Cushman Hauler 800X Electric manual
advertisement
OWNER’S GUIDE
642988-B
HAULER 800XE
REVISED FEBRUARY 2016ISSUED FEBRUARY 2015
642988-B
HAULER 800XE
REVISED FEBRUARY 2016ISSUED FEBRUARY 2015
WELCOME
Thank you for purchasing this vehicle. Before you drive the vehicle, read this Owner’s Guide. This guide contains mainte-
nance and operation information. The illustrations can show items that are optional for your vehicle.
You can do most of the service procedures in this guide with common, automotive hand tools. If necessary, contact your
service representative for information about how to service the vehicle as shown in the Periodic Service Schedule.
Repair or replacement parts are available from your E-Z-GO dealer or E-Z-GO Service Parts Department.
When you contact E-Z-GO about service or parts for your vehicle, the information below is needed.
Vehicle Model: ___________________________________________________________
PIN, VIN or Serial Number: _________________________________________________
Thank you for purchasing this vehicle. Before you drive the vehicle, read this Owner’s Guide. This guide contains mainte-
nance and operation information. The illustrations can show items that are optional for your vehicle.
You can do most of the service procedures in this guide with common, automotive hand tools. If necessary, contact your
service representative for information about how to service the vehicle as shown in the Periodic Service Schedule.
Repair or replacement parts are available from your E-Z-GO dealer or E-Z-GO Service Parts Department.
When you contact E-Z-GO about service or parts for your vehicle, the information below is needed.
Vehicle Model: ___________________________________________________________
PIN, VIN or Serial Number: _________________________________________________
Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability or increase the speed
beyond the factory specifications. Such modifications can cause serious personal injury or death. E-Z-GO Division of Textron Inc. prohib-
its and disclaims responsibility for any such modifications or any other alteration which would adversely affect the safety of the vehicle.
E-Z-GO Division of Textron Inc. reserves the right to incorporate engineering and design changes to products in this manual, without obli-
gation to include these changes on units sold previously.
The information contained in this manual may be revised periodically by E-Z-GO, and therefore is subject to change without notice.
E-Z-GO DISCLAIMS LIABILITY FOR ERRORS IN THIS MANUAL, and SPECIFICALLY DISCLAIMS LIABILITY FOR INCIDENTAL AND CONSE-
QUENTIAL DAMAGES resulting from the use of the information and materials in this Manual.
These are the original instructions as defined by 2006/42/EC.
CONTACT US:
E-Z-GO Division of Textron Inc.
1451 Marvin Griffin Road.
Augusta, Georgia, USA 30906-3852
North America:
Technical Assistance & Warranty PHONE: 1-800-774-3946 FAX: 1-800-448-8124
Service Parts PHONE: 1-888-GET-EZGO (1-888-438-3946) FAX: 1-800-752-6175
International:
PHONE: 001-706-798-4311 FAX: 001-706-771-4609
i
OWNER’S GUIDE
ELECTRIC POWERED VEHICLE
HAULER 800XE
STARTING MODEL YEAR 2015
CALIFORNIA Proposition 65 Warning
WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known
to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids con-
tained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to
cause cancer and birth defects or other reproductive harm.
beyond the factory specifications. Such modifications can cause serious personal injury or death. E-Z-GO Division of Textron Inc. prohib-
its and disclaims responsibility for any such modifications or any other alteration which would adversely affect the safety of the vehicle.
E-Z-GO Division of Textron Inc. reserves the right to incorporate engineering and design changes to products in this manual, without obli-
gation to include these changes on units sold previously.
The information contained in this manual may be revised periodically by E-Z-GO, and therefore is subject to change without notice.
E-Z-GO DISCLAIMS LIABILITY FOR ERRORS IN THIS MANUAL, and SPECIFICALLY DISCLAIMS LIABILITY FOR INCIDENTAL AND CONSE-
QUENTIAL DAMAGES resulting from the use of the information and materials in this Manual.
These are the original instructions as defined by 2006/42/EC.
CONTACT US:
E-Z-GO Division of Textron Inc.
1451 Marvin Griffin Road.
Augusta, Georgia, USA 30906-3852
North America:
Technical Assistance & Warranty PHONE: 1-800-774-3946 FAX: 1-800-448-8124
Service Parts PHONE: 1-888-GET-EZGO (1-888-438-3946) FAX: 1-800-752-6175
International:
PHONE: 001-706-798-4311 FAX: 001-706-771-4609
i
OWNER’S GUIDE
ELECTRIC POWERED VEHICLE
HAULER 800XE
STARTING MODEL YEAR 2015
CALIFORNIA Proposition 65 Warning
WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known
to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids con-
tained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to
cause cancer and birth defects or other reproductive harm.
FORWARD
ii Owner’s Guide
This vehicle was designed and manufactured in the United States of America (USA). The
Standards and Specifications listed in the following text originate in the USA unless other-
wise indicated.
Use Original Equipment Manufacturer (OEM) approved parts to keep the warranty effective.
If you do not correctly do maintenance on the batteries, you will cancel the warranty. Refer
to the MAINTENANCE section for instructions on the correct maintenance of the batteries.
BATTERY PROLONGED STORAGE
The batteries discharge over time. The rate of discharge changes according to the ambient
temperature, the age and condition of the batteries.
Completely charged batteries will not freeze in winter temperatures unless the temperature
is less than -75°F (- 60°C).
For winter storage, the batteries must be clean, completely charged and disconnected from
any electrical drain.
The battery charger can stay connected to the vehicle to keep a full charge on the batteries
while the charger is connected to an active electrical supply. If the power to the electrical
supply is disconnected or interrupted, the battery charger will continuously check the
charge on the battery pack. A continuous check of the battery pack will pull power from the
battery pack and drain the batteries.
The batteries must be checked and charged again as required or at a minimum of 30-day
intervals.
Check and keep correct fluid level in all battery cells during the storage period. Correct fluid
level is necessary for maximum battery performance.
BATTERY DISPOSAL
Lead-acid batteries are recyclable. Return discarded batteries to distributor, manufacturer
or lead smelter for recycling. For neutralized spills, put residue in acid-resistant containers
with absorbent material, sand or earth and discard according to local, state and federal reg-
ulations for acid and lead compounds. Contact local or state environmental authorized peo-
ple for the disposal information.
ii Owner’s Guide
This vehicle was designed and manufactured in the United States of America (USA). The
Standards and Specifications listed in the following text originate in the USA unless other-
wise indicated.
Use Original Equipment Manufacturer (OEM) approved parts to keep the warranty effective.
If you do not correctly do maintenance on the batteries, you will cancel the warranty. Refer
to the MAINTENANCE section for instructions on the correct maintenance of the batteries.
BATTERY PROLONGED STORAGE
The batteries discharge over time. The rate of discharge changes according to the ambient
temperature, the age and condition of the batteries.
Completely charged batteries will not freeze in winter temperatures unless the temperature
is less than -75°F (- 60°C).
For winter storage, the batteries must be clean, completely charged and disconnected from
any electrical drain.
The battery charger can stay connected to the vehicle to keep a full charge on the batteries
while the charger is connected to an active electrical supply. If the power to the electrical
supply is disconnected or interrupted, the battery charger will continuously check the
charge on the battery pack. A continuous check of the battery pack will pull power from the
battery pack and drain the batteries.
The batteries must be checked and charged again as required or at a minimum of 30-day
intervals.
Check and keep correct fluid level in all battery cells during the storage period. Correct fluid
level is necessary for maximum battery performance.
BATTERY DISPOSAL
Lead-acid batteries are recyclable. Return discarded batteries to distributor, manufacturer
or lead smelter for recycling. For neutralized spills, put residue in acid-resistant containers
with absorbent material, sand or earth and discard according to local, state and federal reg-
ulations for acid and lead compounds. Contact local or state environmental authorized peo-
ple for the disposal information.
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
advertisement
Related manuals
advertisement