Warnings. Graco 3A1320K, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, 3A1320H, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, ThermoLazer 300TC, ThermoLazer 200TC, 3A1320J, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, 3A1320L, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair

Add to My manuals
48 Pages

advertisement

Warnings. Graco 3A1320K, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, 3A1320H, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, ThermoLazer 300TC, ThermoLazer 200TC, 3A1320J, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair, 3A1320L, ThermoLazer 200/200TC/300TC and Thermolazer ProMelt Pavement Marking Systems, Repair | Manualzz

4

Warnings

Warnings

The following warnings are for the setup, use, grounding, maintenance, and repair of this equipment. The exclamation point symbol alerts you to a general warning and the hazard symbols refer to procedure-specific risks. When these symbols appear in the body of this manual or on warning labels, refer back to these Warnings. Product-specific hazard symbols and warnings not covered in this section may appear throughout the body of this manual where applicable.

WARNING

FIRE AND EXPLOSION HAZARD

Flammable fumes and liquids, such as propane gas, gasoline and combustible fuel, in work area can ignite or explode. To help prevent fire and explosion:

• Do not use equipment unless fully trained and qualified.

• Do not allow open containers of flammables within 25 ft (7.6 m) of equipment. Do not operate equipment within 10 ft (3 m) of any structure, combustible material, or other gas cylinders.

• Shut off all burners when adding fuel to equipment.

• Close the tank shut-off valve immediately if you smell propane gas; extinguish all open flames. If gas odor continues, keep away from equipment and immediately call the fire department.

• Follow lighting instructions for the burner and torch.

• Do not heat thermoplastic traffic marking compound material above its maximum temperature rating.

• Fire extinguisher equipment shall be present and working.

• Keep work area free of debris, including solvent, rags and gasoline.

EQUIPMENT MISUSE HAZARD

Misuse can cause death or serious injury.

• Do not leave equipment unattended.

• Keep children and animals away from work area.

• Do not exceed the maximum working pressure or temperature rating of the lowest rated system component. See Technical Data in all equipment manuals.

• Check equipment daily. Repair or replace worn or damaged parts immediately with genuine manufacturer’s replacement parts only.

• Do not alter or modify equipment.

• Use equipment only for its intended purpose. Call your Graco distributor for information.

• Do not fill material beyond maximum capacity.

• Route gas lines, hoses, wires and cables away from traffic areas, sharp edges, moving parts, and hot surfaces.

• Do not kink or overbend gas lines.

• Do not override or defeat safety devices.

• Do not operate the unit when fatigued or under the influence of drugs or alcohol.

BURN HAZARD

Equipment surfaces and fluid that is heated can become very hot during operation. To avoid severe burns:

• Do not touch hot fluid or equipment.

CARBON MONOXIDE HAZARD

Exhaust contains poisonous carbon monoxide, which is colorless and odorless. Breathing carbon monoxide can cause death. Do not operate in an enclosed area.

TOXIC FLUID OR FUMES HAZARD

Toxic fluids or fumes can cause serious injury or death if splashed in the eyes or on skin, inhaled, or swallowed.

• Read MSDS to know the specific hazards of the materials you are using.

3A1320K

3A1320K

Warnings

WARNING

PERSONAL PROTECTIVE EQUIPMENT

Wear appropriate protective equipment when in the work area to help prevent serious injury, including eye injury, hearing loss, inhalation of toxic fumes, and burns. This protective equipment includes but is not limited to:

• Clothing and respirator as recommended by the fluid, material, and solvent manufacturer.

• Gloves, shoes, overalls, face shield, hat, etc. rated for elevated temperatures of at least 500° F

(260° C).

CALIFORNIA PROPOSITION 65

Exhaust from this product contains a chemical known to the State of California to cause cancer, birth defects or other reproductive harm.

This product contains a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. Wash hands after handling.

5

advertisement

Related manuals