Swisher 10272 ATV and UTV Accessory Owner Manual

swisherinc.com
OWNER’S
MANUAL
10272
ATV Spreader
Starting Serial #: L208-086001
CHANGING YOUR LANDSCAPE SINCE 1945
IMPORTANT
Read and follow all
Safety Precautions
and Instructions
Before Operating this
Equipment.
SWISHER
1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093
PHONE 660-747-8183 FAX 660-747-8650
Made In The
USA
of US and Global Parts
10791 Rev 08-086
LIMITED WARRANTY
The manufacturer’s warranty to the original consumer purchaser is: This product is free from defects
in materials and workmanship for a period of one (1) year from the date of purchase by the original
consumer purchaser. We will repair or replace, at our discretion, parts found to be defective due to
materials or workmanship. This warranty is subject to the following limitations and exclusions:
1)
Commercial Use
2)
Limitation
3)
Exclusions
This product is not intended for commercial use and carries no
commercial warranty.
This warranty applies only to products which have been properly
assembled, adjusted, and operated in accordance with the instructions
contained within this manual. This warranty does not apply to any
product of Swisher that has been subject to alteration, misuse, abuse,
improper assembly or installation, shipping damage, or to normal
wear of product.
Excluded from this warranty are normal wear, normal adjustments, and
normal maintenance.
In the event you have a claim under this warranty, you must return the product to an authorized
service dealer. All transportation charges, damage, or loss incurred during transportation of parts
submitted for replacement or repair under this warranty shall be borne by the purchaser. Should you
have any questions concerning this warranty, please contact us toll-free at 1-800-222-8183. The
model number, serial number, date of purchase, and the name of the authorized Swisher dealer from
whom you purchased the product will be needed before any warranty claim can be processed.
THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME
PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not
allow the limitation of consequential damages or limitations on how long an implied warranty may
last, so the above limitations or exclusions may not apply to you. This warranty gives you specific
legal rights and you may have other rights, which vary from state-to-state. This is a limited warranty
as defined by the Magnuson-Moss Act of 1975.
2
SAFETY PRECAUTIONS
This Safety Alert Symbol indicates important messages in this
manual. When you see this symbol, carefully read the message that
follows and be alert to the possibility of personal injury.
Read this manual completely. Failure to observe the following safety instructions
could result in serious injury or death.
•
Read the manual. Learn to operate the machine safely.
•
Keep the operating speed low!
•
Allow only responsible adults who are familiar with these instructions to operate
this machine. Never allow children to operate this machine.
•
Be sure the area is clear of other people before operating. Children are often
attracted to the machine and the operating activity. Never assume that children
will remain where you last saw them. Keep children under the watchful care of
another responsible adult.
•
Watch for traffic when operating near or while crossing roadways.
•
Do not operate the attachment if it has been dropped or damaged in any manner.
Repair as necessary.
•
Stop and inspect the equipment if you strike an object. Repair as necessary before
restarting.
•
Dress properly. Do not operate when barefoot or wearing open sandals.
•
Do not operate the machine while under the influence of alcohol or drugs.
•
Never tamper with safety devices. Check their proper operation regularly.
•
Operate attachments up and down slopes. There is a significant risk of overturns
when operating across slopes.
•
Never make adjustments or repairs with the vehicle engine running.
•
Follow the vehicle manufacturers safe operating procedures.
3
Item Number Part Number
1
10113
2
NB505
3
NB556
4
NB579
5
7825Z
6
10051
7
NB555
8
10112TK
9
10111TK
10
10110
11
NB181
24
10192
4
Description
Deflector - Spreader
5/16-18 x 1 1/2 HCC GR5
5/16 USS Flat Washer
5/16 x 1 1/4" OD Fender Washer
Lift Bar Bushing
Gate Spring
1/2" USS Flat Washer ZP
Hopper Gate
Motor Support Bracket - Upper
Tank - Spreader
5/16-18 Nyloc Nut
5/16" Nylon Retainer Washer
Item Number Part Number
9
10111TK
12
10114TK
13
10197
14
10117TK
15
3844
16
15118
17
10118
29
12564
30
N/A
Description
Motor Support Bracket - Upper
Motor Support Bracket - Lower
5/16-18 x 1 Carriage Bolt
Spreader Shield
T-Knob; 5/16-18
12 Volt Spreader Motor
Spinner/Distributor - Spreader
Nut - Nyloc, 10-32 ZP
Snap Ring (Included with Motor)
5
Item Number Part Number
3
NB556
4
NB579
11
NB181
18
10107TK
19
10106TK
20
NB501
26
AS021
27
10176
28
10105
Description
5/16 USS Flat Washer
5/16 x 1 1/4" OD Fender Washer
5/16-18 Nyloc Nut
Tank Support Tube Weldment - Right
Tank Support Tube Weldment - Left
5/16-18 x 1 HCC GR5 ZP
Cable Tie - Black 5 1/2"
Lid - Tank
Plug - 1 1/4 Cap, Square
Step 5:
Attach the Support Tube
Weldments (18 &19) to the
Tank by inserting the bolts (20)
through the washers (3) and
Weldment, and into the holes on
The side of the tank as shown.
Place a washer (4) over each bolt
on the inside of the tank and thread
the nuts (11) onto the bolts and
tighten securely.
6
Item Number Part Number
11
NB181
22
10109
25
N/A
Description
5/16-18 Nyloc Nut
5/16 X 1 3/8" X 3 11/16" U-Bolt
Existing Rack on ATV
Part Number 10179TK
7
Power Hook-Up:
After assembling the Spreader, you must hook up the 12 Volt Spreader
Motor. To do this you must first route the wires coming out of the male
end of the 12 Volt Power Source through your ATV and back to the
rear of your ATV. Be sure to allow enough wire to be able to plug and
unplug the power source from the rear of your ATV. Next, tie the
wires from the motor through the holes located on the bottom of the
Spreader Shield using the supplied zip tie (26). Connect these wires
to the ones coming from the 12 Volt Power Supply.*
To operate, simply plug in the 12 Volt Power Supply and begin using
your Swisher spreader.
*Note: When hooking up the electrical, test the rotation of the motor
shaft. Looking down on the motor shaft, the shaft should rotate
clockwise. If the direction is counterclockwise, switch the wires
coming out of the motor that plug into the 12 Volt Power Source.
8
9
NOTES:
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
10
NOTES:
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
______________________________________________________________________
11
swisherinc.com
OWNER’S
MANUAL
10272
ATV Spreader
WHEN ORDERING PARTS, PLEASE HAVE THE
FOLLOWING INFORMATION AVAILABLE:
* PRODUCT – ________________
* SERIAL NUMBER - _______________
* MODEL NUMBER - _______________
TYPE - _______________
* PART NUMBER WITH PAINT CODE
* PART DESCRIPTION
TELEPHONE - 1-800-222-8183
FAX - 1-660-747-8650
SWISHER
1602 CORPORATE DRIVE
WARRENSBURG, MO 64093
swisherinc.com
SWISHER
1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093
PHONE 660-747-8183 FAX 660-747-8650
Made In The
USA
of US and Global Parts