CARAUDIO-SYSTEMS ZL-MYGIG Audio Video Interface Manual

Version 09.01.2014

z.LiNK-Interface

ZL-MYGIG

Audio-video-input incl. video-in-motion for Chrysler, Dodge and Jeep vehicles with MYGIG navigation systems

AV-input to connect any AV-source to the factory navigation system incl. video-in-motion

ZL-MYGIG

Contents

1. Prior to installation

1.1.

1.2.

1.3.

Delivery contents

Check compatibility of vehicle and accessories

Pin assignments

2. Connection schema

3. Installation

3.1. Activation of the interface as current AV-source

4. Activation of the video-in-motion function

5. Specifications

6. Technical Support

Legal Information

By law, watching moving pictures while driving is prohibited, the driver must not be distracted. We do not accept any liability for material damage or personal injury resulting, directly or indirectly, from installation or operation of this product. This product should only be used while standing or to display fixed menus or rear-view-camera video when the vehicle is moving, for example the MP3 menu for DVD upgrades.

Changes/updates of the vehicle’s software can cause malfunctions of the interface. We offer free software-updates for our interfaces for one year after purchase. To receive a free update, the interface must be sent in at own cost. Labor cost for and other expenses involved with the software-updates will not be refunded.

Version 09.01.2014

ZL-MYGIG

1. Prior to installation

Read the manual prior to installation. Technical knowledge is necessary for installation. The place of installation must be free of moisture and away from heat sources.

1.1. Delivery contents

Take down the SW-version and HW-version of the interface boxes, and store this manual for support purposes.

1.2. Check compatibility of vehicle and accessories

Requirements

Vehicle Chrysler Town & Country 2008-2012

Dodge Grand Caravan 2008-2012, Dodge Journey 2008-2010,

Dodge Nitro 2007-2012, Dodge RAM 1500 2009-2012, Dodge

RAM 2500 2010-2012, Dodge RAM 3500 2010-2012

Navigation

Limitations

Jeep Grand Cherokee, 2012,Jeep Liberty 2008, Jeep Wrangler

2007-2012

Lancia Voyager from 2011

MYGIG REW, RER, REN and RHW with high-speed IHS-CAN (125 kbit)

Factory-RSE

Video-sources

Must NOT be installed.

Only compatible to NTSC-video-sources.

For vehicles with low-speed-B-CAN (83 kbit) the ZL-MYGIG-V2 must be used!

Version 09.01.2014

ZL-MYGIG

1.3. Pin-assignments

Pin-assignment AV-INPUT

Connection Cable colour/connector White 22pin MYGIG connector

Video input

Video signal

RCA female yellow

● yellow → pin 9

Ground

Audio input

● black

RCA female red/white

Audio signal (right) ● red

→ pin 10

→ pin 14

Audio signal (left) ● white → pin 13

Audio ground ● black → pin 01

Pin-assignment AV-OUTPUT (rear-seat-entertainment)

Connection Cable colour/connector White 22pin MYGIG connector

Video output RCA female yellow

Video signal

Ground

● yellow

● black

→ pin 6

→ pin 7

Audio output RCA female red/white

Audio signal (right) ● red → pin 20

Audio signal (left) ● white → pin 18

Audio ground ● black → pin 19

Pin-assignment white 22pin connector

Version 09.01.2014

ZL-MYGIG

2. Connection schema

Version 09.01.2014

ZL-MYGIG

3. Installation

Switch off ignition and disconnect the vehicle’s battery! If according to factory rules disconnecting the battery has to be avoided, it is usually sufficient to put the vehicle in sleep-mode. In case the sleep-mode does not show success, disconnect the battery with a resistor lead.

Place of installation is behind the head-unit.

Version 09.01.2014

ZL-MYGIG

Instruction for example Chrysler C300

Remove the front panel from the centre console, which is attached to multiple clips.

Remove the 4 TORX screws and pull the device out of the centre console.

Remove the grey female 22pin connector from the rear of the device and connect it to harness TV-MYGIG. Connect the grey female 22pin connector of harness TV-MYGIG to the device.

Connect the AV-input and the AV-output to the white female

22pin connector according the pin assignment and connect the

Female RCA to the av-sources.

Note: Use the attached white female 22pin connector if the male 22pin connector of the head-unit isn’t occupied by a white female 22pin connector.

If the male 22pin connector of the head-unit is occupied by a white female 22pin connector connect the pins into the white female 22pin connector of the vehicle (the attached white female connector will not be required.

There are 2 options if the pins are occupied by factory:

1. Factory-RSE is installed. This interface will not be needed (separate video-in-motion

TF-MYGIG optionally available).

2. Factory RSE isn’t installed. The pins are prepared by factory and can be removed.

Version 09.01.2014

ZL-MYGIG

3.1. Activation of the interface as current AV-source

Press RADIO/MEDIA button and after it VES followed by AUX IN 1 via Touch-Screen to select the interface as current AV-source.

4. Activation of the video-in-motion function

The video-in-motion can be activated and deactivated by Dip 1 or alternatively by the included loose green cable in connection with a switch (not included in delivery).

Video-in-motion permanent Dip 1 ON, Dip 2 OFF, Dip 3 OFF

With dip1 to ON the video-in-motion function is activated permanently without disturbing the navigation performance.

Video-in-motion selective Dip 1 OFF, Dip 2 OFF, Dip 3 OFF

With dip1 to OFF the included green cable is used to activate the video-in-motion function.

Connect a switch to the green cable and connect the green cable to +12V ACC.

● +12V = TV-Free is activated

● 0V = TV-Free is not activated

Note: The loose white cable is not required and must be isolated.

Version 09.01.2014

ZL-MYGIG

5. Specifications

Operation voltage

Stand-by power drain

Operation power drain

Power consumption

10.5 – 14.8V DC

>1mA

~60mA

~0,72W

Temperature range

Weight

-30°C to +80°C

44g

Measurements (box only) B x H x T 70 x 20 x 47 mm

6. Technical Support

Caraudio-Systems Vertriebs GmbH

manufacturer/distribution

Rheinhorststr. 22

NavLinkz GmbH

corporate sales/tech dealer-support

Eurotec-Ring 45

D-47445 Moers D-67071 Ludwigshafen am Rhein phone +49 180 3 907050 email [email protected]

Legal disclaimer: Mentioned company and trademarks, as well as product names/codes are registered trademarks ® of their corresponding legal owners.

Version 09.01.2014

ZL-MYGIG