Gas Flow (cfm)
996
Rated Load Exhaust Gas Temperature (ºF)
948
United States EPA - Mobile Off-Highway Tier 4i
Criteria Pollutant
Emission Requirements
NOx (Oxides of Nitrogen as NO2)
1.49
HC (Total Unburned Hydrocarbons)
NOx + HC (Combined)
Limits -
174.3 ! ~ < 750.9 BHP
Certified Engine Emissions
gr/bhp-hr
1.04
gr/bhp-hr
0.141
gr/bhp-hr
0.007
gr/bhp-hr
N/A
gr/bhp-hr
N/A
gr/bhp-hr
CO (Carbon Monoxide)
2.6
gr/bhp-hr
0.0
gr/bhp-hr
PM (Particulate Matter)
0.0149
gr/bhp-hr
0.002
gr/bhp-hr
EPA Engine Family:
DCEXL06.7AAF
EPA Certificate of Conformance:
CCEXL06.7AAF-019
ARB Executive Order:
U-R-002-0588
Effective Date:
Model Year 2013
Note: Engine operation with excessive air intake or exhaust restriction beyond factory published
maximum limits, or with improper service maintenance, may result in higher emission levels.
Data And Specifications Subject To Change Without Notice
Date: May 2013
UNITED STATES ENVIRONMENTAL PROTECTION AGENCY
2013 MODEL YEAR
CERTIFICATE OF CONFORMITY
WITH THE CLEAN AIR ACT OF 1990
Certificate Issued To: Cummins Inc.
(U.S. Manufacturer or Importer)
Certificate Number: DCEXL06.7AAF-019
Model Year: 2013
Manufacturer Type: Original Engine Manufacturer
Engine Family: DCEXL06.7AAF
Effective Date:
05/01/2012
Expiration Date:
12/31/2013
OFFICE OF TRANSPORTATION
AND AIR QUALITY
ANN ARBOR, MICHIGAN 48105
_________________________
Byron J. Bunker, Acting Division Director
Compliance Division
Issue Date:
05/01/2012
Revision Date:
N/A
Mobile/Stationary Indicator: Both
Emissions Power Category: 130<kW<=560
Fuel Type: Diesel
After Treatment Devices: Diesel Oxidation Catalyst, PTOX-DPF-Active
Non-after Treatment Devices: Electronic/Electric EGR - Cooled, Electronic Control
Pursuant to Section 111 and Section 213 of the Clean Air Act (42 U.S.C. sections 7411 and 7547) and 40 CFR Parts 60 and 1039, and subject to the terms and conditions prescribed in those provisions, this
certificate of conformity is hereby issued with respect to the test engines which have been found to conform to applicable requirements and which represent the following engines, by engine family, more
fully described in the documentation required by 40 CFR Parts 60 and 1039 and produced in the stated model year.
This certificate of conformity covers only those new compression-ignition engines which conform in all material respects to the design specifications that applied to those engines described in the
documentation required by 40 CFR Parts 60 and 1039 and which are produced during the model year stated on this certificate of the said manufacturer, as defined in 40 CFR Parts 60 and 1039.
It is a term of this certificate that the manufacturer shall consent to all inspections described in 40 CFR 1068 and authorized in a warrant or court order. Failure to comply with the requirements of such a
warrant or court order may lead to revocation or suspension of this certificate for reasons specified in 40 CFR Parts 60 and 1039. It is also a term of this certificate that this certificate may be revoked or
suspended or rendered void ab initio for other reasons specified in 40 CFR Parts 60 and 1039.
This certificate does not cover engines sold, offered for sale, or introduced, or delivered for introduction, into commerce in the U.S. prior to the effective date of the certificate.
EXECUTIVE ORDER U-R-002-0588
New Off-Road
Compression-Ignition Engines
CUMMINS INC.
Pursuant to the authority vested in the Air Resources Board by Sections 43013, 43018, 43101, 43102, 43104 and
43105 of the Health and Safety Code; and
Pursuant to the authority vested in the undersigned by Sections 39515 and 39516 of the Health and Safety Code
and Executive Order G-02-003;
IT IS ORDERED AND RESOLVED: That the following compression-ignition engines and emission control systems
produced by the manufacturer are certified as described below for use in off-road equipment. Production engines
shall be in all material respects the same as those for which certification is granted.
MODEL
YEAR
ENGINE FAMILY
2013
DCEXL06.7AAF
DISPLACEMENT
FUEL TYPE
USEFUL LIFE
(liters)
6.7
Diesel
8000
(hours)
SPECIAL FEATURES & EMISSION CONTROL SYSTEMS
TYPICAL EQUIPMENT APPLICATION
Electronic Direct Injection, Turbocharger, Charge Air
Cooler, Electronic Control Module, Exhaust Gas
Recirculation, Diesel Oxidation Catalyst, and Periodic
Trap Oxidizer
Generator Set
The engine models and codes are attached.
The following are the exhaust certification standards (STD) and certification levels (CERT) for hydrocarbon (HC),
oxides of nitrogen (NOx), or non-methane hydrocarbon plus oxides of nitrogen (NMHC+NOx), carbon monoxide
(CO), and particulate matter (PM) in grams per kilowatt-hour (g/kw-hr), and the opacity-of-smoke certification
standards and certification levels in percent(%) during acceleration (Accel), lugging (Lug), and the peak value from
either mode (Peak) for this engine family (Title 13, California Code of Regulations, (13 CCR) Section 2423):
RATED
POWER
CLASS
EMISSION STANDARD
CATEGORY
130 s kW < 560
Interim Tier 4/ALT NOx
EXHAUST (g/kw-hr)
HC
NOx
NMHC+NOx
STD
0.19
2.0
N/A
CERT
0.01
1.4
--
OPACITY(%)
co
PM
ACCEL
LUG
PEAK
3.5
0.02
N/A
N/A
N/A
0.01
0.003
--
--
--
BE IT FURTHER RESOLVED: That for the listed engine models, the manufacturer has submitted the information and
materials to demonstrate certification compliance with 13 CCR Section 2424 (emission control labels), and 13 CCR
Sections 2425 and 2426 (emission control system warranty).
Engines certified under this Executive Order must conform to all applicable California emission regulations.
This Executive Order is only granted to the engine family and model-year listed above. Engines in this
family that are produced for any other model-year are not covered by this Executive Order.
2__""-'---
Executed at El Monte, California on this _ _
k
day of August 2012.
Hebert, Chief
Mobile Source Operations Division
{). -(l.,ut/l- OS~
::ngine Family
1. Engine Code
2. Engine Model
3.BHP@RPM
(SAE Gross)
AIL-.#11~ Po lt,
4.Fuel Rate:
5.Fuel Rate:
mm/stroke@ peak HP (lbs/hr) @peak HP
(for diesel only)
(for diesels onlxl
6.Torque @ RPM
(SEA Gross)
~~XL06.JA.f:.f:._ ___3277:.':_~~_?§76 ... ____ _9S§X:§______ 340@1800 ---··- -----~~~-----
_114.2 --·--·--
N/A
~-~~.!:Q.f?J~F____}2~:~-~~?-~~!._____ QSB7-~---·---·--· 314~180_Q __________)_Q_!_______
109.6
N/A
N/A
~EXL06.7AAF
9-lw-t~--z..
7.Fuel Rate:
mm/stroke@peak
8.Fuel Rate:
9.Emission Control
torque
(lbs/hr)@peak torqueoevice Per SAE J1930
N/A
N/A
DDI,ECM.TC,CAC.EGR,
-----------------·····----·----·--f:TOX,OC ________ __
N/A
N/A
N/A
DDI,ECM,TC,CAC,EGR,
· - - - - - - - - - - - - - - · PTOX,OC
N/A
DDI,ECM,TC,CAC,EGR,
PTOX,OC ......
N/A
DDI,ECM,TC,CAC,EGR,
PTOX,OC
3277:FR92857
OS!3X:~-----·-··-- 27 4@ ~E_QQ_ _________~~§______________~---
3277:FR93508
·----
QSB7-G
~EXL06.7AAF
3277:FR93508
~EXL06.7AAF
3094:FR93515
QS87 -~---·-·- .....?_?~~15~_Q_________ _J_~~-- -···-·· ______ ]:§_.4 ---·-----~· N/A ________,._____tj_IA________ N/A ·-----------~~,Ec~b~.~~~~~~~----.
250@2000
126
84.8
N/A
N/A
N/A
DDI,ECM,TC,CAC,EGR,
QSB7
~EXL06.7AAF
_,_~ ~~·· -~--·•·"·-•-••
·-
·n-~•··
--• -·•·••
-~~6~1800__________ ~ __14~---~----87.3_____.
---·----------·--
N/A
N/A
-----------·-·--···--·--·-----
··--------------------.. ·---·------·-··---·--·----------------------.. ····--·-------------·-----·--·-·--P~Q_<:______ .. -·--DDI,ECM,TC,CAC,EGR,
PTOX,OC
~~2':!::Q§.:I.~~ __ --~-~~~:-~R.:~~~~-------_9_§_!?7....._ ..... _.??.Q@2000 _______1_!_1____ ___ .._______ _Z?.:!,_ __________ ....... _NI~---------·---~~~--------NIA ·-------~-~-~~..9~I~~-- ---~~~:~~9351_I_______ ass7 ------- 190@2ooq________~_ ..___ ,_____ __§__~_2______________ ~~---
N/A
~EXL06. 7AAF ___ }_Q95~FR9~?!3..~ _______ _9SB!.____________~OO@.?.Q00_____~----------1 03 ____ , ____ ----·- N/~----- N/A____
N/A
ooi,Ec~-ri&~~c.EGR.
N/A
DDI,EC~-ri&~~C,EGR.
~
Download PDF