414msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: January 15, 2004
DATE OF ISSUE: October 29, 2004
I - Product Identification
Blast
PRODUCT CODE: 0414
CHEMICAL FORMULATION: Water based degreaser.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 0
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Values reported as TWA unless noted.
APPROX
OSHA
ACGIH
EPA 40 CFR:
%
PEL
TLV
302 355 372
CAS #
Sodium Metasilicate
1.00-10.0
N/E
N/E
N
N
N
6834-92-0
Sodium Tripolyphosphate
1.00-10.0
N/E
N/E
Y
N
N
7758-29-4
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Va lue
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
SPECIFIC GRAVITY (WATER = 1): 1.078
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): 0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble
pH: 13.00
APPEARANCE AND ODOR: Clear to slightly hazy, green liquid; mild detergent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): None
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Blast
PRODUCT CODE: 0414
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong acids.
CONDITIONS TO AVOID: None.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION:
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate irritation, redness tearing.
IF ON SKIN: Mild to moderate irritation, chapping and dermatitis, with prolonged or repeated exposure.
IF SWALLOWED: Nausea, cramps, diarrhea.
IF INHALED: May cause irritation to upper respiratory tract.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention.
IF ON SKIN: Wash with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation persists,
obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Give affected person 1 to 2 glasses of water. Do not induce
vomiting. Never give anything to an unconscious person.
IF INHALED: Remove person to fresh air.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Soak up spilled material with inert
absorbent material and place in a properly marked closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH approved
respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses and/or face shield.
OTHER PROTECTIVE EQUIPMENT: None.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when not in
use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None
DOT ID NUMBER: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: January 15, 2004
Prepared by: PMR
DATE OF ISSUE: October 29, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or
third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement