DURAFLOOR HD SDS (NZ)

DURAFLOOR HD SDS (NZ)
Safety Data Sheet
Hazardous Substance, NON-Dangerous Goods
1. MATERIAL AND SUPPLY COMPANY IDENTIFICATION
Product name:
DURAFLOOR HD
Recommended use: Concrete densifier. Applied by spray.
Supplier:
ABN:
Street Address:
Telephone:
Parchem Construction Suppliers Pty Ltd
80 069 961 968
7 Lucca Road
Wyong NSW 2259
Australia
(02) 4350 5000
Emergency telephone number:
Australia – 1800 033 111
Distributed in New Zealand by:
Concrete Plus
23 Watts Road
Sockburn
New Zealand
(03) 343 0090
New Zealand – 0800 734 607
2. HAZARDS IDENTIFICATION
NEW ZEALAND CLASSIFICATION
This material is hazardous according to health criteria of EPA New Zealand
EPA Group Standard:
Construction Products (Subsidiary Hazard) Group Standard 2006; HSR002544
Signal Word
Warning
HSNO Hazard Classification
6.4A
Substances that are irritating to the eye
Hazard Statement(s)
H319
Causes serious eye irritation
Prevention Precautionary Statement(s)
P103
Read label before use
P264
Wash hands, face and all exposed skin thoroughly after handling
P280
Wear protective clothing, gloves, eye/face protection and suitable respirator
Response Precautionary Statement(s)
P305+351+338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if
present and easy to do – continue rinsing
P337+313
If eye irritation persists get medical advice/attention
Storage Precautionary Statement(s)
Not allocated
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 1 of 7
Safety Data Sheet
Disposal Precautionary Statement(s)
P501
Dispose of contents/container in accordance with local, regional, national and international
regulations
DANGEROUS GOODS CLASSIFICATION
Not classified as Dangerous Goods by the criteria of the “Australian Code for the Transport of Dangerous
Goods by Road & Rail” and the “New Zealand NZS5433: Transport of Dangerous Goods on Land”.
3. COMPOSITION INFORMATION
CHEMICAL ENTITY
Lithium polysilicate
Neopentyl glycol
Ingredients determined to be non-hazardous
CAS NO.
PROPORTION
12627-14-4
126-30-7
-
1-10%
<1%
Balance
________
100%
4. FIRST AID MEASURES
If poisoning occurs, contact a doctor or Poisons Information Centre (Phone Australia 131 126, New Zealand
0800 764 766).
Inhalation: Remove victim from exposure - avoid becoming a casualty. Remove contaminated clothing and
loosen remaining clothing. Allow patient to assume most comfortable position and keep warm. Keep at rest
until fully recovered. Seek medical advice if effects persist.
Skin contact: If skin or hair contact occurs, remove contaminated clothing and flush skin and hair with
running water. If swelling, redness, blistering or irritation occurs seek medical assistance.
Eye contact: If in eyes, hold eyelids apart and flush the eyes continuously with running water. Continue
flushing until advised to stop by the Poisons Information Centre or a Doctor; or for at least 15 minutes and
transport to Doctor or Hospital.
Ingestion: Rinse mouth with water. If swallowed, do NOT induce vomiting. Give a glass of water to drink.
Never give anything by the mouth to an unconscious patient. If vomiting occurs give further water. Seek
medical advice.
PPE for First Aiders: Wear overalls, chemical goggles and impervious gloves. Available information
suggests that gloves made from nitrile rubber should be suitable for intermittent contact. However, due to
variations in glove construction and local conditions, the user should make a final assessment. Always
wash hands before smoking, eating, drinking or using the toilet. Wash contaminated clothing and other
protective equipment before storing or re-using.
Notes to physician:
Treat symptomatically.
5. FIRE-FIGHTING MEASURES
Hazchem Code: Not applicable.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 2 of 7
Safety Data Sheet
Suitable extinguishing media:
Not combustible, however, if material is involved in a fire use water fog (or if unavailable fine water spray),
foam, dry agent (carbon dioxide, dry chemical powder).
Specific hazards:
Non-combustible material.
Fire fighting further advice:
Not combustible, however following evaporation of aqueous component residual material can burn if ignited.
On burning may emit toxic fumes. Fire fighters to wear self-contained breathing apparatus and suitable
protective clothing if risk of exposure to vapour or products of combustion.
6. ACCIDENTAL RELEASE MEASURES
SMALL SPILLS
Wear protective equipment to prevent skin and eye contamination. Wipe up with absorbent (clean rag or
paper towels). Allow absorbent to dry before disposing with normal household garbage.
LARGE SPILLS
Slippery when spilt. Avoid accidents, clean up immediately. Wear protective equipment to prevent skin and
eye contamination and the inhalation of vapours. Work up wind or increase ventilation. Contain - prevent
run off into drains and waterways. Use absorbent (soil, sand or other inert material). Collect and seal in
properly labelled containers or drums for disposal.
Dangerous Goods – Initial Emergency Response Guide No: Not applicable.
7. HANDLING AND STORAGE
Handling: Avoid eye contact and repeated or prolonged skin contact.
Storage: Store in a cool, dry, well-ventilated place and out of direct sunlight. Store away from incompatible
materials described in Section 10. Keep containers closed when not in use - check regularly for leaks.
8. EXPOSURE CONTROLS AND PERSONAL PROTECTION
National occupational exposure limits: No value assigned for this specific material by Safe Work
Biological Limit Values: As per the “National Model Regulations for the Control of Workplace Hazardous
Substances (Safe Work Australia)” the ingredients in this material do not have a Biological Limit Allocated.
Engineering measures: Natural ventilation should be adequate under normal use conditions. Keep
containers closed when not in use.
Personal protection equipment: OVERALLS, SAFETY SHOES, CHEMICAL GOGGLES, GLOVES.
Wear overalls, chemical goggles and impervious gloves. Available information suggests that gloves made
from nitrile rubber should be suitable for intermittent contact. However, due to variations in glove
construction and local conditions, the user should make a final assessment. Always wash hands before
smoking, eating, drinking or using the toilet. Wash contaminated clothing and other protective equipment
before storing or re-using.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 3 of 7
Safety Data Sheet
Hygiene measures: Keep away from food, drink and animal feeding stuffs. When using do not eat, drink or
smoke. Wash hands prior to eating, drinking or smoking. Avoid eye contact and repeated or prolonged skin
contact. Ensure that eyewash stations and safety showers are close to the workstation location.
9. PHYSICAL AND CHEMICAL PROPERTIES
Form / Colour / Odour: Clear colourless liquid, practically odourless.
Solubility:
Specific Gravity (23°C):
Relative Vapour Density (air=1):
Vapour Pressure (20 °C):
Flash Point (°C):
Flammability Limits (%):
Autoignition Temperature (°C):
Melting Point (°C):
Boiling Point (°C):
pH:
Viscosity:
Evaporation Rate (n-Butyl acetate=1):
Soluble in water.
1.07
<1
N Av
N App
N App
N App
Approx. 0
Approx. 100
11
N Av
<1
(Typical values only - consult specification sheet)
N Av = Not available
N App = Not applicable
10. STABILITY AND REACTIVITY
Reactivity: No reactivity hazards are known for the material.
Chemical stability: This material is thermally stable when stored and used as directed.
Hazardous reactions: No known hazardous reactions.
Conditions to avoid: Elevated temperatures; keep from freezing.
Incompatible materials: Strong acids and oxidising agents.
Hazardous decomposition products: No known hazardous decomposition products.
11. TOXICOLOGICAL INFORMATION
No adverse health effects expected if the product is handled in accordance with this Safety Data Sheet and
the product label. Symptoms or effects that may arise if the product is mishandled and overexposure occurs
are:
Acute Effects
Inhalation: Where this material is used in a poorly ventilated area, at elevated temperatures or in confined
spaces, vapour may cause irritation to mucous membranes and respiratory tract, headache and nausea.
Skin contact: Repeated or prolonged skin contact may lead to irritation.
Ingestion: No adverse effects expected however large amounts may cause nausea and vomiting.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 4 of 7
Safety Data Sheet
Eye contact: An eye irritant. May cause watering of eyes and blurred vision.
Acute toxicity
Inhalation: This material has been classified as non-hazardous.
Skin contact: This material has been classified as non-hazardous.
Ingestion: This material has been classified as non-hazardous.
Corrosion/Irritancy: Eye: this material has been classified as a Category 2A (6.4A) Hazard (reversible
effects to eyes). Skin: this material has been classified as not corrosive or irritating to skin.
Sensitisation: Inhalation: this material has been classified as not a respiratory sensitiser.
Skin: this material has been classified as not a skin sensitiser.
Aspiration hazard: This material has been classified as non-hazardous.
Specific target organ toxicity (single exposure): This material has been classified as non-hazardous.
Chronic Toxicity
Mutagenicity: This material has been classified as non-hazardous.
Carcinogenicity: This material has been classified as non-hazardous.
Reproductive toxicity (including via lactation): This material has been classified as non-hazardous.
Specific target organ toxicity (repeat exposure): This material has been classified as non-hazardous.
12. ECOLOGICAL INFORMATION
Avoid contaminating waterways. No data available for the product. However, for the constituent:
Acute aquatic hazard: No information is available to complete an assessment.
Long-term aquatic hazard: No information is available to complete an assessment.
Ecotoxicity: No information available.
Persistence and degradability: No information available.
Bioaccumulative potential: No information available.
Mobility: No information available.
13. DISPOSAL CONSIDERATIONS
Persons conducting disposal, recycling or reclamation activities should ensure that appropriate personal
protection equipment is used, see “Section 8. Exposure Controls and Personal Protection” of this SDS.
If possible material and its container should be recycled. If material or container cannot be recycled,
dispose in accordance with local, regional, national and international Regulations.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 5 of 7
Safety Data Sheet
14. TRANSPORT INFORMATION
ROAD AND RAIL TRANSPORT
Not classified as Dangerous Goods by the criteria of the “Australian Code for the Transport of Dangerous
Goods by Road & Rail” and the “New Zealand NZS5433: Transport of Dangerous Goods on Land”.
MARINE TRANSPORT
Not classified as Dangerous Goods by the criteria of the International Maritime Dangerous Goods Code
(IMDG Code) for transport by sea.
AIR TRANSPORT
Not classified as Dangerous Goods by the criteria of the International Air Transport Association (IATA)
Dangerous Goods Regulations for transport by air.
15. REGULATORY INFORMATION
This material is not subject to the following international agreements:
Montreal Protocol (Ozone depleting substances)
The Stockholm Convention (Persistent Organic Pollutants)
The Rotterdam Convention (Prior Informed Consent)
Basel Convention (Hazardous Waste)
International Convention for the Prevention of Pollution from Ships (MARPOL)
This material/constituent(s) is covered by the following requirements:

All the constituents of this material are listed on the Australian Inventory of Chemical Substances
(AICS).
16. OTHER INFORMATION
Literary reference
This Safety Data Sheet has been prepared by Chemical Data Services Pty Ltd (chemdata.com.au) on behalf
of its client.
Supersedes: Not Applicable.
Reason(s) For Issue: First Issue
Technical Support: Australia - 1300 737 787, New Zealand – 0800 657 156
Safety Data Sheets are updated frequently. Please ensure that you have a current copy.
This SDS summarises at the date of issue our best knowledge of the health and safety hazard information of
the product, and in particular how to safely handle and use the product in the workplace. Since Parchem
Construction Supplies Pty Ltd and Concrete Plus cannot anticipate or control the conditions under which the
product may be used, each user must, prior to usage, review this SDS in the context of how the user intends
to handle and use the product in the workplace.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 6 of 7
Safety Data Sheet
If clarification or further information is needed to ensure that an appropriate assessment can be made, the
user should contact this company.
Our responsibility for product as sold is subject to our standard terms and conditions, a copy of which is sent
to our customers and is also available upon request.
Product name: Durafloor HD
Issued: 24 March 2015
SDS No: PARNZLEN000027
Version: 1.0
Page: 7 of 7
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising