427msds

427msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: January 25, 2006
DATE OF ISSUE: February 3, 2006
I - Product Identification
OGS (Oven, Grill & Smokehouse Cleaner)
PRODUCT CODE: 0427
CHEMICAL FORMULATION: Water based alkaline cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 2
FLAMMABILITY: 0
HAZARD RATING:
4 - Extreme;
3 - High;
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
OSHA
ACGIH
APPROX
EPA 40 CFR:
PEL
TLV
302 355 372
CAS #
%
SUBSTANCE
2-Butoxyethanol
1.00-5.00
25 ppm (skin)
25 ppm (skin)
N
N
Y
111-76-2
Potassium Hydroxide
1.00-5.00
2 mg/m3 C
2 mg/m3 C
Y
N
N
1310-58-3
Sodium Metasilicate
1.00-5.00
N/E
N/E
N
N
N
6834-92-0
Sodium Tripolyphosphate
1.00-5.00
N/E
N/E
Y
N
N
7758-29-4
Sodium Laureth Sulfate
1.00-5.00
N/E
N/E
N
N
N
9004-82-4
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY: 1.07
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): 4.2
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): ~1.00
SOLUBILITY IN WATER: Soluble
pH: 13.00-14.00
APPEARANCE AND ODOR: Clear, yellow liquid; detergent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): N/A
(TEST METHOD): N/A
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool drums in vicinity of fire with water fog. Fire fighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: OGS (Oven, Grill & Smokehouse Cleaner)
PRODUCT CODE: 0427
V - Reactivity Data
STABILITY: Stable.
INCOMPATIBILITY: Acids, aluminum, tin and zinc.
CONDITIONS TO AVOID: None.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None.
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Corrosive-Severe irritation, destruction of tissue, redness, swelling and tearing, possibly resulting in blindness.
IF ON SKIN: Severe irritation with prolonged or repeated exposure, burns and dermatitis.
IF SWALLOWED: DANGER-Harmful or fatal if swallowed. Severe burns, destruction of tissue.
IF INHALED: Irritation of respiratory tract.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Call a physician immediately and continue
flushing until medical attention is obtained.
IF ON SKIN: Flush with plenty of cool water for at least 15 minutes while removing contaminated clothing. Obtain medical attention.
Launder clothing separately before re-use.
IF SWALLOWED: Contact physician or poison control center immediately. Rinse mouth with water. Give person 1 to 2 glasses of
water, followed by citrus fruit juice. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. If breathing has stopped, administer artificial respiration. If breathing is difficult, give
oxygen. Obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and contain spill. Soak up spilled material
with inert absorbent material and place in a closed container for disposal. Flush residue away with large amounts of water.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits
are exceeded wear a NIOSH approved respirator, following manufacturer's recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Chemical goggles and/or face shield.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, emergency shower and eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry area, away from acids. Do not mix with
any other cleaning chemical. Never add water to this product; always add this product to water, slowly stirring. Rinse container before
discarding. Keep container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: Compounds, cleaning liquid (potassium hydroxide)
DOT CLASS: 8
DOT ID NUMBER: NA1760
DOT PACKING GROUP: III
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
REVISED DATE: January 25, 2006
Prepared by: Technical Dept.
DATE OF ISSUE: February 3, 2006
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement