MATERIAL SAFETY DATA SHEET Total Solutions P.O. Box 240014 Milwaukee, WI 53224 GENERAL INFORMATION NUMBER: (414) 354-6417 CHEMTREC: (800) 424-9300 REVISION DATE: November 10, 2004 DATE OF ISSUE: December 29, 2004 I - Product Identification Car Shampoo PRODUCT CODE: 0122 CHEMICAL FORMULATION: Water based detergent. NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 0 HAZARD RATING: 4 - Extreme; 3 - High; FLAMMABILITY: 1 2 - Moderate; 1 - Slight; REACTIVITY: 0 0 - Insignificant II - Hazardous Ingredients Values reported as TWA unless noted. APPROX OSHA ACGIH EPA 40 CFR: SUBSTANCE % PEL TLV 302 355 372 CAS # Dodecylbenzene sulfonic acid 5.00-10.0 N/E N/E N N N 27176-87-0 Sodium tripolyphosphate 1.00-10.0 N/E N/E Y N N 7758-29-4 3 3 Potassium hydroxide 1.00-3.00 2 mg/m 2 mg/m Y N N 1310-58-3 Sodium Laureth Sulfate 1.00-10.0 N/E N/E N N N 9004-82-4 3 Ethanol < 2.00 1000 ppm 1900 mg/m N N N 64-17-5 Coco Diethanolamide < 2.00 N/E N/E N N N 68603-42-9 Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No 302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4). 355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355). 372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372). III - Physical Data BOILING POINT (°F): N/D SPECIFIC GRAVITY (WATER = 1): 1.04 VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): 1.00-10.0 VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): N/D SOLUBILITY IN WATER: Soluble pH: 8.5-9.5 APPEARANCE AND ODOR: Clear, amber, viscous liquid; detergent odor. IV - Fire and Explosion Hazard Data FLASH POINT (°F): > 200 (TEST METHOD): Closed cup FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/A LOWER: N/A EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical. SPECIAL FIRE FIGHTING PROCEDURES: Firefighters must be equipped with full protective gear including self-contained breathing apparatus. UNUSUAL FIRE AND EXPLOSION HAZARD: None. PRODUCT NAME: Car Shampoo PRODUCT CODE: 0122 V - Reactivity Data STABILITY: Stable INCOMPATIBILITY: Strong acids. CONDITIONS TO AVOID: None. HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon. HAZARDOUS POLYMERIZATION: Will not occur. CONDITIONS TO AVOID: None VI - Health Hazard Data ROUTES OF ENTRY INHALATION: EYE CONTACT: X SKIN CONTACT: INGESTION: X INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None. EFFECTS OF OVEREXPOSURE IF IN EYES: Mild to moderate irritation, redness. IF ON SKIN: Mild to moderate irritation with prolonged or repeated contact. IF SWALLOWED: Gastrointestinal irritation, nausea, vomiting. IF INHALED: None known under normal use. EMERGENCY AND FIRST AID PROCEDURES IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention if irritation persists. IF ON SKIN: Flush area with water. Remove contaminated clothing and launder separately before reuse. If irritation persists, obtain medical attention. IF SWALLOWED: Call physician or poison control center immediately. Rinse mouth with water. Give affected person 1 to 2 glasses of water and induce vomiting. Never give anything by mouth to an unconscious person. IF INHALED: Remove person to fresh air. VII - Spill or Leak Protection STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and contain spill. Soak up spilled material with inert absorbent material and place in a properly labeled closed container. WASTE DISPOSAL METHOD: Consult local environmental authorities. VIII - Special Protection Information RESPIRATORY PROTECTION: Use with adequate ventilation. VENTILATION LOCAL: Not required MECHANICAL: Not required PROTECTIVE GLOVES: Chemical resistant. EYE PROTECTION: Safety glasses or goggles. OTHER PROTECTIVE EQUIPMENT: None. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when not in use. OTHER PRECAUTIONS: Keep out of reach of children. IX - Transportation Information (ground transportation only) DOT PROPER SHIPPING NAME: None DOT CLASS: None DOT ID NUMBER: None DOT PACKING GROUP: None The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping name depending on packaging, product properties, & mode of shipment. If any alterat ion of packaging, product, or mode of transportation is further intended, different shipping names and labeling may apply. REVISION DATE: November 10, 2004 Prepared by: PMR DATE OF ISSUE: December 29, 2004 This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.