1716msds

1716msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: August 5, 2009
DATE OF ISSUE: August 7, 2009
I - Product Identification
Chisel
PRODUCT CODE: 1716
CHEMICAL FORMULATION: Water based alkaline detergent/cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 2
FLAMMABILITY: 0
REACTIVITY: 0
HAZARD RATING:
4 - Extreme;
3 - High;
2 - Moderate;
1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX
EPA 40 CFR:
OSHA
ACGIH
SUBSTANCE
%
PEL
TLV
302
355
372
CAS #
2-Butoxyethanol
25.0-30.0
50 ppm (skin)
20 ppm (skin)
N
N
Y
111-76-2
Monoethanolamine
5.0-15.0
3 ppm
3 ppm
N
N
N
141-43-5
Poly (oxyethylene) nonylphenol
1. 0-5.0
N/E
N/E
N
N
N
9016-45-9
2 mg/m3
Y
N
N
1310-73-2
Sodium Hydroxide
1. 0-5.0
2 mg/m3
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 1.05
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): <40
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble
pH: 12.75-13.75
APPEARANCE AND ODOR: Clear, slight rose colored liquid; detergent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): None
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool drums in vicinity of fire with water fog. Firefighters should be equipped with
full protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None.
PRODUCT NAME: Chisel
PRODUCT CODE: 1716
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong acids.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate to severe irritation and redness. May cause permanent damage to cornea depending on length of exposure and
concentration of product.
IF ON SKIN: Severe irritation and burns, destruction of tissue.
IF SWALLOWED: Danger-May be harmful or fatal if swallowed. Severe burns to mucous membranes.
IF INHALED: Irritation of respiratory tract, headache, dizziness.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention.
IF ON SKIN: Flush skin for 15 minutes with water while removing contaminated clothing. Obtain medical attention if irritation
persists. Launder clothing separately before re-use.
IF SWALLOWED: Contact physician or poison control center immediately. Rinse mouth with water and give affected person one to
two glasses of water. Do not induce vomiting unless instructed by a poison control center or doctor. Never give anything by mouth to
an unconscious person.
IF INHALED: Remove person to fresh air. If breathing stops, administer artificial respiration. If breathing is difficult, give oxygen.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Soak up on inert absorbent
material and place in a properly labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits
are exceeded wear a NIOSH approved respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing. Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from acids. Never add water
to this product, always add this product to water. Do not mix with other cleaning chemicals. Keep container tightly closed when not in
use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: NA1760
DOT CLASS: 8
DOT PROPER SHIPPING NAME: Compounds, cleaning liquid (sodium hydroxide)
DOT PACKING GROUP: III
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: August 5, 2009
Prepared by: Technical Dept.
DATE OF ISSUE: August 7, 2009
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement