G6C S LCS AVKB24 3

G6C S LCS AVKB24 3
G6…C(S)(LCS) 2-way Pressure Compensated Flanged Globe Valve
Application
This valve is typically used in Large Air Handling Units on heating or cooling coils. This
valve is suitable for use in a hydronic system with variable flow.
Bronze or stainless steel trim valves can be used for steam applications, depending on
actuator and close-off combination.
Media temperature
Water
Steam
Maximum ΔP*
Water
Steam
Rangeability
iron
stainless steel
stainless steel
stainless steel
NLP (no lip packing)
ANSI 125
Class III
iron
stainless steel
stainless steel
stainless steel
NLP (no lip packing)
35 psi (241kPa)
100 psi (680kPa)
100 psi (680kPa)
150 psi (1034kPa)
@ 250°F
150 psi (1034kPa)
@ 250°F
150 psi (1034kPa)
@ 250°F
32°F to 300°F
(0°C to 149°C)
32°F to 280°F
(0°C to 138°C)
50 psi (340kPa)
50 psi (340kPa)
G6100C 98:1
G6125C 100:1
Valve weights
G665C(S)(LCS)
G680C(S)(LCS)
G6100C(S)(LCS)
G6125C(S)(LCS)
G6150C(S)(LCS)
AVK Series
2*AF
Series
Dimensions
Valve Body
G665C(S)
G680C(S)
G6100C(S)
G6125C(S)
G6150C(S)
G665LCS
G680LCS
G6100LCS
G6125LCS
G6150LCS
32°F to 350°F
(0°C to 176°C)
32°F to 338°F
(0°C to 170°C)
25 psi (172kPa)
15 psi (103kPa)
G665C 85:1
G680C 91:1
AF
G665C(S)
G680C(S)
G6100C(S)
G6125C(S)
G6150C(S)
G665LCS
G680LCS
G6100LCS
G6125LCS
G6150LCS
50 psi (340kPa)
50 psi (340kPa)
G6150C 98:1
Valve Nominal Size
Inches DN [mm]
2½”
[65]
3”
[80]
4”
[100]
5”
[125]
6”
[150]
2½”
[65]
3”
[80]
4”
[100]
5”
[125]
6”
[150]
Dimensions (Inches [mm])
A
B
9” [229]
4.75” [120]
10” [254]
5.37” [137]
13” [330]
6.87” [175]
15.75” [400]
7.87” [200]
17.75” [451]
8.50” [216]
9” [229]
4.75” [120]
10” [254]
5.37” [137]
13” [330]
6.87” [175]
15.75” [400]
7.87” [200]
17.75” [451]
8.50” [216]
57 lbs
75 lbs
127 lbs
149 lbs
197 lbs
*(50% or more open)
G6...C(S)(LCS) 2-way Flow Patterns
Flow arrow
shown on
rear of valve
Stem Up - Open A to AB
800-543-9038 USA
10
Piping
The valves should be mounted in a weather-protected area in a location that
is within the ambient limits of the actuator. Allow sufficient room for valve with
actuator and for service. Please allow 12” for complete actuator removal. The
G6/G7 preferred mounting position of the valve is with the valve stem vertical
above the valve body, for maximum life. However, the assemblies can be mounted
with valve stem vertical above the valve or up to 45 degrees in relation to the
horizontal pipe. The actuators should never be mounted underneath the valve, as
condensation can build up and result in a failure of the actuators. Do not reverse
flow direction.
866-805-7089 CANADA
203-791-8396 LATIN AMERICA
N40021 - 03/13 - Subject to change. © Belimo Aircontrols (USA), Inc.
Water
iron
bronze
stainless steel
bronze
NLP (no lip packing)
2-way Flanged
2½
3
4
5
6
2½
3
4
5
6
D166-2WF
Flow characteristic
Action
Sizes
End fitting
Materials
Body
Seat
Stem
Plug
Packing
ANSI class
Leakage
Max inlet
Steam
G6...C
G6...CS
G6...LCS
chilled or hot water,
chilled or hot water,
chilled or hot water,
60% glycol, steam
60% glycol, steam
60% glycol, steam
modified equal percentage
linear
stem up - open A to AB
2½” to 6”
125 lb. flanged
Inches
65
90
170
263
344
65
90
170
263
344
Suitable Actuators
Electronic
Spring Return
Fail-Safe
2*AF
Series
Service
Cv
NonSpring
AF
Technical Data
Type
EV Series
Valve
Nominal Size
AVKB24-3
On/Off, Floating Point, Electronic Fail-Safe, Linear, 24 V
Application
Fail-safe for On/Off and floating control types of globe valves in HVAC steam and
hydronic systems.
Actuator sizing will be dictated by the valve size selection. All valve selections should
be done in accordance with the flow parameters and system specifications. The
actuator is mounted directly to the globe valve bonnet by means of its universal clamp
and collar.
The actuator operates in response to a 24 volt signal being applied from an electronic
controller or positioner.
Operation
The actuator is not provided with and does not require any limit switches, but is
electronically protected against overload. The AVK series provides 32 mm of downward
travel and a visual indicator indicates position of the actuator. When reaching the valve
end position, the actuator automatically stops. The gears can be manually disengaged
with a button on the actuator cover.
The AVK… series actuators use a sensorless brushless DC motor. The ASIC inside
monitors and controls the actuator’s rotation and provides a digital rotation sensing
(DRS) function to prevent damage to the actuator in a stall condition. Power
consumption is reduced in holding mode.
Technical Data
Noise level
Servicing
Quality standard
Weight
Fail-Safe Indication
Green LED status indicator light sequence:
On: operation ok, no faults
Blinking: fail-safe mechanism is active
Off: fault is detected or not in operation / capacitors charging
Dimensions (Inches [mm])
10.3” [262]
5.5” [140]
2.1” [53]
† Use flexible metal conduit. Push the Listed conduit fitting device over the actuator’s cable to butt against
the enclosure. Screw in conduit connector. Jacket the actuators input wiring with Listed flexible conduit.
Properly terminate the conduit in a suitable junction box. Rated impulse Voltage 800V. Type of action 1.
Control Pollution Degree 3.
800-543-9038 USA
71
866-805-7089 CANADA
203-791-8396 LATIN AMERICA / CARIBBEAN
P10401 - 01/13 - Subject to change. © Belimo Aircontrols (USA), Inc.
Running time fail-safe
Humidity
Ambient temperature
Storage temperature
Housing
Housing material
Bridge Time
Initial Charge
Agency listings†
Add-on auxiliary switches are easily fastened directly onto the actuator body for
signaling and switching functions.
12.22” [310]
Overload protection
Electrical protection
Control
Operating Range Y
Input impedance
Feeback Output U
Stroke
Linear Force
Direction of rotation
Position indication
Manual override
Running time motor
24 VAC ± 20% 50/60 Hz
12 W
3W
21 VA (class 2 power source)
3 ft, 18 GA plenum rated cable with 1/2"
conduit connector protected NEMA 2 (IP54)
electronic throughout full stroke
actuators are double insulated
on/off, floating point
on/off, floating point
100 k  (0.1 mA), 500 , 1000  (on/off)
No Feedback
1.25" [32 mm]
450 lbf [2000 N]
reversible with switch
stroke indicator on bracket
5 mm hex crank (3/16" Allen), supplied
90 seconds (default), variable (90 to 150
seconds)
35 seconds
5 to 95% RH non condensing
-22°F to +122°F [-30°C to +50°C]
-40°F to +176°F [-40°C to +80°C]
NEMA 2, IP54, UL enclosure type 2
Aluminum die cast and plastic casing
2 second delay before fail-safe activates
5 to 20 seconds
cULus acc. to UL 60730-1A/-2-14,
CAN/CSA E60730-1:02,
CE acc. to 2004/108/EC and 2006/95/EC
<60dB(A)
maintenance free
ISO 9001
9 lbs
10.4” [264]
Power supply
Power consumption running
Power consumption holding
Transformer sizing
Electrical connection
AVKB24-3
On/Off, Floating Point, Electronic Fail-Safe, Linear, 24 V
Typical Specification
Wiring Diagrams
On/Off, floating control globe valve actuators shall be electronic and direct coupled to
the globe valve bonnet via an integrated linkage, which requires no secondary linkage
and be capable of mounting to valves 2.5” to 6” in size. Actuators must provide control
in response to a control input from an electronic controller or positioner. Actuators shall
have brushless DC motor technology and be protected from overload at all angles of
rotation. Actuators shall have reversing switch and manual override on the cover. Run
time shall be constant and independent of torque. Actuators shall be cULus listed,
have a 5-year warranty, and be manufactured under ISO 9001 International Quality
Control Standards. Actuators shall be as manufactured by Belimo.
CAUTION Equipment Damage!
2
Actuators may be connected in parallel. Power consumption and input
impedance must be observed.
8
Control signal may be pulsed from either the Hot (Source) or Common
(Sink) 24 VAC line.
For triac sink the common connection from the actuator
must be connected to the hot connection of the controller. Contact closures
A & B also can be triacs. A & B should both be closed for the triac source
and open for triac sink.
9
Actuators with plenum cable do not have numbers; use color codes instead.
188
Meets cULus or UL and CSA Standard requirements without the
need of an electrical ground connection.
WARNING
G Live Electrical Components!
During installation, testing, servicing and troubleshooting of this product, it may be
necessary to work with live electrical components. Have a qualified licensed electrician or other
individual who has been properly trained in handling live electrical components perform these
tasks. Failure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury.
24 VAC Transformer Only
Line
Volts
2
18
Blk (1) Common –
Red (2) + Hot
Wht (3) + Y1 input
P10401 - 01/13 - Subject to change. © Belimo Aircontrols (USA), Inc.
Pnk (4)
On
n/Off
18
Floating Point
800-543-9038 USA
866-805-7089 CANADA
203-791-8396 LATIN AMERICA / CARIBBEAN
72
Close-Off Pressures (psi)
G2/G3 Non-Spring Return, Spring Return, and Electronic Fail-Safe
Non-Spring Return
LV
2-way
G212(S)
G213(S)
G214(S)
G215(S)
G219(S)
G220(S)
G224(S)
G225(S)
G232(S)
G240(S)
G250(S)
SV
250
250
250
250
211
211
Spring Return
LF
G315
G320
G325
G332
G340
G350
LVK
207
207
236
159
85
210
120
250
210
250
250
211
210
140
250
250
250
250
220
140
250
236
159
85
210
120
250
250
250
250
250
250
250
250
250
250
250
250
N40021 - 03/13 - Subject to change. © Belimo Aircontrols (USA), Inc.
250
250
250
250
SVK
250
250
250
250
211
211
220
220
140
250
236
159
85
3-way Diverting
G315D
G320D
G325D
G332D
G340D
G350D
Electronic Fail-Safe
AFB
250
250
250
250
140
140
250
250
236
159
85
3-way Mixing
G314
NF
800-543-9038 USA
88
866-805-7089 CANADA
203-791-8396 LATIN AMERICA
Close-Off Pressures (psi)
G6/G7 Non-Spring Return, Spring Return, and Electronic Fail-Safe
Non-Spring Return
N40021 - 03/13 - Subject to change. © Belimo Aircontrols (USA), Inc.
EV
RV
Spring Return
AF
2-way Pressure Comp ANSI 125
G665C
G680C
G6100C
G6125C
G6150C
140
140
140
140
140
140
140
2-way Pressure Comp ANSI 125
G665CS, G665LCS
G680CS, G680LCS
G6100CS, G6100LCS
G6125CS, G6125LCS
G6150C, G6150LCS
125
125
125
125
125
125
125
2-way Pressure Comp ANSI 250
G665C-250
G680C-250
G6100C-250
G6125C-250
G6150C-250
310
310
310
310
244
310
280
2-way Pressure Comp ANSI 250
G665CS-250, G665LCS-250
G680CS-250, G680LCS-250
G6100CS-250, G6100LCS-250
G6125CS-250, G6125LCS-250
G6150CS-250, G6150LCS-250
250
250
250
250
244
250
250
3-way ANSI 125 Mixing
G765, G765S
G780, G780S
G7100, G7100S
G7125, G7125S
G7150, G7150S
3-way ANSI 250 Mixing
G765-250, G765S-250
G780-250, G780S-250
G7100-250, G7100S-250
G7125-250, G7125S-250
G7150-250, G7150S-250
3-way ANSI 125/250 Diverting
G765D, G765DS, G765DS-250
G780D, G780DS, G780DS-250
G7100D, G7100DS, G100DS-250
G7125D, G7125DS, G7125DS-250
G7150D, G7150DS, G7150DS-250
800-543-9038 USA
Electronic Fail-Safe
2*AF
AVK
140
140
110
140
140
140
140
140
125
125
125
110
125
125
125
125
125
280
185
110
310
310
310
232
150
250
185
110
250
250
250
232
150
2*GK
250
94
63
33
125
125
68
42
28
40
26
100
68
12
71
47
125
125
37
94
63
33
185
125
68
42
28
40
26
100
68
12
71
47
222
152
37
22
14
140
140
140
140
175
140
140
140
140
140
140
140
175
866-805-7089 CANADA
203-791-8396 LATIN AMERICA
89
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement