Bowflex | ULTIMATE 2 | Accessory Racks Service Manual

Accessory Racks
Service Manual
Bowflex Ultimate® 2 Accessory Rack
Bowflex Revolution™ Accessory Rack
PN 001-6932 Rev A (5/2006)
Table of Contents
Product Specifications ......................................................2
Safety Information ..............................................................3
Replacement Parts
Exploded Views ............................................................4
Replacement Parts Lists .............................................5
Warranty Information .........................................................6
Contact Information ...........................................................7
Product Specifications
Bowflex Ultimate® 2 Accessory Rack
Dimensions:
41" L x 26" W x 37" H (104cm x 66cm x 94cm)
Weight:
55 lbs. (25kg)
Bowflex Revolution™ Accessory Rack
Dimensions:
31" L x 29" W x 37" H (79cm x 74cm x 94cm)
Weight:
50 lbs. (22.7kg)
�� � � � � � � �
Safety Requirements
IMPORTANT SAFETY INSTRUCTIONS
�������������������������
The following
definition applies to the word “Caution” found throughout this manual:
�������
Used to call attention to POTENTIAL hazards that could result
in personal injury or damage to equipment.
READ ALL INSTRUCTIONS BEFORE USING THE EQUIPMENT.
•
Always read and follow the Safety labels attached to
your Bowflex Ultimate® 2 Accessory Rack or Bowflex
Revolution™ Accessory Rack. Do not remove these
labels. If you need replacement labels, please call a
Nautilus Representative at 1-800-NAUTILUS (6288458).
•
Read the owner’s manual and follow it carefully
before using the rack.
•
Never allow children to use the Bowflex Ultimate® 2
Accessory Rack or Bowflex Revolution™ Accessory
Rack unsupervised. To do so could result in injury.
This equipment is under no circumstances suitable
as a children’s toy.
•
Inspect your rack for any worn or loose components
prior to use. Tighten or replace any worn or loose
components prior to use.
•
Set up and use your Bowflex Ultimate® 2 Accessory
Rack or Bowflex Revolution™ Accessory Rack on a
hard, level surface.
•
Use your Bowflex Ultimate® 2 Accessory Rack
ONLY to store accessory equipment for your
Bowflex Ultimate® 2 home gym. Use your Bowflex
Revolution™ Accessory Rack ONLY to store
accessory equipment for your Bowflex Revolution™
home gym. Store each accessory only in its
designated holder on the rack.
Safety Warning Labels
The following safety warnings are located in site specific areas on the Bowflex Ultimate® 2 Accessory Rack. Please
read all safety precautions and warning information prior to using your product. Be sure to replace any warning label if
damaged, illegible, or missing. If you need replacement labels, please call a Nautilus Representative at 1-800-NAUTILUS
(628-8458)
Label 1: Please make sure all users read, understand, and follow the warning labels on the rack. See Figure A.
Figure A
Location: The warning label in Figure B is located on the
Base Plate under the U-bar. Store only the Leg
Extension on this holder.
Figure B
Label 1
Bowflex® Accessory Rack Service Manual
3
REPLACEMENT PARTS
Part number information in the following tables is meant to help you identify the parts in each drawing for ordering
replacement parts. Call an authorized Nautilus representative at 1-800-NAUTILUS (624-8458) to order replacement parts
and get assistance with your specific replacement or service requirements. Items with no warranty code or part number are
replaceable only as part of a higher-level assembly.
�
��
Bowflex Ultimate® 2 Accessory Rack
��
�
�
�
��
�
�
�
�
�
�
Bowflex Revolution™ Accessory Rack
�
�
�
�
������������������������
�
�
4
REPLACEMENT PARTS
WARRANTY NOTES (FOR UNITS IN USA ONLY):
CUST90 – 90 day customer satisfaction guarantee
CUST42 – 6 week customer satisfaction guarantee
If you do not see a reference # for the part you are looking
for, please send out a replacement box.
Bowflex Ultimate® 2 Accessory Rack Parts List
REF#
WRNTY CODE
PART NO.
DESCRIPTION
1
CUST90
10083
CAP - END 1 3/4 X 2”
2
CUST90
000-2499
CAP - END 16MM TUBE
3
CUST90
000-3371
PLUG, TUBE 1.75” X 3” FLAT U2
4
CUST90
000-3891
DECAL - BFX PLATE SM
5
CUST90
000-4004
PVC FOOT CAP
6
CUST90
001-7383
BRKT - BAR HOOK
7
CUST90
001-7398
BAR -TOWEL
8
CUST90
001-7404
BOX - STORAGE
9
CUST90
001-7460
BAG - FLEX OWNERS MANUAL HOLDER
CUST90
001-7471
HARDWARE CARD - U2 RACK
SCREW - BHCS 0.375-16 x 0.875 G2-BlkO (qty - 2)
SCREW - BHCS 0.375-16 x 2.75 G2-BlkO (qty - 20)
NUT - NL 0.375-16 G2-BlkZ (qty - 20)
WASHER - FLAT 0.375 NARROW BLKZ (qty - 40)
HEX KEY
10
CUST90
001-7538
CURL BAR HOOK KIT - LEFT & RIGHT
11
CUST90
001-7539
WASHER HOOK KIT (INCLUDES 2 HOOKS)
CUST90
001-7540
PRE-ASSEMBLED HARDWARE BAG - U2 RACK
SCREW-BHCS 0.375-16x0.875 G2-BlkO (qty - 4)
WASHER-FLAT 0.375 NARROW BLKZ (qty - 4)
CUST42
001-6930
ASSEMBLY MANUAL - U2 RACK
If you do not see a reference # for the part you are looking
Bowflex Revolution™ Accessory Rack Parts List for, please send out a replacement box.
REF#
WRNTY CODE
PART NO.
DESCRIPTION
1
CUST90
10083
CAP, END 1 3/4 X 2”
2
CUST90
000-3890
DECAL - BFX PLATE XS
3
CUST90
000-4004
PVC FOOT CAP
4
CUST90
000-4104
ULTIMATE 2 PLASTIC SLIDER
5
CUST90
001-7460
BAG - FLEX OWNERS MANUAL HOLDER
CUST90
001-7475
HARDWARE CARD - REVOLUTION RACK
SCREW - BHCS 0.375-16 x 0.875 G2-BlkO (qty -9)
SCREW - BHCS 0.375-16 x 2.75 G2-BlkO (qty - 16)
NUT - NL 0.375-16 G2-BlkZ (qty - 16)
WASHER-FLAT 0.375 NARROW BLKZ (qty - 41)
HEX KEY
6
CUST90
001-7538
CURL BAR HOOK KIT - LEFT & RIGHT
CUST42
001-6931
ASSEMBLY MANUAL - REVOLUTION RACK
Bowflex® Accessory Rack Service Manual
5
WARRANTY
LIMITED WARRANTY FOR EXERCISE PRODUCTS
All Bowflex® branded exercise products manufactured by Nautilus, Inc. are warranted to the retail purchaser to be free from defects in materials and
workmanship. Warranty coverage valid to the original purchaser only and proof of purchase will be required. Any product sold or placed in an application
not recommended by Nautilus will void any warranty coverage set forth by Bowflex® warranty policies and procedures.
TIME PERIOD
This product was designed, warranted, and intended for residential use only.
Residential Environment:
Frame Parts: 90 days
THIS WARRANTY DOES NOT COVER
1. Use in a commercial setting such as health clubs, schools, hotels and hospitals.
2. Damage due to normal wear and tear.
3. Any damage, failure or loss caused by accident, misuse, neglect, abuse, improper assembly, improper maintenance, Acts of God (such as floods or
power surges), or failure to follow instructions or warnings in Owner’s Manual.
4. Use of products in an application not recommended by Nautilus, Inc., or in a manner or environment for which they were not designed.
5. Extended warranties: Nautlus will not be responsible for any extended coverage terms offered by a distributor or service provider.
LIMITATIONS
The foregoing warranties are in lieu of and exclude all other warranties not expressly set forth herein, whether express or implied by operation of law or
otherwise, including, but not limited to, WARRANTY OF MERCHANTABILITY or WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE. Nautilus,
Inc. shall in no event be liable for incidental or consequential losses, damages or expenses in connection with its exercise products. Nautilus liability
hereunder is expressly limited to the replacement of goods not complying with this warranty or, at Nautilus election, to the repayment of an amount
of the purchase price of the exercise product in question. Some states do not permit the exclusion or limitation of implied warranties or incidental
or consequential damages, so the preceding limitations and exclusions may not apply to you.
PROCEDURES
Warranty service will be performed by the original retailer (seller) or an authorized Bowflex® service provider. The original purchaser must provide
proof of purchase. Service calls, assembly, transportation, and/or delivery expenses are the responsibility of the purchaser: 1-800-NAUTILUS (6288458).
1. Nautilus will have the option to repair or replace any exercise product(s), which require warranty service.
2. Nautilus will replace any equipment frame that is structurally defective with a new frame or replace the unit with a unit of equal value. Nautilus is
not responsible for labor charges in replacing defective frames.
3. In the event a product cannot be repaired, Nautilus will apply a limited credit reimbursement toward another Bowflex® exercise product of
equal or greater value.
4. Nautilus is not responsible for dealer labor charges for component changeovers completed after the labor-related warranty period(s) stated
herein.
5. If you elect to repair an exercise product or part yourself, using the services of someone other than an Authorized Bowflex® Dealer, or use a
replacement part not supplied by Nautilus, Nautilus shall not be liable for any cost, damage, failure or loss caused by the use of such unauthorized
service or parts.
6. See an authorized Bowflex® distributor for more information or write to us at:
Nautilus, Inc.
16400 SE Nautilus Dr.
Vancouver, Washington, USA 98683
6
IMPORTANT CONTACT NUMBERS
If you need assistance, please have both the serial number of your machine and the date of purchase available when
you contact the appropriate Nautilus office listed below.
WORLDWIDE CUSTOMER SERVICE
• NORTH AMERICA OFFICE
Nautilus, Inc.
World Headquarters
16400 S.E. Nautilus Drive
Vancouver, Washington, USA 98683
Phone: 800-NAUTILUS (628-8458)
Fax: 877-686-6466
E-mail: cstech@nautilus.com
INTERNATIONAL CUSTOMER SERVICE
• SWITZERLAND OFFICE
Nautilus International S.A.
Rue Jean Prouve 6
1762 Givisiez / Switzerland
Tel: +41-26-460-77-77
Fax: +41-26-460-77-70
E-mail: technics@nautilus.com
INTERNATIONAL OFFICES:
• SWITZERLAND OFFICE
Nautilus International S.A.
Rue Jean Prouve 6
1762 Givisiez / Switzerland
Tel: +41-26-460-77-66
Fax: +41-26-460-77-60
Web: www.nhfg-intl.com
• GERMANY and AUSTRIA OFFICE
Nautilus GmbH
Tel: 02204-61027
Fax: 02204-62890
• ITALY OFFICE
Nautilus Italy s.r.l.
Tel: 031-51-10-86
Fax: 031-34-24-97
• UNITED KINGDOM OFFICE
Nautilus UK Ltd.
Tel: 01-908-267-345
Fax: 01-908-267-346
• CHINA OFFICE
Nautilus Representative Office
Tel: +86-21-523-707-00
Fax: +86-21-523-707-09
Bowflex® Accessory Rack Service Manual
7
Specifications subject to change.
© 2005 Nautilus, Inc. All Rights Reserved. Bowflex, the Bowflex logo, Bowflex Ultimate and Bowflex Revolution are either registered trademarks or trademarks of Nautilus, Inc.
Nautilus Inc., World Headquarters, 16400 SE Nautilus Drive, Vancouver, Washington, USA 98683
1-800-NAUTILUS www.nautilus.com
8
Download PDF