CHARCOAL LEGACY GRILL 12 & 14 BUILT-IN SERIES

CHARCOAL
LEGACY GRILL
12 & 14 BUILT-IN SERIES
22 & 24 STAND ALONE SERIES
Front view of
o charcoal grill
unit (with o
optional smoker
oven/hood and
an warming rack)
showing acce
access door open
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
INSTALLATION OPENING REQUIREMENTS
12 Series: 19 3/4" depth, 26 1/4" width, 12" height
14 Series: 19 3/4" depth, 32 1/4" width, 12" height
Stand alone charcoal grill (with optional smoker oven/hood)
The Fire Magic® stainless steel charcoal grill has the benefit of an adjustable height charcoal pan
allowing you to change the height of the charcoal while cooking and gives you the ability to add fuel
without having to remove the cooking grids. This enables the outdoor chef to be in complete control
of cooking heat at the grilling surface.
WARNING
Built-in models must be installed in masonry or other type of fireproof enclosure. The unit is not insulated
and therefore must be installed with 18" of side and back clearance from unprotected combustible
materials such as wood, plastic or stucco with wood framing.
Do not install this unit under unprotected flammable
surfaces. Do not install or use this appliance inside a
building, garage, or any other enclosed area, including
recreational vehicles or boats.
Carefully unpack your grill and check the parts. If you have
purchased a built-in, simply slide the unit into your grill
opening. Next, fit the crank handle into the hole on the
front right side of the face. Aligning it carefully, screw it into
the nut on the frame (see Fig. 1-1). After installation, crank
the handle in and out to raise and lower the charcoal pan.
Note: Close access door
when cranking
handle.
Handle
Access
door
Fig. 1-1
Installing the crank handle
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
REV 4-1305240910
1
L-C2-153
INSTALLATION
WARNING
Improper installation, adjustment, alteration, service, or maintenance can cause injury or property
damage. Refer to this manual. For assistance or additional information, consult a qualified
professional installer or service agency.
CHARCOAL GRILL OVEN (optional)
If you purchased an oven with your charcoal grill it will come
pre-assembled from the factory.
Fig. 2-1
The oven (with the rounded top Fig. 2-1) is easy to remove and
replace. Simply remove the cooking grids and lift the oven off
of the grill, then replace the cooking grids. To reinstall reverse
the above process.
The smoker model oven has an angled lid and adjustable air
vents to aid in controlling the rate at which the charcoal burns.
The oven may be lifted off after removing the left and right
retaining screws (Fig. 2-2) on the inside of the oven.
Fig. 2-2
Clean all surfaces with Fire Magic® foaming grill cleaner.
For stainless steel restoration and finish maintenance, see
the instructions enclosed with Fire Magic® products for stainless
steel.
Retaining screw
Ashes and dripping are removed by sliding the drip tray out from beneath the grill.
You must keep the drip tray heat shield in position for proper operation.
USING THE GOURMET STAINLESS STEEL CHARCOAL GRILL
1. Remove the cooking grids and pile your charcoal on the charcoal pan. Avoid spillage.
WARNING: When adding charcoal, spread it across the charcoal pan evenly and DO NOT exceed
a height of 1" above the charcoal pan.
Excessive amounts of charcoal may cause over heating and damage to your grill.
2. Follow the instructions supplied with your charcoal/fuel for lighting.
3. Turning the crank handle raises or lowers the charcoal pan to increase or decrease the grilling
heat as you desire.
4. Lower the charcoal pan and open the access door to add or spread out your coals while
cooking.
WARNING
All surfaces of the charcoal unit become HOT during use. Exercise caution when using this unit,
especially when adding charcoal or cranking the charcoal pan up or down.
EXHAUST REMOVAL
If installed under a patio roof, the grill area should be fully covered by a non-combustible chimney and
exhaust hood. An exhaust fan with a rating of 1,000 CFM or more is necessary to efficiently remove
smoke and other cooking by-products from the covered area.
Installation in a fully covered area of any kind is not recommended.
REV 4-1305240910
2
L-C2-153
GOURMET BUILT-IN PARTS LIST
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
Part no.
23729
3542-S-2
3302-S
400363
3137-06
3900-40
23302
3081
3672S
CUSTOM I
Description
Gourmet hood (optional)
Cooking grids, stainless steel (2)
Charcoal pan
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack (optional)
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
Part no.
23733
3543-S-3
3304-S
400364
3162-06
3900-40
23302
3082
3673S
REGAL I
Description
Gourmet hood (optional)
Cooking grids, stainless steel (3)
Charcoal pan (2)
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack (optional)
9
1
3
2
4
Replacement parts can be ordered from
your local Fire Magic® dealer.
6
5
8
7
Drip tray
heat shield
Drip tray
Note: 14'' model shown.
REV 4-1305240910
3
L-C2-153
SMOKER BUILT-IN PARTS LIST
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Part no.
23759-C
3542-S-2
3305
3302-S
400363
3137-06
3900-40
23302
3081
3672C
CUSTOM I
Description
Smoker hood
Cooking grids, stainless steel (2)
Charcoal shield
Charcoal pan
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack
Part no.
23763-C
3543-S-3
3305
3304-S
400364
3162-06
3900-40
23302
3082
3673C
REGAL I
Description
Smoker hood
Cooking grids, stainless steel (3)
Charcoal shield
Charcoal pan (2)
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack
1
10
4
3
2
5
Replacement parts can be ordered from
your local Fire Magic® dealer.
7
6
9
8
Drip tray
heat shield
Drip tray
Note: 14'' model shown.
REV 4-1305240910
4
L-C2-153
GOURMET STAND ALONE PARTS LIST
Replacement parts can be
ordered from your local
Fire Magic® dealer.
CUSTOM I
Item no. Part no.
Description
1.
23729
Gourmet hood
2.
3542-S-2 Cooking grids, stainless steel (2)
3.
3302-S
Charcoal pan
4.
400365
Liner assembly
5.
25326-015 Shelves
6.
25326-014 Cart base
7.
3400-7
Casters set only
8.
3137-06
Face
9.
3900-40
Handle only
10.
23302
Crank
11.
3081
Drip tray assembly
12.
3672S
Gourmet warming rack (optional)
12
1
2
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
Part no.
23733
3543-S-3
3304-S
400366
25326-015
25361-014
3400-7
3162-06
3900-40
23302
3082
3673S
REGAL I
Description
Gourmet hood
Cooking grids, stainless steel (3)
Charcoal pan (2)
Liner assembly
Shelves
Cart base
Casters set only
Face
Handle only
Crank
Drip tray assembly
Gourmet warming rack (optional)
5
3
4
6
8
9
11
10
Drip tray
heat shield
7
Drip tray
Note: 24" model shown.
REV 4-1305240910
5
L-C2-153
SMOKER STAND ALONE PARTS LIST
Replacement parts can be
ordered from your local
Fire Magic® dealer.
CUSTOM I
Item no. Part no. Description
1.
23759-C Smoker hood
2.
3542-S-2 Cooking grids, stainless steel (2)
3.
3305
Charcoal shield
4.
3302-S
Charcoal pan
5.
400365
Liner assembly
6.
25326-015 Shelves
7.
25326-014 Cart base
8.
3400-7
Casters set only
9.
3137-06
Face
10.
3900-40
Handle only
11.
23302
Crank
12.
3081
Drip tray assembly
13.
3672C
Gourmet warming rack
1
13
3
REGAL I
Item no. Part no. Description
1.
23763-C Smoker hood
2.
3543-S-3 Cooking grids, stainless steel (3)
3.
3305
Charcoal shield
4.
3304-S
Charcoal pan (2)
5.
400366
Liner assembly
6.
25326-015 Shelves
7.
25361-014 Cart base
8.
3400-7
Casters set only
9.
3162-06
Face
10.
3900-40
Handle only
11.
23302
Crank
12.
3082
Drip tray assembly
13.
3673C
Gourmet warming rack
2
14
6
4
5
7
9
10
12
11
Drip tray
heat shield
8
Drip tray
Note: 24" model shown.
REV 4-1305240910
6
L-C2-153
ACCESSORIES
USING THE GRILL BRUSH
WARMING RACK (optional)
Purchase a Fire Magic® Stainless-Steel Grill brush to
keep your grill top clean. Complete with scraper for large
particles and replaceable head with brass bristles for
overall cleaning.
The warming rack (Fig. 7-2) is packed separately with
the grill.
To install the warming rack, orient the rack as shown in
Fig. 7-2 with the left and right side pegs forward. With
the rack above the two supports mounted in either side of
the oven, slip both pegs into their respective slots, then
rotate the rack down on top of the supports.
CAUTION: Use hand protection when manipulating
the warming rack while the grill is hot, or
wait for it to cool first.
Fig. 7-1
CLEANING
Grill brush with replacement head
Reverse the process to remove.
Your new Fire Magic® grill represents the latest and most
advanced technology available. In order to continue to
enjoy the benefits of this technology and to protect your
investment, we recommend the following:
Clean the unit with a quality stainless steel cleaner at
least once a month (see Fig. 7-3).
Note: In a humid environment, due to the nature
of stainless steel, iron oxide deposits may
appear. Do not be alarmed – these deposits
are removable with stainless steel cleaner
during periodic maintenance.
Fig. 7-2 Warming rack in place inside oven
Check the burner ports at least annually for blockage by
removing the burner (see orifice changing instructions)
and visually inspecting the gas intake tube for insects
and nests. A clogged tube can lead to a fire beneath
the grill.
Wipe with grain
The inside of the grill may be cleaned periodically
with oven cleaner if desired. Follow the oven cleaner
instructions for proper use.
Fig. 7-3
By following these recommendations, you will enjoy the
beauty and power of your grill for many years to come.
PROTECTING YOUR GRILL
Fig. 7-4
Locking the casters
USING AND (UN)LOCKING CASTERS (STAND
ALONE ONLY)
An optional heavy-duty cover will protect the finish
on your grill and preserve your investment. The water
repellent material will shield the grill from corrosion and
oxidation.
The portable cart comes with four (4) casters, two (2)
of which are locking and articulated.
For ease in guiding the cart when pushing, steer from
behind with the articulated casters and lead with the
others.
To provide a custom fit, each cover has been cut and
sewn by hand for a particular smoke oven model. Make
sure to give the model number of your grill when ordering
a cover from the manufacturer or your local dealer.
Before using the grill, always lock the casters by pushing
down on the side of the steel rocker labeled OFF until
the wheel will no longer roll (Fig. 7-4).
To maintain and protect the grill cover, occasionally wipe
the outside with a sponge soaked in water and a mild
household detergent or cleaner, and rinse with a clean
damp cloth.
Before moving the grill, wait for it to cool, then unlock
the wheels again by pressing the side of the steel rocker
labeled ON until the wheel rolls.
Important: Allow grill to cool before covering.
7
STAINLESS-STEEL CHARCOAL GRILL / SMOKER LIMITED WARRANTY
TEN-YEAR WARRANTY - Fire Magic® stainless steel cooking grids are warranted for ten (10) years from the date of purchase of your
Fire Magic® charcoal grill/smoker.
FIVE-YEAR WARRANTY - Fire Magic® stainless steel charcoal grills/smokers (excluding the charcoal pan, grid, wood pellet screen,
thermometer, and ash tray) are warranted for five (5) years from the date of purchase of your Fire Magic® charcoal grill/smoker.
ONE-YEAR WARRANTY - Fire Magic® charcoal pan, grid, wood pellet screen, thermometer, and ash trays are each warranted for one
(1) year from the date of purchase of your Fire Magic® charcoal grill/smoker.
PLEASE KEEP A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE
This warranty applies to the original purchaser and to single family residential use only. It commences from date of purchase, and is valid only with
proof of purchase.
This warranty does not cover parts becoming defective through misuse, accidental damage, electrical damage, improper handling, lack of routine
maintenance, storage, and/or installation. Product must be installed (and gas must be connected) as specified in the instructions or operator’s
manual, by a qualified professional installer. Accessories, parts, valves, remotes, etc., when used must be Peterson Co. product.
This warranty does not apply to rust, corrosion, oxidation, or discoloration, unless the affected component becomes inoperable. It does not cover
labor or labor-related charges.
This warranty specifically excludes liability for indirect, incidental, or consequential damages. Some states do not allow the exclusion or limitation of
incidental or consequential damages, so the above exclusion may not apply to you. This warranty gives you specified legal rights, and you may have
other rights that may vary from state to state.
For additional information regarding this warranty, or to place a warranty claim, contact the R.H. Peterson dealer where the product was purchased.
TO REGISTER YOUR PRODUCT ONLINE GO TO: WWW.RHPETERSON.COM,
AND CLICK ON PRODUCT REGISTRATION. THANK YOU FOR YOUR PURCHASE.
Quality Check
Date:_________________
Burner Orifices Nat. L.P.
Leak Test: ___________ Model#:
___________________
Model#:
____________________
Serial#:
___________________
Main:
____ ____ Burn Test: ___________ Serial#:
___________________
Other: Inspector: ____
____ Gas Type:
___________
Nat. / L.P.
Air Shutter: ___________________
Inspector:
___________________
Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746
8
Download PDF