AN/TPN 18 Radar Technical Manual
Below you will find brief information for Radar AN/TPN-18. The Radar AN/TPN-18 is a complex piece of equipment that requires specialized skills and knowledge to operate and maintain. This manual provides a comprehensive overview of the Radar AN/TPN-18's components and repair parts, as well as instructions for organizational maintenance.
advertisement
TECHNICAL MANUAL
ORGANIZATIONAL MAINTENANCE
REPAIR PARTS AND SPECIAL TOOLS LISTS
FOR
RADAR SET AN/TPN-18
(NSN 5840-00-944-2452)
HEADQUARTERS, DEPARTMENT OF THE ARMY
APRIL 1979
*TM 11-5840-281-20P
TECHNICAL MANUAL
No. 11-5840-281-20P ,
}
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, DC,
10 April 1979
ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS
FOR
RADAR SET AN/TPN-1 8
(NSN 5840-00-944-2452)
Current as of 20 October 1978
REPORTING OF ERRORS
You can improve this manual by recommending improvements using DA Form 2028-2 located in the back of your manual. Simply tear out the self-addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail.
If there are no blank DA Form 2028-2 in the back of your manual, use the standard DA Form 2028
(Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL-ME-MQ, Fort Monmouth, New
Jersey 07703.
In either case a reply will be furnished direct to you.
Table of Contents
SECTION
Group
Page
Introduction ...............................................................................................................................
Repair parts list .........................................................................................................................
Radar Sets AN/TPN-18 .............................................................................................................
Radar set group.........................................................................................................................
0101 Actuator, elevation servo-azimuth tilt (No parts authorized)
0102
0103
Azimuth Antenna AS-1292/TPN-8 and Yoke Assembly (No parts authorized)
Elevation Antenna AS-1291/TPN-8 and Yoke Assembly (No parts authorized)
0104 Drive, Azimuth Antenna TG- 113/TPN-8 (No parts authorized)
0105 Drive, Elevation Antenna TG-I 14/TPN-8 (No parts authorized)
01070101 Amplifier, Intermediate Frequency AM-3339/TPN-8 ...........................................
01070102 Amplifier, Intermediate Frequency AM-3337/TPN-8 ...........................................
01070103 Amplifier, video (No parts authorized)
01070104 Amplifier, Intermediate Frequency AM-3338/TPN-8 ...........................................
01070105 Amplifier assembly, drive motor (No parts authorized)
01070106 Amplifier, electronic control (No parts authorized)
01070110 Power Supply PP-3382/TPN-8 (No parts authorized)
01070111 Power Supply PP-3381/TPN-8 (No parts authorized)
01070112 Preamplifier electronic control (No parts authorized)
01070113 Regulator voltage 35V (No parts authorized)
01070115 Adapter, test, receiver-transmitter (No parts authorized)
010702 Rotary mount base and frame, R-T (No parts authorized)
02 Control indicator group (No parts authorized)
This manual supersedes TM 11-5840-281-20P, 27 July 1970.
i
Illus
Figure
Group
SECTION
TM 11-5840-281-20P
Page
02010201 Comparator, sawtooth (No parts authorized)
02010202 Control, cursor (No parts authorized)
02010203 Generator, trigger delay (No parts authorized)
02010204 Generator, azimuth-elevation blanking pulse (No parts authorized)
02010205 Generator, range mark (No parts authorized)
02010206 Generator, sawtooth (No parts authorized)
02010207 Generator, cursor (No parts authorized)
02010208 Generator, sweep (No parts authorized)
02010209 Oscillator, range mark (No parts authorized)
020103
Mixer-amplifier (No parts authorized)
02010401 Amplifier, fixed coil (No parts authorized)
02010402 Rectifier, indicator (No parts authorized)
02010403 Regulator, voltage 12V (No parts authorized)
02010404 Regulator, voltage 35V (Same as group 01070113)
02010405 Regulator, voltage 18V (No parts authorized)
03 Adapter, test, pulse generator card (No parts authorized)
04 Simulator, radar target (No parts authorized)
05 Cable installations interconnecting (No parts authorized)
Ill.
Special tools list (Not applicable)
Illus
Figure
ii
TM 11-5840-281-20P
SECTION I
INTRODUCTION
1.
Scope
This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment
(TMDE), and other special support equipment required for performance of organizational maintenance of the
AN/TPN-1 g. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes.
2.
General
This Repair Parts and Special Tools List is divided into the following sections: a.
A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence.
b.
Section III. Special Tools List. Not applicable.
c.
Section IV. National Stock Number and Part
Number Index.
A list, in National item identification number (NUN) sequence, of all National stock numbers
(NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross- referenced to each illustration figure and item number appearance.
3.
Explanation of Columns
a.
Illustration. This column is divided as follows:
(1) Figure number.
Indicates the figure number of on unserviceable items.
(2) Item number. The number used to identify item called out in the illustration.
b.
Source, Maintenance, and Recoverability (SMR)
Codes
(1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or and dispose at the level indicated in position 3.
overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows:
Code Definition
PA
Item procured and stocked for anticipated or known usage.
XD
A support item that is not stocked. When required, item will be procured through normal supply channels.
NOTE
Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft sup port items as restricted by AR-
700-42.
(2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows:
(a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item.
The maintenance code entered in the third position will indicate one of the following levels of maintenance:
Code Application/Explanation
O
Support item is removed, replaced, used at the organizational level.
( b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (.e., all authorized maintenance functions). This position will contain one of the following maintenance codes
Code Application/Explanation
F
The lowest maintenance level capable of complete repair of the support item is the direct support level.
H
The lowest maintenance level capable of complete repair of the support item is the general support level.
Z
Nonreparable. No repair is authorized.
(3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action
The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows:
Recoverability
Codes Definition
Z
Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3.
F
Reparable item. When uneconomically reparable, condemn and dispose at the direct support level.
H
Reparable item. When uneconomically reparable, condemn and dispose at the general support level.
c.
National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes.
d.
Part Number.
Indicates the primary number used by the manufacturer (individual, company, firm, corpora-tion, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items.
1
TM 11-5840-281-20P
NOTE
When a stock numbered item is requisitioned, may be a break in the item number sequence. Only illustrations containing organizational authorized items appear in this manual.
the repair part received may have a different part number than the part being replaced.
e.
Federal Supply Code for Manufacturer (FSCM).
The FSCM is a 5-digit numeric code listed in SB 708-42 which is used to identify the manufacturer, distributor, or
Government agency, etc.
f.
Description. Indicates the Federal item name
5.
How to Locate Repair Parts
a .
When National stock number or part number is unknown.
(1) First. Using the table of contents, determine the functional group within which the item and, if required, a minimum description to identify the item. g. Unit of Measure (UIM).
Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is ex-pressed by a two-character alphabetical abbreviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups.
(2) Second Find the illustration covering the functional group to which the item belongs.
(3 ) Third. Identify the item on the illustration and note the illustration figure and item number of the issue that will satisfy the required units of measure will be requisitioned.
h.
Quantity Incorporated in Unit.
Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly.
item.
(4)
Fourth.
Using the Repair Parts Listing, find the figure and item number noted on the illustration.
b.
when National stock number or part number is known.
(1) First. Using the Index of National Stock
4.
Special Information
a.
The following publication pertains to the
AN/TPN-18 and its components: TM 11-5840-281-12,
Radar Set AN/TPN-18 b .
The illustrations in this manual are identical to
Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number.
(2) Second. After finding the figure and item those published in TM 11-5840-281-34P. Only those parts assigned the third position SMR maintenance code
"C" or "O" are listed in the tabular listing; therefore, there number, locate the figure and item number in the repair parts list.
6.
Abbreviations
Not applicable.
(Next printed page is 4)
2
TM11-5840-281-20P
Figure 1. Radar Set AN/TPN-18.
4
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
1
1
1
1
1
1
1
1
1
5 PAOZZ 4030-00-889-2364 G400054-2
6 XDOZZ 3119151A030
7 XDOFF
8 PAOZZ 5340-00-066-4052
180963-1
G500001-1
9 PAOZZ 5340-00-066-4192 GS500001-2
10 PAOFF 5840-00-433-2359 112449
14 PAOZZ 5840-00-433-2358 103188
15 PAOZZ 5330-00-433-3754 116502
16 XDOHH 100253
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP O0 RADAR SET AN/TPN-18
24930 ANCHOR,GUY.........................................................
7012B STRAP,WEBBING ...................................................
24930 RADAR SET GROUP ..............................................
24930 ROD ........................................................................
24930 ROD, STRAIGHT.....................................................
24930 SHIELD RAIN INDICAT ...........................................
24930 DEFLECTOR,RAIN..................................................
24930 GASKET ..................................................................
24930 SIMULATOR,RDR T ................................................
EA 1
EA 1
EA 1
EA 1
EA 1
EA 2
EA 2
EA 1
EA 3
5/(6 blank)
TM11-5840-281-20P
Figure 2. Radar Set Group (Sheet 1 of 2).
7
ELOTN002
Figure 2. Radar Set Group (Sheet 2 of 2).
8
TM11 -5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
4 PAOZZ 5840-00-191-9343 102824-1
5 XDOFF 103157-1
6 PAOZZ 5305-00-054-6680 NS51957-53
7 PAOZZ 5310-00-933-8119 HS35338-137
8 PAOZZ 5840-00-191-9341 102823-5
9 PAOZZ 5840-00-191-9342 102823-6
10 XDOFF
11 XDOFF
103155-1
103156-1
12 PAOHH 5840-00-082-3728 TG113TPN8B
13 PAOZZ 5310-00-939-2655 MS51972-2
14 PAOZZ 5306-00-656-0193 MS35308-339
15 PAOZZ 15310-00-625-5756 MS15795-812
16 PAOZZ 5310-00-974-6623 MS35338-140
21 PAOHH 5840-00-078-5621 AB738TPNB
28 PAOHH 5840-0082-37271 TG114TPNB
30 PAOZZ 5330-00-806-3197 MS90064-14
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01 RADAR SET GROUP
24930 WAVEGUIDE...........................................................
24930 CABLE ASSY,PR ....................................................
96906 SCREW,MACHINE ..................................................
96906 WASHERLOCK .......................................................
24930 WAVEGUIDE...........................................................
24930 WAVEGUIDE...........................................................
24930 CABLE ASSYPR .....................................................
24930 CABLE ASSY,SPCL ................................................
80058 DRIVE,AZIMUTH A..................................................
96906 NUT.PLAIN.HEXAGON ...........................................
96906 BOLT,MACHINE ......................................................
96906 WASHERFLAT ........................................................
96906 WASHER,LOCK ......................................................
80058 PEDESTAL,ANTENN ..............................................
80058 DRIVE.ELEVATION.................................................
969061 PACKING,PERFORMED .........................................
EA 1
EA 4
EA 4
EA 4
EA 4
EA 1
EA 1
EA 12
EA 1
EA 1
EA 8
EA 37
EA 1
EA 1
EA 1
EA 1
9
Figure 3. Pedestal, Antenna AB-738/TPN-8
10
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
3 6 XDOHH
(4)
PART
NUMBER
00204
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 0106 PEDESTAL,ANTENNA AB-738/TPN-8
24931 LEG ASSY ...............................................................
EA 3
11
TM11-5840-281-20P
RECEIVER-TRANSMITTER AND FRAME
Figure 4. Receiver-Transmitter Group.
12
ELOINO32
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
4 16 PAOHH 5840-00-944-2454 RT818TPN18
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 0107 RECEIVER-TRANSMITTER GROUP
80058 RECEIVER-XR ........................................................
EA 1
13/(14 blank)
TM11-5840-281-20P
UPPER EXPLODED PORTIONS OF CHASSIS
Figure 5. Receiver-Transmitter RT-818/TPN-18,Waveguide Layout (Sheet 1 of 2).
15
ELOTN 035
TM11-5840-281-20P
LOWER EXPLODED PORTIONS OF CHASSIS
Figure 5. Receiver-Transmitter RTR-818/TPN-18, Waveguide layout (Sheet 2 of 2)
16
ELOINO36
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
5
5
8 PAOZZ 5960-00-073-9277 102663
29 PAOZZ 5960-00-754-9775 6975
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 010701 RECEIVER-TRANSMITTER
RT-818/TPN-18
24930 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
EA 2
EA 1
17
TM11-5840-281-20P
Figure 6. Receiver-Transmitter RT-818/TPN-18, Control Panel Assembly.
18
ELOINO40
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
6
6
6
6
6
6
1 PAOZZ 6210-00-299-4557 900410-2900-301
2 PAOZZ 6240-00-155-8714 MS25231-313
28 PAOZZ 5355-00-556-0151 MS91528-1028
31 PAOZZ 5305-00-719-5330 MS51963-21
32 PAOZZ 5355-00-571-0243 65727-2
33 PAOZZ 5305-00-719-5338 MS51963-23
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
72619 LIGHT,PANEL .........................................................
96906 LAMP,INCANDESCENT ..........................................
96906 KNOB ......................................................................
96906 SETSCREW ............................................................
24930 KNOB ......................................................................
96906 SETSCREW ............................................................
EA 1
EA 1
EA 1
EA 1
EA 1
EA 1
19
TM11-5840-281-20P
Figure 7. Receiver-Transmitter RT-818/TPN-18, Fuse Grouping.
20
ELOIN041
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
7
7
7
7
7
7
6 PAO
ZZ
5920-00-243-3787 F03A250V10AS
9 PAOZZ 5920-00-474-6125 F02A250V2AS
10 PAOZZ 5920-00-280-5031 F02A25OV1-4AS
12 PAOZZ 5920-00-877-9934 F02A25V3AS
13 PAOZZ 5920-00-281-0224 FO2A250V1 -2AS
14 PAOZZ 5920-00-850-6091 FO2B250V1AS
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIOGE ................................................
EA 1
EA 1
EA 1
EA 1
EA 1
EA 2
21
TM11-5840-281-20P
LEFT SIDE VIEW
Figure 8. Amplifier, IF AM-3339/TPN-8
FRONT VIEW
22
ELOIN044
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
8
8
8
24 PAOZZ 5960-00-615-9972 6206
26 PA01O 5960-00-548-3072 6205
28 PAOZZ 5960-00-262-0132 6111
(5)
FSCM
TM 11-5840-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070101 AMPLIFIER, IF AN-3339/TPN-8
81349 ELECTRON TUBE...................................................
813491 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
EA 5
EA 3
EA 1
23
Figure 9. Amplifier, IF AM-3337/TPN-8.
24
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
9
9
9
9
37 PAOZZ 5960-00-882-3563 MS22423-4
39 PAOZZ 5960-00-247-8748 5842
40 PAOZZ 5960-00-985-2783 T3-30381
45 PAOZZ 5960-00-548-3072 6205
TM 11-5749-281-20P
(5)
FSCM
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070102 AMPLIFIER, IF AN-3337/TPNB8
96906 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
98978 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
EA 2
EA 2
EA 2
EA 2
25
Figure 10. Amplifier, IF AM-3338/TPN-8.
26
TM 11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
10
10
10
11
3 PAOZZ 5960-00-261-8679 6021
4 PAOZZ 5960-00-985-2783 T3-3031B
5 PAOZZ 5960-00-615-9972 6206
11 PAOZZ 5960-00-548-3072 6205
TM 11-5749-281-20P
(5)
FSCM
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070104 AMPLIFIER, IF AM-3338/TPN-8
81349 ELECTRON TUBE...................................................
98978 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
EA 1
EA 9
EA 2
EA 6
27/(28 blank)
Figure 11. Control, Sensitivity Time (Sheet 1 of 2).
29
TM 11-5840-281-20P
ITEM
NO
3
4
1
2
5
6
2
2
7
8
7
8
8
8
7
8
REF
DES
C1
C2
C3
C4
C5
C6
C7
CR1
CR2
CR3
CR4
CR5
CR6
CR7
CR8
CR9
REF
DES
CR10
CR11
CR12
CR13
CR14
CR15
Q1
R1
R2
R3
R4
R5
RS
R7
R8
R9
ITEM
NO
8
7
7
7
9
7
10
11
12
13
14
15
16
14
17
13
ITEM
NO
18
19
13
20
20
21
21
17
17
22
14
22
14
23
24
25
REF
DES
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
17
17
26
26
26
27
27
27
28
28
28
ITEM
NO
14
13
14
14
R30
R31
TP1
TP2
TP3
V1
V2
V3
XV1
XV2
XV3
REF
DES
R26
R27
R28
R29
Figure 11. Control, Sensitivity Time (Sheet 2 of 2).
30
TM 11-5840-281-20P
ELOIN055
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
11 27 PAOZZ 5960-00-261-8679 6021
(5)
FSCM
TM 11-5749-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070107 CONTROL, SENSITIVITY TIME
81349 ELECTRON TUBE...................................................
EA 3
31/(32 blank)
Figure 12. Control, Remote Switching C-6989/TPN-18 (Sheet 1 of 2).
33
TM 11-5840-281-20P
Figure 12. Control, Remote Switching C-6989/TPN-18 (sheet 2 of 2).
34
TM 11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
12
12
12
12
12
12
12
12
12
12
3 PAOZZ 5945-00-781-7899 G370063S1
4 PAOZZ 5945-00-937-1827 G370060S1
5 PAOZZ 5945-00-782-7921 G370061S2
6 PAOZZ 5945-00-824-1526 G370009S1
7 PAOZZ 5945-00-838-1330 G370059S1
14 PAOZZ 5945-0-827-7203 G370005S1
15 PAOZZ 5945-00-824-1525 G370057S1
16 PAOZZ 5945-00-043-0415 G370058S1
51 PAOZZ 6240-00-763-7744 MS18209-387
53 PAOZZ 5920-00-284-7466 MDX4
TM 11-5749-281-20P
(5)
FSCM
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070108 CONTROL, REMOTE SWITCHING
C-6989/TPN-18
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELY, ARMATURE .................................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
96906 LAMP, INCANDESCE..............................................
71400 FUSE, CARTRIDGE ................................................
EA 4
EA 2
EA 1
EA 2
EA 4
EA 3
EA 1
EA 1
EA 1
EA 1
35/(36 blank)
Figure 13. Filter, Electronic (Sheet 1 of 2).
37
TM 11-5840-281-20P
C5
C6
C7
C8
C9
C10
C11
C12
R1
REF.
DES.
C1
C2
C3
C4
7
8
6
5
2
5
4
1
3
ITEM
NO
2
3
1
2
R6
R7
R8
R9
R10
R11
R12
R13
R14
REF
DES
R2
R3
R4
R5
8
15
16
17
12
10
13
14
8
ITEM.
NO.
8
9
10
11
R19
R20
R21
R22
R23
R24
R25
R26
R27
REF.
DES.
R15
R16
R17
R18
16
17
9
9
21
9
22
22
9
ITEM
NO.
15
18
19
20
Figure 13. Filter, Electronic (Sheet 2 of 2).
38
R32
R33
R34
R35
R36
R37
R38
R39
R40
REF.
DES.
R28
R29
R30
R31
24
25
23
25
20
21
9
22
23
ITEM
NO.
14
16
19
18
TP2
TP3
V1
V2
V3
V4
V5
V6
REF.
DES.
R41
R42
R43
TP1
29
29
30
30
30
30
30
31
ITEM
NO.
21
26
27
28
TM 11-5840-281-20P
ELOIN 060
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
13
13
30 PAOZZ 5960-00-280-5585 6112
31 PAOZZ 5960-00-262-0132 6111
(5)
FSCM
TM 11-5749-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070109 FILTER, ELECTRONIC
81349 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
EA 5
EA 1
39/(40 blank)
Figure 14. Transmitter, Radar (Sheet of 2)
41
TM 11-5840-281-20P
REAR VIEW MISC. DETAIL
Figure 14. Transmitter, Radar (Sheet 2 of 2)
42
TM 11-5840-281-20P
SECTION II TM 11-5749-281-20P
(1)
ILLUSTRATION
(2)
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
14 72 PAOZZ 5920-00-384-7466 MDX4
14 136 PAOZZ 5960-00-899-4077 7006
14 137 PAOZZ 5305-00-719-5352 MS51963-34
14 138 PAOZZ 5355-00-619-3837 MS91528-3N2B
(5)
FSCM
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
GROUP 01070114 TRANSMITTER, RADAR
71400 FUSE, CARTRIDGE ................................................
81349 ELECTRON TUBE...................................................
96906 SETSCREW ............................................................
96906 KNOB ......................................................................
EA 3
EA 1
EA 1
EA 1
43
Figure 15. Transmitter, Radar, Transmitter Subassembly (MP58).
44
TM 11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
15 1 PAOZZ 5960-00-836-6504 8613
(5)
FSCM
TM 11-5749-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
81349 ELECTRON TUBE...................................................
EA 1
45
Figure 16. Transmitter, Radar, Transmitter Subassembly (MP70)
46
TM 11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b)
FIG ITEM SMR
NO.
NO.
CODE
(3)
NATIONAL
STOCK
NUMBER
(4)
PART
NUMBER
16
16
16
16
11 XDOZZ G370000S1
12 PAOZZ 5945-00-824-1525 G370057S1
13 PAOZZ 5945-00-043-0415 G370058S1
16 PAOZZ 5945 00-542-7021 G370006S1
(5)
FSCM
TM 11-5749-281-20P
(6)
DESCRIPTION
(7) (8)
QTY
INC
USABLE ON CODE U/M IN
UNIT
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, THERMAL ..................................................
EA 1
EA 3
EA 2
EA 1
47/(48 blank)
Figure 17. Control Indicator C-6988/TPN-18 (Sheet 1 of 2).
49
TM 11-5840-281-20P
Figure 17. Control Indicator C-6988/TPN-18 (Sheet 2 of 2).
50
TM 11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
(3)
STOCK
NUMBER
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
17
17
10 XDOHH 01333TPN18
28 XDOZZ 10VPGIB119475
8005S
24930
17 104 PAOZZ 5945-00-492-4431 G370061S1
17 118 PAOZZ 5945-00-824-1526 G370009S1
(5)
TM 11-5840-281-20P
(7) (8) (6)
INC
USABLE ON CODE U/M IN FSCM
GROUP 0201 CONTROL INDICATOR C-6988/TPN-18
GENERATOR PULSE .............................................
ELECTRON TUBE...................................................
24930 RELAY, ARMATUE..................................................
24930 RELAY, ARMATURE ...............................................
EA 1
EA 1
EA 1
EA 1
51/(52 BLANK)
Figure 18. Control Indicator C-6988/TPN-18 Panel Assembly.
(Sheet 1 of 2).
53
TM11-5840-281-20P
Figure 18. Control Indicator C-6988/TPN-18 Panel Assembly
(Sheet 2 of 2).
54
TM11-5840-281-20P
18
18
18
18
18
18
18
18
18
18
18
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
(3)
STOCK
NUMBER
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
2 PAOZZ 6240-00-763-7744 MS 18209-3B7
3 PAOZZ 5355-00-543-0789 MS91528-1N2B
8 PAOZZ 5355-00-559-8942 M591528-1N1B
9 PAOZZ 5355-00-571-0243 65727-2
10 PAOZZ 5305-00-719-5329 MS51963-20
11 PAOZZ 5305-00-719-5338 MS51963-23
12 PAOZZ 5305-00-719-5336 MS51017-33
13 PAOZZ 5355-00-057-7988 102986
15 PAOZZ 5305-00-719-5346 AN565D08H4
16 PAOZZ 5355-00-543-0818
17 XDOZZ 102782
71783
24930
(5)
TM 11-5840-281-20P
(7) (8) (6)
INC
USABLE ON CODE U/M IN FSCM
96906 LAMP, INCANDESCE..............................................
96906 KNOB ......................................................................
96906 KNOB ......................................................................
24930 KNOB ......................................................................
96906 SETSCREW ............................................................
96906 SETSCREW ............................................................
96906 SETSCREW ............................................................
24930 3KNOB ....................................................................
88044 SETSCREW ............................................................
24930 KNOB ......................................................................
KNOB ................................................................................
EA 14
EA 3
EA 4
EA 1
EA 1
EA 1
EA 2
EA 1
EA 2
EA 1
EA 1
55/(56 BLANKI
Figure 19. Amplifier, Rotating Coil (Sheet 1 of 2 ).
57
TM11-5840-281-20P
Figure 19. Amplifier. Rotating Coil (Sheet 2 of 2).
58
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
(3)
STOCK
NUMBER
19
19
19
19
19
19
19
19
19
19
19
3 PAOZZ 5960-00-725-0527 MS24232-6
4 PAOZZ 5960-00-807-5272 6877
15 PAOZZ 5960-00-681-9802 6AU6WB
16 PAOZZ 5960-00-681-9769 mS24232-2
17 PAOZZ 5960-00-262-0286 5651WA
18 PAOZZ 5960-00-188-6584 5670
19 PAOZZ 5960-00-82-3563 MS24232-4
25 PAOZZ 5960-00-578-1652 6384
28 PAOZZ 5960-00-870-8262 MS24232-5
29 PAOZZ 5960-00-082-4139 5751
47 PAOZZ 5935-00-892-8987 TS103P03
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
(5)
TM 11-5840-281-20P
(7) (8) (6)
INC
USABLE ON CODE U/M IN FSCM
GROUP 020101 AMPLIFIER, ROTATING COIL
96906 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
96906 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
81349 ELECTRON TUBE...................................................
96906 SHIELD, ELECTRON TUB ......................................
81349 ELECTRON TUBE...................................................
96906, SHIELD, ELECTRON TUB ........................................
81349 ELECTRON TUBE...................................................
81349 SOCKET, PLUG-IN ELEC .......................................
EA 1
EA 1
EA 1
EA 2
EA 1
EA 1
EA 1
EA 2
EA 1
EA 1
EA 3
59/(60 BLANK)
f
Figure 20. Generator, Pulse 0-1333/TPN-18 (Sheet 1 of 2)
61
TM11-5840-281-20P
Figure 20. Generator, Pulse 0-1333/TPN1-18 (Sheet 2 of 2).
62
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
(3)
STOCK
NUMBER
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
20
20
20
20
4 PAOZZ 6240-00-763-7744 MS 18209-387
5 PAOZZ 535-00-571-02431 6527-2
7 PAOZZ 5355-00-559-8942 MS91528-1N1B
12 PAOZZ 5305-00-719-5330 MS51017-21
20 73 PAOZZ 5305-00-717-6949 11551963-0
2082PAOZZ 5355-00-619-9413 65728
20
20
89 PAOZZ 5945-00-043-0415 G370058S1
90 PAOZZ 5945-00-824-1526 G370009S1
(5)
TM 11-5840-281-20P
(7) (8) (6)
INC
USABLE ON CODE U/M IN FSCM
GROUP 020102 GENERATOR,PULSE 0-1333/TP -18
96906 LAMP, INCANDESCE..............................................
24930 KNOB ......................................................................
96906 KNOB ......................................................................
96906 SETSCREW ............................................................
96906 SETSCREW ............................................................
24930 KNOB ......................................................................
24930 RELAY, ARMATURE ...............................................
24930 RELAY, ARMATURE ...............................................
EA 7
EA 2
EA 1
EA 4
EA 2
EA 1
EA 5
EA 1
63
Figure 21. Generator, Pulse 0-1333/TPN-18 Height Finder Assembly.
64
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
21 14 XDOZZ
(3)
STOCK
NUMBER
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
334
(5)
TM 11-5840-281-20P
(7) (8) (6)
INC
USABLE ON CODE U/M IN FSCM
80204 LAMP, INCANDESCE..............................................
EA 1
65
Figure 22. Power Supply PP-3383/TPN-8.
66
TM11-5840-281-20P
SECTION II
(1) (2)
ILLUSTRATION
(a) (b) NATIONAL
FIG ITEM SMR
NO.
NO.
CODE
TM 11-5840-281-20P
(7) (8) (3)
STOCK
NUMBER
(4)
DESCRIPTION
QTY
PART
NUMBER
UNIT
(5)
FSCM
(6)
INC
USABLE ON CODE
22
22
22
22
22
48 PAOZZ 5920-00-280-5031 F02A250V1-4AS
60 PAOZZ 5920-00-280-9320 F02B250V1-2AS
65 PAOZZ 5920-00-280-4465 F02A250V1AS
66 PAOZZ 5920-00-281-0210 F02A250V4AS
67 PAOZZ 5920-00-281-0224 F02A250V1-2AS
GROUP 020104 POWER SUPPLY PP-3383/TPN-18
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIDGE ................................................
81349 FUSE, CARTRIOGE ................................................
U/M IN
EA 1
EA 1
EA 2
EA 1
EA 2
67
SECTION IV TM 11-5840-2810-20P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT END OF
INDEX
STOCK NUMBER
5945-00-043-0415
5945-00-043-0415
5945-00-043-0415
5305-00-054-6680
5355-00-057-7988
5340-00-066-4052
5960-00-073-9277
5840-00-078-5621
5840-00-082-3721
5840-00-082-3728
5960-00-082-4139
6240-00-155-8714
5960-00-188-6584
5840-00-191-9341
5840-00-191-9342
5840-00-191-9343
5920-00-243-3787
5960-00-247-8748
5960-00-261-8679
5960-00-261-8679
5960-00-262-0132
5960-00-262-0132
5960-00-262-0286
5920-00-280-4465
5920-00-280-5031
5920-00-280-5031
5960-00-280-5585
5920-00-280-9320
5920-00-281-0210
5920-00-281-0224
5920-00-281-0224
5920-00-284-7466
6210-00-299-4557
5840-00-433-2359
5330-00-433-3754
5920-00-474-6125
5945-00-492-4431
5945-00-542-7021
5355-00-543-0789
5355-00-543-0818
5960-00-548-3072
5960-00-548-3072
5355-00-556-0151
5355-00-559-8942
5355-00-559-8942
5355-00-571-0243
13
22
22
7
13
19
22
7
22
9
10
11
8
2
7
2
2
FIGURE
NO.
12
16
20
2
2
19
6
19
18
1
5
2
2
18
18
8
9
6
18
20
6
1
7
17
16
22
12
6
1
30
60 b6
13
31
17
65
10
48
39
3
27
28
4
6
8
9
12
29
2
18
13
8
8
21
28
ITEM
NO.
16
13
89
6
3
16
26
45
28
8
7
32
67
53
1
10
15
9
104
16
STOCK NUMBER
5355-00-571-0243
5355-00-571-0243
5960-00-578-1652
5960-00-615-9972
5960-00-615-9972
5355-00-619-3837
5355-00-619-9413
5310-00-625-5756
5306-00-656-0193
5960-00-681-9769
5960-00-681-9802
5305-00-717-6949
5305-00-719-5329
5305-00-719-5330
5305-00-719-5330
5305-00-719-5336
5305-00-711-5342
5305-00-719-5346
5960-00-725-0527
5960-0O-754-9775
5945-00-781-7899
5945-00-782-7921
5330-00-806-3197
5960-00-003-5272
5945-00-824-1525
5945-00-824-1525
5945-00-824-1526
5945-00-624-1526
5945-00-624-1526
5945-00-827-7203
5960-00-836-6504
5945-00-838-1330
5920-00-850-6091
5960-00-870-8262
5920 00-877-9934
5960-00-882-3563
5960-00-882-3563
5960-00-889-4077
5935-00-892-8987
5310-00-933-8119
5945-00-937-1827
5310-00-939-2655
5840-00-944-2454
5310-00-974-6623
5960-00-985-2783
5960-00-985-2783
12
17
20
12
12
2
19
12
16
18
19
5
12
6
20
18
14
FIGURE
NO.
18
20
19
8
19
19
20
18
10
14
20
2
2
19
2
12
2
4
2
9
10
7
9
19
14
15
12
7
19
5
30
4
15
12
6
118
90
14
31
12
12
137
15
3
29
3
5
138
82
15
14
16
15
73
10
ITEM
NO.
9
5
25
24
47
7
4
13
16
16
40
4
1
7
14
28
12
37
19
136
ABT381PN8
AN565D8H4
F02A250V1-2AS
F02A250V1-2AS
F02A250V1-4AS
F02A250V1-4AS
F02A250V1AS
F02A250V2AS
F02A250V3AS
F02A250V4AS
F02B250V-2AS
F02B250V1AS
F03A250V10AS
G370000S1
G370005S1
G370006S1
G370C09S1
G370009S1
G370009S1
G370057S1
G370057S1
G370058S1
G370058S1
G370058S1
G370059S1
G370060S1
G370061S1
G370061S2
G370063S1
PART
NUMBER
81349
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
80058
88044
81349
81349
FIG.
FSCM
81349
81349
81349
81349
81349
81349
81349
81349
12
12
17
12
16
12
16
20
12
12
17
20
12
7
16
12
16
7
22
22
7
7
22
22
1
ITEM
NO.
2
18
1
22
104
5
7
4
12
6
13
89
3
6
118
90
15
6
11
14
16
PART
NO.
21
15
13
67
12
66
60
14
10
48
65
9
68
G500001-1
MDX4
MS15795-812
MS24232-2
MS24232-4
MS24232-4
MS24232-5
MS24232-6
MS25231-313
MS35308-339
MS35338-137
MS35338-140
MS51017-21
MS51017-33
MS51957-53
MS51963-10
MS51963-20
MS51963-21
MS51963-23
MS51963-23
MS51963-34
MS51972-2
MS90064-14
MS91528-1D2B
FIG.
NUMBER
ITEM
FSCM
24930
71400
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
NO.
1
12
2
19
9
19
19
19
6
18
14
2
2
20
18
6
6
6
2
20
18
2
2
2
11
137
13
30
73
10
31
33
28
14
7
16
12
12
6
NO.
8
53
15
16
37
19
28
3
2
SECTION IV
PART
NUMBER
102663
102782
102823-5
102823-6
102824-1
102986
103155-1
103156-1
103157-1
103188
112449
116502
180963-1
MS9152E-1N1B
MS91528-1N1B
MS91528-1N2B
MSS1528-3N2B
01333TPN18
RT818TPN18
TG113TPN8
TG114TPN8
TS103PC3
T3-3031B
T3-3031B
00204
10VP7G18115475
100253
STOCK NUMBER
5340-00-066-4192
5920-00-284-7466
5840-00-433-2358
5960-00-548-3072
5305-00-719-5338
G400054-2
G500001-2
MDX4
MS18209-387
PART
NUMBER
TM 11-5840-281-20P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
FSCM
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
24930
96906
96906
96906
96906
80058
80058
80058
80058
81349
98978
98978
24931
24930
24930
FIG.
NO.
1
1
2
2
1
1
5
18
2
2
2
18
2
2
19
9
10
3
17
1
18
20
18
14
17
4
2
ITEM
NO.
11
5
14
10
15
7
8
17
8
9
4
13
10
28
47
40
4
6
28
16
3
138
8
7
10
16
12
PART
NUMBER
6021
6021
6111
6111
6112
6205
6205
3119151A030
334
5651WA
5670
5751
5842
6AU6WB
6206
6206
6384
65727-2
65727-2
65727-2
65726
6877
6975
7006
71783
8613
90-0410-2900-301
LATEST NATIONAL STOCK NUMBER ASSIGNMENTS
FSCM
81349
81349
81349
24930
24930
24930
24930
81349
81349
81349
24930
81349
72619
70128
80204
81349
81349
81349
81349
81349
81349
81349
81349
81349
81349
81349
81349
ITEM
NO.
4
29
136
16
1
1
24
5
25
32
9
5
82
3
27
28
31
30
26
45
6
14
17
18
29
39
15
FIG.
NO.
19
5
14
18
15
6
8
10
19
6
18
20
20
10
11
8
13
13
8
9
1
21
19
19
19
9
19
FIGURE
NO.
1
14
1
10
6
ITEM
NO.
9
72
14
11
33
STOCK NUMBER
5305-00-719-5338
6240-00-763-7744
6240-00-763-7744
6240-00-763-7744
4030-00-889-2364
FSCM
24930
24930
71400
96906
LATEST PART NUMBER ASSIGNMENTS
FIG.
ITEM
NO.
1
1
14
12
NO.
5
9
72
51
PART
NUMBER
MS18209-387
MS18209-387
6205
FIGURE
NO.
18
12
18
20
1
FSCM
96906
96906
81349
ITEM
NO.
11
51
2
4
5
69/(70 BLANK)
*U.S. GOVERNMENT PRINTING OFFICE: 1994 - 342-421/81880
By order of the Secretary of the Army
BERNARD W. ROGERS
General, United States Army
Chief of Staff
Official:
J. C. PENNINGTON
Major General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-36, organizational maintenance requirements for AN/TPN-18.
PIN: 017399-000
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap “watermarks” and other junk on it, and sell it.
Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it...
They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends?
I am setting this document FREE. This document was made by the US
Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on.
I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines:
<A HREF= http://www.liberatedmanuals.com/ >Free Military and Government Manuals</A>
–
Sincerely
–
Igor Chudov http://igor.chudov.com/
Chicago Machinery Movers
advertisement
Key Features
- Organizational maintenance
- Repair parts and special tools
- Detailed diagrams and instructions
- National stock number and part number index
Frequently Answers and Questions
What is the purpose of this manual?
What type of information is included in this manual?
How do I use this manual?
What is the difference between organizational and direct support maintenance?
advertisement
