TM-11-5805-689-24P

TM-11-5805-689-24P
TM 11-5805-689-24P
TECHNICAL MANUAL
ORGANIZATIONAL, DIRECT SUPPORT, AND
GENERAL SUPPORT
MAINTENANCE REPAIR PARTS AND
SPECIAL TOOLS LISTS
(INCLUDING DEPOT MAINTENANCE REPAIR
PARTS AND SPECIAL TOOLS)
FOR
CONVERTER, TELEPHONE SIGNAL
CV-1919/G
(NSN 5805-00-910-8848)
HEADQUARTERS, DEPARTMENT OF THE ARMY
JULY 1978
TM 11-5805-689-24P
HEADQUARTERS
DEPARMENT OF THE ARMY
W ASHINGTON , DC, 17 July 1978
T ECHNICAL M A N U A L
No. 11-5805-689-24P
ORGANIZATIONAL, DIRECT SUPPORT,
AND GENERAL SUPPORT
MAINTENANCE REPAIR PARTS
AND SPECIAL TOOLS LISTS
(INCLUDING DEPOT MAINTENANCE REPAIR
PARTS AND SPECIAL TOOLS)
FOR
CONVERTER, TELEPHONE SIGNAL CV-1919/G
(NSN 5805-00-910-8848)
REPORTING OF ERRORS
You can improve this manual by recommending improvements using DA Form
2028 located in the back of the manual. Simply tear out the self addressed form, fill
it oat as shown on the sample, fold it where shown, and drop it in the mail.
If there are no blank Form 2028-2 in the back of your manual, use the standard
DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Communications and Electronics Materiel
Readiness Command, ATTN: DRSEL-MA-Q, Fort Monmouth, New Jersey 07703.
In either case a reply will be furnished direct to you.
Table of Contents
SECTION
Group
I.
II.
00
01
02
03
SECTION
III.
IV.
Page
1
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5
Repair parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5
Converter, Telephone signal CV-1919/G. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
7
Chassis. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9
Channel module. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13
0201 Channel module circuit card. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17
Common module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
0301 Common module circuit card. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
0302 0scillator assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
0303 Keyset assembly (No parts authorized
Special tools list (Not applicable)
National stock number and parts number index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
25
27
Ilus
Figure
1
2
3
4
5,6
7
8,9
30
i
TM 11-5895-689-24P
SECTION I
INTRODUCTION
1. Scope
Code
This manual lists spares and repair parts: special
tools; special test, measurement, and diagnostic
equipment (TMDE), and other special support
equipment required for performance of
organizational, direct support, and general support
maintenance of the CV-19191/G. It authorizes the
requisitioning and issue of spares and repair parts
as indicated by the source and maintenance codes.
XA–Item is not procured or stocked because the
requirements for the item will result in the
replacement of the next higher assembly.
XD–A support item that is not stocked. When
required, item will be procured through normal supply channels.
2. General
This Repair Parts and Special Tools List is divided
into the following sections:
a. Section II. Repair Parts List. A list of spares
and repair parts authorized for use in the performance of maintenance. The list also includes
parts which must be removed for replacement of the
authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in
each group listed in figure and item number sequence.
b. Section III. Special Tools List. Not applicable.
c. Section IV. National Stock Number and Part
Number Index. A list, in National item identification number (NIIN) sequence, of all National
stock numbers (NSN) appearing in the listings,
followed by a list, in alphameric sequence, of all part
numbers appearing in the listings. National stock
numbers and part numbers are cross-referenced to
each illustration figure and item number appearance.
3. Explanation of Columns
a. Illustration. This column is divided as follows:
(1) Figure number. Indicates the figure number
of the illustration on which the item is shown.
(2) Item number. The number used to identify
item called out in the illustration.
b. Source, Maintenance, and Recoverability
(SMR) Codes.
(1) Source code. Source codes indicate the manner of acquiring support items for maintenance,
repair, or overhaul of end items. Source codes are entered in the first and second positions of the
Uniform SMR Code format as follows:
Code
Definition
PA–Item procured and stocked for anticipated or
known usage.
Definition
NOTE
Cannibalization or salvage may be used
as a source of supply for any items source
coded above except those coded XA and
aircraft support items as restricted by
AR 700-42.
(2) Maintenance code. Maintenance codes are
assigned to indicate the levels of maintenance
authorized to USE and REPAIR support items. The
maintenance codes are entered in the third and
fourth positions of the Uniform SMR Code format
as follows:
(a) The maintenance code entered in the third
position will indicate the lowest maintenance level
authorized to remove, replace, and use the support
item The maintenance code entered in the third
position will indicate one of the following levels of
maintenance:
Code
Application/Explanation
O–Support item is removed, replaced, used at the
organizational level.
F–Support item is removed, replaced, used at the
direct support level.
D–Support items that are removed, replaced, used
at depot, mobile depot, specialized repair activity only.
(b) The maintenance code entered in the
fourth position indicates whether the item is to be
repaired and identifies the lowest maintenance level
with the capability to perform complete repair (i.e.,
all authorized maintenance functions). This position
will contain one of the following maintenance codes:
Code
Application/Explanation
D—The lowest maintenance level capable of complete repair of the support item is the depot
level.
Z–Nonreparable. No repair is authorized.
(3) Recoverability code. Recoverability codes
are assigned to support items to indicate the
disposition action on unserviceable items. The
1
recoverability code is entered in the fifth position of
the Uniform SMR Code format as follows:
Recoverabiliy
codes
Definition
Z–Nonreparable item. When unserviceable, condemn and dispose at the level indicated in
position 3.
D – Reparable item. When beyond lower level repair
capability, return to depot. Condemnation
and disposal not authorized below depot level.
L– Reparable item. Repair, condemnation, and
disposal not authorized below depot/
specialized repair activity level.
c. National Stock Number. Indicates the
National stock number assigned to the item and will
be used for requisitioning purposes.
d. Part Number. Indicates the primary number
used by the manufacturer (individual, company,
firm, corporation, or Government activity), which
controls the design and characteristics of the item
by means of its engineering drawings,
specifications, standards, and inspection
requirements to identify an item or range of items.
NOTE
When a stock numbered item is
requisitioned, the repair part received
may have a different part number than
the part being replaced.
e. Federal Supply Code for Manufacturur
(FSCM). The FSCM is a 5-digit numeric code listed
in SB 708-42 which is used to identify the manufacturer, distributor, or Government agency, etc.
f. Description. Indicates the Federal item name
and, if required, a minimum description to identify
the item.
g. Unit of Measure (U/M). Indicates the standard
of the basic quantity of the listed item as used in
performing the actual maintenance function. This
measure is expressed by a two-character
alphabetical abbreviation (e.g., ea in pr, etc). When
the unit of measure differs from the unit of issue, the
lowest unit of issue that will satisfy the required
units of measure will be requisitioned.
h. Quantity Incorporated in Unit. Indicates the
quantity of the item used in the breakout shown on
the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly.
4. Special Information
The following publications pertain to the
CV-1919/G and its components:
TM 11-5805-689-14, Telephone Signal CV-1919G
5. How to Locate Repair Parts
a. When National stock number or part number is
unknown.
(1) First. Using the table of contents, determine the functional group within which the item
belongs. This is necessary since illustrations are
prepared for functional groups and listings are
divided into the same groups.
(2) Second. Find the illustration covering the
functional group to which the item belongs.
(3) Third. Identify the item on the illustration
and note the illustration figure and item number of
the item.
(4) Fourth. Using the Repair Parts Listing.
find the figure and item number noted on the
illustration.
b. When National stock number or part number is
known.
(1) First. Using the Index of National Stock
Numbers and Part Numbers, find the pertinent
National stock number or part number. This index
is in NIIN sequence followed by a list of part numbere in alphameric sequence, cross-referenced to the
illustration figure number and item number.
(2) Second. After finding the figure and item
number, locate the figure and item number in the
repair parts list.
6. Abbreviations
Not applicable
(Next printed page is 4.)
2
TM11-5805-689-24P
Figure 1.
4
Converter, Telephone Signal CV-1919/G.
TM11-5805-689-24P
SECTION II
5
TM11-5805-689-24P
6
Figure 2
TM11-5805-669-24P
SECTION II
7
TM11-5805-669-24P
Figure 3.
8
Channel Module.
TM11-5805-669-24P
SECTION II
9
TM11-5805-689-24P
SECTION II
10
TM11-5805-689-24P
Figure 4.
Channel Module Circuit Card (Sheet 1 of 2).
11
TM11-5805-689-24P
12
Figure 4.
TM11-5805-689-24P
SECTION II
13
TM11-5805-689-24P
SECTION II
14/(15 BLANK)
TM11-5805-689-24P
16
Figure 5.
Common Module, Rear, Left Hand Side,
Front, Right Hand Side and Top Views.
TM11-5805-689-24P
SECTION II
17
TM11-5805-689-24P
SECTION II
18/(19 BLANK)
TM11-5805-689-24P
Figure 6.
20
Common Module, Battery Case, Top, Side
and Front Views.
TM11-5805-689-24P
SECTION II
21/(22 BLANK)
TM-5805-689-24P
Figure 7.
Common Module Circuit Card (Sheet 1 of 2).
23
TM11-5805-689-24P
REF
DES
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
CR101
CR102
CR103
CR104
CR105
CR106
CR107
CR108
CR109
CR110
CR111
CR112
CR113
CR 1 14
CR115
CR116
CR117
CR118
CR 1 19
CR120
CR121
CR122
E1
E2
E3
E4
E5
E6
E7
E8
E9
ITEM NO.
2
32
31
3
7
13
3
20
20
13
7
3
15
15
15
14
15
15
15
15
14
15
15
15
15
15
14
15
15
15
15
15
15
15
24
24
24
24
24
24
24
24
24
R E F
D E S
E10
E11
E12
E13
E14
E15
E16
E17
E18
E19
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q108
Q109
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
T101
T102
T103
I T E M
N O .
24
24
24
24
24
24
24
24
24
24
10
8
10
8
8
8
10
8
10
5
5
29
27
28
5
5
11
11
12
17
19
4
5
5
11
11
12
17
16
18
1
21
6
EL3LM011
Figure 7.
24
Common Module Circuit Card (Sheet 2 of 2).
TM11-5805-689-24P
SECTION II
25
TM11-5805-689-24P
Figure 8.
26
Oscillator Assembly, Mounting Details.
TM11-5805-689-24P
SECTION II
27
TM11-5805-689-24P
28
Figure 9.
T11-5805-689-24P
SECTION II
29
SECTION
II
TM11-5805-689-24P
30
TM11-5805-689-24P
SECTION IV
31
SECTION
TM11-5805-689-24P
IV
32
By Order of the Secretary of the Army:
Official:
BERNARD W. ROGERS
Genenal, United States Army
Chief of Staff
J.C. PENNINGTON
Brigadier General, United States Army
The Adjutant General
Distribution:
Active Army:
USAINSCOM (2)
COE(l)
TSG(1)
USAARENBD (1)
DARCOM (1)
TRADOC (2)
OS Maj Comd (4)
TECOM (2)
USACC (4)
MDW(l)
Armies (2)
Corps (2)
Svc Colleges (1)
USASIGS (5)
USAADS (2)
USAFAS (2)
USAARMS (2)
USAIS (2)
USAES (2)
USAICS (3)
MAAG (1)
USARMIS (1)
USAERDAA (1)
NG: N o n e
USAR: N o n e
For explanation of abbreviations usdd. see AR 310-50.
USAERDAIV (1)
Ft Monmouth (HISA) (33)
Fort Gillem (10)
Fort Gordon (10)
Fort Carson (5)
Fort Huachuca (10)
Ft Richardson (CERCOM) (2)
Army Dep (1) except
LBAD (14)
SAAD (30)
TOAD (14)
SHAD (3)
USA Dep (1)
Sig Sec USA Dep (1)
Units org under fol TOE:
(1 cy each UNOINDG)
11-35
29-16
29-26
29-36
29-134
29-207 (2)
29-610 (2)
PIN:034969-000
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly
available information, slap “watermarks” and other junk on it, and sell it.
Those masters of search engine manipulation make sure that their sites that
sell free information, come up first in search engines. They did not create it...
They did not even scan it... Why should they get your money? Why are not
letting you give those free manuals to your friends?
I am setting this document FREE. This document was made by the US
Government and is NOT protected by Copyright. Feel free to share,
republish, sell and so on.
I am not asking you for donations, fees or handouts. If you can, please
provide a link to liberatedmanuals.com, so that free manuals come up first in
search engines:
<A HREF=http://www.liberatedmanuals.com/>Free Military and Government Manuals</A>
– Sincerely
Igor Chudov
http://igor.chudov.com/
– Chicago Machinery Movers
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement