M A T E R I A L ...

M A T E R I A L   ...
MATERIAL
SAFETY
DATA
SHEET
SECTION 1 - PRODUCT INFORMATION and COMPANY IDENTIFICATION
Product Name:
COBRA REVIVE
Product Use:
Liquid Detergent
Supplier:
Kemper Industries, Inc.
P.O. Box 1172
2197 Stanton Rd.
Daphne, AL 36526
In Case of Emergency
CHEMTREC
800-424-9300
HANDLING
251-626-3083
TECHNICAL 866-536-4225
SECTION 2 - COMPOSITION/INFORMATION ON INGREDIENTS
Strong Acid Solution Cleaner Proprietary
Hydrogen Chloride
CAS# 7647-01-0
SECTION 3 - HAZARDS IDENTIFICATION
Appearance:
Clear liquid
Odor:
FRESH
*** EMERGENCY OVERVIEW***
Causes eye irritation. May cause skin irritation. May cause respiratory irritation. This product is
corrosive to aluminum. Store and ship in non-aluminum container.
Health Effects Eyes:
May cause severe irritation or burns. Prolonged or repeated eye contact may
cause irreversible damage or blindness
Health Effects Skin:
Prolonged contact may cause skin irritation.
Health Effects Inhalation:
Inhalation of vapors may cause respiratory irritation.
Health Effects Ingestion:
Not Determined.
(Continued on page 2)
Page 2
SECTION 4 - FIRST AID MEASURES
Eyes:
Immediately flush eyes with water for at least 15 minutes while holding eyelids open. Call
a physician.
Skin:
For skin contact remove contaminated clothing, flush exposed area with large amounts of
water. If irritation persists, get medical attention.
Inhalation:
If symptoms are experienced, remove source of contamination or move victim to fresh air.
If symptoms persist, get medical attention. If the affected person is not breathing, apply
artificial respiration. If breathing is difficult, give oxygen. Seek medical attention.
Ingestion:
Give immediately by mouth a dilute solution of calcium lactate, USP, calcium gluconate,
or milk. Do not induce vomiting. If it occurs spontaneously, keep head below hips to
prevent breathing vomit into lungs. Do not give anything by mouth to an unconscious
person. Call physician immediately.
SECTION 5 - FIRE FIGHTING MEASURES
Flash Point:
N/A
Flammable Explosive Limits:
Lower: N/A
Extinguishing Media:
CO2
Unusual Fire and Explosion Hazards:
None Known.
Special Fire Fighting Procedures:
None Known.
Protective Clothing:
Dry Chemical
Upper:
Foam
N/A
Water Fog
Be sure to used an approved/certified respirator or equivalent.
SECTION 6 - ACCIDENTAL RELEASE MEASURES
Small Spill:
Absorb liquid on paper, vermiculite, floor absorbent or other absorbent material.
Large Spill:
Eliminate all ignition sources (flares, flames, including pilot lights, electrical sparks). Persons not
wearing protective equipment should be excluded from area of spill until clean-up has been
completed. Stop spill at source, dyke area of spill to prevent spreading, pump liquid to salvage tank.
Waste Disposal Method: Alkali solution may be use to neutralize any residue. Small spills flush down
drains with large amounts of water. Collect large spills and slowly add to a large
volume of agitated solution of soda ash and slaked lime. Deposit spills in a landfill
in accordance with local, state, and federal regulations.
(Continued on page 3)
Page 3
SECTION 7 - HANDLING AND STORAGE
Handling:
Do not take internally. Prevent eating, drinking, tobacco use and cosmetic application in
areas where there is a potential for exposure to the material. Avoid contact with eyes, skin
and clothing. Avoid inhalation of dusts or vapors. Wear appropriate chemical protective
clothing and equipment. Always wash thoroughly after handling.
Storage:
Keep from freezing. Keep container closed when not in use.
SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls:
Local exhaust ventilation recommended.
Respiratory Protection:
Where excess concentration of product is expected, a NIOSH approved air
supplied respirator is advised in absence of proper environmental control.
Eye Protection:
Splash proof goggles where possible eye contamination exists.
Skin Protection:
Wear rubber gloves that are chemically resistant to this product.
Other Protective
Clothing or Equipment: Wear boots, gloves, apron, etc. sufficient to prevent
bodily contact. Eye bath, safety shower & washing facilities should be
available.
Hygienic Practices:
Avoid contact with eyes, skin and clothing. Avoid inhalation of
contaminant. Wash thoroughly after handling. Do not eat, drink, use tobacco
products, chew gum or apply cosmetics in area where there is potential for
exposure to this material.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point:
pH:
Specific Gravity:
Freeze Point:
Vapor Pressure:
Vapor Density:
Solubility in Water:
215oF
< 2.0
1.09
0oC (32oF)
N/D
Heavier than air
Complete
(Continued on page 4)
Page 4
SECTION 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal conditions.
Incompatibility:
Strong alkalies and alkali metals.
Hazardous Decomposition: Oxides of phosphorous.
Hazardous Polymerization: Will not occur.
SECTION 11 - TOXICOLOGICAL INFORMATION
No product animal LD50 or LC50 information is available.
SKINTEX DATA: No information.
SECTION 12 - ECOLOGICAL INFORMATION
Ecotoxicity:
No data is available on finished product.
Biodegradability: This product class is readily biodegradable.
SECTION 13 - DISPOSAL CONSIDERATIONS
Disposal Method:
Dispose of in accordance with all local, state and federal regulations.
SECTION 14 - TRANSPORTATION INFORMATION
DOT Proper Shipping Name:
Not regulated by DOT.
DOT Technical Name:
N/A
DOT Hazard Class:
N/A
DOT UN/NA Number:
N/A
SECTION 15 - REGULATORY INFORMATION
All components of this product are listed on the TSCA inventory.
(Continued on page 5)
Page 5
SECTION 16 - OTHER INFORMATION
HMIS Rating:
Health: 1
Flammability: 0
Reactivity: 0
The information provided in this Material Safety Data Sheet is based on characteristics of the individual
components, and is correct to the best of our knowledge. However, the data is provided without guarantee
or representation as to the results. Since the conditions of handling, storage and disposal of this product
are beyond our control, it is the responsibility of the user both to determine safe conditions for use of this
product and to assume full responsibility for loss, injury and expense arising out of the product’s improper
use. This information relates only to the product designated herein, and does not relate to its use in
combination with any other material or in any process.
Date:
Supersedes:
10-27-10
01-28-09
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement