Blue Rhino RV2301CLB Owner's Manual

OWNER’S MANUAL
Outdoor LP Gas Barbecue Grill
WARNING
Model No. RV2301CLB
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury, or death.
4. This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
5. Read and follow all warnings and
instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when
using the appliance.
7. Keep this manual for future reference.
Made from 75% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
DANGER
If you smell gas 1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your fire
department.
Failure to follow these instructions could result
in fire or explosion which could cause property
damage, personal injury or death.
Table of Contents
Important Safeguards 0AGE %XPLODED 6IEW (ARDWARE Assembly Instructions Attach Grill /PERATING )NSTRUCTIONS #ONNECT ,0 'AS ,INE $ISCONNECT ,0 'AS ,INE Checking for Leaks WARNING
FOR YOUR SAFETY:
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
DANGER
1. Do not leave a lit grill unattended.
2. Do not put grill in storage or travel mode
immediately after use. Allow grill to cool to
touch before moving or storing. Failure to do
so could result in a fire resulting in property
damage, personal injury or death.
DANGER
First Use Lighting 4URNING /FF Cooking Controlling Flare ups Tips Cleaning and Care 0RODUCT 2EGISTRATION 9
Limited Warranty 9
Troubleshooting 4HE USE AND INSTALLATION MUST CONFORM WITH LOCAL CODES OR IN THE ABSENCE OF LOCAL
CODES WITH EITHER THE National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas
and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA
Z240 RV Series, Recreational Vehicle Code, AS APPLICABLE
#ALIFORNIA 0ROPOSITION #HEMICALS KNOWN TO THE 3TATE OF #ALIFORNIA TO CAUSE CANCER
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM ARE CREATED BY THE COMBUSTION OF PROPANE
#ALIFORNIA 0ROPOSITION 7ASH YOUR HANDS AFTER HANDLING THIS PRODUCT
Never operate this appliance unattended.
3AVE THESE INSTRUCTIONS FOR FUTURE REFERENCE
If you are assembling this unit for someone else,
GIVE THIS MANUAL TO HIM OR HER TO READ AND SAVE
FOR FUTURE REFERENCE
Manufactured in China for: Blue Rhino Global Sourcing, Inc
7INSTON3ALEM .# 53! s WWWBLUERHINOCOM
¥ "LUE 2HINO 'LOBAL 3OURCING )NC !LL 2IGHTS 2ESERVED
Blue Rhino® IS A REGISTERED TRADEMARK OF &ERRELLGAS ,0 !LL 2IGHTS 2ESERVED
26#,"/- %
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
This grill is for outdoor use only and shall not be used in a building,
garage or any other enclosed area.
This grill is not intended for and should never be used as a heater. TOXIC
fumes can accumulate and cause asphyxiation.
This grill is NOT for commercial use.
This is not a tabletop grill. Therefore, do not operate this grill on any type
of tabletop surface.
This grill is safety certified for use in the United States and Canada only.
Do not modify for use in any other location. Modification will result in a
safety hazard and will void warranty.
Do NOT operate, light or use this appliance within ten (10) feet (3.05 m)
of walls, structures or buildings.
Apartment Dwellers: Check with management to learn the requirements
and fire codes for using an LP gas grill in your apartment complex. If
allowed, use outside on the ground floor with a ten (10) foot (3.05 m)
clearance from any structure. Do not use on or under balconies.
This grill is for use with liquid propane (LP) gas only. The conversion to
or attempted use of natural gas in this LP gas grill is dangerous and will
void your warranty.
LP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
aware of the characteristics before using any LP gas product.
b. LP gas is explosive under pressure, heavier than air and settles and
pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
d. Contact with LP gas can cause freeze burns to skin.
Only tanks marked “propane” may be used with this appliance.
The LP gas tank must be constructed and marked in accordance
with the Specifications for LP gas Cylinders of the U.S. Department of
Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339,
Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods;
and Commission.
LP gas tank must be arranged for vapor withdrawal.
Dented or rusted LP gas tanks may be hazardous and should be checked
by your LP gas supplier prior to use.
The LP gas tank should not be dropped or handled roughly.
LP gas tanks must be stored outdoors out of the reach of children and
must not be stored in a building, garage, or any other enclosed area. Your
tank must never be stored where temperatures can reach over 125°F.
Do not insert any tool or foreign object into the valve outlet or safety
relief valve. You may damage the valve and cause a leak. Leaking
propane may result in explosion, fire, severe personal injury or death.
Do not block holes in sides, back or bottom of grill.
Never attempt to attach this grill to the self-contained LP gas system of
a camper trailer, motor home or house.
Do not store a spare LP gas tank under or within 25 feet (7.62 m) of this
appliance.
The use of alcohol, prescription or non-prescription drugs may impair
the consumer’s ability to properly assemble or safely operate the
appliance.
Strong odors, colds, sinus congestion, etc. may prevent the detection of
propane. Use caution and common sense when testing for leaks.
Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or
alcohol with this product.
Your grill has been checked at all factory connections for leaks.
Recheck all connections as described in the “Operating Instructions”
section of the manual, as movement in shipping can loosen connections.
Check for leaks even if your unit was assembled for you by someone
else.
Do not operate if gas leak is present. Gas leaks may cause a fire or
explosion.
You must follow all leak-checking procedures before operating. To
prevent fire or explosion hazard when testing for a leak:
a. Always perform leak test before lighting the grill and each time the
tank is connected for use.
b. Do not use or permit sources of ignition in the area while conducting
a leak test. No smoking.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do not use matches, lighters or a flame to check for leaks.
e. Do not use grill until any and all leaks are corrected.
If you are unable to stop a leak disconnect the LP gas supply. Call our
customer care at 1.800.762.1142, a gas appliance serviceman or your
local LP gas supplier.
Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
Minimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do not use this appliance under any
type of overhang or roof.
It is essential to keep the grill’s valve compartment, burners, and
circulating air passages clean. Inspect grill before each use.
Do not use the grill unless it is COMPLETELY assembled and all parts are
securely fastened and tightened.
This grill should be thoroughly cleaned and inspected on a regular basis.
Do not alter grill in any manner. Any alteration will void your warranty.
Use only the regulator provided. Any replacement regulator shall be
specified by the manufacturer.
Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous. This will
also void your warranty.
Do not attempt to repair or alter the hose/regulator for any “assumed”
defect. Any modification to this assembly will void your warranty and
create the risk of a gas leak and fire. Use only authorized replacement
parts supplied by manufacturer.
Do not use this appliance without reading “Operating Instructions” in
this manual.
Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
Do not install or use in or on boats or recreational vehicles.
Do not use grill in a vehicle trunk, station wagon, mini-van, sport utility
vehicle (SUV) or recreational vehicle (RV).
When cooking fire extinguishing materials shall be readily accessible. In
the event of an oil/grease fire, do not attempt to extinguish with water.
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
baking soda.
Move gas hoses as far away as possible from hot surfaces and dripping
hot grease.
Do not use grill in high winds.
Never lean over grill when lighting.
Do not leave a lit grill unattended. Keep children and pets away from grill
at all times.
Do not leave grill unattended while preheating or burning off food
residue on HIGH. If grill has not been cleaned, a grease fire can occur
that may damage the product.
Do not place empty cooking vessels on the appliance while in operation.
Use caution when placing anything on the grill while the appliance is in
operation.
Do not attempt to move grill when in use. Allow the grill to cool
(approximately 45 minutes) before moving or storing.
Storage of grill indoors is permissible only if the tank is disconnected,
removed from the grill and properly stored outdoors.
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
Do not attempt to disconnect the gas regulator from the tank or any gas
fitting while the grill is in use.
Disconnect LP gas tank when not in use.
Always use your grill on a hard, non-combustable level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
Do not use directly on wooden decks.
Keep all electrical cords away from a hot grill.
Do not use grill for indoor cooking or heating. TOXIC fumes can
accumulate and cause asphyxiation.
After a period of storage and/or nonuse check for leaks and burner
obstructions.
Failure to open lid while igniting the grill’s burner, or not waiting 5
minutes to allow the gas to clear if the grill does not light, may result in
an explosive flame-up.
Never operate grill without heat plate installed.
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
Use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
Never cover entire cooking area with aluminum foil.
Death, serious injury or damage to property may occur if the above is not
followed exactly.
PAGE NO
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com.
Parts List
Exploded View
1
Warming Rack
2
,ID (ANDLE
3
Temperature Gauge*
4
Cooking Grid
5
Lid*
6
(EAT 0LATE
7
4OP (INGE 8
"OTTOM (INGE 9
Burner*
10
%LECTRODE
11
Ignitor Wire*
12
2EAR (EAT 2EFLECTOR
13
(EAT 0LATE
3UPPORT 14
,EG 3UPPORT ! 15
,EG 3UPPORT " 16
Control Knob*
17
"OTTOM "OWL
18
#ONTROL 0ANEL
19
Ignitor*
20
#ONTROL 6ALVE
21
"OTTOM (EAT
Reflector*
22
Lock*
23
Grill Mounting Rack
&OOT 24
2UBBER "UMPERS 25
,EG 26
Rear Grill Mounting
Rack
27
Front Grill Mounting
Rack
28
,ID (ANDLE (EAT 0LATE 1
2
28
3
4
5
6
7
9
10
12
8
14
11
13
21
15
17
13
15
18
23
24
23
16
22
19
14
20
26
25
27
0REASSEMBLED
Hardware
A
B
C
D
%
F
Tools Required for Assembly (Included)
Wing Bolt
-X :INC 0LATED 0HILLIPS 4RUSS (EAD
PCS
Wing Nut
- 3TEEL
PCS
Washer
’ !LUMINUM
PCS
Washer
’ (EAT 2ESISTANT
PCS
Lock Washer
’ :INC 0LATED
PCS
#OTTER 0IN
’ X 3TEEL
PCS
0HILLIPS (EAD 3CREWDRIVER
PC
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
Assembly Instructions
1
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.762.1142 TOLL FREE 0LEASE HAVE
YOUR OWNERS MANUAL AND MODEL NUMBER AVAILABLE FOR
REFERENCE
2
Attach Legs
Note: 4HE MODEL NUMBER CAN BE FOUND ON THE BACK OR SIDE OF THE GRILL
&OR %ASIEST !SSEMBLY
s 4O AVOID LOSING ANY SMALL COMPONENTS OR HARDWARE ASSEMBLE
YOUR PRODUCT ON A HARD LEVEL SURFACE THAT DOES NOT HAVE CRACKS
OR OPENINGS
s #LEAR AN AREA LARGE ENOUGH TO LAYOUT ALL COMPONENTS AND
HARDWARE
s 7HEN APPLICABLE TIGHTEN ALL HARDWARE CONNECTIONS BY HAND
FIRST /NCE THE STEP IS COMPLETED GO BACK AND FULLY TIGHTEN ALL
HARDWARE
s &OLLOW ALL STEPS IN ORDER TO PROPERLY ASSEMBLE YOUR PRODUCT
4O COMPLETE ASSEMBLY YOU WILL NEED
s ,EAK $ETECTION 3OLUTION )NSTRUCTIONS ON HOW TO MAKE
SOLUTION ARE INCLUDED IN h/PERATING )NSTRUCTIONSv SECTION
4YPICAL ASSEMBLY APPROXIMATELY MINUTES
3
4
Secure Legs
Attach Lid Handle Heat Plate and Lid Handle
B
F
x4
C
x2
x2
D
%
x2
x2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com.
5
7
6
Insert Warming Rack
8
Assemble Grill Mounting Rack
Insert Heat Plate and Cooking Grid
Lock Lid
Unlock Lid
B
A
x2
x2
PAGE NO
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
Assembly Instructions (continued)
9
Fold Legs
Note: !LWAYS LOCK LID BEFORE FOLDING LEGS
Attach Grill
1
Attach Grill Mounting Rack
Unfold Legs
Note: !LWAYS OPEN LEGS COMPLETELY AND SECURE IN PLACE BEFORE LIGHTING
2
Attach Grill
PAGE NO
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com.
Operating Instructions (continued)
Connecting LP Gas Line
4O OPERATE YOU WILL NEED PRECISIONFILLED ,0 GAS
TANK LB LB OR LB WITH EXTERNAL VALVE
threads and securely fastened to the recreational
VEHICLE 26
First Use
Figure 1
CAUTION: LP gas tank must be
properly disconnected and removed
prior to moving this grill.
1
Lighting
Only cylinders marked “propane” may be used.
,0 GAS TANK MUST BE IN THE h#,/3%$v POSITION
#ONTROL KNOB MUST BE IN THE /&& POSITION
&IGURE Important: Before connecting, be sure that there
is no debris caught in the head of the main LP
gas line, head of the grill LP gas line or in the
head of the burner and burner ports.
#ONNECT #3! APPROVED QUICK CONNECT ,0 GAS LINE
TO GRILL &IGURE 4EST FOR LEAKS SEE h#HECKING FOR ,EAKSv SECTION
CAUTION: Keep outdoor gas cooking
appliance area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
CAUTION: Do not obstruct the flow of
combustion and ventilation air.
CAUTION: Check and clean burner/
venturi tubes for insects and insect
nests. A clogged tube can lead to a
fire beneath the grill.
CAUTION: Attempting to light the
burner with the lid closed may cause
an explosion.
Figure 2
2
1
Disconnect LP Gas Line
,0 GAS TANK MUST BE IN THE h#,/3%$v POSITION
#ONTROL KNOB MUST BE IN THE /&& POSITION
&IGURE $ISCONNECT GRILL ,0 GAS LINE FROM GRILL &IGURE 3TORE THE ,0 GAS TANK IN A PROPER LOCATION
&IGURE A
-AKE SURE ALL LABELS PACKAGING AND PROTECTIVE
FILMS HAVE BEEN REMOVED FROM THE GRILL
2EMOVE MANUFACTURING OILS BEFORE COOKING ON THIS
grill for the first time by operating the grill for at
LEAST MINUTES ON ()'( WITH THE LID CLOSED
4HIS WILL hHEAT CLEANv THE INTERNAL PARTS AND
DISSIPATE ODORS
2
Connect LP Gas Line
/PEN LID
-AKE SURE THERE ARE NO OBSTRUCTIONS OF AIRFLOW TO
THE BURNERS 3PIDERS AND INSECTS CAN NEST WITHIN
AND CLOG THE BURNER VENTURI TUBE AT THE ORIFICE !
clogged burner tube can lead to a fire beneath the
APPLIANCE
Figure 3
CAUTION: LP gas tank must be
properly disconnected and removed
prior to moving this grill.
Match
&IGURE B
Match
&IGURE Flame
!LL CONTROL KNOBS MUST BE IN THE /&& POSITION
&IGURE #ONNECT ,0 GAS TANK PER h#ONNECT ,0 'AS ,INEv
SECTION
4URN ,0 GAS TANK VALVE TO h/0%.v
Operating Instructions
1/2"
12,7 mm
1/4"
6,4 mm
0"
0 mm
4URN THE CONTROL KNOB TO ()'(
0RESS THE )GNITER BUTTON REPEATEDLY TO LIGHT BURNER
Checking for Leaks
Burner Connections
)F IGNITION DOES NOT OCCUR IN SECONDS TURN CONTROL KNOB TO /&& WAIT MINUTES AND
REPEAT LIGHTING PROCEDURE
)F IGNITER DOES NOT LIGHT BURNER USE A LONG LIT MATCH TO LIGHT BURNER MANUALLY !CCESS THE
BURNER THROUGH THE HOLE IN BOTTOM BOWL AS INDICATED &IGURE A AND B
!FTER LIGHTING OBSERVE THE BURNER FLAME -AKE SURE ALL BURNER PORTS ARE LIT AND FLAME HEIGHT
MATCHES ILLUSTRATION &IGURE Figure 4
-AKE SURE THE REGULATOR VALVE AND HOSE
connections are securely fastened to the burner
AND THE TANK
)F YOUR UNIT WAS ASSEMBLED FOR YOU VISUALLY CHECK
THE CONNECTION BETWEEN THE BURNER VENTURI PIPE
AND ORIFICE -AKE SURE THE BURNER VENTURI PIPE FITS
OVER THE ORIFICE
Caution: If burner flame goes out during operation, immediately turn
the control knob(s) (OFF) and open lid to let the gas clear for about 5
minutes before re-lighting.
XX X
WARNING: Failure to inspect
this connection or follow these
instructions could cause a fire or an
explosion which can cause death,
serious bodily injury, or damage to
property.
Turning Off
4URN ,0 GAS TANK VALVE TO h#,/3%$v
Note: ! hPOOFv SOUND IS NORMAL AS THE LAST OF THE ,0 GAS IS BURNED
4URN CONTROL KNOB CLOCKWISE TO THE /&& POSITION &IGURE $ISCONNECT ,0 GAS LINE PER h$ISCONNECT ,0 'AS ,INEv INSTRUCTIONS
Figure 5
0LEASE REFER TO DIAGRAM FOR PROPER INSTALLATION
&IGURES AND )F THE BURNER PIPE DOES NOT REST FLUSH TO THE ORIFICE
PLEASE CONTACT FOR ASSISTANCE
Cooking
CAUTION: Do not leave grill unattended while preheating or burning off food
residue on (HIGH). If grill has not been cleaned, a grease fire can occur.
X
Tank/Gas Line Connection
WARNING: Failure to inspect
this connection or follow these
instructions could cause a fire or an
explosion which can cause death,
serious bodily injury or damage to
property.
X
X
X
X
-AKE OZ OF LEAK SOLUTION BY MIXING ONE PART
LIQUID DISHWASHING SOAP WITH THREE PARTS WATER
-AKE SURE CONTROL KNOB IS IN /&& POSITION &IGURE #ONNECT ,0 GAS TANK PER h#ONNECT ,0 'AS ,INEv SECTION
4URN ,0 GAS TANK VALVE TO h/0%.v
3POON LEAK CHECK SOLUTION AT ALL h8v LOCATIONS &IGURES AND A )F ./ BUBBLES APPEAR after one minute THE CONNECTIONS ARE SECURE 7IPE AWAY SOLUTION
AND PROCEED
B )F BUBBLES APPEAR YOU HAVE A LEAK
2EMOVE THE ,0 GAS TANK AND RECONNECT MAKING SURE THE CONNECTION IS SECURE
2ETEST WITH SOLUTION
)F YOU CONTINUE TO SEE BUBBLES AFTER SEVERAL ATTEMPTS DISCONNECT ,0 GAS TANK AND
CONTACT FOR ASSISTANCE
/PEN LID AND IGNITE BURNER PER h,IGHTING )NSTRUCTIONSv
#LOSE LID AND PREHEAT GRILL ON ()'(
7EAR PROTECTIVE GLOVES AND USE LONG HANDLE TONGS TO PLACE FOOD ONTO COOKING GRIDS ABOVE THE
LIT BURNERS
!DJUST CONTROLS TO DESIRED FLAME HEIGHT
7ITH LID OPEN OR CLOSED COOK UNTIL DESIRED INTERNAL FOOD TEMPERATURES ARE ACHIEVED
4URN GRILL /&& PER h4URNING /FFv INSTRUCTIONS
&OR MORE TIPS ON DIRECT COOKING PLEASE SEE h4IPS FOR "ETTER #OOKOUTS AND ,ONGER 'RILL ,IFEv
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
Operating Instructions (continued)
Cleaning and Care
Controlling Flare-ups
Before Each Use:
CAUTION: Putting out grease fires by closing the lid is not possible.
s $O NOT USE WATER ON A GREASE FIRE 4HIS CAN CAUSE THE GREASE TO
splatter and could result in serious burns, bodily harm or other
damage. If a grease fire develops, turn knobs (OFF) and LP gas
tank valve “CLOSED”.
s $O NOT LEAVE GRILL UNATTENDED WHILE PREHEATING OR BURNING OFF FOOD
residue on (HIGH). If grill has not been cleaned, a grease fire can
occur that may damage the product.
WARNING: When cooking, fire extinguishing materials shall be readily
accessible. In the event of an oil/grease fire, do not attempt to
extinguish with water. Use type BC dry chemical fire extinguisher or
smother with dirt, sand or baking soda.
&LAREUPS ARE A PART OF COOKING MEATS ON A GRILL AND ADDS TO THE UNIQUE FLAVOR OF GRILLING
Excessive flare-ups can over-cook your food and cause a dangerous situation for you
and your grill.
Important: %XCESSIVE FLAREUPS RESULT FROM THE BUILDUP OF GREASE IN THE BOTTOM OF YOUR GRILL
Minimize Flare-ups:
4RIM EXCESS FAT FROM MEATS PRIOR TO COOKING
#OOK HIGH FAT CONTENTS MEATS ON ,/7 SETTING OR INDIRECTLY
%NSURE THAT YOUR GRILL IS ON HARD LEVEL NONCOMBUSTIBLE SURFACE AND THE GREASE IS ALLOWED TO
DRAIN INTO GREASE CUP
Tips for Better Cookouts and Longer Grill Life
&OR GREAT RECIPES AND TIPS VISIT RECIPESUNIFLAMECOM
&OR FOOD SAFETY TIPS VISIT HTTPWWWFSISUSDAGOV&ACT?3HEETS"ARBECUE?&OOD?3AFETY
5SE THE UPPER COOKING GRID WARMING RACK FOR KEEPING COOKED FOOD WARM TOASTING BREADS OR
COOKING DELICATE FOODS IN ALUMINUM FOIL POUCHES
5SE THE SIDE BURNER OF THIS APPLIANCE LIKE A NORMAL KITCHEN RANGE FOR BOILING SAUTÏING OR
FRYING
4O KEEP FOOD FROM STICKING TO THE GRIDS SPRAY OR COAT WITH COOKING OIL BEFORE LIGHTING
4O REDUCE FLAREUP KEEP GRILL CLEAN USE LEAN CUTS OF MEAT OR TRIM FAT AND AVOID COOKING ON
VERY HIGH TEMPERATURES
0LACE DELICATE FOODS LIKE FISH AND VEGETABLES IN ALUMINUM FOIL POUCHES AND INDIRECT COOK OR
PLACE ON UPPER COOKING LEVELS WARMING RACK
WARNING: Never cover entire cooking area with aluminum foil.
4O AVOID LOSING NATURAL JUICES USE LONG HANDLED TONGS OR SPATULAS INSTEAD OF FORKS AND TURN
FOODS OVER JUST ONCE DURING COOKING
7HEN DIRECT COOKING ADJUST YOUR BURNERS TO DIFFERENT LEVELS SO FOODS CAN BE PREPARED TO
DIFFERENT INTERNAL TEMPERATURES IN THE SAME TIME FRAME
7HEN INDIRECT COOKING ROASTS AND LARGER CUTS OF MEAT PLACE MEAT ONTO A ROASTING RACK
INSIDE A HEAVY GAUGE METAL PAN 0LACE PAN OVER THE UNLIT BURNERS
4RY WATER PANS TO REDUCE FLAREUPS AND COOK JUICER MEATS "EFORE STARTING GRILL REMOVE
COOKING GRIDS AND PLACE A HEAVY DUTY SHALLOW PAN DIRECTLY ON HEAT PLATES &ILL HALF WAY WITH
WATER FRUIT JUICES OR OTHER FLAVORED LIQUIDS 2EPLACE COOKING GRIDS AND POSITION FOOD OVER THE
LOADED PAN
%NHANCE FOOD FLAVORS BY USING WOOD CHIPS IN SMOKER BOXES OR ALUMINUM FOIL POUCHES
&OLLOW THE WOOD MANUFACTURERS INSTRUCTIONS
2OTISSERIES GRILL BASKETS VERTICAL POULTRY HOLDERS AND OTHER ACCESSORIES CAN ENHANCE YOUR
EXPERIENCES REDUCE COOKING TIMES AND AID IN CLEANUP
#LEAN COOKING GRIDS AND RACKS AFTER EVERY USE WITH A QUALITY GRILL BUSH DESIGNED FOR YOUR
GRID MATERIAL 7EAR PROTECTIVE GLOVES AND GENTLY REMOVE THE BUILDUP WHILE GRIDS ARE HOT
!FTER EVERY USE ALLOW GRILL TO COOL 4HEN PROTECT CLEAN COOKING GRIDS WITH A LIGHT COAT OF
COOKING OIL EMPTY GREASE PAN WIPE OUTSIDE SURFACES WITH A SUITABLE KITCHEN CLEANER AND
PROTECT SURFACES WITH A QUALITY COVER THAT PROPERLY FITS YOUR GRILL
7ATCH BARBECUE THEMED 46 SHOWS OR PURCHASE RELATED BARBECUE COOKBOOKS TO LEARN MORE
interesting tips like –
A gas grill is ideal for reheating leftover pizza. Set burners on low and place pizza slices
directly on preheated cooking grid. Close lid and cook until cheese starts to bubble.
Cleaning and Care
CAUTION:
1. All cleaning and maintenance should be done when grill is cool and
with the fuel supply disconnected.
2. DO NOT clean any grill part in a self cleaning oven. The extreme heat
will damage the finish.
3. Do not enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This grill should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
+EEP THE GRILL AREA CLEAN AND FREE FROM ANY COMBUSTIBLE MATERIALS GASOLINE AND OTHER
FLAMMABLE VAPORS AND LIQUIDS
$O NOT OBSTRUCT THE FLOW OF THE COMBUSTION OF ,0 AND THE VENTILATION AIR
+EEP THE VENTILATION OPENINGS OF THE ,0 GAS TANK AREA FREE AND CLEAR FROM DEBRIS
6ISUALLY CHECK THE BURNER FLAMES TO MAKE SURE YOUR GRILL IS WORKING PROPERLY &IGURE 3EE SECTIONS BELOW FOR PROPER CLEANING INSTRUCTIONS
#HECK AND CLEAN THE BURNERVENTURI TUBES FOR INSECTS AND INSECT NESTS ! CLOGGED TUBE CAN
LEAD TO A FIRE BENEATH THE GRILL
Cleaning Surfaces
7IPE SURFACES CLEAN WITH MILD DISHWASHING DETERGENT OR BAKING SODA
&OR STUBBORN SURFACES USE A CITRUS BASED DEGREASER AND A NYLON SCRUBBING BRUSH
2INSE CLEAN WITH WATER
!LLOW TO AIR DRY
Cleaning Burner
4URN CONTROL KNOBS TO /&& AND ,0 GAS TANK VALVE TO h#,/3%$v
$ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
2EMOVE COOKING GRIDS AND HEAT PLATES
$ISCONNECT WIRE FROM IGNITER
2EMOVE BURNER
2EMOVE ALL FOOD RESIDUE AND DIRT ON BURNER SURFACE
#LEAN INLET OF BURNER WITH SMALL BOTTLE BRUSH OR COMPRESSED AIR
#LEAN ANY CLOGGED PORTS WITH A STIFF WIRE SUCH AS AN OPENED PAPER CLIP
)NSPECT BURNER FOR ANY DAMAGE CRACKS OR HOLES )F DAMAGE IS FOUND REPLACE WITH NEW BURNER
FROM MANUFACTURER
2EINSTALL BURNER 2ECONNECT IGNITER IF APPLICABLE WIND GUARD AND REGULATORCONTROL KNOB
2EPLACE HEAT PLATE AND COOKING GRID
#ONNECT THE ,0 GAS TANK PER h#ONNECT ,0 'AS 4ANKv INSTRUCTIONS
0REFORM LEAK TEST
Before Storing
4URN CONTROL KNOBS TO /&& AND ,0 GAS TANK VALVE TO h#,/3%$v
$ISCONNECT ,0 GAS TANK PER h$ISCONNECT ,0 'AS 4ANKv INSTRUCTIONS
#LEAN ALL SURFACES
,IGHTLY COAT THE BURNERS WITH COOKING OIL TO PREVENT EXCESS RUSTING
)F STORING THE GRILL INDOORS DISCONNECT THE ,0 TANK SEE h$ISCONNECT ,0 'AS 4ANKv SECTION AND
LEAVE THE ,0 GAS TANK /54$//23
0LACE THE PROTECTIVE CAP COVER ON THE ,0 TANK AND STORE THE TANK OUTDOORS IN A WELL VENTILATED
AREA OUT OF DIRECT SUNLIGHT
)F STORING THE GRILL OUTDOORS COVER THE GRILL WITH A GRILL COVER FOR PROTECTION FROM THE WEATHER
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com.
Product Registration
&OR FASTER WARRANTY SERVICE REGISTER YOUR PRODUCT IMMEDIATELY AT WWWBLUERHINOCOM OR CALL
Limited Warranty
"LUE 2HINO 'LOBAL 3OURCING )NC h6ENDORv WARRANTS TO THE ORIGINAL RETAIL PURCHASER OF THIS
product, and to no other person, that if this product is assembled and operated in accordance
WITH THE PRINTED INSTRUCTIONS ACCOMPANYING IT THEN FOR A PERIOD OF ONE YEAR FROM THE DATE
OF PURCHASE ALL PARTS IN SUCH PRODUCT SHALL BE FREE FROM DEFECTS IN MATERIAL AND WORKMANSHIP
6ENDOR MAY REQUIRE REASONABLE PROOF OF YOUR DATE OF PURCHASE 4HEREFORE YOU SHOULD RETAIN
YOUR SALES SLIP OR INVOICE 4HIS ,IMITED 7ARRANTY SHALL BE LIMITED TO THE REPAIR OR REPLACEMENT OF
PARTS WHICH PROVE DEFECTIVE UNDER NORMAL USE AND SERVICE AND WHICH 6ENDOR SHALL DETERMINE
IN ITS REASONABLE DISCRETION UPON EXAMINATION TO BE DEFECTIVE "EFORE RETURNING ANY PARTS YOU
SHOULD CONTACT 6ENDORS #USTOMER 3ERVICE $EPARTMENT USING THE CONTACT INFORMATION LISTED
BELOW )F 6ENDOR CONlRMS AFTER EXAMINATION A DEFECT COVERED BY THIS ,IMITED 7ARRANTY IN ANY
RETURNED PART AND IF 6ENDOR APPROVES THE CLAIM 6ENDOR WILL REPLACE SUCH DEFECTIVE PART WITHOUT
CHARGE )F YOU RETURN DEFECTIVE PARTS TRANSPORTATION CHARGES MUST BE PREPAID BY YOU 6ENDOR WILL
RETURN REPLACEMENT PARTS TO THE ORIGINAL RETAIL PURCHASER FREIGHT OR POSTAGE PREPAID
4HIS ,IMITED 7ARRANTY DOES NOT COVER ANY FAILURES OR OPERATING DIFlCULTIES DUE TO ACCIDENT
abuse, misuse, alteration, misapplication, improper installation or improper maintenance or
SERVICE BY YOU OR ANY THIRD PARTY OR FAILURE TO PERFORM NORMAL AND ROUTINE MAINTENANCE ON
THE PRODUCT AS SET OUT IN THIS OWNERS MANUAL )N ADDITION THE ,IMITED 7ARRANTY DOES NOT COVER
DAMAGE TO THE lNISH SUCH AS SCRATCHES DENTS DISCOLORATION RUST OR OTHER WEATHER DAMAGE
AFTER PURCHASE
4HIS ,IMITED 7ARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES 6ENDOR DISCLAIMS ALL WARRANTIES
FOR PRODUCTS THAT ARE PURCHASED FROM SELLERS OTHER THAN AUTHORIZED RETAILERS OR DISTRIBUTORS
INCLUDING THE WARRANTY OF MERCHANTABILITY OR THE WARRANTY OF lTNESS FOR A PARTICULAR PURPOSE
6%.$/2 !,3/ $)3#,!)-3 !.9 !.$ !,, )-0,)%$ 7!22!.4)%3 ).#,5$).' 7)4(/54
,)-)4!4)/. 4(% )-0,)%$ 7!22!.4)%3 /& -%2#(!.4!"),)49 !.$ &)4.%33 &/2 ! 0!24)#5,!2
0520/3% 6%.$/2 3(!,, (!6% ./ ,)!"),)49 4/ 052#(!3%2 /2 !.9 4()2$ 0!249 &/2 !.9
30%#)!, ).$)2%#4 05.)4)6% ).#)$%.4!, /2 #/.3%15%.4)!, $!-!'%3 6ENDOR FURTHER
DISCLAIMS ANY IMPLIED OR EXPRESS WARRANTY OF AND ASSUMES NO RESPONSIBILITY FOR DEFECTS IN
WORKMANSHIP CAUSED BY THIRD PARTIES
4HIS ,IMITED 7ARRANTY GIVES THE PURCHASER SPECIlC LEGAL RIGHTS A PURCHASER MAY HAVE OTHER
RIGHTS DEPENDING UPON WHERE HE OR SHE LIVES 3OME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR
LIMITATION OF SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW LONG A WARRANTY
LASTS SO THE ABOVE EXCLUSION AND LIMITATIONS MAY NOT APPLY TO EVERYONE
6ENDOR DOES NOT AUTHORIZE ANY PERSON OR COMPANY TO ASSUME FOR IT ANY OTHER OBLIGATION OR
LIABILITY IN CONNECTION WITH THE SALE INSTALLATION USE REMOVAL RETURN OR REPLACEMENT OF ITS
EQUIPMENT AND NO SUCH REPRESENTATIONS ARE BINDING ON 6ENDOR
Blue Rhino Global Sourcing, Inc
Winston-Salem, North Carolina USA
PAGE NO
9
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB
Troubleshooting
Problem
Burner will not light using ignitor
Possible Cause
Prevention/Cure
,0 GAS TANK VALVE IS CLOSED
-AKE SURE REGULATOR IS SECURELY ATTACHED TO THE ,0 GAS TANK TURN ,0 GAS TANK
VALVE TO h/0%.v
,0 GAS TANK IS LOW OR EMPTY
2EPLACE OR REFILL ,0 GAS TANK
,0 GAS LEAK
4URN ,0 GAS TANK VALVE TO h#,/3%$v
7AIT MINUTES FOR GAS TO CLEAR
&OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL
7IRES OR ELECTRODE COVERED WITH COOKING RESIDUE
#LEAN WIRE ANDOR ELECTRODE WITH RUBBING ALCOHOL
%LECTRODE AND BURNERS ARE WET
7IPE DRY WITH CLOTH
%LECTRODE CRACKED OR BROKEN SPARKS AT CRACK
Replace electrode
Wire loose or disconnected
2ECONNECT WIRE OR REPLACE ELECTRODEWIRE ASSEMBLY
7IRE IS SHORTING SPARKING BETWEEN IGNITOR AND ELECTRODE 2EPLACE IGNITOR WIREELECTRODE ASSEMBLY
Bad ignitor
Replace ignitor
.O GAS FLOW
#HECK IF ,0 GAS TANK IS EMPTY
! )F EMPTY REPLACE OR RElLL
" )F ,0 GAS TANK IS NOT EMPTY REFER TO h3UDDEN DROP IN GAS mOW OR REDUCED
mAME HEIGHTv
,0 GAS TANK IS LOW OR EMPTY
2EPLACE OR REFILL ,0 GAS TANK
,0 GAS LEAK
4URN ,0 GAS TANK VALVE TO h#,/3%$v
7AIT MINUTES FOR GAS TO CLEAR
&OLLOW h#HECKING FOR ,EAKSv IN THE OWNERS MANUAL
Coupling nut and regulator not fully connected
4URNING THE COUPLING NUT ABOUT ONEHALF TO THREE QUARTERS ADDITIONAL TURN UNTIL
SOLID STOP Tighten by hand only-do not use tools.
/BSTRUCTION OF GAS FLOW
#LEAR BURNER TUBES
#HECK FOR BENT OR KINKED HOSE
3PIDER WEBS OR INSECT NEST IN VENTURI
#LEAN VENTURI AND BURNER TUBE
Burner ports clogged or blocked
Clean burner ports
/UT OF GAS
2EPLACE OR REFILL ,0 GAS TANK
%XCESS FLOW SAFETY DEVICE MAY HAVE BEEN ACTIVATED
4URN CONTROL KNOBS TO /&&
7AIT SECONDS AND LIGHT GRILL
)F mAMES ARE STILL TOO LOW RESET THE EXCESSIVE mOW SAFETY DEVICE
A 4URN CONTROL KNOB /&&
B 4URN ,0 GAS TANK VALVE TO h#,/3%$v
C $ISCONNECT REGULATOR
D 4URN CONTROL KNOB TO ()'(
E 7AIT MINUTE
F 4URN CONTROL KNOB TO /&&
G 2ECONNECT REGULATOR AND LEAK CHECK CONNECTIONS
H ,IGHT GRILL PER h,IGHTING )NSTRUCTIONSv
Burner ports are clogged or blocked
Clean burner ports
.EW BURNER MAY HAVE RESIDUAL MANUFACTURING OILS
"URN GRILL FOR MINUTES ON ()'( WITH THE LID CLOSED
3PIDER WEBS OR INSECT NEST IN VENTURI
#LEAN VENTURI
&OOD RESIDUE GREASE ETC
Clean burner
0OOR ALIGNMENT OF VALVE TO BURNER VENTURI
!SSURE BURNER VENTURI IS PROPERLY ENGAGED WITH VALVE
(IGH OR GUSTING WINDS
$O NOT USE GRILL IN HIGH WINDS
,OW ON ,0 'AS
2EPLACE OR REFILL ,0 GAS TANK
%XCESS FLOW VALVE TRIPPED
2EFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED FLAME HEIGHTv
Grease buildup
2EMOVE AND CLEAN ALL GRILL PARTS PER h#LEANING AND #AREv INSTRUCTIONS IN THE
OWNERS MANUAL
%XCESS FAT IN MEAT
Trim fat from meat before grilling
%XCESSIVE COOKING TEMPERATURE
!DJUST LOWER COOKING TEMPERATURE
Persistent grease fire
Grease trapped by food buildup around burner system
4URN CONTROL KNOBS TO /&&
4URN ,0 GAS TANK VALVE TO h#,/3%$v
,EAVE LID IN CLOSED POSITION AND LET lRE BURN OUT
!FTER GRILL COOLS REMOVE AND CLEAN ALL PARTS PER h#LEANING AND #AREv
INSTRUCTIONS IN THE OWNERS MANUAL
Flashback (fire in burner tube(s))
Burner and/or burner tubes are blocked
Clean burners and/or burner tubes
The lid is stainless steel, not painted
Baked on grease buildup has turned to carbon and is flaking off, clean
THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
The lid is coated/painted
s 4HIS CAN BE FROM BAKED ON GREASE BUILDUP THAT HAS TURNED INTO CARBON AND IS
flaking off
s #LEAN THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
s !FTER CLEANING IF YOU CAN SEE STEEL PLEASE CALL #USTOMER #ARE AT
Burner will not light with match
Sudden drop in gas flow or reduced flame height
Irregular flame pattern, flame does not run the
full length of burner
Flame is yellow or orange
Flame blow out
Flare-up
Inside of lid is peeling (like paint peeling)
For more assistance please visit us online at www.bluerhino.com or call 1.800.762.1142.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
For great recipes and tips, visit recipes.uniflame.com.
PAGE NO
Outdoor LP Gas Barbecue Grill Model No. RV2301CLB