379msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
DATE OF REVISION: January 16, 2006
DATE OF ISSUE: January 16, 2006
I - Product Identification
Orange Drain Cleaner
PRODUCT CODE: 0379
CHEMICAL FORMULATION: Solvent based drain maintainer.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 2
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Mineral Spirits
d-Limonene
Poly (oxyethylene) nonylphenol
Ethoxylated octyl phenol
Key:
APPROX
%
40.0-50.0
45.0-55.0
1.00-5.00
1.00-5.00
Values reported as TWA unless noted.
OSHA
ACGIH
EPA 40 CFR:
PEL
TLV
302 355 372
N/E
N/E
N
N
N
N/E
N/E
Y
N
N
N/E
N/E
N
N
N
N/E
N/E
N
N
N
CAS #
8052-41-3
5989-27-5
9016-45-9
9036-19-5
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VAPOR DENSITY (AIR = 1): N/D
SOLUBILITY IN WATER: Emulsifiable
APPEARANCE AND ODOR: Clear, orange liquid; citrus scent.
SPECIFIC GRAVITY (WATER = 1): 0.812
VOC CONTENT (% by weight): > 90.0
EVAPORATION RATE (WATER = 1): > 1.0
pH: N/A
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): 121
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/E
LOWER: N/E
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Orange Drain Cleaner
PRODUCT NUMBER: 0379
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers
CONDITIONS TO AVOID: Excess heat and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION:
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate to severe irritation, redness and possible tearing.
IF ON SKIN: Irritation, chapping and dermatitis, with prolonged or repeated exposure. Contains a possible sensitizer.
IF SWALLOWED: Nausea, cramps, diarrhea. Small amounts of this product aspirated into the respiratory system during ingestion or
vomiting may cause mild to severe pulmonary injury, possibly progressing to death.
IF INHALED: Irritation of the respiratory tract, coughing and headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Remove contaminated clothing and launder separately before re-use. Wash with soap and water. If irritation persists,
obtain medical attention.
IF SWALLOWED: Call a physician or poison control center immediately. Do not induce vomiting. Rinse mouth with water, then
drink one glass of water. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. If irritation persists, obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and extinguish all sources of ignition.
Contain spill. Soak up spilled material with inert absorbent material and place in properly labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, eyewash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame.
Keep container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None
DOT ID NUMBER: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
DATE OF REVISION: January 16, 2006
Prepared by: Technical Dept.
DATE OF ISSUE: January 16, 2006
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement