Service Bulletin
SB-6-190-B
Replaces SB-6-190-A
Patents Pending
130525 QC3 Filter and Dryer Unit
INLET AIR
DESCRIPTION
FIGURE 1
This is a point of use unit designed
to remove water, dirt, oil and
humidity.
SPECIFICATIONS:
Air Inlet:
1/2 NPT (male)
Air Outlet:
1/4 NPSM (male)
UNION
Pressure Drop:2 psi (at 30 psi
flowing 16 cfm)
Max. Pressure: 150 PSI
Max. Temp.:
150° F
Filter Size:
0.1 micron
AIR OUT
Material Safety Data Sheet MSDS-55
available upon request.
Risk of personal injury.
Risk of property damage.
Release all air pressure
before servicing.
This product is specifically designed
for compressed air service. Use with
any other fluid (liquid or gas) is a
misapplication. For example, use
with or injection of certain hazardous
gases in the system (such as oxygen
or liquid petroleum gas) could be
harmful to the unit or result in a
combustible condition that may cause
fire or explosion. Manufacturer’s
warranties are void in the event of
misapplication and manufacturer
assumes no responsibility for any
resulting loss.
DRAIN
INSTALLATION
1. A
ssemble per Figure1 and fasten
to wall.
MAINTENANCE
2. Store wrench in top as shown.
• IMPORTANT – Drain filter.
OPERATION
• Check indicator:
Blue = OK
Pink/White = Replace Cartridge
1. T
urn the regulator’s handle
clockwise to increase pressure.
2. T
o decrease pressure, turn the
handle counterclockwise.
3. R
elieve downstream pressure by
triggering spray gun or tool.
DAILY:
See Filter Cartridge Replacement,
page 2.
SERVICE PARTS
See Parts List, page 3.
Page 2
SB-6-190-B
FILTER CARTRIDGE REPLACEMENT
!
WARNING
RISK OF INJURY – RELEASE ALL AIR PRESSURE BEFORE SERVICING.
1. Shut-off air.
2. Release pressure.
3. Loosen 4 screws (3 turns each).
3 turns
4 screws
2
1
4. Remove bowl.
5. Remove cartridge & gasket.
6. Replace indicator – remove nut.
2
1
3
2
1
7. Replace indicator...
8. Install new window & paper.
9. Tighten nut gently.
DO NOT OVER-TIGHTEN
...remove paper & window...
...dispose of old parts.
10. Install new cartridge & gasket.
1
2
DO NOT
OVER-TIGHTEN
11. Install bowl.
12. Tighten screws tight.
gasket
1
2
4 screws
The used cartridge is non-hazardous and can be disposed of according to local regulations.
NOTE
Risk of damage.
Do not clean indicator window with solvent.
Replace if damaged or dirty.
Window is included with replacement cartridge.
Page 3
SB-6-190-B
Parts List
Ref.
No.
Order
No.
Part No.
Individual
Parts Req.
Ref.
No.
1
130100
HAR-520
2
802188
VA-595
3
192314
4
130524
5
*
*
Order
No.
Regulator
1
6
*
*
Shut-Off Valve
1
7
802112
KK-5088
GA-375
1
8
*
*
130524
Cartridge, Dryer Filter**
1
9
803094
HAF-45
Socket Head Screw,
1/4-20 x 3/4
4
Part No.
Individual
Parts Req.
Description
Wingnut, 1/4-20
1
Regulator Repair Kit
1
5mm Hex Key Wrench
1
Gasket, Filter Bowl
1
*Purchase locally
**Cartridge includes gasket, indicator window & humidity paper
FIGURE 2
2
1
8
9
4
3
7
6
1
5
7
Página 4
SB-6-190-B
SB-6-190-B
AIRE DE ENTRADA
FIGURA 1
ESPECIFICACIONES:
Entrada de aire:1/2” NPT
(macho)
UNIÓN
SALIDA
DE AIRE
INSTALACIÓN
MANTENIMIENTO
DIARIO:
PIEZAS DE SERVICIO
• IMPORTANTE – Drenar el filtro.
Página 5
SB-6-190-B
REEMPLAZO DEL CARTUCHO DEL FILTRO DESECANTE
!
ADVERTENCIA
RIESGO DE LESIÓN – LIBERE TODA LA PRESIÓN DE AIRE ANTES DE DARLE SERVICIO.
3.
3 vueltas
4 tornillos
2
1
4. Quite la cubeta.
6.
2
1
3
2
1
NO APRIENTE DEMASIADO
1
2
NO APRIENTE
DEMASIADO
11. Instale la cubeta.
1
empaquetadura
2
4 tornillos
Página 6
SB-6-190-B
No. de
Ref.
Regulador
1
6
*
*
1
7
802112
KK-5088
GA-375
1
8
*
*
130524
1
9
803094
HAF-45
*
4
No. de
Ref.
No. de
Orden
No. De
Pieza
1
130100
HAR-520
2
802188
VA-595
3
192314
4
130524
5
*
No. de
Orden
No. De
Pieza
1
1
1
1
2
1
8
9
4
3
7
6
1
5
7
Page 7
SB-6-190-B
Bulletin de service
SB-6-190-B
Remplace SB-6-190-A
Brevets en instance
DESCRIPTION
FIGURE 1
UNION
SORTIE
D’AIR
INSTALLATION
TOUS LES JOURS :
MODE D’EMPLOI
• IMPORTANT – Vidanger le filtre.
PIÈCES DE RECHANGE
Page 8
SB-6-190-B
!
AVERTISSEMENT
RISQUE DE BLESSURES – RELÂCHER COMPLÈTEMENT LA PRESSION D'AIR AVANT D'EFFECTUER TOUT ENTRETIEN.
2. Relâcher la pression.
2
1
2
1
3
2
1
1
2
NE PAS TROP
SERRER
1
2
4 vis
Page 9
SB-6-190-B
1
6
*
*
1
7
802112
KK-5088
GA-375
1
8
*
*
130524
1
9
803094
HAF-45
4
No de
commande
1
130100
HAR-520
2
802188
VA-595
3
192314
4
130524
5
*
*
No de
commande
1
1
1
1
2
1
8
9
4
3
7
6
1
5
7
Page 10
SB-6-190-B
NOTES / NOTAS
Page 11
NOTES / NOTAS
SB-6-190-B
Page 12
SB-6-190-B
WARRANTY
This product is covered by DeVilbiss’ 1 Year Limited Warranty.
DeVilbiss Worldwide Sales and Service Listing: www.autorefinishdevilbiss.com
DeVilbiss Automotive Refinishing
DeVilbiss has authorized distributors throughout the world.
For equipment, parts and service, check the Yellow Pages
under “Automotive Body Shop Equipment and Supplies.”
For technical assistance, see listing below.
U.S./Canada Customer Service Office:
1724 Indian Wood Circle, Suite J-K, Maumee, OH 43537
Toll-Free Telephone: 1-800-445-3988 (U.S.A. and Canada only)
Toll-Free Fax: 1-800-445-6643
8/08 ©2008 Illinois Tool Works Inc. All rights reserved. Printed in U.S.A.">
