TM-11-5805-262-34P

TM-11-5805-262-34P
TM 11-5805-262-34P
TECHNICAL MANUAL
DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE
REPAIR PARTS AND SPECIAL TOOLS LISTS
(INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS)
FOR
SWITCHBOARDS, TELEPHONE, MANUAL
SB-22/PT (NSN 5805-00-257-3602)
AND
SB-22A/PT (NSN 5805-00-715-6171)
HEADQUARTERS,
DEPARTMENT OF THE ARMY
MAY 1978
*TM 11-5805-262-24P
HEADQUARTERS
DEPARTMENT OF THE ARMY
W A S H I N G T O N , DC, 22 May 1978
T ECHNICAL M A N U A L
No. 11-5805-262-34P
DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE
REPAIR PARTS AND SPECIAL TOOLS LISTS
(INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS)
FOR
SWITCHBOARDS, TELEPHONE, MANUAL
SB-22/PT (NSN 5805-00-257-3602)
AND
SB-22A/PT (NSN 5805-00-71 5-6171)
Current as of 17 November 1977
REPORTING OF ERRORS
You can improve this manual by recommending improvements using
DA Form 2028-2 (Test) located in the back of the manual. Simply tear
out the self-addressed form, fill it out as shown on the sample, fold it
where shown, and drop it in the mail.
If there are no blank DA Forms 2028-2 (Test) in the back of your
manual, use the standard DA Form 2028 (Recommended Changes to
Publications and Blank Forms) and forward to the Commander, US
Army Communications and Electronics Materiel Readiness Command,
ATTN: DRSEL-MA-Q, Fort Monmouth, NJ 07703.
In either case, a reply will be furnished direct to you.
TABLE OF CONTENTS
SECTION I.
II.
Introduction
Page
1
Repair parts list
5
Illus
Figure
Switchboards, Telephone, Manual SB-22/PT and SB-22A/PT
5
1,2
Telephone Circuit, Operators TA-221/PT
9
3,4
02
Telephone Circuit, Line Jack TA-222/PT
13
6
03
Handset-Headset H–144( )/U (See TM 11-5965-206-14P for parts)
04
Accessory Kit MX-2915/PT (A Model only)
15
6
0402 Telephone Circuit, Trunk Jack TA-326/PT
17
7
Accessory Kit MX-230/PT and MX-230A/PT (Plain Model only)
21
8
Group 0 0
01
0401 Telephone Circuit, Line Jack TA-222/PT (Same as group 02)
05
0501 Telephone Circuit, Line Jack TA-222/PT (Same as group 02)
SECTION III.
IV.
Special tools list (Not applicable)
National stock number and part number index
22
* This manual supersedes TM 11-5805-262-35P, 23 December 1971.
i
TM 11-5805-262-34P
SECTION I
INTRODUCTION
Definition
1. Scope
Code
This manual lists spares and repair parts; special
tools; special test, measurement, and diagnostic
equipment ( TMDE ), and other special support
equipment required for performance of direct support’ and general support maintenance of the
SB–22/PT and SB–22A/PT. It authorizes the
requisitioning and issue of spares and repair parts
as indicated by the source and maintenance codes.
PA—Item procured and stocked for anticipated
or known usage.
XD—A support item that is not stocked. When
required, item will be procured through
normal supply channels.
NOTE
Cannibalization or salvage may be used
as a source of supply for any items
source coded above except those coded
XA and aircraft support items as restricted by AR 700–42.
2. General
This Repair Parts and Special Tools List is divided
into the following sections:
a. Section II-Repair Parts List. A list of
spares and repair parts authorized for use in the
performance of maintenance. The list also includes
parts which must be removed for replacement of
the authorized parts. Parts lists are composed of
functional groups in numeric sequence, with the
parts in each group listed in figure and item
number sequence.
b. Section III.-Special Tools List. Not applicable.
c. Section IV.-National Stock Number and
Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the
listings, followed by a list, in alphanumeric sequence,
of all part numbers appearing in the listings.
National stock numbers and part numbers are
cross-referenced to each illustration figure and
item number appearance.
3. Explanation of Columns
a. Illustration. This column is divided as follows:
(1) Figure number. Indicates the figure number of the illustration on which the item is shown.
(2) Item number. The number used to identify item called out in the illustration.
b. Source, Maintenance, and Recoverability
(SMR) Codes.
(1) Source code. Source codes indicate the
manner of acquiring support items for maintenance, repair, or overhaul of end items. Source
codes are entered in the first and second positions
of the Uniform SMR Code format as follows:
(2) Maintenance code. Maintenance codes are
assigned to indicate the levels of maintenance
authorized to USE and REPAIR support items.
The maintenance codes are entered in the third
and fourth positions of the Uniform SMR Code
format as follows:
(a) The maintenance code entered in the
third position will indicate the lowest maintenance
level authorized to remove, replace, and use the
support item. The maintenance code entered in
the third position will indicate the following levels
of maintenance:
Code
Application/Explanation
C-Crew or operator maintenance performed
within organizational maintenance.
O-Support item is removed, replaced, used at the
organizational level.
F-Support item is removed, replaced, used at the
direct support level.
(b) The maintenance code entered in the
fourth position indicates whether the item is to be
repaired and identifies the lowest maintenance
level with the capability to perform complete repair (i.e., all authorized maintenance functions).
This position will contain one of the following
maintenance codes:
Code
Application/Explanation
F-The lowest maintenance level capable of complete repair of the support item is the
direct support level.
Z-Nonreparable. No repair is authorized.
1
TM 11-5805-262-34P
(3) Recoverability code. Recoverability
codes are assigned to support items to indicate the
disposition action on unserviceable items. The recoverability code is entered in the fifth position of
the Uniform SMR Code format as follows:
Recoverability
Definition
Codes
Z-Nonreparable item. When unserviceable,
condemn and dispose at the level indicated
in position 3.
F-Reparable item. When uneconomically reparable, condemn and dispose at the direct
support level.
D-Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal not authorized below
depot level.
c. National Stock Number. Indicates the National stock number assigned to the item and will
be used for requisitioning purposes.
d. Part Number. Indicates the primary number
used by the manufacturer (individual, company,
firm, corporation, or Government activity), which
controls the design and characteristics of the item
by means of its engineering drawings, specifications, standards, and inspection requirements, to
identify an item or range of items.
h. Quantity Incorporated in Unit. Indicates the
quantity of the item used in the breakout shown
on the illustration figure, which is prepared for
a functional group, subfunctional group, or an
assembly.
4. Special Information
a. Usable on codes are shown in the description column. Uncoded items are applicable to all
models. Identification of the usable on codes used
in this publication are:
Code
512
ABK
Used on
SB-22/PT
SB-22A/PT
b. The following publications pertain to the
SB-22/PT, SB-22A/PT and its components:
TM 11–5805-262-12, Switchboards, Telephone,
Manual SB-22/PT and SB-22A/PT
TM 11-5805-262-20P, Switchboards, Telephone,
Manual SB-22/PT and SB-22A/PT
TM 11-5805-262-35, Telephone Manual SB-22/
PT and SB-22A/PT
TM 11-5965-206-14P, Headset-Microphone H91A/U; Handset-Headset H-144/U, H-144A/
U, H-144B/U, and H-144C/U; and HeadsetMicrophone H-210/G
5. How to Locate Repair Parts
NOTE
When a stock-numbered item is requisitioned, the repair part received may have
a different part number than the part
being replaced.
e. Federal Supply Code for Manufacturer
(FSCM). The FSCM is a 5-digit numeric code
listed in SB 708–42 which is used to identify the
manufacturer, distributor, or Government agency,
etc.
f. Description. Indicates the Federal item name
and, if required, a minimum description to identify
the item.
g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used
in performing the actual maintenance function.
This measure is expressed by a two-character alphabetical abbreviation (e.g., ea, in, pr, etc).
When the unit of measure differs from the unit
of issue, the lowest unit of issue that will satisfy
the required units of measure will be requisitioned.
2
a. When National stock number or part number
is unknown:
(1) First. Using the table of contents, determine the functional group within which the item
belongs. This is necessary since illustrations are
prepared for functional groups and listings are
divided into the same groups.
(2) Second. Find the illustration covering the
functional group to which the item belongs.
(3) Third. Identify the item on the illustration and note the illustration figure and item number of the item.
(4) Fourth. Using the Repair Parts Listing,
find the figure and item number noted on the illustration.
b. When National stock number or part number
is known.
(1) First. Using the Index of National Stock
Numbers and Part Numbers, find the pertinent
National stock number or part number. This index
TM 11-5805-262-34P
is in NIIN sequence, followed by a list of part
numbers in alphameric sequence, cross-referenced
to the illustration figure number and item number.
(2) Second. After finding the figure and item
number, locate the figure and item number in the
repair parts list.
6. Abbreviations
(Not applicable.)
3
TM11-5805-262-34P
Figure 1.
4
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
(5)
(6)
(7)
U\M
(8)
QTY
INC
IN
UNIT
DESCRIPTION
FSCM
USABLE ON CODE
GROUP 00 SWITCHBOARDS,TELEPHONE,MANUAL
SB-22/PT
AND SB-22A/PT
1
1
PACFF
5805-00-503-3341
TA221PT
80058
TELEPHONE CIRCUIT,OPR
EA
1
1
2
PACFF
5805-00-503-3337
TA222PT
80058
TELEPHONE CIRCUIT,L JK
EA
12
1
3
PACFF
5805-00-356-2693
MX230PT
80058
SWITCHBOARD ACCESSORY KIT
5I2
EA
1
1
4
PACFF
5805-00-356-2693
MX230APT
80058
SWITCHBOARD ACCESSORY KIT
5I2
EA
1
1
4
PACFF
5805-00-715-6170
MX2915PT
80058
SWITCHBOARD ACCESSORY KIT
ABK
EA
1
5
TM11-5805-262-34P
Figure 2.
6
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
FSCM
2
1
PAFZZ
5805-00-356-3576
SCB84395
80063
2
2
XDFFD
SMD361814
2
3
PAFZZ
5895-00-659-7783
2
4
PAFZZ
5805-00-356-3579
2
5
XDFZZ
2
6
PAOZZ
2
7
2
(5)
(6)
(7)
U\M
(8)
QTY
INC
IN
UNIT
COVER ASSEMBLY
EA
1
80063
CASE ASSEMBLY
EA
1
SCC84365
80063
LATCH CABLE ASSEMBLY
EA
2
SCB84371
80063
HANDLE ASSEMBLY
EA
2
SCB84389
80063
PLATE ASSEMBLY
EA
2
6135-00-635-5223
SCB84406
80063
CASE ASSEMBLY
EA
1
PACFF
5965-00-682-2769
H144U
80058
HANDSET-HEADSET,H-144/U
EA
1
8
PAFZZ
5340-00-324-9411
SCC25265
80063
LATCH ASSEMBLY
EA
2
2
9
PAFZZ
5305-00-043-6803
MS35227-15
96906
SCREW,MACHINE
EA
8
2
10
PAFZZ
5310-00-088-0551
22NM-40
72962
NUT,SELF-LOCKING
EA
8
2
11
XDFZZ
5330-00-351-4188
SCB84388
80063
GASKET
EA
1
2
12
PAFZZ
5305-00-958-5457
MS35190-226
96906
SCREW,MACHINE
EA
12
2
13
PAFZZ
5999-00-643-7687
SCB84384
80063
CLIP,ELECTRICAL
EA
4
DESCRIPTION
7
USABLE ON CODE
TM11-5805-262-34P
8
Figure 3.
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
(5)
(6)
(7)
U\M
(8)
QTY
INC
IN
UNIT
DESCRIPTION
FSCM
USABLE ON CODE
GROUP 01 TELEPHONE CIRCUIT OPERATORS TA-221/PT
3
1
PAFZZ
5930-00-655-1513
MS35058-21
96906
SWITCH,TOGGLE
EA
1
3
2
PAFZZ
5805-00-542-1469
G42A/PT
80058
GENERATOR,RNGG,HAND
EA
1
3
3
PAFZZ
5935-00-549-2646
U79U
80063
CONNECTOR,RCPT
EA
1
3
4
XDFZZ
SMC361818
80063
SWITCH,LEVER
EA
1
3
5
XDFZZ
SCB84618
80063
FRAME,RCPT
EA
1
3
6
PAFZZ
5305-00-011-7646
MS35245-20
96906
SCREW,MACHINE
EA
17
3
7
PAFZZ
5935-00-786-1602
SCB84538GRP11
80063
CONNECTOR,RCPT
EA
5
3
8
XDFZZ
SCB84616
80063
FRAME ASSEMBLY
EA
1
3
9
XDFZZ
SMD361821-11
80063
NUT,SELF LOCKING
EA
2
3
10
XDFZZ
SCC84612
80063
CASE ASSEMBLY
EA
1
3
11
XDFZZ
SCC84619
80063
COVER,CASE
EA
1
3
12
PAOZZ
6240-00-196-4501
1490
24446
LAMP,INCANDESCENT
EA
1
3
13
PAFZZ
5935-00-192-4789
JJ089
81349
JACK,TELEPHONE
EA
1
3
14
PAFZZ
5325-00-835-2185
Z3126
76385
GROMMET,RUBBER
EA
1
3
15
PAFZZ
6625-00-244-8514
SCC27394
80063
CORD ASSEMBLY,ELEC
EA
1
3
16
PAFZZ
5935-00-192-4762
PJ051B
81349
PLUG,TELEPHONE
EA
1
3
17
PAOZZ
6210-00-548-0202
TCS61594-81XP10
72619
LIGHT,INDICATOR
EA
1
3
18
XDFZZ
SMD361821-7
80063
SCREW,MACHINE
EA
4
3
19
PAFZZ
5305-00-546-6866
SCB14093
80063
SCREW,EXT,RLV
EA
4
3
20
PAFZZ
5310-00-579-0079
MS35333-37
96906
WASHER,LOCK
EA
4
3
21
PAFZZ
5340-00-282-0808
SMB84461
80063
RING,RETAINER
EA
4
3
22
XDFZZ
SCB84620
80063
INSULATOR,PLATE
EA
1
3
23
XDFZZ
SCB84621
80063
BUSHING,SLEEVE
EA
2
3
24
PAFZZ
101
19557
BUZZER
EA
1
3
25
XDFFF
SCC84579
80063
BRACKET ASSEMBLY
EA
1
6350-00-351-8022
9
TM11-5805-262-34P
10
Figure 4.
