Expresso Fitness | S2R | Installation guide | Expresso Fitness S2R Installation guide

Expresso Fitness® Corporation
™
Installation Guide
Expresso Fitness Corporation
435 Lakeside Drive
Sunnyvale, CA 94085 USA
Phone: 1-888-528-8589 x9
International: 01-408-636-2200
E-mail: support@expressofitness.com
®
™
Installation Guide
Table of Contents
Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Setting up the S2r . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installing the Router . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Testing and configuring the S2r . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Before using this product, it is essential to read this entire Installation guide and all instructions.
CAUTION: Any changes or modifications to this equipment by other than authorized
personnel will void the product warranty.
While every attempt was made to verify the information in this document at the time of
writing, the information in this document is provided “as is” without warranty of any kind and
is subject to change without notice.
Copyright © 2008 by Expresso Fitness Corporation®. All rights reserved. No part of the contents
of this document may be reproduced or transmitted in any form or by any means without
written consent of the publisher.
Expresso Fitness®, the Expresso Fitness logo, Expresso Chases and S2r are either trademarks or
registered trademarks of Expresso Fitness Corporation®.
All other designated trademarks, registered trademarks, copyrights and brands are the property
of their respective owners.
2
Expresso Fitness® Corporation
Safety instructions
DANGER:
Never open the S2r computer pedestal. This
may expose you to risk of shock, fires or injury.
To reduce risk of burns or shocks only use
grounded (three prong) power cords.
YES
NO!
To reduce the risk of electrical shock, always
unplug the S2r before attempting any maintenance activity.
CAUTION:
Keep the power cord away from heated
surfaces. Do not pull the equipment by the
power cord or use the cord as a handle.
If the power cord is damaged, it must be
replaced by the manufacturer, an authorized
service agent or a similarly qualified person
to avoid a hazard.
Never operate an S2r with the air vents
blocked. Keep air openings free of lint, hair
or any obstructing materials.
Do not use this product in areas where
aerosol spray products are being used or
where oxygen is administered. Such
substances create the danger of combustion
and explosion.
If you are not used to regular physical activity, it
may be dangerous to suddenly engage in strenuous
activity. Increase your exercise level gradually.
If you feel sick or sense that something is wrong
with your body during exercise, stop immediately.
Health-related injuries may result from incorrect
or excessive use of exercise equipment. Expresso also
recommends consulting a fitness professional on
the correct use of this product.
Use the S2r only as described in this guide.
• Children or developmentally-challenged individuals
must be monitored while using S2r.
• Never place containers filled with liquids directly
on the unit, except in the water bottle holders.
Containers should be covered with lids.
• Carefully mount the S2r when starting to
exercise and dismount carefully when you’re
finished, especially if you are tired.
• Wear shoes with rubber or high-traction soles.
Do not use shoes with heels, leather soles, cleats
or spikes. Do not use the S2r with bare feet.
• Keep all loose clothing, shoelaces and towels
away from moving parts.
• Do not reach into, or underneath the S2r; and do
not tip the S2r on its side during operation.
• Keep the area around the S2r clear of any
obstructions, including walls and furniture.
Provide at least three feet of clearance behind
the unit.
• Use caution when stepping on or off of
the S2r bike.
• Never face backward while using the S2r bike.
Safety Approvals:
TUV Rheinland of North America
Do not install the S2r outdoors, near
swimming pools or in areas of high humidity.
Any changes or modifications to this
equipment by other than authorized
personnel could void the product warranty.
USAGE:
Before using the S2r, Expresso Fitness
strongly recommends seeing a medical
specialist, particularly if you are suffering
from any of the following: heart disease
(angina pectoris, myocardial infarction),
hypertension, diabetes, respiratory disease
(asthma, chronic bronchitis, pulmonary
emphysema, etc.), articular metamorphosis,
rheumatism, gout, or other diseases and
physical complaints. Pregnant women
should also consult their doctor before
beginning a training program.
EMC Compliance:
This equipment has been certified to comply
with the limits for a Class A computing device,
pursuant to Subpart B, Part 15 of FCC Rules
3
™
Installation Guide
Setting up the S2r
1. Place the S2r unit in the designated location.
2. Connect the power cord into the front power location.
NOTE: Expresso Fitness’ limited warranty on mechanical and electrical parts is voided if the
product is ever plugged into a power source that is not surge protected.
CAT5e
Connection
Power Plug
Connection
TV
Connection
Power Switch
O = off
I = on
Please turn the bike’s power switch to OFF before connecting the TV.
4
Expresso Fitness® Corporation
Installing the Router
Connecting the Expresso Fitness Linksys wireless-N broadband router
1. Connect your broadband modem or router’s Ethernet cable to the Expresso Fitness router
Internet port.
2. Connect the included power adapter to the router’s Power Port, and then plug the power
adapter into the electrical outlet. The Power LED on the router front panel will light up
when the adapter is connected properly.
3. Power on your S2r bike.
5
™
Installation Guide
Connecting the Expresso Fitness Linksys wired broadband router
1. Connect your broadband modem or router’s Ethernet cable to the Expresso Fitness router
Internet port.
2. Connect the CAT5e cables from the yellow ports on the Linksys router directly to each bike.
3. Connect the included power adapter to the router’s Power Port, and then plug the power
adapter into the electrical outlet. The Power LED on the router front panel will light up
when the adapter is connected properly.
4. Power on your S2r bike.
6
Expresso Fitness® Corporation
Testing and
Configuring the S2r
Power On S2r
Check audio
• Insert headphone jack and turn on music
Enter configuration mode
• Log onto bike using Quick Start (if not
connected to internet press Enter to
continue)
• Select Manual on the User Console
Audio jack located
on right side of seat.
(An audio jack is
also located on
the bottom right
portion of the User
Console.)
• Type 7913
• Press Enter to start configuration mode
Check/Calibrate steering
• Press Enter to select Calibrate Steering
• If steering bar is not centered then press
Enter and follow instructions to
calibrate steering.
• If steering bar is centered go to next step.
s
Properly calibrated steering
makes the “virtual bike” go
down the road straight when
the steering is centered.
Configure Time Zone
• Scroll down to Configure Time Zone and
press Enter
• Highlight appropriate time zone and
press Enter
• Push the Back button to return to the
configuration main menu
7
™
Installation Guide
Configure player number
• Scroll down to Set Player I/D and
press Enter
• Use the side arrow keys on the User
Console to select the player number
you want then press Enter
• Use the Back button to return to the
configuration menu
s
Player numbers are important
in clubs that have more than
one Expresso bike. Each bike
should receive a unique ID,
starting with #1, so players
can recognize each other on
the race course.
Enable/disable TV
• Scroll down to Enable/Disable TV
• Press Enter to turn the TV function
on or off.
Configure TV channels
• Scroll down to Configure TV Channels
and press Enter
• Use the UP/Down arrows on the User
Console to select the channel you want
to turn on or off.
• Pushing Enter will turn the channel
number you have selected on or off.
• Use the up/down arrows to select
other channels.
• To set the a “default” channel (such as
channel 3 or 4 for cable/DVD):
i. Select the channel you want to set
as the default
ii. Ensure it is turned ON (i.e., it is highlighted with a green background)
iii. Push the zero (0) key on the User
Console to set the channel as the
default TV channel.
iv. Use the Back button to exit TV
channel configuration mode.
8
Expresso Fitness® Corporation
Upload log files
• Push the Back button
• Use the down arrow on the User Console
to highlight Use Network then press Enter
• Use the down arrow to highlight Upload
Log Files then press Enter.
Exit configuration mode
• Push the Back button
• Use the down arrow on the User Console
to highlight Exit Configuration then
press Enter
• You will now be returned to Touring Mode.
Check to make sure Heart Rate
is working
• Place both hands on handlebars. Within
five to ten seconds, you should see
“calibrating heart rate” followed by your
heat rate reading on the screen.
• Check wireless heart rate using Polar®
pulse simulator or belt.
Check the following:
• Make sure Speed and RPM are displaying
on the screen
• Make sure Multiplayer is working by
placing all bikes on the same route and
verifying that all player numbers are
displayed on the route track in the left
top corner of the screen
• Check to make sure bike shifts gears
• Press all keys on User Console to make
sure they function correctly
• Check that there is no drive train
slippage (high gear 25-30)
Contact Expresso Fitness and notify us of
installation and upload of file.
• Call 1-888-528-8589 x9
9
™
Installation Guide
Customer Service contact information
Customer Service Phone number:
1-888-528-8589 x9
support@expressofitness.com
Customer Service Hours:
6:00 AM - 5:00 PM (PST)
Monday thru Friday
Power Specifications:
Power:
100-240V 3A 50/60HZ
Label is located on the bike right side were the bike meets the computer
10
Expresso Fitness® Corporation
11
™
Installation Guide
®
Expresso Fitness Corporation
435 Lakeside Drive
Sunnyvale, CA 94085 USA
Document # 2500.0023.01/RevB
Download PDF