Winco RP80 Spec Sheet
Powered by
NEF45 SM2
4.5 Liter
Turbocharged
Electrical Output 65kW/80kVa
Voltage
Amperes
Cycles
Phase
kW
kVa
pf
120/240
225*
60
1
56
56
1.0
120/208
225
60
3
65
80
0.8
120/240
195
60
3
65
80
0.8
277/480
98
60
3
65
80
0.8
* Available amperage at terminal block connection - additional amperage available at receptacle panel for single phase output.
STANDARD FEATURES
• IVECO 4.5 Liter 1800 RPM Engine (Division of FIAT Motors)
- Meets EPA / CARB Tier 3 Emissions
- Mechanical Governor
- Fuel/Water Separator
- Oil Drain Extension with Valve
• BASLER DGC-2020 Digital Controller with Automatic Safety
Shutdowns and Digital Readouts for Low Oil Pressure, High Water
Temp, Engine Overcrank and Engine Overspeed, Low Fuel Level
Shutdown, Battery Disconnect Switch
• Brushless Alternator / Class H Insulation
– Standby Output: 65kW (80kVA)
– Prime Output: 58.5kW (72kVA)
– Motor Starting Capability: 25 h.p. Code G
– Voltage Regulation: 1.5% / < 5% Total Harmonic Distortion
• SWITCHABLE 4-Position Voltage Selector Switch with
Automatic Safety Shutdown and Safety Lock Out
− AC Voltages - 3 Phase: 208, 220, 240, 416, 440, 460, 480V
− AC Voltages - 1 Phase: 120, 139, 208, 220, 240V
Amps: - Single Phase 240V: 225A (at terminal block)
- Three Phase 208V: 225A
- Three Phase 240V: 195A
- Three Phase 480V: 98A
• Illuminated Instrumentation Panel and Connection Box
• Receptacle Package:
- 2-50amp 120/240V Twistlock Receptacles
- 2-20amp 120V GFCI Duplex Receptacles
- 1-Terminal Block for Full Connection with Safety Shut Off
• Shore Power Inlet for Easy Connection to Block Heater
and Battery Charger
• Pre-wired for Remote Emergency Stop (Optional Button Available)
• Two Wire Remote Start Capability
• Selectable High or Low Voltage Mainline Circuit Breakers
for Main Power Connection
• Circuit Breakers for Single Phase Receptacles
• 14-gauge Galvanneal Steel Sound Attenuated Enclosure
with Critical Muffler
• Sound Level: 70 dB(A) @ 7 Meters, Full Load
• Durable Powder Coat Paint Finish / Stainless Steel Fasteners
• Large Lockable Doors for Maintenance Access
• Single Point Lifting Eye
• Full Fluid Containment System with Drains
• Lockable Fuel Access Door
• Six Bolts to Remove Generator Assembly from Trailer
• DOT Approved Trailer & Tank, 7,000 lb. Capacity,
Electric Brakes with Break-Away Kit, Single Axle,
Torsion Bar Suspension, Front Leveling Jack, Rear
Stabilization Jacks, Running Lights, Lighted License Plate Bracket
• 110-gallon, 7-gauge Steel Fuel Tank
• Fuel Consumption:
• Run Time:
Full Load..........4.64 gal/hr
Full Load.......24 hours
75% Load.........3.48 gal/hr
75% Load......32 hours
50% Load.........2.41 gal/hr
50% Load......46 hours
• Removable and Adjustable Hitch
• 3” Pintle Hitch and 2 5/16” Ball Hitch both come Standard
• Large Front Lockable Storage Compartment
• Dimensions: Generator with Trailer - 150” x 66” x 83”
• Weight: Generator with Dry Fuel Tank and Trailer - 4950 lbs
• Warranty: Complete Unit - 1 Year; Engine - 2 Year Limited
APPLICATION &
ENGINEERING DATA
EXPERIENCED DESIGN
GENSET CONTROL
•
•
•
•
•
•
•
•
OVER 80 YEARS EXPERIENCE IN
THE GENERATOR INDUSTRY
DESIGNED FOR LONG LIFE
TO MAXIMIZE RETURN
ON INVESTMENT
REACTIVE L0AD BANK
TESTED / SINGLE STEP 100%
LOAD TESTED
“ORIGINATOR” OF THE MOBILE
DIESEL GENERATOR
•
•
•
BASLER DGC-2020 DIGITAL CONTROLLER
GENERATOR PROTECTION AND METERING
EVENT FAULT LOG RECORDING
DEDICATED RELAYS FOR FUEL SOLENOIDS,
GLOW PLUGS AND STARTER SOLENOID
AUTOMATIC SAFETY SHUTDOWN
DIGITAL READOUTS FOR LOW OIL PRESSURE,
HIGH WATER TEMP, ENGINE OVERCRANK
AND ENGINE OVERSPEED
LOW FUEL LEVEL SHUTDOWN AND FUEL LEAK
DETECTION ALARM
ENGINE SPECIFICATIONS
GENERATOR SPECIFICATIONS
•
•
•
•
•
DIVISION OF FIAT MOTORS INC.
EPA CARB TIER 3 COMPLIANT
COMPLETE SERVICE NETWORK
EFFICIENT LOW FUEL CONSUMPTION DESIGN
BRUSHLESS ROTATING FIELD FOR LONG LIFE
AND LOW MAINTENANCE
• MEETS BS EN 60034, BS5000, VDE 0530
• NEMA MG1-32, ICE34, CSA C22.2-100, AS1359
• INCLUDES: HIGH EFFICIENCY SEMICONDUCTORS,
RECTIFIER SURGE PROTECTION
• STANDARD OUTPUT: 65kW, 80kVA (3-Phase)
• PRIME OUTPUT: 58.5kW, 72kVA (3-Phase)
• AMPS: 1-PHASE 240V - 225A at terminal block,
233 amps total, including receptacle panel
3-PHASE 208V - 225A
3-PHASE 240V - 195A
3-PHASE 480V - 98A
RATING..............................................(125/40°C) STANDBY
TYPE....................................4 POLE – REVOLVING FIELD
SPEED/FREQUENCY..................................1800 RPM/60HZ
INSULATION SYSTEM..........................................CLASS H
STATOR WINDINGS......DOUBLE LAYER CONCENTRIC
PITCH.................................................................................2/3
WAVEFORM DISTORTION...........................................1.5%
TELEPHONE INTERFERENCE..................................<2.0%
EFFICIENCY PEAK...................................................~92.5%
COUPLING..................................................FLEXIBLE DISC
BEARINGS (MAINTENANCE FREE).................................1
CONTROL...............(SX460 STANDARD) SELF EXCITED
REGULATION...........................................................+/- 1.5%
SINGLE PHASE RATING...............................................1.0pf
THREE PHASE RATING................................................0.8pf
MAKE.....................................................................................IVECO
MODEL..........................................................................NEF45 SM2
TYPE.....................................................................................DIESEL
DIRECT INJECTION...............................................MECHANICAL
SPEED GOVERNOR...............................................MECHANICAL
CYLINDERS....................................................................................4
TOTAL DISPLACEMENT..........................................................4.5L
BORE X STROKE.....................................................mm 104 X 132
ASPIRATION/COOLING....................TURBOCHARGED/LIQUID
RADIATOR CAPACITY....................................................2.25 GAL
TOTAL COOLING CAPACITY...........................................5.0 GAL
HOUSING................................................................................SAE 3
FLYWHEEL (TEETH 125)....................................................11½ in.
ROTATION...............................................................................CCW
LUBE OIL SPEC.......................................SAE TYPE, API CF-CH4
LUBE OIL CONSUMPTION.................................< 0.1% OF FUEL
OIL & FILTER REPLACEMENT........................................600 HRS
TOTAL OIL CAPACITY.............................................13.5 QUARTS
EXHAUST OUTLET SIZE @ MUFFLER..................................3.0”
ELECTRICAL SYSTEM (NEGATIVE GROUND)..............12 VDC
ALTERNATOR (BOSCH)..................................................90 AMPS
STARTER..............................................................................BOSCH
BATTERY (NOT INCLUDED BCI 24)..............................650 CCA
Tel: (507) 357-6821
Fax: (507) 357-4857
Sales: (800) 733-2112
E-Mail: [email protected]
Web Site: www.wincogen.com
RP80-0311
225 South Cordova Ave
Le Center MN 56057 USA
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement