TM-11-6130-392-20P

TM 11-6130-392-20P
TECHNICAL MANUAL
ORGANIZATIONAL MAINTENANCE REPAIR PARTS
AND SPECIAL TOOLS LISTS
FOR
BATTERY CHARGER PP-7286/U
(NSN 6130-01-041-3490)
HEADQUARTERS,
DEPARTMENT
17 OCTOBER 1979
OF
THE
ARMY
TM 11-6130-392-20P
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON , DC, 17 October 1979
TECHNICAL MANUAL
No. 11-6130-392-20P
ORGANIZATION MAINTENANCE REPAIR PARTS
AND SPECIAL TOOLS LISTS
FOR
BATTERY CHARGER PP-7286/U
(NSN 6130-01-041-3490)
Current as of 16 May 1979
REPORTING ERRORS AND RECOMMENDED IMPROVEMENTS
You can help improve this manual. If you find any mistakes or if you know of a way to
improve the procedures, please let us know.
Mail your DA Form 2028 (Recommended Changes to Publications and Blank Forms) direct to:
Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN:
DRSEL-ME-MQ, Fort Monmouth, NJ 07703.
A reply will be furnished direct to you.
Table of Contents
Illus
Figure
Page
S ECTION I .
II.
Group
00
01
1
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5
Repair Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Charger PP-7286/U (no parts authorized)
Battery Charger Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
0101
Charging Module Printed Circuit Board (A6-A10) (no parts authorized)
0102
Power Supply Printed Circuit Board (A11) (no parts authorized)
Timing Circuit Printed Circuit Board (A12) (no parts authorized)
0103
Display Circuit Printed Circuit Board (A13) (no parts authorized)
0104
S ECTION III.
IV.
Special Tools List (not applicable)
National Stock Number and Park Number Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1
6
i
TM 11-6130-392-20P
SECTION I
INTRODUCTION
1. Scope
This manual lists spares and repair parts; special
tools; special test, measurement, and diagnostic
equipment (TMDE), and other special support
equipment required for performance of organizational maintenance of the PP-7286/U. It authorizes
the requisitioning and issue of spares and repair
parts as indicated by the source and maintenance
codes.
2. General
This Repair Parts and Special Tools list is divided
into the following sections:
a. Section II. Repair Parts List. A list of spares
and repair parts authorized for use in the performance of maintenance. The list also includes parts
which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts
in each group listed in figure and item number
sequence.
b. Section III. Special Tools List. Not applicable.
c. Section IV. National Stock Number and Part
Number Index. A list, in National item identification number (NIIN) sequence, of all National stock
numbers (NSN) appearing in the listings, followed
by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each
illustration figure and item number appearance.
3. Explanation of Columns
a. Illustration. This column is divided as follows:
(1) Figure number. Indicates the figure
number of the illustration on which the item is
shown.
(2) Item number. The number used to identify
item called out in the illustration.
b. Source, Maintenance, and Recoverability
(SMR) Codes.
(1) Source code. Source codes indicate the
manner of acquiring support items for maintenance, repair, or overhaul of end items. Source
codes are entered in the first and second positions
of the Uniform SMR Code format as follows:
Code
Definition
PA—Item procured and stocked for anticipated or
known usage.
NOTE
Cannibalization or salvage may be used as
a source of supply for any items source
coded above except those coded XA and
aircraft support items as restricted by AR
700-42.
(2) Maintenance code. Maintenance codes are
assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The
maintenance codes are entered in the third and
fourth positions of the Uniform SMR Code format
as follows:
(a) The maintenance code entered in the
third position will indicate the lowest maintenance
level authorized to remove, replace, and use the
support item. The maintenance code entered in the
third position will indicate one of the following
levels of maintenance:
Code
Application/Explanation
C—Crew or operator maintenance performed
within organizational maintenance.
O—Support item is removed, replaced, used at the
organizational level.
(b) The maintenance code entered in the
fourth position indicates whether the item is to be
repaired and identifies the lowest maintenance
level with the capability to perform complete repair
(i.e., all authorized maintenance functions). This
position will contain one of the following maintenance codes:
Code
Application/Explanation
Z—Nonreparable. No repair is authorized.
(3) Recoverability code. Recoverability codes
are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the
Uniform SMR Code format as follows:
Recoverability
codes
Definition
Z—Nonreparable item. When unserviceable, con1
TM 11-6130-392-20P
demn and dispose at the level indicated in position 3.
c. National Stock Number. Indicates the National stock number assigned to the item and will
be used for requisitioning purposes.
d. Part Number. Indicates the primary number
used by the manufacturer (individual, company,
firm, corporation, or Government activity), which
controls the design and characteristics of the item
by means of its engineering drawings, specifications, standards, and inspection requirements to
identify an item or range of items.
NOTE
When a stock numbered item is requisitioned, the repair part received may have
a different part number than the part
being replaced.
e. Federal Supply Code for Manufacturer
(FSCM). The FSCM is a 5-digit numeric code listed
in SB 708-42 which is used to identify the manufacturer, distributor, or Government agency, etc.
f. Description. Indicates the Federal item name
and, if required, a minimum description to identify
the item.
g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used
in performing the actual maintenance function.
This measure is expressed by a two-character alphabetical abbreviations (e. g., ea, in, pr, etc).
When the unit of measure differs from the unit of
issue, the lowest unit of issue that will satisfy the
required units of measure will be requisitioned.
h. Quantity Incorporated in Unit. Indicates the
quantity of the item used in the breakout shown on
the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly.
TM 11-6130-392-12, Operator’s and Organizational Maintenance Manual: Battery Charger
PP-7286/U (to be published).
b. The illustrations in this manual are identical to
those published in TM 11-6130-392-34P. Only
those parts assigned the third position SMR
maintenance code “C” or “O” are listed in the
tabular listing; therefore, there may be a break in
the item number sequence. Only illustrations containing organizational authorized items appear in
this manual.
5. How to locate Repair Parts
a. When National stock number or part number
is unknown.
(1) First. Using the table of contents, determine the functional group within which the item
belongs. This is necessary since illustrations are
prepared for functional groups and listings are divided into the same groups.
(2) Second. Find the illustration covering the
functional group to which the item belongs.
(3) Third. Identify the item on the illustration
and note the illustration figure and item number of
the item.
(4) Fourth. Using the Repair Parts Listing,
find the figure and item number noted on the illustration.
b. When National stock number or part number
is known.
(1) First. Using the Index of National Stock
Numbers and Part Numbers, find the pertinent
National stock number or part number. This index
is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to
the illustration figure number and item number.
(2) Second. After finding the figure and item
number, locate the figure and item number in the
repair parts list.
4. Special Information
a. The following publications pertain to the
PP-7286/U and its components:
6. Abbreviations
Not applicable.
(Next printed page is 4.1)
2
TM 11-6130-392-20P
Figure 1. Battery Charger Assembly (Sheet 1 of 2).
4.1
TM 11-6130-392-20P
Figure 1. Battery Charger Assembly (Sheet 2 of .2).
4.2
SECTION II
(1)
ILLUSTRATION
(A)
(B)
FIG
ITEM
NO
NO
(2)
(3)
SMR
CODE
NATIONAL
STOCK
NUMBER
(4)
(5)
TM11-6130-392-20P
(6)
(7)
DESCRIPTION
PART
NUMBER
FSCM
USABLE ON CODE U/M
(8)
QTY
INC
IN
UNIT
GROUP 01 BATTERY CHARGER ASSEMBLY
1
97
PACZZ
5920-00-901-9938
FM01-125V1A
81349
FUSE,CARTRIDGE
EA
8
1
140
PAOZZ
6240-00-763-7744
MS25237-387
96906
LAMP,INCANDESCENT
EA
1
1
141
PAOZZ
6210-00-248-5478
LC27GT2
81349
LENS
EA
1
5
SECTION IV
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
STOCK NUMBER
FIGURE
NO
ITEM
NO
6210-00-248-5478
6240-00-763-7744
1
1
141
140
PART
NUMBER
FSCM
FM01-125V1A
LC27GT2
81349
81349
TM11-6130-392-20P
STOCK NUMBER
FIGURE
NO
ITEM
NO
5920-00-901-9938
1
97
FIG
NO
ITEM
NO
PART
NUMBER
FSCM
FIG
NO
ITEM
NO
1
1
97
141
MS25237-387
96906
1
140
6
TM 11-6130-392-20P
By Order of the Secretary of the Army:
Official:
E. C. MEYER
General, United States Army
Chief of Staff
J. C. PENNINGTON
Major General, United States Army
The Adjutant General
Distribution:
Active Army:
HISA (Ft Monmouth) (21)
USAINSCOM (2)
COE (1)
TSG (1)
USAARENBD (1)
DARCOM (1)
TRADOC (2)
OS MAJ COMD (4)
TECOM (2)
USACC (4)
MDW (1)
Armies (2)
corps (2)
Svc Colleges (1)
USASIGS (5)
USAADS (2)
USAFAS (2)
USAARMS (2)
USAIS (2)
ARNG: None.
USAR: None.
For explanation of abbreviations used, see AR 310-50.
USAES (2)
USAICS (3)
MAAG (1)
USARMIS (1)
USAERDAA (1)
USAERDAW (1)
Ft Carson (5)
Ft Gillem (10)
Ft Gordon (10)
Ft Richardson (CERCOM Ofc) (2)
Army Dep (1) except:
LBAD (14)
SAAD (30)
SHAD (3)
TOAD (14)
USA Dep (1)
Sig Sec USA Dep (1)
Units org under fol TOE:
29-207 (2)
29-610 (2)
PIN: 043801-000
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly
available information, slap “watermarks” and other junk on it, and sell it.
Those masters of search engine manipulation make sure that their sites that
sell free information, come up first in search engines. They did not create it...
They did not even scan it... Why should they get your money? Why are not
letting you give those free manuals to your friends?
I am setting this document FREE. This document was made by the US
Government and is NOT protected by Copyright. Feel free to share,
republish, sell and so on.
I am not asking you for donations, fees or handouts. If you can, please
provide a link to liberatedmanuals.com, so that free manuals come up first in
search engines:
<A HREF=http://www.liberatedmanuals.com/>Free Military and Government Manuals</A>
– Sincerely
Igor Chudov
http://igor.chudov.com/
– Chicago Machinery Movers
Download PDF