Savin | 9520 | MSDS Unlimited(tm) 2002

Savin Black Toner 9520
RTN Number: 00002085
Page 1 of 5
December 15, 2008
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Identification
Product Name: Savin Black Toner 9520
Product Number: 887573 (4303)
Chemical Name: mixture
CAS Number: 0-00-0
Company Identification
Ricoh Americas Corporation
5 Dedrick Place
West Caldwell, NJ 07006 USA
1-973-882-2000 or 1-973-882-5218 (For product information)
1-800-336-6737 (For emergencies)
GENERAL USE:
9520.
2. COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT LISTING:
Chemical Name
STYRENE ACRYLIC RESIN
CARBON BLACK
DYE
EXPOSURE GUIDELINES:
Carbon Black
OSHA PEL: 3.5 mg/m^3
ACGIH TWA: 3.5 mg/m^3
3. HAZARDS IDENTIFICATION
PRIMARY ENTRY ROUTES:
Inhalation, skin, ingestion.
ACUTE EYE EFFECTS:
May cause slight transient irritation.
ACUTE SKIN EFFECTS:
May be non-irritant.
ACUTE INHALATION EFFECTS:
Exposure to excessive amount of dust may cause physical irritation to respiratory tract.
Amount
> 85.0 %
< 15.0 %
< 5.0 %
CAS Number
Confidential
1333-86-4
Confidential
Savin Black Toner 9520
RTN Number: 00002085
Page 2 of 5
December 15, 2008
ACUTE INGESTION EFFECTS:
Low acute toxicity in animal experiment.
CARCINOGENICITY:
Carbon black contained in this product is classified to Group 2B of IARC as the result of only inhalation test in use of rat. But
oral/skin test does not show carcinogenicity. The toner containing carbon black did not show carcinogenicity in chronic inhalation
exposure test in use of rat.
MEDICAL CONDITION AGGRAVATED BY LONG-TERM EXPOSURE:
Not applicable.
CHRONIC EFFECTS:
Slight pulmonary fibrosis has been reported in rats upon chronic inhalation exposure to a toner at 4mg/m3 every day for 2 years. No
pulmonary change was found at 1mg/m3. These findings show that exposure to excessive amounts of powder may cause damage to
lungs. However, normal use and handling of this product as intended, does not result in inhalation of excessive amounts of powder.
4. FIRST AID MEASURES
EYE CONTACT FIRST AID:
Flush with a large amount of water until particles are removed. Seek medical advice.
SKIN CONTACT FIRST AID:
Wash thoroughly with soapy water.
INHALATION FIRST AID:
Remove from exposure into fresh air and rinse mouth with water. Seek medical advice.
INGESTION FIRST AID:
Drink several glasses of water to dilute ingested toner. Seek medical advice.
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES
COC Flash Point: N/A
Autoignition Temperature: N/A
FLAMMABLE LIMITS IN AIR
LEL: N/A
UEL: N/A
BURNING RATE:
(mm/sec): 0.223 or below.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
Can form explosive dust air mixtures when finely dispersed in air.
FIRE FIGHTING INSTRUCTIONS:
No special fire protecting method is required. Sprinkling or fire extinguishers can be used.
6. ACCIDENTAL RELEASE MEASURES
SPILL / LEAK PROCEDURES:
Confirm there is no source of fire and if there is a source, remove it. Sweep up spilled powder slowly and clean remainder with wet
Savin Black Toner 9520
RTN Number: 00002085
Page 3 of 5
December 15, 2008
cloth.
MISCELLANEOUS:
Do not breath in dust. Do not flush into sewers and watercourses.
7. HANDLING AND STORAGE
HANDLING PRECAUTIONS:
Do not handle in areas where there is wind or draught, this may cause dust to get into eyes. Avoid breathing in dust.
STORAGE REQUIREMENTS:
Keep out of reach of children. Store in dry, well-ventilated area, to maintain quality the temperature should not exceed 35 degrees
centigrade for a long time. Avoid direct sunlight.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
VENTILATION:
None required with intended use.
RESPIRATORY PROTECTION:
None required in normal use.
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM:
COLOR:
ODOR:
BOILING POINT:
VAPOR PRESSURE:
VAPOR DENSITY:
SOLUBILITY IN WATER:
MELTING/FREEZING POINT:
PH:
% VOLATILES:
VISCOSITY:
EVAPORATION RATE:
Solid powder
Black
slight plastic odor
Not applicable C
Not applicable psia
Not applicable (Air = 1)
Insoluble
Not available C
Not applicable
-%
Not applicable
Not applicable
10. STABILITY AND REACTIVITY
STABILITY:
Stable.
POLYMERIZATION:
None.
CONDITIONS TO AVOID:
Not applicable in normal use.
HAZARDOUS DECOMPOSITION PRODUCTS:
Decomposition products will not occur.
Savin Black Toner 9520
RTN Number: 00002085
Page 4 of 5
December 15, 2008
11. TOXICOLOGICAL INFORMATION
ACUTE ORAL EFFECTS:
(LD50): >5000mg/kg.
CARCINOGENICITY:
Carbon black contained in this product is classified to Group 2B of IARC as the result of inhalation test in use of rat. But oral/skin
test does not show carcinogenicity. The toner containing carbon black did not show carcinogenicity in chronic inhalation exposure
test in use of rat.
MUTAGENICITY:
Negative (Ames test).
TERATOGENICITY:
Not available.
12. ECOLOGICAL INFORMATION
ENVIRONMENTAL DEGRADATION:
Not available.
MISCELLANEOUS:
Not available.
13. DISPOSAL CONSIDERATIONS
DISPOSAL:
Disposal recommendations are based on material as supplied. Disposal must be in accordance with current applicable laws and
regulations, and material characteristics at time of disposal. Confirm disposal procedures with local regulations.
MISCELLANEOUS:
Do not throw the toner cartridge or toner into an open flame. Hot toner may scatter and cause burns or other damage.
14. TRANSPORT INFORMATION
PRODUCT LABEL:
Savin Black Toner 9520
MISCELLANEOUS:
Avoid direct sunlight in quality.
15. REGULATORY INFORMATION
No information available.
16. OTHER INFORMATION
HMIS Rating:
Health - 1
Flammability - 1
Savin Black Toner 9520
RTN Number: 00002085
Page 5 of 5
December 15, 2008
Reactivity - 0
APPROVED BY:
TITLE:
APPROVAL DATE:
SUPERCEDES DATE:
RTN NUMBER:
David Huelbig
Safety Engineer
December 15, 2008
August 31, 2004
00002085 (Official Copy)
**********************************************************************
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Ricoh
Americas Corporation. The data on this sheet are related only to the specific material designated herein. Ricoh Americas
Corporation assumes no legal responsibility for use or reliance upon these data.
**********************************************************************
END OF MSDS
**********************************************************************
Download PDF

advertising