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
FSCM
4
1
XDFZZ
96TM-62
80063
4
2
PAFZZ
191F56492S4
4
3
XDFZZ
4
4
PAFZZ
4
5
PAFZZ
4
6
XDFZZ
4
7
PAFZZ
4
8
4
U\M
(8)
QTY
INC
IN
UNIT
NUT,SLF-LKG
EA
6
56289
CAPACITOR,FXD,P
EA
1
SCB84580
80063
BRACKET,MTG
EA
1
5305-00-550-9330
MS35229-13
96906
SCREW,MACHINE
EA
2
5310-00-579-0079
MS35333-37
96906
WASHER,LOCK
EA
2
353-17-03-001 78189
TERMINAL BOARD
EA
1
5910-00-666-7035
29F407G2
24446
CAPACITOR,TANTA
EA
1
XDFZZ
5310-00-595-7235
MS35333-20
96906
WASHER,LOCK
EA
4
9
XDFZZ
5310-00-983-8483
MS15795-5
96906
WASHER,FLAT
EA
4
4
10
XDFZZ
SMB108453
80063
INSULATOR,PLATE
EA
1
4
11
XDFZZ
332-11-05-055 78189
TERMINAL BOARD
EA
1
4
12
PAFZZ
5305-00-550-9326
MS35229-17
96906
SCREW,MACHINE
EA
4
4
13
PAFZZ
5310-00-616-3092
MS35649-45
96906
NUT,PLAIN,HEXAGON
EA
2
4
14
PAFZZ
5950-00-645-4465
SCC84598
80063
TRANSFORMER,AF
EA
1
4
15
PAFZZ
5950-00-351-5484
SCC84585
80063
COIL,TEL RTD
EA
1
5910-00-280-6975
(5)
(6)
(7)
DESCRIPTION
11
USABLE ON CODE
TM11-5805-262-34P
Figure 5.
12
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
(5)
(6)
(7)
U\M
(8)
QTY
INC
IN
UNIT
DESCRIPTION
FSCM
USABLE ON CODE
GROUP 02 TELEPHONE CIRCUIT,LINE JACK TA-222/PT
5
1
XDFFF
SCC84430
80063
COVER ASSEMBLY
EA
1
5
2
XDFZZ
SCC84431
80063
COVER
EA
1
5
3
PAFFF
SCC35755
80063
CORD ASSEMBLY,ELEC
EA
1
5
4
XDFZZ
SMB361801
80063
STOP,PLUG
EA
1
5
5
PAFZZ
PJ051R
81349
PLUG,TELEPHONE
EA
1
5
6
XDFZZ
MS35229-8
96906
SCREW,MACHINE
EA
3
5
7
PAFZZ
5310-00-208-5335
MS35649-25
96906
NUT,PLAIN,HEXAGON
EA
3
5
8
PAFFF
5805-00-503-3332
SMD84439
80063
SIGNAL ASSEMBLY
EA
1
5
9
XDFZZ
SCB84445
80063
HOUSING ASSEMBLY
EA
1
5
10
PAFZZ
5935-00-258-8940
SCC84478
80063
JACK,TELEPHONE
EA
1
5
11
PAFZZ
5916-00-577-6214
1N538
81349
SEMICOUNDUCTOR,D
EA
1
5
12
XDFZZ
MS35333-87
96906
WASHER,LOCK
EA
4
5
13
PAFZZ
5310-00-616-3092
MS35649-45
96906
NUT,PLAIN,HEXAGON
EA
2
5
14
PAFZZ
5325-00-837-3648
SMB361802
80063
BUSHING,PANEL
EA
1
5
15
PAFZZ
9905-00-639-1679
SCB84438
80063
STRIP,DESIGNATION
EA
1
5
16
XDFZZ
SCB84505
80063
NUT,PLAIN,HEXAGON
EA
1
5
17
XDFZZ
SCB84485
80063
WASHER,FLAT
EA
1
5
18
PAFZZ
5970-00-796-1264
SCB84480
80063
BUSHING,SLEEVE
EA
1
5
19
PAFZZ
6210-00-284-0389
SCB84440
80063
WINDOW ASSEMBLY
EA
1
5
20
XDFZZ
SCB84432
80063
INSULATION,TAPE
EA
2
5
21
PAFZZ
MS35239-19
96906
SCREW,MACHINE
EA
2
5
22
XDFZZ
SCB84518
80063
SPACER
EA
2
5
23
XDFZZ
SMC84433
80063
CASE ASSEMBLY
EA
1
5
24
XDFZZ
SCB140981
80063
SHIELD,REEL
EA
1
5
25
PAFZZ
5935-00-636-5784
SCB84539GRP1
80063
CONNECTOR
EA
1
5
26
PAFZZ
5305-00-011-7648
MS35245-24
96906
SCREW,MACHINE
EA
2
5
27
PAFFF
5920-00-285-0188
SMB84543
81349
LIGHTING ARRESTOR ASSEMBLY
EA
1
5
28
PAFFF
5995-00-607-0367
SCC35756
80063
CORD ASSEMBLY ELECTRIC
EA
1
5
29
XDFZZ
SMD84512
80063
RETAINER SPRING
EA
2
5
30
PAFFF
5805-00-607-0357
SCD35754
80063
REEL AND PLUG ASSEMBLY
EA
1
5
31
PAFZZ
5805-00-392-7946
SMD84511
80063
REEL,CABLE
EA
1
5995-00-752-2392
5935-00-837-5969
5305-00-616-8592
13
TM11-5805-262-34P
Figure 6.
14
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
(5)
(6)
(7)
U\M
(8)
QTY
INC
IN
UNIT
DESCRIPTION
FSCM
USABLE ON CODE
GROUP 04 ACCESSORY KIT MX-2915/PT (A MODEL ONLY)
6
1
PAFFF
5805-00-392-8058
SCD147778
80063
CASE ASSEMBLY
ABK
EA
1
6
2
PAFZZ
5340-00-205-5159
SCD20648
80063
CATCH,LUGGAGE
ABK
EA
2
6
3
PAFZZ
5805-00-523-9045
SCB142210
80063
GASKET
EA
1
6
4
PAFZZ
8305-00-263-2462
SCD147778-1
80063
WEBBING,TEXTILE
IN
12
6
5
XDFZZ
SCC142220
80063
COVER ASSEMBLY
EA
1
6
6
PACFF
5805-00-799-3225
SCD142211
80063
CASE ASSEMBLY
EA
1
6
7
PAFZZ
5935-00-323-5995
SCB142216
80063
STUD
EA
5
6
8
PACFF
5805-00-715-6175
TA326PT
80058
TRUNK JACK
EA
1
6
9
PACFF
5805-00-503-3337
TA222PT
80058
TELEPHONE CIRCUIT L JK
EA
2
6
10
PAOZZ
6240-00-196-4501
1490
24446
LAMP,INCANDESCENT
EA
2
15
ABK
ABK
ABK
ABK
ABK
ABK
ABK
ABK
TM11-5805-262-34P
Figure 7.
16
TM11-5805-262-34P
SECTION II
(1)
ILLUSTRATION
(a)
(b)
FIG
ITEM
NO.
NO.
(2)
(3)
(4)
(5)
SMR
CODE
NATIONAL
STOCK
NUMBER
PART
NUMBER
FSCM
(6)
(7)
USABLE ON CODE
U\M
(8)
QTY
INC
IN
UNIT
ABK
EA
1
DESCRIPTION
GROUP 0402 TELEPHONE CIRCUIT,TRUNK JACK TA-326/PT
7
1
XDFFF
SCC84430
80063
COVER ASSEMBLY
7
2
XDFZZ
7
3
PAFZZ
5805-00-607-0357
SCC84431
80063
COVER
ABK
EA
1
SCD35754
80063
REEL AND PLUG ASSEMBLY
ABK
EA
1
7
4
PAFFF
6240-00-196-4501
SCC35755
80063
CARD ASSEMBLY,ELEC
ABK
EA
1
7
5
XDFZZ
SMB361801
80063
STOP,PLUG
ABK
EA
1
7
6
PAFZZ
7
7
PAFFF
5935-00-837-5969
PJ051R
81349
PLUG,TELEPHONE
ABK
EA
1
5955-00-607-0367
SCC35756
80063
CORD ASSEMBLY,ELEC
ABK
EA
1
7
8
PAFZZ
5910-00-666-7035
29G407A
24446
CAPACITOR,TANTA
ABK
EA
2
7
9
7
10
XDFZZ
SCB33707
80063
CLAMP
ABK
EA
1
XDFZZ
SB33705-2
80063
INSULATOR,PLATE
ABK
EA
2
7
11
XDFZZ
SCB33705-1
80063
INSULATOR,PLATE
ABK
EA
1
7
12
PAFZZ
5305-00-022-6756
MS35201-11
96906
SCREW,MACHINE
ABK
EA
2
7
13
PAFZZ
5325-00-837-3648
SMB361802
80063
BUSHING,PANEL
ABK
EA
1
7
14
PAFZZ
5950-00-811-1787
SCB33708
80063
REACTOR
ABK
EA
1
7
15
PAFZZ
9905-00-639-1679
SCB84438
80063
STRIP,DESIGNATION
ABK
EA
1
7
16
XDFZZ
SCB84505
80063
NUT,PLAIN,HEXAGON
ABK
EA
1
7
17
XDFZZ
SCB84485
80063
WASHER,FLAT
ABK
EA
1
7
18
PAFZZ
5970-00-796-1264
SCB84480
80063
BUSHING,SLEEVE
ABK
EA
1
7
19
PAFZZ
6210-00-284-0389
SCB84440
80063
WINDOW ASSEMBLY
ABK
EA
1
7
20
PAFZZ
5305-00-546-6866
SCB14093
80063
SCREW,EXT RLV
ABK
EA
2
7
21
PAFZZ
5340-00-282-0808
SCB84461
80063
RING,RETAINER
ABK
EA
2
7
22
PAFZZ
5310-00-261-7156
MS35333-78
96906
WASHER,LOCK
ABK
EA
2
7
23
XDFZZ
SCB84432
80063
INSULATION TAPE
ABK
EA
2
7
24
PAFZZ
MS35239-19
96906
SCREW,MACHINE
ABK
EA
2
7
25
XDFZZ
SCB84518
80063
SPACER
ABK
EA
2
7
26
XDFZZ
SCC33709
80063
CASE ASSEMBLY
ABK
EA
1
7
27
XDFZZ
SCB140981
80063
SHIELD,REEL
ABK
EA
1
7
28
PAFZZ
5935-00-636-5784
SCB84538
80063
CONNECTOR,RCPT
ABK
EA
1
7
29
PAFFF
5805-00-503-3332
SMD84439
80063
SIGNAL ASSEMBLY
ABK
EA
1
7
30
XDFZZ
SCB84445
80063
HOUSING ASSEMBLY
ABK
EA
1
7
31
PAFZZ
5960-00-816-4735
PT520
70779
SEMICONDUCTOR,DIODE
ABK
EA
1
7
32
PAFZZ
5905-00-942-9326
RC20GF561K
81349
RESISTOR,FXD,CM
ABK
EA
1
7
33
PAFFF
5935-00-810-9450
SCC33721
80063
JACK,TELEPHONE
ABK
EA
1
7
34
PAFZZ
5805-00-392-7946
SMD84511
80063
REEL,CABLE
ABK
EA
1
7
35
XDFZZ
SMD84512
80063
RETAINING SPRING
ABK
EA
2
7
36
XDFZZ
MS35229-8
96906
SCREW,MACHINE
ABK
EA
3
7
37
PAFZZ
MS35649-25
96906
NUT,PLAIN,HEXAGON
ABK
EA
3
5305-00-616-8592
5310-00-208-5335
17/(18 BLANK)
TM11-5805-262-34P
Figure 8.
Accessory Kit, MX-230/PT and MX-230A/PT (Sheet 1 of 2).
19
TM11-5805-262-34P
Figure 8.
20
TM11-5805-262-34P
SECTION II
(1)
(2)
ILLUSTRATION
(a)
(b)
FIG
ITEM
SMR
NO.
NO.
CODE
(3)
(4)
NATIONAL
STOCK
NUMBER
PART
NUMBER
(5)
(6)
USABLE ON CODE
(7) (8)
QTY
INC
IN
U\M UNIT
DESCRIPTION
FSCM
GROUP 05 ACCESSORY KIT MX-230/PT AND MX-230A/PT
(PLAIN MODEL ONLY)
8
1
PACFF
5805-00-392-8058
BA31062
28528
CASE,CANVAS
5I2
EA
1
8
2
PACFF
5805-00-313-3548
SCD147777-3
80063
SLING,CARRYING
5I2
EA
1
8
3
PACFF
5805-00-503-3337
TA222PT
80058
TELEPHONE CIRCIT L JK
5I2
EA
3
8
4
PAFZZ
6240-00-196-4501
1490
24446
LAMP,INCANDESCENT
5I2
EA
2
8
5
PAFZZ
5805-00-392-8058
SCD147778
80063
CASE ASSEMBLY
5I2
EA
1
8
6
PAFZZ
5340-00-205-5159
SCD20648
80063
CATCH,LUGGAGE
5I2
EA
2
8
7
PAFZZ
5805-00-523-9045
SCB142210
80063
GASKET
5I2
EA
1
8
8
PAFZZ
8305-00-263-2462
SCD147778-1
80063
WEBBING,TEXTILE
5I2
IN
12
8
9
XDFZZ
SCC142220
80063
COVER ASSEMBLY
5I2
EA
1
8
10
PACFF
5805-00-799-3225
SCD142211
80063
CASE ASSEMBLY
5I2
EA
1
8
11
PAFZZ
5935-00-323-5995
SCB142216
80063
STUD
5I2
EA
5
8
12
PACFF
5805-00-503-3337
TA222PT
80058
TELEPHONE CIRCUIT L JK
5I2
EA
3
8
13
PAFZZ
6240-00-196-4501
1490
24446
LAMP,INCANDESCENT
5I2
EA
2
21
SECTION IV
TM11-5805-262-34P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT END OF INDEX
STOCK NUMBER
FIGURE
NO.
ITEM
NO.
STOCK NUMBER
FIGURE
NO.
ITEM
NO.
5305-00-011-7646
5305-00-011-7648
5305-00-022-6756
5935-00-192-4762
3
5
7
3
6
26
12
16
5305-00-546-6866
5305-00-546-6866
6210-00-548-0202
5305-00-549-2646
5305-00-550-9326
5305-00-550-9330
3
7
3
3
4
4
19
20
17
3
12
4
6240-00-196-4501
6240-00-196-4501
6240-00-196-4501
6240-00-196-4501
6240-00-196-4501
5310-00-208-5335
5310-00-208-5335
6625-00-244-8514
5935-00-258-8940
5305-00-263-2462
8305-00-263-2462
5910-00-280-6975
5340-00-282-0808
5340-00-282-0808
6210-00-282-0389
6210-00-284-0389
5920-00-285-0188
5805-00-313-3548
5935-00-323-5995
5935-00-323-5995
5950-00-351-5484
6350-00-351-8022
5805-00-356-2693
5805-00-356-2693
5805-00-356-3576
5805-00-356-3579
5805-00-392-7946
5805-00-392-7946
3
6
7
8
8
5
7
3
5
6
8
4
3
7
5
7
5
8
6
8
4
3
1
1
2
2
5
7
12
10
4
4
13
7
37
15
10
4
8
2
21
21
19
19
27
2
7
11
15
24
3
4
1
4
31
34
5916-00-577-6214
5310-00-579-0079
5310-00-579-0079
5310-00-595-7235
5805-00-607-0357
5995-00-607-0367
5995-00-607-0367
5310-00-616-3092
5303-00-616-3092
5303-00-616-8592
5305-00-616-8592
6135-00-635-5223
5935-00-636-5784
5935-00-636-5784
9905-00-639-1679
5950-00-645-4465
5930-00-655-1513
5985-00-659-7783
5910-00-666-7035
5910-00-666-7035
5965-00-682-2769
5805-00-715-6170
5805-00-715-6175
5
3
4
4
7
5
7
4
5
5
7
2
5
7
5
4
3
2
4
7
3
1
6
11
20
5
8
3
28
7
13
13
21
24
6
25
28
15
14
1
3
7
8
26
4
8
5805-00-392-8058
5805-00-392-8058
5805-00-392-8058
6
8
8
1
1
5
5995-00-752-2392
5935-00-786-1602
5970-00-796-1264
5970-00-796-1264
5935-00-810-9450
5950-00-811-1787
5960-00-816-4735
5325-00-835-2185
5325-00-837-3648
5325-00-837-3648
5
3
5
7
7
7
7
3
5
7
3
7
18
18
33
14
31
14
14
13
5805-00-503-3337
5805-00-503-3337
5805-00-503-3337
5805-00-503-3337
5805-00-503-3341
5805-00-503-9045
5805-00-523-9045
1
6
8
8
1
6
8
2
9
3
12
1
3
7
5310-00-983-8483
4
9
PART
NUMBER
FSCM
FIG.
NO.
ITEM
NO.
PART
NUMBER
FSCM
FIG.
NO.
ITEM
NO.
BA31062
28528
8
1
H144U
80058
2
7
JJ089
MS15795-5
MS35058-21
MS35201-11
MS35229-13
MS35229-17
MS35229-8
MS35229-8
MS35239-19
MS35239-19
MS35245-20
MS35245-24
MS35333-20
MS35333-37
MS35333-37
MS35333-87
81349
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
96906
3
4
3
7
4
4
5
7
5
7
3
5
4
3
4
5
13
9
1
12
4
12
6
36
21
24
6
26
8
20
5
12
MS35649-25
MS35649-25
MS35649-45
MS35649-45
MX230APT
MX230PT
MX2915PT
PJ051B
PJ051R
PJ051R
96906
96906
96906
96906
80063
80063
80063
81349
81349
81349
5
7
4
5
1
1
1
3
5
7
7
37
13
13
4
3
5
16
5
6
PT520
RC20GF561K
SCB14093
SCB14093
SCB140981
SCB140981
SCB142210
SCB142210
SCB142216
SCB142216
SCB33705-1
SCB33705-2
SCB33707
SCB33708
SCBB4371
SCB84389
SCB84395
SCB84406
SCB84431
SCB84432
SCB84432
SCB84438
SCB84438
SCB84439
SCB84439
SCB84440
SCB84440
SCB84445
SCB84445
SCB84461
70779
81349
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
80063
7
7
3
7
5
7
6
8
6
8
7
7
7
7
2
2
2
2
5
5
7
5
7
7
5
5
7
5
7
7
31
32
19
20
24
27
3
7
7
11
11
10
9
14
4
5
1
6
22
20
23
15
15
29
8
19
19
9
30
21
22
SECTION IV
PART
NUMBER
SCB84480
SCB84480
SCB84485
SCB84485
SCB84505
SCB84505
SCB84518
SCB84518
SCB84538
SCB84538GRP1
SCB84538GRP11
SCB84579
SCB84580
SCB84616
SCB84618
SCB84620
SCB84261
SCC142220
SCC27394
SCC33709
SCC33721
SCC35755
SCC35755
SCC35756
SCC35756
SCC84365
SCC84430
SCC84431
SCC84478
SCC84585
SCC84598
SCC84612
SCC84619
SCD142211
SCD142211
SCD14777-3
SCD147778
SCD147778
SCD147778-1
SCD147778-1
SCD20648
SCD20648
TM11-5805-262-34P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
FIG.
ITEM
PART
FSCM
NO.
NO.
NUMBER
80063
5
18
SCD35754
80063
7
18
SCD35754
80063
5
17
SMB108453
80063
7
17
SMB361801
80063
5
16
SMB361801
80063
7
16
SMB361802
80063
5
22
SMB361802
80063
7
25
SMB84461
80063
7
28
SMB84543
80063
5
25
SMC361818
80063
3
7
SMC84433
80063
3
25
SMD145951
80063
4
3
SMD361814
80063
3
8
SMD361821-11
80063
3
5
SMD361821-7
80063
3
22
80063
3
23
80063
8
9
SMD84439
80063
3
15
SMD84511
80063
7
26
SMD84511
80063
7
33
SMD84512
80063
5
3
SMD84512
80063
7
4
TA221PT
80063
7
7
TA222PT
80063
5
28
TA222PT
80063
2
3
TA326PT
80063
7
1
TCS61594-81XP10
80063
7
2
U79U
80063
5
10
Z3126
80063
4
15
1N538
80063
4
14
101
80063
3
10
1490
80063
3
11
1490
80063
8
10
1490
80063
6
6
1490
80063
8
2
191F56492SA
80063
6
1
29F407G2
80063
8
5
29G407A
80063
6
4
332-11-05-055
80063
8
8
353-17-03-001
80063
6
2
96TM-62
80063
8
6
LATEST NATIONAL STOCK NUMBER ASSIGNMENTS
FIGURE ITEM
NO.
NO.
STOCK NUMBER
5305-00-043-6803
5310-00-088-0551
5935-00-192-4789
5340-00-205-5159
5340-00-205-5159
5310-00-261-7156
5805-00-503-3332
5805-00-503-3332
5805-00-542-1469
5805-00-607-0357
9905-00-639-1679
5965-00-632-2769
5805-00-799-3225
5805-00-799-3225
5935-00-837-5969
5935-00-837-5969
5905-00-942-9326
5305-00-958-5457
PART
NUMBER
2
9
2
10
3
13
6
2
8
6
7
22
5
8
7
29
3
2
5
30
7
15
2
7
6
6
8
10
5
5
7
6
7
32
2
12
LATEST PART NUMBER ASSIGNMENTS
FIG.
ITEM
FSCM
NO.
NO.
G42A/PT
MS35190-226
MS35227-15
MS35333-78
SCB84388
SCC25265
TA222PT
TA222PT
22NM-40
80058
96906
96906
96906
80063
80063
80058
80058
72962
3
2
2
7
2
2
8
8
2
2
12
9
22
11
8
3
12
10
23
FSCM
FIG.
NO.
ITEM
NO.
80063
80063
80063
80063
80063
80063
80063
80063
81349
80063
80063
80063
80063
80063
80063
5
7
4
5
7
5
7
3
5
3
5
3
2
3
3
30
3
10
4
5
14
13
21
27
4
23
26
2
9
18
80063
80063
80063
80063
80063
80058
80058
80058
80058
72619
80063
76385
81349
19557
24446
24446
24446
24446
56289
24446
24446
78189
78189
80063
5
5
7
5
7
1
1
6
6
3
3
3
5
3
3
6
8
8
4
4
7
4
4
4
8
31
34
29
35
1
2
9
8
17
3
14
11
24
12
10
4
13
2
7
8
11
6
1
SECTION IV
TM11-5805-262-34P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
ADDITIONAL LATEST STOCK NUMBER ASSIGNMENTS
STOCK NUMBER
FIGURE
NO.
ITEM
NO.
5340-00-324-9411
5330-00-351-4188
5999-00-643-7687
2
2
2
8
11
13
ADDITIONAL LATEST PART NUMBER ASSIGNMENTS
PART
NUMBER
FSCM
FIG.
NO.
ITEM
NO.
SCB84384
80063
2
13
24
TM 11-5805-262-34P
By Order of the Secretary of the Army:
BERNARD W. ROGERS
General, United States Army
Chief of Staff
Official:
J. C. PENNINGTON
Brigadier General, United States Army
The Adjutant General
Distribution:
Active Army:
USAINSCOM (2)
COE (1)
TSG (1)
USAARENBD (1)
DARCOM (1)
TECOM (2)
USACC (4)
USACC-EUR (2)
TRADOC (2)
OS Maj Comd (4)
HQ 7th Sig Comd (2)
MDW (1)
Armies (2)
Corps (2)
HISA (Ft Monmouth) (33)
Fort Gillem (10)
Fort Gordon (10)
Fort Huachuca (10)
Fort Carson (5)
Ft Richardson (CERCOM Oft) (2)
Svc Colleges (1)
USASIGS (5)
USAICS (3)
USAADS (2)
USAFAS (2)
USAARMS (2)
USAIS (2)
USAES (2)
AD (1) except
SAAD (30)
LBAD (14)
TOAD (14)
SHAD (3)
USA Dep (1)
Sig Sec USA Dep (1)
USMA (2)
USAJFKCENMA (2)
USATC&S (2)
USAQMS (2)
USAEPG (2)
MAAG (1)
USARMIS (1)
USAERDAA (1)
USAERDAW (1)
Units org under fol TOE :-1 ea. UNOINDC
11-15
29-56
11-16
29-207 (2)
11-17
29-610 (2)
11-18
11-19
11-25
11-26
11-27
11-35
11-36
11-37
11-38
11-39
11-45
11-46
11-47
11-85
11-86
11-87
11-95
11-97
11–98
11-116
11-117
11-127
11-137
11-205
11-206
11-207
11-215
11-217
11-218
11-226
11-226
11-227
11-228
11-237
11-303
11-327
11-357
11-367
11-377
11-500 (AA-AC)
ARNG: State AG (3); Units-Same as Active Army.
USAR: None.
For explanation of abbreviationa used, see AR 310-50.
3hJ.S. GOVERNMENT PRINTING OklVCE: 1992- 311-831/44368
PIN : 034008 - 000
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly
available information, slap “watermarks” and other junk on it, and sell it.
Those masters of search engine manipulation make sure that their sites that
sell free information, come up first in search engines. They did not create it...
They did not even scan it... Why should they get your money? Why are not
letting you give those free manuals to your friends?
I am setting this document FREE. This document was made by the US
Government and is NOT protected by Copyright. Feel free to share,
republish, sell and so on.
I am not asking you for donations, fees or handouts. If you can, please
provide a link to liberatedmanuals.com, so that free manuals come up first in
search engines:
<A HREF=http://www.liberatedmanuals.com/>Free Military and Government Manuals</A>
– Sincerely
Igor Chudov
http://igor.chudov.com/
– Chicago Machinery Movers
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement