Reznor Q6SD Manual

REPLACEMENT PARTS LIST

Single Package Heat Pump

Q6SD Series

13 SEER, 208V, 3 Phase Models

IMPORTANT

• This document is primarily intended to assist qualified individuals experienced in the proper repair or servicing of this appliance. Only factory authorized parts or accessory kits may be used with this product. Improper installation, service, adjustment, or maintenance may cause explosion, fire, electrical shock or other hazardous conditions which may result in personal injury or property damage.

• Some local codes require licensed installation / service personnel to service this type of equipment.

Under no circumstances should the equipment owner attempt to install parts or service this equipment.

Failure to comply with this warning could result in property damage, personal injury, or death.

2

Q6SD Series Single Package Heat Pump

13 SEER, 208V, 3 Phase Models

ITEM

10

11

12

13

5

6

7

1

2

3

4

8

9

14

15

16

17

18

19

20

24

25

26

21

22

23

27

28

29

30

31

32

33

34

DESCRIPTION

RAIL,BASE,47.23”LG

RAIL,BASE,55.63”LG

CHANNEL,DRAIN

PANEL,BLOWER TRANSITION

RETURN PANEL ASSEMBLY W/ACCESS DR

CONTROL PANEL ASSEMBLY

INSULATED TOP RIGHT PAN ASSEMBLY

ASSY,COVER,HEADER,34” COIL

ASSY,COVER,HEADER,38” COIL

INDOOR COIL ASSEMBLY,036

INDOOR COIL ASSEMBLY, 048

INDOOR COIL ASSEMBLY, 060

BLOWER HSG ASSEMBLY,9/10X10

PANEL,FRONT,R6/P6/Q6

NUT,HEX,8-32,DBL THICK,BLACK(NOT SHOWN)

BRASS NUT, EXT. SERVICE PORT

TRANSFORMER 40 VA

MTR,FAN,PSC,1/4 HP

MTR,FAN,PSC,1/3 HP

CONTACTOR,3 POLE/30A W/AUX. SW

CAPAC,RUN 7.5/370-RND-PLST

DISTRIBUTOR,3CIR,ID(NOT SHOWN)

DISTRIBUTOR,6CIR,ID(NOT SHOWN)

DISTRIBUTOR,8CIR,ID(NOT SHOWN)

RELAY,BLOWER,240V COIL

COMPRESSOR, ZP31K5E-TF5

COMPRESSOR, ZP42K5E-TF5

COMPRESSOR, ZP54K5E-TF5

BOARD,DFRST,OPTIONAL DELAY

DFRST SENSOR(NOT SHOWN)

FUSE,3-AMP(NOT SHOWN)

BLOCK, TERMINAL-3 POLE

SWITCH,HIGH PRESSURE(NOT SHOWN)

HEATER,CRANKCASE,240V/40W,60”(NOT SHOWN)

PLUG,MOLDED,HV,3PH,48”(NOT SHOWN)

CORE,CHARGING PORT(NOT SHOWN)

DISTRIBUTOR,4CIR,OD(NOT SHOWN)

DISTRIBUTOR,5CIR,OD(NOT SHOWN)

DISTRIBUTOR,6CIR,OD(NOT SHOWN)

FITTING, ACCESS

CAP, SERVICE PORT, BRASS(NOT SHOWN)

DRAIN TUBE ASSEMBLY

RESTRICTOR OD. (.053 )(NOT SHOWN)

CONNECTOR, SWIVEL(NOT SHOWN)

Q6SD-X36C

919950

277551

277552

279722R

283942

286702R

M0038370

292441R

293114

—

283091R

—

—

297214R

298892R

606261

618084

621709

621721

—

621832

622132

663913

—

—

622180

919609

—

—

624656

626488

632261

632348

632401

632509

634718

662103

663581

—

—

663812

663818

663833

664053

664194

—

621832

622132

—

664410

—

622180

—

919610

—

624656

626488

632261

632348

632401

632509

634718

662103

—

663582

—

663812

663818

663833

—

—

Q6SD-X48C

919951

277551

277552

279722R

283942

286702R

M0038371

292441R

—

M0034214

—

D06255R

—

297214R

298893R

606261

618084

621709

621721

—

663586

622180

—

—

919611

624656

626488

632261

632348

632401

632509

634718

662103

—

—

664351

663812

663818

663833

—

—

Q6SD-X60C

919952

277551

277552

279722R

283942

286701R

M0038371

292441R

—

M0034214

—

—

D06256R

297214R

298893R

606261

618084

621709

—

621740

621832

622132

—

Please specify Model No., Serial No, and the correct part number(s) when ordering parts from the nearest authorized dealer or service center.

ITEM

35

36

37

38

39

40

41

42

43

44

45

56

57

58

59

60

61

51

52

53

54

55

46

47

48

49

50

62

63

64

65

66

67

68

69

70

CORE,PORT,HI FLOW,BRASS(NOT SHOWN)

VALVE,TXV,EQ,CK,R410A,3.0T,ID

VALVE,TXV,EQ,CK,R410A,4.0T,ID

VALVE,TXV,EQ,CK,R410A,5.0T,ID

FITTING,PANEL MNT,HI-FLOW,3/8”

WHEEL,BLOWER 10 X 10

FAN,3BL,20.0D,30P,CW,1/2,1140

FAN,4BL,20.0D,28P,CW,1/2,1140

ACCUM,5”D,3/4”,124 IN3

ACCUM,5”D,7/8”,174 IN3

PAN,DRAIN

REPLACEMENT HAIL GUARD KIT(NOT SHOWN)

DRIER,FILTER,BIFLOW,8 IN^3

GRILLE,TOP-24”BLACK

REVERSING VALVE

REVERSING VALVE KIT

COIL,RV,24V,84”

PAINT, TOUCH UP, STERLING GREY(NOT SHOWN)

PANEL,SERVICE

DIVIDER,LOW VOLTAGE

PANEL,ELECTRIC HEAT

STAND,DRAIN PAN

PANEL,BLOWER TRANS SIDE

BOTTOM PAN ASSEMBLY

DIVIDER PANEL ASSEMBLY

DUCT CAP ASSEMBLY

BLOWER PANEL ASSEMBLY

SUPPLY PANEL ASSEMBLY

CORNER PANEL ASSEMBLY

TOP PAN ASSY.-LEFT

PANEL,CLOSE-OFF ASSEMBLY

COIL,OUTDOOR

POST,CORNER,35.09L

POST,CORNER,39.09L

MTR,X-13 PROG,1/2 HP

MTR,X-13 PROG,3/4 HP

SET OF WIRES(NOT SHOWN)

VALVE,TXV,EQ,CK,R410A,4.0T,OD

VALVE,TXV,EQ,CK,R410A,5.0T,OD

DUAL GROUNDING LUG

BRACKET,EXT. SERVICE PORT

CONTROL BRACKET

ONE-PIECE TOP PAN KIT (ORIFICE INCLUDED)

DROP-IN ORIFICE

Q6SD Series Single Package Heat Pump

13 SEER, 208V, 3 Phase Models (Continued)

DESCRIPTION

D05113R

2A9692

D05420

D05440

D05450

D05480R

D05503R

D05530R

D05543R

D05556R

D05626R

293781R

D05686R

D06265R

—

D09997R

—

M0023903R

M0033305R

664346

—

632235

298551

298591

M0034721

263210

Q6SD-X48C

919951

664331

—

664345

—

664393

667207

997207

—

—

668854

669190

921213

669762

669404

—

M0079101R

669472

903598

—

669472

903598

D05112R

2A9692

D05420

D05440

D05450

D05480R

D05502R

D05530R

D05542R

D05555R

D05625R

293781R

D05685R

D06262R

D09996R

—

M0002944R

—

M0033305R

—

—

632235

298551

298591

M0034721

263210

Q6SD-X36C

919950

664331

664343

—

—

664393

667207

997207

—

668853

—

669190

921213

669762

669404

669465

Q6SD-X60C

919952

664331

—

—

664347

664393

667207

—

667282

—

668854

669190

921213

669762

669404

—

M0079101R

669472

903598

D05113R

2A9692

D05420

D05440

D05450

D05480R

D05503R

D05530R

D05543R

D05556R

D05626R

293781R

D05686R

D06266R

—

D09997R

—

M0023903R

M0033305R

—

664348

632235

298551

298591

M0034721

263210

Please specify Model No., Serial No, and the correct part number(s) when ordering parts from the nearest authorized dealer or service center.

3

Specifications & illustrations subject to change without notice or incurring obligations.

O’ Fallon, MO | Printed in U.S.A. (07/11) 709182B (Replaces 709182A)