Simplex | PAT SERIES | INSTALLER FRIENDLY SERIES™ - IFS Single Phase Simplex

Single phase, simplex demand dose, float controlled system for pump
control and system monitoring.
C
A
D
B
The IFS single phase simplex capacitor (start/run) control panel is designed to
control one 120, 208, or 240 VAC single phase pump in water and sewage
installations.
The IFS single phase simplex capacitor (start/run) control panel features a simple,
easy-to-use touch pad on the inner door for programming and monitoring pump
and float operation.
TOUCH PAD FEATURES
F
E
G
A.
Control Power Indicator/Fuse. Indicator light will illuminate if control power
is present in panel.
H
B.
Control Fuse Replace Indicator will illuminate if control fuse is blown. Alarm
will activate if control fuse is blown.
I
C.
Alarm Power Indicator/Fuse. Indicator light will illuminate if alarm power is
present in panel.
D.
Alarm Fuse Replace Indicator will illuminate if alarm fuse is blown.
E.
Float Indicators will illuminate when floats are activated. Alarm will activate
if a float operates out of sequence and the appropriate float indicator will flash.
F.
HOA (Hand-Off-Automatic) Buttons control pump mode with indication.
Hand mode defaults to Automatic when stop level is reached.
Model Shown IFS71W114X912A8AC
(Inner door view)
1
2
3
10
12
G.
Pump Run Indicator will illuminate when pump is called to run.
H.
Seven-Segment LED Display shows mode, pump elapsed time (hh:mm),
events (cycles), alarm counter and pump fail counter. (Display is optional.)
7
I.
Next Push Button when pressed toggles display through: mode, elapsed
time meter, cycle counter, alarm counter, and pump fail counter.
4
11
Note: LED display will turn off after one minute of not being used.
8
5
PANEL COMPONENTS
1.
Enclosure measures 14 x 12 x 6 inches (35.56 x 30.48 x 15.24 cm).
NEMA 4X (ultraviolet stabilized thermoplastic with removable mounting
feet for outdoor or indoor use).
2.
Red Alarm Beacon provides 360° visual check of alarm condition.
3.
IEC Motor Contactor controls pump by switching electrical lines.
4.
Exterior Alarm Test/Normal/Silence Switch allows horn and light to be
tested and horn to be silenced in an alarm condition. Alarm automatically
resets once alarm condition is cleared.
5.
Alarm Horn provides audio warning of alarm condition (83 to 85 decibel
rating).
6.
Float Connection Terminal Block
7.
Large Incoming Power Connection Terminal Block
8.
Terminal Block Installation Label
9.
Ground Lugs
6
9
Model Shown IFS71W114X912A8AC
(Inside view)
Reg. Cdn Pat. & TM Off
FEATURES
Q Entire control system (panel and
switches) is UL Listed to meet and/or
exceed industry safety standards
Q Dual safety certification for the United
States and Canada
Q Standard package includes three
20' Sensor Float® control switches
Q Complete with step-by-step
installation instructions
10. Alarm Activation Relay
11. Capacitor Start Module - start/run capacitor kits must be ordered
separately.
Q Three-year limited warranty
12. Circuit Breaker (optional) provides pump disconnect and branch circuit
protection.
NOTE: Schematic/Wiring Diagram and Pump Specification Label are located
inside the panel on enclosure cover
PO Box 1708, Detroit Lakes, MN 56502
1-888-DIAL-SJE • 1-218-847-1317
1-218-847-4617 Fax
email: sje@sjerhombus.com
SEE BACKSIDE FOR COMPLETE LISTING OF AVAILABLE OPTIONS.
www.sjerhombus.com
11
CONTROL PANELS
INSTALLER FRIENDLY SERIES™ - IFS Single Phase Simplex Capacitor (Start/Run)
CONTROL PANELS
IFS7
W
1
MODEL IFS7 .......................................................................................................................................... $1000.00
ALARM PACKAGE
1 = alarm package (includes test/normal/silence switch, fuse, red light, horn, & float) .................................. Base
________
ENCLOSURE RATING
W = Weatherproof, NEMA 4X (engineered thermoplastic) ............................................................................... Base
STARTING DEVICE
1 = IEC motor contactor 120/208/240V .......................................................................................................... Base
PUMP FULL LOAD AMPS
0
1
2
3
4
= 0-7 FLA .................................................................................................................................................. Base
= 7-15 FLA ................................................................................................................................................ Base
= 15-20 FLA ........................................................................................................................................... $80.00
= 20-30 FLA ........................................................................................................................................... $90.00
= 30-40 FLA ......................................................................................................................................... $115.00
________
PUMP DISCONNECTS
0 = no pump disconnect ............................................................................................................................... Base
4 = circuit breaker .................................................................................................................................. $ 70.00
________
FLOAT SWITCH APPLICATION
H or L = pump down or pump up ...................................................................................................................... Base
X = no floats
WITH alarm package ............................................................................................................................ - $75.00
OPTIONS Listed below
Start/run capacitor kits must be ordered separately (see option 12 below or call factory)
Total Options
................................................................................................................................. TOTAL LIST PRICE
________
________
If additional features are required, call the factory for a quote on an Engineered Custom control panel.
CODE DESCRIPTION
3A
5A
5E
6A
8AC
9_A
10E
10F
10K
11C
CODE
LIST PRICE
DESCRIPTION
SAMPLE
MODEL
IFS7
1
W
Alarm Package
Enclosure Rating
Starting Device
Pump Full Load Amps
Pump Disconnect
Float Switch Application
Options: Pump Overload, Motor Start
Components Supplied by Customer
12
1
1
LIST PRICE
11D NEMA 4X alarm panel must select option 6A .............. $170.00
12B Customer supplied motor start components, mounted in
enclosure by SJE-Rhombus .......................................... $110.00
12C Motor start component, mounted and supplied by
SJE-Rhombus ........................................................... Call Factory
16A 10' cord in lieu of 20' (per float) ..................................... - $2.00
16B 15' cord in lieu of 20' (per float) ..................................... - $1.00
16C 30' cord in lieu of 20' (per float) ........................................ $5.00
16D 40' cord in lieu of 20' (per float) ...................................... $15.00
17C Sensor Float® / internally weighted (per float) ................. $5.00
17D Sensor Float® / externally weighted (per float) ............... $7.00
17G SJE MilliAmpMaster™ / pipe clamp (per float) .................... $0.00
17H SJE MilliAmpMaster ™ / externally weighted (per float) ... $7.00
Alarm flasher ................................................. $50.00
Thermal cutout ............................................... $40.00
Seal fail circuit and indicator ....................... $160.00
Auxiliary alarm contact, form C type ............ $40.00
Display board includes: ETM counter, events
(cycles) counter, alarm counter. ................ $100.00
Pump overload
specify amperage after number 9 followed
by letter "A". Example: 912A = 12 amp pump.
0-30 FLA ........................................................ $60.00
30-40 FLA .................................................... $100.00
Lockable latch ................................................ $40.00
Lightning arrester ........................................ $160.00
Anti-condensation heater ........................... $100.00
NEMA 1 alarm panel ...................................... $65.00
(must select option 6A)
4
H
912A 12B
LIST PRICE IFS7 ...... $1000.00
1 ............. Base
W ............. Base
1 ............. Base
1 ............. Base
4 .......... $70.00
H ............. Base
912A .......... $60.00
12B ........ $110.00
TOTAL LIST PRICE
$1240.00
Cat Page PN 1019700A
© SJE-Rhombus Printed in USA 11/06
Download PDF