473msds 1
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: December 21, 2011
DATE OF ISSUE: December 21, 2011
I - Product Identification
Rinse Aid
PRODUCT CODE: 0473
CHEMICAL FORMULATION: Water based drying agent.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1
HAZARD RATING:
4 – Extreme;
3 – High;
FLAMMABILITY: 0
2 – Moderate;
1 – Slight;
REACTIVITY: 0
0 – Insignificant
II – Hazardous Ingredients
SUBSTANCE
Alkyl Aryl Polyether
Key:
APPROX
%
5.0-15.0
Values reported as TWA unless noted.
OSHA
ACGIH
EPA 40 CFR:
PEL
TLV
302
355
372
N/E
N/E
N
N
N
CAS #
Proprietary
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VAPOR DENSITY (AIR = 1): N/D
SOLUBILITY IN WATER: Soluble
APPEARANCE AND ODOR: Clear, blue liquid; mild odor.
SPECIFIC GRAVITY (WATER = 1): 1.01
VOC CONTENT (% by weight): <1.0
EVAPORATION RATE (WATER = 1): N/D
pH: 2.0-3.0
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): None
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Rinse Aid
PRODUCT CODE: 0473
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong alkaline products.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION:
EYE CONTACT: X
SKIN CONTACT:
INGESTION:
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: May cause mild irritation.
IF ON SKIN: May cause mild irritation, dryness with prolonged use.
IF SWALLOWED: May cause nausea, vomiting.
IF INHALED: None under normal use.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Wash with soap and water. If irritation persists, obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Rinse mouth with water. Do not induce vomiting unless
told to do so by a physician or poison control center. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill and pick up using an
absorbent material and place in a labeled closed container. Flush residue with water.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation.
VENTILATION
LOCAL: Not required.
MECHANICAL: Not required
PROTECTIVE GLOVES: None under normal use, otherwise chemical resistant.
EYE PROTECTION: None under normal use, otherwise safety glasses.
OTHER PROTECTIVE EQUIPMENT: None.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when
not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: None
DOT CLASS: None
DOT PROPER SHIPPING NAME: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: December 21, 2011
Prepared by: Technical Dept.
DATE OF ISSUE: December 21, 2011
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement